THE BRAKE "LINES FROM THE PROPORTIONING VALVE TO MODULATOR, LINES FROM MASTER CYL TO PROPORTIONING VALVE" HAD TO BE REPLACED. THE QUOTED DESCRIPTION IS FROM THE DEALERS SERVICE INVOICE. ONE OR MORE OF THESE LINES CORRODED THRU AND FAILED WHILE I WAS (LUCKILY) IN MY DRIVEWAY. I HAD FILED A COMPLAINT IN 2012 REGARDING CORROSION …
Read full complaint
THE BRAKE "LINES FROM THE PROPORTIONING VALVE TO MODULATOR, LINES FROM MASTER CYL TO PROPORTIONING VALVE" HAD TO BE REPLACED. THE QUOTED DESCRIPTION IS FROM THE DEALERS SERVICE INVOICE. ONE OR MORE OF THESE LINES CORRODED THRU AND FAILED WHILE I WAS (LUCKILY) IN MY DRIVEWAY. I HAD FILED A COMPLAINT IN 2012 REGARDING CORROSION FAILURE RELATED TO THE REAR BRAKE LINES AND IN 2013 FOR CORROSION FAILURE RELATED TO THE FRONT BRAKE LINES. ODI NUMBERS ARE AVAILABLE.
NHTSA ODI #10747573
119,200 miles · Aug 7, 2013
Service Brakes
THE DRIVER SIDE FRONT BRAKE LINE CORRODED THRU. THIS IS A LITTLE OVER A YEAR SINCE THE REAR BRAKE LINE CORRODED THRU. *TR
NHTSA ODI #10533994
111,054 miles · May 14, 2012
Service Brakes
LEFT REAR BRAKE LINES RUSTED THROUGH AT THE WHEEL AREA. SIGNIFICANT FLUID LEAKAGE. LINES FOR BOTH REAR BRAKES HAD TO BE REPLACED. *JS
ON CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES, THE GALVANIZED STEEL TAILGATE SUPPORT CABLES THAT RETAIN THE TAILGATE IN THE FULL OPEN (HORIZONTAL) POSITION MAY CORRODE, WEAKEN, AND EVENTUALLY FRACTURE. IF BOTH CABLES FRACTURED, THE TAILGATE WOULD SUDDENLY DROP AND STRIKE THE TOP SURFACE OF THE REAR BUMPER.
Consequence & remedy
Consequence: ANYONE SITTING OR STANDING ON THE HORIZONTAL SURFACE OF THE TAILGATE WHEN BOTH CABLES FRACTURED COULD BE INJURED BY FALLING FROM THE TAILGATE. ON VEHICLES THAT HAVE HAD THE BUMPER REMOVED, THE TAILGATE MAY DROP EVEN LOWER. ADDITIONALLY, IF THERE IS CARGO ON THE TAILGATE THE CARGO MAY FALL OFF IF THE SUPPORT CABLES FRACTURE.
Remedy: DEALERS WILL REPLACE THE CABLES. INTERIM OWNER NOTIFICATION BEGAN ON APRIL 7, 20004. THE RECALL BEGAN ON SEPTEMBER 24, 2004, WHEN REPLACEMENT PARTS WERE AVAILABLE, AND WILL CONTINUE THROUGH OCTOBER 29, 2004. OWNERS SHOULD CONTACT CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438 OR GMC AT 1-866-996-9463, OR VISIT WWW.MYGMLINK.COM, AND ENTER YOUR VEHICLE IDENTIFICATION NUMBER.
CERTAIN SPORT UTILITY VEHICLES, PICKUP TRUCKS, AND PASSENGER VANS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 135, ?PASSENGER CAR BRAKE SYSTEMS.? SOME OF THESE VEHICLES WERE PRODUCED WITH AN OUT-OF-SPECIFICATION BRAKE HYDRO-BOOST HOUSING RELIEF VALVE BORE.
Consequence & remedy
Consequence: CONSEQUENTLY, THE VALVE O-RING SEAL MAY FRACTURE. STEERING EFFORTS MAY BE SLIGHTLY INCREASED WHILE BRAKING OR PARKING. UNDER CERTAIN DRIVING CONDITIONS, A FRACTURED SEAL MAY REQUIRE A SLIGHT INCREASE IN THE APPLIED BRAKE PEDAL EFFORT TO ACHIEVE THE SAME VEHICLE DECELERATION RATE AS PRIOR TO THE SEAT FRACTURE.
Remedy: DEALERS ARE TO REPLACE THE HYDRO-BOOST RELIEF VALVE. THE RECALL BEGAN ON JUNE 18, 2004. OWNERS SHOULD CONTACT CADILLAC AT 1-866-982-2339; CHEVROLET AT 1-800-630-2438; GMC AT 1-866-996-9463; OR HUMMER AT 1-866-486-6376.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
2004 Cadillac Escalade Ext Problems, Complaints & Recalls | Skip That Year
Illustration