NHTSA owner reports · September 18, 2026 snapshot.
Fuel System, Gasoline complaints
17 reportsClear category filter87,200 miles · Jul 30, 2013
Fuel System, Gasoline
HIT A SPEED BUMP - LOUD NOISE - COULD BARELY BRAKE - AVOID COLLISION AND AFTER EVENTUALLY BEING ABLE TO STOP; LOOKED UNDER CAR AND FLUID GUSHING OUT LIKE A RAINSTORM. CALL INSURANCE COMPANY WHO STATED IT WAS A COLLISION; HOWEVER, REPAIR SHOP AND ADJUSTER FOR INSURANCE COMPANY STATED IT WAS BOUND TO HAPPEN DUE TO RUSTING AND CRA…
Read full complaint
HIT A SPEED BUMP - LOUD NOISE - COULD BARELY BRAKE - AVOID COLLISION AND AFTER EVENTUALLY BEING ABLE TO STOP; LOOKED UNDER CAR AND FLUID GUSHING OUT LIKE A RAINSTORM. CALL INSURANCE COMPANY WHO STATED IT WAS A COLLISION; HOWEVER, REPAIR SHOP AND ADJUSTER FOR INSURANCE COMPANY STATED IT WAS BOUND TO HAPPEN DUE TO RUSTING AND CRACKING OF BRAKE LINE, ETC. AND WILL NOT PAY FOR REPAIR - AUTO REPAIR DID SEND A PAPER SHOWING A RECALL THAT WAS ISSUED BY NHTSA ID: 04V110000 ON JUNE 2, 2004 DEALING WITH FUEL SYSTEM AND THE FUEL RAIL CONSTRUCTION WHICH MAY DEGRADE AND CRACK. I INFORMED NOT ONLY THE INSURANCE ADJUSTER AND THE REPAIR SHOP, AND I ALSO CALLED CADILLAC AT L-8---458-8006, ABOUT THIS RECALL AND SINCE I NEVER RECEIVED A RECALL FROM CADILLAC, IT WOULD APPEAR THAT THIS IS AN ISSUE WHICH SHOULD BE ADDRESSED BY THEM. I THANK YOU FOR YOUR ASSISTANCE. *TR
NHTSA ODI #10532740
144,000 miles · Jun 17, 2009
Fuel System, GasolineFire
TL*THE CONTACT OWNS A 1997 CADILLAC SEVILLE. THE CONTACT WAS INFORMED THAT HIS VEHICLE WAS INCLUDED IN NHTSA CAMPAIGN ID NUMBER 04V110000; HOWEVER, THE DEALER STATED THAT THE RECALL HAD EXPIRED. THE DEALER DID NOT WANT TO MAKE ANY REPAIRS. LESS THAN 72 HOURS LATER, THE VEHICLE CAUGHT FIRE UPON STARTING. FLAMES APPEARED UNDER…
Read full complaint
TL*THE CONTACT OWNS A 1997 CADILLAC SEVILLE. THE CONTACT WAS INFORMED THAT HIS VEHICLE WAS INCLUDED IN NHTSA CAMPAIGN ID NUMBER 04V110000; HOWEVER, THE DEALER STATED THAT THE RECALL HAD EXPIRED. THE DEALER DID NOT WANT TO MAKE ANY REPAIRS. LESS THAN 72 HOURS LATER, THE VEHICLE CAUGHT FIRE UPON STARTING. FLAMES APPEARED UNDER THE HOOD AND WERE EXTINGUISHED WITH A FIRE EXTINGUISHER. THE DEALER STATED THAT THEY WOULD NOT TOUCH THE VEHICLE DUE TO THE FIRE. A CLAIM WAS FILED WITH THE MANUFACTURER, WHICH WAS ESCALATED TO HIGHER AUTHORITIES. THE CONTACT IS AWAITING A CALL BACK. THE VEHICLE HAS NOT BEEN REPAIRED. THE VIN WAS UNKNOWN. THE CURRENT AND FAILURE MILEAGES WERE LESS THAN 144,000.
NHTSA ODI #10274173
65,000 miles · Oct 7, 2005
Fuel System, Gasoline
DT: THE CONSUMER STATES THAT THE FUEL SENDING UNIT IN THE GAS TANK DID NOT WORK PROPERLY, IT HAS A DIGITAL FUEL GAUGE ON IT. THE VEHICLE SHOWED NINE GALLONS OF GASOLINE, THEN IT INCREASED WITHOUT PLACING ANY GASOLINE IN THE VEHICLE, AND SHOWED THE TANK WAS COMPLETELY FULL. THE CONSUMER TOOK THE VEHICLE TO THE DEALER, THEY S…
Read full complaint
DT: THE CONSUMER STATES THAT THE FUEL SENDING UNIT IN THE GAS TANK DID NOT WORK PROPERLY, IT HAS A DIGITAL FUEL GAUGE ON IT. THE VEHICLE SHOWED NINE GALLONS OF GASOLINE, THEN IT INCREASED WITHOUT PLACING ANY GASOLINE IN THE VEHICLE, AND SHOWED THE TANK WAS COMPLETELY FULL. THE CONSUMER TOOK THE VEHICLE TO THE DEALER, THEY SAID THAT THE FUEL SENDING UNIT NEEDED TO BE REPLACED. THE CONSUMER NOTICED THIS ISSUE WITH THE VEHICLE ON JULY 1, 2002. THERE WAS NO FOR WARNING, AND THIS OCCURRED EVERY TIME THE CONSUMER DROVE THE VEHICLE. *AK (11/17/05) *SC
NHTSA ODI #10139021
50,000 miles · Oct 28, 2004
Fuel System, Gasoline
1997 CAD SEVILLE RECALL NOTICE RECEIVED FOR DEFECT RELATES TO MOTOR VEHICLE SAFETY. *BF RECALL#04V110000. *SC
NHTSA ODI #10099118
130,000 miles · Aug 16, 2004
Fuel System, Gasoline
CONSUMER HAS A CONCERN ABOUT SMELLING GAS FUMES WHEN EXITING HIS PARKED VEHICLE. CONSUMER INSPECTED THE VEHICLE AND SAW FUEL SPRAYING ONTO THE MANIFOLD FROM THE FUEL RAIL. DEALER WAS NOTIFIED. PLEASE PROVIDE ANY FURTHER INFORMATION. *JB
NHTSA ODI #10087990
72,101 miles · Jan 15, 2004
Engine And Engine CoolingFuel System, GasolineUnknown Or Other
I BOUGHT A USED CAR WITH AN EXTENDED WARRANTY. A WEEK LATER THE FUEL SWITCH WENT OUT. I HAD TO SPEND $80 TO GET THAT FIXED AT THE SAME DEALERSHIP. AFTER A FEW WEEKS THE TURING SWITCH STARTED SMOKING SO I TOOK IT TO DIFFERENT DEALERSHIP TO GET CHECK OUT AND THEY FIXED IT FOR $100 (CO PAY) WHILE MY CAR WAS BEING FIXED THEY FOUND A…
Read full complaint
I BOUGHT A USED CAR WITH AN EXTENDED WARRANTY. A WEEK LATER THE FUEL SWITCH WENT OUT. I HAD TO SPEND $80 TO GET THAT FIXED AT THE SAME DEALERSHIP. AFTER A FEW WEEKS THE TURING SWITCH STARTED SMOKING SO I TOOK IT TO DIFFERENT DEALERSHIP TO GET CHECK OUT AND THEY FIXED IT FOR $100 (CO PAY) WHILE MY CAR WAS BEING FIXED THEY FOUND A MAJOR OIL LEAK AND ASKED ME IF I WOULD LIKE TO SEE IF MY WARRANTY WOULD FIX IT. THE WARRENTY PEOPLE CAME OUT AND SAID NO WE ARE NOT GOING TO PAY THE $1,500 -$2,500 TO FIX IT. THE CAR NEEDS TO GO BACK TO WHERE YOU BOUGHT IT SO THEY CAN FIX THE CAR BECAUSE THE LEAK WAS PREEXISTING . AT THAT TIME I WENT AND TALKED TO ONE OF THE OWNERS. HE SAID HE WOULD LOOK INTO IT AND ADVISED ME TO GO AND LET THE SERVICE MANAGER TAKE A LOOK AT THE CAR. COME TO FIND OUT THE USED CAR LOT KNEW ABOUT THE LEAK AND DID NOT TELL ME AT THE TIME OF SALE OTHERWISE I WOULD NOT HAVE BOUGHT THE CAR . I WAS TOLD BY THE SERVICE MANAGER THAT THE SALES DEPARTMENT MAY PAY TO GET IT FIXED AND THEY DECLINED. I AM NOW STUCK WITH A $320.00 A MONTH PAYMENT ON A CAR THAT I CAN'T DRIVE VERY MUCH UNTIL THE LEAK IS FIXED . I WOULD LIKE TO GET MY OLD CAR BACK THAT I TRADED IN. I WAS TOLD THAT I WOULD BE ABLE TO UNDER THE USED CAR LEMON LAW ACT. ONE MORE NOTE I ALSO NEED TO GET THE STEERING COLUM REPAIRED THAT WOULD BE ANOTHER $210.00 AND I WORK FOR THE COMPANY I BOUGHT THE CAR FROM.
NHTSA ODI #10070348
46,808 miles · Nov 26, 2003
Fuel System, Gasoline
FUEL RAIL CRACKS AND LEAKS GASOLINE INTO THE ENGINE COMPARTMENT. *LA
NHTSA ODI #10047646
135,000 miles · Nov 11, 2003
Fuel System, Gasoline
I HAVE A 1997 CADILLAC SEVILLE STS AND THE FUEL RAIL SPRUNG A LEAK RESULTING IN GAS SPREAD ON THE ENGINE AND FUMES IN THE PASSENGER COMPARTMENT. THIS IS EXTREMELY DANGEROUS AND HAD I NOT STOPPED QUICKLY, A FIRE WOULD HAVE RESULTED. FROM MY CAR REPAIRMAN AND LOOKING ON THE WEB, THIS IS NOT AN ISOLATED INCIDENT. NOTE COMPLAINT 1…
Read full complaint
I HAVE A 1997 CADILLAC SEVILLE STS AND THE FUEL RAIL SPRUNG A LEAK RESULTING IN GAS SPREAD ON THE ENGINE AND FUMES IN THE PASSENGER COMPARTMENT. THIS IS EXTREMELY DANGEROUS AND HAD I NOT STOPPED QUICKLY, A FIRE WOULD HAVE RESULTED. FROM MY CAR REPAIRMAN AND LOOKING ON THE WEB, THIS IS NOT AN ISOLATED INCIDENT. NOTE COMPLAINT 10045758.*AK
NHTSA ODI #10045965
107,871 miles · Nov 8, 2003
Fuel System, Gasoline
IN REFERENCE TO OPEN INVESTIGATION PE03050. I HAVE CADILLAC SEVILLE, STS, 1997. HAD EXACTLY THE SAME PROBLEM AS DESCRIBED -- STRONG FUEL SMELL IN THE CAR -- WHEN CHECKED BY THE DEALERSHIP -- THERE WAS A PIN HOLE IN THE FUEL RAIL -- I HAVE SEEN IT MYSELF AND IT WAS SCARY. LOGGED THE COMPLAINT WITH CADILLAC: [XXX] ON 09/30/2003, …
Read full complaint
IN REFERENCE TO OPEN INVESTIGATION PE03050. I HAVE CADILLAC SEVILLE, STS, 1997. HAD EXACTLY THE SAME PROBLEM AS DESCRIBED -- STRONG FUEL SMELL IN THE CAR -- WHEN CHECKED BY THE DEALERSHIP -- THERE WAS A PIN HOLE IN THE FUEL RAIL -- I HAVE SEEN IT MYSELF AND IT WAS SCARY. LOGGED THE COMPLAINT WITH CADILLAC: [XXX] ON 09/30/2003, BUT THEY WERE NOT WILLING TO INVESTIGATE ANY FURTHER AT THAT TIME. CADILLAC SHOULD RECALL ALL THESE VEHICLE AS SOON AS POSSIBLE BECAUSE THIS IS A SIGNIFICANT FIRE HAZARD. PLEASE FEEL FREE TO CONTACT ME AT [XXX](WORK) IF YOU HAVE ANY QUESTIONS. REGARDS, [XXX]. *AK INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
NHTSA ODI #10045758
75,300 miles · Nov 5, 2003
Engine And Engine CoolingFuel System, Gasoline
ENGINE EXHIBITED EXTENDED CRANKS AFTER SITTING FOR SEVERAL HOURS. DEALER REPLACED FUEL PRESSURE REGULATOR($$$). ENGINE CONTINUED TO EXHIBIT EXTENDED CRANKS ONLY MORE SEVERE. DEALER REPLACED FUEL PUMP ($$$$). ENGINE CONTINUED TO EXHIBIT EXTENDED CRANKS. DEALER REPLACED FUEL FILTER ($$) AND FUEL PUMP AGAIN. CRANK PROBLEM NOW REPLA…
Read full complaint
ENGINE EXHIBITED EXTENDED CRANKS AFTER SITTING FOR SEVERAL HOURS. DEALER REPLACED FUEL PRESSURE REGULATOR($$$). ENGINE CONTINUED TO EXHIBIT EXTENDED CRANKS ONLY MORE SEVERE. DEALER REPLACED FUEL PUMP ($$$$). ENGINE CONTINUED TO EXHIBIT EXTENDED CRANKS. DEALER REPLACED FUEL FILTER ($$) AND FUEL PUMP AGAIN. CRANK PROBLEM NOW REPLACED BY STALLING AFTER DECELERATING TO NEAR STOP THEN DOING A GENTLE TIP IN ON ACCELERATOR AS IN MAKING A TURN OR ENTERING A TRAFFIC CIRCLE.*AK
NHTSA ODI #10045551
NHTSA investigations
3EA04003 · Fuel Rail Leaks
Opened Feb 3, 2004 · Closed Apr 23, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:delivery; Fuel System, Gasoline:fuel Injection System:fuel Rail
ON MARCH 3, 2004, GENERAL MOTORS NOTIFIED ODI THAT IT WAS RECALLING APPROXIMATELY 94,000 MY 1995-97 OLDSMOBILE AURORA VEHICLES EQUIPPED WITH 4.0L V8 ENGINES (RPO L47 - VIN8 C) TO ADDRESS CONCERNS WITH UNDERHOOD FUEL LEAKAGE FROM CRACKED FUEL RAILS AND, IN SOME OF THE VEHICLES, CRACKED FUEL RETURN LINES. ACCORDING TO GM, THE NYLON TUBING (PA12) USED IN THE FUEL RAIL CONSTRUCTION IN THESE VEHICLES MAY DEGRADE AND CRACK.GM'S SUPPLIER ATTRIBUTED THE CRACKING TO THE COMBINED EFFECTS OF HEAT, TIME, ALCOHOL FUEL, FUEL PRESSURE CYCLING, AND DESIGN STRESSES.IN ADDITION, GM STATED THAT THE MY 1995 AURORA USES A UNIQUE UNDERHOOD FUEL RETURN LINE THAT MAY ALSO CRACK AT UNUSUALLY HIGH RATES.GM DEALERS WILL INSTALL A NEW FUEL RAIL CONSTRUCTED OUT OF STAINLESS STEEL IN ALL OF THE RECALLED VEHICLES AND WILL ALSO INSTALL A REVISED CHASSIS FUEL RETURN LINE IN THE MY 1995 AURORAS. ON APRIL 16, 2004, GENERAL MOTORS NOTIFIED ODI THAT IT WAS ADDING APPROXIMATELY 389,000 MY 1995-97 CADILLAC SEVILLE, DEVILLE AND ELDORADO VEHICLES EQUIPPED WITH 4.6L V8 ENGINES (RPO'S LD8 AND L37 - VIN8 Y AND 9) TO RECALL 04V-110.THE RECALLED CADILLACS WILL RECEIVE THE NEW STAINLESS STEEL FUEL RAILS.THIS ENGINEERING ANALYSIS IS CLOSED.
Additional source detail variants (3)
Fuel System, Gasoline:delivery
ON MARCH 3, 2004, GENERAL MOTORS NOTIFIED ODI THAT IT WAS RECALLING APPROXIMATELY 94,000 MY 1995-97 OLDSMOBILE AURORA VEHICLES EQUIPPED WITH 4.0L V8 ENGINES (RPO L47 - VIN8 C) TO ADDRESS CONCERNS WITH UNDERHOOD FUEL LEAKAGE FROM CRACKED FUEL RAILS AND, IN SOME OF THE VEHICLES, CRACKED FUEL RETURN LINES. ACCORDING TO GM, THE NYLON TUBING (PA12) USED IN THE FUEL RAIL CONSTRUCTION IN THESE VEHICLES MAY DEGRADE AND CRACK.GM'S SUPPLIER ATTRIBUTED THE CRACKING TO THE COMBINED EFFECTS OF HEAT, TIME, ALCOHOL FUEL, FUEL PRESSURE CYCLING, AND DESIGN STRESSES.IN ADDITION, GM STATED THAT THE MY 1995 AURORA USES A UNIQUE UNDERHOOD FUEL RETURN LINE THAT MAY ALSO CRACK AT UNUSUALLY HIGH RATES.GM DEALERS WILL INSTALL A NEW FUEL RAIL CONSTRUCTED OUT OF STAINLESS STEEL IN ALL OF THE RECALLED VEHICLES AND WILL ALSO INSTALL A REVISED CHASSIS FUEL RETURN LINE IN THE MY 1995 AURORAS. ON APRIL 16, 2004, GENERAL MOTORS NOTIFIED ODI THAT IT WAS ADDING APPROXIMATELY 389,000 MY 1995-97 CADILLAC SEVILLE, DEVILLE AND ELDORADO VEHICLES EQUIPPED WITH 4.6L V8 ENGINES (RPO'S LD8 AND L37 - VIN8 Y AND 9) TO RECALL 04V-110.THE RECALLED CADILLACS WILL RECEIVE THE NEW STAINLESS STEEL FUEL RAILS.THIS ENGINEERING ANALYSIS IS CLOSED.
Fuel System, Gasoline:fuel Injection System:fuel Rail
ON MARCH 3, 2004, GENERAL MOTORS NOTIFIED ODI THAT IT WAS RECALLING APPROXIMATELY 94,000 MY 1995-97 OLDSMOBILE AURORA VEHICLES EQUIPPED WITH 4.0L V8 ENGINES (RPO L47 - VIN8 C) TO ADDRESS CONCERNS WITH UNDERHOOD FUEL LEAKAGE FROM CRACKED FUEL RAILS AND, IN SOME OF THE VEHICLES, CRACKED FUEL RETURN LINES. ACCORDING TO GM, THE NYLON TUBING (PA12) USED IN THE FUEL RAIL CONSTRUCTION IN THESE VEHICLES MAY DEGRADE AND CRACK.GM'S SUPPLIER ATTRIBUTED THE CRACKING TO THE COMBINED EFFECTS OF HEAT, TIME, ALCOHOL FUEL, FUEL PRESSURE CYCLING, AND DESIGN STRESSES.IN ADDITION, GM STATED THAT THE MY 1995 AURORA USES A UNIQUE UNDERHOOD FUEL RETURN LINE THAT MAY ALSO CRACK AT UNUSUALLY HIGH RATES.GM DEALERS WILL INSTALL A NEW FUEL RAIL CONSTRUCTED OUT OF STAINLESS STEEL IN ALL OF THE RECALLED VEHICLES AND WILL ALSO INSTALL A REVISED CHASSIS FUEL RETURN LINE IN THE MY 1995 AURORAS. ON APRIL 16, 2004, GENERAL MOTORS NOTIFIED ODI THAT IT WAS ADDING APPROXIMATELY 389,000 MY 1995-97 CADILLAC SEVILLE, DEVILLE AND ELDORADO VEHICLES EQUIPPED WITH 4.6L V8 ENGINES (RPO'S LD8 AND L37 - VIN8 Y AND 9) TO RECALL 04V-110.THE RECALLED CADILLACS WILL RECEIVE THE NEW STAINLESS STEEL FUEL RAILS.THIS ENGINEERING ANALYSIS IS CLOSED.
Fuel System, Gasoline
ON MARCH 3, 2004, GENERAL MOTORS NOTIFIED ODI THAT IT WAS RECALLING APPROXIMATELY 94,000 MY 1995-97 OLDSMOBILE AURORA VEHICLES EQUIPPED WITH 4.0L V8 ENGINES (RPO L47 - VIN8 C) TO ADDRESS CONCERNS WITH UNDERHOOD FUEL LEAKAGE FROM CRACKED FUEL RAILS AND, IN SOME OF THE VEHICLES, CRACKED FUEL RETURN LINES. ACCORDING TO GM, THE NYLON TUBING (PA12) USED IN THE FUEL RAIL CONSTRUCTION IN THESE VEHICLES MAY DEGRADE AND CRACK.GM'S SUPPLIER ATTRIBUTED THE CRACKING TO THE COMBINED EFFECTS OF HEAT, TIME, ALCOHOL FUEL, FUEL PRESSURE CYCLING, AND DESIGN STRESSES.IN ADDITION, GM STATED THAT THE MY 1995 AURORA USES A UNIQUE UNDERHOOD FUEL RETURN LINE THAT MAY ALSO CRACK AT UNUSUALLY HIGH RATES.GM DEALERS WILL INSTALL A NEW FUEL RAIL CONSTRUCTED OUT OF STAINLESS STEEL IN ALL OF THE RECALLED VEHICLES AND WILL ALSO INSTALL A REVISED CHASSIS FUEL RETURN LINE IN THE MY 1995 AURORAS. ON APRIL 16, 2004, GENERAL MOTORS NOTIFIED ODI THAT IT WAS ADDING APPROXIMATELY 389,000 MY 1995-97 CADILLAC SEVILLE, DEVILLE AND ELDORADO VEHICLES EQUIPPED WITH 4.6L V8 ENGINES (RPO'S LD8 AND L37 - VIN8 Y AND 9) TO RECALL 04V-110.THE RECALLED CADILLACS WILL RECEIVE THE NEW STAINLESS STEEL FUEL RAILS.THIS ENGINEERING ANALYSIS IS CLOSED.
PE03050 · Fuel Rail Leakage
Opened Oct 30, 2003 · Closed Feb 3, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline:fuel Injection System:fuel Rail
THE FUEL RAIL ASSEMBLIES USED IN THE SUBJECT VEHICLES WERE MANUFACTURED BY DANA.THE FUEL RAIL JUMPER TUBES WERE MADE OF MONOLAYER NYLON 12 (PA12).IN MODEL YEAR (MY) 1998, THE JUMPER TUBE MATERIAL WAS CHANGED FROM PA12 TO M-BOND (A MULTI-LAYER PTFE/PA12).IN ADDITION, ALL SERVICE PARTS PRODUCED SINCE THE END OF PRODUCTION 1997 USE THE M-BOND JUMPER TUBES. MATERIAL ANALYSIS PERFORMED BY DANA ON FAILED FUEL RAILS SHOWED THAT THE MONO-LAYER NYLON 12 JUMPER TUBES ARE SUSCEPTIBLE TO ENVIRONMENTAL STRESS CRACKING (ESC).GM BELIEVES THE ESC IS A RESULT OF HEAT, TIME, ALCOHOL BLENDED FUEL, FUEL PRESSURE CYCLING, AND DESIGNED IN STRESS. EIGHT OF THE GM COMPLAINTS ARE DUPLICATIVE OF ODI COMPLAINTS.ODI HAS RECEIVED 77 OF IT'S 123 COMPLAINTS IN THE PAST 12 MONTHS.FUEL RAIL PART SALES OVER THE LAST THREE YEARS RANGE FROM 3.0 PERCENT OF PRODUCTION FOR THE MY 1997 CADILLAC VEHICLES TO 13.1 PERCENT FOR THE MY 1995 AURORAS.AT LEAST ONE OF THE FIRE INCIDENTS OCCURED WHILE THE VEHICLE WAS PARKED WITHIN A GARAGE ATTACHED TO THE CONSUMERS HOME.THE FIRE RESULTED IN DAMAGE TO THE DWELLING AS WELL AS THE TOTAL LOSS OF THE VEHICLE.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS.
RQ03001 · Power Rack And Pinion Steering Failure
Opened Jan 2, 2003 · Closed Sep 15, 2003
Status: closed (inferred from source dates) · Steering; Steering:rack And Pinion
GM CONDUCTED A SAFETY RECALL (NHTSA # 02V286) TO ADDRESS A STEERING DEFECT PERTAINING TO A LOWER PINION BEARING (LPB) WITHIN THE RACK AND PINION STEERING GEAR (R&P). THE RECALL COVERED 1,159,156 MODEL YEAR 1997-1998 PONTIAC GRAND PRIX VEHICLES BUILT BETWEEN MARCH 1, 1996 AND OCTOBER 31, 1997, 1996-1998 PONTIAC TRANS SPORT, CHEVROLET LUMINA APV, CHEVROLET VENTURE, OLDSMOBILE SILHOUETTE MINIVANS, AND CHEVROLET CAVALIER AND PONTIAC SUNFIRE SEDANS BUILT BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997.ODI OPENED THIS RQ AFTER RECEIVING REPORTS THAT OTHER VEHICLES WERE EXHIBITING THE SAME SYMPTOMS AS THE RECALLED VEHICLES.BASED ON ODI'S REVIEW OF TECHNICAL AND COMPLAINT DATA COLLECTED DURING THE RQ, THE W-CARS ARE ASSOCIATED WITH EITHER A HIGHER STEERING COMPLAINT RATE OR A HIGHER LPB FAILURE RATE THAN THE OTHER VEHICLES INVESTIGATED UNDER THE RQ AND ARE ABOVE OR NEAR THE RATES FOR THE RECALLED VEHICLES.THUS, ODI WILL FURTHER EXAMINE THE W-CARS (1996-1997 OLDSMOBILE CUTLASS SUPREME, 1996-1998 BUICK REGAL, CHEVROLET LUMINA, CHEVROLET MONTE CARLO, 1997-1998 BUICK CENTURY, AND 1998 OLDSMOBILE INTRIGUE) UNDER A NEW INVESTIGATION, ENGINEERING ANALYSIS (EA)03-019.
Additional source detail variants (2)
Steering
GM CONDUCTED A SAFETY RECALL (NHTSA # 02V286) TO ADDRESS A STEERING DEFECT PERTAINING TO A LOWER PINION BEARING (LPB) WITHIN THE RACK AND PINION STEERING GEAR (R&P). THE RECALL COVERED 1,159,156 MODEL YEAR 1997-1998 PONTIAC GRAND PRIX VEHICLES BUILT BETWEEN MARCH 1, 1996 AND OCTOBER 31, 1997, 1996-1998 PONTIAC TRANS SPORT, CHEVROLET LUMINA APV, CHEVROLET VENTURE, OLDSMOBILE SILHOUETTE MINIVANS, AND CHEVROLET CAVALIER AND PONTIAC SUNFIRE SEDANS BUILT BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997.ODI OPENED THIS RQ AFTER RECEIVING REPORTS THAT OTHER VEHICLES WERE EXHIBITING THE SAME SYMPTOMS AS THE RECALLED VEHICLES.BASED ON ODI'S REVIEW OF TECHNICAL AND COMPLAINT DATA COLLECTED DURING THE RQ, THE W-CARS ARE ASSOCIATED WITH EITHER A HIGHER STEERING COMPLAINT RATE OR A HIGHER LPB FAILURE RATE THAN THE OTHER VEHICLES INVESTIGATED UNDER THE RQ AND ARE ABOVE OR NEAR THE RATES FOR THE RECALLED VEHICLES.THUS, ODI WILL FURTHER EXAMINE THE W-CARS (1996-1997 OLDSMOBILE CUTLASS SUPREME, 1996-1998 BUICK REGAL, CHEVROLET LUMINA, CHEVROLET MONTE CARLO, 1997-1998 BUICK CENTURY, AND 1998 OLDSMOBILE INTRIGUE) UNDER A NEW INVESTIGATION, ENGINEERING ANALYSIS (EA)03-019.
Steering:rack And Pinion
GM CONDUCTED A SAFETY RECALL (NHTSA # 02V286) TO ADDRESS A STEERING DEFECT PERTAINING TO A LOWER PINION BEARING (LPB) WITHIN THE RACK AND PINION STEERING GEAR (R&P). THE RECALL COVERED 1,159,156 MODEL YEAR 1997-1998 PONTIAC GRAND PRIX VEHICLES BUILT BETWEEN MARCH 1, 1996 AND OCTOBER 31, 1997, 1996-1998 PONTIAC TRANS SPORT, CHEVROLET LUMINA APV, CHEVROLET VENTURE, OLDSMOBILE SILHOUETTE MINIVANS, AND CHEVROLET CAVALIER AND PONTIAC SUNFIRE SEDANS BUILT BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997.ODI OPENED THIS RQ AFTER RECEIVING REPORTS THAT OTHER VEHICLES WERE EXHIBITING THE SAME SYMPTOMS AS THE RECALLED VEHICLES.BASED ON ODI'S REVIEW OF TECHNICAL AND COMPLAINT DATA COLLECTED DURING THE RQ, THE W-CARS ARE ASSOCIATED WITH EITHER A HIGHER STEERING COMPLAINT RATE OR A HIGHER LPB FAILURE RATE THAN THE OTHER VEHICLES INVESTIGATED UNDER THE RQ AND ARE ABOVE OR NEAR THE RATES FOR THE RECALLED VEHICLES.THUS, ODI WILL FURTHER EXAMINE THE W-CARS (1996-1997 OLDSMOBILE CUTLASS SUPREME, 1996-1998 BUICK REGAL, CHEVROLET LUMINA, CHEVROLET MONTE CARLO, 1997-1998 BUICK CENTURY, AND 1998 OLDSMOBILE INTRIGUE) UNDER A NEW INVESTIGATION, ENGINEERING ANALYSIS (EA)03-019.
Illustration