Illustration1997 ASTRO VAN. FUEL TANK ALWAYS READS FULL. RUNNING OUT OF GAS IN TRAFFIC CAN BE VERY DANGEROUS. I KNOW OF OTHERS WITH SAME VEHICLE WHO HAD THIS SAME PROBLEM. CALLED GM AND OPENED TROUBLE TICKET. THEY SAID NO RECALLS OR BULLITENS ARE OPEN FOR THIS PROBLEM. FUEL LEVEL SENSOR ON FUEL PUMP IS BAD.
1997 Chevrolet Astro
Owner reports · Recalls · Investigations
More warning signs than most Astro years
Owner complaints for the 1997 Chevrolet Astro are substantially higher than the model-year median of 69.
About this comparison →How this year compares
Owner complaints by model year
Compare all Astro years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 46 of 360 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Service Brakes, Hydraulic. Review the 64 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Visibility. Review the 62 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 53 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
23 crash reports7 fire reports16 injury reports
Fuel System, Other complaints
12 reportsFUEL GAUGE READS FULL ALL THE TIME. I REALIZE THAT IT IS NOT AS IMPORTANT AS OTHER THINGS. THIS HAPPENED ABOUT 3 MONTHS AFTER THE WARRENTY RAN OUT. THIS IS A COMMON PROBLEM WITH GM VECHICALS AND NOT WITH JUST THE ASTRO VANS. WHEN I CALLED THE DEALER THEY SAID THAT PEOPLE NORMALY JUST USE THERE TRIP ODOMETER. THE REASON I W…
Read full complaint
FUEL GAUGE READS FULL ALL THE TIME. I REALIZE THAT IT IS NOT AS IMPORTANT AS OTHER THINGS. THIS HAPPENED ABOUT 3 MONTHS AFTER THE WARRENTY RAN OUT. THIS IS A COMMON PROBLEM WITH GM VECHICALS AND NOT WITH JUST THE ASTRO VANS. WHEN I CALLED THE DEALER THEY SAID THAT PEOPLE NORMALY JUST USE THERE TRIP ODOMETER. THE REASON I WAS GIVEN WAS THAT IT WAS A $500 FIX. I KNOW 5 OTHER PEOPLE THAT HAVE OR HAD THIS SAME PROBLEM. MOST JUST GET BY UNTIL THEY GET RID OF THE VECHICAL.*AK
THE ENGINE RACED AT FULL THROTTLE WHICH CAUSED THE VEHICLE NOT TO STOP WHEN THE BRAKES WERE APPLIED, THE DEALER STATED THE FUEL PRESSURE REGULATOR HAD MALFUNCTIONED. *JB
TRANSMISSION SHIFTS HARD FROM FIRST TO SECOND GEAR WHEN I GET OFF OF THE HIGHWAY,FEELS LIKE SOMEONE REARENDED ME. GAS GUAGE ALWAYS REGISTERS FULL.GRINDING NOISE FROM RIGHT REAR TIRE,SOUNDS LIKE THE REAR AXLE,HAD BRAKES CHECKED BY DEALER THEY ARE FINE.MAYBE I SHOULD OF BOUGHT A FORD. *AK
FUEL GAUGE STOPPED WORKING. AIR CONDITIONER AND TRANSMISSION BROKE.
OCCURANCE 1) ENGINE STOPPED WITHOUT WARNING WHILE APPROCAHING AN INTERSECTION. THE RESULTING LOSS OF POWER CAUSED A SEVERE CONTROL PROBLEM WITH THE VAN. THE REASON FOR THE FAILURE WAS THE FUEL GUAGE READ 3/4 AND THE VAN RAN OUT OF FUEL. OCCURANCE 2) THE FUEL GUAGE HAS TOTALLY STOPPED FUNCTIONING, AFTER TOPPING OFF AND PROCEEDIN…
Read full complaint
OCCURANCE 1) ENGINE STOPPED WITHOUT WARNING WHILE APPROCAHING AN INTERSECTION. THE RESULTING LOSS OF POWER CAUSED A SEVERE CONTROL PROBLEM WITH THE VAN. THE REASON FOR THE FAILURE WAS THE FUEL GUAGE READ 3/4 AND THE VAN RAN OUT OF FUEL. OCCURANCE 2) THE FUEL GUAGE HAS TOTALLY STOPPED FUNCTIONING, AFTER TOPPING OFF AND PROCEEDING ONTO HIGHWAY I DROVE FOR 1/2 HOUR AT 65, A SUDDEN SLAM OCCURED 2 OR THREE TIMES, APPEARED TO BE THE ENGINE CUTTING IN AND OUT, SLOWED TO 55 AND CONTINUED FOR 150 MILES WITHOUT FURTHER INCIDENT. OCCURANCE 3) VEHICLE HAS NO FUEL GUAGE, I AM TOLD IT'S OUT OF WARRANTY, EVEN IF FULL THE VEHICLE SEEM TO LOOSE CONTROL MOMENTARALLY, AS IF TO LOOSE POWER.
RADIO BROKE DOWN. YH
THE GAS INDICATOR FAILS TO REGISTER THE CORRECT FUEL LEFT IN VEHICLE. OWNER RAN OUT OF GAS DUE TO DEFECTIVE INDICATOR. THE DOOR HINGES ON THE DUTCH DOORS ALLOW DOORS TO SWING WIDE. TOOK VEHICLE TO MECHANIC TO REPAIR HINGES, BUT THE FUEL INDICATOR COULD NOT BE FIXED. *AK *ML
YOU DO NOT REALIZE GAUGE DOES NOT WORK BECAUSE IT ACTS AS IF IT DOES. IF YOU RUN OUT OF GAS YOU WILL HAVE NO POWER BRAKES OR STEERING. *AK
GAS GUAGE DOES NOT FUNCTION AT ALL. OWNER CAN'T TELL IF THERE IS ANY GAS IN THE VEHICLE. DEALER HAS NOT SEEN VEHICLE. *AK
Official recalls
403V159000 · Visibility:windshield Wiper/washer
Apr 28, 2003
ON CERTAIN MINIVANS, PICKUP TRUCKS, AND SPORT UTILITY VEHICLES WITH CERTAIN MODEL-ENGINE COMBINATIONS, THE WINDSHIELD WIPER MOTOR MAY FAIL DUE TO CRACKED SOLDER JOINTS ON THE CONTROLLER CIRCUIT BOARD. THE WINDSHIELD WIPERS COULD WORK INTERMITTENTLY OR NOT AT ALL.
Consequence & remedy
Consequence: IF THIS WERE TO OCCUR DURING BAD WEATHER, DRIVER VISIBILITY WOULD BE REDUCED, WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE WIPER MOTOR CIRCUIT BOARD AND COVER. OWNER NOTIFICATION BEGAN ON JUNE 19, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR OLDSMOBILE AT 1-800-442-6537.
01V123000 · Seat Belts:front:warning Light/devices
Apr 10, 2001
VEHICLE DESCRIPTION: MINI VANS. SOME OF THESE VEHICLES FAIL TO COMPLY WITH REQUIREMENTS OF FMVSS NO. 208, "OCCUPANT CRASH PROTECTION." THE "FASTEN SAFETY-BELT" AUDIBLE WARNING OCCASIONALLY MAY NOT COME ON OR MAY TERMINATE IN LESS THAN FOUR SECONDS AS REQUIRED BY THE STANDARD.
Consequence & remedy
Consequence: THIS DOES NOT MEET THE REQUIREMENTS OF THE STANDARD.
Remedy: DEALERS WILL INSTALL A NEW ALARM MODULE. OWNER NOTIFICATION BEGAN JUNE 27, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020 OR GMC AT 1-800-462-8782.
99V009000 · Child Seat
Jan 20, 1999
VEHICLE DESCRIPTION: MINI VANS EQUIPPED WITH INTEGRATED DUAL CHILD SEATS. SOME OF THESE VEHICLES MAY BE MISSING A SEAT BELT RETRACTOR CLUTCH SPRING AND/OR PAWL SPRING IN THE CHILD SEAT. IF THE CLUTCH SPRING WAS MISSING, THE SEAT BELT WOULD LOCK IN THE RETRACTED POSITION AND COULD NOT BE USED. IF THE PAWL SPRING WAS MISSING, THE SEAT BELT RESTRAINT WOULD CONTINUALLY PLAY OUT AND WOULD NOT LOCK.
Consequence & remedy
Consequence: THESE CONDITIONS COULD INCREASE THE OCCUPANT'S RISK OF INJURY IN THE EVENT OF A VEHICLE CRASH.
Remedy: DEALERS WILL INSPECT THE SEAT BELTS ON THE CHILD SEATS, AND IF NECESSARY, REPLACE THE CHILD SEAT.
97V057000 · Seat Belts:rear/other
Apr 8, 1997
THE OUTBOARD SAFETY BELT WEBBING ON THE RIGHT-HAND REAR BUCKET SEAT CAN SEPARATE DURING A VEHICLE CRASH.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, THE VEHICLE OCCUPANT WOULD NOT BE PROPERLY RESTRAINED AND PERSONAL INJURY COULD RESULT.
Remedy: DEALERS WILL INSTALL A PROTECTOR ON THE REAR SEAT CUSHION FRAME.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1EA02006 · Windshield Wiper Failure
Opened May 31, 2002 · Closed Jul 23, 2003
Status: closed (inferred from source dates) · Visibility:windshield Wiper/washer:motor
AS A RESULT OF THIS, AND THE PRECEDINGINVESTIGATION, RQ99-003, GM HAS EXPANDED THE POPULATION OF SAFETY RECALL 98V-150 (REPLACEMENT OF THE WINDSHIELD WIPER CONTROL MODULE) TO INCLUDE AN ADDITIONAL 1.77 MILLION VEHICLES.INCLUDED ARE VARIOUS 1994-1997 MY M/L VANS, S/T TRUCKS AND SUVS, & C/K TRUCKS AND SUVS.SEE ATTACHED TECHNICAL REPORT FOR DETAILS.
Additional source detail variants (2)
Visibility:windshield Wiper/washer:motor
AS A RESULT OF THIS, AND THE PRECEDINGINVESTIGATION, RQ99-003, GM HAS EXPANDED THE POPULATION OF SAFETY RECALL 98V-150 (REPLACEMENT OF THE WINDSHIELD WIPER CONTROL MODULE) TO INCLUDE AN ADDITIONAL 1.77 MILLION VEHICLES.INCLUDED ARE VARIOUS 1994-1997 MY M/L VANS, S/T TRUCKS AND SUVS, & C/K TRUCKS AND SUVS.SEE ATTACHED TECHNICAL REPORT FOR DETAILS.
Visibility:windshield Wiper/washer:motor
AS A RESULT OF THIS, AND THE PRECEDINGINVESTIGATION, RQ99-003, GM HAS EXPANDED THE POPULATION OF SAFETY RECALL 98V-150 (REPLACEMENT OF THE WINDSHIELD WIPER CONTROL MODULE) TO INCLUDE AN ADDITIONAL 1.77 MILLION VEHICLES.INCLUDED ARE VARIOUS 1994-1997 MY M/L VANS, S/T TRUCKS AND SUVS, & C/K TRUCKS AND SUVS.SEE ATTACHED TECHNICAL REPORT FOR DETAILS.