IllustrationWAS COMING TO A STOP LIGHT & STARTED TO APPLY BRAKES, AND BRAKE PEDAL WENT TO THE FLOOR. HAD NO BRAKES. DID NOT HIT ANYTHING. HAD VEHICLE TOWED TO DEALER. MECHANIC INDICATED THAT EGR VALVE WAS OPENED DUE TO CARBON BUILT UP. BRAKE PROBLEM COULD BE REPAIRED, BUT COULD ALSO REAPPEAR.*AK
1997 Chevrolet Astro
Owner reports · Recalls · Investigations
More warning signs than most Astro years
Owner complaints for the 1997 Chevrolet Astro are substantially higher than the model-year median of 69.
About this comparison →How this year compares
Owner complaints by model year
Compare all Astro years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 46 of 360 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Service Brakes, Hydraulic. Review the 64 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Visibility. Review the 62 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 53 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
23 crash reports7 fire reports16 injury reports
Engine And Engine Cooling complaints
37 reportsAS YOU CAN SEE, I HAVE HAD NUMEROUS PROBLEMS WITH THIS VAN. THE DEALER NOR CHEVROLET HAVE OFFERED ANY ASSISTANCE SAYING THAT AFTER 36,000 MILES THEY ARE NOT RESPONSIBLE. OBVIOUSLY, THERE IS SOMETHING WRONG WITH THIS CAR. I AM A SINGLE MOM AND I CANNOT PAY MY CAR PAYMENT PLUS REPAIRS EVERY MONTH. I CANNOT TRADE IT IN BECAUSE …
Read full complaint
AS YOU CAN SEE, I HAVE HAD NUMEROUS PROBLEMS WITH THIS VAN. THE DEALER NOR CHEVROLET HAVE OFFERED ANY ASSISTANCE SAYING THAT AFTER 36,000 MILES THEY ARE NOT RESPONSIBLE. OBVIOUSLY, THERE IS SOMETHING WRONG WITH THIS CAR. I AM A SINGLE MOM AND I CANNOT PAY MY CAR PAYMENT PLUS REPAIRS EVERY MONTH. I CANNOT TRADE IT IN BECAUSE I OWE TOO MUCH ON IT. IF I TURN IT IN, I DO NOT HAVE CREDIT TO BUY ANOTHER CAR. CAN YOU ASSIST ME IN ANY WAY? NO SAFETY DEFECT LISTED. *AK
ENGINE HAS BEEN CUTTING OFF EXCESSIVELY, CAUSING A LOSS OF POWER STEERING AND POWER BRAKES. DEALER CAN'T FIND THE PROBLEM. *AK
INTERMITTENTLY VEHICLE WILL LOSE POWER AND STOP IN TRAFFIC. DEALER CANNOT DETERMINE CAUSE. ALSO, CONSUMER NOTICED A WHITE PASTY FUNGUS GROWING WHICH IS EATING THROUGH THE METAL AND CARPET.*AK
IN OCT. 1997 WHEN STARTING TO DRIVE TRANSMISSION SLIPS, FEELS LIKE VAN HAS BEEN HIT FROM BEHIND. DEALER REPLACED VALVE BODY,DUE TO A KNOWN PRODUCT PROBLEM.VAN ONCE AGAIN HAD SAME TROBLE IN MAY 2000, DEALER CHANGED VALVE BODY, ALSO STATEDE BECAUSED OF A KNOWN PRODUCT CONCERN. BUT TJIS TIME I HAD TO PAY $672.06. THEIR CUSTOMER SER…
Read full complaint
IN OCT. 1997 WHEN STARTING TO DRIVE TRANSMISSION SLIPS, FEELS LIKE VAN HAS BEEN HIT FROM BEHIND. DEALER REPLACED VALVE BODY,DUE TO A KNOWN PRODUCT PROBLEM.VAN ONCE AGAIN HAD SAME TROBLE IN MAY 2000, DEALER CHANGED VALVE BODY, ALSO STATEDE BECAUSED OF A KNOWN PRODUCT CONCERN. BUT TJIS TIME I HAD TO PAY $672.06. THEIR CUSTOMER SERVICE WAS OF NO HELP. EVEN THOUGH THEIR MECHANIC STATED THAT GM HAD SAID TO REPLOACE THE VALVE BODY THE SECOND TIME WITH A NEW DESIGN, SINCE THE FIRST REPLACEMENT WAS DEFECTIVE. *AK
VEHICLE WOULD BE RUNNING ROUGH & WOULD SHAKE. TOOK VEHICLE TO DEALERSHIP & WAS INFORMED BY MECHANIC THE JETS ON ENGINE WERE PLUGGED UP. THIS WAS CAUSED BY THE GASOLINE & COULD BE REPAIRED.
TRIM ON TWO REAR BENCH SEATS FELL OFF WHICH WAS REPLACED. *YC
4 OF 6 CYLINDERS LESS THAN 150 PSI. ONLY CHECK ENGINE LIGHT CAME ON. DEALER , CHEVROLET, AND EXTENDED WARRANTY SERVICE REFUSE TO HONOR ANY DISCOUNTED OR WARRANTY ON THIS ENGINE THAT WAS MAINTAINED THROUGH THE DEALERSHIP.
FUEL TANK AND GAUGE FAILED.
ENGINE VALVE SEAL FAILED CAUSING VALVES TO STICK WHICH RESULTED IN EXCESSIVE ENGINE NOISE. *YC
Official recalls
403V159000 · Visibility:windshield Wiper/washer
Apr 28, 2003
ON CERTAIN MINIVANS, PICKUP TRUCKS, AND SPORT UTILITY VEHICLES WITH CERTAIN MODEL-ENGINE COMBINATIONS, THE WINDSHIELD WIPER MOTOR MAY FAIL DUE TO CRACKED SOLDER JOINTS ON THE CONTROLLER CIRCUIT BOARD. THE WINDSHIELD WIPERS COULD WORK INTERMITTENTLY OR NOT AT ALL.
Consequence & remedy
Consequence: IF THIS WERE TO OCCUR DURING BAD WEATHER, DRIVER VISIBILITY WOULD BE REDUCED, WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE WIPER MOTOR CIRCUIT BOARD AND COVER. OWNER NOTIFICATION BEGAN ON JUNE 19, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR OLDSMOBILE AT 1-800-442-6537.
01V123000 · Seat Belts:front:warning Light/devices
Apr 10, 2001
VEHICLE DESCRIPTION: MINI VANS. SOME OF THESE VEHICLES FAIL TO COMPLY WITH REQUIREMENTS OF FMVSS NO. 208, "OCCUPANT CRASH PROTECTION." THE "FASTEN SAFETY-BELT" AUDIBLE WARNING OCCASIONALLY MAY NOT COME ON OR MAY TERMINATE IN LESS THAN FOUR SECONDS AS REQUIRED BY THE STANDARD.
Consequence & remedy
Consequence: THIS DOES NOT MEET THE REQUIREMENTS OF THE STANDARD.
Remedy: DEALERS WILL INSTALL A NEW ALARM MODULE. OWNER NOTIFICATION BEGAN JUNE 27, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020 OR GMC AT 1-800-462-8782.
99V009000 · Child Seat
Jan 20, 1999
VEHICLE DESCRIPTION: MINI VANS EQUIPPED WITH INTEGRATED DUAL CHILD SEATS. SOME OF THESE VEHICLES MAY BE MISSING A SEAT BELT RETRACTOR CLUTCH SPRING AND/OR PAWL SPRING IN THE CHILD SEAT. IF THE CLUTCH SPRING WAS MISSING, THE SEAT BELT WOULD LOCK IN THE RETRACTED POSITION AND COULD NOT BE USED. IF THE PAWL SPRING WAS MISSING, THE SEAT BELT RESTRAINT WOULD CONTINUALLY PLAY OUT AND WOULD NOT LOCK.
Consequence & remedy
Consequence: THESE CONDITIONS COULD INCREASE THE OCCUPANT'S RISK OF INJURY IN THE EVENT OF A VEHICLE CRASH.
Remedy: DEALERS WILL INSPECT THE SEAT BELTS ON THE CHILD SEATS, AND IF NECESSARY, REPLACE THE CHILD SEAT.
97V057000 · Seat Belts:rear/other
Apr 8, 1997
THE OUTBOARD SAFETY BELT WEBBING ON THE RIGHT-HAND REAR BUCKET SEAT CAN SEPARATE DURING A VEHICLE CRASH.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, THE VEHICLE OCCUPANT WOULD NOT BE PROPERLY RESTRAINED AND PERSONAL INJURY COULD RESULT.
Remedy: DEALERS WILL INSTALL A PROTECTOR ON THE REAR SEAT CUSHION FRAME.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1EA02006 · Windshield Wiper Failure
Opened May 31, 2002 · Closed Jul 23, 2003
Status: closed (inferred from source dates) · Visibility:windshield Wiper/washer:motor
AS A RESULT OF THIS, AND THE PRECEDINGINVESTIGATION, RQ99-003, GM HAS EXPANDED THE POPULATION OF SAFETY RECALL 98V-150 (REPLACEMENT OF THE WINDSHIELD WIPER CONTROL MODULE) TO INCLUDE AN ADDITIONAL 1.77 MILLION VEHICLES.INCLUDED ARE VARIOUS 1994-1997 MY M/L VANS, S/T TRUCKS AND SUVS, & C/K TRUCKS AND SUVS.SEE ATTACHED TECHNICAL REPORT FOR DETAILS.
Additional source detail variants (2)
Visibility:windshield Wiper/washer:motor
AS A RESULT OF THIS, AND THE PRECEDINGINVESTIGATION, RQ99-003, GM HAS EXPANDED THE POPULATION OF SAFETY RECALL 98V-150 (REPLACEMENT OF THE WINDSHIELD WIPER CONTROL MODULE) TO INCLUDE AN ADDITIONAL 1.77 MILLION VEHICLES.INCLUDED ARE VARIOUS 1994-1997 MY M/L VANS, S/T TRUCKS AND SUVS, & C/K TRUCKS AND SUVS.SEE ATTACHED TECHNICAL REPORT FOR DETAILS.
Visibility:windshield Wiper/washer:motor
AS A RESULT OF THIS, AND THE PRECEDINGINVESTIGATION, RQ99-003, GM HAS EXPANDED THE POPULATION OF SAFETY RECALL 98V-150 (REPLACEMENT OF THE WINDSHIELD WIPER CONTROL MODULE) TO INCLUDE AN ADDITIONAL 1.77 MILLION VEHICLES.INCLUDED ARE VARIOUS 1994-1997 MY M/L VANS, S/T TRUCKS AND SUVS, & C/K TRUCKS AND SUVS.SEE ATTACHED TECHNICAL REPORT FOR DETAILS.