IllustrationSTARTED TO CLOSE SLIDING DOOR; REAR PORTION OF DOOR FELL OFF ONTO THE GROUND. HANDLE STILL IN HAND. TOOK TO DEALER & HAD IT REPAIRED. SPECTOR ROLLER HAD CAME OFF. *AK
1995 Chevrolet Astro
Owner reports · Recalls · Investigations
More warning signs than most Astro years
Owner complaints for the 1995 Chevrolet Astro are substantially higher than the model-year median of 69.
About this comparison →How this year compares
Owner complaints by model year
Compare all Astro years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 32 of 446 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Service Brakes, Hydraulic. Review the 105 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Visibility. Review the 104 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Suspension. Review the 75 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
51 crash reports6 fire reports26 injury reports
What owners actually said
446 reportsTHE AIR BAG DID NOT INFLATE DURING FRONT END COLLISION, RESULTING I N INJURY.
STEERING: DRIVING APPROXIMATELY 65MPH APPROACHING TO AN EXIT, ATTEMPTED TO TURN THE STEERING WHEEL WAS VERY HARD TO TURN. APPLIED BRAKES, THERE WERE NO BRAKES AND COMPLETE LOSS OF STEERING. *AK
WHEN DEPRESSING THE BRAKE PEDAL THE VEHICLE WILL CONTINUE TO MOVE, RESULTING IN EXTENDED STOPPING DISTANCE AND BRAKES FADING AWAY. CONSUMER HAS CONTACTED THE DEALER, DEALER HAS REPLACED THE BRAKE SENSORS/CALIPERS ROTORS. CONSUMER STILL HAVING PROBLEM. *AK
VEHICLE WAS INVOLVED IN A CRASH GOING ABOUT 20 MPH, HIT A CEMENT POLE HEAD-ON AND THE AIR BAGS DID NOT DEPLOY. THE WHOLE FRONT END OF VEHICLE WAS DAMAGED. DRIVER OF VEHICLE WAS KILLED, CAUSE OF DEATH WAS DETERMINED AS A HEART ATTACK. *AK
ON LONG TRIPS OVER, 2-3 HOURS, ENGINE LIGHT COMES ON AND CAUSES ERRATIC ENGINE BUCKING AND WILL NOT COME OUT OF LOWER GEARS. *AK
ANOTHER VEHICLE RAN STOP SIGN, ASTRO HIT OTHER VEHICLE BROADSIDE AT 50 MPH; THE FRONT OF ASTRO WAS DAMAGED; DRIVER'S AIR BAG DID NOT DEPLOY. DRIVER WAS INJURED. *AK
RIGHT FRONT BRACKET BROKE IN BUMPER, CAUSING IT TO CRACK ALL THE WAY ACROSS TO THE LICENSE PLATE.
ON NORMAL ROAD CONDITIONS WHEN BRAKING VEHICLE PULLS TO THE RIGHT. VEHICLE HAS BEEN SERVICED 9 TIMES FOR BRAKE PROBLEMS. ON 05/24/95, SANDED PADS, LUBED CALIPER SLIDE PINS. ON 07/17/95, COULD NOT DUPLICATE PROBLEM; 08/28/95, ROTATED TIRES, AND ON 08/31/95, REPLACED PADS, CLEANED AND LUBED CALIPER SLIDE PINS. *AK
THE REAR HATCHBACK HYDRAULIC RODS ARE COMPLETELY INOPERATIVE AND THE HATCH FELL ON THE HEAD OF THE DRIVER SUDDENLY. *AK
Official recalls
303V159000 · Visibility:windshield Wiper/washer
Apr 28, 2003
ON CERTAIN MINIVANS, PICKUP TRUCKS, AND SPORT UTILITY VEHICLES WITH CERTAIN MODEL-ENGINE COMBINATIONS, THE WINDSHIELD WIPER MOTOR MAY FAIL DUE TO CRACKED SOLDER JOINTS ON THE CONTROLLER CIRCUIT BOARD. THE WINDSHIELD WIPERS COULD WORK INTERMITTENTLY OR NOT AT ALL.
Consequence & remedy
Consequence: IF THIS WERE TO OCCUR DURING BAD WEATHER, DRIVER VISIBILITY WOULD BE REDUCED, WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE WIPER MOTOR CIRCUIT BOARD AND COVER. OWNER NOTIFICATION BEGAN ON JUNE 19, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR OLDSMOBILE AT 1-800-442-6537.
95V175000 · Suspension:front:control Arm:lower Arm
Sep 13, 1995
THESE VEHICLES WERE ASSEMBLED WITH THE LEFT-HAND LOWER CONTROL ARM-TO-FRAME REAR NUT NOT TIGHTENED TO THE SPECIFIED TORQUE.
Consequence & remedy
Consequence: LOW TORQUE CAN ALLOW THE ATTACHMENT BOLT TO LOOSEN AND SUBSEQUENTLY FATIGUE AND BREAK. THIS CAN RESULT IN SEPARATION OF THE LEFT-HAND CONTROL ARM FROM THE FRAME INCREASING THE POTENTIAL FOR A VEHICLE ACCIDENT.
Remedy: DEALERS WILL TIGHTEN THE LEFT-HAND LOWER CONTROL ARM-TO- FRAME REAR NUT TO THE PROPER TORQUE SPECIFICATION.
94V188000 · Fuel System, Gasoline:storage:tank Assembly:mounting
Oct 4, 1994
THE FUEL LINES ATTACHED TO THE FUEL TANK WERE NOT PROPERLY TIGHTENED.
Consequence & remedy
Consequence: THESE FUEL LINES CAN LOOSEN TO THE POINT OF ALLOWING FUEL TO LEAK FROM THE LINES RESULTING IN A VEHICLE FIRE.
Remedy: DEALERS WILL LOWER THE FUEL TANK AND TIGHTEN THE FUEL TANK LINES TO THE PROPER TORQUE VALUE.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3EA02006 · Windshield Wiper Failure
Opened May 31, 2002 · Closed Jul 23, 2003
Status: closed (inferred from source dates) · Visibility:windshield Wiper/washer:motor
AS A RESULT OF THIS, AND THE PRECEDINGINVESTIGATION, RQ99-003, GM HAS EXPANDED THE POPULATION OF SAFETY RECALL 98V-150 (REPLACEMENT OF THE WINDSHIELD WIPER CONTROL MODULE) TO INCLUDE AN ADDITIONAL 1.77 MILLION VEHICLES.INCLUDED ARE VARIOUS 1994-1997 MY M/L VANS, S/T TRUCKS AND SUVS, & C/K TRUCKS AND SUVS.SEE ATTACHED TECHNICAL REPORT FOR DETAILS.
Additional source detail variants (2)
Visibility:windshield Wiper/washer:motor
AS A RESULT OF THIS, AND THE PRECEDINGINVESTIGATION, RQ99-003, GM HAS EXPANDED THE POPULATION OF SAFETY RECALL 98V-150 (REPLACEMENT OF THE WINDSHIELD WIPER CONTROL MODULE) TO INCLUDE AN ADDITIONAL 1.77 MILLION VEHICLES.INCLUDED ARE VARIOUS 1994-1997 MY M/L VANS, S/T TRUCKS AND SUVS, & C/K TRUCKS AND SUVS.SEE ATTACHED TECHNICAL REPORT FOR DETAILS.
Visibility:windshield Wiper/washer:motor
AS A RESULT OF THIS, AND THE PRECEDINGINVESTIGATION, RQ99-003, GM HAS EXPANDED THE POPULATION OF SAFETY RECALL 98V-150 (REPLACEMENT OF THE WINDSHIELD WIPER CONTROL MODULE) TO INCLUDE AN ADDITIONAL 1.77 MILLION VEHICLES.INCLUDED ARE VARIOUS 1994-1997 MY M/L VANS, S/T TRUCKS AND SUVS, & C/K TRUCKS AND SUVS.SEE ATTACHED TECHNICAL REPORT FOR DETAILS.
EA00008 · Loss Of Power Assist
Opened Mar 16, 2000 · Closed Aug 31, 2001
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
There is no summary currently available
RQ99003 · Windshield Wiper
Opened Mar 8, 1999 · Closed May 31, 2002
Status: closed (inferred from source dates) · Visibility:windshield Wiper/washer
No summary supplied.