IllustrationVEHICLE EXPERIENCED FIRE, THE CAUSE OF THE FIRE WAS ACCIDENTAL, PART FAILURE, MALFUNCTION, THE FIRE ORIGINATED AT THE ENGINES FUELING SYSTEM ON THE INTAKE HOUSING SIDE, CLAIM 53-C681-096. *SLC
1997 Buick Lesabre
Owner reports · Recalls · Investigations
More warning signs than most Lesabre years
Owner complaints for the 1997 Buick Lesabre are substantially higher than the model-year median of 24.
About this comparison →How this year compares
Owner complaints by model year
Compare all Lesabre years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
50–25K
1225–50K
1850–75K
2175–100K
29100–150K
21150K+
106 reports with mileage · 288 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Engine And Engine Cooling. Review the 110 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 42 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Fuel System, Gasoline. Review the 37 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
26 crash reports31 fire reports20 injury reports
Fuel System, Gasoline complaints
37 reportsWHILE ATTEMPTING TO START THE VEHICLE THE ENGINE CAUGHT FIRE TOTALLY DESTROYING THE CAR. NLM THERE WAS RECALL ON THE UPPER INTAKE MANIFOLD.*JB AN INVESTIGATOR STATED THAT THE FIRE ORIGINATED WITHIN THE IGNITION OF VAPORS OF GASOLINE IN THE ENGINE COMPARTMENT OF THE VEHICLE, THEY STATED THAT IT SHOULD BE NOTED THAT THE CONDITI…
Read full complaint
WHILE ATTEMPTING TO START THE VEHICLE THE ENGINE CAUGHT FIRE TOTALLY DESTROYING THE CAR. NLM THERE WAS RECALL ON THE UPPER INTAKE MANIFOLD.*JB AN INVESTIGATOR STATED THAT THE FIRE ORIGINATED WITHIN THE IGNITION OF VAPORS OF GASOLINE IN THE ENGINE COMPARTMENT OF THE VEHICLE, THEY STATED THAT IT SHOULD BE NOTED THAT THE CONDITIONS DESCRIBED AT THE TIME OF THE FIRE ARE IN LINE WITH THE RECALL REGARDING THE UPPER INTAKE MANIFOLD. *SLC REFERENCED IN EA02-030
ENGINE CAUGHT ON FIRE WHILE TRYING TO START VEHICLE , VEHICLE WAS A TOTAL LOSS, AND MANUFACTURER WAS UNABLE TO DETECT ORGIN OF FIRE.*AK AAA DETECTED A HOT SPOT IN THE MANIFOLD AND THE FUEL LINE RUNS ALONG THE MANIFOLD, ALSO VEHICLE HAD AN INTAKE MANIFOLD LEAK, FIRE POSSIBLY FUEL RELATED. *SLC
INTAKE MANIFOLD REPLACED. RECALL ON THIS COMPONENT FOR 1997 BUICK LESABRE, BUT PER BUICK THIS VEHICLE WAS NOT AFFECTED BY RECALL.*AK
INTAKE MANIFOLD NEEDS TO BE REPLACED. RECALL ON THIS COMPONENT, BUT PER BUICK THIS VEHICLE WAS NOT AFFECTED BY RECALL. *AK THE INTAKE MANIFOLD FAILURE ALLOWED ANTIFREEZE INTO THE ENGINE. *YH
INTAKE MANIFOLD MALFUNCTIONED, CAUSING VEHICLE TO STALL AT HIGH SPEEDS. VEHICLE HAS BEEN REPAIRED BY A PRIVATE MECHANIC. DEALER WILL BE NOTIFIED.*AK
CONSUMER WAS STARTING VEHICLE WHEN A BROKEN GAS LINE CAUSED A FIRE, THE ADJUSTER STATED THAT THE REGULATOR LEAKED ONTO THE MANIFOLD AND CAUSED AN EXPLOSION, CLAIM 23-1276-311. *SLC
Official recalls
296V116000 · Fuel System, Gasoline:fuel Injection System
Jul 1, 1996
A BACKFIRE DURING ENGINE STARTING CAN CAUSE BREAKAGE OF THE UPPER INTAKE MANIFOLD.
Consequence & remedy
Consequence: THIS CONDITION CAN CAUSE A NO-START CONDITION AND POSSIBLY AN ENGINE COMPARTMENT FIRE.
Remedy: DEALERS WILL UPDATE THE POWERTRAIN CONTROL MODULE PROGRAMMING. UNTIL THE CAMPAIGN REPAIR IS MADE, THE VEHICLE HOOD SHOULD BE SHUT WHENEVER STARTING THE VEHICLE TO REDUCE THE CHANCE OF PERSONAL INJURY.
96V044000 · Seat Belts:front:buckle Assembly
Mar 5, 1996
THESE VEHICLES WERE ASSEMBLED WITH ONE OR MORE INCORRECT SAFETY BELT AND/OR SAFETY BELT BUCKLE ENDS. THIS DOES NOT CONFORM WITH THE REQUIREMENTS OF FMVSS NO. 209, "SEAT BELT ASSEMBLIES."
Consequence & remedy
Consequence: CONSEQUENCE OF NON-COMPLIANCE: IF AN INCORRECT PART IS USED, THE BELT MAY NOT LATCH PROPERLY, INCREASING THE RISK OF INJURY TO THE OCCUPANT SHOULD A VEHICLE CRASH OCCUR.
Remedy: DEALERS WILL INSPECT ALL FRONT AND REAR SAFETY BELT LATCH ENDS AND SAFETY BELT BUCKLES FOR CORRECT PARTS AND REPLACE ANY INCORRECT PARTS.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA02030 · Engine Compartment Fires
Opened Oct 22, 2002 · Closed Mar 9, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:delivery; Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (3)
Fuel System, Gasoline:delivery
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
PE02050 · Engine Compartment Fires
Opened Jun 13, 2002 · Closed Oct 22, 2002
Status: closed (inferred from source dates) · Engine And Engine Cooling
No summary supplied.