Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
90–25K
2225–50K
3650–75K
575–100K
5100–150K
0150K+
77 reports with mileage · 14 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Steering. Review the 55 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Air Bags. Review the 14 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Electrical System. Review the 13 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
1 crash reports3 fire reports1 injury reports
What owners actually said
91 reports
Mileage unknown · Jun 28, 2021
Steering
During warm weather the steering will momentary stick while driving which requires additional force to overcome. This happens at all speeds but is more noticeable at highway speeds while trying to maintain vehicle in driving lane. There are numerous complaints of this on the NHTSA site. I have written to BMW North America abou…
Read full complaint
During warm weather the steering will momentary stick while driving which requires additional force to overcome. This happens at all speeds but is more noticeable at highway speeds while trying to maintain vehicle in driving lane. There are numerous complaints of this on the NHTSA site. I have written to BMW North America about this safety problem and mentioned the multitude of similar complaints but they refuse to address the problem and suggest I purchase a new steering column at $2500+!
NHTSA ODI #11422683
60,000 miles · Jul 29, 2020
Structure
THE CONVERTIBLE TOP ON THE 2006 Z4 BMW HAS A MECHANISM THAT RAISES AND LOWERS THAT FAILS. IT'S LOCATION IS SUCH THAT IT IS EXPOSED TO THE ELEMENTS. WHEN I BOUGHT MY CAR (USED)I WENT TO A BMW MECHANIC THAT TOLD ME THAT IF I DID HAVE HIM FIX IT IT WOULD HAPPEN AGAIN. TALKING TO OTHER BMW MECHANICS I GOT THE SAME INFO.
NHTSA ODI #11342167
46,000 miles · Jun 29, 2020
Steering
VEHICLE STEERING BECOMES "STICKY" AFTER VEHICLE HAS BEEN EXPOSED TO WARM TEMPERATURES. THIS CAUSES THE STEERING TO CENTER AND REQUIRE GREATER THAN USUAL FORCE TO OFF CENTER THE WHEEL, CAUSING THE CAR TO BE DIFFICULT TO CONTROL ESPECIALLY AT HIGHWAY SPEEDS.
NHTSA ODI #11331628
104,000 miles · Feb 12, 2020
Electrical System
WENT TO CHANGE MY HEADLIGHT BULB AND NOTICES ALL OF THE WIRES WERE BARE. THE SHEATHING AROUND THE WIRES HAVE ALL CORRODED. THIS IS FOR THE COMPLETE HEADLIGHT ASSEMBLY. EVERY SINGLE WIRE HAS CORRODED. SEEMS LIKE A FIRE HAZARD.
NHTSA ODI #11308882
Mileage unknown · Jan 17, 2020
Air Bags
ABOUT 9 YEARS (2015) AFTER PURCHASING VEHICLE THE AIRBAG WARNING LIGHT BEGAN ILLUMINATING CONSTANTLY. THE VEHICLE WAS PURCHASED NEW AND HAD APPROXIMATELY 55K MILES WHEN ISSUE BEGAN. VEHICLE HAS NEVER BEEN IN A MINOR OR MAJOR ACCIDENT. VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, BUT DIAGNOSIS COULD NOT BE DETERMINED. CONTACTED …
Read full complaint
ABOUT 9 YEARS (2015) AFTER PURCHASING VEHICLE THE AIRBAG WARNING LIGHT BEGAN ILLUMINATING CONSTANTLY. THE VEHICLE WAS PURCHASED NEW AND HAD APPROXIMATELY 55K MILES WHEN ISSUE BEGAN. VEHICLE HAS NEVER BEEN IN A MINOR OR MAJOR ACCIDENT. VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, BUT DIAGNOSIS COULD NOT BE DETERMINED. CONTACTED BMW ABOUT ISSUE, BUT WAS TOLD MY VEHICLE WAS NOT COVERED UNDER ANY OF THE AIRBAG RECALLS THEY'VE INITIATED. NO ACTION WAS TAKEN BY ME TO DETERMINE ROOT CAUSE AND CONTINUED TO UTILIZE VEHICLE WITH AIR BAG LIGHT ALWAYS ILLUMINATED. IN FEBRUARY 2018, RECEIVED A LETTER FROM BMW REGARDING WARRANTY EXTENSION TO 15 YEARS FOR FRONT PASSENGER SEAT OCCUPANCY MAT (OC3) FOR AIR BAG SYSTEM. BELIEVING AIRBAG ISSUE WAS DUE TO OC3 MAT, BROUGHT MY VEHICLE TO LOCAL BMW DEALER TO GET REPAIR. BMW DIAGNOSED THE ISSUE AS A "RESTRAINT PASS LOWER BELT UNIT FAULTING" AND NOT OC3 MAT. HAD REPAIR PERFORMED SUCCESSFULLY.
NHTSA ODI #11300223
95,000 miles · Oct 9, 2019
Electrical SystemExterior Lighting
THE INSULATED WIRING INSIDE THE HEADLIGHT HOUSING HAS HARDENED AND THE INSULATION HAD CRACKED AND FALLEN OFF. THIS ALLOWS THE WIRES TO SHORT AND CAUSES UNEXPECTED FAILURE OF THE HEADLIGHTS, PARKING LIGHTS, TURN SIGNALS AND OTHER ITEMS INSIDE THE HEADLIGHT HOUSING. THE LIGHTS FAILED UNEXPECTEDLY AND INTERMITTENTLY.
NHTSA ODI #11267326
103,000 miles · Aug 27, 2019
Steering
VERY STICKY STEERING, DANGEROUS IN HOT WEATHER, THIS HAPPENS AT ALL SPEEDS. IT SOMETIMES REQUIRES SIGNIFICANT EFFORT TO CORRECT IT. THIS IS A SERIOUS SAFETY ISSUE.
NHTSA ODI #11246701
15 miles · Jul 8, 2019
Electrical SystemEngineFuel/propulsion System
MY BATTERY IS IN GOOD CONDITION BUT I CAN'T START THE ENGINE.-700KM OIL SERVICE WARNING LIGHT DISPLAY ON MY DASH.FUEL PUMP IS WORKING.THEM OPEN THE KEY LIKE THAT SOUND GAP GAP IS COME OUT...PLS HELP ME...
NHTSA ODI #11230059
70,500 miles · Mar 31, 2019
Steering
STEERING APPEARS TO BE STICKING OR STAYING AT A CERTAIN POINT IN THE STEERING RADIUS. I ALMOST VEERED INTO ONCOMING INTERSTATE TRAFFIC. I COMPENSATED IMMEDIATELY, BUT IT RELEASED ITS "STICK" AND TURN TO MUCH AND ALMOST VEERED INTO TRAFFIC I WAS IN. VERY SCARY, VERY DANGEROUS. THERE WAS A POSSIBILITY OF MUCH INJURY OR DEATH BECAU…
Read full complaint
STEERING APPEARS TO BE STICKING OR STAYING AT A CERTAIN POINT IN THE STEERING RADIUS. I ALMOST VEERED INTO ONCOMING INTERSTATE TRAFFIC. I COMPENSATED IMMEDIATELY, BUT IT RELEASED ITS "STICK" AND TURN TO MUCH AND ALMOST VEERED INTO TRAFFIC I WAS IN. VERY SCARY, VERY DANGEROUS. THERE WAS A POSSIBILITY OF MUCH INJURY OR DEATH BECAUSE OF THIS ISSUE. BAD
NHTSA ODI #11192705
32,000 miles · Oct 9, 2018
Steering
RECURRING PROBLEM WITH STEERING INPUT EFFORT WHEN DRIVING ON HIGHWAYS. THE STEERING STICKS WHEN IN THE CENTER POSITION. RESISTANCE IS FELT AND IS DIFFICULT TO RETURN BACK TO THE CENTER POSITION. STICKING PROBLEM SEEMS WORSE AT HIGHER SPEEDS AND WITH WARM OUTSIDE TEMPERATURE ABOVE 80 DEGREES. THE FASTER THE SPEED, THE MORE EFFO…
Read full complaint
RECURRING PROBLEM WITH STEERING INPUT EFFORT WHEN DRIVING ON HIGHWAYS. THE STEERING STICKS WHEN IN THE CENTER POSITION. RESISTANCE IS FELT AND IS DIFFICULT TO RETURN BACK TO THE CENTER POSITION. STICKING PROBLEM SEEMS WORSE AT HIGHER SPEEDS AND WITH WARM OUTSIDE TEMPERATURE ABOVE 80 DEGREES. THE FASTER THE SPEED, THE MORE EFFORT NEEDED TO OVERCOME THE DETENT RESISTANCE, TO THE POINT THAT IT BECOMES EASY TO OVERSTEER THE CAR. THIS CAN BE REAL SCARY DURING AVOIDANCE MANEUVERS AND QUICK LANE CHANGES.
BMW of North America, LLC (BMW) is recalling certain 2008-2013 1 Series Coupe (128i); 2007-2013 3 Series Coupe (328i, 328xi, 328i xDrive); 2007-2010 X3 SAV (X3 3.0si, X3 xDrive30i); 2008-2013 1 Series Convertible (128i); 2006-2011 3 Series Sedan (325i, 325xi, 328i, 328xi, 328i xDrive, 330i, 330xi); 2006-2012 3 Series Wagon (328i, 328i xDrive); 2007-2013 3 Series Convertible (328i); 2006-2010 5 Series Sedan (525i, 525xi, 528i, 528xi, 530i, 530xi); 2006-2007 5 Series Wagon (530xi); 2007-2010 X5 SAV (X5 3.0si, X5 xDrive30i); 2006-2008 Z4 Coupe (Z4 3.0si); and 2006-2011 Z4 Roadster (Z4 3.0i, Z4 3.0si, Z4 sDrive30i) vehicles. The heater for the positive crankcase ventilation (PCV) valve may short circuit.
Consequence & remedy
Consequence: An electrical short can cause the PCV valve heater to overheat, increasing the risk of a fire while driving or, soon after driving when parked.
Remedy: This recall supersedes and expands previous NHTSA recalls 17V-683 and 19V-273. Dealers will install an electrical wiring harness with fuse protection for the PCV Valve heater in potentially affected vehicles, free of charge. This recall supersedes and expands previous NHTSA recalls 17V-683 and 19V-273. Vehicles previously repaired under the prior recalls will need to come back for the new recall remedy. The remedy is currently being developed. Interim owner notification letters informing owners of the safety risk were mailed on April 1, 2022. Owner notification letters were mailed on July 22, 2022. Owners may contact BMW customer service at 1-800-525-7417.
BMW of North America, LLC (BMW) is recalling certain 2006 525i, 525xi, 530i, 530xi, 530xi Sports Wagon, 325i, 325xi, 325xi Sports Wagon, 330i, 330xi, Z4 3.0i and Z4 3.0si vehicles. The heater for the positive crankcase ventilation (PCV) valve may short circuit.
Consequence & remedy
Consequence: An electrical short can cause the parts within the PCV valve to melt, increasing the risk of a fire, even when the vehicle is not in use.
Remedy: BMW will notify owners, and dealers will replace the PCV valve heater, free of charge. The recall began May 30, 2019. Owners may contact BMW customer service at 1-800-525-7417. Note: This recall is an expansion to recall 17V-683.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
EA08001 · BMW Airbag Light Illumination
Opened Jan 4, 2008 · Closed Dec 31, 2008
Status: closed (inferred from source dates) · Air Bags; Air Bags:frontal; Air Bags:frontal:sensor/control MODULE-INACTIVE
BMW IS CONDUCTING A SAFETY RECALL CAMPAIGN ON APPROXIMATELY 200,000 MY04 THROUGH MY06 SUBJECT VEHICLES BUILT THROUGH 11/30/05 TO CORRECT THE FRONT PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT. THE SPECIFIC VEHICLES INCLUDED IN THE RECALL AREMY04- 06/ 5-SERIES WITH STANDARD AND SPORT SEATS, MY04-06/ X3-SERIES AND MY06/ 3-SERIES WITH SPORT SEATS. IN ADDITION, BMW WILL EXTEND THE WARRANTY COVERAGE OF THE PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT TO 10-YEAR/UNLIMITED MILEAGE ON APPROXIMATELY 120,000 REMAINING MY04-06 SUBJECT VEHICLES BUILT THROUGH 11/30/05. THE SPECIFIC VEHICLES INCLUDED IN THE EXTENDED WARRANTY ARE MY 06/ 6 SERIES, MY 06/ 3-SERIES WITH STANDARD SEATS, MY04-05/ Z4, MY04-06/ 7 SERIES, MY 06/ X5, AND MY04-06/ 5-SERIES WITH COMFORT SEATS.THE AVERAGE FREQUENCY OF FAILURES AMONG THE EXTENDED WARRANTY GROUPS WAS LESS THAN 1/7TH OF THE RECALL VEHICLE GROUPS.PLEASE SEE BMW'S 08V-384 RECALL NOTIFICATION FOR FURTHER DETAILSDEPENDING ON SEAT CONFIGURATION AND VEHICLE GEOMETRY, THE OCCUPANT DETECTION MAT CAN FATIGUE DURING USE DEPENDING ON THE MANNER AND FREQUENCY OF THE FRONT PASSENGER'S ENTRY AND EXIT.SPECIFICALLY, OVER TIME, MICRO-CRACKS COULD DEVELOP IN THE SIDE FLANKS OF THE MAT CAUSING A BROKEN CIRCUIT.A BROKENCIRCUIT CAN LEAD TO THE DEACTIVATION OF THE PASSENGER AIR BAG AND THE ILLUMINATION OF BOTH THE AIR BAG WARNING LIGHT AND THE PASSENGER AIR BAG LIGHT.
Additional source detail variants (3)
Air Bags
BMW IS CONDUCTING A SAFETY RECALL CAMPAIGN ON APPROXIMATELY 200,000 MY04 THROUGH MY06 SUBJECT VEHICLES BUILT THROUGH 11/30/05 TO CORRECT THE FRONT PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT. THE SPECIFIC VEHICLES INCLUDED IN THE RECALL AREMY04- 06/ 5-SERIES WITH STANDARD AND SPORT SEATS, MY04-06/ X3-SERIES AND MY06/ 3-SERIES WITH SPORT SEATS. IN ADDITION, BMW WILL EXTEND THE WARRANTY COVERAGE OF THE PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT TO 10-YEAR/UNLIMITED MILEAGE ON APPROXIMATELY 120,000 REMAINING MY04-06 SUBJECT VEHICLES BUILT THROUGH 11/30/05. THE SPECIFIC VEHICLES INCLUDED IN THE EXTENDED WARRANTY ARE MY 06/ 6 SERIES, MY 06/ 3-SERIES WITH STANDARD SEATS, MY04-05/ Z4, MY04-06/ 7 SERIES, MY 06/ X5, AND MY04-06/ 5-SERIES WITH COMFORT SEATS.THE AVERAGE FREQUENCY OF FAILURES AMONG THE EXTENDED WARRANTY GROUPS WAS LESS THAN 1/7TH OF THE RECALL VEHICLE GROUPS.PLEASE SEE BMW'S 08V-384 RECALL NOTIFICATION FOR FURTHER DETAILSDEPENDING ON SEAT CONFIGURATION AND VEHICLE GEOMETRY, THE OCCUPANT DETECTION MAT CAN FATIGUE DURING USE DEPENDING ON THE MANNER AND FREQUENCY OF THE FRONT PASSENGER'S ENTRY AND EXIT.SPECIFICALLY, OVER TIME, MICRO-CRACKS COULD DEVELOP IN THE SIDE FLANKS OF THE MAT CAUSING A BROKEN CIRCUIT.A BROKENCIRCUIT CAN LEAD TO THE DEACTIVATION OF THE PASSENGER AIR BAG AND THE ILLUMINATION OF BOTH THE AIR BAG WARNING LIGHT AND THE PASSENGER AIR BAG LIGHT.
Air Bags:frontal
BMW IS CONDUCTING A SAFETY RECALL CAMPAIGN ON APPROXIMATELY 200,000 MY04 THROUGH MY06 SUBJECT VEHICLES BUILT THROUGH 11/30/05 TO CORRECT THE FRONT PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT. THE SPECIFIC VEHICLES INCLUDED IN THE RECALL AREMY04- 06/ 5-SERIES WITH STANDARD AND SPORT SEATS, MY04-06/ X3-SERIES AND MY06/ 3-SERIES WITH SPORT SEATS. IN ADDITION, BMW WILL EXTEND THE WARRANTY COVERAGE OF THE PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT TO 10-YEAR/UNLIMITED MILEAGE ON APPROXIMATELY 120,000 REMAINING MY04-06 SUBJECT VEHICLES BUILT THROUGH 11/30/05. THE SPECIFIC VEHICLES INCLUDED IN THE EXTENDED WARRANTY ARE MY 06/ 6 SERIES, MY 06/ 3-SERIES WITH STANDARD SEATS, MY04-05/ Z4, MY04-06/ 7 SERIES, MY 06/ X5, AND MY04-06/ 5-SERIES WITH COMFORT SEATS.THE AVERAGE FREQUENCY OF FAILURES AMONG THE EXTENDED WARRANTY GROUPS WAS LESS THAN 1/7TH OF THE RECALL VEHICLE GROUPS.PLEASE SEE BMW'S 08V-384 RECALL NOTIFICATION FOR FURTHER DETAILSDEPENDING ON SEAT CONFIGURATION AND VEHICLE GEOMETRY, THE OCCUPANT DETECTION MAT CAN FATIGUE DURING USE DEPENDING ON THE MANNER AND FREQUENCY OF THE FRONT PASSENGER'S ENTRY AND EXIT.SPECIFICALLY, OVER TIME, MICRO-CRACKS COULD DEVELOP IN THE SIDE FLANKS OF THE MAT CAUSING A BROKEN CIRCUIT.A BROKENCIRCUIT CAN LEAD TO THE DEACTIVATION OF THE PASSENGER AIR BAG AND THE ILLUMINATION OF BOTH THE AIR BAG WARNING LIGHT AND THE PASSENGER AIR BAG LIGHT.
Air Bags:frontal:sensor/control MODULE-INACTIVE
BMW IS CONDUCTING A SAFETY RECALL CAMPAIGN ON APPROXIMATELY 200,000 MY04 THROUGH MY06 SUBJECT VEHICLES BUILT THROUGH 11/30/05 TO CORRECT THE FRONT PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT. THE SPECIFIC VEHICLES INCLUDED IN THE RECALL AREMY04- 06/ 5-SERIES WITH STANDARD AND SPORT SEATS, MY04-06/ X3-SERIES AND MY06/ 3-SERIES WITH SPORT SEATS. IN ADDITION, BMW WILL EXTEND THE WARRANTY COVERAGE OF THE PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT TO 10-YEAR/UNLIMITED MILEAGE ON APPROXIMATELY 120,000 REMAINING MY04-06 SUBJECT VEHICLES BUILT THROUGH 11/30/05. THE SPECIFIC VEHICLES INCLUDED IN THE EXTENDED WARRANTY ARE MY 06/ 6 SERIES, MY 06/ 3-SERIES WITH STANDARD SEATS, MY04-05/ Z4, MY04-06/ 7 SERIES, MY 06/ X5, AND MY04-06/ 5-SERIES WITH COMFORT SEATS.THE AVERAGE FREQUENCY OF FAILURES AMONG THE EXTENDED WARRANTY GROUPS WAS LESS THAN 1/7TH OF THE RECALL VEHICLE GROUPS.PLEASE SEE BMW'S 08V-384 RECALL NOTIFICATION FOR FURTHER DETAILSDEPENDING ON SEAT CONFIGURATION AND VEHICLE GEOMETRY, THE OCCUPANT DETECTION MAT CAN FATIGUE DURING USE DEPENDING ON THE MANNER AND FREQUENCY OF THE FRONT PASSENGER'S ENTRY AND EXIT.SPECIFICALLY, OVER TIME, MICRO-CRACKS COULD DEVELOP IN THE SIDE FLANKS OF THE MAT CAUSING A BROKEN CIRCUIT.A BROKENCIRCUIT CAN LEAD TO THE DEACTIVATION OF THE PASSENGER AIR BAG AND THE ILLUMINATION OF BOTH THE AIR BAG WARNING LIGHT AND THE PASSENGER AIR BAG LIGHT.
2006 BMW Z4 Problems, Complaints & Recalls | Skip That Year
Illustration