NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
187 reports19,000 miles · Aug 11, 2010
Structure
TL*THE CONTACT OWNS A 2001 BUICK REGAL. THE CONTACT NOTICED THAT THERE WAS POWER STEERING FLUID LEAKING ALL OVER HIS DRIVEWAY. THE VEHICLE WAS TOWED TO THE DEALER, WHERE THEY STATED THAT THERE WAS RUST CORROSION UNDERNEATH THE VEHICLE. THE CORROSION WAS CAUSING THE LEAK AND THEY STATED THAT THEY WILL HAVE TO REPLACE ALL OF THE P…
Read full complaint
TL*THE CONTACT OWNS A 2001 BUICK REGAL. THE CONTACT NOTICED THAT THERE WAS POWER STEERING FLUID LEAKING ALL OVER HIS DRIVEWAY. THE VEHICLE WAS TOWED TO THE DEALER, WHERE THEY STATED THAT THERE WAS RUST CORROSION UNDERNEATH THE VEHICLE. THE CORROSION WAS CAUSING THE LEAK AND THEY STATED THAT THEY WILL HAVE TO REPLACE ALL OF THE PARTS THAT WERE CORRODED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 19000.
NHTSA ODI #10348708
74,882 miles · Jul 24, 2010
Fuel System, GasolineStructure
2001 BUICK REGAL GS. FUEL FILLER PIPE RUSTED OUT, SUB FRAME VERY RUSTY, AND REAR BUMPER SUPPORT RUSTED OUT. ALL HAD TO BE REPLACED. HAD NOTIFIED BUICK ON MAY 25, 2010 AND THEY GAVE ME A CASE NUMBER ( [XXX] ) BUICK SAID THERE WAS NOTHING THEY COULD DO FOR ME AS THERE WAS NO RECALL ON THIS CAR. INFORMATION REDACTED PURSUANT TO…
Read full complaint
2001 BUICK REGAL GS. FUEL FILLER PIPE RUSTED OUT, SUB FRAME VERY RUSTY, AND REAR BUMPER SUPPORT RUSTED OUT. ALL HAD TO BE REPLACED. HAD NOTIFIED BUICK ON MAY 25, 2010 AND THEY GAVE ME A CASE NUMBER ( [XXX] ) BUICK SAID THERE WAS NOTHING THEY COULD DO FOR ME AS THERE WAS NO RECALL ON THIS CAR. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
NHTSA ODI #10345075
200,000 miles · Jun 30, 2010
Engine And Engine CoolingFire
MY VEHICLE HAD THE NECESSARY RECALL WORK DONE, BUT IT STILL CAUGHT FIRE AND IS NO LONGER IN WORKING ORDER. THE WHOLE ENGINE IS BURNT TO A CRISP... *TR
NHTSA ODI #10340788
Mileage unknown · Jun 17, 2010
Electrical System
TL* THE CONTACT OWNS A 2001 BUICK REGAL. THE CONTACT STATED THAT IN ORDER TO START THE VEHICLE, SHE WOULD HAVE TO ENGAGE THE HAZARD LIGHTS FIRST AND THEN TURN THE IGNITION BEFORE IT WOULD START. THE DASHBOARD COMPONENTS WOULD ILLUMINATE SPORADICALLY AND THE FUEL LEVEL GAUGE, GEAR SHIFTER, AND ODOMETER WERE ALL INOPERABLE. THE VE…
Read full complaint
TL* THE CONTACT OWNS A 2001 BUICK REGAL. THE CONTACT STATED THAT IN ORDER TO START THE VEHICLE, SHE WOULD HAVE TO ENGAGE THE HAZARD LIGHTS FIRST AND THEN TURN THE IGNITION BEFORE IT WOULD START. THE DASHBOARD COMPONENTS WOULD ILLUMINATE SPORADICALLY AND THE FUEL LEVEL GAUGE, GEAR SHIFTER, AND ODOMETER WERE ALL INOPERABLE. THE VEHICLE WAS NOT REPAIRED AND THE CONTACT WAS UNAWARE IF THERE WERE ANY RECALLS ON THE VEHICLE. THE FAILURE AND CURRENT MILEAGES WERE UNKNOWN.
NHTSA ODI #10336816
99,584 miles · Mar 19, 2010
Engine And Engine CoolingPower Train
TL*THE CONTACT OWNS A 2001 BUICK REGAL. THE CONTACT STARTED THE ENGINE ON A COLD START AND A SHAKING MOTION OCCURRED. ADDITIONALLY, WHENEVER THE VEHICLE WAS IN OPERATION THE ENGINE POWER FAILED TO ALLOW THE VEHICLE TO EXCEED OVER 25 MPH. ALSO, THE TRANSMISSION WAS LEAKING TRANSMISSION FLUID. THE VEHICLE WAS TAKEN TO A LOCAL DEAL…
Read full complaint
TL*THE CONTACT OWNS A 2001 BUICK REGAL. THE CONTACT STARTED THE ENGINE ON A COLD START AND A SHAKING MOTION OCCURRED. ADDITIONALLY, WHENEVER THE VEHICLE WAS IN OPERATION THE ENGINE POWER FAILED TO ALLOW THE VEHICLE TO EXCEED OVER 25 MPH. ALSO, THE TRANSMISSION WAS LEAKING TRANSMISSION FLUID. THE VEHICLE WAS TAKEN TO A LOCAL DEALER FOR INSPECTION. THE FAILURE WAS CONTRIBUTED TO THE POWER TRAIN, TRANSMISSION AND ENGINE. THE VEHICLE HAS NOT BEEN REPAIRED FOR THE MALFUNCTIONS. THE FAILURE MILEAGE WAS 99,500. THE CURRENT MILEAGE WAS 99,584. UPDATED 05/13/10. *LJ
NHTSA ODI #10321065
111,000 miles · Mar 15, 2010
Engine And Engine Cooling
MY 2011 REGAL HAD TO HAVE THE LOWER AND UPPER INTAKE GASKET REPLACED AS WELL AS THE VALVE COVER GASKETS.. A WEEK AFTER THAT THE SERVICE ENGINE SOON LIGHT CAME ON AND THE MECHANIC SAID IT WAS THE THROTTLE BODY GASKET. I THEN GOT IT REPLACED AND THEN A WEEK AFTER THAT THE SERVICE ENGINE SOON LIGHT CAME ON AGAIN. IT WAS PULLING UP …
Read full complaint
MY 2011 REGAL HAD TO HAVE THE LOWER AND UPPER INTAKE GASKET REPLACED AS WELL AS THE VALVE COVER GASKETS.. A WEEK AFTER THAT THE SERVICE ENGINE SOON LIGHT CAME ON AND THE MECHANIC SAID IT WAS THE THROTTLE BODY GASKET. I THEN GOT IT REPLACED AND THEN A WEEK AFTER THAT THE SERVICE ENGINE SOON LIGHT CAME ON AGAIN. IT WAS PULLING UP A CODE FOR A VACUUM LEAK. WTF! MY BOYFRIEND TURNED THE LIGHT OFF AND IT HASN'T COME ON SINCE, SO I DON'T KNOW IF IT WAS A GLITCH. *TR
NHTSA ODI #10319972
120,000 miles · Mar 2, 2010
Vehicle Speed Control
TL*THE CONTACT OWNS A 2001 BUICK REGAL. THE THROTTLE BECAME STUCK AND THE VEHICLE WOULD NOT SLOW DOWN UNTIL IT WAS PLACED IN NEUTRAL GEAR. THE VEHICLE WAS TOWED TO A LOCAL MECHANIC WHO STATED THAT THE THROTTLE CABLE WAS DEFECTIVE AND HE SHOULD FILE A SAFETY COMPLAINT WITH NHTSA. THE VEHICLE WAS TRAVELING AT 35 MPH WHEN THE VEHIC…
Read full complaint
TL*THE CONTACT OWNS A 2001 BUICK REGAL. THE THROTTLE BECAME STUCK AND THE VEHICLE WOULD NOT SLOW DOWN UNTIL IT WAS PLACED IN NEUTRAL GEAR. THE VEHICLE WAS TOWED TO A LOCAL MECHANIC WHO STATED THAT THE THROTTLE CABLE WAS DEFECTIVE AND HE SHOULD FILE A SAFETY COMPLAINT WITH NHTSA. THE VEHICLE WAS TRAVELING AT 35 MPH WHEN THE VEHICLE SUDDENLY ACCELERATED. THE FAILURE MILEAGE WAS 120,000. THE CURRENT MILEAGE WAS 123,000.
NHTSA ODI #10315648
54,000 miles · Nov 13, 2009
Vehicle Speed Control
I JUST BOUGHT THIS CAR. THE INCIDENT INVOLVES THE CRUISE CONTROL OF THIS VEHICLE. I WAS DRIVING ON I-65. I SET THE CRUISE FOR 65 MPH. LATER, I PUSHED THE ACCELERATE BUTTON TO INCREASE THE SPEED BY 5 MPH. I RELEASED THE SWITCH AT THE DESIRED SPEED BUT THE CAR CONTINUED TO ACCELERATE AS IF I FLOORED IT. I QUICKLY HIT THE BRA…
Read full complaint
I JUST BOUGHT THIS CAR. THE INCIDENT INVOLVES THE CRUISE CONTROL OF THIS VEHICLE. I WAS DRIVING ON I-65. I SET THE CRUISE FOR 65 MPH. LATER, I PUSHED THE ACCELERATE BUTTON TO INCREASE THE SPEED BY 5 MPH. I RELEASED THE SWITCH AT THE DESIRED SPEED BUT THE CAR CONTINUED TO ACCELERATE AS IF I FLOORED IT. I QUICKLY HIT THE BRAKES AND THAT FIRST STOPPED THE ACCELERATION. BUT AS SOON AS I RELEASED THE BRAKES, IT WENT BACK TO ACCELERATION. I THEN TURNED THE CRUISE CONTROL SWITCH TO THE OFF POSITION AND THAT STOPPED THE ACCELERATION. I CONTINUED FOR ABOUT 10 MILES WHEN I TRIED THE CRUISE CONTROL AGAIN. THE UNCONTROLLED ACCELERATION OCCURRED AGAIN WHEN I USED THE ACCELERATE BUTTON BUT THIS TIME I APPLIED THE DECELERATE BUTTON ONE TIME AS IF TO DECREASE THE SPEED BY 1 MPH. THAT ACTION KILLED THE CRUISE CONTROL ALL TOGETHER. IF I WANTED CRUISE CONTROL AGAIN, I WOULD HAVE TO RESET THE DESIRED SPEED ALL OVER AGAIN AS IF IT WEREN'T SET AT ALL. I HAVE ANOTHER INCIDENT INVOLVING THE CRUISE CONTROL ON THE SAME TRIP. I HAD THE DESIRED SPEED SET. WHEN THE CAR HIT A BUMP SUCH AS A SMALL POTHOLE, THE CAR'S SPEED SUDDENLY WOULD START TO INCREASE AS IF I FLOORED IT. AGAIN I HAD TO APPLY THE OFF SWITCH OR DECELERATE BUTTON TO KILL IT. ANOTHER INCIDENT OCCURRED ON THE SAME TRIP INVOLVING THE CRUISE CONTROL. I HAD THE CRUISE CONTROL SWITCH IN THE ON POSITION BUT HADN'T SET THE SPEED WHEN I HIT A BUMP ON THE INTERSTATE. AGAIN THE CAR ACTED AS IF I FLOORED THE ACCELERATOR AND AGAIN I HAD TO TURN THE SWITCH TO THE OFF POSITION OR USE THE DECELERATE BUTTON TO STOP IT. I HAD THIS CAR TROUBLE-SHOT FOR THIS PROBLEM. THEY FOUND THAT THE CRUISE CONTROL MODULE WAS AT FAULT BUT THE PART IS ON BACK ORDER NATIONWIDE. I WAS TOLD I COULD BE PUT ON A WAITING LIST BUT IT COULD BE A WHILE. ONE WOULD HAVE TO THINK I'M NOT THE ONLY ONE HAVING THESE PROBLEMS. I THINK THIS IS AN UNSAFE CONDITION AND SHOULD BE LOOKED AT. *TR JEFF LEONARD,
NHTSA ODI #10292066
115,000 miles · Aug 21, 2009
Air BagsService Brakes, HydraulicCrashInjury
WAS IN FATAL ACCIDENT ON MAY 8 2009 IN DES MOINES, IA. IT WAS LIGHT RAIN THAT NIGHT AND I MADE AN ATTEMPT TO TURN A CORNER AND SLIDE RIGHT THROUGH AND FENCE AND DROPPED DOWN A HILL ABOUT AND ESTIMATED 20 FEET. THE ANTI-BRAKE SYSTEM FAILED AS WELL AS THE AIRBAG NOT DEPLOYING IS MY CONCERN. THIS WAS NOT THE FIRST INCIDENT. THE…
Read full complaint
WAS IN FATAL ACCIDENT ON MAY 8 2009 IN DES MOINES, IA. IT WAS LIGHT RAIN THAT NIGHT AND I MADE AN ATTEMPT TO TURN A CORNER AND SLIDE RIGHT THROUGH AND FENCE AND DROPPED DOWN A HILL ABOUT AND ESTIMATED 20 FEET. THE ANTI-BRAKE SYSTEM FAILED AS WELL AS THE AIRBAG NOT DEPLOYING IS MY CONCERN. THIS WAS NOT THE FIRST INCIDENT. THE ONE TOOK PLACE IN DECEMBER OF 2009. A DEER RAN OUT IN FRONT OF THE CAR AND THE SAME THING HAPPENED I WAS THEY CONDUCTED AN INVESTIGATION, BUT WAS NOT INFORMED TO WHERE I COULD UNDERSTAND. NOW THE CASE IS WITH THEIR LAWYERS WHO WON'T ANSWER THE PHONE. *TR
NHTSA ODI #10281320
32,000 miles · May 19, 2009
Engine And Engine CoolingFire
TL*THE CONTACT OWNS A 2001 BUICK REGAL. MINUTES LATER AFTER THE CONTACT PARKED THE VEHICLE, IT CAUGHT FIRE. THE FIRE DEPARTMENT EXTINGUISHED THE FIRE AND FILED A REPORT. THERE WERE NO INJURIES AND THE VEHICLE WAS DESTROYED. THE CONTACT WAS ADVISED TO FILE A COMPLAINT WITH THE MANUFACTURER. THE FAILURE MILEAGE WAS 32,000.
NHTSA ODI #10269335
Official recalls
6Oct 26, 2015
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence & remedy
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Additional source detail variants (2)
Engine And Engine Cooling:exhaust System:manifold/header/muffler/tail Pipe
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Engine And Engine Cooling:engine
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Apr 8, 2009
GENERAL MOTORS IS RECALLING 1,497,516 MY 1997-2003 BUICK REGAL, MY 1998-2003 CHEVROLET LUMINA, MONTE CARLO AND IMPALA, MY 1998-1999 OLDSMOBILE INTRIGUE, MY 1997-2003 PONTIAC GRAND PRIX VEHICLES EQUIPPED WITH A 3.8L V6 NATURALLY ASPIRATED ENGINE. SOME OF THESE VEHICLES HAVE A CONDITION IN WHICH DROPS OF ENGINE OIL MAY BE DEPOSITED ON THE EXHAUST MANIFOLD THROUGH HARD BRAKING.
Consequence & remedy
Consequence: IF THE MANIFOLD IS HOT ENOUGH AND THE OIL RUNS BELOW THE HEAT SHIELD, IT MAY IGNITE INTO A SMALL FLAME AND MAY SPREAD TO THE PLASTIC SPARK PLUG WIRE CHANNEL AND BEYOND INCREASING THE RISK OF AN ENGINE COMPARTMENT FIRE.
Remedy: DEALERS WILL REPLACE THE ENGINES FRONT VALVE COVER AND FRONT-VALVE-COVER GASKET WITH NEW PARTS OF AN IMPROVED DESIGN AND REMOVE THE ENGINES PLASTIC COVER AND PLASTIC OIL-FILL-TUBE EXTENSION, FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2016. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, OLDSMOBILE AT 1-800-630-6537, AND PONTIAC AT 1-800-620-7668 OR HTTP://WWW.PONTIAC.COM OR HTTP:WWW.GMOWNERCENTER.COM.
Mar 12, 2008
GM IS RECALLING 207,542 MY 1997-2003 BUICK REGAL AND PONTIAC GRAND PRIX VEHICLES EQUIPPED WITH A 3.8L SUPERCHARGED V-6 ENGINE. THESE VEHICLES HAVE HIGHER FRONT ROCKER COVER GASKET TEMPERATURES, CREATING THE POTENTIAL FOR EARLIER DEGRADATION OF THE FRONT ROCKER COVER GASKET AND EVENTUAL OIL SEEPAGE.
Consequence & remedy
Consequence: CERTAIN UNDERHOOD FIRES MAY BE CAUSED BY DROPS OF ENGINE OIL, FROM SEEPAGE OR SPILLAGE, BEING DEPOSITED ON THE EXHAUST MANIFOLD THROUGH HARD BRAKING. IF THE MANIFOLD IS HOT ENOUGH AND THE OIL RUNS BELOW THE HEAT SHIELD, IT MAY IGNITE INTO A SMALL FLAME AND, IN SOME INSTANCES, THE FIRE MAY SPREAD TO THE PLASTIC SPARK PLUG WIRE CHANNEL AND BEYOND.
Remedy: DEALERS WILL REPLACE THE ENGINES FRONT VALVE COVER AND FRONT-VALVE-COVER GASKET WITH NEW PARTS OF AN IMPROVED DESIGN AND REMOVE THE ENGINES PLASTIC COVER AND PLASTIC OIL-FILL-TUBE EXTENSION, ALONG WITH THE 1-3-5 SPARK PLUG WIRE RETAINERS, FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2016. , FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2016. UNTIL THE REMEDY IS COMPLETED, GM STRONGLY RECOMMENDS THAT OWNERS OBSERVE THE FOLLOWING IMPORTANT PRECAUTIONS (1) THAT OWNERS DO NOT PARK THEIR VEHICLE IN A GARAGE, CAR PORT, OR OTHER STRUCTURE; (2) IF OWNERS NOTICE A BURNING ODOR, THEY SHOULD HAVE THEIR DEALER INSPECT THE VEHICLE. THE DEALER WILL INSPECT THE VEHICLE WITHOUT CHARGE; (3) USE PREMIUM FUEL (91 OCTANE OR HIGHER) IN THE VEHICLE AS RECOMMENDED IN THE VEHICLE'S OWNER MANUAL. OWNERS MAY CONTACT BUICK AT 1-866-608-8080 OR PONTIAC AT 1-800-620-7668, OR THROUGH THEIR WEBSITE AT <A HREF=HTTP://WWW.GMOWNERCENTER.COM>HTTP://WWW.GMOWNERCENTER.COM</A> .
Apr 6, 2001
VEHICLE DESCRIPTION: CERTAIN PASSENGER VEHICLES, EQUIPPED WITH SUNVISOR LOCATED AIR BAG LABELS, FAIL TO CONFORM TO FEDERAL MOTOR VEHICLES SAFETY STANDARD NO. 208, "OCCUPANT CRASH PROTECTION." THESE VEHICLES HAVE A MESSAGE AREA LESS THAN 30 CM WHICH DOES NOT MEET THE REQUIREMENTS OF THE STANDARD.
Consequence & remedy
Consequence: THESE VEHICLES DO NOT COMPLY WITH THE STANDARD.
Remedy: GM WILL MAIL A NEW BILINGUAL AIR BAG LABEL WITH INSTALLATION INSTRUCTIONS. HOWEVER, THE CUSTOMER MAY BRING THE LABEL TO THEIR DEALER FOR INSTALLATION FREE OF CHARGE. OWNER NOTIFICATION BEGAN MAY 4, 2001. OWNERS WHO DO NOT RECEIVE THE FREE LABEL AND INSTALLATION INSTRUCTIONS WITHIN A REASONABLE TIME SHOULD CONTACT OLDSMOBILE AT 1-800-442-6537 OR BUICK AT 1-800-521-7300.
Nov 13, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES. SOME OF THESE VEHICLES EXHIBIT A CONDITION IN WHICH THE DRIVER SIDE IMPACT AIR BAG INFLATOR SEPARATES FROM THE AIR BAG MODULE DURING DEPLOYMENT.
Consequence & remedy
Consequence: IF THE INFLATOR SEPARATES, THE AIR BAG WILL NOT DEPLOY PROPERLY DURING A CRASH AND OCCUPANT PROTECTION WOULD BE REDUCED. IF IS ALSO POSSIBLE THAT A SEPARATED INFLATOR COULD BE PROPELLED DOWNWARD AND COULD RESULT IN INJURY TO A REAR SEAT PASSENGER WHOSE FOOT IS POSITIONED APPROXIMATELY UNDER THE INFLATOR MODULE.
Remedy: DEALERS WILL REPLACE THE SIDE IMPACT AIR BAG MODULE.
Aug 7, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES, LIGHT DUTY TRUCKS, SPORT UTILITY VEHICLES, AND MINI VANS EQUIPPED WITH TRW SEAT BELT BUCKLE ASSEMBLIES. THE BUCKLE BASE OF THESE SEAT BELT ASSEMBLIES WERE NOT PROPERLY HEAT TREATED AND THEREFORE DO NOT PASS THE LOAD BEARING REQUIREMENT OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 209, "SEAT BELT ASSEMBLIES."
Consequence & remedy
Consequence: IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT MAY NOT BE PROPERLY RESTRAINED.
Remedy: DEALERS WILL INSPECT THE VEHICLE'S SAFETY BELT BUCKLE ASSEMBLY DATE CODES AND, IF NECESSARY, WILL REPLACE ANY SAFETY BELT BUCKLE ASSEMBLY.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA07008 · Engine Compartment Fire
Opened Jun 12, 2007 · Closed May 1, 2008
Status: closed (inferred from source dates) · Engine And Engine Cooling
BY LETTER DATED MARCH 12, 2008, GENERAL MOTORS CORP. (GM) HAS NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL (IDENTIFIED BY NHTSA RECALL NUMBER 08V-118) TO ADDRESS A DEFECT IN APPROXIMATELY 207,542 MODEL YEAR (MY) 1997-2003 BUICK REGAL GS AND PONTIAC GRAND PRIX GTP VEHICLES EQUIPPED WITH THE L67 SUPERCHARGED VERSION OF GM'S 3800 SERIES II V6 ENGINE.THE RECALLED REGAL GS VEHICLES WERE BUILT FROM AUGUST 1996 TO JUNE 2003 AND THE GRAND PRIX GTP FROM MARCH 1996 THROUGH JANUARY 2003.ACCORDING TO GM, OIL MAY ESCAPE PAST THE VALVE COVER GASKET ON THE FRONT CYLINDER BANK (CYLINDERS 1-3-5) AND DEPOSIT ONTO HOT EXHAUST SYSTEM COMPONENTS.UNDER CERTAIN CONDITIONS, IT IS POSSIBLE FOR THIS OIL TO IGNITE A SMALL PILOT FLAME, WHICH MAY SPREAD TO THE ADJACENT PLASTIC SPARK PLUG WIRE CHANNEL, THE SPARK PLUG WIRES THEMSELVES, THE PLASTIC ENGINE COVER, AND OTHER UNDER HOOD COMPONENTS.REPORTS INDICATE THIS MOST OFTEN OCCURS ON HIGHER-MILEAGE VEHICLES SHORTLY AFTER THE VEHICLE HAS BEEN DRIVEN AND THEN PARKED.TYPICALLY, THE FIRE WAS DISCOVERED WITHIN 5 TO 15 MINUTES AFTER THE VEHICLE WAS PARKED.DURING THIS TIME WINDOW, UNDER HOOD TEMPERATURES MAY BECOME ELEVATED.SUCH ELEVATED TEMPERATURES COMBINED WITH A LACK OF AIRFLOW THROUGH THE ENGINE COMPARTMENT MAY PERMIT A SMALL PILOT FLAME TO PROPAGATE AND IGNITE OTHER FUEL SOURCES.TO CORRECT THE SAFETY DEFECT, GM WILL INSTALL AN IMPROVED DESIGN FRONT VALVE COVER GASKET AND SPARK PLUG WIRE RETAINER.THIS REMEDY WILL BE SUPPLIEDFREE OF CHARGE FOR ALL RECALLED VEHICLES.UNTIL SUFFICIENT PARTS BECOME AVAILABLE TO REPAIR ALL OF THE AFFECTED VEHICLES, GM STRONGLY RECOMMENDS THAT OWNERS OBSERVE THE FOLLOWING IMPORTANT PRECAUTIONS: (1) THEY STRONGLY RECOMMEND THAT OWNERS DO NOT PARK THEIR VEHICLE IN A GARAGE, CARPORT, OR OTHER STRUCTURE; (2) IF OWNERS NOTICE A BURNING ODOR, THEY SHOULD HAVE THEIR DEALER INSPECT THE VEHICLE - THE DEALER WILL INSPECT THE VEHICLE WITHOUT CHARGE; AND (3) USE PREMIUM FUEL (91 OCTANE OR HIGHER) IN THE VEHICLE AS RECOMMENDED IN THE VEHICLE'S OWNER MANUAL.THE ACTION TAKEN BY GM IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE SUBJECT FIRE INCIDENT RATE ON THE C-, G-, AND H-PLATFORM SUBJECT VEHICLES IS LOW.THE AGENCY WILL CONTINUE TO MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
Additional source detail variants (2)
Engine And Engine Cooling
BY LETTER DATED MARCH 12, 2008, GENERAL MOTORS CORP. (GM) HAS NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL (IDENTIFIED BY NHTSA RECALL NUMBER 08V-118) TO ADDRESS A DEFECT IN APPROXIMATELY 207,542 MODEL YEAR (MY) 1997-2003 BUICK REGAL GS AND PONTIAC GRAND PRIX GTP VEHICLES EQUIPPED WITH THE L67 SUPERCHARGED VERSION OF GM'S 3800 SERIES II V6 ENGINE.THE RECALLED REGAL GS VEHICLES WERE BUILT FROM AUGUST 1996 TO JUNE 2003 AND THE GRAND PRIX GTP FROM MARCH 1996 THROUGH JANUARY 2003.ACCORDING TO GM, OIL MAY ESCAPE PAST THE VALVE COVER GASKET ON THE FRONT CYLINDER BANK (CYLINDERS 1-3-5) AND DEPOSIT ONTO HOT EXHAUST SYSTEM COMPONENTS.UNDER CERTAIN CONDITIONS, IT IS POSSIBLE FOR THIS OIL TO IGNITE A SMALL PILOT FLAME, WHICH MAY SPREAD TO THE ADJACENT PLASTIC SPARK PLUG WIRE CHANNEL, THE SPARK PLUG WIRES THEMSELVES, THE PLASTIC ENGINE COVER, AND OTHER UNDER HOOD COMPONENTS.REPORTS INDICATE THIS MOST OFTEN OCCURS ON HIGHER-MILEAGE VEHICLES SHORTLY AFTER THE VEHICLE HAS BEEN DRIVEN AND THEN PARKED.TYPICALLY, THE FIRE WAS DISCOVERED WITHIN 5 TO 15 MINUTES AFTER THE VEHICLE WAS PARKED.DURING THIS TIME WINDOW, UNDER HOOD TEMPERATURES MAY BECOME ELEVATED.SUCH ELEVATED TEMPERATURES COMBINED WITH A LACK OF AIRFLOW THROUGH THE ENGINE COMPARTMENT MAY PERMIT A SMALL PILOT FLAME TO PROPAGATE AND IGNITE OTHER FUEL SOURCES.TO CORRECT THE SAFETY DEFECT, GM WILL INSTALL AN IMPROVED DESIGN FRONT VALVE COVER GASKET AND SPARK PLUG WIRE RETAINER.THIS REMEDY WILL BE SUPPLIEDFREE OF CHARGE FOR ALL RECALLED VEHICLES.UNTIL SUFFICIENT PARTS BECOME AVAILABLE TO REPAIR ALL OF THE AFFECTED VEHICLES, GM STRONGLY RECOMMENDS THAT OWNERS OBSERVE THE FOLLOWING IMPORTANT PRECAUTIONS: (1) THEY STRONGLY RECOMMEND THAT OWNERS DO NOT PARK THEIR VEHICLE IN A GARAGE, CARPORT, OR OTHER STRUCTURE; (2) IF OWNERS NOTICE A BURNING ODOR, THEY SHOULD HAVE THEIR DEALER INSPECT THE VEHICLE - THE DEALER WILL INSPECT THE VEHICLE WITHOUT CHARGE; AND (3) USE PREMIUM FUEL (91 OCTANE OR HIGHER) IN THE VEHICLE AS RECOMMENDED IN THE VEHICLE'S OWNER MANUAL.THE ACTION TAKEN BY GM IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE SUBJECT FIRE INCIDENT RATE ON THE C-, G-, AND H-PLATFORM SUBJECT VEHICLES IS LOW.THE AGENCY WILL CONTINUE TO MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
Engine And Engine Cooling
BY LETTER DATED MARCH 12, 2008, GENERAL MOTORS CORP. (GM) HAS NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL (IDENTIFIED BY NHTSA RECALL NUMBER 08V-118) TO ADDRESS A DEFECT IN APPROXIMATELY 207,542 MODEL YEAR (MY) 1997-2003 BUICK REGAL GS AND PONTIAC GRAND PRIX GTP VEHICLES EQUIPPED WITH THE L67 SUPERCHARGED VERSION OF GM'S 3800 SERIES II V6 ENGINE.THE RECALLED REGAL GS VEHICLES WERE BUILT FROM AUGUST 1996 TO JUNE 2003 AND THE GRAND PRIX GTP FROM MARCH 1996 THROUGH JANUARY 2003.ACCORDING TO GM, OIL MAY ESCAPE PAST THE VALVE COVER GASKET ON THE FRONT CYLINDER BANK (CYLINDERS 1-3-5) AND DEPOSIT ONTO HOT EXHAUST SYSTEM COMPONENTS.UNDER CERTAIN CONDITIONS, IT IS POSSIBLE FOR THIS OIL TO IGNITE A SMALL PILOT FLAME, WHICH MAY SPREAD TO THE ADJACENT PLASTIC SPARK PLUG WIRE CHANNEL, THE SPARK PLUG WIRES THEMSELVES, THE PLASTIC ENGINE COVER, AND OTHER UNDER HOOD COMPONENTS.REPORTS INDICATE THIS MOST OFTEN OCCURS ON HIGHER-MILEAGE VEHICLES SHORTLY AFTER THE VEHICLE HAS BEEN DRIVEN AND THEN PARKED.TYPICALLY, THE FIRE WAS DISCOVERED WITHIN 5 TO 15 MINUTES AFTER THE VEHICLE WAS PARKED.DURING THIS TIME WINDOW, UNDER HOOD TEMPERATURES MAY BECOME ELEVATED.SUCH ELEVATED TEMPERATURES COMBINED WITH A LACK OF AIRFLOW THROUGH THE ENGINE COMPARTMENT MAY PERMIT A SMALL PILOT FLAME TO PROPAGATE AND IGNITE OTHER FUEL SOURCES.TO CORRECT THE SAFETY DEFECT, GM WILL INSTALL AN IMPROVED DESIGN FRONT VALVE COVER GASKET AND SPARK PLUG WIRE RETAINER.THIS REMEDY WILL BE SUPPLIEDFREE OF CHARGE FOR ALL RECALLED VEHICLES.UNTIL SUFFICIENT PARTS BECOME AVAILABLE TO REPAIR ALL OF THE AFFECTED VEHICLES, GM STRONGLY RECOMMENDS THAT OWNERS OBSERVE THE FOLLOWING IMPORTANT PRECAUTIONS: (1) THEY STRONGLY RECOMMEND THAT OWNERS DO NOT PARK THEIR VEHICLE IN A GARAGE, CARPORT, OR OTHER STRUCTURE; (2) IF OWNERS NOTICE A BURNING ODOR, THEY SHOULD HAVE THEIR DEALER INSPECT THE VEHICLE - THE DEALER WILL INSPECT THE VEHICLE WITHOUT CHARGE; AND (3) USE PREMIUM FUEL (91 OCTANE OR HIGHER) IN THE VEHICLE AS RECOMMENDED IN THE VEHICLE'S OWNER MANUAL.THE ACTION TAKEN BY GM IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE SUBJECT FIRE INCIDENT RATE ON THE C-, G-, AND H-PLATFORM SUBJECT VEHICLES IS LOW.THE AGENCY WILL CONTINUE TO MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
EA02030 · Engine Compartment Fires
Opened Oct 22, 2002 · Closed Mar 9, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:delivery; Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (3)
Fuel System, Gasoline:delivery
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Illustration