← New search

2006 Buick Rainier

Owner reports · Recalls · Investigations

Similar to other model years

Owner complaints for the 2006 Buick Rainier do not stand out strongly from the model-year median of 91.

About this comparison →

When problems were reported

Mileage at the reported incident

72 reports with mileage · 19 unknown

NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.

What to inspect

Issues worth paying extra attention to based on owner reports.

  • Fuel System, Gasoline. Review the 25 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Electrical System. Review the 17 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Exterior Lighting. Review the 12 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

1 crash reports5 fire reports0 injury reports

What owners actually said

91 reports
106,000 miles · Apr 22, 2015
Electrical SystemFire

THE AIR CONDITIONING AND HEATING CONTROLS HAD NOT BEEN WORKING AND /OR WORKING ERRATICALLY. WE TOOK THE VEHICLE TO THE LOCAL DEALERSHIP FOR REPAIR. THEY CLAIMED THAT THEY COULDN'T FIND ANY PROBLEM. WE ALSO ASKED THEM TO FIX THE RECALL ITEM, DOOR SWITCH, AND WERE TOLD THERE WAS NO RECALL ON OUR VEHICLE EVENTHOUGH WE HAD RECEIVED …

Read full complaint

THE AIR CONDITIONING AND HEATING CONTROLS HAD NOT BEEN WORKING AND /OR WORKING ERRATICALLY. WE TOOK THE VEHICLE TO THE LOCAL DEALERSHIP FOR REPAIR. THEY CLAIMED THAT THEY COULDN'T FIND ANY PROBLEM. WE ALSO ASKED THEM TO FIX THE RECALL ITEM, DOOR SWITCH, AND WERE TOLD THERE WAS NO RECALL ON OUR VEHICLE EVENTHOUGH WE HAD RECEIVED NOTICE FROM GM BY MAIL. ON MARCH 14, 2015 I WAS DRIVING ON THE INTERSTATE WHEN THE AIR CONDITIONER SUDDENLY STARTED WORKING FULL FORCE. WITHIN 10 MINUTES I SMELLED AN ELECTRIC FIRE AND WHITE SMOKE STARTED COMING INTO THE CAB FROM ABOVE AND BELOW THE DASH. I IMMEDIATELY PULLED OFF THE ROAD AND TRIED TO OPEN THE HOOD. AS THE SMOKE INCREASED I WENT TO THE PASSENGER SIDE TO REMOVE BELONGINGS FROM THE GLOVE COMPARTMENT. BLACK SMOKE WAS COMING FROM THE DASH AND BURNING EMBERS FALLING INTO THE CAB. BY THE TIME THE FIRE DEPARTMENT ARRIVE, THE VEHICLE WAS FULLY ENGULFED IN FLAMES. MY FAMILY AND I WERE NOT HURT, BUT ARE NOW WITHOUT A VEHICLE AND STILL OWE THE FINANCE COMPANY SINCE WE HAD ONLY PURCHASED THE VEHICLE 9 MONTHS AGO. SUBSEQUENT RESEARCH REVEALED THE HEADLIGHTS WE HAD REPLACED TWICE ALSO HAD ELECTRICAL ISSUES, AND THE SUSPENSION NOISE FROM THE REAR OF THE VEHICLE HAD MULTIPLE COMPLAINTS. *TR

NHTSA ODI #10712209

100,000 miles · Feb 26, 2015
Exterior LightingFire

TL* THE CONTACT OWNS A 2006 BUICK RAINIER. WHILE THE VEHICLE WAS PARKED, THE CONTACT NOTICED THAT THE PASSENGER SIDE LOW BEAM HEADLIGHT BLEW OUT. THE CONTACT REPLACED THE BULB; HOWEVER, THE FAILURE RECURRED AND THE HEADLIGHT SOCKET MELTED. THE CONTACT REPAIRED THE VEHICLE. THE FAILURE RECURRED ON THE DRIVER SIDE LOW BEAM HEADLIG…

Read full complaint

TL* THE CONTACT OWNS A 2006 BUICK RAINIER. WHILE THE VEHICLE WAS PARKED, THE CONTACT NOTICED THAT THE PASSENGER SIDE LOW BEAM HEADLIGHT BLEW OUT. THE CONTACT REPLACED THE BULB; HOWEVER, THE FAILURE RECURRED AND THE HEADLIGHT SOCKET MELTED. THE CONTACT REPAIRED THE VEHICLE. THE FAILURE RECURRED ON THE DRIVER SIDE LOW BEAM HEADLIGHT. THE CONTACT STATED THAT THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 14V755000 (EXTERIOR LIGHTING). THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 100,000.

NHTSA ODI #10690893

69,000 miles · Feb 21, 2015
Suspension

MY RAINER STARTED TO LOOSE AIR IN THE REAR SUSPENSION, AIR RIDE SYSTEM. AT THIS TIME THE COMPRESSOR WORKS AND DOES FILL THE AIR RIDE SUSPENSION BUT YOU CAN'T BE IN A HURRY TO GO ANYWHERE. YOU MUST LET THE CAR SIT WHILE RUNNING FOR SEVERAL MINUTES BEFORE YOU CAN LEAVE. IF YOU DON'T, YOU BOUNCE DOWN THE ROAD AND THAT COULD BE A…

Read full complaint

MY RAINER STARTED TO LOOSE AIR IN THE REAR SUSPENSION, AIR RIDE SYSTEM. AT THIS TIME THE COMPRESSOR WORKS AND DOES FILL THE AIR RIDE SUSPENSION BUT YOU CAN'T BE IN A HURRY TO GO ANYWHERE. YOU MUST LET THE CAR SIT WHILE RUNNING FOR SEVERAL MINUTES BEFORE YOU CAN LEAVE. IF YOU DON'T, YOU BOUNCE DOWN THE ROAD AND THAT COULD BE A DANGER TO YOU OR SOMEONE ELSE ON THE ROAD, I HAVE SPOKEN TO MY LOCAL DEALER ABOUT THE ISSUE AND THEY WOULD BE MORE THAN HAPPY TO CHARGE ME THOUSANDS OF DOLLARS TO FIX THE ISSUE. I THINK THIS IS SOMETHING THAT GM SHOULD TAKE CARE OF UNDER A SAFETY RECALL SINCE IT SEEMS TO BE A DESIGN FLAW. MY CAR ONLY HAS 70,500 MILES ON IT. *TR

NHTSA ODI #10689744

46,000 miles · Feb 9, 2015
Suspension

WHILE THE VEHICLE WAS PARKED IN OUR DRIVEWAY THE AIR SUSPENSION FAILED CAUSING THE REAR OF VEHICLE TO DROP TO AND UNSAFE LEVEL. UPON STARTING THE VEHICLE THE COMPRESSOR REFILLED THE SUSPENSION BAGS BUT WHEN PARKED AND NOT DRIVEN FOR ANY PERIOD OF TIME THE AIR BAGS LEAK DOWN CAUSING THE REAR SUSPENSION TO DROP DOWN AGAIN. THIS HA…

Read full complaint

WHILE THE VEHICLE WAS PARKED IN OUR DRIVEWAY THE AIR SUSPENSION FAILED CAUSING THE REAR OF VEHICLE TO DROP TO AND UNSAFE LEVEL. UPON STARTING THE VEHICLE THE COMPRESSOR REFILLED THE SUSPENSION BAGS BUT WHEN PARKED AND NOT DRIVEN FOR ANY PERIOD OF TIME THE AIR BAGS LEAK DOWN CAUSING THE REAR SUSPENSION TO DROP DOWN AGAIN. THIS HAS BEEN HAPPENING FOR SEVERAL MONTHS NOW AND I UNDERSTAND THAT THIS IS NOT AND UNCOMMON PROBLEM WITH THIS MAKE AND MODEL VEHICLE. THE VEHICLE NOW HAS ONLY 50,000 ACTUAL MILES AND HAS NEVER BEEN USED FOR TOWING. *TR

NHTSA ODI #10682182

122,499 miles · Oct 3, 2014
Electronic Stability Control (esc)Power TrainCrash

I HAD INVOLVED CAR ACCIDENT WHICH FROM THEY CALLED THROTTLEBODY DUE TO (TPS...SHIFT BY WIRE) YOU CAN FIND IN ASK.COM ENCYCLOPEDIA *(SEE BOTTOM) THAT I EXPERIENCED WHICH I HAD. IT WAS RUNNING IN REVERSE AND HIT STEEL POST THAT PROTECT GAS METER WHILE I TRIED BRAKE BUT ENGINE AND TRANNY WAS IN FULL IDLE AND I TRIED CHANGE TO IN…

Read full complaint

I HAD INVOLVED CAR ACCIDENT WHICH FROM THEY CALLED THROTTLEBODY DUE TO (TPS...SHIFT BY WIRE) YOU CAN FIND IN ASK.COM ENCYCLOPEDIA *(SEE BOTTOM) THAT I EXPERIENCED WHICH I HAD. IT WAS RUNNING IN REVERSE AND HIT STEEL POST THAT PROTECT GAS METER WHILE I TRIED BRAKE BUT ENGINE AND TRANNY WAS IN FULL IDLE AND I TRIED CHANGE TO INTO DRIVE WHILE IT STILL IN FULL IDLE AND MY BRAKE CANT STOP UNTIL I HIT EMERGENCY BRAKE AND TURN ENGINE OFF BY KEY SWITCH. I DID SOME RESEARCH AND FOUND I'M NOT ALONE AND MY INSURANCE (NATIONAL GENERAL WHICH USED BE GMAC) PUSHED MY CAR INTO TOTALED THAT THEY USED BY NEVADA LAW AND BODY SHOP TRYING TO SEND THIS CAR TO DEALER FOR TESTING BUT NEVER HAPPEN CUZ OF TOTALED PROCESSING. WHICH LEAVE ME PUZZLED AND FOUND OUT THAT MY CAR SOLD TO BODY SHOP AND REPAIRED AND SOLD OTHER PEOPLE. MY WORRY IS IF THEY NOT TESTING THROTTLE AND OTHER PEOPLE WHO BOUGHT THIS CAR MAY FACE RISK WHICH I HAD. *DISADVANTAGES THE COST OF DBW SYSTEMS IS OFTEN GREATER THAN CONVENTIONAL SYSTEMS.THAT FALL UNDER THE CATEGORY OF SAFETY CRITICAL SYSTEMSWHICH ARE RECOMMENDED TO BE DEVELOPED UNDER STANDARDS LIKE ISO 26262 WHICH REQUIRE EXTENSIVE CHANGES IN THE DEVELOPMENT PROCESS GENERALLY TAKEN FOR DEVELOPING OTHER TRADITIONAL SYSTEMS.. *TR

NHTSA ODI #10641283

100,000 miles · Aug 28, 2014
Electrical SystemElectronic Stability Control (esc)Engine

BUICK RAINIER 2006, [XXX], I HAVE HAD TROUBLE WITH MY SUV TURNING OFF WHILE DRIVING MANY TIMES. ALSO, IT WILL NOT START AFTER SEVERAL ATTEMPTS UNTIL IT JUST WANTS TO. NOW, IT HAS COMPLETELY STOPPED STARTING AND IS SITTING IN A PARKING LOT AFTER TRYING TO START OVER 5 HOURS, I AM SO UPSET AND STRANDED. MY VIN DOES NOT APPEAR ON R…

Read full complaint

BUICK RAINIER 2006, [XXX], I HAVE HAD TROUBLE WITH MY SUV TURNING OFF WHILE DRIVING MANY TIMES. ALSO, IT WILL NOT START AFTER SEVERAL ATTEMPTS UNTIL IT JUST WANTS TO. NOW, IT HAS COMPLETELY STOPPED STARTING AND IS SITTING IN A PARKING LOT AFTER TRYING TO START OVER 5 HOURS, I AM SO UPSET AND STRANDED. MY VIN DOES NOT APPEAR ON RECALL LIST FOR SWITCH, BUT THAT IS THE TROUBLE I AM HAVING. WHAT DO I DO NOW? INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

NHTSA ODI #10629253

112,000 miles · Aug 22, 2014
Electrical SystemEngine

TL* THE CONTACT OWNS A 2006 BUICK RAINIER. THE CONTACT STATED THAT UPON STARTING THE VEHICLE, THE ENGINE STALLED AND THE PASSENGER SIDE AIR BAG WARNING LIGHT ILLUMINATED INTERMITTENTLY. THE VEHICLE RESTARTED AFTER MULTIPLE ATTEMPTS. HOWEVER, THE FAILURE RECURRED MULTIPLE TIMES. ALSO, THE CONTACT HAD STATED THAT THERE WAS A BU…

Read full complaint

TL* THE CONTACT OWNS A 2006 BUICK RAINIER. THE CONTACT STATED THAT UPON STARTING THE VEHICLE, THE ENGINE STALLED AND THE PASSENGER SIDE AIR BAG WARNING LIGHT ILLUMINATED INTERMITTENTLY. THE VEHICLE RESTARTED AFTER MULTIPLE ATTEMPTS. HOWEVER, THE FAILURE RECURRED MULTIPLE TIMES. ALSO, THE CONTACT HAD STATED THAT THERE WAS A BURNING ODOR PRESENT. THE VEHICLE WAS TAKEN TO THE DEALER FOR A DIAGNOSIS. THE TECHNICIAN STATED THAT THE IGNITION SWITCH, VARIOUS WIRES, AND THROTTLE BODY NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. HOWEVER, THE VIN WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 12V406000 (ELECTRICAL SYSTEM, VISIBILITY). THE APPROXIMATE FAILURE MILEAGE WAS 112,000.

NHTSA ODI #10627550

84,500 miles · Jun 13, 2014
Fuel/propulsion System

THE FUEL SENSOR FOR MY 2006 BUICK RAINIER STARTED TO MALFUNCTION APPROXIMATELY TWO YEARS AGO. I HAD IT DIAGNOSED BY GM DEALER, KING CHEVROLET BUICK GMC OF LONGMONT, COLORADO AND THEY INFORMED ME THE CAR NEEDED A NEW FUEL SENSOR. THE FUEL GAUGE INDICATES THE TANK IS EMPTY, WHEN ACTUALLY FULL. WE DECIDED NOT TO CORRECT THE PROBLEM…

Read full complaint

THE FUEL SENSOR FOR MY 2006 BUICK RAINIER STARTED TO MALFUNCTION APPROXIMATELY TWO YEARS AGO. I HAD IT DIAGNOSED BY GM DEALER, KING CHEVROLET BUICK GMC OF LONGMONT, COLORADO AND THEY INFORMED ME THE CAR NEEDED A NEW FUEL SENSOR. THE FUEL GAUGE INDICATES THE TANK IS EMPTY, WHEN ACTUALLY FULL. WE DECIDED NOT TO CORRECT THE PROBLEM, DUE TO THE COST. THE BUICK RAN OUT OF GAS NUMEROUS TIMES THROUGHOUT THE LAST 2 YEARS. THREE DAYS AGO THE CAR STALLED ON INTERSTATE 25 WITH PASSENGERS ON BOARD. WE TOWED IT BACK TO KING CHEVROLET BUICK GMC, LONGMONT, CO. AND NOW DIAGNOSED WITH A FAULTY FUEL PUMP WITH AN ESTIMATED COST OF $1400 TO CORRECT THE FUEL PUMP/SENSOR PROBLEM. EACH TIME THE CAR WAS DIAGNOSED BY THE GM DEALER, NOT A WORD WAS MENTIONED BY STAFF/TECHNICIANS ABOUT THE KNOWN FUEL COMPONENT FAILURE. I DISCOVERED THIS ISSUE AFTER SEARCHING THE INTERNET, YESTERDAY. I FIND IT HARD TO BELIEVE THAT THIS SERIOUS SAFETY HAZARD IS NOT PUBLICLY ACKNOWLEDGED BY GM CORP AND ITS DEALERS AND A RECALL FOR THESE VEHICLES HAS NOT OCCURRED. SEEMS GM CORP AND KING CHEVROLET BUICK GMC HAVE NO CONCERN FOR CONSUMER SAFETY. *JS

NHTSA ODI #10598102

15,000 miles · Jun 4, 2014
Latches/locks/linkagesStructure

TL* THE CONTACT OWNS A 2006 BUICK RAINIER. THE CONTACT STATED THAT THE EXTERIOR DRIVER LATCH BECAME LOOSE AND THE DRIVER'S SIDE DOOR LATCH WOULD NOT OPEN. THE CONTACT TOOK HER VEHICLE TO THE DEALER FOR DIAGNOSTIC TESTING AND THE STATED THE DOOR LATCH WOULD NEED TO BE REPLACED AND REPAINTED. THE VEHICLE WAS REPAIRED. THE FAILURE …

Read full complaint

TL* THE CONTACT OWNS A 2006 BUICK RAINIER. THE CONTACT STATED THAT THE EXTERIOR DRIVER LATCH BECAME LOOSE AND THE DRIVER'S SIDE DOOR LATCH WOULD NOT OPEN. THE CONTACT TOOK HER VEHICLE TO THE DEALER FOR DIAGNOSTIC TESTING AND THE STATED THE DOOR LATCH WOULD NEED TO BE REPLACED AND REPAINTED. THE VEHICLE WAS REPAIRED. THE FAILURE RECURRED TWO ADDITIONAL TIMES. WHENEVER THE FAILURE OCCURRED THE DEALER REPAIRED THE DOOR LATCH HOWEVER, THE FAILURE CONTINUED TO OCCUR. THE IDENTICAL FAILURE OCCURRED WITH THE REAR PASSENGER SIDE EXTERIOR LATCH. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 15,000. UPDATED 9/*CN/ UPDATED 09/10/2014*JS

NHTSA ODI #10596064

Mileage unknown · Apr 13, 2014
Electrical System

DRIVING BACK TO FINDLAY OHIO FROM LIMA OHIO ON INTERSTATE 75 AND THE CAR JUST STOPPED, NOTHING WORKED - NO LIGHTS, NOTHING. IGNITION REPLACED AT A COST OF $300.00. WANTING TO KNOW IF THIS MODEL SHOULD ALSO BE INCLUDED IN THE GM RECALL? *JS

NHTSA ODI #10579459

Official recalls

7

15V599000 · Visibility:power Window Devices And Controls

Sep 24, 2015

General Motors LLC (GM) is recalling certain model year 2006-2007 Buick Rainier, Chevrolet Trailblazer and GMC Envoy vehicles, and 2006 GMC Envoy XL and Chevrolet Trailblazer EXT vehicles. Fluid may enter into the driver's door master power window switch module, causing corrosion that could result in a short in the circuit board, causing window switches to become inoperative. Previously, the affected vehicles may have had their master power window switch module treated with a protective coating, instead of having it replaced.

Consequence & remedy

Consequence: The protective coating may not eliminate the risk that the circuit board could short and result in a fire, even while the vehicle is unattended.

Remedy: GM will notify owners, and dealers will install a new driver's door switch module, free of charge. The recall began on November 2, 2015. Owners may contact Buick customer service at 1-800-521-7300, Chevrolet customer service at 1-800-222-1020, and GMC customer service at 1-800-462-8782. GM's number for this recall is 15700.

15V519000 · Exterior Lighting:headlights

Aug 14, 2015

General Motors LLC (GM) is recalling certain model year 2007 Pontiac Grand Prix, 2006-2009 Buick LaCrosse, 2006-2007 Buick Rainier, Chevrolet Trailblazer, GMC Envoy, 2006 Chevrolet Trailblazer EXT, GMC Envoy XL, 2006-2008 Isuzu Ascender, and Saab 9-7x vehicles. In the affected vehicles, the headlamp driver module (HDM) may overheat and fail, causing the headlamps and daytime running lights to not illuminate.

Consequence & remedy

Consequence: Headlamps that do not illuminate reduce the driver's ability to see the roadway and reduce the vehicle's visibility to oncoming vehicles, both of which increase the risk of a vehicle crash.

Remedy: GM will notify owners, and dealers will replace the HDM, free of charge. The recall began on May 17, 2016. Owners may contact Buick customer service at 1-800-521-7300 or Pontiac customer service at 1-800-762-2737. GM's number for this recall is 14291.

14V404000 · Visibility:power Window Devices And Controls

Jul 2, 2014

General Motors LLC (GM) is recalling certain model year 2005-2007 SAAB 9-7x; 2006 Chevrolet Trailblazer EXT and GMC Envoy XL; and 2006-2007 Chevrolet Trailblazer, GMC Envoy, Buick Rainier and Isuzu Ascender vehicles. Fluid may enter the driver's door master power window switch module, causing corrosion that could result in a short in the circuit board. A short may cause the power door lock and power window switches to function intermittently or become inoperative. The short may also cause overheating, which could melt components of the door module, producing odor, smoke, or a fire.

Consequence & remedy

Consequence: A short in the circuit board could lead to a fire, increasing the risk of personal injury. A fire could occur even while the vehicle is not in use. As a precaution, owners are advised to park outside until the remedy has been made.

Remedy: GM will notify owners, and dealers will inspect the part number on the door module, and install a new door module if necessary, free of charge. Parts for the remedy are not currently available. An interim letter was mailed to owners in August 2014. A second owner letter will be mailed when parts are available. Owners may contact GM customer service at 1-800-521-7300 (Buick), 1-800-222-1020 (Chevrolet), 1-800-462-8782 (GMC), 1-800-955-9007 (SAAB), and 1-800-255-6727 (Isuzu). GM's number for this recall is 14309. NOTE: This recall provides a new remedy for all vehicles covered by recall 13V-248. Vehicles whose modules were modified but not replaced as part of the previous recall remedy must have their vehicles remedied again under this campaign.

13V248000 · Electrical System; Visibility:power Window Devices And Controls

Jun 13, 2013

General Motors (GM) is recalling certain model year 2005-2007 SAAB 9-7x; 2006 Chevrolet Trailblazer EXT and GMC Envoy XL; and 2006-2007 Chevrolet Trailblazer, GMC Envoy, Buick Rainier and Isuzu Ascender vehicles. Fluid may enter the driver's door module, causing corrosion that could result in a short in the circuit board. A short may cause the power door lock and power window switches to function intermittently or become inoperative. The short may also cause overheating, which could melt components of the door module, producing odor, smoke, or a fire.

Consequence & remedy

Consequence: A short in the circuit board could lead to a fire, increasing the risk of personal injury. A fire could occur even while the vehicle is not in use. As a precaution, owners are advised to park outside until the remedy has been made.

Remedy: Owners will be contacted and dealers will test the driver's door module. If the module is functioning properly, a protective coating will be applied. If the module is not functioning properly, it will be replaced. These repairs will be done free of charge. GM will notify Buick, Chevrolet, and GMC owners, Isuzu and Saab will contact their respective owners. The recall began on August 2, 2013. Buick owners may contact the owner center at 1-800-521-7300, Chevrolet owners at 1-866-694-6546, GMC owners at 1-866-996-9463, Isuzu owners at 1-800-255-6727, and Saab owners at 1-800-955-9007. GM's campaign number is 12180. This recall is an expansion of recall 12V-406.

Additional source detail variants (2)

Visibility:power Window Devices And Controls

General Motors (GM) is recalling certain model year 2005-2007 SAAB 9-7x; 2006 Chevrolet Trailblazer EXT and GMC Envoy XL; and 2006-2007 Chevrolet Trailblazer, GMC Envoy, Buick Rainier and Isuzu Ascender vehicles. Fluid may enter the driver's door module, causing corrosion that could result in a short in the circuit board. A short may cause the power door lock and power window switches to function intermittently or become inoperative. The short may also cause overheating, which could melt components of the door module, producing odor, smoke, or a fire.

Consequence: A short in the circuit board could lead to a fire, increasing the risk of personal injury. A fire could occur even while the vehicle is not in use. As a precaution, owners are advised to park outside until the remedy has been made.

Remedy: Owners will be contacted and dealers will test the driver's door module. If the module is functioning properly, a protective coating will be applied. If the module is not functioning properly, it will be replaced. These repairs will be done free of charge. GM will notify Buick, Chevrolet, and GMC owners, Isuzu and Saab will contact their respective owners. The recall began on August 2, 2013. Buick owners may contact the owner center at 1-800-521-7300, Chevrolet owners at 1-866-694-6546, GMC owners at 1-866-996-9463, Isuzu owners at 1-800-255-6727, and Saab owners at 1-800-955-9007. GM's campaign number is 12180. This recall is an expansion of recall 12V-406.

Electrical System

General Motors (GM) is recalling certain model year 2005-2007 SAAB 9-7x; 2006 Chevrolet Trailblazer EXT and GMC Envoy XL; and 2006-2007 Chevrolet Trailblazer, GMC Envoy, Buick Rainier and Isuzu Ascender vehicles. Fluid may enter the driver's door module, causing corrosion that could result in a short in the circuit board. A short may cause the power door lock and power window switches to function intermittently or become inoperative. The short may also cause overheating, which could melt components of the door module, producing odor, smoke, or a fire.

Consequence: A short in the circuit board could lead to a fire, increasing the risk of personal injury. A fire could occur even while the vehicle is not in use. As a precaution, owners are advised to park outside until the remedy has been made.

Remedy: Owners will be contacted and dealers will test the driver's door module. If the module is functioning properly, a protective coating will be applied. If the module is not functioning properly, it will be replaced. These repairs will be done free of charge. GM will notify Buick, Chevrolet, and GMC owners, Isuzu and Saab will contact their respective owners. The recall began on August 2, 2013. Buick owners may contact the owner center at 1-800-521-7300, Chevrolet owners at 1-866-694-6546, GMC owners at 1-866-996-9463, Isuzu owners at 1-800-255-6727, and Saab owners at 1-800-955-9007. GM's campaign number is 12180. This recall is an expansion of recall 12V-406.

12V406000 · Electrical System; Visibility:power Window Devices And Controls

Aug 16, 2012

General Motors (GM) is recalling certain model year 2006 Chevrolet Trailblazer EXT and GMC Envoy XL and 2006-2007 Chevrolet Trailblazer, GMC Envoy, Buick Rainier, SAAB 9-7x, and Isuzu Ascender vehicles, originally sold or currently registered in Connecticut, Delaware, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, Wisconsin, and the District of Columbia. Fluid may enter the driver's door module, causing corrosion that could result in a short in the circuit board. A short may cause the power door lock and power window switches to function intermittently or become inoperative. The short may also cause overheating, which could melt components of the door module, producing odor, smoke, or a fire.

Consequence & remedy

Consequence: A short in the circuit board could lead to a fire, increasing the risk of personal injury. A fire could occur even while the vehicle is not in use. As a precaution, owners are advised to park outside until the remedy has been made.

Remedy: Parts for this recall are expected to available in March 2013. GM will notify Buick, Chevrolet, and GMC owners when parts are available. Buick owners may contact the owner center at 1-800-521-7300, Chevrolet owners at 1-866-694-6546, and GMC owners at 1-866-996-9463. Isuzu owners will be notified by Isuzu Motors when parts are available. Owners may contact Isuzu customer service at 1-800-255-6727. SAAB owners will be notified by SAAB Cars North America when parts are available and for inquiries, owners may call SAAB customer service at 1-800-955-9007.

Additional source detail variants (2)

Visibility:power Window Devices And Controls

General Motors (GM) is recalling certain model year 2006 Chevrolet Trailblazer EXT and GMC Envoy XL and 2006-2007 Chevrolet Trailblazer, GMC Envoy, Buick Rainier, SAAB 9-7x, and Isuzu Ascender vehicles, originally sold or currently registered in Connecticut, Delaware, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, Wisconsin, and the District of Columbia. Fluid may enter the driver's door module, causing corrosion that could result in a short in the circuit board. A short may cause the power door lock and power window switches to function intermittently or become inoperative. The short may also cause overheating, which could melt components of the door module, producing odor, smoke, or a fire.

Consequence: A short in the circuit board could lead to a fire, increasing the risk of personal injury. A fire could occur even while the vehicle is not in use. As a precaution, owners are advised to park outside until the remedy has been made.

Remedy: Parts for this recall are expected to available in March 2013. GM will notify Buick, Chevrolet, and GMC owners when parts are available. Buick owners may contact the owner center at 1-800-521-7300, Chevrolet owners at 1-866-694-6546, and GMC owners at 1-866-996-9463. Isuzu owners will be notified by Isuzu Motors when parts are available. Owners may contact Isuzu customer service at 1-800-255-6727. SAAB owners will be notified by SAAB Cars North America when parts are available and for inquiries, owners may call SAAB customer service at 1-800-955-9007.

Electrical System

General Motors (GM) is recalling certain model year 2006 Chevrolet Trailblazer EXT and GMC Envoy XL and 2006-2007 Chevrolet Trailblazer, GMC Envoy, Buick Rainier, SAAB 9-7x, and Isuzu Ascender vehicles, originally sold or currently registered in Connecticut, Delaware, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, Wisconsin, and the District of Columbia. Fluid may enter the driver's door module, causing corrosion that could result in a short in the circuit board. A short may cause the power door lock and power window switches to function intermittently or become inoperative. The short may also cause overheating, which could melt components of the door module, producing odor, smoke, or a fire.

Consequence: A short in the circuit board could lead to a fire, increasing the risk of personal injury. A fire could occur even while the vehicle is not in use. As a precaution, owners are advised to park outside until the remedy has been made.

Remedy: Parts for this recall are expected to available in March 2013. GM will notify Buick, Chevrolet, and GMC owners when parts are available. Buick owners may contact the owner center at 1-800-521-7300, Chevrolet owners at 1-866-694-6546, and GMC owners at 1-866-996-9463. Isuzu owners will be notified by Isuzu Motors when parts are available. Owners may contact Isuzu customer service at 1-800-255-6727. SAAB owners will be notified by SAAB Cars North America when parts are available and for inquiries, owners may call SAAB customer service at 1-800-955-9007.

05V552000 · Equipment:other:labels

Dec 7, 2005

CERTAIN TRUCKS AND SPORT UTILITY VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SHIPPED WITH TIRE AND LOADING INFORMATION LABELS LISTING AN INACCCURATE VEHICLE CAPACITY WEIGHT.

Consequence & remedy

Consequence: A MISPRINTED LABEL COULD LEAD TO IMPROPER VEHICLE LOADING SPECIFICATIONS OR TIRE INFLATION WHICH COULD RESULT IN A TIRE FAILURE, INCREASING THE RISK OF A CRASH.

Remedy: OWNERS WILL BE PROVIDED WITH CORRECTED LABELS AND INSTALLATION INSTRUCTIONS. AT THE CUSTOMER'S OPTION, A DEALER CAN INSTALL THE LABEL FOR THEM. THE RECALL BEGAN ON MARCH 31, 2006. OWNERS MAY CONTACT BUICK AT 1-866-608-8080, CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, HUMMER AT 1-800-732-5493, PONTIAC AT 1-800-620-7668, SATURN AT 1-800-972-8876, OR ISUZU AT 1-800-255-6727.

05V455000 · Steering:hydraulic Power Assist:hose, Piping, And Connections

Oct 5, 2005

CERTAIN PASSENGER VEHICLES MAY HAVE BEEN BUILT WITH A POWER STEERING HOSE THAT IS NOT TO SPECIFICATION. UNDER EXTREME STEERING MANEUVERS, SUCH AS TURNING THE STEERING WHEEL FULLY TO THE LEFT OR RIGHT WHILE BRAKING, THE HOSE MAY FRACTURE AND LEAK FLUID.

Consequence & remedy

Consequence: IF THIS WERE TO OCCUR, POWER STEERING ASSIST WOULD BE LOST AND INCREASED STEERING EFFORT WOULD BE REQUIRED. ON VEHICLES EQUIPPED WITH HYDRO-BOOST POWER BRAKES, IT COULD ALSO RESULT IN LOSS OF POWER BRAKE ASSIST AND INCREASED BRAKING EFFORT WOULD BE REQUIRED. IF THE POWER STEERING FLUID SPRAY WERE TO SPRAY ONTO HOT ENGINE PARTS, AN ENGINE COMPARTMENT FIRE COULD OCCUR.

Remedy: DEALERS WILL INSPECT THE POWER STEERING HOSE(S) FOR TWO SUSPECT DATE CODES AND REPLACE THEM IF REQUIRED. THE RECALL WILL BEGIN ON OCTOBER 14, 2005. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, BUICK AT 1-866-608-8080, CADILLAC AT 1-866-982-2339, ISUZU AT 1-800-255-6727, OR HUMMER AT 1-800-732-5493.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

4

RQ17002 · Loss Of Headlights

Opened Apr 24, 2017 · Closed Mar 29, 2021

Status: closed (inferred from source dates) · Exterior Lighting:headlights

The subject vehicles are model year (MY) 2002-2009 Chevrolet Trailblazer, GMC Envoy, 2004-2007 Buick Rainier, 2003-2008 Isuzu Ascender, 2005-2009 Saab 9-7X, 2002-2004 Oldsmobile Bravada, 2003-2006 Chevrolet SSR, 2005-2009 Buick Lacrosse, and 2006-2008 Pontiac Grand Prix. This scope includes the Trailblazer/Envoy variants: 2002-2006 Envoy XL/Trailblazer EXT and 2004-2005 Envoy XUV. The original scope of this investigation was expanded to include all vehicles equipped with the subject Headlight Driver Module (HDM). The focus of the investigation was to determine whether actions performed by General Motors adequately addressed any unreasonable risk to motor vehicle safety in the subject vehicles concerning the headlights and the HDM that controls them.Under normal electrical load and environmental conditions, the HDM can overheat inside the Underhood Electrical Center (UEC). This can cause the module to fail and result in a simultaneous loss of both low beam headlights and both daytime running lights (DRLs), often with no warning or prior detectability to the driver. This failure can be intermittent or permanent. No other exterior lights are affected. High beams, turn signals, brake lights, and reverse lights are still operational.General Motors addressed this issue with 2 recalls (14V755 & 15V519) and a special coverage program (N172091910). In view of the recalls and special coverage program implemented by GM and the vehicle high beams continuing to operate, ODI has tentatively concluded that the actions taken by GM mitigate any unreasonable risk to safety posed by HDM failure in the subject vehicles.Accordingly, the investigation is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take additional action if warranted by new circumstances.The ODI reports cited above are available for review online at NHTSA.gov under the identification numbers in the attached document.

EA12004 · Driver's Master Power Window Switch

Opened Jun 11, 2012 · Closed Jun 21, 2013

Status: closed (inferred from source dates) · Electrical System; Visibility:power Window Devices And Controls

On August 15, 2012 General Motors (GM) announced a regional recall action (12V-406) involving model year (MY) 2006-2007 Chevrolet Trailblazer, GMC Envoy, Buick Rainier, Isuzu Ascender and MY2005-2007 SAAB 9-7x vehicles originally sold or currently registered in the salt belt states of Connecticut, Delaware, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, Wisconsin, and the District of Columbia. The recall remedy requires the inspection and repair or replacement of the master power window switch, which GM refers to as a driver door module (DDM). At the same time, GM implemented a special coverage program to replace failed DDMs for vehicles registered outside of these states. ODI was not satisfied with GM's exclusion of non-salt belt vehicles and continued its investigation. On June 13, 2013, GM submitted a related recall notification (13V-248) to reclassify the initial special coverage program into a safety recall for vehicles that were not previously repaired under special coverage.The Office of Defects Investigation (ODI) opened Engineering Analysis EA12-004 on June 11, 2012 to further investigate allegations of DDM thermal incidents in model year (MY) 2006-2007 Chevrolet Trailblazer vehicles. Thermal incidents involve cases where fire-related events such as smoke and melt are present. ODI has received 170 reports alleging a thermal event occurred. Complainants stated that the DDM melted and in some cases produced odor and/or smoke. Fourteen of these incidents led to a fire where visible flames were reported or the damage extended significantly beyond the DDM. In addition to the 170 reports listed above, ODI received 63 reports alleging the DDM acted erratically or became inoperative. In response to ODI's Information Request (IR), GM provided 619 unique consumer complaints that related to the alleged problem. Seventy-seven of those reports led to a fire with flame, and 4 reported injuries of smoke inhalation and/or slight burns from contact with hot switches. GM also submitted 20,400 warranty claims for replacement of the DDM, most of which involved inoperative switches. The problem condition is caused by fluids, such as rain water, entering the driver's door module and subsequently causing corrosion that could result in an electrical short in the printed circuit board. A short may cause the power door lock and power window switches to function intermittently or become inoperative. However, the electrical short may also cause overheating that could melt components of the door module, producing odor, smoke or in some cases fire with flame. The circuit board was redesigned and GM implemented the new design into vehicle production on May 14, 2007. All failures cited above occurred in vehicles produced before this build date (i.e., with the original design DDM). GM also reported that all MY 2006-2007 GMT360/370 platform vehicles and MY 2005 SAAB 9-7x vehicles utilized the same DDM and therefore ODI expanded the subject population to include these vehicles.This investigation is closed on the basis of GM's announcement of safety recalls 12V-406 and 13V-248. The ODI complaints cited above can be reviewed at: http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID, see the attached list for ODI numbers.

Additional source detail variants (4)

Electrical System

On August 15, 2012 General Motors (GM) announced a regional recall action (12V-406) involving model year (MY) 2006-2007 Chevrolet Trailblazer, GMC Envoy, Buick Rainier, Isuzu Ascender and MY2005-2007 SAAB 9-7x vehicles originally sold or currently registered in the salt belt states of Connecticut, Delaware, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, Wisconsin, and the District of Columbia. The recall remedy requires the inspection and repair or replacement of the master power window switch, which GM refers to as a driver door module (DDM). At the same time, GM implemented a special coverage program to replace failed DDMs for vehicles registered outside of these states. ODI was not satisfied with GM's exclusion of non-salt belt vehicles and continued its investigation. On June 13, 2013, GM submitted a related recall notification (13V-248) to reclassify the initial special coverage program into a safety recall for vehicles that were not previously repaired under special coverage.The Office of Defects Investigation (ODI) opened Engineering Analysis EA12-004 on June 11, 2012 to further investigate allegations of DDM thermal incidents in model year (MY) 2006-2007 Chevrolet Trailblazer vehicles. Thermal incidents involve cases where fire-related events such as smoke and melt are present. ODI has received 170 reports alleging a thermal event occurred. Complainants stated that the DDM melted and in some cases produced odor and/or smoke. Fourteen of these incidents led to a fire where visible flames were reported or the damage extended significantly beyond the DDM. In addition to the 170 reports listed above, ODI received 63 reports alleging the DDM acted erratically or became inoperative. In response to ODI's Information Request (IR), GM provided 619 unique consumer complaints that related to the alleged problem. Seventy-seven of those reports led to a fire with flame, and 4 reported injuries of smoke inhalation and/or slight burns from contact with hot switches. GM also submitted 20,400 warranty claims for replacement of the DDM, most of which involved inoperative switches. The problem condition is caused by fluids, such as rain water, entering the driver's door module and subsequently causing corrosion that could result in an electrical short in the printed circuit board. A short may cause the power door lock and power window switches to function intermittently or become inoperative. However, the electrical short may also cause overheating that could melt components of the door module, producing odor, smoke or in some cases fire with flame. The circuit board was redesigned and GM implemented the new design into vehicle production on May 14, 2007. All failures cited above occurred in vehicles produced before this build date (i.e., with the original design DDM). GM also reported that all MY 2006-2007 GMT360/370 platform vehicles and MY 2005 SAAB 9-7x vehicles utilized the same DDM and therefore ODI expanded the subject population to include these vehicles.This investigation is closed on the basis of GM's announcement of safety recalls 12V-406 and 13V-248. The ODI complaints cited above can be reviewed at: http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID, see the attached list for ODI numbers.

Electrical System

On August 15, 2012 General Motors (GM) announced a regional recall action (12V-406) involving model year (MY) 2006-2007 Chevrolet Trailblazer, GMC Envoy, Buick Rainier, Isuzu Ascender and MY2005-2007 SAAB 9-7x vehicles originally sold or currently registered in the salt belt states of Connecticut, Delaware, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, Wisconsin, and the District of Columbia. The recall remedy requires the inspection and repair or replacement of the master power window switch, which GM refers to as a driver door module (DDM). At the same time, GM implemented a special coverage program to replace failed DDMs for vehicles registered outside of these states. ODI was not satisfied with GM's exclusion of non-salt belt vehicles and continued its investigation. On June 13, 2013, GM submitted a related recall notification (13V-248) to reclassify the initial special coverage program into a safety recall for vehicles that were not previously repaired under special coverage.The Office of Defects Investigation (ODI) opened Engineering Analysis EA12-004 on June 11, 2012 to further investigate allegations of DDM thermal incidents in model year (MY) 2006-2007 Chevrolet Trailblazer vehicles. Thermal incidents involve cases where fire-related events such as smoke and melt are present. ODI has received 170 reports alleging a thermal event occurred. Complainants stated that the DDM melted and in some cases produced odor and/or smoke. Fourteen of these incidents led to a fire where visible flames were reported or the damage extended significantly beyond the DDM. In addition to the 170 reports listed above, ODI received 63 reports alleging the DDM acted erratically or became inoperative. In response to ODI's Information Request (IR), GM provided 619 unique consumer complaints that related to the alleged problem. Seventy-seven of those reports led to a fire with flame, and 4 reported injuries of smoke inhalation and/or slight burns from contact with hot switches. GM also submitted 20,400 warranty claims for replacement of the DDM, most of which involved inoperative switches. The problem condition is caused by fluids, such as rain water, entering the driver's door module and subsequently causing corrosion that could result in an electrical short in the printed circuit board. A short may cause the power door lock and power window switches to function intermittently or become inoperative. However, the electrical short may also cause overheating that could melt components of the door module, producing odor, smoke or in some cases fire with flame. The circuit board was redesigned and GM implemented the new design into vehicle production on May 14, 2007. All failures cited above occurred in vehicles produced before this build date (i.e., with the original design DDM). GM also reported that all MY 2006-2007 GMT360/370 platform vehicles and MY 2005 SAAB 9-7x vehicles utilized the same DDM and therefore ODI expanded the subject population to include these vehicles.This investigation is closed on the basis of GM's announcement of safety recalls 12V-406 and 13V-248. The ODI complaints cited above can be reviewed at: http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID, see the attached list for ODI numbers.

Visibility:power Window Devices And Controls

On August 15, 2012 General Motors (GM) announced a regional recall action (12V-406) involving model year (MY) 2006-2007 Chevrolet Trailblazer, GMC Envoy, Buick Rainier, Isuzu Ascender and MY2005-2007 SAAB 9-7x vehicles originally sold or currently registered in the salt belt states of Connecticut, Delaware, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, Wisconsin, and the District of Columbia. The recall remedy requires the inspection and repair or replacement of the master power window switch, which GM refers to as a driver door module (DDM). At the same time, GM implemented a special coverage program to replace failed DDMs for vehicles registered outside of these states. ODI was not satisfied with GM's exclusion of non-salt belt vehicles and continued its investigation. On June 13, 2013, GM submitted a related recall notification (13V-248) to reclassify the initial special coverage program into a safety recall for vehicles that were not previously repaired under special coverage.The Office of Defects Investigation (ODI) opened Engineering Analysis EA12-004 on June 11, 2012 to further investigate allegations of DDM thermal incidents in model year (MY) 2006-2007 Chevrolet Trailblazer vehicles. Thermal incidents involve cases where fire-related events such as smoke and melt are present. ODI has received 170 reports alleging a thermal event occurred. Complainants stated that the DDM melted and in some cases produced odor and/or smoke. Fourteen of these incidents led to a fire where visible flames were reported or the damage extended significantly beyond the DDM. In addition to the 170 reports listed above, ODI received 63 reports alleging the DDM acted erratically or became inoperative. In response to ODI's Information Request (IR), GM provided 619 unique consumer complaints that related to the alleged problem. Seventy-seven of those reports led to a fire with flame, and 4 reported injuries of smoke inhalation and/or slight burns from contact with hot switches. GM also submitted 20,400 warranty claims for replacement of the DDM, most of which involved inoperative switches. The problem condition is caused by fluids, such as rain water, entering the driver's door module and subsequently causing corrosion that could result in an electrical short in the printed circuit board. A short may cause the power door lock and power window switches to function intermittently or become inoperative. However, the electrical short may also cause overheating that could melt components of the door module, producing odor, smoke or in some cases fire with flame. The circuit board was redesigned and GM implemented the new design into vehicle production on May 14, 2007. All failures cited above occurred in vehicles produced before this build date (i.e., with the original design DDM). GM also reported that all MY 2006-2007 GMT360/370 platform vehicles and MY 2005 SAAB 9-7x vehicles utilized the same DDM and therefore ODI expanded the subject population to include these vehicles.This investigation is closed on the basis of GM's announcement of safety recalls 12V-406 and 13V-248. The ODI complaints cited above can be reviewed at: http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID, see the attached list for ODI numbers.

Visibility:power Window Devices And Controls

On August 15, 2012 General Motors (GM) announced a regional recall action (12V-406) involving model year (MY) 2006-2007 Chevrolet Trailblazer, GMC Envoy, Buick Rainier, Isuzu Ascender and MY2005-2007 SAAB 9-7x vehicles originally sold or currently registered in the salt belt states of Connecticut, Delaware, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, Wisconsin, and the District of Columbia. The recall remedy requires the inspection and repair or replacement of the master power window switch, which GM refers to as a driver door module (DDM). At the same time, GM implemented a special coverage program to replace failed DDMs for vehicles registered outside of these states. ODI was not satisfied with GM's exclusion of non-salt belt vehicles and continued its investigation. On June 13, 2013, GM submitted a related recall notification (13V-248) to reclassify the initial special coverage program into a safety recall for vehicles that were not previously repaired under special coverage.The Office of Defects Investigation (ODI) opened Engineering Analysis EA12-004 on June 11, 2012 to further investigate allegations of DDM thermal incidents in model year (MY) 2006-2007 Chevrolet Trailblazer vehicles. Thermal incidents involve cases where fire-related events such as smoke and melt are present. ODI has received 170 reports alleging a thermal event occurred. Complainants stated that the DDM melted and in some cases produced odor and/or smoke. Fourteen of these incidents led to a fire where visible flames were reported or the damage extended significantly beyond the DDM. In addition to the 170 reports listed above, ODI received 63 reports alleging the DDM acted erratically or became inoperative. In response to ODI's Information Request (IR), GM provided 619 unique consumer complaints that related to the alleged problem. Seventy-seven of those reports led to a fire with flame, and 4 reported injuries of smoke inhalation and/or slight burns from contact with hot switches. GM also submitted 20,400 warranty claims for replacement of the DDM, most of which involved inoperative switches. The problem condition is caused by fluids, such as rain water, entering the driver's door module and subsequently causing corrosion that could result in an electrical short in the printed circuit board. A short may cause the power door lock and power window switches to function intermittently or become inoperative. However, the electrical short may also cause overheating that could melt components of the door module, producing odor, smoke or in some cases fire with flame. The circuit board was redesigned and GM implemented the new design into vehicle production on May 14, 2007. All failures cited above occurred in vehicles produced before this build date (i.e., with the original design DDM). GM also reported that all MY 2006-2007 GMT360/370 platform vehicles and MY 2005 SAAB 9-7x vehicles utilized the same DDM and therefore ODI expanded the subject population to include these vehicles.This investigation is closed on the basis of GM's announcement of safety recalls 12V-406 and 13V-248. The ODI complaints cited above can be reviewed at: http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID, see the attached list for ODI numbers.

PE11014 · Fuel Level Gauge System Failure

Opened Apr 25, 2011 · Closed Sep 23, 2011

Status: closed (inferred from source dates) · Fuel System, Other; Fuel System, Other:storage:fuel Gauge System

The office of defects investigations (ODI) analyzed complaint data provided by General Motors (GM) as well as complaints submitted to ODI from consumers.In total, there were 5,089 unique reports indicating an inaccurate fuel level reading while driving.General Motors stated that this condition occurs when the contacts of the fuel sensor wear prematurely.Most of the complaints indicated an empty fuel gauge reading after filling the tank.Less than 10 percent of theODI complaints involved an engine stall incident.During this investigation, GM developed a remedy procedure and issued special coverage bulletin instructing dealers to install a new design fuel level sensor.The bulletin was sent to dealers on August 10, 2011 and the owner letter mailing began on August 15, 2011.See the investigative file for copies of GM's bulletin and owner letter.This preliminary evaluation is closed.

Additional source detail variants (2)

Fuel System, Other

The office of defects investigations (ODI) analyzed complaint data provided by General Motors (GM) as well as complaints submitted to ODI from consumers.In total, there were 5,089 unique reports indicating an inaccurate fuel level reading while driving.General Motors stated that this condition occurs when the contacts of the fuel sensor wear prematurely.Most of the complaints indicated an empty fuel gauge reading after filling the tank.Less than 10 percent of theODI complaints involved an engine stall incident.During this investigation, GM developed a remedy procedure and issued special coverage bulletin instructing dealers to install a new design fuel level sensor.The bulletin was sent to dealers on August 10, 2011 and the owner letter mailing began on August 15, 2011.See the investigative file for copies of GM's bulletin and owner letter.This preliminary evaluation is closed.

Fuel System, Other:storage:fuel Gauge System

The office of defects investigations (ODI) analyzed complaint data provided by General Motors (GM) as well as complaints submitted to ODI from consumers.In total, there were 5,089 unique reports indicating an inaccurate fuel level reading while driving.General Motors stated that this condition occurs when the contacts of the fuel sensor wear prematurely.Most of the complaints indicated an empty fuel gauge reading after filling the tank.Less than 10 percent of theODI complaints involved an engine stall incident.During this investigation, GM developed a remedy procedure and issued special coverage bulletin instructing dealers to install a new design fuel level sensor.The bulletin was sent to dealers on August 10, 2011 and the owner letter mailing began on August 15, 2011.See the investigative file for copies of GM's bulletin and owner letter.This preliminary evaluation is closed.

DP10001 · Fuel Level Gauge System Failure

Opened Jan 7, 2010 · Closed May 23, 2011

Status: closed (inferred from source dates) · Fuel System, Other; Fuel System, Other:storage:fuel Gauge System

The Office of Defects Investigation has received 668 complaints alleging inaccurate fuel gauge reading while driving in model year 2005-07 Chevrolet Trailblazer, GMC Envoy, Buick Rainier, and Saab 9-7x vehicles.Of the 668 complaints, 58 incidents were alleged to result in a vehicle stall.Of the 58 stalling incidents, 43 complaints reported stalling because the fuel level reading indicated more fuel availability than what is actually in the fuel tank. One complaint alleged a vehicle crash after the vehicle stalled while exiting the interstate, became disabled, and was struck from behind.Summarily, the complaints show an apparent increasing trend, with most complaints received within the past year.A Preliminary Evaluation has been opened to assess the scope, frequency and potential safety consequences associated with the alleged defect.

Additional source detail variants (2)

Fuel System, Other

The Office of Defects Investigation has received 668 complaints alleging inaccurate fuel gauge reading while driving in model year 2005-07 Chevrolet Trailblazer, GMC Envoy, Buick Rainier, and Saab 9-7x vehicles.Of the 668 complaints, 58 incidents were alleged to result in a vehicle stall.Of the 58 stalling incidents, 43 complaints reported stalling because the fuel level reading indicated more fuel availability than what is actually in the fuel tank. One complaint alleged a vehicle crash after the vehicle stalled while exiting the interstate, became disabled, and was struck from behind.Summarily, the complaints show an apparent increasing trend, with most complaints received within the past year.A Preliminary Evaluation has been opened to assess the scope, frequency and potential safety consequences associated with the alleged defect.

Fuel System, Other:storage:fuel Gauge System

The Office of Defects Investigation has received 668 complaints alleging inaccurate fuel gauge reading while driving in model year 2005-07 Chevrolet Trailblazer, GMC Envoy, Buick Rainier, and Saab 9-7x vehicles.Of the 668 complaints, 58 incidents were alleged to result in a vehicle stall.Of the 58 stalling incidents, 43 complaints reported stalling because the fuel level reading indicated more fuel availability than what is actually in the fuel tank. One complaint alleged a vehicle crash after the vehicle stalled while exiting the interstate, became disabled, and was struck from behind.Summarily, the complaints show an apparent increasing trend, with most complaints received within the past year.A Preliminary Evaluation has been opened to assess the scope, frequency and potential safety consequences associated with the alleged defect.