Electrical SystemEngine And Engine CoolingFuel System, Gasoline
AT THE FIRST FILLING OF GAS TANK, FUEL CAME OUT OF BAD GASKET AND SPILLED FUEL CAUSING WICKED BAD FUEL SMELL THROUGH OUT INTERIOR OF CAR. HEATER HAS NEVER OPERATED PROPERLY. THE ONLY WAY THAT YOU CAN BE COMFORTABLE IN COLD WEATHER IS TO OPERATE MANUALLY. THE ALTERNATOR HAS ALWAYS HAD A VERY NOTICEABLE AND ANNOYING HUM AT SLOW SP…
Read full complaint
AT THE FIRST FILLING OF GAS TANK, FUEL CAME OUT OF BAD GASKET AND SPILLED FUEL CAUSING WICKED BAD FUEL SMELL THROUGH OUT INTERIOR OF CAR. HEATER HAS NEVER OPERATED PROPERLY. THE ONLY WAY THAT YOU CAN BE COMFORTABLE IN COLD WEATHER IS TO OPERATE MANUALLY. THE ALTERNATOR HAS ALWAYS HAD A VERY NOTICEABLE AND ANNOYING HUM AT SLOW SPEEDS. THE ALTERNATOR HAS BEEN REPLACED TWICE, WITH NO IMPROVEMENTS IN THE NOISES. POWER ASSIST FAILED AND AS A RESULT I LOST ALL BRAKING AND A STRONG ODOR DEVELOPED INSIDE THE CAR. THIS IS OK NOW AND ALONG WITH THE GAS TANK IS THE ONLY THINGS THAT HAVE BEEN REPAIRED.
NHTSA ODI #720756
Mileage unknown · Mar 20, 2000
Electrical System
EXPERIENCING ONGOING PROBLEM WITH HORN; UNABLE TO ACTIVATE HORN WHEN NEEDED UNLESS EXTREME PRESSURE IS APPLIED. DEALER NOTIFIED, AND INFORMED CONSUMER THAT NOTHING COULD BE FOUND. *AK
NHTSA ODI #858864
Mileage unknown · Mar 9, 2000
Electrical System
CONSUMER CANNOT BLOW HORN, IT TAKES TOO MUCH PRESSURE TO MAKE THE HORN BLOW. ALSO, IT IS NOT NECESSARY ALWAYS TO LOOK IN THE SAME PLACE TO MAKE HORN BLOW. *AK
NHTSA ODI #858266
Mileage unknown · Feb 29, 2000
Electrical SystemVisibility
DRIVER UNABLE TO SOUND THE HORN DUE TO LOCATION OF THE HORN AND HARD TO DEPRESS IT. YH
NHTSA ODI #551161
Mileage unknown · Feb 1, 2000
Electrical System
HORN IS VERY DIFFICULT TO ACTIVATE, AN ABNORMAL AMOUNT OF PRESSURE IS REQUIRED. *MJS
NHTSA ODI #550635
Mileage unknown · Dec 1, 1999
Electrical SystemFire
DRIVER WAS ABOUT TO PARK VEHICLE WHEN SHE SMELLED SMOKE WITHIN SECONDS FLAMES DEVELOPED UNDERNEATH HOOD.PLEASE PROVIDE FURTHER INFORMATION. *AK
NHTSA ODI #853534
Mileage unknown · Aug 11, 1999
Electrical System
ELECTRICAL SYSTEM ISN'T WORKING, CAUSING ALL THE COMPONENTS ON THE DASHBOARD TO MALFUNCTION. ALSO, BRAKE LIGHT COMES ON/ HORN KEEPS BLOWING, AND THE COMPUTER SYSTEM ISN'T WORKING. *AK
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH 3800 V6 (L36) ENGINES AND CERTAIN DELPHI FUEL PRESSURE REGULATORS, THE REGULATORS HAVE A MUCH HIGHER THAN USUAL RATE OF FUEL LEAKS. A LEAK CAN ALLOW FUEL TO ENTER THE INTAKE MANIFOLD THROUGH A VACUUM LINE. IF THE ENGINE DOES NOT START WHEN CRANKED, THE FUEL FROM THE LEAKING REGULATOR AND A MISTIMED SPARK CAN CAUSE A BACKFIRE.
Consequence & remedy
Consequence: THE BACKFIRE CAN RUPTURE THE INTAKE MANIFOLD. THE RUPTURE OF THE INTAKE MANIFOLD CAN DISPLACE A FUEL LINE, PULLING AN INJECTOR OUT OF PLACE, AND CAUSING A FUEL LEAK AND POSSIBLE FIRE.
Remedy: DEALERS WILL INSTALL NEW FUEL PRESSURE REGULATORS WITH IMPROVED DIAPHRAGMS. THE RECALL WILL BE CONDUCTED IN PHASED MAILINGS. PHASE 1 BEGAN ON JUNE 30, 2004, AND PHASE 2 BEGAN ON SEPTEMBER 30, 2004. OWNERS SHOULD CONTACT BUICK AT 1-866-608-8080, OLDSMOBILE AT 1-800-630-6537, OR PONTIAC AT 1-800-620-7668.
VEHICLE DESCRIPTION: PASSENGER VEHICLES. SOME OF THESE VEHICLES HAVE INTERNAL FLUID LEAKS IN THE BRAKE HYDRAULIC CONTROL UNIT.
Consequence & remedy
Consequence: WHEN THE REAR BRAKE PROPORTIONING, ANTILOCK BRAKE, TRACTION CONTROL, OR STABILITY CONTROL FEATURE IS ACTIVATED IN SOME DRIVING SITUATIONS, THE FEATURE MAY NOT PERFORM AS DESIGNED.
Remedy: DEALERS WILL INSPECT THE ABS HYDRAULIC MODULATOR UNIT AND IF NECESSARY, REPLACE THE HYDRAULIC MODULATOR.
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THESE VEHICLES DO NOT CONFORM TO THE REQUIREMENTS OF FMVSS NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THE HEAD LAMP ADJUSTMENT DEVICE HORIZONTAL ADJUSTER MAY NOT MOVE THE HEAD LAMP REFLECTOR WHEN THE SHAFT IS ROTATED IN A NORMAL MANNER DURING AIMING.
Consequence & remedy
Consequence: DRIVER VISIBILITY MAY BE IMPAIRED INCREASING THE RISK OF A CRASH.
Remedy: AN INSERT CONTAINING INSTRUCTIONS FOR OPTICALLY AIMING THE HEADLAMPS WILL BE PROVIDED TO OWNERS FOR THE OWNER'S MANUAL. OWNERS SHOULD FOLLOW THE PROCEDURE IN THE INSERT FOR HEADLAMP AIM ADJUSTMENT, RATHER THAN USING THE HORIZONTAL VHAD INDICATOR.
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE BRAKE BOOSTER TO PEDAL ASSEMBLY ATTACHMENT NUTS MAY BE LOOSE.
Consequence & remedy
Consequence: IF THESE NUTS ARE LOOSE, THE BRAKE PEDAL MAY BE LOW, THE ASSEMBLY MAY BE LOOSE, THE BRAKES MAY NOT RELEASE, AND IF THE NUTS BACK COMPLETELY OFF, BRAKING MAY BE LOST. ALSO FUME AND WATER INTRUSION TO THE PASSENGER COMPARTMENT CAN OCCUR.
Remedy: DEALERS WILL REPLACE ANY MISSING BRAKE BOOSTER TO BRAKE PEDAL ASSEMBLY NUTS AND TIGHTEN ALL FOUR (4) NUTS TO SPECIFIED TORQUE.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2
EA02030 · Engine Compartment Fires
Opened Oct 22, 2002 · Closed Mar 9, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:delivery; Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (3)
Fuel System, Gasoline:delivery
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
PE02050 · Engine Compartment Fires
Opened Jun 13, 2002 · Closed Oct 22, 2002
Status: closed (inferred from source dates) · Engine And Engine Cooling
No summary supplied.
2000 Buick Lesabre Problems, Complaints & Recalls | Skip That Year
Illustration