IllustrationWHEN VEHICLE IS IN PARK ON A HILL, COUPLE OF HOURS LATER VEHICLE WILL MOVE FOUR CAR LENGTHS. CAUSE UNKNOWNN. PLEASE PROVIDE ANY FURTHER INFORMATION.*AK
1997 Chevrolet Astro
Owner reports · Recalls · Investigations
More warning signs than most Astro years
Owner complaints for the 1997 Chevrolet Astro are substantially higher than the model-year median of 69.
About this comparison →How this year compares
Owner complaints by model year
Compare all Astro years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 46 of 360 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Service Brakes, Hydraulic. Review the 64 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Visibility. Review the 62 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 53 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
23 crash reports7 fire reports16 injury reports
What owners actually said
360 reportsDRIVERS SEAT BELT BUCKLE ATTACHMENT HAS FAULTY WEBBING THAT WILL CAUSES BUCKLE TO PULL FREE. PLEASE DESCRIBE DETAILS.*JB
WHILE DRIVING AT 68MPH AND WITH NO WARNING VEHICLE STARTED TO VIBRATE, CAUSING IT TO ROLLOVER. DEALER NOTIFIED.*AK *DT
AFTER DRIVING FOR 20-40 MINUTES, THE TRANSMISSION WILL SHIFT VERY HARD FROM FIRST TO SECOND GEAR. WE HAVE REPORTED THIS TO THE DEALER AND AM TOLD THAT IT WOULD COST $1800.00 + TO REPLACE THE TRANSMISSION. WE HAVE HAD 3 TRANSMISSION SHOPS LOOK AT THIS PROBLEM AND RUN DIAGNOSTICS AND TUNE UP ON THE TRANSMISSION. THE PROBLEM STI…
Read full complaint
AFTER DRIVING FOR 20-40 MINUTES, THE TRANSMISSION WILL SHIFT VERY HARD FROM FIRST TO SECOND GEAR. WE HAVE REPORTED THIS TO THE DEALER AND AM TOLD THAT IT WOULD COST $1800.00 + TO REPLACE THE TRANSMISSION. WE HAVE HAD 3 TRANSMISSION SHOPS LOOK AT THIS PROBLEM AND RUN DIAGNOSTICS AND TUNE UP ON THE TRANSMISSION. THE PROBLEM STILL EXISTS. WE HAVE BEEN DEALING WITH THIS AGGRAVATING SITUATION THE LAST TWO YEARS, SPOKEN WITH MANY PEOPLE IN THE REPAIR BUSINESS AND NO ONE SEEMS TO BE ABLE TO PINPOINT THE EXACT PROBLEM. THEY ONLY WANT TO "LOOK" AT THE PROBLEM AND COLLECT MORE MONEY, WHICH WE HAVE DONE ON 3 SEPERATE OCCASIONS. ALL TO NO AVAIL. PROBLEM STILL EXISTS.*AK
WINDSHIELD WIPERS WORK INTERMITTENTLY OR STOP DURING OPERATION. DEALER AND MANUFACTURER HAVE BEEN NOTIFIED. *AK CONSUMER WAS AFRAID OF RUNNING INTO THE BACK OF THE VEHICLE OR CRASHING INTO THE GAURD RAIL. IT WAS RAINING HEAVILY WHEN THE WINDSHIELD WIPERS JUST STOPPED. CONSUMER COULD ONLY SEE THE TAIL LIGHTS OF THE OTHER VE…
Read full complaint
WINDSHIELD WIPERS WORK INTERMITTENTLY OR STOP DURING OPERATION. DEALER AND MANUFACTURER HAVE BEEN NOTIFIED. *AK CONSUMER WAS AFRAID OF RUNNING INTO THE BACK OF THE VEHICLE OR CRASHING INTO THE GAURD RAIL. IT WAS RAINING HEAVILY WHEN THE WINDSHIELD WIPERS JUST STOPPED. CONSUMER COULD ONLY SEE THE TAIL LIGHTS OF THE OTHER VEHICLE. *JG
WHILE DRIVING AT ANY SPEED CATALYTIC CONVERTER WILL RATTLE MAKING A LOUD NOISE. DEALER NOTIFIED.*AK
VEHICLE CUT OFF WHILE DRIVING AT 45 MPH. VEHICLE TOWED TO A REPAIR SHOP. INFORMED CONSUMER OF A FUEL PUMP FAILURE. DEALER AND MANUFACTURER WERE NOT NOTIFIED AT THIS TIME. FEEEL FREE TO PROVIDE ANY FURTHER INFORMATION.*AK
BRAKE PEDAL LOCKED UP, AND THEY WERE UNABLE TO PRESS DOWN ON BRAKE PEDAL. THIS COULD HAVE CAUSDE AN ACCIDENT. CAUSE UNKNOWN. DEALER NOTIFIED.*AKI
WHILE DRIVING 65 MPH CONSUMER HEARD A LOUD POP FROM FRONT END, THEN, DRIVER'S SIDE DROPPED ONTO FRONT WHEEL. DEALER DETERMINED TORSION BAR HAD BROKEN.*AK
I HAVE HAD A NUMBER OF PROBLEMS WITH THIS VEHICLE: BOTH THE LEFT AND RIGHT POWER WINDOR MOTORS; REPLACE THE KEY REMOTE, BOTH IDLER ARMS,FRONT BRAKE PAD AT 37,000 MILES, SERPENTIME BELT, POWER STEERING PUMP - REPLACED TWICE, HAD TO FIX OIL COOLER LINES TWICE, REPLACED DISTRIBUTOR/ROTOR; REPLACED LOWER GASKET DUE TO INTAKE MANIFOL…
Read full complaint
I HAVE HAD A NUMBER OF PROBLEMS WITH THIS VEHICLE: BOTH THE LEFT AND RIGHT POWER WINDOR MOTORS; REPLACE THE KEY REMOTE, BOTH IDLER ARMS,FRONT BRAKE PAD AT 37,000 MILES, SERPENTIME BELT, POWER STEERING PUMP - REPLACED TWICE, HAD TO FIX OIL COOLER LINES TWICE, REPLACED DISTRIBUTOR/ROTOR; REPLACED LOWER GASKET DUE TO INTAKE MANIFOLD LEAK, AND FUEL PUMP MODUAL. ALL OF THIS WAS DONE BEFORE MY CAR HAD 57,000 MILES. THE DEALER HAS BEEN VERY FAIR AND REPAIRED AT LOW OR NOW COST. I HAVE HAD TWO TRIPS SHORTENED DUE TO BREAKDOWNS AND HAVE SPENT OVER $1,500 ON REPAIRS NOT COVERED UNDER WARRENTY OR BY THE DEALER. THIS IS IN ADDITION TO NORMAL MAINTENANCE (OIL AND FILTER,FOUR NEW TIRES,AND TRANSMISSION FLUID AND FILTER). I AM CONCERNED AS TO "WHAT IS NEXT" AND WHEN THE DEALER WHEN NO LONGER BE ABLE TO FIX THESE PROBLEMS AT LOW COST TO ME.*AK
Official recalls
403V159000 · Visibility:windshield Wiper/washer
Apr 28, 2003
ON CERTAIN MINIVANS, PICKUP TRUCKS, AND SPORT UTILITY VEHICLES WITH CERTAIN MODEL-ENGINE COMBINATIONS, THE WINDSHIELD WIPER MOTOR MAY FAIL DUE TO CRACKED SOLDER JOINTS ON THE CONTROLLER CIRCUIT BOARD. THE WINDSHIELD WIPERS COULD WORK INTERMITTENTLY OR NOT AT ALL.
Consequence & remedy
Consequence: IF THIS WERE TO OCCUR DURING BAD WEATHER, DRIVER VISIBILITY WOULD BE REDUCED, WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE WIPER MOTOR CIRCUIT BOARD AND COVER. OWNER NOTIFICATION BEGAN ON JUNE 19, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR OLDSMOBILE AT 1-800-442-6537.
01V123000 · Seat Belts:front:warning Light/devices
Apr 10, 2001
VEHICLE DESCRIPTION: MINI VANS. SOME OF THESE VEHICLES FAIL TO COMPLY WITH REQUIREMENTS OF FMVSS NO. 208, "OCCUPANT CRASH PROTECTION." THE "FASTEN SAFETY-BELT" AUDIBLE WARNING OCCASIONALLY MAY NOT COME ON OR MAY TERMINATE IN LESS THAN FOUR SECONDS AS REQUIRED BY THE STANDARD.
Consequence & remedy
Consequence: THIS DOES NOT MEET THE REQUIREMENTS OF THE STANDARD.
Remedy: DEALERS WILL INSTALL A NEW ALARM MODULE. OWNER NOTIFICATION BEGAN JUNE 27, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020 OR GMC AT 1-800-462-8782.
99V009000 · Child Seat
Jan 20, 1999
VEHICLE DESCRIPTION: MINI VANS EQUIPPED WITH INTEGRATED DUAL CHILD SEATS. SOME OF THESE VEHICLES MAY BE MISSING A SEAT BELT RETRACTOR CLUTCH SPRING AND/OR PAWL SPRING IN THE CHILD SEAT. IF THE CLUTCH SPRING WAS MISSING, THE SEAT BELT WOULD LOCK IN THE RETRACTED POSITION AND COULD NOT BE USED. IF THE PAWL SPRING WAS MISSING, THE SEAT BELT RESTRAINT WOULD CONTINUALLY PLAY OUT AND WOULD NOT LOCK.
Consequence & remedy
Consequence: THESE CONDITIONS COULD INCREASE THE OCCUPANT'S RISK OF INJURY IN THE EVENT OF A VEHICLE CRASH.
Remedy: DEALERS WILL INSPECT THE SEAT BELTS ON THE CHILD SEATS, AND IF NECESSARY, REPLACE THE CHILD SEAT.
97V057000 · Seat Belts:rear/other
Apr 8, 1997
THE OUTBOARD SAFETY BELT WEBBING ON THE RIGHT-HAND REAR BUCKET SEAT CAN SEPARATE DURING A VEHICLE CRASH.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, THE VEHICLE OCCUPANT WOULD NOT BE PROPERLY RESTRAINED AND PERSONAL INJURY COULD RESULT.
Remedy: DEALERS WILL INSTALL A PROTECTOR ON THE REAR SEAT CUSHION FRAME.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1EA02006 · Windshield Wiper Failure
Opened May 31, 2002 · Closed Jul 23, 2003
Status: closed (inferred from source dates) · Visibility:windshield Wiper/washer:motor
AS A RESULT OF THIS, AND THE PRECEDINGINVESTIGATION, RQ99-003, GM HAS EXPANDED THE POPULATION OF SAFETY RECALL 98V-150 (REPLACEMENT OF THE WINDSHIELD WIPER CONTROL MODULE) TO INCLUDE AN ADDITIONAL 1.77 MILLION VEHICLES.INCLUDED ARE VARIOUS 1994-1997 MY M/L VANS, S/T TRUCKS AND SUVS, & C/K TRUCKS AND SUVS.SEE ATTACHED TECHNICAL REPORT FOR DETAILS.
Additional source detail variants (2)
Visibility:windshield Wiper/washer:motor
AS A RESULT OF THIS, AND THE PRECEDINGINVESTIGATION, RQ99-003, GM HAS EXPANDED THE POPULATION OF SAFETY RECALL 98V-150 (REPLACEMENT OF THE WINDSHIELD WIPER CONTROL MODULE) TO INCLUDE AN ADDITIONAL 1.77 MILLION VEHICLES.INCLUDED ARE VARIOUS 1994-1997 MY M/L VANS, S/T TRUCKS AND SUVS, & C/K TRUCKS AND SUVS.SEE ATTACHED TECHNICAL REPORT FOR DETAILS.
Visibility:windshield Wiper/washer:motor
AS A RESULT OF THIS, AND THE PRECEDINGINVESTIGATION, RQ99-003, GM HAS EXPANDED THE POPULATION OF SAFETY RECALL 98V-150 (REPLACEMENT OF THE WINDSHIELD WIPER CONTROL MODULE) TO INCLUDE AN ADDITIONAL 1.77 MILLION VEHICLES.INCLUDED ARE VARIOUS 1994-1997 MY M/L VANS, S/T TRUCKS AND SUVS, & C/K TRUCKS AND SUVS.SEE ATTACHED TECHNICAL REPORT FOR DETAILS.