1999 Buick Century

INTAKE GASKET FAILED ON 3.1 ENGINE IN A 1999 BUICK CENTURY. THIS ENGINE HAS LESS THAN 55,000 MILES ON IT AT THE TIME OF FAILURE. IT APPEARS AS IF THERE ARE MANY OTHER COMPLAINTS FOR THE SAME ISSUE AND THE MANUFACTURER DENIES THAT THERE WAS FAULTY WORKMANSHIP INVOLVED. ESTIMATED COST OF REPAIR $700.00 ALSO SAME CAR WITH LESS THAN 20,000 MILES THE BOLT HOLDING THE LEFT FRONT CALIPER FELL OFF WHILE TRAVELING DOWN THE ROAD WITH MY DAUGHTER DRIVING (DRIVERS PERMIT) AND LOCKED UP THE LEFT FRONT WHEEL DAMAGING THE RIM. COST OF REPAIR $350.00. *JB

DT: THE CONSUMER OWNS A 1999 BUICK CENTURY. HE STATES THAT SIX MONTHS AFTER HE PURCHASED THE VEHICLE HE TOOK THE VEHICLE IN FOR A RECALL ON THE HEADLIGHTS. WHILE THE VEHICLE WAS THERE THEY MAINTENANCE THE VEHICLE AND FOUND THAT THE GAS FILLER PIPE HAD DETERIORATED AND THE COOLING SYSTEM INTAKE WAS LEAKING COOLANT. THIS VEHICLE ONLY HAS ABOUT 50,000 MILES. BOTH FRONT LOWER CONTROL ARM BUSHINGS HAD BLOWN OUT AND THEY HAD TO BE REPLACED ALSO. WYOMING VALLEY MOTORS PO BOX 1308 KINGSTON, PA 18704-0308. HE HAS SPOKEN WITH GM THEY TOLD HIM THEY WOULD GET BACK WITH HIM IN A COUPLE OF DAYS AND THEY DID NOT CONTACT HIM BACK. HE IS NOT AVAILABLE UNTIL AFTER 4:30. THEY TOLD HIM THE GAS FILLER PIPE WAS NORMAL FOR THE VEHICLE. HE SEEN A ARTICLE THAT SAID THEY HAD BEEN HAVING THIS PROBLEM WITH YEAR FOR THE COOLING SYSTEM. THEY ALSO SAID THE BUSHINGS WAS NORMAL WEAR ON A CAR ALSO. HE DID GO ONTO CARFAX AND IT DID NOT INDICATE ANY TIME OF PROBLEMS WITH THE VEHICLE. *JB *NM

THE INTAKE MANIFOLD WAS LEAKING ANTIFREEZE, WHICH COULD CAUSE THE VEHICLE TO OVERHEAT. MANUFACTURER WAS CONTACTED BY CONSUMER.*AK THE ENGINE LOCKED UP DUE TO LOSS OF COOLANT. THE WATER PUMP STARTED LEAKING AT THE SHAFT SEAL WITH LESS THAN 43000 MILES ON THE VEHICLE. A DIRTY, OILY SUBSTANCE WAS NOTICED IN THE RADIATOR NECK. *TC

CAR STARTED TO LEAK ANTI-FREEZE VERY SLOWLY. HAS THE DEXCOOL ANTIFREEZE. I CHECKED THE RADIATOR TO SEE IF IT WAS LOW, AND THE RADIATOR LOOKED AS THOUGH IT HAD LOTS OF RUST IN IT. SO I TOOK IT TO A LOCAL FIRESTONE STORE TO HAVE IT LOOKED AT, AND THEY FOUND THE LEAK AND PROCEEDED TO TELL ME THAT THIS WAS A COMMON OCCURRENCE IN GM VEHICLES AROUND THIS MODEL YEAR WITH THE 3.1 LITER ENGINE, THAT A MANIFOLD GASKET WOULD START TO LEAK, AND YOU EITHER GOT ANTIFREEZE LEAKING INTO THE OIL, OR AS IN MY CASE, THE OIL FROM THE ENGINE GOT INTO THE COOLING SYSTEM, HENCE INTO THE RADIATOR AND TURNED IT INTO "GUNK". THE PRICE TAG TO DO THE WORK WAS AROUND $700. SO I THOUGHT I WOULD CALL THE BUICK DEALER IN TOWN TO SEE WHAT THEY KNEW ABOUT THIS PROBLEM AND SEE WHAT THEY WOULD CHARGE TO FIX IT. I FOUND IT IRONIC THAT THE GENTLEMAN IN THE SERVICE DEPARTMENT KNEW EXACTLY WHAT I WAS TALKING ABOUT, SAID THEY THE PARTS ON HAND TO FIX IT AND QUOTED ME THE EXACT PRICE WITHOUT EVEN TAKING A BREATH. SEEMS THIS IS A RATHER COMMON OCCURRENCE WITH THESE ENGINES. WHICH LEADS ME TO BELIEVE THAT THIS IS SOME SORT OF MANUFACTURING DEFECT, AND THAT PERHAPS GM/THE MANUFACTURER SHOULD BE PICKING UP THE BILL FOR THIS FIX. THE SERVICE MAN AT THE FIRESTONE STORE SAID THE SAME THING, THAT THIS IS GETTING TO BE PRETTY COMMON WITH THESE CARS AND COULD RECITE THE NECESSARY WORK THAT NEEDED TO BE DONE TO FIX IT RIGHT OFF THE TOP OF HIS HEAD. SO I WOULD LIKE TO REGISTER MY COMPLAINT IN HOPES THAT SOMETHING COULD BE DONE TO RECTIFY THE SITUATION. THE CAR IS IN THE SHOP PRESENTLY BEING REPAIRED. THE HEAD GASKET AND MANIFOLD GASKETS NEED TO BE REPLACED, WHICH CONSTITUTES TEARING HALF THE ENGINE APART. ALSO THE OIL NEEDS TO BE CHANGED A COUPLE OF TIMES TO GET ANY COOLANT OUT OF THE ENGINE, AND OF COURSE THE RADIATOR NEEDS TO BE FLUSHED, CLEANED AND REFILLED. NO OLD PARTS WOULD BE AVAILABLE AS WHAT NEEDS TO BE REPLACED ARE GASKETS.*AK

DRIVING DOWN ROAD ONE DAY WHEN CAR OVERHEATED. ONE MECHANIC REPLACED THERMOSTAT BUT CONTINUED TO DO SAME. TOOK TO ANOTHER FACILITY WHO RAN DIAGNOSTIC TEST AND WAS TOLD THAT IT WAS THE R & R INTAKE MANIFOLD GASKET. CAR IS A 1999 BUICK CENTURY WITH ONLY 46,191 MILES. HAVE BEEN TOLD THE COST TO FIX PROBLEM IS APPROX. $700. WITH ALL OF THE OTHER IDENTICAL PROBLEMS OF OTHER OWNERS WHY HASN'T SOMETHING BEEN DONE WITH THIS PROBLEM? CONSUMER SHOULD NOT HAVE TO FOOT THE BILL FOR GM'S DEFECTIVE PARTS. THERE IS OBVIOUSLY SOMETHING WRONG WITH THE ENGINE DESIGN. HAD A BUICK REGAL BEFORE THIS AND IT IS STILL RUNNING WITH OVER 195,000 MILES. NO ENGINE COOLING SYSTEM PROBLEM WITH IT. *JB

I HAVE A 1999 BUICK CENTURY , I TOOK THE VEHICLE TO HAVE A RADIATOR FLUSH AND WAS ADVISED THAT I COULDN'T HAVE THIS JOB PERFORMED DUE TO A LEAK OR CRACK IN THE INTAKE GASKET. AT THIS TIME I WAS VERY SURPRISE TO SEE THE COMPLAINTS AND THERE IS NO RECALL. THIS IS OUTRAGEOUS THAT NO ONE SEEMS TO CARE THIS IS A VERY EXPENSIVE REPAIR AND SHOULD NOT BE THE RESPONSIBILITY OF THE CONSUMER TO REPLACE. THIS SHOULD'VE BEEN DONE BY GENERAL MOTORS. *NM

COOLING SYSTEM DEFECT IN 1999 BUICK CENTURY. COOLING SYSTEM IS BEING CONTAINMINATED BY BROWN SUBSTANCE IN SYSTEM, CAUSING THE SYSTEM TO OVERHEAT. REPORTED TO DEALER THREE TIMES. THEY HAVE A TSB OUT ON THIS, BUT NO CLUE ON WHAT IS CAUSING THIS. THEY HAVE INSPECTED THE VEHICLE THREE TIMES, FLUSHED THE SYSTEM, AND REPLACED THE RADIATOR CAP, BUT PROBLEM RECCURS. NOW IT IS GOING IN FOR THE FOUTH TIME. PROBLEM WAS NOT CORRECTED UNDER ORIGINAL WARRANTY, NOW THE EXTENDED WARRANTY THAT I PURCHASED IS ABOUT TO RUN OUT, YET HAVING THE SAME PROBLEM. IF THEY HAVE A TSB OUT ON THIS, WHY CAN'T THEY FIX THE PROBLEM ONCE AND FOREVER?*AK