IllustrationCONSUMER COMPLAINED ABOUT PROBLEMS WITH TRACTION CONTROL, ABS AND CONSOLE MESSAGE CENTER, INDICATING A PROBLEM WITH STEERING. CONSUMER TOOK VEHICLE TO THE DEALER, WHO INFORMED CONSUMER THAT THESE PROBLEMS WERE NOT COVERED UNDER A RECALL, AND ANY REPAIRS WOULD BE CHARGED TO THE CONSUMER. *AK
1997 Cadillac Deville
Owner reports · Recalls · Investigations
More warning signs than most Deville years
Owner complaints for the 1997 Cadillac Deville are substantially higher than the model-year median of 44.
About this comparison →How this year compares
Owner complaints by model year
Compare all Deville years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
00–25K
1325–50K
1950–75K
2475–100K
22100–150K
3150K+
81 reports with mileage · 188 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Service Brakes, Hydraulic. Review the 55 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 47 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Fuel System, Gasoline. Review the 34 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
4 crash reports8 fire reports5 injury reports
What owners actually said
269 reportsPE 03 050 CONCERNING FUEL RAIL LEAKS. CONSUMER SMELLED FUEL ODOR WHILE DRIVING OR IDLING. VEHICLE WAS BEING INSPECTED BY A REPAIR SHOP. MANUFACTURER WAS NOTIFIED. *AK
CONSUMER COMPLAINED ABOUT FUEL RAIL SPLITTING AND CREATING A FUEL LEAK. THIS CAUSED FUEL TO SPILL ALL OVER AND AROUND THE ENGINE, WHICH COULD HAVE CAUSED A FIRE. CONSUMER STATED THAT THIS PROBLEM WAS REPAIRED, BUT THERE WAS A PRODUCT SAFETY BULLETIN ON THIS. HE DID NOT KNOW WHETHER OR NOT THIS WAS A RECALL. *AK
SMELLED GASOLINE STRONG IN CABIN AND IN ENGINE COMPARTMENT. NO VISIBLE SIGNS OF GAS UNTIL TOOK OFF TOP COVER. FOUND FUEL RAIL LEAKING AND SQUIRTING RAW GASOLINE ONTO HOT ENGINE FROM THE PLASTIC FUEL LINE BETWEEN INJECTORS. QUITE FORTUNATE THAT NO FIRE OR EXPLOSION OCCURED. SAW RECALL ON THIS SITE FOR FUEL RAIL REGARDING 97 C…
Read full complaint
SMELLED GASOLINE STRONG IN CABIN AND IN ENGINE COMPARTMENT. NO VISIBLE SIGNS OF GAS UNTIL TOOK OFF TOP COVER. FOUND FUEL RAIL LEAKING AND SQUIRTING RAW GASOLINE ONTO HOT ENGINE FROM THE PLASTIC FUEL LINE BETWEEN INJECTORS. QUITE FORTUNATE THAT NO FIRE OR EXPLOSION OCCURED. SAW RECALL ON THIS SITE FOR FUEL RAIL REGARDING 97 CAD DEVILLE BUT DEALERSHIP REFUSED TO FIX SAYING NOT ON RECALL...BUT IT IS AT NHTSA SITE. THIS NEEDS TO BE INCLUDED IN THE RECALL OF ANY OTHER MODELS WITH THIS FUEL RAIL SYSTEM. THIS IS A VERY DANGEROUS SITUATION WITH PRESSURIZED GASOLINE BEING BLOWN RIGHT ON ENGINE!! WE ARE CONCERNED THAT OTHERS MIGHT HAVE THIS SAME PROBLEM AND IT COULD RESULT IN AN EXPLOSION OR FIRE. *AK
THE CONSUMER NOTICED A NOISE EMANATING FROM UNDER THE LEFT FLOORBOARD. OVERTIME, THE MINOR NOISE BECAME A LOUD NOISE WHICH HAD COME FROM THE TRACTION CONTROL SYSTEM. THIS PROBLEM WOULD HAPPEN INTERMITTENTLY UPON ACCELERATION. THE MECHANIC ATTEMPTED TO REPAIR THE PROBLEM FOR THE PAST TWO YEARS. THE VEHICLE WOULD ALSO EXPERIE…
Read full complaint
THE CONSUMER NOTICED A NOISE EMANATING FROM UNDER THE LEFT FLOORBOARD. OVERTIME, THE MINOR NOISE BECAME A LOUD NOISE WHICH HAD COME FROM THE TRACTION CONTROL SYSTEM. THIS PROBLEM WOULD HAPPEN INTERMITTENTLY UPON ACCELERATION. THE MECHANIC ATTEMPTED TO REPAIR THE PROBLEM FOR THE PAST TWO YEARS. THE VEHICLE WOULD ALSO EXPERIENCE A COMPLETE LOST OF POWER ASSIST BRAKING, AND AT TIMES, THE VEHICLE WOULD LOSE DRIVE TRAIN POWER CAUSING THE VEHICLE TO COAST THROUGH AN INTERSECTION. THE CONSUMER HAVE EXPERIENCED THIS PROBLEM ON A DAILY BASIS. THE DEALERSHIP WAS AWARE OF THE PROBLEM BECAUSE THEY HAD SECURED THE PLUG WIRES FOR INDUCED VOLTAGE ON THE SPEED SENSOR WIRING HARNESS, A YEAR OR SO LATER, THE DEALERSHIP REPLACED THE ELECTRONIC BRAKE AND OR THE TRACTION CONTROL MODULE. *AK *SC *JB
VERY STRONG GASOLINE SMELL EVERYTIME TIME YOU GET OUT OF THE CAR OR JUST WALK BY THE CAR. NO GAS ON GROUND LEAKAGE OF GASOLINE WILL CERTAINLY START A FIRE INDEPENDENT GARAGE FOUND THE FILLER PIPE CORRODED AND LEAKING. *AK GARAGE REPLACED FILLER PIPE. OLD PIPE NOT AVAILABLE
I JANUARY 2004 I TOOK MY 97 CADILLAC DEVILLE TO BE SERVICED DUE TO AN INDICATOR LIGHT ON TO CHECK THE COOLANT SYSTEM. I WAS TOLD THAT I WOULD NEED A NEW ENGINE DUE TO THE ENGINEERING DESIGN OF THE CADILLACS SINCE 1992 OF MOUNTING STEEL BOLTS IN ALLUMINUM MOTOR MOUNT WHICH WAS DESIGNED TO LAST ONLY UP TO 100,000 MILES. THE OPTI…
Read full complaint
I JANUARY 2004 I TOOK MY 97 CADILLAC DEVILLE TO BE SERVICED DUE TO AN INDICATOR LIGHT ON TO CHECK THE COOLANT SYSTEM. I WAS TOLD THAT I WOULD NEED A NEW ENGINE DUE TO THE ENGINEERING DESIGN OF THE CADILLACS SINCE 1992 OF MOUNTING STEEL BOLTS IN ALLUMINUM MOTOR MOUNT WHICH WAS DESIGNED TO LAST ONLY UP TO 100,000 MILES. THE OPTIONS I WAS GIVER WERE TO REPLACE THE ENGINE OR HAVE THE MOUNTS REBUILT BUT THE LATER NO LONGER CAME WITH A WARRANTY OPTION SINCE A FAMILY OPTED FOR THAT AT WHICH TIME THEIR ENGINE FELL OUT IN THE MIDDLE OF THE ROAD ON THEIR WAY TO CALIFORNIA. GM INFORMED ME THAT THEY WOULD GIVE NO ASSISTANCE FOR ANY SOURCE OF REPAIR WITH OPENLY ADMITTING THEY WERE AWARE OF THE DEFECT BUT WERE NOT PLANNING TO MAKE ANY CHANGES TO THE ENGINE DESIGN MUCH LESS RECALL THE VEHICLES. AFTER SPENDING MANY HOURS COMMUNICATING WITH THEM AND AN ATTORNEY WRITING A COURTESY LETTER ON MY BEHALF, THEIR RESOLVE WAS TO GIVE ME A CERTIFICATE TOWARDS THE PURCHASE OF A NEW VEHICLE. THEY HAVE ENO CONCERN THAT THIS PROBLEM IS A SAFETY ISSUE, AS WELL AS A DELIBERATE ENGINEERING DESIGN FLAW TO CAUSE THE CONSUMER TO CONTINUE TO SPEND MONEY. GM INDICATED THAT THEY WERE PERFECTLY HAPPY WITH FALSE ADVERTISEMENT STATING THEY BACKED THEIR PRODUCT WITH INTEGRITY AND QUALITY ALL WELL KNOWING THIS IS A LIE TO THE PUBLIC. TELLING LIES AND STEALING FROM THE AMERICAN CONSUMER HAS TO STOP! UNFORTUNATELY THE COURTS WILL NOT GO AGAINST GM BUT HOPEFULLY THE NEWS MEDIA WILL TAKE A STAND FOR THE AMERICAN CONSUMER. *AK
MY 1997 CADILLAC DEVILLE STALLED WHILE DRIVING. THIS HAS HAPPENED AT STEADY SPEED ON THE FREEWAY, WHILE EXITING ON A CLOVER LEAF RAMP AT HIGHWAY SPEEDS, WHILE DRIVING ON A COUNTRY ROAD, WHILE APPROACHING A STOP SIGN. THE DEALER SERVICE DEPT. SAYS IT SHOWS CODES THAT CAR STALLED BUT NO REASON. THEREFORE, EVEN THOUGH THE CAR IS U…
Read full complaint
MY 1997 CADILLAC DEVILLE STALLED WHILE DRIVING. THIS HAS HAPPENED AT STEADY SPEED ON THE FREEWAY, WHILE EXITING ON A CLOVER LEAF RAMP AT HIGHWAY SPEEDS, WHILE DRIVING ON A COUNTRY ROAD, WHILE APPROACHING A STOP SIGN. THE DEALER SERVICE DEPT. SAYS IT SHOWS CODES THAT CAR STALLED BUT NO REASON. THEREFORE, EVEN THOUGH THE CAR IS UNDER CADILLAC EXTENDED WARRANTY, THEY WILL NOT ATTEMPT TO DIAGNOSE THE PROBLEM UNLESS THE CAR STALLS WHILE THEY ARE DRIVING IT OR IF THE STALL LEAVES A CODE STATING THE CAUSE. I FEEL THE CAR IS UNSAFE FOR MY FAMILY TO BE DRIVING AND AM FRUSTRATED THAT THEY WON'T TRY TO FIX THE PROBLEM. I'VE CALLED CADILLAC CUSTOMER CARE, THE DEALER'S GMGR, THE SVC. MGR. AND THEY ALL SAY THEY WON'T DO ANYTHING TILL IT ACTS UP FOR THEM. IF I PUT THE CAR IN NEUTRAL, I CAN ALWAYS RESTART, BUT IF THIS CONDITION OCCURS IN HIGHWAY TRAFFIC WITH A VEHICLE FOLLOWING CLOSE, THERE COULD BE HORRIBLE CONSEQUENCES.*AK
VEHICLE BURNS OIL EXCESSIVELY. *AK THE VEHICLE MAY STOP WORKING AT ANYTIME. IT SEEMED AS THOUGH THE ENGINE DIDN'T HAVE AN OIL PAN. THE OIL WAS CHANGED REGULARLY AS SCHEDULED AND WOULD BURN 2 TO 4 QUARTS BETWEEN CHANGES AND BEGAN TO USE MORE BETWEEN 39K TO 42K MILES. THE MANUFACTURER WAS MADE AWARE OF THE PROBLEM BUT WOULD…
Read full complaint
VEHICLE BURNS OIL EXCESSIVELY. *AK THE VEHICLE MAY STOP WORKING AT ANYTIME. IT SEEMED AS THOUGH THE ENGINE DIDN'T HAVE AN OIL PAN. THE OIL WAS CHANGED REGULARLY AS SCHEDULED AND WOULD BURN 2 TO 4 QUARTS BETWEEN CHANGES AND BEGAN TO USE MORE BETWEEN 39K TO 42K MILES. THE MANUFACTURER WAS MADE AWARE OF THE PROBLEM BUT WOULD NOT HELP REMEDY THE PROBLEM. *SC *JB
FUEL RAIL PRODUCED A LEAK. CONSUMER WAS CONCERNED THAT THE VEHICLE WILL CATCH ON FIRE. *AK
Official recalls
204V110000 · Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
Mar 4, 2004
SOME PASSENGER VEHICLES EQUIPPED WITH 4.0L V8 ENGINES HAVE A CONDITION IN WHICH THE NYLON TUBING USED IN THE FUEL RAIL CONSTRUCTION MAY DEGRADE AND CRACK. ADDITIONALLY, THE 1995 MODEL YEAR USES A UNIQUE UNDERHOOD FUEL RETURN LINE THAT MAY CRACK. CRACKING OF THE FUEL RAIL OR RETURN LINE TUBING CAN RESULT IN A FUEL LEAK INTO THE ENGINE COMPARTMENT.
Consequence & remedy
Consequence: FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy: DEALERS WILL INSPECT AND, IF NECESSARY, REPLACE THE ENGINE FUEL RAIL WITH A NEW STAINLESS STEEL FUEL RAIL. DEALERS WILL ALSO INSTALL A REVISED CHASSIS FUEL RETURN LINE. THE RECALL BEGAN ON JUNE 2, 2004, FOR 1996-1997 OLDSMOBILE AURORA VEHICLES. OWNERS OF 1995 CADILLACS AND 1996-1997 OLDSMOBILE AURORA WERE SENT LETTERS ON AUGUST 6, 2004. ADDITIONAL LETTERS TO OWNERS WILL BE FORTHCOMING. OWNERS SHOULD CONTACT OLDSMOBILE AT 1-800-630-6537.
97V064000 · Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip
Apr 28, 1997
THE ELECTRONIC BRAKE CONTROL MODULE OR THE ELECTRONIC BRAKE AND TRACTION CONTROL MODULE CAN CAUSE THE ANTILOCK BRAKE SYSTEM (ABS) TO CYCLE DURING A NON-ABS BRAKE APPLICATION.
Consequence & remedy
Consequence: THIS CONDITION CAN RESULT IN AN INCREASE IN VEHICLE STOPPING DISTANCE INCREASING THE RISK OF A VEHICLE CRASH.
Remedy: DEALERS WILL REPLACE THE ELECTRONIC BRAKE CONTROL MODULE OR THE ELECTRONIC BRAKE AND TRACTION CONTROL MODULE.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
5EA04003 · Fuel Rail Leaks
Opened Feb 3, 2004 · Closed Apr 23, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:delivery; Fuel System, Gasoline:fuel Injection System:fuel Rail
ON MARCH 3, 2004, GENERAL MOTORS NOTIFIED ODI THAT IT WAS RECALLING APPROXIMATELY 94,000 MY 1995-97 OLDSMOBILE AURORA VEHICLES EQUIPPED WITH 4.0L V8 ENGINES (RPO L47 - VIN8 C) TO ADDRESS CONCERNS WITH UNDERHOOD FUEL LEAKAGE FROM CRACKED FUEL RAILS AND, IN SOME OF THE VEHICLES, CRACKED FUEL RETURN LINES. ACCORDING TO GM, THE NYLON TUBING (PA12) USED IN THE FUEL RAIL CONSTRUCTION IN THESE VEHICLES MAY DEGRADE AND CRACK.GM'S SUPPLIER ATTRIBUTED THE CRACKING TO THE COMBINED EFFECTS OF HEAT, TIME, ALCOHOL FUEL, FUEL PRESSURE CYCLING, AND DESIGN STRESSES.IN ADDITION, GM STATED THAT THE MY 1995 AURORA USES A UNIQUE UNDERHOOD FUEL RETURN LINE THAT MAY ALSO CRACK AT UNUSUALLY HIGH RATES.GM DEALERS WILL INSTALL A NEW FUEL RAIL CONSTRUCTED OUT OF STAINLESS STEEL IN ALL OF THE RECALLED VEHICLES AND WILL ALSO INSTALL A REVISED CHASSIS FUEL RETURN LINE IN THE MY 1995 AURORAS. ON APRIL 16, 2004, GENERAL MOTORS NOTIFIED ODI THAT IT WAS ADDING APPROXIMATELY 389,000 MY 1995-97 CADILLAC SEVILLE, DEVILLE AND ELDORADO VEHICLES EQUIPPED WITH 4.6L V8 ENGINES (RPO'S LD8 AND L37 - VIN8 Y AND 9) TO RECALL 04V-110.THE RECALLED CADILLACS WILL RECEIVE THE NEW STAINLESS STEEL FUEL RAILS.THIS ENGINEERING ANALYSIS IS CLOSED.
Additional source detail variants (3)
Fuel System, Gasoline:delivery
ON MARCH 3, 2004, GENERAL MOTORS NOTIFIED ODI THAT IT WAS RECALLING APPROXIMATELY 94,000 MY 1995-97 OLDSMOBILE AURORA VEHICLES EQUIPPED WITH 4.0L V8 ENGINES (RPO L47 - VIN8 C) TO ADDRESS CONCERNS WITH UNDERHOOD FUEL LEAKAGE FROM CRACKED FUEL RAILS AND, IN SOME OF THE VEHICLES, CRACKED FUEL RETURN LINES. ACCORDING TO GM, THE NYLON TUBING (PA12) USED IN THE FUEL RAIL CONSTRUCTION IN THESE VEHICLES MAY DEGRADE AND CRACK.GM'S SUPPLIER ATTRIBUTED THE CRACKING TO THE COMBINED EFFECTS OF HEAT, TIME, ALCOHOL FUEL, FUEL PRESSURE CYCLING, AND DESIGN STRESSES.IN ADDITION, GM STATED THAT THE MY 1995 AURORA USES A UNIQUE UNDERHOOD FUEL RETURN LINE THAT MAY ALSO CRACK AT UNUSUALLY HIGH RATES.GM DEALERS WILL INSTALL A NEW FUEL RAIL CONSTRUCTED OUT OF STAINLESS STEEL IN ALL OF THE RECALLED VEHICLES AND WILL ALSO INSTALL A REVISED CHASSIS FUEL RETURN LINE IN THE MY 1995 AURORAS. ON APRIL 16, 2004, GENERAL MOTORS NOTIFIED ODI THAT IT WAS ADDING APPROXIMATELY 389,000 MY 1995-97 CADILLAC SEVILLE, DEVILLE AND ELDORADO VEHICLES EQUIPPED WITH 4.6L V8 ENGINES (RPO'S LD8 AND L37 - VIN8 Y AND 9) TO RECALL 04V-110.THE RECALLED CADILLACS WILL RECEIVE THE NEW STAINLESS STEEL FUEL RAILS.THIS ENGINEERING ANALYSIS IS CLOSED.
Fuel System, Gasoline:fuel Injection System:fuel Rail
ON MARCH 3, 2004, GENERAL MOTORS NOTIFIED ODI THAT IT WAS RECALLING APPROXIMATELY 94,000 MY 1995-97 OLDSMOBILE AURORA VEHICLES EQUIPPED WITH 4.0L V8 ENGINES (RPO L47 - VIN8 C) TO ADDRESS CONCERNS WITH UNDERHOOD FUEL LEAKAGE FROM CRACKED FUEL RAILS AND, IN SOME OF THE VEHICLES, CRACKED FUEL RETURN LINES. ACCORDING TO GM, THE NYLON TUBING (PA12) USED IN THE FUEL RAIL CONSTRUCTION IN THESE VEHICLES MAY DEGRADE AND CRACK.GM'S SUPPLIER ATTRIBUTED THE CRACKING TO THE COMBINED EFFECTS OF HEAT, TIME, ALCOHOL FUEL, FUEL PRESSURE CYCLING, AND DESIGN STRESSES.IN ADDITION, GM STATED THAT THE MY 1995 AURORA USES A UNIQUE UNDERHOOD FUEL RETURN LINE THAT MAY ALSO CRACK AT UNUSUALLY HIGH RATES.GM DEALERS WILL INSTALL A NEW FUEL RAIL CONSTRUCTED OUT OF STAINLESS STEEL IN ALL OF THE RECALLED VEHICLES AND WILL ALSO INSTALL A REVISED CHASSIS FUEL RETURN LINE IN THE MY 1995 AURORAS. ON APRIL 16, 2004, GENERAL MOTORS NOTIFIED ODI THAT IT WAS ADDING APPROXIMATELY 389,000 MY 1995-97 CADILLAC SEVILLE, DEVILLE AND ELDORADO VEHICLES EQUIPPED WITH 4.6L V8 ENGINES (RPO'S LD8 AND L37 - VIN8 Y AND 9) TO RECALL 04V-110.THE RECALLED CADILLACS WILL RECEIVE THE NEW STAINLESS STEEL FUEL RAILS.THIS ENGINEERING ANALYSIS IS CLOSED.
Fuel System, Gasoline
ON MARCH 3, 2004, GENERAL MOTORS NOTIFIED ODI THAT IT WAS RECALLING APPROXIMATELY 94,000 MY 1995-97 OLDSMOBILE AURORA VEHICLES EQUIPPED WITH 4.0L V8 ENGINES (RPO L47 - VIN8 C) TO ADDRESS CONCERNS WITH UNDERHOOD FUEL LEAKAGE FROM CRACKED FUEL RAILS AND, IN SOME OF THE VEHICLES, CRACKED FUEL RETURN LINES. ACCORDING TO GM, THE NYLON TUBING (PA12) USED IN THE FUEL RAIL CONSTRUCTION IN THESE VEHICLES MAY DEGRADE AND CRACK.GM'S SUPPLIER ATTRIBUTED THE CRACKING TO THE COMBINED EFFECTS OF HEAT, TIME, ALCOHOL FUEL, FUEL PRESSURE CYCLING, AND DESIGN STRESSES.IN ADDITION, GM STATED THAT THE MY 1995 AURORA USES A UNIQUE UNDERHOOD FUEL RETURN LINE THAT MAY ALSO CRACK AT UNUSUALLY HIGH RATES.GM DEALERS WILL INSTALL A NEW FUEL RAIL CONSTRUCTED OUT OF STAINLESS STEEL IN ALL OF THE RECALLED VEHICLES AND WILL ALSO INSTALL A REVISED CHASSIS FUEL RETURN LINE IN THE MY 1995 AURORAS. ON APRIL 16, 2004, GENERAL MOTORS NOTIFIED ODI THAT IT WAS ADDING APPROXIMATELY 389,000 MY 1995-97 CADILLAC SEVILLE, DEVILLE AND ELDORADO VEHICLES EQUIPPED WITH 4.6L V8 ENGINES (RPO'S LD8 AND L37 - VIN8 Y AND 9) TO RECALL 04V-110.THE RECALLED CADILLACS WILL RECEIVE THE NEW STAINLESS STEEL FUEL RAILS.THIS ENGINEERING ANALYSIS IS CLOSED.
PE03050 · Fuel Rail Leakage
Opened Oct 30, 2003 · Closed Feb 3, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline:fuel Injection System:fuel Rail
THE FUEL RAIL ASSEMBLIES USED IN THE SUBJECT VEHICLES WERE MANUFACTURED BY DANA.THE FUEL RAIL JUMPER TUBES WERE MADE OF MONOLAYER NYLON 12 (PA12).IN MODEL YEAR (MY) 1998, THE JUMPER TUBE MATERIAL WAS CHANGED FROM PA12 TO M-BOND (A MULTI-LAYER PTFE/PA12).IN ADDITION, ALL SERVICE PARTS PRODUCED SINCE THE END OF PRODUCTION 1997 USE THE M-BOND JUMPER TUBES. MATERIAL ANALYSIS PERFORMED BY DANA ON FAILED FUEL RAILS SHOWED THAT THE MONO-LAYER NYLON 12 JUMPER TUBES ARE SUSCEPTIBLE TO ENVIRONMENTAL STRESS CRACKING (ESC).GM BELIEVES THE ESC IS A RESULT OF HEAT, TIME, ALCOHOL BLENDED FUEL, FUEL PRESSURE CYCLING, AND DESIGNED IN STRESS. EIGHT OF THE GM COMPLAINTS ARE DUPLICATIVE OF ODI COMPLAINTS.ODI HAS RECEIVED 77 OF IT'S 123 COMPLAINTS IN THE PAST 12 MONTHS.FUEL RAIL PART SALES OVER THE LAST THREE YEARS RANGE FROM 3.0 PERCENT OF PRODUCTION FOR THE MY 1997 CADILLAC VEHICLES TO 13.1 PERCENT FOR THE MY 1995 AURORAS.AT LEAST ONE OF THE FIRE INCIDENTS OCCURED WHILE THE VEHICLE WAS PARKED WITHIN A GARAGE ATTACHED TO THE CONSUMERS HOME.THE FIRE RESULTED IN DAMAGE TO THE DWELLING AS WELL AS THE TOTAL LOSS OF THE VEHICLE.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS.
RQ03001 · Power Rack And Pinion Steering Failure
Opened Jan 2, 2003 · Closed Sep 15, 2003
Status: closed (inferred from source dates) · Steering; Steering:rack And Pinion
GM CONDUCTED A SAFETY RECALL (NHTSA # 02V286) TO ADDRESS A STEERING DEFECT PERTAINING TO A LOWER PINION BEARING (LPB) WITHIN THE RACK AND PINION STEERING GEAR (R&P). THE RECALL COVERED 1,159,156 MODEL YEAR 1997-1998 PONTIAC GRAND PRIX VEHICLES BUILT BETWEEN MARCH 1, 1996 AND OCTOBER 31, 1997, 1996-1998 PONTIAC TRANS SPORT, CHEVROLET LUMINA APV, CHEVROLET VENTURE, OLDSMOBILE SILHOUETTE MINIVANS, AND CHEVROLET CAVALIER AND PONTIAC SUNFIRE SEDANS BUILT BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997.ODI OPENED THIS RQ AFTER RECEIVING REPORTS THAT OTHER VEHICLES WERE EXHIBITING THE SAME SYMPTOMS AS THE RECALLED VEHICLES.BASED ON ODI'S REVIEW OF TECHNICAL AND COMPLAINT DATA COLLECTED DURING THE RQ, THE W-CARS ARE ASSOCIATED WITH EITHER A HIGHER STEERING COMPLAINT RATE OR A HIGHER LPB FAILURE RATE THAN THE OTHER VEHICLES INVESTIGATED UNDER THE RQ AND ARE ABOVE OR NEAR THE RATES FOR THE RECALLED VEHICLES.THUS, ODI WILL FURTHER EXAMINE THE W-CARS (1996-1997 OLDSMOBILE CUTLASS SUPREME, 1996-1998 BUICK REGAL, CHEVROLET LUMINA, CHEVROLET MONTE CARLO, 1997-1998 BUICK CENTURY, AND 1998 OLDSMOBILE INTRIGUE) UNDER A NEW INVESTIGATION, ENGINEERING ANALYSIS (EA)03-019.
Additional source detail variants (2)
Steering
GM CONDUCTED A SAFETY RECALL (NHTSA # 02V286) TO ADDRESS A STEERING DEFECT PERTAINING TO A LOWER PINION BEARING (LPB) WITHIN THE RACK AND PINION STEERING GEAR (R&P). THE RECALL COVERED 1,159,156 MODEL YEAR 1997-1998 PONTIAC GRAND PRIX VEHICLES BUILT BETWEEN MARCH 1, 1996 AND OCTOBER 31, 1997, 1996-1998 PONTIAC TRANS SPORT, CHEVROLET LUMINA APV, CHEVROLET VENTURE, OLDSMOBILE SILHOUETTE MINIVANS, AND CHEVROLET CAVALIER AND PONTIAC SUNFIRE SEDANS BUILT BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997.ODI OPENED THIS RQ AFTER RECEIVING REPORTS THAT OTHER VEHICLES WERE EXHIBITING THE SAME SYMPTOMS AS THE RECALLED VEHICLES.BASED ON ODI'S REVIEW OF TECHNICAL AND COMPLAINT DATA COLLECTED DURING THE RQ, THE W-CARS ARE ASSOCIATED WITH EITHER A HIGHER STEERING COMPLAINT RATE OR A HIGHER LPB FAILURE RATE THAN THE OTHER VEHICLES INVESTIGATED UNDER THE RQ AND ARE ABOVE OR NEAR THE RATES FOR THE RECALLED VEHICLES.THUS, ODI WILL FURTHER EXAMINE THE W-CARS (1996-1997 OLDSMOBILE CUTLASS SUPREME, 1996-1998 BUICK REGAL, CHEVROLET LUMINA, CHEVROLET MONTE CARLO, 1997-1998 BUICK CENTURY, AND 1998 OLDSMOBILE INTRIGUE) UNDER A NEW INVESTIGATION, ENGINEERING ANALYSIS (EA)03-019.
Steering:rack And Pinion
GM CONDUCTED A SAFETY RECALL (NHTSA # 02V286) TO ADDRESS A STEERING DEFECT PERTAINING TO A LOWER PINION BEARING (LPB) WITHIN THE RACK AND PINION STEERING GEAR (R&P). THE RECALL COVERED 1,159,156 MODEL YEAR 1997-1998 PONTIAC GRAND PRIX VEHICLES BUILT BETWEEN MARCH 1, 1996 AND OCTOBER 31, 1997, 1996-1998 PONTIAC TRANS SPORT, CHEVROLET LUMINA APV, CHEVROLET VENTURE, OLDSMOBILE SILHOUETTE MINIVANS, AND CHEVROLET CAVALIER AND PONTIAC SUNFIRE SEDANS BUILT BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997.ODI OPENED THIS RQ AFTER RECEIVING REPORTS THAT OTHER VEHICLES WERE EXHIBITING THE SAME SYMPTOMS AS THE RECALLED VEHICLES.BASED ON ODI'S REVIEW OF TECHNICAL AND COMPLAINT DATA COLLECTED DURING THE RQ, THE W-CARS ARE ASSOCIATED WITH EITHER A HIGHER STEERING COMPLAINT RATE OR A HIGHER LPB FAILURE RATE THAN THE OTHER VEHICLES INVESTIGATED UNDER THE RQ AND ARE ABOVE OR NEAR THE RATES FOR THE RECALLED VEHICLES.THUS, ODI WILL FURTHER EXAMINE THE W-CARS (1996-1997 OLDSMOBILE CUTLASS SUPREME, 1996-1998 BUICK REGAL, CHEVROLET LUMINA, CHEVROLET MONTE CARLO, 1997-1998 BUICK CENTURY, AND 1998 OLDSMOBILE INTRIGUE) UNDER A NEW INVESTIGATION, ENGINEERING ANALYSIS (EA)03-019.
EA00004 · Inadvertent Of Side Impact Air Bag
Opened Feb 15, 2000 · Closed Sep 28, 2000
Status: closed (inferred from source dates) · Air Bags:side/window
There is no summary currently available
PE98005 · Erratic Turn Signal Operation
Opened Feb 6, 1998 · Closed Aug 27, 1998
Status: closed (inferred from source dates) · Exterior Lighting
No summary supplied.