TL* THE CONTACT OWNED A 1989 CHEVROLET ASTRO. WHILE DRIVING 55 MPH, THE VEHICLE STALLED. AS A RESULT, ANOTHER VEHICLE CRASHED INTO THE REAR OF THE CONTACT'S VEHICLE. THE CONTACT WAS UNSURE IF THE AIR BAGS DEPLOYED. THE DRIVER DIED AT THE SCENE AND THE REAR DRIVER SIDE PASSENGER SUSTAINED A HEAD INJURY, MEMORY LOSS, BACK, LEFT AR…
Read full complaint
TL* THE CONTACT OWNED A 1989 CHEVROLET ASTRO. WHILE DRIVING 55 MPH, THE VEHICLE STALLED. AS A RESULT, ANOTHER VEHICLE CRASHED INTO THE REAR OF THE CONTACT'S VEHICLE. THE CONTACT WAS UNSURE IF THE AIR BAGS DEPLOYED. THE DRIVER DIED AT THE SCENE AND THE REAR DRIVER SIDE PASSENGER SUSTAINED A HEAD INJURY, MEMORY LOSS, BACK, LEFT ARM, AND LEFT LEG INJURIES THAT REQUIRED MEDICAL ATTENTION. A POLICE REPORT WAS FILED. THE VEHICLE WAS DESTROYED. THE CONTACT STATED THAT THE VEHICLE PREVIOUSLY STALLED ON NUMEROUS OCCASIONS AND THE VEHICLE WAS TAKEN TO A DEALER MULTIPLE TIMES. THE CONTACT WAS UNSURE ABOUT WHAT NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN. MA 10/25/15
NHTSA ODI #10759138
Mileage unknown · Jul 12, 2002
Electrical SystemService Brakes, HydraulicFire
BRAKES WENT OUT AND STARTED ON FIRE. BAFFLES ON ENGINE EXHAUST RUSTED OUT AND LAYED ON FRAME TOUCHING STARTER MOTOR ELECTRICAL CONTACTS WHICH STARTED BRAKE FLUID ON FIRE FROM OTHER SIDE OF VEHICLE. BRAKE LINE HAD RUSTED THROUGH APPROXIMATELY SAME TIME AS BAFFLE RUSTED OUT. MASTER CYLINDER WAS BUBBLING FROM THE HEAT AS BRAKE FLUI…
Read full complaint
BRAKES WENT OUT AND STARTED ON FIRE. BAFFLES ON ENGINE EXHAUST RUSTED OUT AND LAYED ON FRAME TOUCHING STARTER MOTOR ELECTRICAL CONTACTS WHICH STARTED BRAKE FLUID ON FIRE FROM OTHER SIDE OF VEHICLE. BRAKE LINE HAD RUSTED THROUGH APPROXIMATELY SAME TIME AS BAFFLE RUSTED OUT. MASTER CYLINDER WAS BUBBLING FROM THE HEAT AS BRAKE FLUID WAS ON FIRE. FIRE WAS VERY DIFFICULT TO PUT OUT. BUCKETS OF WATER WOULD NOT EXTINGUISH FLAMES. ONLY A HOSE COULD REACH THAT AREA OF THE FIRE.*AK*AK
NHTSA ODI #764159
Mileage unknown · Aug 18, 2000
Electrical SystemFireInjury
WHILE DRIVING THE VEHICLE LOST POWER AND BEGAN TO SMOKE, ONCE THE HOOD WAS OPENED THEY FOUND THAT THE ALTERNATOR HAD CAUGHT FIRE IN AN ATTEMPT TO EXTINGUISH THE FIRE CONSUMER RECEIVED BURNS TO THE FACE. NLM
THE RECLINER MECHANISM AND THE SEAT FRAME MAY HAVE FOAM AND/OR VINYL BETWEEN THEM, CREATING A "SOFT" JOINT. THIS "SOFT" JOINT RESULTS IN LOWER THAN SPECIFIED BOLT TORQUE WHICH LEADS TO JOINT LOOSENESS, CAUSING BOLT FATIGUE AND EVENTUAL BOLT FAILURE.
Consequence & remedy
Consequence: IF BOLT FAILURE OCCURS TO THE DRIVER'S SEAT, IT WOULDALLOW THE SEAT BACK TO SUDDENLY RECLINE, AND COULD RESULT IN LOSS OF VEHICLECONTROL AND A VEHICLE CRASH WITHOUT PRIOR WARNING.
Remedy: DEALERS WILL REMOVE THE FOAM AND/OR VINYL FROM BETWEEN THE RECLINER MECHANISM AND THE SEAT FRAME "SOFT" JOINT AND REPLACE THE RECLINER BOLTS.
Illustration