NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
204 reports90,000 miles · May 24, 2009
Engine And Engine CoolingFuel System, Gasoline
VEHICLE BACK FIRE THROUGH THE INTAKE AND SMOKE ROLLS OUT FROM UNDER THE HOOD WHEN TRYING TO START THE VEHICLE, NORMALLY START GOOD AFTER SITTING OVER NIGHT, BUT GO TO START IT AGAIN IT WILL BACK FIRE OR THE ENGINE IDLE IS VERY ERRATIC BEFORE IT WILL SMOOTH OUT. I REPLACE SPARK PLUG, SPARK PLUG WIRES, CAM SENSOR, PCV VALVE, FUEL …
Read full complaint
VEHICLE BACK FIRE THROUGH THE INTAKE AND SMOKE ROLLS OUT FROM UNDER THE HOOD WHEN TRYING TO START THE VEHICLE, NORMALLY START GOOD AFTER SITTING OVER NIGHT, BUT GO TO START IT AGAIN IT WILL BACK FIRE OR THE ENGINE IDLE IS VERY ERRATIC BEFORE IT WILL SMOOTH OUT. I REPLACE SPARK PLUG, SPARK PLUG WIRES, CAM SENSOR, PCV VALVE, FUEL FILTER CHECK BATTERY CONNECTION. *TR
NHTSA ODI #10269816
78,117 miles · Dec 26, 2008
Engine And Engine CoolingFuel System, Gasoline
TL*THE CONTACT OWNS A 1996 BUICK REGAL. THE CONTACT NOTICED THAT THE VEHICLE SPORADICALLY EXPERIENCED A NO-START CONDITION. THERE WAS ALSO A BACKFIRE THAT OCCURRED WHEN THE VEHICLE WAS STARTED. THE UPPER INTAKE MANIFOLD FAILED PRIOR TO THE UPPER INTAKE MANIFOLD. THE DEALER STATED THAT HIS VIN WAS EXCLUDED FROM NHTSA CAMPAIGN…
Read full complaint
TL*THE CONTACT OWNS A 1996 BUICK REGAL. THE CONTACT NOTICED THAT THE VEHICLE SPORADICALLY EXPERIENCED A NO-START CONDITION. THERE WAS ALSO A BACKFIRE THAT OCCURRED WHEN THE VEHICLE WAS STARTED. THE UPPER INTAKE MANIFOLD FAILED PRIOR TO THE UPPER INTAKE MANIFOLD. THE DEALER STATED THAT HIS VIN WAS EXCLUDED FROM NHTSA CAMPAIGN ID NUMBER 96V116000 (FUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM). THE CONTACT WOULD NOT ASSUME RESPONSIBILITY FOR THE REPAIR. THE VEHICLE HAS NOT BEEN REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 78,117. UPDATED 02/05/09. *LJ COOLANT WAS FOUND IN THE OIL WHEN REPAIRS WERE MADE ON THE MANIFOLD. UPDATED 02/10/09. *JB
NHTSA ODI #10252849
157,000 miles · Dec 19, 2008
Air Bags
TL*THE CONTACT OWNS A 1996 BUICK REGAL. AFTER INSERTING THE KEY INTO THE IGNITION, THE DRIVER'S SIDE FRONTAL AIR BAG SPONTANEOUSLY DEPLOYED WITHOUT AN IMPACT OR CRASH. HE IS IN THE PROCESS OF NOTIFYING THE DEALER TO DETERMINE THE CAUSE OF THE FAILURE. THE FAILURE AND CURRENT MILEAGES WERE 157,000.
NHTSA ODI #10252282
30,000 miles · Jul 23, 2008
Structure
I PURCHASED MY CAR IN 1998 AND SOON AFTER THAT THE PAINT STARTED TO PEEL. IN ABOUT 2000 I FINALLY RESEARCHED IT ONLINE AND FOUND OUT TO LOOK AT MY VIN NUMBER, AND IF THE 11TH NUMBER WAS A '1' THAT IT WAS PAINTED IN CANADA AND THAT THEY TROUBLE WITH BAD PRIMER UP THERE. A LOT OF PEOPLE HAD SUED FOR A NEW PAINT JOB. GM CLOSED THAT…
Read full complaint
I PURCHASED MY CAR IN 1998 AND SOON AFTER THAT THE PAINT STARTED TO PEEL. IN ABOUT 2000 I FINALLY RESEARCHED IT ONLINE AND FOUND OUT TO LOOK AT MY VIN NUMBER, AND IF THE 11TH NUMBER WAS A '1' THAT IT WAS PAINTED IN CANADA AND THAT THEY TROUBLE WITH BAD PRIMER UP THERE. A LOT OF PEOPLE HAD SUED FOR A NEW PAINT JOB. GM CLOSED THAT PLANT DOWN. I WENT TO MAACO HERE AND WAS TOLD THAT SINCE THE PRIMER WAS BAD, THEY WOULD HAVE TO STRIP THAT ALL OFF TOO, AND THE WHOLE JOB WAS MORE THAN I COULD AFFORD. ALSO, EVER SINCE I'VE HAD THE CAR, THE BRAKES HAVE MADE A HORRIBLE NOISE ON STOPPING, MAINLY IN WARM WEATHER. ALL MECHANICS THINK IT IS VERY ODD AND HAVE TRIED TO FIX IT SEVERAL TIMES. TWO MECHANICS HAVE ACTUALLY STOPPED THE NOISE BUT IT RETURNS PROMPTLY. IT DOESN'T SEEM TO IMPAIR THE BRAKING ABILITY. IT'S A GOOD OLD CAR AND NOW HAS 93,000 MILES WITHOUT OTHER COMPLAINTS, BUT IS EMBARRASSING TO DRIVE WITH 1/2 OF ITS PAINT MISSING. IT LOOKS LIKE A COW. *TR
NHTSA ODI #10235436
176,000 miles · Jul 3, 2008
Steering
THERE IS A SEVERE PROBLEM WITH THE STEERING. WE BROUGHT THE VEHICLE TO A GARAGE AND WE WERE TOLD THAT THERE IS A RECALL ON THE VEHICLE TO CORRECT THE RACK AND PINION STEERING. WE CALLED BUICK AND WERE TOLD THAT THE RECALL IS VIN SPECIFIC AND THAT OUR VIN WAS NOT RECALLED. WE WERE ADVISED BY BUICK THAT IT WAS JUST A COINCIDEN…
Read full complaint
THERE IS A SEVERE PROBLEM WITH THE STEERING. WE BROUGHT THE VEHICLE TO A GARAGE AND WE WERE TOLD THAT THERE IS A RECALL ON THE VEHICLE TO CORRECT THE RACK AND PINION STEERING. WE CALLED BUICK AND WERE TOLD THAT THE RECALL IS VIN SPECIFIC AND THAT OUR VIN WAS NOT RECALLED. WE WERE ADVISED BY BUICK THAT IT WAS JUST A COINCIDENCE THAT OUR VEHICLE WAS THE SAME YEAR, MAKE AND MODEL AS THE RECALL AND HAD THE SAME PROBLEM AND THAT WE WOULD HAVE TO PAY ONE OF THEIR DEALERS TO LOOK AT IT. *TR
NHTSA ODI #10233151
150,000 miles · Jul 11, 2007
WheelsCrashInjury
MY DAUGHTER WAS DRIVING THE 1996 BUCK REGAL ON I-77 NORTH NEAR CHELYAN, WV ANOTHER DAUGHTER WAS IN THE PASSENGER SEAT. THE REAR DRIVER'S SIDE WHEEL BROKE FROM THE HUB, CAUSING THE CAR TO VEER AND EVENTUALLY HIT THE CONCRETE MEDIAN. THE CRASH SEVERELY DAMAGED THE FRONT LEFT SIDE OF THE CAR; IT WA STOTALLED. THE CRASH RESULTE…
Read full complaint
MY DAUGHTER WAS DRIVING THE 1996 BUCK REGAL ON I-77 NORTH NEAR CHELYAN, WV ANOTHER DAUGHTER WAS IN THE PASSENGER SEAT. THE REAR DRIVER'S SIDE WHEEL BROKE FROM THE HUB, CAUSING THE CAR TO VEER AND EVENTUALLY HIT THE CONCRETE MEDIAN. THE CRASH SEVERELY DAMAGED THE FRONT LEFT SIDE OF THE CAR; IT WA STOTALLED. THE CRASH RESULTED IN INJURIES TO BOTH OF MY DAUGHTERS - THE DRIVER SUSTAINE D A BUMP ON HER FOREHEAD, AND THE PASSENGER HASD A SWOLEN LEFT ANKLE - PRELIMINARY REVIEW OF THE X-RAYS WERE NEGATIVE FOR A BREAK/FRACTURE. THE CAR WAS TOWED TO A GARAGE. *AK
NHTSA ODI #10196049
85,000 miles · Jun 5, 2007
Steering
TL*THE CONTACT OWNS 1996 BUICK REGAL. THE CONTACT STATED THAT THE CHECK ENGINE LIGHT ILLUMINATED DURING AN OIL CHANGE. AFTER THE OIL CHANGE, THE ENGINE LIGHT ILLUMINATED AGAIN AND THE CONTACT HAD THE BATTERY CHANGED. SHE DROVE APPROXIMATELY ONE AND A HALF MILES, MADE A RIGHT TURN, AND ATTEMPTED TO MAKE A LEFT TURN WHEN THE ST…
Read full complaint
TL*THE CONTACT OWNS 1996 BUICK REGAL. THE CONTACT STATED THAT THE CHECK ENGINE LIGHT ILLUMINATED DURING AN OIL CHANGE. AFTER THE OIL CHANGE, THE ENGINE LIGHT ILLUMINATED AGAIN AND THE CONTACT HAD THE BATTERY CHANGED. SHE DROVE APPROXIMATELY ONE AND A HALF MILES, MADE A RIGHT TURN, AND ATTEMPTED TO MAKE A LEFT TURN WHEN THE STEERING WHEEL LOCKED. THE FAILURE OCCURRED WHILE DRIVING 10 MPH. THE CONTACT HAD TO SHIFT THE VEHICLE IN REVERSE IN ORDER TO MOVE THE WHEEL. THE CONTACT REFERENCED NHTSA RECALL # 03V527000 (STEERING:RACK AND PINION). THE CURRENT MILEAGE IS 86,000 AND FAILURE MILEAGE WAS 85,000.
NHTSA ODI #10192498
186,000 miles · May 23, 2007
Engine And Engine CoolingFire
TL*THE CONTACT OWNS A 1996 BUICK REGAL. THE CONTACT'S VEHICLE CAUGHT FIRE AFTER BEING PARKED FOR APPROXIMATELY FIFTEEN MINUTES. THE CURRENT AND FAILURE MILEAGES WERE 186,000. UPDATED 02-01-08. *KB UPDATED 02/19/10. *LJ UPDATED 09/2810*JB
NHTSA ODI #10191601
87,000 miles · Dec 16, 2006
Engine And Engine Cooling
I BOUGHT A USED CAR IN BOARDMAN, OHIO AREA AND I NOW HAVE A 1490.00 REPAIR BILL AFTER SALESMAN TOLD ME IT WAS CHECKED OUT. THEY REPLACED A BURNED OUT BULB WITH ANOTHER BURNED OUT BULB WHICH I CAN PROVE. I NEED HELP TO STOP THIS PRACTICE. *JB
NHTSA ODI #10176299
78,000 miles · Dec 12, 2006
Steering
WHILE MAKING A TURN, THE STEERING IN MY 1996 BUICK REGAL BECAME VERY STIFF AND WOULD NOT RETURN TO NEUTRAL. IT HAS ONLY BEEN TWO DAYS NOW THAT THIS HAS HAPPENED, BUT IT'S DANGEROUS, AS IT GIVES NO WARNING. THE TURN ALMOST PUT ME INTO A TREE! IT HAPPENED TODAY BUT I WAS MORE AWARE THAT IT MIGHT HAPPEN AND ALERT FOR IT. MY 1995 CE…
Read full complaint
WHILE MAKING A TURN, THE STEERING IN MY 1996 BUICK REGAL BECAME VERY STIFF AND WOULD NOT RETURN TO NEUTRAL. IT HAS ONLY BEEN TWO DAYS NOW THAT THIS HAS HAPPENED, BUT IT'S DANGEROUS, AS IT GIVES NO WARNING. THE TURN ALMOST PUT ME INTO A TREE! IT HAPPENED TODAY BUT I WAS MORE AWARE THAT IT MIGHT HAPPEN AND ALERT FOR IT. MY 1995 CENTURY HAD THE SAME PROBLEM AND IT WAS THAT THE STEERING RACK GETS TIGHT IN COLDER WEATHER AND AFTER 75000 MILES! *NM
NHTSA ODI #10176002
NHTSA investigations
6EA03019 · Power Rack And Pinion Steering Failure
Opened Sep 15, 2003 · Closed Dec 18, 2003
Status: closed (inferred from source dates) · Steering; Steering:rack And Pinion
GM'S LETTER TO NHTSA DATED DECEMBER 11, 2003, EXPANDS ITS ORIGINAL RECALL (NHTSA 02V286) TO INCLUDE CERTAIN W-BODY VEHICLES: 96-97 OLDS CUTLASS SUPREME; 98 OLDS INTRIGUE; 97-98 OLDS CUTLASS; 97-98 CHEVY LUMINA, MONTE CARLO AND MALIBU; 96 PONTIAC GRAND PRIX; AND 96-98 BUICK REGAL.THE NUMBER OF VEHICLES RECALLED IS 750,283.GM DETERMINED THAT FAILURE OF THE RACK AND PINION IS RELATED TO DAMAGE OF THE LOWER PINION BEARING AND THE LEVEL OF THE PINION BEARING PRE-LOAD SPRING FORCE.GM STATES, HIGHER RACK PRE-LOAD SPRING FORCE (133 LB.) IS THE DESIGN CHARACTERISTIC MOST CLOSELY ASSOCIATED WITH HIGHER BEARING DAMAGE RATES IN MOST OF THE VEHICLE APPLICATIONS THAT USED THE GENERAL BEARING COMPANY (GBC) BEARING.ALL OF THE VEHICLES COVERED IN THE EXPANDED RECALL HAVE THE 133 LB SPRING FORCE.THE 96 LUMINA/MONTE CARLO AND 97-98 CENTURY W-BODY VEHICLES INCLUDED IN THIS INVESTIGATION UTILIZE A LOWER SPRING FORCE AND ARE NOT INCLUDED IN THE RECALL.
Additional source detail variants (2)
Steering
GM'S LETTER TO NHTSA DATED DECEMBER 11, 2003, EXPANDS ITS ORIGINAL RECALL (NHTSA 02V286) TO INCLUDE CERTAIN W-BODY VEHICLES: 96-97 OLDS CUTLASS SUPREME; 98 OLDS INTRIGUE; 97-98 OLDS CUTLASS; 97-98 CHEVY LUMINA, MONTE CARLO AND MALIBU; 96 PONTIAC GRAND PRIX; AND 96-98 BUICK REGAL.THE NUMBER OF VEHICLES RECALLED IS 750,283.GM DETERMINED THAT FAILURE OF THE RACK AND PINION IS RELATED TO DAMAGE OF THE LOWER PINION BEARING AND THE LEVEL OF THE PINION BEARING PRE-LOAD SPRING FORCE.GM STATES, HIGHER RACK PRE-LOAD SPRING FORCE (133 LB.) IS THE DESIGN CHARACTERISTIC MOST CLOSELY ASSOCIATED WITH HIGHER BEARING DAMAGE RATES IN MOST OF THE VEHICLE APPLICATIONS THAT USED THE GENERAL BEARING COMPANY (GBC) BEARING.ALL OF THE VEHICLES COVERED IN THE EXPANDED RECALL HAVE THE 133 LB SPRING FORCE.THE 96 LUMINA/MONTE CARLO AND 97-98 CENTURY W-BODY VEHICLES INCLUDED IN THIS INVESTIGATION UTILIZE A LOWER SPRING FORCE AND ARE NOT INCLUDED IN THE RECALL.
Steering:rack And Pinion
GM'S LETTER TO NHTSA DATED DECEMBER 11, 2003, EXPANDS ITS ORIGINAL RECALL (NHTSA 02V286) TO INCLUDE CERTAIN W-BODY VEHICLES: 96-97 OLDS CUTLASS SUPREME; 98 OLDS INTRIGUE; 97-98 OLDS CUTLASS; 97-98 CHEVY LUMINA, MONTE CARLO AND MALIBU; 96 PONTIAC GRAND PRIX; AND 96-98 BUICK REGAL.THE NUMBER OF VEHICLES RECALLED IS 750,283.GM DETERMINED THAT FAILURE OF THE RACK AND PINION IS RELATED TO DAMAGE OF THE LOWER PINION BEARING AND THE LEVEL OF THE PINION BEARING PRE-LOAD SPRING FORCE.GM STATES, HIGHER RACK PRE-LOAD SPRING FORCE (133 LB.) IS THE DESIGN CHARACTERISTIC MOST CLOSELY ASSOCIATED WITH HIGHER BEARING DAMAGE RATES IN MOST OF THE VEHICLE APPLICATIONS THAT USED THE GENERAL BEARING COMPANY (GBC) BEARING.ALL OF THE VEHICLES COVERED IN THE EXPANDED RECALL HAVE THE 133 LB SPRING FORCE.THE 96 LUMINA/MONTE CARLO AND 97-98 CENTURY W-BODY VEHICLES INCLUDED IN THIS INVESTIGATION UTILIZE A LOWER SPRING FORCE AND ARE NOT INCLUDED IN THE RECALL.
RQ03001 · Power Rack And Pinion Steering Failure
Opened Jan 2, 2003 · Closed Sep 15, 2003
Status: closed (inferred from source dates) · Steering; Steering:rack And Pinion
GM CONDUCTED A SAFETY RECALL (NHTSA # 02V286) TO ADDRESS A STEERING DEFECT PERTAINING TO A LOWER PINION BEARING (LPB) WITHIN THE RACK AND PINION STEERING GEAR (R&P). THE RECALL COVERED 1,159,156 MODEL YEAR 1997-1998 PONTIAC GRAND PRIX VEHICLES BUILT BETWEEN MARCH 1, 1996 AND OCTOBER 31, 1997, 1996-1998 PONTIAC TRANS SPORT, CHEVROLET LUMINA APV, CHEVROLET VENTURE, OLDSMOBILE SILHOUETTE MINIVANS, AND CHEVROLET CAVALIER AND PONTIAC SUNFIRE SEDANS BUILT BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997.ODI OPENED THIS RQ AFTER RECEIVING REPORTS THAT OTHER VEHICLES WERE EXHIBITING THE SAME SYMPTOMS AS THE RECALLED VEHICLES.BASED ON ODI'S REVIEW OF TECHNICAL AND COMPLAINT DATA COLLECTED DURING THE RQ, THE W-CARS ARE ASSOCIATED WITH EITHER A HIGHER STEERING COMPLAINT RATE OR A HIGHER LPB FAILURE RATE THAN THE OTHER VEHICLES INVESTIGATED UNDER THE RQ AND ARE ABOVE OR NEAR THE RATES FOR THE RECALLED VEHICLES.THUS, ODI WILL FURTHER EXAMINE THE W-CARS (1996-1997 OLDSMOBILE CUTLASS SUPREME, 1996-1998 BUICK REGAL, CHEVROLET LUMINA, CHEVROLET MONTE CARLO, 1997-1998 BUICK CENTURY, AND 1998 OLDSMOBILE INTRIGUE) UNDER A NEW INVESTIGATION, ENGINEERING ANALYSIS (EA)03-019.
Additional source detail variants (2)
Steering
GM CONDUCTED A SAFETY RECALL (NHTSA # 02V286) TO ADDRESS A STEERING DEFECT PERTAINING TO A LOWER PINION BEARING (LPB) WITHIN THE RACK AND PINION STEERING GEAR (R&P). THE RECALL COVERED 1,159,156 MODEL YEAR 1997-1998 PONTIAC GRAND PRIX VEHICLES BUILT BETWEEN MARCH 1, 1996 AND OCTOBER 31, 1997, 1996-1998 PONTIAC TRANS SPORT, CHEVROLET LUMINA APV, CHEVROLET VENTURE, OLDSMOBILE SILHOUETTE MINIVANS, AND CHEVROLET CAVALIER AND PONTIAC SUNFIRE SEDANS BUILT BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997.ODI OPENED THIS RQ AFTER RECEIVING REPORTS THAT OTHER VEHICLES WERE EXHIBITING THE SAME SYMPTOMS AS THE RECALLED VEHICLES.BASED ON ODI'S REVIEW OF TECHNICAL AND COMPLAINT DATA COLLECTED DURING THE RQ, THE W-CARS ARE ASSOCIATED WITH EITHER A HIGHER STEERING COMPLAINT RATE OR A HIGHER LPB FAILURE RATE THAN THE OTHER VEHICLES INVESTIGATED UNDER THE RQ AND ARE ABOVE OR NEAR THE RATES FOR THE RECALLED VEHICLES.THUS, ODI WILL FURTHER EXAMINE THE W-CARS (1996-1997 OLDSMOBILE CUTLASS SUPREME, 1996-1998 BUICK REGAL, CHEVROLET LUMINA, CHEVROLET MONTE CARLO, 1997-1998 BUICK CENTURY, AND 1998 OLDSMOBILE INTRIGUE) UNDER A NEW INVESTIGATION, ENGINEERING ANALYSIS (EA)03-019.
Steering:rack And Pinion
GM CONDUCTED A SAFETY RECALL (NHTSA # 02V286) TO ADDRESS A STEERING DEFECT PERTAINING TO A LOWER PINION BEARING (LPB) WITHIN THE RACK AND PINION STEERING GEAR (R&P). THE RECALL COVERED 1,159,156 MODEL YEAR 1997-1998 PONTIAC GRAND PRIX VEHICLES BUILT BETWEEN MARCH 1, 1996 AND OCTOBER 31, 1997, 1996-1998 PONTIAC TRANS SPORT, CHEVROLET LUMINA APV, CHEVROLET VENTURE, OLDSMOBILE SILHOUETTE MINIVANS, AND CHEVROLET CAVALIER AND PONTIAC SUNFIRE SEDANS BUILT BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997.ODI OPENED THIS RQ AFTER RECEIVING REPORTS THAT OTHER VEHICLES WERE EXHIBITING THE SAME SYMPTOMS AS THE RECALLED VEHICLES.BASED ON ODI'S REVIEW OF TECHNICAL AND COMPLAINT DATA COLLECTED DURING THE RQ, THE W-CARS ARE ASSOCIATED WITH EITHER A HIGHER STEERING COMPLAINT RATE OR A HIGHER LPB FAILURE RATE THAN THE OTHER VEHICLES INVESTIGATED UNDER THE RQ AND ARE ABOVE OR NEAR THE RATES FOR THE RECALLED VEHICLES.THUS, ODI WILL FURTHER EXAMINE THE W-CARS (1996-1997 OLDSMOBILE CUTLASS SUPREME, 1996-1998 BUICK REGAL, CHEVROLET LUMINA, CHEVROLET MONTE CARLO, 1997-1998 BUICK CENTURY, AND 1998 OLDSMOBILE INTRIGUE) UNDER A NEW INVESTIGATION, ENGINEERING ANALYSIS (EA)03-019.
EA02030 · Engine Compartment Fires
Opened Oct 22, 2002 · Closed Mar 9, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:delivery; Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (3)
Fuel System, Gasoline:delivery
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
PE02050 · Engine Compartment Fires
Opened Jun 13, 2002 · Closed Oct 22, 2002
Status: closed (inferred from source dates) · Engine And Engine Cooling
No summary supplied.
EA99026 · Inadvertent Air Bag Deployment
Opened Aug 31, 1999 · Closed Dec 28, 2001
Status: closed (inferred from source dates) · Air Bags
There is no summary currently available
EA96023 · Inappropriate Air Bag Deployment
Opened Sep 27, 1996 · Closed Feb 13, 1998
Status: closed (inferred from source dates) · Air Bags
THE FAILURE RATE (1.25/100K) ON THIS ISSUE IS LOW.A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF THE AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITURE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.ODI WILL CONTINUE TO CLOSELY MONITOR THIS ISSUE.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.AN ENGINEERING ANALYSIS CLOSING REPORT IS INCLUDED IN THE PUBLIC FILE.
Illustration