IllustrationFUEL PUMP IS CREATING A HUMMING NOISE. CONSUMER HAS TAKEN VEHICLE TO DEALERSHIP, AND HAD FUEL PUMP REPLACED. REPLACED FUEL PUMP IS MAKING SAME NOISE. *AK THE ORIGINAL FUEL PUMP WAS REPLACED BECAUSE THE GAS GUAGE STOPED WORKING. *YH
1997 Chevrolet Astro
Owner reports · Recalls · Investigations
More warning signs than most Astro years
Owner complaints for the 1997 Chevrolet Astro are substantially higher than the model-year median of 69.
About this comparison →How this year compares
Owner complaints by model year
Compare all Astro years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 46 of 360 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Service Brakes, Hydraulic. Review the 64 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Visibility. Review the 62 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 53 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
23 crash reports7 fire reports16 injury reports
Fuel System, Gasoline complaints
31 reportsFUEL GUAGE DID NOT REGISTER CORRECT LEVELS OF FUEL WHICH CAUSED VEHICLE TO UNEXPECTEDLY RUN OUT OF FUEL. PLEASE GIVE ANY FURTHER DETAILS. *AK
DRIVER'S SIDE REAR WINDOW WILL NOT STAY OPEN, CLIPS THAT SHOULD HOLD IT UP ARE BLOCKED BY MATERIAL, WINDOW SLAMS SHUT WHEN GOING OVER A BUMP. TRANSMISSION WENT OUT AT 45000 MILES. *AK OIL LEAK, DEALER ORDERED AXLE OUTPUT SHAFT SEAL AND CRANKSHAFT SENSOR. ELECTRIC FUEL PUMP REPLACED DUE TO VEHICLE CUTTING AND WOULD CRANK, BUT …
Read full complaint
DRIVER'S SIDE REAR WINDOW WILL NOT STAY OPEN, CLIPS THAT SHOULD HOLD IT UP ARE BLOCKED BY MATERIAL, WINDOW SLAMS SHUT WHEN GOING OVER A BUMP. TRANSMISSION WENT OUT AT 45000 MILES. *AK OIL LEAK, DEALER ORDERED AXLE OUTPUT SHAFT SEAL AND CRANKSHAFT SENSOR. ELECTRIC FUEL PUMP REPLACED DUE TO VEHICLE CUTTING AND WOULD CRANK, BUT WOULD NOT STAR. OIL PRESSURE GAUGE ERRATIC, DEALER REPLACED OIL PRESSURE SENDER. FRONT BRAKES AND PADS WERE REPLACED, ROTORS WERE RESURFACED. CONSUMER STATES THERE IS PLAY IN THE STEERING, DEALER REPLACED BOTH IDLER ARMS AND RESET TOE IN. POWER DOOR LOCKS INOPERABLE, DEALER REPLACED POWER DOOR LOCK SWITCH. POWER WINDOW INOPERABLE, DEALER REPLACED POWER WINDOW SWITCH. SHIFTER WAS HARD TO MOVE, DEALER REPLACED SHIFT CABLE. GAS PEDAL BINDS AT TIMES, DEALER ORDERED THROTTLE CABLE AND REPLACED ACCELERATOR CABLE. DRIVER SETA SEEMS LOOSE WHEN BRAKING, DEALER ORDERED DRIVER SEAT TRACK ASSEMBLY AND REPLACED DRIVER SEAT ADJUSTER. PCM FUSE KEPT BLOWING OUT, DEALER REMOVED ENGINE COVER AND TRACED WIRE HARNESS, REPAIRED SHORTED HARNESS AT THE REAR OF THE TRANSMISSION. *SLC
WHILE VEHICLE WAS BEING DRIVEN FUEL PUMP MALFUNCTIONED, CAUSING VEHICLE TO COMPLETELY SHUTDOWN. PLEASE GIVE ANY FURTHER DETAILS.*AK
ADDITONAL FAILURE DATES / MI: 8-11-99 @20544 MI., 12-2-99 @ 21932 MI., 6-30-00 @24992MI, 10-13-00 @26737 MI., AS YOU CAN SEE THE PROBLEM REPETES AT ABOUT EVERY 2000 - 2500 MILES. CHEVY SAYS ITS A PROBLEM WITH THE GAS BLENDS IN CA & NY ONLY? IF THIS IS TRUE THEN WHY ARE THEY NOT HAVING PROBLEMS WITH ALL OF THERE ENGINES?…
Read full complaint
ADDITONAL FAILURE DATES / MI: 8-11-99 @20544 MI., 12-2-99 @ 21932 MI., 6-30-00 @24992MI, 10-13-00 @26737 MI., AS YOU CAN SEE THE PROBLEM REPETES AT ABOUT EVERY 2000 - 2500 MILES. CHEVY SAYS ITS A PROBLEM WITH THE GAS BLENDS IN CA & NY ONLY? IF THIS IS TRUE THEN WHY ARE THEY NOT HAVING PROBLEMS WITH ALL OF THERE ENGINES? THE INJECTION PORTS ARE DEFECTIVE AND THEY REFUSE TO FIX REPALCE THEM. INSTEAD THEY BRING THE VAN IN FOR A "INJECTOR CLEANING" PER CHEVY BULLETIN. THE ENGINE RUNS SO ROUGH IT SHAKES THE WHOLE VAN! THE FUEL INJECTOR DESIGN IS DEFECTIVE AND NEEDS TO BE FIXED/RECALLED!
NO SUMMARY LISTED FRO ABOVE VEHICLE. *AK
CHEVROLET DOESN'T CARE ABOUT USING CHEAP PARTS- AFTER WARRANTY THEY SAY TRADE IT IN .NUMEROUS THINGS WRONG WITH VAN AND HAVE TALKED TO CHEVROLET MANY TIMES. CAN'T USE BACK DOOR OF VAN, RUN OUT OF GAS, KNOBS FALL OF INTERIOR DEVICES, ASKED CHEVY TO HELP SINCE 37,000 AND PROBLEMS STILL HAPPENING AS I GO, CAN'T AFFORD TO FIX AND CA…
Read full complaint
CHEVROLET DOESN'T CARE ABOUT USING CHEAP PARTS- AFTER WARRANTY THEY SAY TRADE IT IN .NUMEROUS THINGS WRONG WITH VAN AND HAVE TALKED TO CHEVROLET MANY TIMES. CAN'T USE BACK DOOR OF VAN, RUN OUT OF GAS, KNOBS FALL OF INTERIOR DEVICES, ASKED CHEVY TO HELP SINCE 37,000 AND PROBLEMS STILL HAPPENING AS I GO, CAN'T AFFORD TO FIX AND CAN'T AFFORD TO TRADE. ANOTHER NICE SHOVE IT JOB BY CHEVROLET THEY DON'T STAND BY THEIR PRDUCT AND THEIR PRODUCT IS NOT SAFE PLEASE RESPOND. *AK
WHILE TRAVELING AT HIGHWAY SPEED OF 60 MPH OR MORE VEHICLE LURCHED FORWARD TWICE. ALSO, FUEL GAUGE MOVED FROM FULL TO EMTPY AND CONTINUED TO MOVE BACK AND FORTH. VEHICLE TAKEN TO DEALER, AND INFORMED CONSUMER THAT THE FUEL TANK SENDER UNIT HAS MELTED DOWN, AND COULD HAVE STARTED A FIRE IN THE TANK. *AK
DEFECTIVE FUEL INJECTOR PLUG NEEDS TO BE CLEANED EVERY 15,000 FOR WHICH THE MANUFACTURER HAS AN EXTENDED WARRANTY. THIS MAY CAUSE A CRASH. PLEASE PROVIDE FURTHER INFORMATION. *AK
NO SUMMARY LISTED FOR ABOV EVEHICLE. *AK
Official recalls
403V159000 · Visibility:windshield Wiper/washer
Apr 28, 2003
ON CERTAIN MINIVANS, PICKUP TRUCKS, AND SPORT UTILITY VEHICLES WITH CERTAIN MODEL-ENGINE COMBINATIONS, THE WINDSHIELD WIPER MOTOR MAY FAIL DUE TO CRACKED SOLDER JOINTS ON THE CONTROLLER CIRCUIT BOARD. THE WINDSHIELD WIPERS COULD WORK INTERMITTENTLY OR NOT AT ALL.
Consequence & remedy
Consequence: IF THIS WERE TO OCCUR DURING BAD WEATHER, DRIVER VISIBILITY WOULD BE REDUCED, WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE WIPER MOTOR CIRCUIT BOARD AND COVER. OWNER NOTIFICATION BEGAN ON JUNE 19, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR OLDSMOBILE AT 1-800-442-6537.
01V123000 · Seat Belts:front:warning Light/devices
Apr 10, 2001
VEHICLE DESCRIPTION: MINI VANS. SOME OF THESE VEHICLES FAIL TO COMPLY WITH REQUIREMENTS OF FMVSS NO. 208, "OCCUPANT CRASH PROTECTION." THE "FASTEN SAFETY-BELT" AUDIBLE WARNING OCCASIONALLY MAY NOT COME ON OR MAY TERMINATE IN LESS THAN FOUR SECONDS AS REQUIRED BY THE STANDARD.
Consequence & remedy
Consequence: THIS DOES NOT MEET THE REQUIREMENTS OF THE STANDARD.
Remedy: DEALERS WILL INSTALL A NEW ALARM MODULE. OWNER NOTIFICATION BEGAN JUNE 27, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020 OR GMC AT 1-800-462-8782.
99V009000 · Child Seat
Jan 20, 1999
VEHICLE DESCRIPTION: MINI VANS EQUIPPED WITH INTEGRATED DUAL CHILD SEATS. SOME OF THESE VEHICLES MAY BE MISSING A SEAT BELT RETRACTOR CLUTCH SPRING AND/OR PAWL SPRING IN THE CHILD SEAT. IF THE CLUTCH SPRING WAS MISSING, THE SEAT BELT WOULD LOCK IN THE RETRACTED POSITION AND COULD NOT BE USED. IF THE PAWL SPRING WAS MISSING, THE SEAT BELT RESTRAINT WOULD CONTINUALLY PLAY OUT AND WOULD NOT LOCK.
Consequence & remedy
Consequence: THESE CONDITIONS COULD INCREASE THE OCCUPANT'S RISK OF INJURY IN THE EVENT OF A VEHICLE CRASH.
Remedy: DEALERS WILL INSPECT THE SEAT BELTS ON THE CHILD SEATS, AND IF NECESSARY, REPLACE THE CHILD SEAT.
97V057000 · Seat Belts:rear/other
Apr 8, 1997
THE OUTBOARD SAFETY BELT WEBBING ON THE RIGHT-HAND REAR BUCKET SEAT CAN SEPARATE DURING A VEHICLE CRASH.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, THE VEHICLE OCCUPANT WOULD NOT BE PROPERLY RESTRAINED AND PERSONAL INJURY COULD RESULT.
Remedy: DEALERS WILL INSTALL A PROTECTOR ON THE REAR SEAT CUSHION FRAME.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1EA02006 · Windshield Wiper Failure
Opened May 31, 2002 · Closed Jul 23, 2003
Status: closed (inferred from source dates) · Visibility:windshield Wiper/washer:motor
AS A RESULT OF THIS, AND THE PRECEDINGINVESTIGATION, RQ99-003, GM HAS EXPANDED THE POPULATION OF SAFETY RECALL 98V-150 (REPLACEMENT OF THE WINDSHIELD WIPER CONTROL MODULE) TO INCLUDE AN ADDITIONAL 1.77 MILLION VEHICLES.INCLUDED ARE VARIOUS 1994-1997 MY M/L VANS, S/T TRUCKS AND SUVS, & C/K TRUCKS AND SUVS.SEE ATTACHED TECHNICAL REPORT FOR DETAILS.
Additional source detail variants (2)
Visibility:windshield Wiper/washer:motor
AS A RESULT OF THIS, AND THE PRECEDINGINVESTIGATION, RQ99-003, GM HAS EXPANDED THE POPULATION OF SAFETY RECALL 98V-150 (REPLACEMENT OF THE WINDSHIELD WIPER CONTROL MODULE) TO INCLUDE AN ADDITIONAL 1.77 MILLION VEHICLES.INCLUDED ARE VARIOUS 1994-1997 MY M/L VANS, S/T TRUCKS AND SUVS, & C/K TRUCKS AND SUVS.SEE ATTACHED TECHNICAL REPORT FOR DETAILS.
Visibility:windshield Wiper/washer:motor
AS A RESULT OF THIS, AND THE PRECEDINGINVESTIGATION, RQ99-003, GM HAS EXPANDED THE POPULATION OF SAFETY RECALL 98V-150 (REPLACEMENT OF THE WINDSHIELD WIPER CONTROL MODULE) TO INCLUDE AN ADDITIONAL 1.77 MILLION VEHICLES.INCLUDED ARE VARIOUS 1994-1997 MY M/L VANS, S/T TRUCKS AND SUVS, & C/K TRUCKS AND SUVS.SEE ATTACHED TECHNICAL REPORT FOR DETAILS.