Electrical System. Review the 35 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Engine. Review the 26 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Engine And Engine Cooling. Review the 10 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

5 crash reports14 fire reports5 injury reports

Service Brakes, Hydraulic complaints

4 reports

Clear category filter

110,000 miles · Jul 9, 2014

Service BrakesService Brakes, Hydraulic

TL* THE CONTACT OWNS A 2003 BUICK REGAL. THE CONTACT STATED THAT WHILE INSPECTING THE VEHICLE, HE NOTICED THAT THE BRAKE LINE WAS COMPLETELY CORRODED. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS ADVISED THAT THE BRAKE LINE NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE…

Read full complaint

NHTSA ODI #10609174

195,716 miles · Nov 3, 2011

Electrical SystemEngine And Engine CoolingPower Train

Read full complaint

TL* THE CONTACT OWNS A 2003 BUICK REGAL. THE CONTACT STATED THAT THE VEHICLE WAS OVERHEATING AND WOULD LOSE POWER WITHOUT WARNING. THE VEHICLE WAS TAKEN TO THE DEALER WHERE HE WAS INFORMED THAT THE CATALYTIC CONVERTER, IDLE AIR CONTROL VALVE AND THE MANIFOLD ABSOLUTE PRESSURE WERE DEFECTIVE AND NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE NOR WAS THE VEHICLE REPAIRED. UPDATED 12/12/11*LJ THE CONSUMER STATED THE EXHAUST MANIFOLD FRONT AND REAR GLOWED REED HOT. THE ENGINE TEMPERATURE GAUGE WAS IN THE RED. COOLANT LEAKED FROM A HOSE NEAR THE ENGINE AND THE ENGINE BEGAN TO EMIT BLUE SMOKE. THE VEHICLE BURNED ONE QUART OF OIL EXCESSIVELY. THE BATTERY, THERMOSTAT, FRONT BRAKES, TRANSMISSION OIL FILTER AND GASKET WERE ALL REPLACED. ALSO, THE DRIVER REAR WINDOW WAS INOPERATIVE, THE WINDSHIELD WASHER WAS SPRAYER DID NOT WORK, THE CATALYTIC CONVERTER NEEDED TO BE REPLACED AND THE HEAT/AC BLOWER DID NOT OPERATE IN ALL THE SETTINGS. UPDATED 12/23/11

NHTSA ODI #10434147

17,700 miles · May 31, 2005

Power TrainService Brakes, Hydraulic

Read full complaint

(1) I HAVE A 2003 BUICK REGAL WITH MILEAGE OF 17700.THIS MORNING AT 9 AM WHEN I STOPPED BEFORE THE TRAFFIC LIGHT IN THE INTERSECTION OF MOUND RD AND 13 MILE RD. (2) SUDDENLY THE BRAKE PEDAL APPEARS TO BE VERY LOOSE AND THE CAR STARTS GOING BACKWARD SLOWLY. I KEEP ON PRESSING THE BRAKE BUT THE CAR KEEPS GOING BACKWARD. I SWITCHED TO PARKING GEAR AND THEN DRIVING GEAR AND PRESS THE GASPEDAL AND THE CAR STARTS MOVING FORWARD. BOTH MY WIFE AND I WERE IN THE CAR. FORTUNATELY NO CAR WAS BEHIND US SO NO ACCIDENT OCCURED. (3) THE DEALER CHECKED THE CAR AND CAN NOT FIND WHAT IS THE PROBLEM. SO THEY ASKED US TO CONTINUE DRIVING UNTIL THE PROBLEM HAPPENS AGAIN! HOW CAN WE CONTINUE DRIVING A CAR WHICH ALMOST LED TO A FATAL ACCIDENT? THAT IS CRAZY!

NHTSA ODI #10122584

11,000 miles · Jun 4, 2004

Air BagsService Brakes, HydraulicCrashInjury

WHILE TRAVELING AT 25 MPH IN TRAFFIC DRIVER APPLIED THE BRAKES AND THE BRAKE PEDAL WAS VERY HARD. AS A RESULT, THE DRIVER HIT ANOTHER VEHICLE. *AK THE AIR BAG FAILED TO DEPLOY DURING THE ACCIDENT. THE VEHICLE SUSTAINED $9700 DAMAGE BUT THE OTHER VEHICLE SUSTAINED NO DAMAGE. *NM

NHTSA ODI #10071481

Official recalls

15V701000 · Engine And Engine Cooling:engine; Engine And Engine Cooling:exhaust System:manifold/header/muffler/tail Pipe

Oct 26, 2015

General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.

Consequence & remedy

Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.

Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.

Additional source detail variants (2)

Engine And Engine Cooling:exhaust System:manifold/header/muffler/tail Pipe

Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.

Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.

Engine And Engine Cooling:engine

Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.

09V116000 · Engine And Engine Cooling

Apr 8, 2009

GENERAL MOTORS IS RECALLING 1,497,516 MY 1997-2003 BUICK REGAL, MY 1998-2003 CHEVROLET LUMINA, MONTE CARLO AND IMPALA, MY 1998-1999 OLDSMOBILE INTRIGUE, MY 1997-2003 PONTIAC GRAND PRIX VEHICLES EQUIPPED WITH A 3.8L V6 NATURALLY ASPIRATED ENGINE. SOME OF THESE VEHICLES HAVE A CONDITION IN WHICH DROPS OF ENGINE OIL MAY BE DEPOSITED ON THE EXHAUST MANIFOLD THROUGH HARD BRAKING.

Consequence & remedy

Consequence: IF THE MANIFOLD IS HOT ENOUGH AND THE OIL RUNS BELOW THE HEAT SHIELD, IT MAY IGNITE INTO A SMALL FLAME AND MAY SPREAD TO THE PLASTIC SPARK PLUG WIRE CHANNEL AND BEYOND INCREASING THE RISK OF AN ENGINE COMPARTMENT FIRE.

Remedy: DEALERS WILL REPLACE THE ENGINES FRONT VALVE COVER AND FRONT-VALVE-COVER GASKET WITH NEW PARTS OF AN IMPROVED DESIGN AND REMOVE THE ENGINES PLASTIC COVER AND PLASTIC OIL-FILL-TUBE EXTENSION, FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2016. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, OLDSMOBILE AT 1-800-630-6537, AND PONTIAC AT 1-800-620-7668 OR HTTP://WWW.PONTIAC.COM OR HTTP:WWW.GMOWNERCENTER.COM.

08V118000 · Engine And Engine Cooling

Mar 12, 2008

GM IS RECALLING 207,542 MY 1997-2003 BUICK REGAL AND PONTIAC GRAND PRIX VEHICLES EQUIPPED WITH A 3.8L SUPERCHARGED V-6 ENGINE. THESE VEHICLES HAVE HIGHER FRONT ROCKER COVER GASKET TEMPERATURES, CREATING THE POTENTIAL FOR EARLIER DEGRADATION OF THE FRONT ROCKER COVER GASKET AND EVENTUAL OIL SEEPAGE.

Consequence & remedy

Consequence: CERTAIN UNDERHOOD FIRES MAY BE CAUSED BY DROPS OF ENGINE OIL, FROM SEEPAGE OR SPILLAGE, BEING DEPOSITED ON THE EXHAUST MANIFOLD THROUGH HARD BRAKING. IF THE MANIFOLD IS HOT ENOUGH AND THE OIL RUNS BELOW THE HEAT SHIELD, IT MAY IGNITE INTO A SMALL FLAME AND, IN SOME INSTANCES, THE FIRE MAY SPREAD TO THE PLASTIC SPARK PLUG WIRE CHANNEL AND BEYOND.

Remedy: DEALERS WILL REPLACE THE ENGINES FRONT VALVE COVER AND FRONT-VALVE-COVER GASKET WITH NEW PARTS OF AN IMPROVED DESIGN AND REMOVE THE ENGINES PLASTIC COVER AND PLASTIC OIL-FILL-TUBE EXTENSION, ALONG WITH THE 1-3-5 SPARK PLUG WIRE RETAINERS, FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2016. , FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2016. UNTIL THE REMEDY IS COMPLETED, GM STRONGLY RECOMMENDS THAT OWNERS OBSERVE THE FOLLOWING IMPORTANT PRECAUTIONS (1) THAT OWNERS DO NOT PARK THEIR VEHICLE IN A GARAGE, CAR PORT, OR OTHER STRUCTURE; (2) IF OWNERS NOTICE A BURNING ODOR, THEY SHOULD HAVE THEIR DEALER INSPECT THE VEHICLE. THE DEALER WILL INSPECT THE VEHICLE WITHOUT CHARGE; (3) USE PREMIUM FUEL (91 OCTANE OR HIGHER) IN THE VEHICLE AS RECOMMENDED IN THE VEHICLE'S OWNER MANUAL. OWNERS MAY CONTACT BUICK AT 1-866-608-8080 OR PONTIAC AT 1-800-620-7668, OR THROUGH THEIR WEBSITE AT <A HREF=HTTP://WWW.GMOWNERCENTER.COM>HTTP://WWW.GMOWNERCENTER.COM</A> .

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

No exact-year investigations in this snapshot.