IllustrationWAS COMING TO A STOP LIGHT & STARTED TO APPLY BRAKES, AND BRAKE PEDAL WENT TO THE FLOOR. HAD NO BRAKES. DID NOT HIT ANYTHING. HAD VEHICLE TOWED TO DEALER. MECHANIC INDICATED THAT EGR VALVE WAS OPENED DUE TO CARBON BUILT UP. BRAKE PROBLEM COULD BE REPAIRED, BUT COULD ALSO REAPPEAR.*AK
1997 Chevrolet Astro
Owner reports · Recalls · Investigations
More warning signs than most Astro years
Owner complaints for the 1997 Chevrolet Astro are substantially higher than the model-year median of 69.
About this comparison →How this year compares
Owner complaints by model year
Compare all Astro years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 46 of 360 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Service Brakes, Hydraulic. Review the 64 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Visibility. Review the 62 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 53 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
23 crash reports7 fire reports16 injury reports
Service Brakes, Hydraulic complaints
64 reportsWHILE TRAVELING AT 20 MPH AND DEPRESSING BRAKE PEDAL, VEHICLE WENT INTO EXTENDED STOPPING DISTANCE AND LOST CONTROL. PLEASE PROVIDE FURTHER INFORMARTION. *AK
CONSUMER WAS TRAVELING FIVE MPH ON A SIDE STREET AND BRAKES AND POWER STEERING COMPLETLY STOPPED. NO PRIOR WARNING AT ALL. CONSUMER STATED THAT HE HAD JUST GOT BACK FROM A TRAVELING TRIP EIGHT HUNDRED MILES. *AK
STEERING & BRAKES WENT OUT AT THE SAME TIME. THEY ARE BOTH ASSISTED BY THE POWER STEERING PUMP. *AK
UPON DRIVING OUT OF A PARKING LOT, THERE WAS NO BRAKING OR STEERING ABLILITY. DRIVER HAD NO CONTROL OF THE VAN AND COULD HARDLY STOP. DEALERSHIP HAS BEEN NOTIFIED ABOUT THE PROBLEM. THE PROBLEM HAS NOT BEEN CORRECTED. PLEASE PROVIDE ANY FURHTER INFORMATION. *AK
WHILE DRIVING ON LOCAL ROAD , TRAVELING 40-45MPH, TWO VEHICLES UP AND AHEAD WERE CROSSING THE INTERSECTION. CONSUMER REALIZING THAT THERE WERE CAMERAS AND LIGHT TURNED YELLOW, SLAMMED ON THE BRAKES, AND A PICKUP TRUCK BEHIND REARENDED HER. CONSUMER APPLIED BRAKES, AND THEY FAILED. ALSO, UPON IMPACT, NEITHER AIRBAG DEPLOYE…
Read full complaint
WHILE DRIVING ON LOCAL ROAD , TRAVELING 40-45MPH, TWO VEHICLES UP AND AHEAD WERE CROSSING THE INTERSECTION. CONSUMER REALIZING THAT THERE WERE CAMERAS AND LIGHT TURNED YELLOW, SLAMMED ON THE BRAKES, AND A PICKUP TRUCK BEHIND REARENDED HER. CONSUMER APPLIED BRAKES, AND THEY FAILED. ALSO, UPON IMPACT, NEITHER AIRBAG DEPLOYED. *AK
ABS BRAKES SEEM TO KICK IN AT LOW SPEEDS. CAN FEEL THE BRAKE PEDAL PULSATING. WOULD MAKE LOUD NOISES WHEN BRAKES ARE APPLIED. ON ITS OWN THE ABS BRAKES WOULD ENGAGE & THEN DISENGAGE. PROBLEM IS INTERMITTENT & CANNOT BE DUPLICATED. HAVE TAKEN VEHICLE TO DEALERSHIP & MECHANIC HAS TEST DRIVEN VEHICLE TO APPLY BRAKES, BUT THE PROBL…
Read full complaint
ABS BRAKES SEEM TO KICK IN AT LOW SPEEDS. CAN FEEL THE BRAKE PEDAL PULSATING. WOULD MAKE LOUD NOISES WHEN BRAKES ARE APPLIED. ON ITS OWN THE ABS BRAKES WOULD ENGAGE & THEN DISENGAGE. PROBLEM IS INTERMITTENT & CANNOT BE DUPLICATED. HAVE TAKEN VEHICLE TO DEALERSHIP & MECHANIC HAS TEST DRIVEN VEHICLE TO APPLY BRAKES, BUT THE PROBLEM WAS NEVER SOLVED. *AK
WHILE DRIVING THE VEHICLE LOST BOTH BRAKES & STEERING AT ONCE & WITHOUT WARNING. EXTREMELY DANGEROUS AND IF VEHICLE WAS TRAVELING AT A HIGHER RATE OF SPEED, SEVERE PERSONAL INJURIES & PROPERTY DAMAGE WOULD CERTAINLY HAVE RESULTED.
CONSUMER TOOK VEHICLE IN FOR FRONT BRAKE REPAIRS & FOUND OUT THAT THE REAR AXLE SEALS FAILED. REAR BRAKES HAD TO BE REPLACED DUE TO THIS PROBLEM. SERVICE ADVISOR TOLD CONSUMER THIS WAS NOT COMMON FOR THIS VEHICLE. *AK *ML
THE RUBBER BRAKE COVER SLIPPED OFF THE BRAKE WHILE CONSUMER WAS DEPRESSING IT CAUSING CONSUMER FOOT TO HIT THE GAS PEDAL, LURCH FORWARD AND HIT THE VEHICLE IN FRONT OF HIM. *NLM
Official recalls
403V159000 · Visibility:windshield Wiper/washer
Apr 28, 2003
ON CERTAIN MINIVANS, PICKUP TRUCKS, AND SPORT UTILITY VEHICLES WITH CERTAIN MODEL-ENGINE COMBINATIONS, THE WINDSHIELD WIPER MOTOR MAY FAIL DUE TO CRACKED SOLDER JOINTS ON THE CONTROLLER CIRCUIT BOARD. THE WINDSHIELD WIPERS COULD WORK INTERMITTENTLY OR NOT AT ALL.
Consequence & remedy
Consequence: IF THIS WERE TO OCCUR DURING BAD WEATHER, DRIVER VISIBILITY WOULD BE REDUCED, WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE WIPER MOTOR CIRCUIT BOARD AND COVER. OWNER NOTIFICATION BEGAN ON JUNE 19, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR OLDSMOBILE AT 1-800-442-6537.
01V123000 · Seat Belts:front:warning Light/devices
Apr 10, 2001
VEHICLE DESCRIPTION: MINI VANS. SOME OF THESE VEHICLES FAIL TO COMPLY WITH REQUIREMENTS OF FMVSS NO. 208, "OCCUPANT CRASH PROTECTION." THE "FASTEN SAFETY-BELT" AUDIBLE WARNING OCCASIONALLY MAY NOT COME ON OR MAY TERMINATE IN LESS THAN FOUR SECONDS AS REQUIRED BY THE STANDARD.
Consequence & remedy
Consequence: THIS DOES NOT MEET THE REQUIREMENTS OF THE STANDARD.
Remedy: DEALERS WILL INSTALL A NEW ALARM MODULE. OWNER NOTIFICATION BEGAN JUNE 27, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020 OR GMC AT 1-800-462-8782.
99V009000 · Child Seat
Jan 20, 1999
VEHICLE DESCRIPTION: MINI VANS EQUIPPED WITH INTEGRATED DUAL CHILD SEATS. SOME OF THESE VEHICLES MAY BE MISSING A SEAT BELT RETRACTOR CLUTCH SPRING AND/OR PAWL SPRING IN THE CHILD SEAT. IF THE CLUTCH SPRING WAS MISSING, THE SEAT BELT WOULD LOCK IN THE RETRACTED POSITION AND COULD NOT BE USED. IF THE PAWL SPRING WAS MISSING, THE SEAT BELT RESTRAINT WOULD CONTINUALLY PLAY OUT AND WOULD NOT LOCK.
Consequence & remedy
Consequence: THESE CONDITIONS COULD INCREASE THE OCCUPANT'S RISK OF INJURY IN THE EVENT OF A VEHICLE CRASH.
Remedy: DEALERS WILL INSPECT THE SEAT BELTS ON THE CHILD SEATS, AND IF NECESSARY, REPLACE THE CHILD SEAT.
97V057000 · Seat Belts:rear/other
Apr 8, 1997
THE OUTBOARD SAFETY BELT WEBBING ON THE RIGHT-HAND REAR BUCKET SEAT CAN SEPARATE DURING A VEHICLE CRASH.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, THE VEHICLE OCCUPANT WOULD NOT BE PROPERLY RESTRAINED AND PERSONAL INJURY COULD RESULT.
Remedy: DEALERS WILL INSTALL A PROTECTOR ON THE REAR SEAT CUSHION FRAME.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1EA02006 · Windshield Wiper Failure
Opened May 31, 2002 · Closed Jul 23, 2003
Status: closed (inferred from source dates) · Visibility:windshield Wiper/washer:motor
AS A RESULT OF THIS, AND THE PRECEDINGINVESTIGATION, RQ99-003, GM HAS EXPANDED THE POPULATION OF SAFETY RECALL 98V-150 (REPLACEMENT OF THE WINDSHIELD WIPER CONTROL MODULE) TO INCLUDE AN ADDITIONAL 1.77 MILLION VEHICLES.INCLUDED ARE VARIOUS 1994-1997 MY M/L VANS, S/T TRUCKS AND SUVS, & C/K TRUCKS AND SUVS.SEE ATTACHED TECHNICAL REPORT FOR DETAILS.
Additional source detail variants (2)
Visibility:windshield Wiper/washer:motor
AS A RESULT OF THIS, AND THE PRECEDINGINVESTIGATION, RQ99-003, GM HAS EXPANDED THE POPULATION OF SAFETY RECALL 98V-150 (REPLACEMENT OF THE WINDSHIELD WIPER CONTROL MODULE) TO INCLUDE AN ADDITIONAL 1.77 MILLION VEHICLES.INCLUDED ARE VARIOUS 1994-1997 MY M/L VANS, S/T TRUCKS AND SUVS, & C/K TRUCKS AND SUVS.SEE ATTACHED TECHNICAL REPORT FOR DETAILS.
Visibility:windshield Wiper/washer:motor
AS A RESULT OF THIS, AND THE PRECEDINGINVESTIGATION, RQ99-003, GM HAS EXPANDED THE POPULATION OF SAFETY RECALL 98V-150 (REPLACEMENT OF THE WINDSHIELD WIPER CONTROL MODULE) TO INCLUDE AN ADDITIONAL 1.77 MILLION VEHICLES.INCLUDED ARE VARIOUS 1994-1997 MY M/L VANS, S/T TRUCKS AND SUVS, & C/K TRUCKS AND SUVS.SEE ATTACHED TECHNICAL REPORT FOR DETAILS.