NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
302 reports75,000 miles · Apr 17, 2008
Exterior Lighting
1998 BUICK REGAL GS, PROBLEM EVIDENT FOR THE LAST 10, 000 MILES. WHEN USING THE TURN SIGNAL STICK, CAR EXPERIENCES A "DEAD SHORT" AND ENGINE SHUTS DOWN WHILE CAR IS ROLLING. CAR BECOMES WORSE AS CAR IS DRIVEN FOR AN EXTENDED PERIOD OF TIME. DEALER SAID HE COULD NOT REPRODUCE THE PROBLEM. IT IS INTERMITTENT, BUT EXTREMELY DAN…
Read full complaint
1998 BUICK REGAL GS, PROBLEM EVIDENT FOR THE LAST 10, 000 MILES. WHEN USING THE TURN SIGNAL STICK, CAR EXPERIENCES A "DEAD SHORT" AND ENGINE SHUTS DOWN WHILE CAR IS ROLLING. CAR BECOMES WORSE AS CAR IS DRIVEN FOR AN EXTENDED PERIOD OF TIME. DEALER SAID HE COULD NOT REPRODUCE THE PROBLEM. IT IS INTERMITTENT, BUT EXTREMELY DANGEROUS. ON MY LAST RIDE(4/21/2008), THE VEHICLE CONSISTENTLY EXPERIENCED A CUT OFF OF POWER AND IF I HAD NOT MOVED THE TURN SIGNAL STALK TO ITS NEUTRAL POSITION, I AM SURE THE CAR WOULD HAVE STALLED WHILE STILL IN MOTION, REDUCING AND/OR ELIMINATING POWER STEERING AND BRAKE FUNCTIONS. THE PROBLEM STARTED AT ABOUT 75,000 MILES. HAVE THERE BEEN OTHER COMPLAINTS? *TR
NHTSA ODI #10224789
166,000 miles · Mar 29, 2008
Engine And Engine CoolingFire
1998 BUICK REGAL LS (3.8 NON-SUPERCHARGED) WAS DRIVEN ABOUT 5-10 MILES FOR THE FIRST TIME TODAY. CAR WAS THEN PARKED, DRIVER ENTERED DESTINATION ESTABLISHMENT, THEN QUESTIONED IF CAR WAS THEIRS, AND WITHIN 10 MINUTES OF CAR BEING SHUT OFF, A FIRE ENGULFED THE ENGINE COMPARTMENT. FIRE WAS PUT OUT BY LOCAL FIRE DEPARTMENT AND PO…
Read full complaint
1998 BUICK REGAL LS (3.8 NON-SUPERCHARGED) WAS DRIVEN ABOUT 5-10 MILES FOR THE FIRST TIME TODAY. CAR WAS THEN PARKED, DRIVER ENTERED DESTINATION ESTABLISHMENT, THEN QUESTIONED IF CAR WAS THEIRS, AND WITHIN 10 MINUTES OF CAR BEING SHUT OFF, A FIRE ENGULFED THE ENGINE COMPARTMENT. FIRE WAS PUT OUT BY LOCAL FIRE DEPARTMENT AND POLICE REPORT WAS FILED. NO INJURIES AND NO OTHER BY STANDING VEHICLE DAMAGE. THERE IS A POSSIBILITY THAT THIS IS RELATED TO THE 3.8 SUPERCHARGED GRAND PRIX & REGAL RECALL THAT IS ONLINE AT NHTSA (08V-118). VEHICLE IS NOT REPAIRABLE. VEHICLE HAD 166,000 MILES AND 1500 SINCE LAST OIL CHANGE. RECALL SHOULD BE EXTENDED TO INCLUDE NON-SUPERCHARGED 3.8L ENGINES OF SAME TYPE. *TR
NHTSA ODI #10222688
99,000 miles · Mar 18, 2008
Engine And Engine CoolingFire
I BOUGHT A BUICK REGAL GS IN 1998 BRAND NEW AND PAID $26,000.00 FOR IT. I WAS THE SOLE OWNER OF THIS VEHICLE AND IT WAS IN VERY GOOD CONDITION AS OF LAST YEAR. ON AUGUST 22 MY SON AND I ARRIVED AT HOME AND PARKED THE CAR ON THE DRIVEWAY OF OUR RESIDENCE. ABOUT 15 MINUTES LATER THE CAR BURST INTO FLAMES UNDER THE HOOD. IT DAM…
Read full complaint
I BOUGHT A BUICK REGAL GS IN 1998 BRAND NEW AND PAID $26,000.00 FOR IT. I WAS THE SOLE OWNER OF THIS VEHICLE AND IT WAS IN VERY GOOD CONDITION AS OF LAST YEAR. ON AUGUST 22 MY SON AND I ARRIVED AT HOME AND PARKED THE CAR ON THE DRIVEWAY OF OUR RESIDENCE. ABOUT 15 MINUTES LATER THE CAR BURST INTO FLAMES UNDER THE HOOD. IT DAMAGED THE GARAGE AND DRIVEWAY AND COULD HAVE BEEN MUCH WORSE IF THE FIRE DEPARTMENT HADN'T ARRIVED WHEN IT DID, AS THE CARS GAS TANK WAS FULL. THE CAR WAS DAMAGED BEYOND REPAIR. MY INSURANCE DID COVER THE CAR AND THE AMOUNT THEY GAVE WAS PITIFUL. I NOW OWN A 2002 PONTIAC GRAND PRIX 30TH ANNIVERSARY EDITION AND IS THAT BEING RECALLED FOR THE SAME THING? IS THERE SOME COMPENSATION FOR ME? I'VE ALWAYS BOUGHT GM VEHICLES AND I WILL CONTINUE TO DEPENDING ON YOUR RESPONSE TO THIS EMAIL. *TR
NHTSA ODI #10221536
91,000 miles · Jan 16, 2008
Electrical SystemEngine And Engine CoolingEquipment
TL*THE CONTACT OWNS A 1998 BUICK REGAL. WHILE DRIVING 1-5 MPH, THE VEHICLE WOULD CONSTANTLY STALL. IN ADDITION, THE VEHICLE STALLED WHILE DRIVING IN REVERSE. THE CONTACT STATED THAT THE VEHICLE WOULD SHUT OFF WHEN THE CHECK ENGINE LIGHT ILLUMINATED. THE CONTACT WAS ABLE TO RESTART THE VEHICLE AFTER IT STALLED. THE FAILURE M…
Read full complaint
TL*THE CONTACT OWNS A 1998 BUICK REGAL. WHILE DRIVING 1-5 MPH, THE VEHICLE WOULD CONSTANTLY STALL. IN ADDITION, THE VEHICLE STALLED WHILE DRIVING IN REVERSE. THE CONTACT STATED THAT THE VEHICLE WOULD SHUT OFF WHEN THE CHECK ENGINE LIGHT ILLUMINATED. THE CONTACT WAS ABLE TO RESTART THE VEHICLE AFTER IT STALLED. THE FAILURE MILEAGE WAS 92,900 AND CURRENT MILEAGE WAS 92,988. UPDATED 02/15/08. *LJ THE CONSUMER HAS EXPERIENCED OTHER PROBLEMS WITH THE VEHICLE SUCH AS STEERING GEAR FAILURE, WHICH THE RACK AND PINION WAS REPLACED. AIR CONDITION FAILURE, TRANSMISSION TORQUE CONVERTER, WHICH THE ENTIRE TRANSMISSION WAS OVERHAULED. THE IGNITION SWITCH SHORTED OUT. THE RIGHT FRONT WINDOW REGULATOR WAS REPLACED. UPDATED
NHTSA ODI #10215176
Mileage unknown · Aug 15, 2007
Steering
I WAS LEAVING A PARKING LOT WHEN THE POWER STEERING FAILED TO ASSIST WHEN TURNING RIGHT, TURNING LEFT WAS O K. I MANAGED TO GET THE CAR HOME, IT WAS A SHORT DISTANCE. THIS OCCURRED ON OR ABOUT 8/2/07. ON 8/13/07 I LOOKED UNDER THE CAR WITH A MIRROR AND WAS ABLE TO FIND A OPEN CAVITY ON THE BOTTOM OF THE STEERING UNIT. THERE WAS…
Read full complaint
I WAS LEAVING A PARKING LOT WHEN THE POWER STEERING FAILED TO ASSIST WHEN TURNING RIGHT, TURNING LEFT WAS O K. I MANAGED TO GET THE CAR HOME, IT WAS A SHORT DISTANCE. THIS OCCURRED ON OR ABOUT 8/2/07. ON 8/13/07 I LOOKED UNDER THE CAR WITH A MIRROR AND WAS ABLE TO FIND A OPEN CAVITY ON THE BOTTOM OF THE STEERING UNIT. THERE WAS A SHAFT AND NUT IN THE CAVITY BUT COULD NOT DISCERN A BEARING. I LOOKED ON THE INTERNET FOR RELEVANT INFORMATION AND FOUND THAT A RECALL HAD BEEN ISSUED FOR THIS PROBLEM. I WENT TO THE LOCAL DEALER AND FOUND OUT THAT THE DEALER HAD ACCOMPLISHED THE RECALL ON THE VEHICLE. I CAME HOME AND FOUND THE INVOICE FOR THE RECALL, IT INDICATES A DATE OF JULY 27, 2004, A MILEAGE OF 58,373 AND THAT THE POWER STEERING GEAR LOWER BEARING WAS REPLACED. THE CAR NOW HAS 96,644 MILES ON IT. I HAVE AN APPOINTMENT WITH THE DEALER ON 8/17/07 TO ASCERTAIN WHAT NEEDS TO BE DONE TO REMEDY THE SITUATION. NO PARTS ARE AVAILABLE. JUST THOUGHT YOU MIGHT LIKE TO KNOW. *JB
NHTSA ODI #10199638
71,000 miles · Jul 25, 2007
Steering
TL*THE CONTACT OWNS A 1998 BUICK REGAL. IN 2004, THE CONTACT RECEIVED RECALL NOTICE NUMBER 03V527000 (STEERING:RACK AND PINION). THE VEHICLE HAD 48,721 MILES AT THE TIME. SHE WENT TO THE DEALER AND HAD THE RECALL REPAIR PERFORMED. THE POWER STEERING HAS FAILED AGAIN AND SHE BELIEVES THAT IT SHOULD NOT HAVE FAILED SO QUICKLY.…
Read full complaint
TL*THE CONTACT OWNS A 1998 BUICK REGAL. IN 2004, THE CONTACT RECEIVED RECALL NOTICE NUMBER 03V527000 (STEERING:RACK AND PINION). THE VEHICLE HAD 48,721 MILES AT THE TIME. SHE WENT TO THE DEALER AND HAD THE RECALL REPAIR PERFORMED. THE POWER STEERING HAS FAILED AGAIN AND SHE BELIEVES THAT IT SHOULD NOT HAVE FAILED SO QUICKLY. THE CURRENT MILEAGE WAS 72,000 AND FAILURE MILEAGE WAS 71,000.
NHTSA ODI #10197436
90,000 miles · May 3, 2007
Steering
THE STEERING RACK AND PINION OF THE BUICK REGAL HAS BEEN NOTED TO FAIL IN VARIOUS MODELS, YEARS 1996-1998; HOWEVER MANY VEHICLES (IDENTIFIED BY VIN) ARE NOT SUBJECT TO RECALL STATUS. I BELIEVE THAT FURTHER INVESTIGATION NEEDS TO BE CONDUCTED, SIMPLY BECAUSE SOME OF THE VEHICLES NOT LISTED ARE EXPERIENCING THE SAME PROBLEM. THE…
Read full complaint
THE STEERING RACK AND PINION OF THE BUICK REGAL HAS BEEN NOTED TO FAIL IN VARIOUS MODELS, YEARS 1996-1998; HOWEVER MANY VEHICLES (IDENTIFIED BY VIN) ARE NOT SUBJECT TO RECALL STATUS. I BELIEVE THAT FURTHER INVESTIGATION NEEDS TO BE CONDUCTED, SIMPLY BECAUSE SOME OF THE VEHICLES NOT LISTED ARE EXPERIENCING THE SAME PROBLEM. THE STEERING SUDDENLY FAILS TO THE LEFT, CAUSING HAZARDOUS DRIVING CONDITIONS FOR THE DRIVER. *TR
NHTSA ODI #10189631
26,000 miles · Jan 8, 2007
Steering
1998 REGAL POWER STEERING RACK WONT TURN LEFT. THIS IS IRRESPONSIBLE OF GM (BUICK) TO NOT STEP UP AND FIX THIS PROBLEM. I WAS GIVEN THIS CAR THIS YEAR WITH ONLY 26000 MILES ON IT. WITHIN 2 MONTHS THE STEERING GAVE OUT ON THE HIGHWAY 600 MILES FROM HOME. BUICK HAD THE SAME OLD STORY, YOUR VIN DOESN'T FALL WITHIN THE RECALLS BLOCK…
Read full complaint
1998 REGAL POWER STEERING RACK WONT TURN LEFT. THIS IS IRRESPONSIBLE OF GM (BUICK) TO NOT STEP UP AND FIX THIS PROBLEM. I WAS GIVEN THIS CAR THIS YEAR WITH ONLY 26000 MILES ON IT. WITHIN 2 MONTHS THE STEERING GAVE OUT ON THE HIGHWAY 600 MILES FROM HOME. BUICK HAD THE SAME OLD STORY, YOUR VIN DOESN'T FALL WITHIN THE RECALLS BLOCK OF VIN'S. THIS PROBLEM HAS NOTHING TO DO WITH VIN'S OR PRODUCTION DATES. THE CASTING ON THE HOUSING OF THE STEERING GEAR IS WHERE THE TRUE MANUFACTURING DEFECT CAN BE IDENTIFIED. THE STATE DEPT OF REHAB WAS GOING TO PUT HAND CONTROLS IN THIS CAR FOR ME, BUT NOW I HAVE A 1200$ REPAIR BILL I CAN'T AFFORD. THIS ISN'T RIGHT. *JB
NHTSA ODI #10178089
Mileage unknown · Jan 4, 2007
Unknown Or Other
I OWN A 1998 BUICK REGAL LS. WHEN IT RAINS, WATER DRIPS DOWN FROM BEHIND THE GLOVE BOX AND ONTO THE PASSENGER FLOOR. IN ONE PARTICULARLY HEAVY RAINFALL, THERE WAS 2 INCHES OF STANDING WATER ON THE FLOOR OF THE PASSENGER SIDE. THANKS IN ADVANCE FOR ANY ASSISTANCE. *JB
NHTSA ODI #10177754
89,379 miles · Dec 28, 2006
Steering
TL*- THE CONTACT STATED THAT WHILE DRIVING HIS 1998 BUICK REGAL HARD TIME TURNING LEFT, USUALLY WHEN DRIVING AT 40 MPH OR LOWER. THE CONTACT STATED THAT HE TOOK HIS VEHICLE TO DEALERSHIP ,AND WAS TOLD THAT VEHICLE DIDN'T QUALIFY FOR RECALL 03V527000 DUE TO VIN. THE CONTACT WAS TOLD HE NEEDED TO CONTACT THE MANUFACTURER, …
Read full complaint
TL*- THE CONTACT STATED THAT WHILE DRIVING HIS 1998 BUICK REGAL HARD TIME TURNING LEFT, USUALLY WHEN DRIVING AT 40 MPH OR LOWER. THE CONTACT STATED THAT HE TOOK HIS VEHICLE TO DEALERSHIP ,AND WAS TOLD THAT VEHICLE DIDN'T QUALIFY FOR RECALL 03V527000 DUE TO VIN. THE CONTACT WAS TOLD HE NEEDED TO CONTACT THE MANUFACTURER, WHEN HE DID THAT THE MANUFACTURER TOLD HIM TO CONTACT HIS LOCAL DEALERSHIP TO HAVE THE PROBLEM DIAGNOSED. THE CONTACT WENT BACK TO SAME DEALERSHIP, AND WAS TOLD THAT IT WAS THE POWER STEERING AND DIDN'T CHARGE HIM THE DIAGNOSTIC FEE. THE CONTACT TOOK THE VEHICLE TO HIS OWN MECHANIC AND THEY INSTALLED TWO NEW POWER STEERING PUMPS. THE REPAIR STILL DIDN'T RESOLVE THE FAILURE. THE CONTACT DIDN'T THINK THAT THE DEALERSHIP RAN A DIAGNOSTIC ON VEHICLE BEFORE TELLING HIM THAT THE POWER STEERING VALVES NEEDED TO REPLACED. THE CONTACT STATED THAT HIS MECHANIC TOLDHIM THAT THE VEHICLE DIDN'T NEED TO HAVE THE PUMPS REPLACED, BUTTHE CONTACT THOUGHT IT WAS BEST TO HAVE PUMPS REPLACED. THE CONTACT STATED THAT HE CALLED THE DEALERSHIP BACK, AND TOLD THEM THAT HE DID HAVE THE PUMPS REPLACED, AND THEY TOLD HIM THAT MAYBE IT MAY BE HIS STEERING RACK AND PINION. THE CONTACT CALLED THE MANUFACTURER BACK AND TOLD THEM OF ALL THE REPAIRS, AND ASKED THEM IF THEY WOULD REPAIR RACK AND PINION. HE WAS TOLD THAT THEY WOULD NOT DO REPAIRS BECAUSE THEY EXCHANGED HE PARTS OUT FOR THIS VEHICLE MANUFACTURED. AK
NHTSA ODI #10177253
Official recalls
6Oct 26, 2015
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence & remedy
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Additional source detail variants (2)
Engine And Engine Cooling:exhaust System:manifold/header/muffler/tail Pipe
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Engine And Engine Cooling:engine
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Apr 8, 2009
GENERAL MOTORS IS RECALLING 1,497,516 MY 1997-2003 BUICK REGAL, MY 1998-2003 CHEVROLET LUMINA, MONTE CARLO AND IMPALA, MY 1998-1999 OLDSMOBILE INTRIGUE, MY 1997-2003 PONTIAC GRAND PRIX VEHICLES EQUIPPED WITH A 3.8L V6 NATURALLY ASPIRATED ENGINE. SOME OF THESE VEHICLES HAVE A CONDITION IN WHICH DROPS OF ENGINE OIL MAY BE DEPOSITED ON THE EXHAUST MANIFOLD THROUGH HARD BRAKING.
Consequence & remedy
Consequence: IF THE MANIFOLD IS HOT ENOUGH AND THE OIL RUNS BELOW THE HEAT SHIELD, IT MAY IGNITE INTO A SMALL FLAME AND MAY SPREAD TO THE PLASTIC SPARK PLUG WIRE CHANNEL AND BEYOND INCREASING THE RISK OF AN ENGINE COMPARTMENT FIRE.
Remedy: DEALERS WILL REPLACE THE ENGINES FRONT VALVE COVER AND FRONT-VALVE-COVER GASKET WITH NEW PARTS OF AN IMPROVED DESIGN AND REMOVE THE ENGINES PLASTIC COVER AND PLASTIC OIL-FILL-TUBE EXTENSION, FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2016. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, OLDSMOBILE AT 1-800-630-6537, AND PONTIAC AT 1-800-620-7668 OR HTTP://WWW.PONTIAC.COM OR HTTP:WWW.GMOWNERCENTER.COM.
Mar 12, 2008
GM IS RECALLING 207,542 MY 1997-2003 BUICK REGAL AND PONTIAC GRAND PRIX VEHICLES EQUIPPED WITH A 3.8L SUPERCHARGED V-6 ENGINE. THESE VEHICLES HAVE HIGHER FRONT ROCKER COVER GASKET TEMPERATURES, CREATING THE POTENTIAL FOR EARLIER DEGRADATION OF THE FRONT ROCKER COVER GASKET AND EVENTUAL OIL SEEPAGE.
Consequence & remedy
Consequence: CERTAIN UNDERHOOD FIRES MAY BE CAUSED BY DROPS OF ENGINE OIL, FROM SEEPAGE OR SPILLAGE, BEING DEPOSITED ON THE EXHAUST MANIFOLD THROUGH HARD BRAKING. IF THE MANIFOLD IS HOT ENOUGH AND THE OIL RUNS BELOW THE HEAT SHIELD, IT MAY IGNITE INTO A SMALL FLAME AND, IN SOME INSTANCES, THE FIRE MAY SPREAD TO THE PLASTIC SPARK PLUG WIRE CHANNEL AND BEYOND.
Remedy: DEALERS WILL REPLACE THE ENGINES FRONT VALVE COVER AND FRONT-VALVE-COVER GASKET WITH NEW PARTS OF AN IMPROVED DESIGN AND REMOVE THE ENGINES PLASTIC COVER AND PLASTIC OIL-FILL-TUBE EXTENSION, ALONG WITH THE 1-3-5 SPARK PLUG WIRE RETAINERS, FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2016. , FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2016. UNTIL THE REMEDY IS COMPLETED, GM STRONGLY RECOMMENDS THAT OWNERS OBSERVE THE FOLLOWING IMPORTANT PRECAUTIONS (1) THAT OWNERS DO NOT PARK THEIR VEHICLE IN A GARAGE, CAR PORT, OR OTHER STRUCTURE; (2) IF OWNERS NOTICE A BURNING ODOR, THEY SHOULD HAVE THEIR DEALER INSPECT THE VEHICLE. THE DEALER WILL INSPECT THE VEHICLE WITHOUT CHARGE; (3) USE PREMIUM FUEL (91 OCTANE OR HIGHER) IN THE VEHICLE AS RECOMMENDED IN THE VEHICLE'S OWNER MANUAL. OWNERS MAY CONTACT BUICK AT 1-866-608-8080 OR PONTIAC AT 1-800-620-7668, OR THROUGH THEIR WEBSITE AT <A HREF=HTTP://WWW.GMOWNERCENTER.COM>HTTP://WWW.GMOWNERCENTER.COM</A> .
Dec 11, 2003
CERTAIN PASSENGER VEHICLES HAVE LOWER PINION BEARINGS IN THE POWER RACK AND PINION ASSEMBLY IN WHICH THE RETAINER TABS WERE NOT CRIMPED PROPERLY. THESE RETAINERS COULD FAIL AND PERMIT THE BALL BEARINGS TO ESCAPE.
Consequence & remedy
Consequence: IF THIS OCCURS, THE PINION SHAFT CAN BE FORCED UPWARD DURING LEFT TURNS AND BACK DOWN AS THE STEERING WHEEL IS MOVED BACK AND TO THE RIGHT. IF THE PINION SHAFT MOVES FURTHER, THE DRIVER WILL NEED TO EXERT MORE EFFORT TO TURN THE STEERING WHEEL, SIMILAR TO A VEHICLE WITHOUT POWER ASSISTED STEERING. IF THE PINION SHAFT MOVES EVEN FURTHER, THE DRIVER WILL REQUIRE MUCH HIGHER EFFORT TO TURN LEFT AND MAY NOT BE ABLE TO TURN THE WHEEL AS MUCH AS INTENDED. WITH THE MAXIMUM PINION SHAFT MOVEMENT, WHICH REQUIRES INTERNAL GEAR COMPONENT DAMAGE, THE DRIVER CAN ENCOUNTER HIGH RESISTANCE TO TURNING LEFT, FOLLOWED BY UNINTENDED POWER ASSIST TO THE RIGHT. IN ANY OF THESE CONDITIONS, A CRASH COULD OCCUR.
Remedy: DEALERS WILL INSTALL A NEW LOWER PINION BEARING UNLESS INSPECT OF THE EXISTING BEARING INDICATES THAT REPLACEMENT OF THE GEAR ASSEMBLY IS NECESSARY. OWNER NOTIFICATION BEGAN ON FEBRUARY 5, 2004. OWNERS SHOULD CONTACT BUICK AT 1-866-608-8080; CHEVROLET AT 1-800-630-2438; OLDSMOBILE AT 1-800-630-6537; OR PONTIAC AT 1-800-620-7668.
Dec 17, 1999
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THESE VEHICLES DO NOT CONFORM TO THE REQUIREMENTS OF FMVSS NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THE VERTICAL HEAD LAMP ADJUSTING DEVICE MAY NOT BE CALIBRATED PROPERLY.
Consequence & remedy
Consequence: DRIVER VISIBILITY MAY BE IMPAIRED INCREASING THE RISK OF A CRASH.
Remedy: OWNERS WILL BE PROVIDED WITH AN OWNER'S MANUAL INSERT CONTAINING INSTRUCTIONS FOR OPTICALLY AIMING THE HEADLAMPS.
May 15, 1998
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE OWNER MANUALS DO NOT CONTAIN THE REQUIREMENT INFORMATION PERTAINING TO THE VEHICLE HEADLAMP AIMING DEVICE. THIS DOES NOT COMPLY WITH REQUIREMENTS OF FMVSS NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
Consequence & remedy
Consequence: IF THE HEADLAMP ASSEMBLIES ARE REPLACED, CUSTOMERS MAY NOT BE ABLE TO PROPERLY AIM THE HEADLIGHTS.
Remedy: OWNERS WILL BE MAILED AN OWNER MANUAL'S INSERT WHICH CONTAINS THE APPROPRIATE INFORMATION.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
6EA03019 · Power Rack And Pinion Steering Failure
Opened Sep 15, 2003 · Closed Dec 18, 2003
Status: closed (inferred from source dates) · Steering; Steering:rack And Pinion
GM'S LETTER TO NHTSA DATED DECEMBER 11, 2003, EXPANDS ITS ORIGINAL RECALL (NHTSA 02V286) TO INCLUDE CERTAIN W-BODY VEHICLES: 96-97 OLDS CUTLASS SUPREME; 98 OLDS INTRIGUE; 97-98 OLDS CUTLASS; 97-98 CHEVY LUMINA, MONTE CARLO AND MALIBU; 96 PONTIAC GRAND PRIX; AND 96-98 BUICK REGAL.THE NUMBER OF VEHICLES RECALLED IS 750,283.GM DETERMINED THAT FAILURE OF THE RACK AND PINION IS RELATED TO DAMAGE OF THE LOWER PINION BEARING AND THE LEVEL OF THE PINION BEARING PRE-LOAD SPRING FORCE.GM STATES, HIGHER RACK PRE-LOAD SPRING FORCE (133 LB.) IS THE DESIGN CHARACTERISTIC MOST CLOSELY ASSOCIATED WITH HIGHER BEARING DAMAGE RATES IN MOST OF THE VEHICLE APPLICATIONS THAT USED THE GENERAL BEARING COMPANY (GBC) BEARING.ALL OF THE VEHICLES COVERED IN THE EXPANDED RECALL HAVE THE 133 LB SPRING FORCE.THE 96 LUMINA/MONTE CARLO AND 97-98 CENTURY W-BODY VEHICLES INCLUDED IN THIS INVESTIGATION UTILIZE A LOWER SPRING FORCE AND ARE NOT INCLUDED IN THE RECALL.
Additional source detail variants (2)
Steering
GM'S LETTER TO NHTSA DATED DECEMBER 11, 2003, EXPANDS ITS ORIGINAL RECALL (NHTSA 02V286) TO INCLUDE CERTAIN W-BODY VEHICLES: 96-97 OLDS CUTLASS SUPREME; 98 OLDS INTRIGUE; 97-98 OLDS CUTLASS; 97-98 CHEVY LUMINA, MONTE CARLO AND MALIBU; 96 PONTIAC GRAND PRIX; AND 96-98 BUICK REGAL.THE NUMBER OF VEHICLES RECALLED IS 750,283.GM DETERMINED THAT FAILURE OF THE RACK AND PINION IS RELATED TO DAMAGE OF THE LOWER PINION BEARING AND THE LEVEL OF THE PINION BEARING PRE-LOAD SPRING FORCE.GM STATES, HIGHER RACK PRE-LOAD SPRING FORCE (133 LB.) IS THE DESIGN CHARACTERISTIC MOST CLOSELY ASSOCIATED WITH HIGHER BEARING DAMAGE RATES IN MOST OF THE VEHICLE APPLICATIONS THAT USED THE GENERAL BEARING COMPANY (GBC) BEARING.ALL OF THE VEHICLES COVERED IN THE EXPANDED RECALL HAVE THE 133 LB SPRING FORCE.THE 96 LUMINA/MONTE CARLO AND 97-98 CENTURY W-BODY VEHICLES INCLUDED IN THIS INVESTIGATION UTILIZE A LOWER SPRING FORCE AND ARE NOT INCLUDED IN THE RECALL.
Steering:rack And Pinion
GM'S LETTER TO NHTSA DATED DECEMBER 11, 2003, EXPANDS ITS ORIGINAL RECALL (NHTSA 02V286) TO INCLUDE CERTAIN W-BODY VEHICLES: 96-97 OLDS CUTLASS SUPREME; 98 OLDS INTRIGUE; 97-98 OLDS CUTLASS; 97-98 CHEVY LUMINA, MONTE CARLO AND MALIBU; 96 PONTIAC GRAND PRIX; AND 96-98 BUICK REGAL.THE NUMBER OF VEHICLES RECALLED IS 750,283.GM DETERMINED THAT FAILURE OF THE RACK AND PINION IS RELATED TO DAMAGE OF THE LOWER PINION BEARING AND THE LEVEL OF THE PINION BEARING PRE-LOAD SPRING FORCE.GM STATES, HIGHER RACK PRE-LOAD SPRING FORCE (133 LB.) IS THE DESIGN CHARACTERISTIC MOST CLOSELY ASSOCIATED WITH HIGHER BEARING DAMAGE RATES IN MOST OF THE VEHICLE APPLICATIONS THAT USED THE GENERAL BEARING COMPANY (GBC) BEARING.ALL OF THE VEHICLES COVERED IN THE EXPANDED RECALL HAVE THE 133 LB SPRING FORCE.THE 96 LUMINA/MONTE CARLO AND 97-98 CENTURY W-BODY VEHICLES INCLUDED IN THIS INVESTIGATION UTILIZE A LOWER SPRING FORCE AND ARE NOT INCLUDED IN THE RECALL.
RQ03001 · Power Rack And Pinion Steering Failure
Opened Jan 2, 2003 · Closed Sep 15, 2003
Status: closed (inferred from source dates) · Steering; Steering:rack And Pinion
GM CONDUCTED A SAFETY RECALL (NHTSA # 02V286) TO ADDRESS A STEERING DEFECT PERTAINING TO A LOWER PINION BEARING (LPB) WITHIN THE RACK AND PINION STEERING GEAR (R&P). THE RECALL COVERED 1,159,156 MODEL YEAR 1997-1998 PONTIAC GRAND PRIX VEHICLES BUILT BETWEEN MARCH 1, 1996 AND OCTOBER 31, 1997, 1996-1998 PONTIAC TRANS SPORT, CHEVROLET LUMINA APV, CHEVROLET VENTURE, OLDSMOBILE SILHOUETTE MINIVANS, AND CHEVROLET CAVALIER AND PONTIAC SUNFIRE SEDANS BUILT BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997.ODI OPENED THIS RQ AFTER RECEIVING REPORTS THAT OTHER VEHICLES WERE EXHIBITING THE SAME SYMPTOMS AS THE RECALLED VEHICLES.BASED ON ODI'S REVIEW OF TECHNICAL AND COMPLAINT DATA COLLECTED DURING THE RQ, THE W-CARS ARE ASSOCIATED WITH EITHER A HIGHER STEERING COMPLAINT RATE OR A HIGHER LPB FAILURE RATE THAN THE OTHER VEHICLES INVESTIGATED UNDER THE RQ AND ARE ABOVE OR NEAR THE RATES FOR THE RECALLED VEHICLES.THUS, ODI WILL FURTHER EXAMINE THE W-CARS (1996-1997 OLDSMOBILE CUTLASS SUPREME, 1996-1998 BUICK REGAL, CHEVROLET LUMINA, CHEVROLET MONTE CARLO, 1997-1998 BUICK CENTURY, AND 1998 OLDSMOBILE INTRIGUE) UNDER A NEW INVESTIGATION, ENGINEERING ANALYSIS (EA)03-019.
Additional source detail variants (2)
Steering
GM CONDUCTED A SAFETY RECALL (NHTSA # 02V286) TO ADDRESS A STEERING DEFECT PERTAINING TO A LOWER PINION BEARING (LPB) WITHIN THE RACK AND PINION STEERING GEAR (R&P). THE RECALL COVERED 1,159,156 MODEL YEAR 1997-1998 PONTIAC GRAND PRIX VEHICLES BUILT BETWEEN MARCH 1, 1996 AND OCTOBER 31, 1997, 1996-1998 PONTIAC TRANS SPORT, CHEVROLET LUMINA APV, CHEVROLET VENTURE, OLDSMOBILE SILHOUETTE MINIVANS, AND CHEVROLET CAVALIER AND PONTIAC SUNFIRE SEDANS BUILT BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997.ODI OPENED THIS RQ AFTER RECEIVING REPORTS THAT OTHER VEHICLES WERE EXHIBITING THE SAME SYMPTOMS AS THE RECALLED VEHICLES.BASED ON ODI'S REVIEW OF TECHNICAL AND COMPLAINT DATA COLLECTED DURING THE RQ, THE W-CARS ARE ASSOCIATED WITH EITHER A HIGHER STEERING COMPLAINT RATE OR A HIGHER LPB FAILURE RATE THAN THE OTHER VEHICLES INVESTIGATED UNDER THE RQ AND ARE ABOVE OR NEAR THE RATES FOR THE RECALLED VEHICLES.THUS, ODI WILL FURTHER EXAMINE THE W-CARS (1996-1997 OLDSMOBILE CUTLASS SUPREME, 1996-1998 BUICK REGAL, CHEVROLET LUMINA, CHEVROLET MONTE CARLO, 1997-1998 BUICK CENTURY, AND 1998 OLDSMOBILE INTRIGUE) UNDER A NEW INVESTIGATION, ENGINEERING ANALYSIS (EA)03-019.
Steering:rack And Pinion
GM CONDUCTED A SAFETY RECALL (NHTSA # 02V286) TO ADDRESS A STEERING DEFECT PERTAINING TO A LOWER PINION BEARING (LPB) WITHIN THE RACK AND PINION STEERING GEAR (R&P). THE RECALL COVERED 1,159,156 MODEL YEAR 1997-1998 PONTIAC GRAND PRIX VEHICLES BUILT BETWEEN MARCH 1, 1996 AND OCTOBER 31, 1997, 1996-1998 PONTIAC TRANS SPORT, CHEVROLET LUMINA APV, CHEVROLET VENTURE, OLDSMOBILE SILHOUETTE MINIVANS, AND CHEVROLET CAVALIER AND PONTIAC SUNFIRE SEDANS BUILT BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997.ODI OPENED THIS RQ AFTER RECEIVING REPORTS THAT OTHER VEHICLES WERE EXHIBITING THE SAME SYMPTOMS AS THE RECALLED VEHICLES.BASED ON ODI'S REVIEW OF TECHNICAL AND COMPLAINT DATA COLLECTED DURING THE RQ, THE W-CARS ARE ASSOCIATED WITH EITHER A HIGHER STEERING COMPLAINT RATE OR A HIGHER LPB FAILURE RATE THAN THE OTHER VEHICLES INVESTIGATED UNDER THE RQ AND ARE ABOVE OR NEAR THE RATES FOR THE RECALLED VEHICLES.THUS, ODI WILL FURTHER EXAMINE THE W-CARS (1996-1997 OLDSMOBILE CUTLASS SUPREME, 1996-1998 BUICK REGAL, CHEVROLET LUMINA, CHEVROLET MONTE CARLO, 1997-1998 BUICK CENTURY, AND 1998 OLDSMOBILE INTRIGUE) UNDER A NEW INVESTIGATION, ENGINEERING ANALYSIS (EA)03-019.
EA02030 · Engine Compartment Fires
Opened Oct 22, 2002 · Closed Mar 9, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:delivery; Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (3)
Fuel System, Gasoline:delivery
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
PE02050 · Engine Compartment Fires
Opened Jun 13, 2002 · Closed Oct 22, 2002
Status: closed (inferred from source dates) · Engine And Engine Cooling
No summary supplied.
EA99024 · Windshield Wiper
Opened Aug 20, 1999 · Closed Jan 13, 2000
Status: closed (inferred from source dates) · Visibility
BY LETTER DATED DECEMBER 12, 1999, GM NOTIFIED NHTSA OF ITS PLANS TO CONDUCT A SAFETY RELATED DEFECT CAMPAIGN TO REMEDY 155,149 OF THE SUBJECT VEHICLES.THE VEHICLE POPULATION FOR THE CAMPAIGN INCLUDES THE 1997 BUICK REGAL/CENTURY AND PONTIAC GRAN PRIX MODELS BUILT DURING THE PERIOD FROM THE START OF PRODUCTION THROUGH MAY 1, 1997.GM DETERMINED THAT THE WIPERS INSTALLED PRIOR TO THIS DATE COULD STOP WORKING, USUALLY DURING HEAVY LOAD CONDITIONS, DUE TO SEPARATION BETWEEN THE DRIVE PIN AND THE CRESCENT IN THE WIPER CRANK ARM ASSEMBLY.EFFECTIVE MAY 1, 1997,GM CORRECTED THIS PROBLEM IN PRODUCTION BY MODIFYING THE DRIVE PIN AND STRENGTHENING THE CRESCENT.THESE SAME IMPROVED PARTS WILL BE INSTALLED IN THE VEHICLES TO BE RECALLED.THE SCOPE OF THE CAMPAIGN WILL INCLUDE ALL VEHICLES PRODUCED PRIOR TO THE MAY 1, 1997 CORRECTION (THE OLDSMOBILE INTRIQUE PRODUCTION DID NOT START UNTIL AFTER MAY 1, 1997, AND IS THEREFORE NOT INCLUDED).VEHICLES WITH THE SCOPE OF THIS INVESTIGATION AND PRODUCED AFTER MAY 1, 1997, CONTAIN THE MORE ROBUST CRESCENT AND IMPROVED PIN DESIGN AND ARE NOT INCLUDED IN THE RECALL CAMPAIGN.ODI WILL CONTINUE TO MONITOR COMPLAINT REPORTS ON THE VEHICLES PRODUCED AFTER MAY 1, 1997 AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.BASED ON GM'S RECALL ACTION (ODI 99V-348) THIS INVESTIGATION IS CLOSED.
PE99028 · Windshield Wiper
Opened Apr 16, 1999 · Closed Aug 20, 1999
Status: closed (inferred from source dates) · Visibility
INCIDENTS OF WIPER FAILURE (OWNER REPORTS AND WARRANTY) ARE VERY HIGH, AND MANY OF THE REPORTS INDICATE THAT THE FAILURES ARE STILL OCCURRING IN 1999.
Illustration