IllustrationTRANSMISSION, PUT VAN IN GEAR AND SOMETIMES IT DOES NOT ENGAGE. FINALLY VEHICLE MAKES A LOUD POP AND JUMPS WHILE FOOT ON THE GAS. *TR
2001 Chevrolet Astro
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2001 Chevrolet Astro do not stand out strongly from the model-year median of 69.
About this comparison →How this year compares
Owner complaints by model year
Compare all Astro years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
50–25K
1525–50K
1550–75K
675–100K
11100–150K
9150K+
61 reports with mileage · 30 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Service Brakes, Hydraulic. Review the 28 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Exterior Lighting. Review the 19 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 7 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
9 crash reports1 fire reports2 injury reports
Power Train complaints
5 reportsTRANSFER CASE CONTROL MODULE FAILED AT 146,000 MILES IN 2001 AWD CHEVY ASTRO. *JB
THE JULY 2002 FAILURE (FIRST OF TWO) OF THE 2001 ASTRO AWD TRANSMISSION WAS FULLY COVERED BY THE WARRANTY. I BOUGHT THE VEHICLE USED WITH 8000 MILES IN FEBRUARY 2001. IT HAD BEEN PURCHASED NEW IN AUGUST 2000. I DROVE IT FOR 16000 MILES IN 16 MONTHS (24000 ODO), AND THE TRANSMISSION WOULD NOT GO INTO REVERSE OR 3RD GEAR. THE …
Read full complaint
THE JULY 2002 FAILURE (FIRST OF TWO) OF THE 2001 ASTRO AWD TRANSMISSION WAS FULLY COVERED BY THE WARRANTY. I BOUGHT THE VEHICLE USED WITH 8000 MILES IN FEBRUARY 2001. IT HAD BEEN PURCHASED NEW IN AUGUST 2000. I DROVE IT FOR 16000 MILES IN 16 MONTHS (24000 ODO), AND THE TRANSMISSION WOULD NOT GO INTO REVERSE OR 3RD GEAR. THE DEALER REPAIRED THE TRANSMISSION AND GAVE A ONE YEAR/12000 MILE WARRANTY ON THEIR WORK. UNFORTUNATELY THE REPAIRED TRANSMISSION IS NOW SLIPPING IN 3RD AND I AM AFRAID TO DRIVE IT. IT IS OVER ONE YEAR SINCE THE JULY 2002 FIX, BUT I HAVE JUST DRIVEN IT OVER 11000 MILES (35000 ODO). I HAVE NOT YET CONTACTED THE DEALER, BUT I FEAR THAT THE RESPONSE WILL BE ISN'T THAT JUST TOO BAD
DEALER NOT FIXING PROBLEMS WITH BRAKES AND DRIVE TERRAIN. CHEVROLET NO HELP IN REPAIR EITHER. PLEASE HELP! MR
VEHICLE HAS BEEN SERVICED BY DEALER SEVERAL TIMES FOR ALL WHEEL DRIVE LIGHT CONSTANTLY ILLUMINATED. VEHICLE HAS BEEN CHECKED BY DEALER, WHO HAS TO CONSTANTLY REPLACE TRANSFER CASE CONTROL MODULE. CONSUMER LIVES IN MOUNTAINOUS AREA, AND IS VERY CONCERNED ABOUT ALL WHEEL DRIVE PERFORMANCE WHEN NEEDED.*AKTHIS PROBLEM STARTED SOO…
Read full complaint
VEHICLE HAS BEEN SERVICED BY DEALER SEVERAL TIMES FOR ALL WHEEL DRIVE LIGHT CONSTANTLY ILLUMINATED. VEHICLE HAS BEEN CHECKED BY DEALER, WHO HAS TO CONSTANTLY REPLACE TRANSFER CASE CONTROL MODULE. CONSUMER LIVES IN MOUNTAINOUS AREA, AND IS VERY CONCERNED ABOUT ALL WHEEL DRIVE PERFORMANCE WHEN NEEDED.*AKTHIS PROBLEM STARTED SOON AFTER THE VEHICLE WAS PURCHASED. THE PROBLEM STILL EXISTS. *JG
Official recalls
105V099000 · Exterior Lighting:brake Lights:switch
Mar 14, 2005
ON CERTAIN MINIVANS, THE MULTIFUNCTION SWITCH MAY DEVELOP AN OPEN CIRCUIT CONDITION IN THE STOP LAMP OR HAZARD LAMP CIRCUIT THAT RESULTS IN THE STOP LAMPS AND HAZARD LAMPS BEING INOPERATIVE.
Consequence & remedy
Consequence: THE LOSS OF STOP LAMPS AND REAR HAZARD LAMPS COULD FAIL TO WARN A FOLLOWING DRIVER THAT THE VEHICLE IS BRAKING AND/OR IS STOPPED AND COULD LEAD TO A VEHICLE CRASH.
Remedy: DEALERS WILL REPLACE THE HAZARD WARNING FLASHER SWITCH AND APPLY SPECIAL GREASE TO THE CONTACTS AT THE TIME OF INSTALLATION OF THE MODULE FREE OF CHARGE. THE REPAIR WOULD BE USED IN VEHICLES IN WHICH THE HAZARD SLIDER BUTTON IS STILL MOVABLE. IF A VEHICLE HAS A HAZARD SLIDER BUTTON THAT IS NOT MOVABLE (FROZEN), THE ENTIRE MULTIFUNCTION SWITCH WILL BE REPLACED. THE RECALL BEGAN ON APRIL 13, 2005. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 OR GMC AT 1-866-996-9463.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE04072 · Loss Of Brake Lamp Illumination
Opened Oct 19, 2004 · Closed Mar 21, 2005
Status: closed (inferred from source dates) · Exterior Lighting:brake Lights; Exterior Lighting:hazard Flashing Warning Lights
IN ITS LETTER DATED MARCH 9, 2005, GM STATED THAT IT WOULD CONDUCT A SAFETY RECALL TO REMEDY A FAULTY MULTIFUNCTION SWITCH IN CERTAIN MODEL YEAR (MY) 2001 AND 2002 CHEVROLET ASTRO AND GMC SAFARI VEHICLES; SPECIFICALLY, ALL MY 2001 VEHICLES AND EARLY MY 2002 VEHICLES BUILT BETWEEN MARCH AND AUGUST 2001.SEE NHTSA RECALL NO. 05V-099 FOR DETAILS.THE MULTIFUNCTION SWITCH MAY DEVELOP AN OPEN CIRCUIT IN THE BRAKE LAMP OR HAZARD LAMP CIRCUIT RESULTING IN INOPERATIVE BRAKE LAMPS AND HAZARD LAMPS.THIS IS DUE TO THE COMBINED EFFECTS OF THE MATERIAL AND LUBRICATION FOR THE HAZARD SWITCH CONTACTOR THAT RESULT IN INCREASED RESISTANCE IN THE HAZARD SWITCH AND STUCK HAZARD SLIDER BUTTON IN OPEN (NO CONTACT) CONDITION.DEALERS ARE TO REPLACE THE HAZARD SWITCH AND APPLY SPECIAL GREASE TO THE HAZARD SWITCH CONTACTOR.IF A VEHICLE HAS A STUCK HAZARD SLIDER BUTTON, DEALERS ARE TO REPLACE THE ENTIRE MULTIFUNCTION SWITCH.
Additional source detail variants (2)
Exterior Lighting:brake Lights
IN ITS LETTER DATED MARCH 9, 2005, GM STATED THAT IT WOULD CONDUCT A SAFETY RECALL TO REMEDY A FAULTY MULTIFUNCTION SWITCH IN CERTAIN MODEL YEAR (MY) 2001 AND 2002 CHEVROLET ASTRO AND GMC SAFARI VEHICLES; SPECIFICALLY, ALL MY 2001 VEHICLES AND EARLY MY 2002 VEHICLES BUILT BETWEEN MARCH AND AUGUST 2001.SEE NHTSA RECALL NO. 05V-099 FOR DETAILS.THE MULTIFUNCTION SWITCH MAY DEVELOP AN OPEN CIRCUIT IN THE BRAKE LAMP OR HAZARD LAMP CIRCUIT RESULTING IN INOPERATIVE BRAKE LAMPS AND HAZARD LAMPS.THIS IS DUE TO THE COMBINED EFFECTS OF THE MATERIAL AND LUBRICATION FOR THE HAZARD SWITCH CONTACTOR THAT RESULT IN INCREASED RESISTANCE IN THE HAZARD SWITCH AND STUCK HAZARD SLIDER BUTTON IN OPEN (NO CONTACT) CONDITION.DEALERS ARE TO REPLACE THE HAZARD SWITCH AND APPLY SPECIAL GREASE TO THE HAZARD SWITCH CONTACTOR.IF A VEHICLE HAS A STUCK HAZARD SLIDER BUTTON, DEALERS ARE TO REPLACE THE ENTIRE MULTIFUNCTION SWITCH.
Exterior Lighting:hazard Flashing Warning Lights
IN ITS LETTER DATED MARCH 9, 2005, GM STATED THAT IT WOULD CONDUCT A SAFETY RECALL TO REMEDY A FAULTY MULTIFUNCTION SWITCH IN CERTAIN MODEL YEAR (MY) 2001 AND 2002 CHEVROLET ASTRO AND GMC SAFARI VEHICLES; SPECIFICALLY, ALL MY 2001 VEHICLES AND EARLY MY 2002 VEHICLES BUILT BETWEEN MARCH AND AUGUST 2001.SEE NHTSA RECALL NO. 05V-099 FOR DETAILS.THE MULTIFUNCTION SWITCH MAY DEVELOP AN OPEN CIRCUIT IN THE BRAKE LAMP OR HAZARD LAMP CIRCUIT RESULTING IN INOPERATIVE BRAKE LAMPS AND HAZARD LAMPS.THIS IS DUE TO THE COMBINED EFFECTS OF THE MATERIAL AND LUBRICATION FOR THE HAZARD SWITCH CONTACTOR THAT RESULT IN INCREASED RESISTANCE IN THE HAZARD SWITCH AND STUCK HAZARD SLIDER BUTTON IN OPEN (NO CONTACT) CONDITION.DEALERS ARE TO REPLACE THE HAZARD SWITCH AND APPLY SPECIAL GREASE TO THE HAZARD SWITCH CONTACTOR.IF A VEHICLE HAS A STUCK HAZARD SLIDER BUTTON, DEALERS ARE TO REPLACE THE ENTIRE MULTIFUNCTION SWITCH.