IllustrationTENSIONER BELT ON MY 1997 CHEVROLET ASTRO VAN CONTINUES TO MAKE CHIRPING SOUNDS ESPECIALLY AFTER IT RAINS. TENSIONER BELT HAS BEEN CHANGED 4 TIMES AND ALLEVIATES THE PROBLEM TEMPORARILY.*AK
1997 Chevrolet Astro
Owner reports · Recalls · Investigations
More warning signs than most Astro years
Owner complaints for the 1997 Chevrolet Astro are substantially higher than the model-year median of 69.
About this comparison →How this year compares
Owner complaints by model year
Compare all Astro years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 46 of 360 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Service Brakes, Hydraulic. Review the 64 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Visibility. Review the 62 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 53 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
23 crash reports7 fire reports16 injury reports
What owners actually said
360 reportsPOWER WINDOW ON PASSENGER SIDE HAS FAILED. VEHICLE HAS BEEN THROUGH 2 NEW BATTERIES SINCE WE PURCHASED IT 6 MONTHS AGO. SEEMS TO BE DRAINING BATTERIES AND WE ARE NOT SURE WHY. WE PUT BATTERY ON RECHARGER OVERNIGHT, BUT WITHIN HOURS OF TAKING ITOFF THE CHARGER, THE BATTERY IS DRAINED WHILE THE CAR IS NOT RUNNING.*JB
PAINT IS PEELING AND CRACKING ON MY 1997 CHEVROLET ASTRO. WHILE UNDER WARRENTY THE ROOF WAS REPAINTED. SOON IT STARTED TO CRACK BUT DEALER WOULD NOT HELP. AS A OWNER OF SEVERAL GM VEHICLES I FEEL MY VAN SHOULD BE REPAINTED FOR FREE SINCE THIS IS A KNOWN DEFECT OF GM. ALL I AM ASKING FOR IS FOR GM TO PAY TO HAVE MY VAN FULLY R…
Read full complaint
PAINT IS PEELING AND CRACKING ON MY 1997 CHEVROLET ASTRO. WHILE UNDER WARRENTY THE ROOF WAS REPAINTED. SOON IT STARTED TO CRACK BUT DEALER WOULD NOT HELP. AS A OWNER OF SEVERAL GM VEHICLES I FEEL MY VAN SHOULD BE REPAINTED FOR FREE SINCE THIS IS A KNOWN DEFECT OF GM. ALL I AM ASKING FOR IS FOR GM TO PAY TO HAVE MY VAN FULLY REPAINTED. THANK YOU AND LOOK FORWARD TO HEARING FROM YOU. ANTHONY O. HOOPER. *AK
CAR BEGAN TO IDLE VERY HIGH THEN BEGAN TO DRIVE ITSELF. BRAKES HAD TO BE USED AT ALL TIMES DURING OPERATION OF VEHICLE UNTIL VEHICLE WAS BROUGHT TO MECHANIC.*AK
MY VAN IS A 1997 ASTRO AND IT HAS SOME SERIOUS TRANSMISSION PROBLEMS AFTER GOING 30-40 MILES AND STOPING AT A LIGHT IT JERKS REAL HARD AND FEELS LIKE I WAS HIT IN THE BACK I HAVE TOOK IT 3 TIMES TO GET FIXED AND IT STILL DOES IT THE SERVICE INGINE LIGHT COMES ON WHEN IT STARTS DOING IT NO ONE SEEMS TO KNOW WHEAT WRONG THEY J…
Read full complaint
MY VAN IS A 1997 ASTRO AND IT HAS SOME SERIOUS TRANSMISSION PROBLEMS AFTER GOING 30-40 MILES AND STOPING AT A LIGHT IT JERKS REAL HARD AND FEELS LIKE I WAS HIT IN THE BACK I HAVE TOOK IT 3 TIMES TO GET FIXED AND IT STILL DOES IT THE SERVICE INGINE LIGHT COMES ON WHEN IT STARTS DOING IT NO ONE SEEMS TO KNOW WHEAT WRONG THEY JUST KEEP TAKEING MY MONEY AND TELLING ME ITS FIXED WHEN ITS NO IF SOME ONE COULD TELL ME WHAT THE PROBLEM IS I WOULD BE VERY HAPPY THE FUEL PUMP WENT OUT 900.00$ THE DRIVER WINDOW MOTOR WENT OUT THE IDLER ARMS HAVE HAD TO BE REPLACED BRAKES KEEP WEARING DOWN ...PLEASE SOME ONE CONTACT ME.*AK
WHILE DRIVING IN A RAINSTORM THE VEHICLE WINDSHIELD WIPERS FAIL WITHOUT WARNING. THE CAUSE WAS UNKNOWN. *NM
WHILE DRIVING IN A RAINSTORM THE VEHICLE WINDSHIELD WIPERS FAILED WITHOUT WARNING. THE CAUSE IS UNKNOWN. PLEASE PROVIDE ANY ADDITIONAL INFORMATION. *NM
THE CONSUMER NOTICED THAT THE FUEL INDICATOR READ FULL WHEN THE FUEL TANK LEVEL WAS LOW. *AK
WHILE DRIVING AT 70 MPH ACCELERATOR PEDAL STICKS INTERMITTENTLY. *AK
WINDSHIELD WIPER MOTOR FOUND DEFECTIVE.*MR THE WIPER MOTOR HAS BEEN REPLACED TWICE. THE CONSUMER BELIEVES THERE IS A DEFINITE PROBLEM WITH THE WIPER MOTORS. *PH *NM
Official recalls
403V159000 · Visibility:windshield Wiper/washer
Apr 28, 2003
ON CERTAIN MINIVANS, PICKUP TRUCKS, AND SPORT UTILITY VEHICLES WITH CERTAIN MODEL-ENGINE COMBINATIONS, THE WINDSHIELD WIPER MOTOR MAY FAIL DUE TO CRACKED SOLDER JOINTS ON THE CONTROLLER CIRCUIT BOARD. THE WINDSHIELD WIPERS COULD WORK INTERMITTENTLY OR NOT AT ALL.
Consequence & remedy
Consequence: IF THIS WERE TO OCCUR DURING BAD WEATHER, DRIVER VISIBILITY WOULD BE REDUCED, WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE WIPER MOTOR CIRCUIT BOARD AND COVER. OWNER NOTIFICATION BEGAN ON JUNE 19, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR OLDSMOBILE AT 1-800-442-6537.
01V123000 · Seat Belts:front:warning Light/devices
Apr 10, 2001
VEHICLE DESCRIPTION: MINI VANS. SOME OF THESE VEHICLES FAIL TO COMPLY WITH REQUIREMENTS OF FMVSS NO. 208, "OCCUPANT CRASH PROTECTION." THE "FASTEN SAFETY-BELT" AUDIBLE WARNING OCCASIONALLY MAY NOT COME ON OR MAY TERMINATE IN LESS THAN FOUR SECONDS AS REQUIRED BY THE STANDARD.
Consequence & remedy
Consequence: THIS DOES NOT MEET THE REQUIREMENTS OF THE STANDARD.
Remedy: DEALERS WILL INSTALL A NEW ALARM MODULE. OWNER NOTIFICATION BEGAN JUNE 27, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020 OR GMC AT 1-800-462-8782.
99V009000 · Child Seat
Jan 20, 1999
VEHICLE DESCRIPTION: MINI VANS EQUIPPED WITH INTEGRATED DUAL CHILD SEATS. SOME OF THESE VEHICLES MAY BE MISSING A SEAT BELT RETRACTOR CLUTCH SPRING AND/OR PAWL SPRING IN THE CHILD SEAT. IF THE CLUTCH SPRING WAS MISSING, THE SEAT BELT WOULD LOCK IN THE RETRACTED POSITION AND COULD NOT BE USED. IF THE PAWL SPRING WAS MISSING, THE SEAT BELT RESTRAINT WOULD CONTINUALLY PLAY OUT AND WOULD NOT LOCK.
Consequence & remedy
Consequence: THESE CONDITIONS COULD INCREASE THE OCCUPANT'S RISK OF INJURY IN THE EVENT OF A VEHICLE CRASH.
Remedy: DEALERS WILL INSPECT THE SEAT BELTS ON THE CHILD SEATS, AND IF NECESSARY, REPLACE THE CHILD SEAT.
97V057000 · Seat Belts:rear/other
Apr 8, 1997
THE OUTBOARD SAFETY BELT WEBBING ON THE RIGHT-HAND REAR BUCKET SEAT CAN SEPARATE DURING A VEHICLE CRASH.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, THE VEHICLE OCCUPANT WOULD NOT BE PROPERLY RESTRAINED AND PERSONAL INJURY COULD RESULT.
Remedy: DEALERS WILL INSTALL A PROTECTOR ON THE REAR SEAT CUSHION FRAME.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1EA02006 · Windshield Wiper Failure
Opened May 31, 2002 · Closed Jul 23, 2003
Status: closed (inferred from source dates) · Visibility:windshield Wiper/washer:motor
AS A RESULT OF THIS, AND THE PRECEDINGINVESTIGATION, RQ99-003, GM HAS EXPANDED THE POPULATION OF SAFETY RECALL 98V-150 (REPLACEMENT OF THE WINDSHIELD WIPER CONTROL MODULE) TO INCLUDE AN ADDITIONAL 1.77 MILLION VEHICLES.INCLUDED ARE VARIOUS 1994-1997 MY M/L VANS, S/T TRUCKS AND SUVS, & C/K TRUCKS AND SUVS.SEE ATTACHED TECHNICAL REPORT FOR DETAILS.
Additional source detail variants (2)
Visibility:windshield Wiper/washer:motor
AS A RESULT OF THIS, AND THE PRECEDINGINVESTIGATION, RQ99-003, GM HAS EXPANDED THE POPULATION OF SAFETY RECALL 98V-150 (REPLACEMENT OF THE WINDSHIELD WIPER CONTROL MODULE) TO INCLUDE AN ADDITIONAL 1.77 MILLION VEHICLES.INCLUDED ARE VARIOUS 1994-1997 MY M/L VANS, S/T TRUCKS AND SUVS, & C/K TRUCKS AND SUVS.SEE ATTACHED TECHNICAL REPORT FOR DETAILS.
Visibility:windshield Wiper/washer:motor
AS A RESULT OF THIS, AND THE PRECEDINGINVESTIGATION, RQ99-003, GM HAS EXPANDED THE POPULATION OF SAFETY RECALL 98V-150 (REPLACEMENT OF THE WINDSHIELD WIPER CONTROL MODULE) TO INCLUDE AN ADDITIONAL 1.77 MILLION VEHICLES.INCLUDED ARE VARIOUS 1994-1997 MY M/L VANS, S/T TRUCKS AND SUVS, & C/K TRUCKS AND SUVS.SEE ATTACHED TECHNICAL REPORT FOR DETAILS.