IllustrationFUEL SYSTEM SENSOR WAS THE FIRST TO MALFUNCTION. THEN THE OIL GAUGE IS MALFUNCTIONING AND NOW AIR SUSPENSION AND OTHER SYSTEMS ARE STARTING TO NOT WORK PROPERLY. *KB
2005 Buick Rainier
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2005 Buick Rainier do not stand out strongly from the model-year median of 91.
About this comparison →How this year compares
Owner complaints by model year
Compare all Rainier years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
90–25K
1525–50K
2150–75K
1375–100K
19100–150K
5150K+
82 reports with mileage · 21 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 38 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Fuel System, Gasoline. Review the 20 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Exterior Lighting. Review the 15 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
6 crash reports3 fire reports3 injury reports
Engine And Engine Cooling complaints
5 reportsTL* THE CONTACT OWNS A 2005 BUICK RAINIER. THE CONTACT STATED THE CHECK ENGINE WARNING LIGHT REMAINED ILLUMINATED ON THE CONSOLE. THE DEALER ADVISED THAT THE ENGINE HEADS HAD FAILED AND WOULD NEED TO BE REPLACED. THE CONTACT STATED HE WAS UNABLE TO PASS EMISSIONS DUE TO THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILE…
Read full complaint
TL* THE CONTACT OWNS A 2005 BUICK RAINIER. THE CONTACT STATED THE CHECK ENGINE WARNING LIGHT REMAINED ILLUMINATED ON THE CONSOLE. THE DEALER ADVISED THAT THE ENGINE HEADS HAD FAILED AND WOULD NEED TO BE REPLACED. THE CONTACT STATED HE WAS UNABLE TO PASS EMISSIONS DUE TO THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 68,000 AND THE CURRENT MILEAGE 70,000.
I WAS THIRD IN LINE WAITING TO PULL OUT OF A PARKING LOT IN PEORIA, AZ IN MY 2005 BUICK RAINIER. MY FOOT WAS RESTING ON THE BRAKE PEDAL. ALL OF THE SUDDEN THE CAR REVVED UP AND SURGED FORWARD (FROM A STANDING START) WITH ENOUGH FORCE TO CRASH INTO THE CAR IN FRONT OF ME AND PUSHING THAT CAR IN TO THE ONE IN FRONT OF IT--ALL THRE…
Read full complaint
I WAS THIRD IN LINE WAITING TO PULL OUT OF A PARKING LOT IN PEORIA, AZ IN MY 2005 BUICK RAINIER. MY FOOT WAS RESTING ON THE BRAKE PEDAL. ALL OF THE SUDDEN THE CAR REVVED UP AND SURGED FORWARD (FROM A STANDING START) WITH ENOUGH FORCE TO CRASH INTO THE CAR IN FRONT OF ME AND PUSHING THAT CAR IN TO THE ONE IN FRONT OF IT--ALL THREE CARS WERE SEVERELY DAMAGED. *TR
(1) COMPLETE BRAKE JOB W/ROTORS AND DRUMS REPLACED, I WAS TOLD I HAD BEEN DRIVING WITH THE EMERGENCY BRAKE ON THOUGH I NEVER HAD USED THE EMERGENCY BRAKE..FIXED UNDER WARRANTY. (2) HATCH BACK DOOR "PISTONS??" THAT HOLDS UP THE HATCHBACK FAILED..FIXED UNDER WARRANTY. (3) FAN CLUTCH FAILED...FIXED UNDER WARRANTY. (4) PAINT CHIPP…
Read full complaint
(1) COMPLETE BRAKE JOB W/ROTORS AND DRUMS REPLACED, I WAS TOLD I HAD BEEN DRIVING WITH THE EMERGENCY BRAKE ON THOUGH I NEVER HAD USED THE EMERGENCY BRAKE..FIXED UNDER WARRANTY. (2) HATCH BACK DOOR "PISTONS??" THAT HOLDS UP THE HATCHBACK FAILED..FIXED UNDER WARRANTY. (3) FAN CLUTCH FAILED...FIXED UNDER WARRANTY. (4) PAINT CHIPPING/PEELING; RADIO BUTTONS CHIPPING/PEELING. (5) AC/HEATER GETS STUCK ON HOT AIR BLOWING OUT WHEN SWITCHING TO AC SOMETIMES. (6) PASSENGER SIDE FEELS LIKE TIRE OR FRONT END IS WOBBLY??...DEALERSHIP COULDN'T FIND ANYTHING. (7) DEC 2008, DRIVER SEAT HEATER WAS REPLACED DUE TO MAJOR OVERHEATING...FIXED UNDER WARRANTY. (8) FEB 2010 - 14 MONTHS LATER REPLACING DRIVER SEAT HEATER AGAIN DUE TO MAJOR OVERHEATING...SEAT HEATER HAS NOW BURNED 3 HOLES INTO LEATHER SEAT..NOT UNDER WARRANTY. *TR
DESIGN FAULT - AIR PUMP IS MOUNTED LOW ON THE FRAME OF 2005 BUICK RAINIER. ON 10/30/07 IT FAILED AND HAD TO BE REPLACED. MILEAGE AT THAT TIME WAS 30,947. PUMP FAILED AGAIN BECAUSE OF WATER INTRUSION. SINCE IT IS MOUNTED LOW WITHOUT ANY SHIELD I WOULD EXPECT RAIN WATER TO SPLASH UP AS YOU DRIVE. PUMP WAS REPLACED A SECOND TIME ON…
Read full complaint
DESIGN FAULT - AIR PUMP IS MOUNTED LOW ON THE FRAME OF 2005 BUICK RAINIER. ON 10/30/07 IT FAILED AND HAD TO BE REPLACED. MILEAGE AT THAT TIME WAS 30,947. PUMP FAILED AGAIN BECAUSE OF WATER INTRUSION. SINCE IT IS MOUNTED LOW WITHOUT ANY SHIELD I WOULD EXPECT RAIN WATER TO SPLASH UP AS YOU DRIVE. PUMP WAS REPLACED A SECOND TIME ON 12/12/08, MILEAGE WAS 39,994. THE SECOND PUMP ONLY LASTED 9,000 MILES AND GM REFUSES TO PAY FOR REPLACEMENT ( THE WARRANTY IS FOR 12,000 MILES OR 12 MONTHS, YOUR PART IS 13 MONTHS OLD). *TR
Official recalls
105V035000 · Visibility:windshield
Feb 3, 2005
CERTAIN SPORT UTILITY VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 212, 'WINDSHIELD MOUNTING.' THE WINDSHIELD URETHANE BEAD MAY NOT HAVE ADHERED TO THE BODY IN CERTAIN AREAS DURING THE CURE PROCESS.
Consequence & remedy
Consequence: IF A CRASH OCCURS, THE WINDSHIELD MAY NOT BE RETAINED, INCREASING THE RISK OF INJURY TO A VEHICLE OCCUPANT.
Remedy: DEALERS WILL REPLACE THE WINDSHIELD FREE OF CHARGE. THE RECALL BEGAN ON MARCH 10, 2005. OWNERS MAY CONTACT BUICK AT 1-866-608-8080, CHEVROLET AT 1-800-630-2438, OR GMC AT 1-866-996-9463.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3RQ17002 · Loss Of Headlights
Opened Apr 24, 2017 · Closed Mar 29, 2021
Status: closed (inferred from source dates) · Exterior Lighting:headlights
The subject vehicles are model year (MY) 2002-2009 Chevrolet Trailblazer, GMC Envoy, 2004-2007 Buick Rainier, 2003-2008 Isuzu Ascender, 2005-2009 Saab 9-7X, 2002-2004 Oldsmobile Bravada, 2003-2006 Chevrolet SSR, 2005-2009 Buick Lacrosse, and 2006-2008 Pontiac Grand Prix. This scope includes the Trailblazer/Envoy variants: 2002-2006 Envoy XL/Trailblazer EXT and 2004-2005 Envoy XUV. The original scope of this investigation was expanded to include all vehicles equipped with the subject Headlight Driver Module (HDM). The focus of the investigation was to determine whether actions performed by General Motors adequately addressed any unreasonable risk to motor vehicle safety in the subject vehicles concerning the headlights and the HDM that controls them.Under normal electrical load and environmental conditions, the HDM can overheat inside the Underhood Electrical Center (UEC). This can cause the module to fail and result in a simultaneous loss of both low beam headlights and both daytime running lights (DRLs), often with no warning or prior detectability to the driver. This failure can be intermittent or permanent. No other exterior lights are affected. High beams, turn signals, brake lights, and reverse lights are still operational.General Motors addressed this issue with 2 recalls (14V755 & 15V519) and a special coverage program (N172091910). In view of the recalls and special coverage program implemented by GM and the vehicle high beams continuing to operate, ODI has tentatively concluded that the actions taken by GM mitigate any unreasonable risk to safety posed by HDM failure in the subject vehicles.Accordingly, the investigation is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take additional action if warranted by new circumstances.The ODI reports cited above are available for review online at NHTSA.gov under the identification numbers in the attached document.
PE11014 · Fuel Level Gauge System Failure
Opened Apr 25, 2011 · Closed Sep 23, 2011
Status: closed (inferred from source dates) · Fuel System, Other; Fuel System, Other:storage:fuel Gauge System
The office of defects investigations (ODI) analyzed complaint data provided by General Motors (GM) as well as complaints submitted to ODI from consumers.In total, there were 5,089 unique reports indicating an inaccurate fuel level reading while driving.General Motors stated that this condition occurs when the contacts of the fuel sensor wear prematurely.Most of the complaints indicated an empty fuel gauge reading after filling the tank.Less than 10 percent of theODI complaints involved an engine stall incident.During this investigation, GM developed a remedy procedure and issued special coverage bulletin instructing dealers to install a new design fuel level sensor.The bulletin was sent to dealers on August 10, 2011 and the owner letter mailing began on August 15, 2011.See the investigative file for copies of GM's bulletin and owner letter.This preliminary evaluation is closed.
Additional source detail variants (2)
Fuel System, Other
The office of defects investigations (ODI) analyzed complaint data provided by General Motors (GM) as well as complaints submitted to ODI from consumers.In total, there were 5,089 unique reports indicating an inaccurate fuel level reading while driving.General Motors stated that this condition occurs when the contacts of the fuel sensor wear prematurely.Most of the complaints indicated an empty fuel gauge reading after filling the tank.Less than 10 percent of theODI complaints involved an engine stall incident.During this investigation, GM developed a remedy procedure and issued special coverage bulletin instructing dealers to install a new design fuel level sensor.The bulletin was sent to dealers on August 10, 2011 and the owner letter mailing began on August 15, 2011.See the investigative file for copies of GM's bulletin and owner letter.This preliminary evaluation is closed.
Fuel System, Other:storage:fuel Gauge System
The office of defects investigations (ODI) analyzed complaint data provided by General Motors (GM) as well as complaints submitted to ODI from consumers.In total, there were 5,089 unique reports indicating an inaccurate fuel level reading while driving.General Motors stated that this condition occurs when the contacts of the fuel sensor wear prematurely.Most of the complaints indicated an empty fuel gauge reading after filling the tank.Less than 10 percent of theODI complaints involved an engine stall incident.During this investigation, GM developed a remedy procedure and issued special coverage bulletin instructing dealers to install a new design fuel level sensor.The bulletin was sent to dealers on August 10, 2011 and the owner letter mailing began on August 15, 2011.See the investigative file for copies of GM's bulletin and owner letter.This preliminary evaluation is closed.
DP10001 · Fuel Level Gauge System Failure
Opened Jan 7, 2010 · Closed May 23, 2011
Status: closed (inferred from source dates) · Fuel System, Other; Fuel System, Other:storage:fuel Gauge System
The Office of Defects Investigation has received 668 complaints alleging inaccurate fuel gauge reading while driving in model year 2005-07 Chevrolet Trailblazer, GMC Envoy, Buick Rainier, and Saab 9-7x vehicles.Of the 668 complaints, 58 incidents were alleged to result in a vehicle stall.Of the 58 stalling incidents, 43 complaints reported stalling because the fuel level reading indicated more fuel availability than what is actually in the fuel tank. One complaint alleged a vehicle crash after the vehicle stalled while exiting the interstate, became disabled, and was struck from behind.Summarily, the complaints show an apparent increasing trend, with most complaints received within the past year.A Preliminary Evaluation has been opened to assess the scope, frequency and potential safety consequences associated with the alleged defect.
Additional source detail variants (2)
Fuel System, Other
The Office of Defects Investigation has received 668 complaints alleging inaccurate fuel gauge reading while driving in model year 2005-07 Chevrolet Trailblazer, GMC Envoy, Buick Rainier, and Saab 9-7x vehicles.Of the 668 complaints, 58 incidents were alleged to result in a vehicle stall.Of the 58 stalling incidents, 43 complaints reported stalling because the fuel level reading indicated more fuel availability than what is actually in the fuel tank. One complaint alleged a vehicle crash after the vehicle stalled while exiting the interstate, became disabled, and was struck from behind.Summarily, the complaints show an apparent increasing trend, with most complaints received within the past year.A Preliminary Evaluation has been opened to assess the scope, frequency and potential safety consequences associated with the alleged defect.
Fuel System, Other:storage:fuel Gauge System
The Office of Defects Investigation has received 668 complaints alleging inaccurate fuel gauge reading while driving in model year 2005-07 Chevrolet Trailblazer, GMC Envoy, Buick Rainier, and Saab 9-7x vehicles.Of the 668 complaints, 58 incidents were alleged to result in a vehicle stall.Of the 58 stalling incidents, 43 complaints reported stalling because the fuel level reading indicated more fuel availability than what is actually in the fuel tank. One complaint alleged a vehicle crash after the vehicle stalled while exiting the interstate, became disabled, and was struck from behind.Summarily, the complaints show an apparent increasing trend, with most complaints received within the past year.A Preliminary Evaluation has been opened to assess the scope, frequency and potential safety consequences associated with the alleged defect.