Illustration3 OUT OF 4 POWER WINDOWS HAVE FAILED. ONE WAS COVERED BY EXTENDED WARRANTY. THE PARTS TO FIX THE WINDOW YOURSELF FROM DEALER IS OVER $300.00. THE COST TO HAVE FIXED AT THE DEALER IS OVER $500.00. WINDOWS HAVE FAILED FOR NO APPARENT REASON. NORMAL USE ONLY. THE DESIGN/MOTORS OF THESE WINDOWS MUST BE FAULTY. *JB
1999 Buick Regal
Owner reports · Recalls · Investigations
More warning signs than most Regal years
Owner complaints for the 1999 Buick Regal are substantially higher than the model-year median of 29.
About this comparison →How this year compares
Owner complaints by model year
Compare all Regal years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
30–25K
1825–50K
2250–75K
2675–100K
32100–150K
15150K+
116 reports with mileage · 130 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Engine. Review the 49 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 43 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 42 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
8 crash reports44 fire reports7 injury reports
Visibility complaints
20 reports(12-06-05) 1999 BUICK REGAL CHECK ENGINE AND ANTI LOCK LIGHT CAME ON. CONSUMER HAD TO REPLACE BRAKE MODULE. *TS ***NO ANSWER REQUIRED*** THE HEATING AND AIR CONDITION DISPLAY WOULD LIGHT UP AND THEN BECOME DARK. THE MECHANIC REPLACED THE CONTROL HEAD. THE CONSUMER EXPERIENCE STARTING PROBLEMS WHICH RESULTED IN A NEW IGNITION …
Read full complaint
(12-06-05) 1999 BUICK REGAL CHECK ENGINE AND ANTI LOCK LIGHT CAME ON. CONSUMER HAD TO REPLACE BRAKE MODULE. *TS ***NO ANSWER REQUIRED*** THE HEATING AND AIR CONDITION DISPLAY WOULD LIGHT UP AND THEN BECOME DARK. THE MECHANIC REPLACED THE CONTROL HEAD. THE CONSUMER EXPERIENCE STARTING PROBLEMS WHICH RESULTED IN A NEW IGNITION SWITCH BEING INSTALLED. *JB
THE ELECTRIC MOTOR FOR ALL 4 WINDOWS MALFUNCTIONED, AND COMPLETELY DIED. THE WINDOWS WILL NOT COME DOWN. THE MOTORS BURNED OUT AT DIFFERENT TIMES. CONSUMER TOOK THE VEHICLE INTO THE DEALER. CONSUMER WAS TOLD THAT THESE MOTORS WERE A PROBLEM. *AK
SIMULTANEOUS FAILURE OF BOTH MOTORS IN POWER WINDOWS IN DRIVER AND FRONT SEAT PASSENGER OF 1999 BUICK REGAL, CAUSING SUDDEN DROP OF WINDOWS. BOTH WERE REPLACED BY DEALER AT COST TO OWNER OF $1,100. NO EXPLANATION WAS PROVIDED BY DEALER AS TO REASON FOR THIS EXTRAORDINARY OCCURENCE OTHER THAN STATING THAT REPLACEMENT WAS NOT UN…
Read full complaint
SIMULTANEOUS FAILURE OF BOTH MOTORS IN POWER WINDOWS IN DRIVER AND FRONT SEAT PASSENGER OF 1999 BUICK REGAL, CAUSING SUDDEN DROP OF WINDOWS. BOTH WERE REPLACED BY DEALER AT COST TO OWNER OF $1,100. NO EXPLANATION WAS PROVIDED BY DEALER AS TO REASON FOR THIS EXTRAORDINARY OCCURENCE OTHER THAN STATING THAT REPLACEMENT WAS NOT UNDER EXPIRED WARRANTY. THE SUDDEN DROP OF THE WINDOWS WAS HIGHLY DANGEROUS DUE TO ITS DISTRACTION FACTOR, INABILITY TO REPEL INCLEMENT ELEMENTS, ETC.*AK
EXTERIOR MIRROR GLASS VIBRATES WHILE DRIVING CAUSING BLURRED VISION. HAD ONE SIDE REPLACED UNDER WARRANTY. 6 MONTHS LATER, BOTH SIDES DO IT. IMPOSSIBLE TO SEE CLEARLY!!! CHROME COATING ON WHEELS PEELING OFF. PIECES WILL STICK TO THE ABS SENSOR CAUSING FAULT. ONE OCCASION IT MADE BRAKES FAIL ALMOST CAUSING ACCIDENT. *LA …
Read full complaint
EXTERIOR MIRROR GLASS VIBRATES WHILE DRIVING CAUSING BLURRED VISION. HAD ONE SIDE REPLACED UNDER WARRANTY. 6 MONTHS LATER, BOTH SIDES DO IT. IMPOSSIBLE TO SEE CLEARLY!!! CHROME COATING ON WHEELS PEELING OFF. PIECES WILL STICK TO THE ABS SENSOR CAUSING FAULT. ONE OCCASION IT MADE BRAKES FAIL ALMOST CAUSING ACCIDENT. *LA
THE HVAC (TEMPERATURE CONTROL PANEL) STARTED FADING IN AND OUT, AND THEN EVENTUALLY WENT BLANK. SEEMS TO WORK FINE. BUT CANNOT TELL WETHER THE DEFROST ETC. IS SET AT AND WHAT TEMPERATURE THE HEAT OR AIR IS SET AT. TOOK TO DEALER, WAS TOLD WOULD COST $600.00 TO FIX. I ALSO HAVE TROUBLE WITH WATER COMING INTO THE CAR ON THE FRONT…
Read full complaint
THE HVAC (TEMPERATURE CONTROL PANEL) STARTED FADING IN AND OUT, AND THEN EVENTUALLY WENT BLANK. SEEMS TO WORK FINE. BUT CANNOT TELL WETHER THE DEFROST ETC. IS SET AT AND WHAT TEMPERATURE THE HEAT OR AIR IS SET AT. TOOK TO DEALER, WAS TOLD WOULD COST $600.00 TO FIX. I ALSO HAVE TROUBLE WITH WATER COMING INTO THE CAR ON THE FRONT PASSENGER SIDE ON FLOOR. HAVE BEEN TOLD THAT IT MAY BE DRAINING IN FROM UP UNDER WINDSHIELD WASHERS. ALSO, HAD TO REPLACE ALL FOUR EAGLE LS TIRES. I HAD TERRIBLE VIBRATION, TOOK INTO SHOP AND WERE TOLD THAT THEY WERE UNSAFE TO DRIVE.*AK
I HAVE HAD FIVE OR SIX FAILURES ON THIS PART ON MY TWO 1999 REGAL GS. WOULD OF BEEN MOR BUT I WAIT UNTIL DISPLAY FADES MORE UNTIL I REPLACE. DEALER IS AWARE. FACTORY IS AWARE. I HAVE EXTENDED WARRANTY, SO IT IS FREE. PEOPLE ON YOUE SITE HAD TO PAY $600.00. THIS WILL CAUSE AN ACCIDENT BECAUSE YOU CAN NOT TELL WHAT IS SET IN THE H…
Read full complaint
I HAVE HAD FIVE OR SIX FAILURES ON THIS PART ON MY TWO 1999 REGAL GS. WOULD OF BEEN MOR BUT I WAIT UNTIL DISPLAY FADES MORE UNTIL I REPLACE. DEALER IS AWARE. FACTORY IS AWARE. I HAVE EXTENDED WARRANTY, SO IT IS FREE. PEOPLE ON YOUE SITE HAD TO PAY $600.00. THIS WILL CAUSE AN ACCIDENT BECAUSE YOU CAN NOT TELL WHAT IS SET IN THE HVAC. IF YOU NEED A CONSTANT HEAT AND DEFOG YOU CAN NOT TELL. NO DISPLAY. HAVE TO PUT HAND TO TELL ON VENTS. GM IGNORING THE PROBLEM! NOT BEING ABLE TO TELL IF YOU ARE IN DEFOG IS A SAFETY ISSUE! MR
THE NUT THAT SECURES THE DRIVERS SIDE WIPER ARM TO THE DRIVE SHAFT CAME LOOSE DURING A DRIVING RAIN STORM WHILE TRAVELING ON THE PA TURNPIKE. THE WIPERS WERE OPERATING ON THE HIGHEST SPEED. THE WIPER ARM FLEW OFF FROM THE DRIVE SHAFT AND CAME TO REST AGAINST THE DRIVERS SIDE VIEW MIRROR. DRIVERS VISION IMMEDIATELY AND SEVE…
Read full complaint
THE NUT THAT SECURES THE DRIVERS SIDE WIPER ARM TO THE DRIVE SHAFT CAME LOOSE DURING A DRIVING RAIN STORM WHILE TRAVELING ON THE PA TURNPIKE. THE WIPERS WERE OPERATING ON THE HIGHEST SPEED. THE WIPER ARM FLEW OFF FROM THE DRIVE SHAFT AND CAME TO REST AGAINST THE DRIVERS SIDE VIEW MIRROR. DRIVERS VISION IMMEDIATELY AND SEVERELY IMPAIRED DUE TO THE HEAVY DOWNPOUR AND ONLY WITH GREAT DIFFICULTY AND CAUTION (NEGOTIATING THROUGH OTHER TRUCK/CAR TRAFFIC) WAS ABLE TO PULL OFF TO THE SIDE OFF THE ROAD. YOU WOULD EXPECT A NUT, SECURING SUCH A CRITICAL ITEM, WOULD BE DESIGNED NOT TO COME LOOSE. TURNPIKE SERVICE REATTACHED THE WIPER ARM AND NUT AT NO CHARGE.*AK
CONSUMER HAS BEEN UNABLE TO OBTAIN A FIX FOR RECALL FOR DRIVERS SIDE CARPET WHICH HAS COME UNDONE WHICH CAN SNAG A FEMALES SHOE CAUSING HER TO TRIP. NLM CONSUMER STATES AFTER SEVERAL ATTEMPTS TO HAVE THE PASSENGER SIDE DOOR LOCK REPAIRED AT SEVERAL DEALERS AND BEING TOLD THEY COULD NOT REPAIR THE LOCK, SEVERAL INDEPENDENT MECH…
Read full complaint
CONSUMER HAS BEEN UNABLE TO OBTAIN A FIX FOR RECALL FOR DRIVERS SIDE CARPET WHICH HAS COME UNDONE WHICH CAN SNAG A FEMALES SHOE CAUSING HER TO TRIP. NLM CONSUMER STATES AFTER SEVERAL ATTEMPTS TO HAVE THE PASSENGER SIDE DOOR LOCK REPAIRED AT SEVERAL DEALERS AND BEING TOLD THEY COULD NOT REPAIR THE LOCK, SEVERAL INDEPENDENT MECHANIC CLAIM THE PROBLEM IS THE AUTOMATIC SWITCH WHICH WILL NOT SPRING THE LOCK BACK COMPLETELY TO ALLOW THE DOOR TO BE OPENED, IT REMIANS IN THE LOCK POSITION, CONSUMER WAS ADVISED BY MECHANIC THEY CAN NOT CORRECT THE PROBLEM BECAUSE THE VEHICLE IS STILL UNDER WARRANTY , GM MECHANICS CLAIM THEY DO NOT NOT WHAT THE PROBLEM IS. *JB
WHILE DRIVING VEHICLE AT VARIOUS SPEEDS, THE OUTSIDE MIRROR ON DRIVER'S SIDE WOULD FLICKER OR VIBRATES. HAD NO CLEAR VISION OF OTHER VEHICLES IN MIRROR. BEEN TO DEALER TO REPLACE SIDE MIRRORS. NOT SATISFIED. HAVING THE SAME PROBLEM WITH REPLACEMENT MIRRORS. CUSTOMER SERVICE REPRESENTATIVE SAID ALL 99 BUICKS MIRRORS ARE LIKE THA…
Read full complaint
WHILE DRIVING VEHICLE AT VARIOUS SPEEDS, THE OUTSIDE MIRROR ON DRIVER'S SIDE WOULD FLICKER OR VIBRATES. HAD NO CLEAR VISION OF OTHER VEHICLES IN MIRROR. BEEN TO DEALER TO REPLACE SIDE MIRRORS. NOT SATISFIED. HAVING THE SAME PROBLEM WITH REPLACEMENT MIRRORS. CUSTOMER SERVICE REPRESENTATIVE SAID ALL 99 BUICKS MIRRORS ARE LIKE THAT. *AK
Official recalls
615V701000 · Engine And Engine Cooling:engine; Engine And Engine Cooling:exhaust System:manifold/header/muffler/tail Pipe
Oct 26, 2015
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence & remedy
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Additional source detail variants (2)
Engine And Engine Cooling:exhaust System:manifold/header/muffler/tail Pipe
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Engine And Engine Cooling:engine
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
09V116000 · Engine And Engine Cooling
Apr 8, 2009
GENERAL MOTORS IS RECALLING 1,497,516 MY 1997-2003 BUICK REGAL, MY 1998-2003 CHEVROLET LUMINA, MONTE CARLO AND IMPALA, MY 1998-1999 OLDSMOBILE INTRIGUE, MY 1997-2003 PONTIAC GRAND PRIX VEHICLES EQUIPPED WITH A 3.8L V6 NATURALLY ASPIRATED ENGINE. SOME OF THESE VEHICLES HAVE A CONDITION IN WHICH DROPS OF ENGINE OIL MAY BE DEPOSITED ON THE EXHAUST MANIFOLD THROUGH HARD BRAKING.
Consequence & remedy
Consequence: IF THE MANIFOLD IS HOT ENOUGH AND THE OIL RUNS BELOW THE HEAT SHIELD, IT MAY IGNITE INTO A SMALL FLAME AND MAY SPREAD TO THE PLASTIC SPARK PLUG WIRE CHANNEL AND BEYOND INCREASING THE RISK OF AN ENGINE COMPARTMENT FIRE.
Remedy: DEALERS WILL REPLACE THE ENGINES FRONT VALVE COVER AND FRONT-VALVE-COVER GASKET WITH NEW PARTS OF AN IMPROVED DESIGN AND REMOVE THE ENGINES PLASTIC COVER AND PLASTIC OIL-FILL-TUBE EXTENSION, FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2016. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, OLDSMOBILE AT 1-800-630-6537, AND PONTIAC AT 1-800-620-7668 OR HTTP://WWW.PONTIAC.COM OR HTTP:WWW.GMOWNERCENTER.COM.
08V118000 · Engine And Engine Cooling
Mar 12, 2008
GM IS RECALLING 207,542 MY 1997-2003 BUICK REGAL AND PONTIAC GRAND PRIX VEHICLES EQUIPPED WITH A 3.8L SUPERCHARGED V-6 ENGINE. THESE VEHICLES HAVE HIGHER FRONT ROCKER COVER GASKET TEMPERATURES, CREATING THE POTENTIAL FOR EARLIER DEGRADATION OF THE FRONT ROCKER COVER GASKET AND EVENTUAL OIL SEEPAGE.
Consequence & remedy
Consequence: CERTAIN UNDERHOOD FIRES MAY BE CAUSED BY DROPS OF ENGINE OIL, FROM SEEPAGE OR SPILLAGE, BEING DEPOSITED ON THE EXHAUST MANIFOLD THROUGH HARD BRAKING. IF THE MANIFOLD IS HOT ENOUGH AND THE OIL RUNS BELOW THE HEAT SHIELD, IT MAY IGNITE INTO A SMALL FLAME AND, IN SOME INSTANCES, THE FIRE MAY SPREAD TO THE PLASTIC SPARK PLUG WIRE CHANNEL AND BEYOND.
Remedy: DEALERS WILL REPLACE THE ENGINES FRONT VALVE COVER AND FRONT-VALVE-COVER GASKET WITH NEW PARTS OF AN IMPROVED DESIGN AND REMOVE THE ENGINES PLASTIC COVER AND PLASTIC OIL-FILL-TUBE EXTENSION, ALONG WITH THE 1-3-5 SPARK PLUG WIRE RETAINERS, FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2016. , FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2016. UNTIL THE REMEDY IS COMPLETED, GM STRONGLY RECOMMENDS THAT OWNERS OBSERVE THE FOLLOWING IMPORTANT PRECAUTIONS (1) THAT OWNERS DO NOT PARK THEIR VEHICLE IN A GARAGE, CAR PORT, OR OTHER STRUCTURE; (2) IF OWNERS NOTICE A BURNING ODOR, THEY SHOULD HAVE THEIR DEALER INSPECT THE VEHICLE. THE DEALER WILL INSPECT THE VEHICLE WITHOUT CHARGE; (3) USE PREMIUM FUEL (91 OCTANE OR HIGHER) IN THE VEHICLE AS RECOMMENDED IN THE VEHICLE'S OWNER MANUAL. OWNERS MAY CONTACT BUICK AT 1-866-608-8080 OR PONTIAC AT 1-800-620-7668, OR THROUGH THEIR WEBSITE AT <A HREF=HTTP://WWW.GMOWNERCENTER.COM>HTTP://WWW.GMOWNERCENTER.COM</A> .
04V375000 · Exterior Lighting:headlights
Aug 10, 2004
CERTAIN PASSENGER VEHICLES DO NOT CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." SOME OF THESE VEHICLES DO NOT MEET THE OVERHEAD SIGN ILLUMINATION REQUIREMENTS.
Consequence & remedy
Consequence: LESS ILLUMINATION MAY REDUCE THE ABILITY OF THE DRIVER TO READ OVERHEAD SIGNS WHEN DRIVING AT NIGHT.
Remedy: DEALERS WILL INSTALL NEW LOW BEAM HEADLAMP BULBS IN BOTH OF THE HEADLAMP ASSEMBLIES. THE RECALL BEGAN ON SEPTEMBER 8, 2004. OWNERS SHOULD CONTACT BUICK AT 1-866-608-8080. NOTE: IF THE BULB NEEDS REPLACEMENT IN THE FUTURE, GM BULB NUMBER 89024715 IS AVAILABLE FROM A DEALER, OR THE EQUIVALENT SYLVANIA BULB IS 9006HP, WITH ORANGE LETTERING ON THE BULB.
99V356000 · Exterior Lighting:headlights
Dec 17, 1999
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THESE VEHICLES DO NOT CONFORM TO THE REQUIREMENTS OF FMVSS NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THE VERTICAL HEAD LAMP ADJUSTING DEVICE MAY NOT BE CALIBRATED PROPERLY.
Consequence & remedy
Consequence: DRIVER VISIBILITY MAY BE IMPAIRED INCREASING THE RISK OF A CRASH.
Remedy: OWNERS WILL BE PROVIDED WITH AN OWNER'S MANUAL INSERT CONTAINING INSTRUCTIONS FOR OPTICALLY AIMING THE HEADLAMPS.
99V170000 · Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip
Jul 9, 1999
SOME OF THESE VEHICLES WITH THE KEY IN THE "ON" POSITION, EXHIBIT A CONDITION IN WHICH THE ANTILOCK BRAKE SYSTEM (ABS) MOTOR SHORTS TO ITS CASE AND GROUNDS THROUGH A FLEXIBLE BRAKE FLUID PIPE.
Consequence & remedy
Consequence: THIS SHORT CAN CAUSE EXTREME HEATING OF THE FLEXIBLE BRAKE PIPE WHERE IT CAN MELT A NEARBY FLEXIBLE PLASTIC FUEL HOSE, WHICH COULD RESULT IN AN UNDERHOOD FIRE.
Remedy: DEALERS WILL INSTALL A GROUND CABLE FROM THE ELECTRONIC BRAKE CONTROL MODULE (EBCM) TO THE ENGINE COMPARTMENT BODY RAIL.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3EA07008 · Engine Compartment Fire
Opened Jun 12, 2007 · Closed May 1, 2008
Status: closed (inferred from source dates) · Engine And Engine Cooling
BY LETTER DATED MARCH 12, 2008, GENERAL MOTORS CORP. (GM) HAS NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL (IDENTIFIED BY NHTSA RECALL NUMBER 08V-118) TO ADDRESS A DEFECT IN APPROXIMATELY 207,542 MODEL YEAR (MY) 1997-2003 BUICK REGAL GS AND PONTIAC GRAND PRIX GTP VEHICLES EQUIPPED WITH THE L67 SUPERCHARGED VERSION OF GM'S 3800 SERIES II V6 ENGINE.THE RECALLED REGAL GS VEHICLES WERE BUILT FROM AUGUST 1996 TO JUNE 2003 AND THE GRAND PRIX GTP FROM MARCH 1996 THROUGH JANUARY 2003.ACCORDING TO GM, OIL MAY ESCAPE PAST THE VALVE COVER GASKET ON THE FRONT CYLINDER BANK (CYLINDERS 1-3-5) AND DEPOSIT ONTO HOT EXHAUST SYSTEM COMPONENTS.UNDER CERTAIN CONDITIONS, IT IS POSSIBLE FOR THIS OIL TO IGNITE A SMALL PILOT FLAME, WHICH MAY SPREAD TO THE ADJACENT PLASTIC SPARK PLUG WIRE CHANNEL, THE SPARK PLUG WIRES THEMSELVES, THE PLASTIC ENGINE COVER, AND OTHER UNDER HOOD COMPONENTS.REPORTS INDICATE THIS MOST OFTEN OCCURS ON HIGHER-MILEAGE VEHICLES SHORTLY AFTER THE VEHICLE HAS BEEN DRIVEN AND THEN PARKED.TYPICALLY, THE FIRE WAS DISCOVERED WITHIN 5 TO 15 MINUTES AFTER THE VEHICLE WAS PARKED.DURING THIS TIME WINDOW, UNDER HOOD TEMPERATURES MAY BECOME ELEVATED.SUCH ELEVATED TEMPERATURES COMBINED WITH A LACK OF AIRFLOW THROUGH THE ENGINE COMPARTMENT MAY PERMIT A SMALL PILOT FLAME TO PROPAGATE AND IGNITE OTHER FUEL SOURCES.TO CORRECT THE SAFETY DEFECT, GM WILL INSTALL AN IMPROVED DESIGN FRONT VALVE COVER GASKET AND SPARK PLUG WIRE RETAINER.THIS REMEDY WILL BE SUPPLIEDFREE OF CHARGE FOR ALL RECALLED VEHICLES.UNTIL SUFFICIENT PARTS BECOME AVAILABLE TO REPAIR ALL OF THE AFFECTED VEHICLES, GM STRONGLY RECOMMENDS THAT OWNERS OBSERVE THE FOLLOWING IMPORTANT PRECAUTIONS: (1) THEY STRONGLY RECOMMEND THAT OWNERS DO NOT PARK THEIR VEHICLE IN A GARAGE, CARPORT, OR OTHER STRUCTURE; (2) IF OWNERS NOTICE A BURNING ODOR, THEY SHOULD HAVE THEIR DEALER INSPECT THE VEHICLE - THE DEALER WILL INSPECT THE VEHICLE WITHOUT CHARGE; AND (3) USE PREMIUM FUEL (91 OCTANE OR HIGHER) IN THE VEHICLE AS RECOMMENDED IN THE VEHICLE'S OWNER MANUAL.THE ACTION TAKEN BY GM IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE SUBJECT FIRE INCIDENT RATE ON THE C-, G-, AND H-PLATFORM SUBJECT VEHICLES IS LOW.THE AGENCY WILL CONTINUE TO MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
Additional source detail variants (2)
Engine And Engine Cooling
BY LETTER DATED MARCH 12, 2008, GENERAL MOTORS CORP. (GM) HAS NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL (IDENTIFIED BY NHTSA RECALL NUMBER 08V-118) TO ADDRESS A DEFECT IN APPROXIMATELY 207,542 MODEL YEAR (MY) 1997-2003 BUICK REGAL GS AND PONTIAC GRAND PRIX GTP VEHICLES EQUIPPED WITH THE L67 SUPERCHARGED VERSION OF GM'S 3800 SERIES II V6 ENGINE.THE RECALLED REGAL GS VEHICLES WERE BUILT FROM AUGUST 1996 TO JUNE 2003 AND THE GRAND PRIX GTP FROM MARCH 1996 THROUGH JANUARY 2003.ACCORDING TO GM, OIL MAY ESCAPE PAST THE VALVE COVER GASKET ON THE FRONT CYLINDER BANK (CYLINDERS 1-3-5) AND DEPOSIT ONTO HOT EXHAUST SYSTEM COMPONENTS.UNDER CERTAIN CONDITIONS, IT IS POSSIBLE FOR THIS OIL TO IGNITE A SMALL PILOT FLAME, WHICH MAY SPREAD TO THE ADJACENT PLASTIC SPARK PLUG WIRE CHANNEL, THE SPARK PLUG WIRES THEMSELVES, THE PLASTIC ENGINE COVER, AND OTHER UNDER HOOD COMPONENTS.REPORTS INDICATE THIS MOST OFTEN OCCURS ON HIGHER-MILEAGE VEHICLES SHORTLY AFTER THE VEHICLE HAS BEEN DRIVEN AND THEN PARKED.TYPICALLY, THE FIRE WAS DISCOVERED WITHIN 5 TO 15 MINUTES AFTER THE VEHICLE WAS PARKED.DURING THIS TIME WINDOW, UNDER HOOD TEMPERATURES MAY BECOME ELEVATED.SUCH ELEVATED TEMPERATURES COMBINED WITH A LACK OF AIRFLOW THROUGH THE ENGINE COMPARTMENT MAY PERMIT A SMALL PILOT FLAME TO PROPAGATE AND IGNITE OTHER FUEL SOURCES.TO CORRECT THE SAFETY DEFECT, GM WILL INSTALL AN IMPROVED DESIGN FRONT VALVE COVER GASKET AND SPARK PLUG WIRE RETAINER.THIS REMEDY WILL BE SUPPLIEDFREE OF CHARGE FOR ALL RECALLED VEHICLES.UNTIL SUFFICIENT PARTS BECOME AVAILABLE TO REPAIR ALL OF THE AFFECTED VEHICLES, GM STRONGLY RECOMMENDS THAT OWNERS OBSERVE THE FOLLOWING IMPORTANT PRECAUTIONS: (1) THEY STRONGLY RECOMMEND THAT OWNERS DO NOT PARK THEIR VEHICLE IN A GARAGE, CARPORT, OR OTHER STRUCTURE; (2) IF OWNERS NOTICE A BURNING ODOR, THEY SHOULD HAVE THEIR DEALER INSPECT THE VEHICLE - THE DEALER WILL INSPECT THE VEHICLE WITHOUT CHARGE; AND (3) USE PREMIUM FUEL (91 OCTANE OR HIGHER) IN THE VEHICLE AS RECOMMENDED IN THE VEHICLE'S OWNER MANUAL.THE ACTION TAKEN BY GM IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE SUBJECT FIRE INCIDENT RATE ON THE C-, G-, AND H-PLATFORM SUBJECT VEHICLES IS LOW.THE AGENCY WILL CONTINUE TO MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
Engine And Engine Cooling
BY LETTER DATED MARCH 12, 2008, GENERAL MOTORS CORP. (GM) HAS NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL (IDENTIFIED BY NHTSA RECALL NUMBER 08V-118) TO ADDRESS A DEFECT IN APPROXIMATELY 207,542 MODEL YEAR (MY) 1997-2003 BUICK REGAL GS AND PONTIAC GRAND PRIX GTP VEHICLES EQUIPPED WITH THE L67 SUPERCHARGED VERSION OF GM'S 3800 SERIES II V6 ENGINE.THE RECALLED REGAL GS VEHICLES WERE BUILT FROM AUGUST 1996 TO JUNE 2003 AND THE GRAND PRIX GTP FROM MARCH 1996 THROUGH JANUARY 2003.ACCORDING TO GM, OIL MAY ESCAPE PAST THE VALVE COVER GASKET ON THE FRONT CYLINDER BANK (CYLINDERS 1-3-5) AND DEPOSIT ONTO HOT EXHAUST SYSTEM COMPONENTS.UNDER CERTAIN CONDITIONS, IT IS POSSIBLE FOR THIS OIL TO IGNITE A SMALL PILOT FLAME, WHICH MAY SPREAD TO THE ADJACENT PLASTIC SPARK PLUG WIRE CHANNEL, THE SPARK PLUG WIRES THEMSELVES, THE PLASTIC ENGINE COVER, AND OTHER UNDER HOOD COMPONENTS.REPORTS INDICATE THIS MOST OFTEN OCCURS ON HIGHER-MILEAGE VEHICLES SHORTLY AFTER THE VEHICLE HAS BEEN DRIVEN AND THEN PARKED.TYPICALLY, THE FIRE WAS DISCOVERED WITHIN 5 TO 15 MINUTES AFTER THE VEHICLE WAS PARKED.DURING THIS TIME WINDOW, UNDER HOOD TEMPERATURES MAY BECOME ELEVATED.SUCH ELEVATED TEMPERATURES COMBINED WITH A LACK OF AIRFLOW THROUGH THE ENGINE COMPARTMENT MAY PERMIT A SMALL PILOT FLAME TO PROPAGATE AND IGNITE OTHER FUEL SOURCES.TO CORRECT THE SAFETY DEFECT, GM WILL INSTALL AN IMPROVED DESIGN FRONT VALVE COVER GASKET AND SPARK PLUG WIRE RETAINER.THIS REMEDY WILL BE SUPPLIEDFREE OF CHARGE FOR ALL RECALLED VEHICLES.UNTIL SUFFICIENT PARTS BECOME AVAILABLE TO REPAIR ALL OF THE AFFECTED VEHICLES, GM STRONGLY RECOMMENDS THAT OWNERS OBSERVE THE FOLLOWING IMPORTANT PRECAUTIONS: (1) THEY STRONGLY RECOMMEND THAT OWNERS DO NOT PARK THEIR VEHICLE IN A GARAGE, CARPORT, OR OTHER STRUCTURE; (2) IF OWNERS NOTICE A BURNING ODOR, THEY SHOULD HAVE THEIR DEALER INSPECT THE VEHICLE - THE DEALER WILL INSPECT THE VEHICLE WITHOUT CHARGE; AND (3) USE PREMIUM FUEL (91 OCTANE OR HIGHER) IN THE VEHICLE AS RECOMMENDED IN THE VEHICLE'S OWNER MANUAL.THE ACTION TAKEN BY GM IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE SUBJECT FIRE INCIDENT RATE ON THE C-, G-, AND H-PLATFORM SUBJECT VEHICLES IS LOW.THE AGENCY WILL CONTINUE TO MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
EA02030 · Engine Compartment Fires
Opened Oct 22, 2002 · Closed Mar 9, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:delivery; Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (3)
Fuel System, Gasoline:delivery
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
PE02050 · Engine Compartment Fires
Opened Jun 13, 2002 · Closed Oct 22, 2002
Status: closed (inferred from source dates) · Engine And Engine Cooling
No summary supplied.