I GOT IN MY VAN TO DRIVE TO A STORE AND THE BRAKE PEDAL WENT RIGHT TO THE FLOOR. THERE WAS BRAKE FLUID LEAKING FROM NEAR THE REAR TIRE. THE STEEL HARD BRAKE LINE RUNNING FROM THE ABS UNIT TO THE REAR AXLE IS RUSTED THROUGH AND IS LEAKING. THIS WAS A SUDDEN EVENT. ALSO THE FUEL LINES LOOK TO BE JUST AS BAD. I'M SURE STAINLESS ST…
Read full complaint
I GOT IN MY VAN TO DRIVE TO A STORE AND THE BRAKE PEDAL WENT RIGHT TO THE FLOOR. THERE WAS BRAKE FLUID LEAKING FROM NEAR THE REAR TIRE. THE STEEL HARD BRAKE LINE RUNNING FROM THE ABS UNIT TO THE REAR AXLE IS RUSTED THROUGH AND IS LEAKING. THIS WAS A SUDDEN EVENT. ALSO THE FUEL LINES LOOK TO BE JUST AS BAD. I'M SURE STAINLESS STEEL LINES WOULD NOT HAVE ADDED MUCH TO THE VEHICLES COST AND WOULD HAVE PREVENTED THIS HAZARD AND EXPENSE. *TR
NHTSA ODI #10706501
120,000 miles · Oct 7, 2013
Electrical SystemService Brakes
VEHICLE LOST ALL ELECTRICAL POWER TO EVERY SYSTEM THAT IS CONTROLLED BY THE IGNITION BEING TURNED ON. DRIVER WAS IN THE PROCESS OF MAKING A U-TURN AROUND A CURBING ISLAND IN THE DIVIDED TRAFFIC ROAD WHEN ALL ELECTRICAL WAS INTERRUPTED WHILE THE STEERING WHEEL WAS TURNED ALL THE WAY TO THE LEFT. CONDITION CAUSED STEERING TO BECOM…
Read full complaint
VEHICLE LOST ALL ELECTRICAL POWER TO EVERY SYSTEM THAT IS CONTROLLED BY THE IGNITION BEING TURNED ON. DRIVER WAS IN THE PROCESS OF MAKING A U-TURN AROUND A CURBING ISLAND IN THE DIVIDED TRAFFIC ROAD WHEN ALL ELECTRICAL WAS INTERRUPTED WHILE THE STEERING WHEEL WAS TURNED ALL THE WAY TO THE LEFT. CONDITION CAUSED STEERING TO BECOME DIFFICULT, BRAKE PEDAL WENT CLEAR TO THE FLOOR, AIR CONDITIONING AND RADIO AND HEADLIGHTS ALL WENT OFF. CONDITION WAS REPEATABLE WITH EXCEPTION OF BRAKE PEDAL, EACH TIME STEERING WAS TURNED TO THE LEFT. INSPECTION UNDER VEHICLE FOUND THAT MAIN POWER CABLE IS ROUTED ACROSS FRONT SIDE OF MAIN FRAME MOTOR MOUNT MEMBER. THERE WAS A SLIGHT CURVE IN THE WAY THE WIRE WAS ROUTED AND EACH TIME THE STEERING WAS TURNED TO THE LEFT, THE INNER TIE ROD END FOR THE RIGHT WHEEL CAME IN CONTACT WITH THE WIRE HARNESS. AFTER MANY MILES, THE PROTECTIVE COVER AND THEN THE ACTUAL WIRE INSULATION WAS RUBBED THROUGH. THIS CAUSED A DIRECT SHORT TO GROUND THROUGH THE STEERING PARTS OF ALL (SWITCHED WHILE RUNNING) ELECTRICAL COMPONENTS OF THE VEHICLE. PROBLEM WAS CORRECTED BY TAPING THE WIRE INSULATION, THEN TAPING THE PROTECTIVE COVERING. I THEN HAD TO FABRICATE A BRACKET TO SCREW TO THE STEEL CRUMPLE MEMBER TO HOLD THE HARNESS BACK FROM THE STEERING LINKAGE. *TR
NHTSA ODI #10546973
79,000 miles · Jul 28, 2012
Service Brakes
ABS WAS ACTIVATED AT SLOW SPEEDS CAUSING A SUBSTANTIAL DROP IN BRAKING POWER. *TR
ON CERTAIN MINIVANS, THE MULTIFUNCTION SWITCH MAY DEVELOP AN OPEN CIRCUIT CONDITION IN THE STOP LAMP OR HAZARD LAMP CIRCUIT THAT RESULTS IN THE STOP LAMPS AND HAZARD LAMPS BEING INOPERATIVE.
Consequence & remedy
Consequence: THE LOSS OF STOP LAMPS AND REAR HAZARD LAMPS COULD FAIL TO WARN A FOLLOWING DRIVER THAT THE VEHICLE IS BRAKING AND/OR IS STOPPED AND COULD LEAD TO A VEHICLE CRASH.
Remedy: DEALERS WILL REPLACE THE HAZARD WARNING FLASHER SWITCH AND APPLY SPECIAL GREASE TO THE CONTACTS AT THE TIME OF INSTALLATION OF THE MODULE FREE OF CHARGE. THE REPAIR WOULD BE USED IN VEHICLES IN WHICH THE HAZARD SLIDER BUTTON IS STILL MOVABLE. IF A VEHICLE HAS A HAZARD SLIDER BUTTON THAT IS NOT MOVABLE (FROZEN), THE ENTIRE MULTIFUNCTION SWITCH WILL BE REPLACED. THE RECALL BEGAN ON APRIL 13, 2005. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 OR GMC AT 1-866-996-9463.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
IN ITS LETTER DATED MARCH 9, 2005, GM STATED THAT IT WOULD CONDUCT A SAFETY RECALL TO REMEDY A FAULTY MULTIFUNCTION SWITCH IN CERTAIN MODEL YEAR (MY) 2001 AND 2002 CHEVROLET ASTRO AND GMC SAFARI VEHICLES; SPECIFICALLY, ALL MY 2001 VEHICLES AND EARLY MY 2002 VEHICLES BUILT BETWEEN MARCH AND AUGUST 2001.SEE NHTSA RECALL NO. 05V-099 FOR DETAILS.THE MULTIFUNCTION SWITCH MAY DEVELOP AN OPEN CIRCUIT IN THE BRAKE LAMP OR HAZARD LAMP CIRCUIT RESULTING IN INOPERATIVE BRAKE LAMPS AND HAZARD LAMPS.THIS IS DUE TO THE COMBINED EFFECTS OF THE MATERIAL AND LUBRICATION FOR THE HAZARD SWITCH CONTACTOR THAT RESULT IN INCREASED RESISTANCE IN THE HAZARD SWITCH AND STUCK HAZARD SLIDER BUTTON IN OPEN (NO CONTACT) CONDITION.DEALERS ARE TO REPLACE THE HAZARD SWITCH AND APPLY SPECIAL GREASE TO THE HAZARD SWITCH CONTACTOR.IF A VEHICLE HAS A STUCK HAZARD SLIDER BUTTON, DEALERS ARE TO REPLACE THE ENTIRE MULTIFUNCTION SWITCH.
Additional source detail variants (2)
Exterior Lighting:brake Lights
IN ITS LETTER DATED MARCH 9, 2005, GM STATED THAT IT WOULD CONDUCT A SAFETY RECALL TO REMEDY A FAULTY MULTIFUNCTION SWITCH IN CERTAIN MODEL YEAR (MY) 2001 AND 2002 CHEVROLET ASTRO AND GMC SAFARI VEHICLES; SPECIFICALLY, ALL MY 2001 VEHICLES AND EARLY MY 2002 VEHICLES BUILT BETWEEN MARCH AND AUGUST 2001.SEE NHTSA RECALL NO. 05V-099 FOR DETAILS.THE MULTIFUNCTION SWITCH MAY DEVELOP AN OPEN CIRCUIT IN THE BRAKE LAMP OR HAZARD LAMP CIRCUIT RESULTING IN INOPERATIVE BRAKE LAMPS AND HAZARD LAMPS.THIS IS DUE TO THE COMBINED EFFECTS OF THE MATERIAL AND LUBRICATION FOR THE HAZARD SWITCH CONTACTOR THAT RESULT IN INCREASED RESISTANCE IN THE HAZARD SWITCH AND STUCK HAZARD SLIDER BUTTON IN OPEN (NO CONTACT) CONDITION.DEALERS ARE TO REPLACE THE HAZARD SWITCH AND APPLY SPECIAL GREASE TO THE HAZARD SWITCH CONTACTOR.IF A VEHICLE HAS A STUCK HAZARD SLIDER BUTTON, DEALERS ARE TO REPLACE THE ENTIRE MULTIFUNCTION SWITCH.
Exterior Lighting:hazard Flashing Warning Lights
IN ITS LETTER DATED MARCH 9, 2005, GM STATED THAT IT WOULD CONDUCT A SAFETY RECALL TO REMEDY A FAULTY MULTIFUNCTION SWITCH IN CERTAIN MODEL YEAR (MY) 2001 AND 2002 CHEVROLET ASTRO AND GMC SAFARI VEHICLES; SPECIFICALLY, ALL MY 2001 VEHICLES AND EARLY MY 2002 VEHICLES BUILT BETWEEN MARCH AND AUGUST 2001.SEE NHTSA RECALL NO. 05V-099 FOR DETAILS.THE MULTIFUNCTION SWITCH MAY DEVELOP AN OPEN CIRCUIT IN THE BRAKE LAMP OR HAZARD LAMP CIRCUIT RESULTING IN INOPERATIVE BRAKE LAMPS AND HAZARD LAMPS.THIS IS DUE TO THE COMBINED EFFECTS OF THE MATERIAL AND LUBRICATION FOR THE HAZARD SWITCH CONTACTOR THAT RESULT IN INCREASED RESISTANCE IN THE HAZARD SWITCH AND STUCK HAZARD SLIDER BUTTON IN OPEN (NO CONTACT) CONDITION.DEALERS ARE TO REPLACE THE HAZARD SWITCH AND APPLY SPECIAL GREASE TO THE HAZARD SWITCH CONTACTOR.IF A VEHICLE HAS A STUCK HAZARD SLIDER BUTTON, DEALERS ARE TO REPLACE THE ENTIRE MULTIFUNCTION SWITCH.
2002 Chevrolet Astro Problems, Complaints & Recalls | Skip That Year
Illustration