IllustrationWHILE DRIVING AT HIGHWAY SPEEDS THE PASSENGER'S SIDE REAR VIEW MIRROR POPPED OUT. IT WAS REPLACED WITH A PLASTIC MIRROR. THE DRIVERS SIDE REAR VIEW MIRROR ALSO CAME OFF WHILE DRIVING. THE DEALER WAS NOTIFIED BUT DID NOT RESOLVE THE PROBLEM. *AK *BF *NM
1995 Chevrolet Astro
Owner reports · Recalls · Investigations
More warning signs than most Astro years
Owner complaints for the 1995 Chevrolet Astro are substantially higher than the model-year median of 69.
About this comparison →How this year compares
Owner complaints by model year
Compare all Astro years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 32 of 446 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Service Brakes, Hydraulic. Review the 105 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Visibility. Review the 104 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Suspension. Review the 75 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
51 crash reports6 fire reports26 injury reports
Visibility complaints
104 reportsRECALL CAMPAIGN 03V150000 CONCERNING WINDSHIELD WIPER MOTOR. BEFORE THE RECALL WAS DONE, THE WINDSHIELD WIPERS WERE OPERATING PRIOR TO DEALER REPLACING THE CIRCUIT BOARD AND COVER. CURRENTLY, AFTER REPAIRS WERE DONE, THE WINDSHIELD WIPERS DO NOT WORK. THE DEALER WANTED TO CHARGE THE CONSUMER TO REPLACE THE WINDSHIELD WIPER M…
Read full complaint
RECALL CAMPAIGN 03V150000 CONCERNING WINDSHIELD WIPER MOTOR. BEFORE THE RECALL WAS DONE, THE WINDSHIELD WIPERS WERE OPERATING PRIOR TO DEALER REPLACING THE CIRCUIT BOARD AND COVER. CURRENTLY, AFTER REPAIRS WERE DONE, THE WINDSHIELD WIPERS DO NOT WORK. THE DEALER WANTED TO CHARGE THE CONSUMER TO REPLACE THE WINDSHIELD WIPER MOTOR. *AK *SC AFTER THE COMPLAINT WAS FILED THE DEALERSHIP DECIDED TO FIX WINDSHIELD WIPERS.*JB
I HAVE HAD PROBLEMS WITH MY 1995 ASTRO VAN 4.03L FROM THE DAY I BOUGHT IT HARD STARTING ASB LOCKING UP DEALER REPLACED EGR VALUE TWICE TOOK BACK WITH SAME PROBLEM 3 MONTHS LATER WAS TOLD NOTHING WRONG COMPUTER DIGITAL CHECK SAID SO NOW I HAVE GOTTEN 2 MECHANICS TO LOOK AT IT AND SAID THE EGR VALVE FUEL LIND STAYS OPEN POURING…
Read full complaint
I HAVE HAD PROBLEMS WITH MY 1995 ASTRO VAN 4.03L FROM THE DAY I BOUGHT IT HARD STARTING ASB LOCKING UP DEALER REPLACED EGR VALUE TWICE TOOK BACK WITH SAME PROBLEM 3 MONTHS LATER WAS TOLD NOTHING WRONG COMPUTER DIGITAL CHECK SAID SO NOW I HAVE GOTTEN 2 MECHANICS TO LOOK AT IT AND SAID THE EGR VALVE FUEL LIND STAYS OPEN POURING OUT GAS THEY WANT TO CHARGE MY 600.00 TO CLEAN OUT THE SLUGE THIS PROBLEM HAS BEEN GOING ON FOR 3 YEARS MY VAN NOW HAS 82000 MILES AND IT SOUNDS AND SMELLS LIKE A MAC TRUCK I ALSO HAS TO REPLACE TO WIPER MOTOR ABOUT 2 YEARS AGO AND I PAID FOR IT I JUST A NOTICE TO REPLACE IT IT NO CHARGE I CANT FIND THE ORGINAL RECEIPT SO I'M OUT ANOTHER120.00 FOR THAT REPAIR ALONG WITH THE 65.00 SO A LOCAL MECHANIC. CAN TELL ME THIS IS A DEFECT FROM CHEVROLET FOR MY ASTRO VAN I HAVE HAD THE BREAKS CHECKED BY THE DEALER ABOUT 6 TIMES THEY INFORMED ME I DIDN'T KNOW HOW TO USE ABS SYSTEM AND THEY WERE FINE IN ALL MY BRAKES LOCKED UP ON I4 IN FLORIDA LAST AUGUST TRYING TO AVOID AN ACCIDENT 4700.00 LATER I WAS IN THE DITCH BECAUSE THE BRAKES LOCKED UP AND MY VAN WENT SLIDING *LA
CONSUMER STATES THE WINDSHIELD WIPER MOTOR WAS WORKING INTERMITTENLY, BUT NOW HAS FAILED COMPLETELY. THIS HAS RESULTED IN POOR VISIBILITY DURING THE RAIN. TS
WINDSHEILD WIPERS START AND STOP ON THERE OWN STOPPING MORE THAN GOING. DT
1. THE WINDSHIELD WIPERS HAVE A MIND OF THEIR OWN. THE WIPERS DON'T WORK WHEN THE SWITCH IS TURNED ON. OFTEN THE WIPERS WILL CYCLE WHEN NOT NEEDED AND ON THEIR OWN. THE WIPER BLADES HAVE TO BE REPLACED TOO OFTEN DUE TO WEAR. WE CANNOT CONTROL THE SPEED OF THE BLADES WITH THE SWITCH. 2. THE WINDOW ON THE…
Read full complaint
1. THE WINDSHIELD WIPERS HAVE A MIND OF THEIR OWN. THE WIPERS DON'T WORK WHEN THE SWITCH IS TURNED ON. OFTEN THE WIPERS WILL CYCLE WHEN NOT NEEDED AND ON THEIR OWN. THE WIPER BLADES HAVE TO BE REPLACED TOO OFTEN DUE TO WEAR. WE CANNOT CONTROL THE SPEED OF THE BLADES WITH THE SWITCH. 2. THE WINDOW ON THE PASSENGER SIDE DOES NOT WORK CORRECTLY WHILE USING THE SWITCH.
INTERMITTENTLY WINDSHIELD WIPERS COME ON SPORADICALLY. PROBLEM HAS PROGRESSED. DEALER NOTIFIED. PLEASE PROVIDE MORE INFORMATION.*AK
WINDSHIELD WIPERS WORK INTERMITTENTLY. DEALER HAS BEEN NOTIFIED. *AK *YH
FOR OVER 2 YEARS WINDSHIELD WIPERS WOULD RUN ON OR STOP IN THE MIDDLE OF THE CYCLE. I UNDERSTAND FROM THE LOCAL NEWS THAT YOU ARE CONDUCTING AN INVESTIGATION INTO DEFECTIVE WINDSHIELD WIPERS ON VANS OUR YEAR. WE HAD THE WIPER BOARD REPLACED & NOW ALL WORKS CORRECTLY.*AK
WINDSHIELD WIPERS TURN ON AND OFF ANYTIME AND THEN FAIL TO TURN ON OR STOP WHEN BEING USED. *AK
Official recalls
303V159000 · Visibility:windshield Wiper/washer
Apr 28, 2003
ON CERTAIN MINIVANS, PICKUP TRUCKS, AND SPORT UTILITY VEHICLES WITH CERTAIN MODEL-ENGINE COMBINATIONS, THE WINDSHIELD WIPER MOTOR MAY FAIL DUE TO CRACKED SOLDER JOINTS ON THE CONTROLLER CIRCUIT BOARD. THE WINDSHIELD WIPERS COULD WORK INTERMITTENTLY OR NOT AT ALL.
Consequence & remedy
Consequence: IF THIS WERE TO OCCUR DURING BAD WEATHER, DRIVER VISIBILITY WOULD BE REDUCED, WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE WIPER MOTOR CIRCUIT BOARD AND COVER. OWNER NOTIFICATION BEGAN ON JUNE 19, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR OLDSMOBILE AT 1-800-442-6537.
95V175000 · Suspension:front:control Arm:lower Arm
Sep 13, 1995
THESE VEHICLES WERE ASSEMBLED WITH THE LEFT-HAND LOWER CONTROL ARM-TO-FRAME REAR NUT NOT TIGHTENED TO THE SPECIFIED TORQUE.
Consequence & remedy
Consequence: LOW TORQUE CAN ALLOW THE ATTACHMENT BOLT TO LOOSEN AND SUBSEQUENTLY FATIGUE AND BREAK. THIS CAN RESULT IN SEPARATION OF THE LEFT-HAND CONTROL ARM FROM THE FRAME INCREASING THE POTENTIAL FOR A VEHICLE ACCIDENT.
Remedy: DEALERS WILL TIGHTEN THE LEFT-HAND LOWER CONTROL ARM-TO- FRAME REAR NUT TO THE PROPER TORQUE SPECIFICATION.
94V188000 · Fuel System, Gasoline:storage:tank Assembly:mounting
Oct 4, 1994
THE FUEL LINES ATTACHED TO THE FUEL TANK WERE NOT PROPERLY TIGHTENED.
Consequence & remedy
Consequence: THESE FUEL LINES CAN LOOSEN TO THE POINT OF ALLOWING FUEL TO LEAK FROM THE LINES RESULTING IN A VEHICLE FIRE.
Remedy: DEALERS WILL LOWER THE FUEL TANK AND TIGHTEN THE FUEL TANK LINES TO THE PROPER TORQUE VALUE.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3EA02006 · Windshield Wiper Failure
Opened May 31, 2002 · Closed Jul 23, 2003
Status: closed (inferred from source dates) · Visibility:windshield Wiper/washer:motor
AS A RESULT OF THIS, AND THE PRECEDINGINVESTIGATION, RQ99-003, GM HAS EXPANDED THE POPULATION OF SAFETY RECALL 98V-150 (REPLACEMENT OF THE WINDSHIELD WIPER CONTROL MODULE) TO INCLUDE AN ADDITIONAL 1.77 MILLION VEHICLES.INCLUDED ARE VARIOUS 1994-1997 MY M/L VANS, S/T TRUCKS AND SUVS, & C/K TRUCKS AND SUVS.SEE ATTACHED TECHNICAL REPORT FOR DETAILS.
Additional source detail variants (2)
Visibility:windshield Wiper/washer:motor
AS A RESULT OF THIS, AND THE PRECEDINGINVESTIGATION, RQ99-003, GM HAS EXPANDED THE POPULATION OF SAFETY RECALL 98V-150 (REPLACEMENT OF THE WINDSHIELD WIPER CONTROL MODULE) TO INCLUDE AN ADDITIONAL 1.77 MILLION VEHICLES.INCLUDED ARE VARIOUS 1994-1997 MY M/L VANS, S/T TRUCKS AND SUVS, & C/K TRUCKS AND SUVS.SEE ATTACHED TECHNICAL REPORT FOR DETAILS.
Visibility:windshield Wiper/washer:motor
AS A RESULT OF THIS, AND THE PRECEDINGINVESTIGATION, RQ99-003, GM HAS EXPANDED THE POPULATION OF SAFETY RECALL 98V-150 (REPLACEMENT OF THE WINDSHIELD WIPER CONTROL MODULE) TO INCLUDE AN ADDITIONAL 1.77 MILLION VEHICLES.INCLUDED ARE VARIOUS 1994-1997 MY M/L VANS, S/T TRUCKS AND SUVS, & C/K TRUCKS AND SUVS.SEE ATTACHED TECHNICAL REPORT FOR DETAILS.
EA00008 · Loss Of Power Assist
Opened Mar 16, 2000 · Closed Aug 31, 2001
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
There is no summary currently available
RQ99003 · Windshield Wiper
Opened Mar 8, 1999 · Closed May 31, 2002
Status: closed (inferred from source dates) · Visibility:windshield Wiper/washer
No summary supplied.