IllustrationTHE CONSUMER'S 1987 AND 1997 CHEVROLET ASTRO VANS HAD FAULTY ENGINE'S.***NO ANSWER REQUIRED***. *MR THE POWER WINDOWS FAILED, THE DRIVER'S SEAT CAME LOOSE, THE REAR DOOR HATCH BROKE AND THE TRANSMISSION FAILED DUE TO THE TORQUE CONVERTER SLIPPING AND VALVE BODY WEAR (90000 MILES). *NM
1997 Chevrolet Astro
Owner reports · Recalls · Investigations
More warning signs than most Astro years
Owner complaints for the 1997 Chevrolet Astro are substantially higher than the model-year median of 69.
About this comparison →How this year compares
Owner complaints by model year
Compare all Astro years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 46 of 360 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Service Brakes, Hydraulic. Review the 64 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Visibility. Review the 62 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 53 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
23 crash reports7 fire reports16 injury reports
Engine And Engine Cooling complaints
37 reportsWHILE DRIVING 70 MPH VEHICLE COMMENCED TO LOSE SPEED. VEHICLE WOULD NOT ACCELERATE MORE THEN 20-25 MPH. CONSUMER WAS ABLE TO DRIVE THE VEHICLE TO THE DEALER, WHO INFORMED CONSUMER THAT THE OXYGEN SENSOR/ EGR VALVE, AND THE CATALYTIC CONVERTER MALFUNCTIONED. *AK THE CONSUMER STATED THAT THE OXYGEN SENSOR/ EGR VALVE, AND THE …
Read full complaint
WHILE DRIVING 70 MPH VEHICLE COMMENCED TO LOSE SPEED. VEHICLE WOULD NOT ACCELERATE MORE THEN 20-25 MPH. CONSUMER WAS ABLE TO DRIVE THE VEHICLE TO THE DEALER, WHO INFORMED CONSUMER THAT THE OXYGEN SENSOR/ EGR VALVE, AND THE CATALYTIC CONVERTER MALFUNCTIONED. *AK THE CONSUMER STATED THAT THE OXYGEN SENSOR/ EGR VALVE, AND THE CATALYTIC CONVERTER MELTED DOWN. THE ENGINE LIGHT WAS ON. *TC
TENSIONER BELT ON MY 1997 CHEVROLET ASTRO VAN CONTINUES TO MAKE CHIRPING SOUNDS ESPECIALLY AFTER IT RAINS. TENSIONER BELT HAS BEEN CHANGED 4 TIMES AND ALLEVIATES THE PROBLEM TEMPORARILY.*AK
MY PROBLEM IS THAT I HAVE A 1997 CHEVROLET ASTRO VAN WITH 63,005 MILES ON IT AND THE MAIN BEARINGS FAILED. I TOOK IT MY LOCAL DEALER FOR A OIL PRESSURE DROP, AND THEY INFORMED ME THAT THE BEARINGS WERE BAD. AFTER SOME INVESTIGATING ON THE INTERNET I HAVE FOUND THAT CHEVROLET MAY HAVE BEEN AWARE OF A PROBLEM WITH THE BEARINGS, H…
Read full complaint
MY PROBLEM IS THAT I HAVE A 1997 CHEVROLET ASTRO VAN WITH 63,005 MILES ON IT AND THE MAIN BEARINGS FAILED. I TOOK IT MY LOCAL DEALER FOR A OIL PRESSURE DROP, AND THEY INFORMED ME THAT THE BEARINGS WERE BAD. AFTER SOME INVESTIGATING ON THE INTERNET I HAVE FOUND THAT CHEVROLET MAY HAVE BEEN AWARE OF A PROBLEM WITH THE BEARINGS, HAVING ISSUED A TSB[87-61-22]. NOW THAT A NEW ENGINE HAS BEEN INSTALLED AT MY COST OF $4600, I AM LOOKING FOR SOME HELP OR INFORMATION ON HOW TO RECOUP SOME OR ALL OF THE COST. I HAVE HAD ALL POSSIBLE MAINTENANCE DONE AND ALL RECALL WORK DONE SINCE 1997. CHEVROLET HAS INFORMED ME THAT SOME RECALL WORK WAS NOT DONE, BUT MY DEALER RECORDS SHOW IT HAS BEEN DONE.*AK
*OHIO TRAFFIC CRASH REPORT* CONSUMER SMELLED SMOKE AND IMMEDIATELY PULLED TO THE SIDE. THE ENGINE HAD CAUGHT ON FIRE WHICH RESULTED IN DAMAGE TO THE WINDSHIELD AND ENGINE. *JG *JB
WHILE DRIVING AT ANY SPEED CATALYTIC CONVERTER WILL RATTLE MAKING A LOUD NOISE. DEALER NOTIFIED.*AK
I HAVE HAD A NUMBER OF PROBLEMS WITH THIS VEHICLE: BOTH THE LEFT AND RIGHT POWER WINDOR MOTORS; REPLACE THE KEY REMOTE, BOTH IDLER ARMS,FRONT BRAKE PAD AT 37,000 MILES, SERPENTIME BELT, POWER STEERING PUMP - REPLACED TWICE, HAD TO FIX OIL COOLER LINES TWICE, REPLACED DISTRIBUTOR/ROTOR; REPLACED LOWER GASKET DUE TO INTAKE MANIFOL…
Read full complaint
I HAVE HAD A NUMBER OF PROBLEMS WITH THIS VEHICLE: BOTH THE LEFT AND RIGHT POWER WINDOR MOTORS; REPLACE THE KEY REMOTE, BOTH IDLER ARMS,FRONT BRAKE PAD AT 37,000 MILES, SERPENTIME BELT, POWER STEERING PUMP - REPLACED TWICE, HAD TO FIX OIL COOLER LINES TWICE, REPLACED DISTRIBUTOR/ROTOR; REPLACED LOWER GASKET DUE TO INTAKE MANIFOLD LEAK, AND FUEL PUMP MODUAL. ALL OF THIS WAS DONE BEFORE MY CAR HAD 57,000 MILES. THE DEALER HAS BEEN VERY FAIR AND REPAIRED AT LOW OR NOW COST. I HAVE HAD TWO TRIPS SHORTENED DUE TO BREAKDOWNS AND HAVE SPENT OVER $1,500 ON REPAIRS NOT COVERED UNDER WARRENTY OR BY THE DEALER. THIS IS IN ADDITION TO NORMAL MAINTENANCE (OIL AND FILTER,FOUR NEW TIRES,AND TRANSMISSION FLUID AND FILTER). I AM CONCERNED AS TO "WHAT IS NEXT" AND WHEN THE DEALER WHEN NO LONGER BE ABLE TO FIX THESE PROBLEMS AT LOW COST TO ME.*AK
VEHICLE KEEPS DYING ON ROAD. MECHANIC CANNOT FIND THE CAUSE. ALSO, SOMETIMES VEHICLE DOES NOT START AT ALL. CONSUMER CAN BE RIDING ALONG AND VEHICLE CUTS OFF, CAUSING CONSUMER TO SHIFT NEUTRAL OR DRIFT TO THE SIDE, AND GET IT RESTARTED.*AK
CONSUMER STATED WATER WAS LEAKING FROM THE REAR DOOR. (CONSUMER NO LONGER OWNS VEHICLE)*TT
PLEASE SEND ME FRONTAL IMPACT STATS AND SIDE IMPACT STATS IF AVAILABLE--HOW DOES THIS CAR RATE????NO AFETY DEFECT LISTED. *AK
Official recalls
403V159000 · Visibility:windshield Wiper/washer
Apr 28, 2003
ON CERTAIN MINIVANS, PICKUP TRUCKS, AND SPORT UTILITY VEHICLES WITH CERTAIN MODEL-ENGINE COMBINATIONS, THE WINDSHIELD WIPER MOTOR MAY FAIL DUE TO CRACKED SOLDER JOINTS ON THE CONTROLLER CIRCUIT BOARD. THE WINDSHIELD WIPERS COULD WORK INTERMITTENTLY OR NOT AT ALL.
Consequence & remedy
Consequence: IF THIS WERE TO OCCUR DURING BAD WEATHER, DRIVER VISIBILITY WOULD BE REDUCED, WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE WIPER MOTOR CIRCUIT BOARD AND COVER. OWNER NOTIFICATION BEGAN ON JUNE 19, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR OLDSMOBILE AT 1-800-442-6537.
01V123000 · Seat Belts:front:warning Light/devices
Apr 10, 2001
VEHICLE DESCRIPTION: MINI VANS. SOME OF THESE VEHICLES FAIL TO COMPLY WITH REQUIREMENTS OF FMVSS NO. 208, "OCCUPANT CRASH PROTECTION." THE "FASTEN SAFETY-BELT" AUDIBLE WARNING OCCASIONALLY MAY NOT COME ON OR MAY TERMINATE IN LESS THAN FOUR SECONDS AS REQUIRED BY THE STANDARD.
Consequence & remedy
Consequence: THIS DOES NOT MEET THE REQUIREMENTS OF THE STANDARD.
Remedy: DEALERS WILL INSTALL A NEW ALARM MODULE. OWNER NOTIFICATION BEGAN JUNE 27, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020 OR GMC AT 1-800-462-8782.
99V009000 · Child Seat
Jan 20, 1999
VEHICLE DESCRIPTION: MINI VANS EQUIPPED WITH INTEGRATED DUAL CHILD SEATS. SOME OF THESE VEHICLES MAY BE MISSING A SEAT BELT RETRACTOR CLUTCH SPRING AND/OR PAWL SPRING IN THE CHILD SEAT. IF THE CLUTCH SPRING WAS MISSING, THE SEAT BELT WOULD LOCK IN THE RETRACTED POSITION AND COULD NOT BE USED. IF THE PAWL SPRING WAS MISSING, THE SEAT BELT RESTRAINT WOULD CONTINUALLY PLAY OUT AND WOULD NOT LOCK.
Consequence & remedy
Consequence: THESE CONDITIONS COULD INCREASE THE OCCUPANT'S RISK OF INJURY IN THE EVENT OF A VEHICLE CRASH.
Remedy: DEALERS WILL INSPECT THE SEAT BELTS ON THE CHILD SEATS, AND IF NECESSARY, REPLACE THE CHILD SEAT.
97V057000 · Seat Belts:rear/other
Apr 8, 1997
THE OUTBOARD SAFETY BELT WEBBING ON THE RIGHT-HAND REAR BUCKET SEAT CAN SEPARATE DURING A VEHICLE CRASH.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, THE VEHICLE OCCUPANT WOULD NOT BE PROPERLY RESTRAINED AND PERSONAL INJURY COULD RESULT.
Remedy: DEALERS WILL INSTALL A PROTECTOR ON THE REAR SEAT CUSHION FRAME.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1EA02006 · Windshield Wiper Failure
Opened May 31, 2002 · Closed Jul 23, 2003
Status: closed (inferred from source dates) · Visibility:windshield Wiper/washer:motor
AS A RESULT OF THIS, AND THE PRECEDINGINVESTIGATION, RQ99-003, GM HAS EXPANDED THE POPULATION OF SAFETY RECALL 98V-150 (REPLACEMENT OF THE WINDSHIELD WIPER CONTROL MODULE) TO INCLUDE AN ADDITIONAL 1.77 MILLION VEHICLES.INCLUDED ARE VARIOUS 1994-1997 MY M/L VANS, S/T TRUCKS AND SUVS, & C/K TRUCKS AND SUVS.SEE ATTACHED TECHNICAL REPORT FOR DETAILS.
Additional source detail variants (2)
Visibility:windshield Wiper/washer:motor
AS A RESULT OF THIS, AND THE PRECEDINGINVESTIGATION, RQ99-003, GM HAS EXPANDED THE POPULATION OF SAFETY RECALL 98V-150 (REPLACEMENT OF THE WINDSHIELD WIPER CONTROL MODULE) TO INCLUDE AN ADDITIONAL 1.77 MILLION VEHICLES.INCLUDED ARE VARIOUS 1994-1997 MY M/L VANS, S/T TRUCKS AND SUVS, & C/K TRUCKS AND SUVS.SEE ATTACHED TECHNICAL REPORT FOR DETAILS.
Visibility:windshield Wiper/washer:motor
AS A RESULT OF THIS, AND THE PRECEDINGINVESTIGATION, RQ99-003, GM HAS EXPANDED THE POPULATION OF SAFETY RECALL 98V-150 (REPLACEMENT OF THE WINDSHIELD WIPER CONTROL MODULE) TO INCLUDE AN ADDITIONAL 1.77 MILLION VEHICLES.INCLUDED ARE VARIOUS 1994-1997 MY M/L VANS, S/T TRUCKS AND SUVS, & C/K TRUCKS AND SUVS.SEE ATTACHED TECHNICAL REPORT FOR DETAILS.