IllustrationCONSUMER STATES THAT BRAKES ARE LEAKING FLUID WHILE DRIVING.*JB
1997 Chevrolet Astro
Owner reports · Recalls · Investigations
More warning signs than most Astro years
Owner complaints for the 1997 Chevrolet Astro are substantially higher than the model-year median of 69.
About this comparison →How this year compares
Owner complaints by model year
Compare all Astro years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 46 of 360 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Service Brakes, Hydraulic. Review the 64 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Visibility. Review the 62 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 53 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
23 crash reports7 fire reports16 injury reports
Service Brakes, Hydraulic complaints
64 reportsANTI-LOCK BRAKE FAILURE. *AK
WHEN T BRAKES WERE APPLIED PEDAL WENT TO THE FLOOR, RESULTING IN EXTENDED STOPPING DISTANCE. DEALER HAS INSPECTED VEHICLE. PLEASE PROVIDE ADDITIONAL INFORMATION.*AK
THE TRANSMISSION WAS REPLACED DUE TO IT MISSING 1ST AND GOING RIGHT INTO 2ND GEAR.FRONT END OF VEHICLE SHAKES AT 40 MPH. HAD TIRES REPLACED AND ALIGNMENT DONE. INTERIOR LIGHT STAY S ON UNLESS MANUAL OVERRIDE IS TURNED OFF.BRAKES MAKE NOISES WHEN YOU COME TO A STOP OR YOU ARE STOPPING SLOWLY. ENGINE LIGHT COMES ON ALL THE TIME …
Read full complaint
THE TRANSMISSION WAS REPLACED DUE TO IT MISSING 1ST AND GOING RIGHT INTO 2ND GEAR.FRONT END OF VEHICLE SHAKES AT 40 MPH. HAD TIRES REPLACED AND ALIGNMENT DONE. INTERIOR LIGHT STAY S ON UNLESS MANUAL OVERRIDE IS TURNED OFF.BRAKES MAKE NOISES WHEN YOU COME TO A STOP OR YOU ARE STOPPING SLOWLY. ENGINE LIGHT COMES ON ALL THE TIME BROUGHT TO MECHANIC EVERY TIME TO GET ANALYZED.
MY WIFE AND DAUGHTER WERE IN THE VEHICLE. MY WIFE WAS DRIVING. SUDDENLY, THE ACCELERATOR STUCK IN AN OPEN POSITION. CLOSE TO HOME AND UNCERTAIN WHAT TO DO, MY WIFE WAS ABLE TO GET IN OUR DRIVEWAY AT HOME. THE NEW REAR BRAKES INSTALLED A WEEK BEFORE WERE RUINED. I HAD MECHANIC REPLACE THEM AND A REAR BRAKE CYLINDER ALSO. THE STRE…
Read full complaint
MY WIFE AND DAUGHTER WERE IN THE VEHICLE. MY WIFE WAS DRIVING. SUDDENLY, THE ACCELERATOR STUCK IN AN OPEN POSITION. CLOSE TO HOME AND UNCERTAIN WHAT TO DO, MY WIFE WAS ABLE TO GET IN OUR DRIVEWAY AT HOME. THE NEW REAR BRAKES INSTALLED A WEEK BEFORE WERE RUINED. I HAD MECHANIC REPLACE THEM AND A REAR BRAKE CYLINDER ALSO. THE STRESS APPARENTLY CAUSED THE CYLINDER TO START LEAKING. MY MECHANIC ALSO INVESTIGATED THE THROTTLE PROBLEM. A FACTORY WIRING HARNESS STRAP HAD BROKEN AND FLIPPED AROUND INTO THE THROTTLE LINKAGE. FORTUNATELY, NO ONE WAS INJURED. WE LIVE IN A RURAL AREA AND TRAFFIC WAS NOT VERY HEAVY. MY ENGINE ON THE OTHER HAND IS NOT SO FORTUNATE. IT SEEMS THAT IT RAN AT TOO HIGH AN RPM FOR TOO LONG. IT HAS DEVELOPED A SEVERE ENGINE KNOCK. GM DOES NOT SEEM VERY INTERESTED IN HEARING ABOUT MY SAFETY CONCERNS AND APPEAL FOR REPAIR COMPENSATION.*AK
NO SUMMARY LISTED FOR ABOVE VEHICLE. *AK
ROTORS RUSTED FROM BRAKE HUB. WHEN CONSUMER WAS TRAVELING ON HIGHWAY VEHICLE VEERED INTO ANOTHER OF TRAFFIC LANE. DEALERSHIP WAS AWARE OF PROBLEM.*AK
BRAKES AND STEERING FAILED SIMULTANEOUSLY, RESULTING IN A CRASH. GMC KNOWS ABOUT THE PROBLEM AND WILL NOT FIX IT UNTIL ENOUGH PEOPLE DIE. MY FAMILY WAS ALMOST KILLED. ANYONE WHO HAS HAD A FAMILY MEMBER HURT OR KILLED IN A GM VAN SHOULD SUE GMC. *AK
UPON APPLYING THE BRAKES, WITHOUT NOTICE WARNING OR INDICATION, BRAKES COMPLETELY FAILED. THE POWER STEERING QUIT WORKING AT THE SAME TIME.
WHILE TRAVELING 30-40MPH APPLIED BRAKES TO STOP AND HAD NO BRAKES, PEDAL WAS HARD AND RESISTED, DID NOT HIT ANYTHING, LOST ALL POWER STEERING HOWEVER, ENGINE STILL RUNNING, HAD TO SHUT DOWN VEHICLE AND RESTART IT. CONTACTED DEALERSHIP, BUT NO SOLUTION WAS FOUND. *AK *YH
Official recalls
403V159000 · Visibility:windshield Wiper/washer
Apr 28, 2003
ON CERTAIN MINIVANS, PICKUP TRUCKS, AND SPORT UTILITY VEHICLES WITH CERTAIN MODEL-ENGINE COMBINATIONS, THE WINDSHIELD WIPER MOTOR MAY FAIL DUE TO CRACKED SOLDER JOINTS ON THE CONTROLLER CIRCUIT BOARD. THE WINDSHIELD WIPERS COULD WORK INTERMITTENTLY OR NOT AT ALL.
Consequence & remedy
Consequence: IF THIS WERE TO OCCUR DURING BAD WEATHER, DRIVER VISIBILITY WOULD BE REDUCED, WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE WIPER MOTOR CIRCUIT BOARD AND COVER. OWNER NOTIFICATION BEGAN ON JUNE 19, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR OLDSMOBILE AT 1-800-442-6537.
01V123000 · Seat Belts:front:warning Light/devices
Apr 10, 2001
VEHICLE DESCRIPTION: MINI VANS. SOME OF THESE VEHICLES FAIL TO COMPLY WITH REQUIREMENTS OF FMVSS NO. 208, "OCCUPANT CRASH PROTECTION." THE "FASTEN SAFETY-BELT" AUDIBLE WARNING OCCASIONALLY MAY NOT COME ON OR MAY TERMINATE IN LESS THAN FOUR SECONDS AS REQUIRED BY THE STANDARD.
Consequence & remedy
Consequence: THIS DOES NOT MEET THE REQUIREMENTS OF THE STANDARD.
Remedy: DEALERS WILL INSTALL A NEW ALARM MODULE. OWNER NOTIFICATION BEGAN JUNE 27, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020 OR GMC AT 1-800-462-8782.
99V009000 · Child Seat
Jan 20, 1999
VEHICLE DESCRIPTION: MINI VANS EQUIPPED WITH INTEGRATED DUAL CHILD SEATS. SOME OF THESE VEHICLES MAY BE MISSING A SEAT BELT RETRACTOR CLUTCH SPRING AND/OR PAWL SPRING IN THE CHILD SEAT. IF THE CLUTCH SPRING WAS MISSING, THE SEAT BELT WOULD LOCK IN THE RETRACTED POSITION AND COULD NOT BE USED. IF THE PAWL SPRING WAS MISSING, THE SEAT BELT RESTRAINT WOULD CONTINUALLY PLAY OUT AND WOULD NOT LOCK.
Consequence & remedy
Consequence: THESE CONDITIONS COULD INCREASE THE OCCUPANT'S RISK OF INJURY IN THE EVENT OF A VEHICLE CRASH.
Remedy: DEALERS WILL INSPECT THE SEAT BELTS ON THE CHILD SEATS, AND IF NECESSARY, REPLACE THE CHILD SEAT.
97V057000 · Seat Belts:rear/other
Apr 8, 1997
THE OUTBOARD SAFETY BELT WEBBING ON THE RIGHT-HAND REAR BUCKET SEAT CAN SEPARATE DURING A VEHICLE CRASH.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, THE VEHICLE OCCUPANT WOULD NOT BE PROPERLY RESTRAINED AND PERSONAL INJURY COULD RESULT.
Remedy: DEALERS WILL INSTALL A PROTECTOR ON THE REAR SEAT CUSHION FRAME.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1EA02006 · Windshield Wiper Failure
Opened May 31, 2002 · Closed Jul 23, 2003
Status: closed (inferred from source dates) · Visibility:windshield Wiper/washer:motor
AS A RESULT OF THIS, AND THE PRECEDINGINVESTIGATION, RQ99-003, GM HAS EXPANDED THE POPULATION OF SAFETY RECALL 98V-150 (REPLACEMENT OF THE WINDSHIELD WIPER CONTROL MODULE) TO INCLUDE AN ADDITIONAL 1.77 MILLION VEHICLES.INCLUDED ARE VARIOUS 1994-1997 MY M/L VANS, S/T TRUCKS AND SUVS, & C/K TRUCKS AND SUVS.SEE ATTACHED TECHNICAL REPORT FOR DETAILS.
Additional source detail variants (2)
Visibility:windshield Wiper/washer:motor
AS A RESULT OF THIS, AND THE PRECEDINGINVESTIGATION, RQ99-003, GM HAS EXPANDED THE POPULATION OF SAFETY RECALL 98V-150 (REPLACEMENT OF THE WINDSHIELD WIPER CONTROL MODULE) TO INCLUDE AN ADDITIONAL 1.77 MILLION VEHICLES.INCLUDED ARE VARIOUS 1994-1997 MY M/L VANS, S/T TRUCKS AND SUVS, & C/K TRUCKS AND SUVS.SEE ATTACHED TECHNICAL REPORT FOR DETAILS.
Visibility:windshield Wiper/washer:motor
AS A RESULT OF THIS, AND THE PRECEDINGINVESTIGATION, RQ99-003, GM HAS EXPANDED THE POPULATION OF SAFETY RECALL 98V-150 (REPLACEMENT OF THE WINDSHIELD WIPER CONTROL MODULE) TO INCLUDE AN ADDITIONAL 1.77 MILLION VEHICLES.INCLUDED ARE VARIOUS 1994-1997 MY M/L VANS, S/T TRUCKS AND SUVS, & C/K TRUCKS AND SUVS.SEE ATTACHED TECHNICAL REPORT FOR DETAILS.