IllustrationCOOLANT LINE RUBBED UP AGAINST THE ENGINE BLOCK AND WORE A HOLE IN IT. THE NEW LINE HAS BEEN REDESIGNED TO AVOID THE CONTACT. THE WINDSHIELD WIPERS INTERMITTENTLY STOPS AND HAS HAPPENED AT LEAST 15 TIMES. THE FUEL GAUGE STOPPED WORKING, READS FULL FOR 20 MINUTES THEN SLOWLY COMES DOWN, DEALER REPLACED THE TANK GAUGE
1997 Chevrolet Astro
Owner reports · Recalls · Investigations
More warning signs than most Astro years
Owner complaints for the 1997 Chevrolet Astro are substantially higher than the model-year median of 69.
About this comparison →How this year compares
Owner complaints by model year
Compare all Astro years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 46 of 360 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Service Brakes, Hydraulic. Review the 64 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Visibility. Review the 62 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 53 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
23 crash reports7 fire reports16 injury reports
Engine And Engine Cooling complaints
37 reportsCHRONIC ENGINE KNOCK THAT IS NORMAL. *AK
CONSUMER STATES WHILE DRIVING, ELECTRICAL SYSTEM FAILED AND VEHICLE CEASED AS BATTERY RAN DOWN, REPLACED ALTERNATOR AND IGNITION COIL AND WIRE. *JB
WHILE DRIVING BATTERY LIGHT CAME ON. PROBLEM WAS DUE TO 'BELT TENSIONER BREAKING. CONSUMER WAS DRIVING AT APPROXIMATELY 10 - 15 MPH. PLEASE PROVIDE ANY ADDITIONAL INFORMATION. *AK
DRIVER'S SIDE REAR WINDOW WILL NOT STAY OPEN, CLIPS THAT SHOULD HOLD IT UP ARE BLOCKED BY MATERIAL, WINDOW SLAMS SHUT WHEN GOING OVER A BUMP. TRANSMISSION WENT OUT AT 45000 MILES. *AK OIL LEAK, DEALER ORDERED AXLE OUTPUT SHAFT SEAL AND CRANKSHAFT SENSOR. ELECTRIC FUEL PUMP REPLACED DUE TO VEHICLE CUTTING AND WOULD CRANK, BUT …
Read full complaint
DRIVER'S SIDE REAR WINDOW WILL NOT STAY OPEN, CLIPS THAT SHOULD HOLD IT UP ARE BLOCKED BY MATERIAL, WINDOW SLAMS SHUT WHEN GOING OVER A BUMP. TRANSMISSION WENT OUT AT 45000 MILES. *AK OIL LEAK, DEALER ORDERED AXLE OUTPUT SHAFT SEAL AND CRANKSHAFT SENSOR. ELECTRIC FUEL PUMP REPLACED DUE TO VEHICLE CUTTING AND WOULD CRANK, BUT WOULD NOT STAR. OIL PRESSURE GAUGE ERRATIC, DEALER REPLACED OIL PRESSURE SENDER. FRONT BRAKES AND PADS WERE REPLACED, ROTORS WERE RESURFACED. CONSUMER STATES THERE IS PLAY IN THE STEERING, DEALER REPLACED BOTH IDLER ARMS AND RESET TOE IN. POWER DOOR LOCKS INOPERABLE, DEALER REPLACED POWER DOOR LOCK SWITCH. POWER WINDOW INOPERABLE, DEALER REPLACED POWER WINDOW SWITCH. SHIFTER WAS HARD TO MOVE, DEALER REPLACED SHIFT CABLE. GAS PEDAL BINDS AT TIMES, DEALER ORDERED THROTTLE CABLE AND REPLACED ACCELERATOR CABLE. DRIVER SETA SEEMS LOOSE WHEN BRAKING, DEALER ORDERED DRIVER SEAT TRACK ASSEMBLY AND REPLACED DRIVER SEAT ADJUSTER. PCM FUSE KEPT BLOWING OUT, DEALER REMOVED ENGINE COVER AND TRACED WIRE HARNESS, REPAIRED SHORTED HARNESS AT THE REAR OF THE TRANSMISSION. *SLC
WHILE DRIVING ABOUT 70 MPH ENGINE WAS MAKING NOISE. POWER STEERING AND POWER BRAKES WERE AFFECTED.TECHNICIAN SAID THAT PROBLEM WAS WITH IDLER PULLEY AND TENSION PULLEY.*AK AFTER EXPLOSION LIKE SOUND UNDER THE HOOD, THE TENSIONER PULLEY DISINTEGRATED CAUSING LOSS OF POWER STEERING AND POWER BRAKES. *YH
EVERY THOUSAND MILES, SERVICE LIGHT COMES ON AND VEHICLE RUNS VERY ROUGH, JETS HAVE BEEN CLEANED 4 TIMES ON THE ENGINE. DEALER WAS BLAMING IT ON CHEVRON GAS. CHEVRON HAS SENT A LETTER STATING IT WAS THE POPPET VALVE. DELAER CHANGED ALL 6 POPPET VALVES AND CLEANED THE FUEL INTAKE SYSTEM, AND IT WORKED FOR 5 MONTHS. PROBLEM HA…
Read full complaint
EVERY THOUSAND MILES, SERVICE LIGHT COMES ON AND VEHICLE RUNS VERY ROUGH, JETS HAVE BEEN CLEANED 4 TIMES ON THE ENGINE. DEALER WAS BLAMING IT ON CHEVRON GAS. CHEVRON HAS SENT A LETTER STATING IT WAS THE POPPET VALVE. DELAER CHANGED ALL 6 POPPET VALVES AND CLEANED THE FUEL INTAKE SYSTEM, AND IT WORKED FOR 5 MONTHS. PROBLEM HAS COME UP AGAIN. *SLC
OCCURANCE 1) ENGINE STOPPED WITHOUT WARNING WHILE APPROCAHING AN INTERSECTION. THE RESULTING LOSS OF POWER CAUSED A SEVERE CONTROL PROBLEM WITH THE VAN. THE REASON FOR THE FAILURE WAS THE FUEL GUAGE READ 3/4 AND THE VAN RAN OUT OF FUEL. OCCURANCE 2) THE FUEL GUAGE HAS TOTALLY STOPPED FUNCTIONING, AFTER TOPPING OFF AND PROCEEDIN…
Read full complaint
OCCURANCE 1) ENGINE STOPPED WITHOUT WARNING WHILE APPROCAHING AN INTERSECTION. THE RESULTING LOSS OF POWER CAUSED A SEVERE CONTROL PROBLEM WITH THE VAN. THE REASON FOR THE FAILURE WAS THE FUEL GUAGE READ 3/4 AND THE VAN RAN OUT OF FUEL. OCCURANCE 2) THE FUEL GUAGE HAS TOTALLY STOPPED FUNCTIONING, AFTER TOPPING OFF AND PROCEEDING ONTO HIGHWAY I DROVE FOR 1/2 HOUR AT 65, A SUDDEN SLAM OCCURED 2 OR THREE TIMES, APPEARED TO BE THE ENGINE CUTTING IN AND OUT, SLOWED TO 55 AND CONTINUED FOR 150 MILES WITHOUT FURTHER INCIDENT. OCCURANCE 3) VEHICLE HAS NO FUEL GUAGE, I AM TOLD IT'S OUT OF WARRANTY, EVEN IF FULL THE VEHICLE SEEM TO LOOSE CONTROL MOMENTARALLY, AS IF TO LOOSE POWER.
VEHICLE IS LEAKING ANTI FREEZE BETWEEN THE HEAD GASKET AND THE ENGINE DUE TO DEFECTIVE CASTING.*AK TIRES WERE SHOWING HEAL AND TOE WEARING. DEALER OFFERED TO PRORATED TIRES BUT CUSTOMER DECLINED. *YH
FAST ENGINE IDLE, INTERMITTANT, HIGH AMBIENT TEMP. NO "CHK ENG" OR "STORED CODES" VAN WILL INTERMITTANTLY ACCELLERATE TO 45 TO 62 MPH WITH NO PEDAL. SEVERAL NEAR ACCIDENTS. FREQUENTLY MUST USE BRAKES OR LOW GEAR TO HOLD 45-55 MPH DEALERS MAKE EXCUSE OVER WARRANTY WHILE ADMITING IT IS A SAFETY PROBLEM, BUT NO REAL INTEREST FROM S…
Read full complaint
FAST ENGINE IDLE, INTERMITTANT, HIGH AMBIENT TEMP. NO "CHK ENG" OR "STORED CODES" VAN WILL INTERMITTANTLY ACCELLERATE TO 45 TO 62 MPH WITH NO PEDAL. SEVERAL NEAR ACCIDENTS. FREQUENTLY MUST USE BRAKES OR LOW GEAR TO HOLD 45-55 MPH DEALERS MAKE EXCUSE OVER WARRANTY WHILE ADMITING IT IS A SAFETY PROBLEM, BUT NO REAL INTEREST FROM SEVERAL LEVELS OF MGMT. 3 YR PROBLEM, DEALER SERV HAS ONLY SEEN MALFUNCTION ONCE WITH COMPUTER TOOL PLUGED IN BUT SAID "NO PROBLEM INDICATED" WHILE SEEING THE FAST IDLE. CAN I GET AN INCIDENT NUMBER TO TAKE TO THE DEALER?
Official recalls
403V159000 · Visibility:windshield Wiper/washer
Apr 28, 2003
ON CERTAIN MINIVANS, PICKUP TRUCKS, AND SPORT UTILITY VEHICLES WITH CERTAIN MODEL-ENGINE COMBINATIONS, THE WINDSHIELD WIPER MOTOR MAY FAIL DUE TO CRACKED SOLDER JOINTS ON THE CONTROLLER CIRCUIT BOARD. THE WINDSHIELD WIPERS COULD WORK INTERMITTENTLY OR NOT AT ALL.
Consequence & remedy
Consequence: IF THIS WERE TO OCCUR DURING BAD WEATHER, DRIVER VISIBILITY WOULD BE REDUCED, WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE WIPER MOTOR CIRCUIT BOARD AND COVER. OWNER NOTIFICATION BEGAN ON JUNE 19, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR OLDSMOBILE AT 1-800-442-6537.
01V123000 · Seat Belts:front:warning Light/devices
Apr 10, 2001
VEHICLE DESCRIPTION: MINI VANS. SOME OF THESE VEHICLES FAIL TO COMPLY WITH REQUIREMENTS OF FMVSS NO. 208, "OCCUPANT CRASH PROTECTION." THE "FASTEN SAFETY-BELT" AUDIBLE WARNING OCCASIONALLY MAY NOT COME ON OR MAY TERMINATE IN LESS THAN FOUR SECONDS AS REQUIRED BY THE STANDARD.
Consequence & remedy
Consequence: THIS DOES NOT MEET THE REQUIREMENTS OF THE STANDARD.
Remedy: DEALERS WILL INSTALL A NEW ALARM MODULE. OWNER NOTIFICATION BEGAN JUNE 27, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020 OR GMC AT 1-800-462-8782.
99V009000 · Child Seat
Jan 20, 1999
VEHICLE DESCRIPTION: MINI VANS EQUIPPED WITH INTEGRATED DUAL CHILD SEATS. SOME OF THESE VEHICLES MAY BE MISSING A SEAT BELT RETRACTOR CLUTCH SPRING AND/OR PAWL SPRING IN THE CHILD SEAT. IF THE CLUTCH SPRING WAS MISSING, THE SEAT BELT WOULD LOCK IN THE RETRACTED POSITION AND COULD NOT BE USED. IF THE PAWL SPRING WAS MISSING, THE SEAT BELT RESTRAINT WOULD CONTINUALLY PLAY OUT AND WOULD NOT LOCK.
Consequence & remedy
Consequence: THESE CONDITIONS COULD INCREASE THE OCCUPANT'S RISK OF INJURY IN THE EVENT OF A VEHICLE CRASH.
Remedy: DEALERS WILL INSPECT THE SEAT BELTS ON THE CHILD SEATS, AND IF NECESSARY, REPLACE THE CHILD SEAT.
97V057000 · Seat Belts:rear/other
Apr 8, 1997
THE OUTBOARD SAFETY BELT WEBBING ON THE RIGHT-HAND REAR BUCKET SEAT CAN SEPARATE DURING A VEHICLE CRASH.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, THE VEHICLE OCCUPANT WOULD NOT BE PROPERLY RESTRAINED AND PERSONAL INJURY COULD RESULT.
Remedy: DEALERS WILL INSTALL A PROTECTOR ON THE REAR SEAT CUSHION FRAME.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1EA02006 · Windshield Wiper Failure
Opened May 31, 2002 · Closed Jul 23, 2003
Status: closed (inferred from source dates) · Visibility:windshield Wiper/washer:motor
AS A RESULT OF THIS, AND THE PRECEDINGINVESTIGATION, RQ99-003, GM HAS EXPANDED THE POPULATION OF SAFETY RECALL 98V-150 (REPLACEMENT OF THE WINDSHIELD WIPER CONTROL MODULE) TO INCLUDE AN ADDITIONAL 1.77 MILLION VEHICLES.INCLUDED ARE VARIOUS 1994-1997 MY M/L VANS, S/T TRUCKS AND SUVS, & C/K TRUCKS AND SUVS.SEE ATTACHED TECHNICAL REPORT FOR DETAILS.
Additional source detail variants (2)
Visibility:windshield Wiper/washer:motor
AS A RESULT OF THIS, AND THE PRECEDINGINVESTIGATION, RQ99-003, GM HAS EXPANDED THE POPULATION OF SAFETY RECALL 98V-150 (REPLACEMENT OF THE WINDSHIELD WIPER CONTROL MODULE) TO INCLUDE AN ADDITIONAL 1.77 MILLION VEHICLES.INCLUDED ARE VARIOUS 1994-1997 MY M/L VANS, S/T TRUCKS AND SUVS, & C/K TRUCKS AND SUVS.SEE ATTACHED TECHNICAL REPORT FOR DETAILS.
Visibility:windshield Wiper/washer:motor
AS A RESULT OF THIS, AND THE PRECEDINGINVESTIGATION, RQ99-003, GM HAS EXPANDED THE POPULATION OF SAFETY RECALL 98V-150 (REPLACEMENT OF THE WINDSHIELD WIPER CONTROL MODULE) TO INCLUDE AN ADDITIONAL 1.77 MILLION VEHICLES.INCLUDED ARE VARIOUS 1994-1997 MY M/L VANS, S/T TRUCKS AND SUVS, & C/K TRUCKS AND SUVS.SEE ATTACHED TECHNICAL REPORT FOR DETAILS.