IllustrationCONSUMER COMPLAINED THAT WINDSHIELD WIPER MOTOR INTERMITTENTLY WOULD FAIL TO WORK PROPERLY.THERE IS A RECALL CONCERNING OTHER CHEVORET VEHICLES, RECALL # 98V-15 . BUT ASTRO IS NOT INCLUDED. DEALER / AMUFACTURER NOTIFIED, BUT WILL NOT REPAIR UNLESS COST IS PICKED UP BY CONSUMER. *AK
1994 Chevrolet Astro
Owner reports · Recalls · Investigations
More warning signs than most Astro years
Owner complaints for the 1994 Chevrolet Astro are substantially higher than the model-year median of 69.
About this comparison →How this year compares
Owner complaints by model year
Compare all Astro years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 33 of 328 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Service Brakes, Hydraulic. Review the 91 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Visibility. Review the 88 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Suspension. Review the 40 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
43 crash reports3 fire reports27 injury reports
What owners actually said
328 reportsWINDSHIELD WIPERS START/STOP ON THEIR OWN. QCAW
IDLER ARMS AND BALL JOINTS BREAK FREQUENTLY. WHEN PROBLEM IS FIXED, IT RETURNS FREQUENTLY. DEALERS ARE AWARE OF THE PROBLEM. *AK
WINDSHIELD WIPERS FAIL INTERMITTANTLY.
SEAT LATCH FAILED,BROKE AND CAUSED SEAT TO COLLAPSE.
CONSUMER HAS BEEN EXPERIENCING AN ONGOING PROBLEM CONCERNING WINDSHIELD WIPER MOTOR NOT WORK PROPERLY. WHEN SWITCH IS TURNED ON THE WIPERS WOULD RUN FOR A WHILE THEN STOP. CONSUMER WOULD TAP THE MOTOR AND THE WIPERS WOULD OPERATE AGAIN FOR A WHILE AND START ALL OVER AGAIN. VEHICLE BEEN IN/OUT OF DEALER SHOP. DEALER NOW KNOWS W…
Read full complaint
CONSUMER HAS BEEN EXPERIENCING AN ONGOING PROBLEM CONCERNING WINDSHIELD WIPER MOTOR NOT WORK PROPERLY. WHEN SWITCH IS TURNED ON THE WIPERS WOULD RUN FOR A WHILE THEN STOP. CONSUMER WOULD TAP THE MOTOR AND THE WIPERS WOULD OPERATE AGAIN FOR A WHILE AND START ALL OVER AGAIN. VEHICLE BEEN IN/OUT OF DEALER SHOP. DEALER NOW KNOWS WHAT THE PROBLEM IS, BUT WILL NOT REPAIR UNLESS COST IS TO THE CONSUMER. *AK
BRAKES AND ENGINE FAILED REPEATEDLY. THERE IS NO COMPLAINT IN NHTSA'S DATABASE, WHEN CHEVROLET ITSELT RECALLED THE PART.
DRIVING THE VEHICLE AND THE RIGHT FRONT TIRE BLEW OUT AND ALL FIVE WHEEL STUDS ON THE RIGHT FRONT FRACTURED THROUGH ,AND THE WHEEL FELL OFF, CAUSING DAMAGE TO THE RIGHT FRONT OF THE VAN.
STARTED TO SHIFT INTO DRIVE, HAD FOOT ON BRAKES, VEHICLE TOOK OFF AT FULL THROTTLE. HAD SHIFTED INTO PARK & PRESSED HARD ON BRAKES TO STOP. TOOK TO DEALER & MECHANIC REPLACED ACCELERATOR CABLE. A FEW DAYS LATER, ACCELERATOR PROBLEM REAPPEARED. *AK
WHEN TRAVELING IN BAD WEATHER CONDITIONS AND WHEN THE WINDSHIELD WIPERS ARE NEEDED, THE WIPERS INTERMITTENTLY TURN OFF WITHOUT PRIOR WARNING, CAUSING POOR VISIBILTY. WHEN RESTARTING THE VEHICLE THE WIPERS WILL COME BACK ON. PLEASE PROVIDE ANY FURTHER DETAILS. *K
Official recalls
294V177000 · Seats:front Assembly:head Restraint
Sep 14, 1994
THE FRONT DRIVER AND PASSENGER SEAT BACK HEIGHT DOES NOT CONFORM TO THE REQUIREMENTS OF FMVSS NO. 202, "HEAD RESTRAINTS."
Consequence & remedy
Consequence: CONSEQUENCE OF NON-COMPLIANCE: SEAT OCCUPANTS ARE SUBJECT TO INCREASED RISK OF INJURY IN THE EVENT OF A SUDD STOP OR ACCIDENT.
Remedy: SHERRY DESIGNS WILL PROVIDE AN ATTACHABLE HEADREST FOR THE DEALER OR CUSTOMER TO ADD TO THE SEATS.
94V087000 · Equipment:other:labels
May 9, 1994
THE MANUFACTURER'S CERTIFICATION LABEL AND/OR THE DRIVER AIR BAG ADVISORY LABEL MAY BE MISSING FROM THE VEHICLES, WHICH DOES NOT CONFORM TO THE REQUIREMENTS OF 49 CFR 567.
Consequence & remedy
Consequence: CONSEQUENCE OF NON-COMPLIANCE: OWNERS OF VEHICLE WOULD BE UNAWARE OF THE LOAD CAPACITY OF THE VANS, THE VAN BUILD DATE, AND WOULD NOT HAVE ANY ASSURANCE THAT THE VANS MEET THE FEDERAL MOTOR VEHICLE SAFETY STANDARDS.
Remedy: THE LABELS WILL BE FURNISHED TO OWNER'S FOR INSTALLATION ON THE VEHICLES.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1RQ99003 · Windshield Wiper
Opened Mar 8, 1999 · Closed May 31, 2002
Status: closed (inferred from source dates) · Visibility:windshield Wiper/washer
No summary supplied.