MY TRUCK WILL STOP RUNNING AT FREEWAY SPEEDS WITH NO ENGIN LIGHT HAVE HAD TO STOP IN TRAVEL LANE TO RESTART THE TRUCK THE BRAKES WILL SHAKE STEERING WHEEL OUT OF YOUR HANDS AND MUTIPUL EMISSION RELATED ENGIN LIGHTS DAILY THE TRUCK IS ONLY 3 WEEKS OLD THE ENGIN BRAKE SHIFTS FROM OVER DRIVE TO 3RD OR SECOND GEAR REDLINING THE MOTO…
Read full complaint
MY TRUCK WILL STOP RUNNING AT FREEWAY SPEEDS WITH NO ENGIN LIGHT HAVE HAD TO STOP IN TRAVEL LANE TO RESTART THE TRUCK THE BRAKES WILL SHAKE STEERING WHEEL OUT OF YOUR HANDS AND MUTIPUL EMISSION RELATED ENGIN LIGHTS DAILY THE TRUCK IS ONLY 3 WEEKS OLD THE ENGIN BRAKE SHIFTS FROM OVER DRIVE TO 3RD OR SECOND GEAR REDLINING THE MOTOR AND U HAVE TO APPLY WIDE OPEN THEOTTLE WHILE PULLING A TRAILER DOWN A STEEP GRADE VERY UNSAFE
NHTSA ODI #11349153
Mileage unknown · Feb 11, 2020
Service Brakes
BRAKE BOOSTER PUMP MOTOR RUNS ALL THE TIME EVEN AFTER IGNITION IS TURNED OFF. IF TRUCK WAS TO SHUT OFF THEN WOULD HAVE NO BRAKES TO STOP,
General Motors. LLC (GM) is recalling certain 2019-2023 Chevrolet 4500HD, 5500HD, and 6500HD Medium-Duty trucks. The brake pressure sensor assembly may leak brake fluid into the brake pressure switch and cause an electrical short-circuit.
Consequence & remedy
Consequence: An electrical short in the brake pressure switch can overheat the circuit and increase the risk of a fire while driving or parked.
Remedy: Owners are advised to park outside and away from structures until the recall repair is complete. Dealers will replace the master cylinder pressure sensor and inspect the wire harness, replacing it, if necessary, free of charge. Owner notification letters were mailed July 11, 2023. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N222375270.
Isuzu Technical Center of America, Inc. (Isuzu) is recalling certain 2015-2017 Isuzu NPR, Reach, 2016-2020 Isuzu NPR XD, NPR HD, NQR, 2016-2021 Isuzu NRR, 2017-2020 Chevrolet 4500XD, 4500HD, 5500HD, and 2020 Chevrolet 5500XD vehicles. The U-bolt nuts for the rear axle may not have been properly tightened and may loosen, causing the axle to misalign.
Consequence & remedy
Consequence: The misalignment may cause the propeller shaft to separate, causing a loss of power to the rear wheels and a stall, increasing the risk of a crash.
Remedy: Isuzu will notify owners, and dealers will inspect and, if needed, replace and tighten the rear axle U-bolt nuts, free of charge. The recall began on April 23, 2021. Owners may contact Isuzu customer service at 1-866-441-9638. Isuzu's number for this recall is V2103.
Isuzu Technical Center of America, Inc. (Isuzu) is recalling certain 2017-2020 NPR-HD, 2019-2020 NPR-XD, NQR, NRR, Chevrolet 4500HD, Chevrolet 5500HD and Chevrolet 5500XD, and 2020 Chevrolet 4500XD vehicles. The lug nuts on the rear outer wheels may not have been properly tightened when installed onto the rear axles.
Consequence & remedy
Consequence: If the lug nuts were not properly tightened, they can loosen, causing the to wheel separate from the vehicle, increasing the risk of a crash.
Remedy: Isuzu will notify owners, and dealers will inspect the rear outer wheel lug nuts and tightening or replacing them as necessary, free of charge. The recall began December 20, 2019. Owners may contact Isuzu customer service at 1-866-441-9638 or Chevrolet customer service at 1-800-222-1020. Isuzu's number for this recall is V1906.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
2019 Chevrolet 5500HD Problems, Complaints & Recalls | Skip That Year
Illustration