1998 Chevrolet Astro

TL*THE CONTACT OWNS A 1998 CHEVROLET ASTRO. THE CONTACT STATED THAT THERE WAS NOT ENOUGH SPACE BETWEEN THE BRAKE PEDAL AND THE MOTOR COVER FOR HIM TO MANEUVER HIS FEET. HE WAS CONCERNED THAT HE COULD POSSIBLY GET HIS FOOT CAUGHT BETWEEN THE BRAKE PEDAL AND MOTOR COVER IN THE EVENT THAT HE NEEDED TO APPLY THE BRAKES QUICKLY. THE VIN WAS UNKNOWN. THE FAILURE AND CURRENT MILEAGES WERE LESS THAN 114,000. UPDATED 04-20-09 *BF UPDATED 04/24/09.*JB

TL*THE CONTACT OWNS A 1998 CHEVROLET ASTRO. WHILE DRIVING 10 MPH THE ANTILOCK BRAKE SYSTEM ACTIVATED AND THE CONTACT HAD TO SWERVE TO AVOID STRIKING ANOTHER VEHICLE. THE FAILURE OCCURRED WITHOUT WARNING WHEN BRAKING AT LOW SPEEDS. THE MANUFACTURER STATED THAT THIS VEHICLE WAS NOT INCLUDED IN THE RECALL AND WILL NOT PAY FOR THE REPAIR. THE CURRENT MILEAGE IS 88,000, AND FAILURE MILEAGE WAS 85,000*AK.

WHILE SLOWING TO A STOP AT ABOUT 2 MPH ON DRY PAVEMENT, THE VEHICLE'S ANTI-LOCK BRAKING SYSTEM STARTED RAPIDLY CYCLING, NO BRAKES WERE GRABBING BECAUSE OF THE RAPID CYCLING, THE ENGINE STARTED TO RACE SLIGHTLY, AND THE VEHICLE WAS HEADED FOR EITHER TWO PEDESTRIANS OR A BUILDING. TO STOP THE VEHICLE, I PLACED THE TRANSMISSION IN REVERSE AND THE VEHICLE CAME TO A STOP. AFTER ANOTHER BRAKE ATTEMPT THE BRAKES RESPONDED. I WENT TO AN ISOLATED STREET WITH SOME ICE AND DRY PAVEMENT, AND THIS ANTI-LOCK BRAKING FAILURE OCCURRED IN 1 OUT OF 5 BRAKING ATTEMPTS. I NEVER RECEIVED AN ANTI-LOCK WARNING LIGHT AND THE SYSTEM COMPLETED ITS SELF TESTS PROPERLY ON EACH ENGINE START UP. I REMOVED THE 60 AMP FUSE TO DISABLE THE SYSTEM AND I AM NOT SURE I CAN EVER TRUST THIS SYSTEM AGAIN. *JB

WHILE BRAKING AT LOW SPEED THE ABS WOULD CAUSE EXTENDED STOPPING DISTANCE. DEALERSHIP WAS NOTIFIED, BUT DID NOT RESOLVE THE PROBLEM. *AK FRONT WHEEL SPEED SENSOR REPLACED. LEFT FRONT WINDOW HANGS WHEN GOING UP. WINDOW TRACKE LUBED. PADS AND ROTORS REPLACED. RER BRAKE ADJUSTED. BRAKE PEDAL KICKED UP WHEN ALMOST TO A STOP. REPLACED BRAKE CALIPERS/ROTORS/ BACKING PLATES AND REMOVED SENSORS AND CLEANED RUST BUILD UP ON SENSOR AND HUB ASSEMBLIES. BOTH IDLER AMRS AND FRONT AND REAR SHOCKS WERE REPLACED DUE TO FRONT END PLAY. *TT

CANNOT GET AIR THROUGHT VENTS IN DASH, ALL CONTROLS WORK PROPERLY VACUUM ACTUATOR MOVES, THERE IS VACUUM AT THE SWITHC, NO ONE KNOWS THE ANSWER PAINT ON GAS DOOR BUBBLING AND LOOKS LIKE IT IS GOING TO FALL OFF TRANSMISSION SHIFTED HARD INTO 2ND GEAR SINCE WE BOUGHT IT ( 54000KMS) FINALLY STARTED TO SLIP , BOUGHT USED TRANS AND HAD IT INSTALLED, QUOTED 3000.00 TO REBUILD, DEALER WAS PAST EVEN BELIEF. ABS COMES ON WHEN COMING TO A STOP EVERY TIME . LF FRONT SENSOR READS O MPH WHEN OTHER SENSORS READ MOVEMENT CAUSING IT TO ASSUME A SKID SITUATION, REPLACED SENSOR AT 205.00 NO BETTER, DOES NOT SET CODE IN COMPUTER ACCORDING TO MECHANIC. PULLED FUSE. HAS HAD VIBRATION IN DRIVELINE SINCE PURCHASED NO ONE CAN FIND ANYTHING SUGEESTION RANGE FROM REPLACE ALL U JOINTS, DID SOME OF THEM NO BETTER TO REPLACE REAR END. IT IS NOT POSSIBLE IN NOVA SCOTIA TO OBTAIN A BLASTING PERMIT TO BLOW UP YOUR CAR EVEN IF YOU TAKE PRECAUTIONS AND HIRE A PROFESSIONAL. I HAVE NEVER IN 40 YEARS OF DRIVING SOME BAD STUFF FROM OLD ENGLISH CARS TO TRANSPORT TRUCKS WITH MORE MILES THAN THERE ARE NUMBERS, EVER HAD THIS KIND OF PROBLEM, MOST THINGS CAN BE FIXED. YOU HAVE NEVER LIVED UNTIL YOU HAVE TAKEN THE WHOLE DASH APART ON ONE OF THESE, THE VEHICLE WAS DESIGNED BY MADMEN.

BELT TENSIONER CASING CRACKED/BROKEN AROUND MOUNT BOLT, CAUSING LOSS OF BELT TENSION, POWER ASSISTED STEERING, AND POWER ASSISTED BRAKING. THROTTLE CONTROL PEDAL "STICKS" AND EXCESSIVE PRESSURE MUST BE APPLIED TO OVERCOME RESISTANCE. BRAKE PEDAL COULD NOT BE DEPRESSED UNTIL EXCESSIVE FORCE WAS APPLIED WITH BOTH FEET, OCCURRED TWICE AT VERY SLOW SPEEDS WHILE CRESTING A SHORT STEEP INCLINE AND TURNING TO THE RIGHT TO PARK, CAUSE YET UNKNOWN. DT

AFTER DRIVING FOR ABOUT 7/10 MILES AND THEN PARKING IT SMELLS LIKE BURNING BRAKES. WHEN WE TOOK IT IN TO HAVE THE BRAKES CHECKED THE REPAIR SHOP SAID THE PADS WERE LOOSE AND GLAZED. WE HAVE REPLACED THE BRAKES PADS 2 TWICE SINCE WE PURCHASED THE VEHICLE AND THE TIME FRAME FROM THE 1ST TIME TO THE LAST TIME WAS ABOUT 4 MONTHS AGO AND WE ARE TAKING IT BACK TO HAVE THE BRAKES CHECK AGAIN FOR THE SAME REASON. *AK