Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
680–25K
12925–50K
10550–75K
4275–100K
26100–150K
2150K+
372 reports with mileage · 39 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Steering. Review the 378 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Air Bags. Review the 18 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Electrical System. Review the 14 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
1 crash reports2 fire reports0 injury reports
What owners actually said
411 reports
39,000 miles · Oct 1, 2012
Electronic Stability Control (esc)Steering
I HAVE A 2004 Z4 THAT I PURCHASED LAST AUGUST USED. I RARELY DROVE THE CAR AND KEPT IT MAINLY FOR LEISURE UNTIL THIS PAST JULY. THIS JULY, ON THE DRIVE FROM WARNER ROBINS, GA TO HILTON HEAD, SC, I NOTICED THE STEERING WOULD STICK AND I HAD TO USE FORCE TO GET IT BACK ALIGNED WITH THE ROAD. SINCE THAT TIME EACH DAY WHEN I LE…
Read full complaint
I HAVE A 2004 Z4 THAT I PURCHASED LAST AUGUST USED. I RARELY DROVE THE CAR AND KEPT IT MAINLY FOR LEISURE UNTIL THIS PAST JULY. THIS JULY, ON THE DRIVE FROM WARNER ROBINS, GA TO HILTON HEAD, SC, I NOTICED THE STEERING WOULD STICK AND I HAD TO USE FORCE TO GET IT BACK ALIGNED WITH THE ROAD. SINCE THAT TIME EACH DAY WHEN I LEAVE WORK AFTER THE CAR HAS BEEN PARKED ALL DAY IN THE HEAT IT DOES THE SAME THING. ITS ALMOST AS IF THE CAR IS TRACKING. NORMALLY MY SPEED DOES NOT EXCEED 40 MPH. I HAVE HAD THE TIRES CHECKED, THEY ARE NEW RUN FLAT TIRES, NO PROBLEM, I HAVE HAD IT ALIGNED AND I AM STILL HAVING PROBLEMS WITH STEERING WHEN TEMPERATURES EXCEED 85 DEGREES. IT DOES NOT DO THIS IN THE MORNING WHEN THE TEMPERATURE IS BELOW 80. IT IS SOMETIMES SO HARD TO STEER THAT IT CREATES A HAZARD AS I HAVE TO FIGHT TO CORRECT AND THAN IT PULLS RADICALLY TO THE RIGHT TO OVERCORRECT. THIS HAS AT TIMES PUT ME IN A VERY HAZARDOUS AND DANGEROUS CONDITION WITH TRAFFIC. *TR
NHTSA ODI #10478149
38,300 miles · Sep 28, 2012
Air Bags
AIRBAG DEPLOYMENT WHILE VEHICLE IN MOTION. 9/27/2012 APPROX. 6:20PM HAD ONE OF THE PASSENGER SIDE AIRBAGS DEPLOY WITHOUT WARNING WHILE VEHICLE WAS BEING DRIVEN. NO ACCIDENT INVOLVED, NO STRIKING CURB, NO POTHOLE...NOTHING UNTOWARD. BMW DEALER NOW HAS VEHICLE TO DETERMINE CAUSE OF MALFUNCTION. I HAVE REQUESTED THAT BMW NORTH…
Read full complaint
AIRBAG DEPLOYMENT WHILE VEHICLE IN MOTION. 9/27/2012 APPROX. 6:20PM HAD ONE OF THE PASSENGER SIDE AIRBAGS DEPLOY WITHOUT WARNING WHILE VEHICLE WAS BEING DRIVEN. NO ACCIDENT INVOLVED, NO STRIKING CURB, NO POTHOLE...NOTHING UNTOWARD. BMW DEALER NOW HAS VEHICLE TO DETERMINE CAUSE OF MALFUNCTION. I HAVE REQUESTED THAT BMW NORTH AMERICA HAVE A REPRESENTATIVE INSPECT THE VEHICLE TO ASSIST IN DETERMINING CAUSE OF THIS MALFUNCTION AND TO PASS ALONG HIS FINDINGS TO THE APPROPRIATE INDIVIDUALS AT BMW. HAD ONE OF THE DRIVER'S SIDE AIRBAGS MALFUNCTIONED AND DEPLOYED WHILE THIS VEHICLE WAS BEING DRIVEN, THE RESULTS COULD HAVE EASILY BEEN CATASTROPHIC! *TR
NHTSA ODI #10477419
3,700 miles · Sep 25, 2012
Steering
I BOUGHT THIS CAR BRAND NEW. IT CURRENTLY HAS ONLY 39K MILES ON IT RIGHT NOW (2012) SO ONE CAN EASILY SEE THAT I DRIVE THE CAR ONLY FOR LEISURE/PLEASURE. I LIVE IN UPSTATE NY SO CAN ONLY DRIVE THE CAR SEASONALLY. I INITIALLY THOUGHT THE STICKING/NOTCHING WAS DUE TO THE POOR RUN-FLAT TIRES (WHICH ALWAYS SEEMED TO SET OFF THE DA…
Read full complaint
I BOUGHT THIS CAR BRAND NEW. IT CURRENTLY HAS ONLY 39K MILES ON IT RIGHT NOW (2012) SO ONE CAN EASILY SEE THAT I DRIVE THE CAR ONLY FOR LEISURE/PLEASURE. I LIVE IN UPSTATE NY SO CAN ONLY DRIVE THE CAR SEASONALLY. I INITIALLY THOUGHT THE STICKING/NOTCHING WAS DUE TO THE POOR RUN-FLAT TIRES (WHICH ALWAYS SEEMED TO SET OFF THE DASHBOARD SENSOR THAT THERE WAS NOT ENOUGH AIR IN THEM AND THEN PERHAPS AN ALIGNMENT ISSUE. THIS IS MY FIRST BMW, SO I THOUGHT THAT IT MIGHT BE ATTRIBUTED TO BEING MORE DIFFICULT TO CONTROL (EVEN AT LOWER SPEEDS LIKE 35-40MPH) BECAUSE IT WAS A PERFORMANCE CAR. I COMPLAINED TO THE DEALER BUT THEY CLAIMED THEY HAD "NEVER HEARD OF SUCH A PROBLEM," AND IT "WASN'T HAPPENING" FOR THEM. SO YET ANOTHER YEAR WOULD PASS AND THE CAR WOULD BE STORED FOR THE WINTER. WITH SUCH LIMITED TIME TO DRIVE THE CAR, I OVERLOOKED THE "NOTCHING" OF THE STEERING.... UNTIL THIS YEAR WHEN THERE WERE NO MORE POSSIBLE EXCUSES! I REPLACED ALL 4 RUN FLAT TIRES WITH ALL-SEASON RADIALS, HAD THE CAR COMPLETELY ALIGNED, CONVINCED THAT THIS WOULD SOLVE MY PROBLEM. I WAS VERY WRONG! I WAS AND AM SHOCKED THAT BMW WOULD ALLOW 14+ PAGES OF COMPLAINTS DATING BACK TO 2005 WITHOUT DOING A RECALL ON THIS MATTER!! DOES A LIFE OR LIVES HAVE TO BE DESTROYED DUE TO SOMETHING CATASTROPHIC HAPPENING WITH THE STEERING BEFORE BMW TAKES ACTION? THIS IS THE SUPPOSED "ULTIMATE DRIVING MACHINE" THAT I DREAMED OF HAVING FOR DECADES. I'M OUTRAGED TO LEARN THAT THE PRESTIGIOUS BMW COMPANY DOES NOT SEEM TO CARE MUCH ABOUT ITS CUSTOMERS SAFETY AND WELL BEING. I WOULD LIKE TO BE CONTACTED BY NHTSA AS WELL AS BMW AND WILL CONTINUE TO PURSUE THIS MATTER UNTIL I AND ALL OF US THAT ARE EXPERIENCING THESE PROBLEMS ARE GIVEN THE RECALL AND RESOLUTION TO THE MECHANICAL PROBLEM THAT WE DESERVE. *TR
NHTSA ODI #10477065
42,000 miles · Sep 8, 2012
Steering
EVER SINCE I BOUGHT MY 04 BMW Z4 AT 42,000 MILES THE STEERING I NOTCHY, AND STICKY TOOK BACK TO DEALER AND THEY DONT ADMIT THERE IS A PROBLEM. HAVE LOOKED UP ON INTERNET AND IT SEEMS TO BE A COMMON WELL KNOWN PROBLEM WITH THE CAR. *TR
NHTSA ODI #10474352
62,375 miles · Sep 5, 2012
Steering
AS I BACKED OUT OF PARKING SPACE, POWER ASSISTED STEERING FAILED. I MANAGED TO DRIVE VEHICLE WITH MUCH INCREASED STEERING EFFORT. IT IS DOUBTFUL THAT MY WIFE COULD HAVE MANAGED TO DRIVE. VEHICLE WAS TOWED TO DEALER WHERE THE STEERING COLUMN IS BEING REPLACED. *TR
NHTSA ODI #10473910
36,000 miles · Aug 13, 2012
Steering
STEERING STICKS IN THE AFTERNOON, WHEN OUTSIDE IS HOT AROUND 90F. I NOTICED THIS CONDITION THIS SUMMER WHEN DROVE THE CAR AFTER WORK. THE CAR HAD ABOUT 38000MI. ON IT. THE STEERING WHEEL LITERATELY FEELS STUCK IN A POSITION AND TAKES ABNORMAL AMOUNT OF EFFORT TO TURN/CHANGE DIRECTION THEN IT'S LIKE IT JUST SUDDENLY RELEASES AND …
Read full complaint
STEERING STICKS IN THE AFTERNOON, WHEN OUTSIDE IS HOT AROUND 90F. I NOTICED THIS CONDITION THIS SUMMER WHEN DROVE THE CAR AFTER WORK. THE CAR HAD ABOUT 38000MI. ON IT. THE STEERING WHEEL LITERATELY FEELS STUCK IN A POSITION AND TAKES ABNORMAL AMOUNT OF EFFORT TO TURN/CHANGE DIRECTION THEN IT'S LIKE IT JUST SUDDENLY RELEASES AND CAUSES YOU TO OVER-STEER THE CAR IT FEELS UNSAFE DRIVING ESPECIALLY IN TRAFFIC OR DRIVING CLOSE TO A HWY BARRIER/CONSTRUCTION ZONE ETC.. I HAD TO FORCE TO CHANGE DIRECTION AND THE CAR WOULD DART DUE TO HAVING TO OVERCOMPENSATE FOR THE STUCK CONDITION. I KNOW THERE IS PROBLEM WITH THE STEERING, BUT NOT SURE WHAT PARTICULAR CAUSING THE PROBLEM, MY BEST GUESS IS THE EPS SYSTEM. I HAVE BEEN READING THE FORUMS AND BLOGS AND THERE ARE MANY PEOPLE EXPERIENCING THE SAME PROBLEMS WITH 2003-2005 BMW Z4'S SO I AM ADDING MINE TO THE LIST. SINCE THIS IS A SAFETY (SAFETY! SAFETY!) ISSUE, I BELIEVE/WISH BMW SHOULD STEP UP AND RECALL OR TAKE CARE OF THIS APPARENT DESIGN FLAW WITHIN THE STEERING SYSTEM. THESE CARS BECOME UNSAFE TO DRIVE WHEN THIS CONDITION ARISES. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
NHTSA ODI #10470470
52,185 miles · Jul 18, 2012
Steering
STEERING STICKS WHEN OUTSIDE TEMPERATURES ARE HOT 90DEG+. I NOTICED THIS CONDITION LAST YEAR IN THE SUMMER MONTHS EVERY TIME I DROVE THE CAR IN THE HEAT (N. TEXAS SUMMER) THE CAR HAD ABOUT 39000MI. ON IT. THE STEERING WHEEL LITERATELY FEELS STUCK IN A POSITION AND TAKES ABNORMAL AMOUNT OF EFFORT TO TURN/CHANGE DIRECTION THEN IT'…
Read full complaint
STEERING STICKS WHEN OUTSIDE TEMPERATURES ARE HOT 90DEG+. I NOTICED THIS CONDITION LAST YEAR IN THE SUMMER MONTHS EVERY TIME I DROVE THE CAR IN THE HEAT (N. TEXAS SUMMER) THE CAR HAD ABOUT 39000MI. ON IT. THE STEERING WHEEL LITERATELY FEELS STUCK IN A POSITION AND TAKES ABNORMAL AMOUNT OF EFFORT TO TURN/CHANGE DIRECTION THEN IT'S LIKE IT JUST SUDDENLY RELEASES AND CAUSES YOU TO OVER-STEER THE CAR IT FEELS UNSAFE DRIVING ESPECIALLY IN TRAFFIC OR DRIVING CLOSE TO A HWY BARRIER/CONSTRUCTION ZONE ETC.. MY WIFE STARTED DRIVING THE CAR TODAY AND SAID THE STEERING FELT LIKE IT WAS STICKING, AND THAT SHE HAD TO USE CONSIDERABLE FORCE TO CHANGE DIRECTION AND THE CAR WOULD DART DUE TO HAVING TO OVERCOMPENSATE FOR THE STUCK CONDITION, SHE SAID IT SCARED HER. BEST DESCRIPTION I CAN GIVE IS TO COMPARE THE STEERING TO AN ELECTRICAL SWITCH E.G. (FAN BLOWER SWITCH) THAT HAS A DETENTE OR CLICK BETWEEN THE SPEEDS AND HOW IT TAKES ADDITIONAL EFFORT TO CHANGE FROM ONE SPEED TO ANOTHER. I HAVE BEEN READING THE FORUMS AND BLOGS AND THERE ARE MANY PEOPLE EXPERIENCING THE SAME PROBLEMS WITH 2003-2005 BMW Z4'S SO I AM ADDING MINE TO THE LIST. SINCE THIS IS A SAFETY ISSUE I BELIEVE BMW SHOULD STEP UP AND RECALL OR TAKE CARE OF THIS APPARENT DESIGN FLAW WITHIN THE STEERING SYSTEM. THESE CARS BECOME UNSAFE TO DRIVE WHEN THIS CONDITION ARISES. *TR
NHTSA ODI #10466534
10,000 miles · Jul 16, 2012
Steering
TL* THE CONTACT OWNS A 2004 BMW Z4. THE CONTACT STATED THAT THE STEERING WHEEL DID NOT AUTOMATICALLY RETURN TO THE STRAIGHT POSITION AFTER COMPLETING TURNS. THE CONTACT HAD TO MANUALLY TURN THE STEERING WHEEL STRAIGHT AFTER TURNING AT ALL SPEEDS. THE FAILURE ONLY OCCURRED WHEN THE WEATHER CONDITIONS PRODUCED TEMPERATURES OF AT L…
Read full complaint
TL* THE CONTACT OWNS A 2004 BMW Z4. THE CONTACT STATED THAT THE STEERING WHEEL DID NOT AUTOMATICALLY RETURN TO THE STRAIGHT POSITION AFTER COMPLETING TURNS. THE CONTACT HAD TO MANUALLY TURN THE STEERING WHEEL STRAIGHT AFTER TURNING AT ALL SPEEDS. THE FAILURE ONLY OCCURRED WHEN THE WEATHER CONDITIONS PRODUCED TEMPERATURES OF AT LEAST SEVENTY FIVE DEGREES. THE VEHICLE WAS NOT TAKEN TO HAVE THE FAILURE DIAGNOSED OR REPAIRED. THE MANUFACTURER OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS 10,000.
NHTSA ODI #10465765
20,000 miles · Jun 4, 2012
Steering
THE STEERING WHEEL STUCK IN ONE POSITION AND NEEDED UNUSUAL EFFORT TO CONTINUE TO STEER THE CAR IN THE PROPER DIRECTION. THIS STEERING PROBLEM OCCURS WHEN THE WEATHER IS WARM AND SUNNY AND THE CAR IS PARKED OUTSIDE. THIS IS AN ONGOING PROBLEM. I UNDERSTAND THAT THIS CONDITION IS PECULIAR TO BMW Z4'S MANUFACTURED AND SOLD BETWEEN…
Read full complaint
THE STEERING WHEEL STUCK IN ONE POSITION AND NEEDED UNUSUAL EFFORT TO CONTINUE TO STEER THE CAR IN THE PROPER DIRECTION. THIS STEERING PROBLEM OCCURS WHEN THE WEATHER IS WARM AND SUNNY AND THE CAR IS PARKED OUTSIDE. THIS IS AN ONGOING PROBLEM. I UNDERSTAND THAT THIS CONDITION IS PECULIAR TO BMW Z4'S MANUFACTURED AND SOLD BETWEEN 2003 AND 2005. OBVIOUSLY BMW RECTIFIED THE PROBLEM ON THE 2006 MODELS. THE STEERING IS ELECTRIC STEERING. MY PROBLEM IS SERIOUS,I WILL NOT ALLOW MY WIFE TO DRIVE THIS CAR. SUMMER IS UPON US AND PROBLEM WILL AGAIN MANIFEST ITSELF BECAUSE OF SUMMER TEMPS. BMW KNOWS OF THIS MALFUNCTION BUT STONE WALLS EFFORTS TO GET THIS DANGEROUS CONDITION CORRECTED. THANK YOU *TR
NHTSA ODI #10460551
24,000 miles · May 31, 2012
Steering
STEERING SEEMS TO LOCK IN A POSITION. TAKES EFFORT TO MOVE WHEEL TO A NEUTRAL POSITION. HAPPENS WHEN THE VEHICLE HAS BEEN WARMED. DOES NOT OCCUR WHEN FIRST DRIVEN. *TR
ON CERTAIN PASSENGER VEHICLES, UNDER CERTAIN ENVIRONMENTAL CONDITIONS, A VAPOR LOCK IN THE FUEL PUMP COULD OCCUR CAUSING THE ENGINE TO STALL. IF THIS WERE TO HAPPEN, THE ENGINE WOULD NOT BE ABLE TO BE RESTARTED FOR APPROXIMATELY 15 TO 20 MINUTES.
Consequence & remedy
Consequence: IF STALLING WERE TO OCCUR, THE DRIVER WOULD BE UNABLE TO MAINTAIN VEHICLE SPEED OR ACCELERATE, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSTALL A RESISTOR IN THE ELECTRICAL LINE POWERING THE FUEL PUMP IN ORDER TO PREVENT AN OCCURRENCE OF VAPOR LOCK. THE RECALL BEGAN MAY 11, 2004. OWNERS SHOULD CONTACT BMW AT 1-800-831-1117.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2
PE10020 · Sticky Steering
Opened Jun 28, 2010 · Closed Jun 28, 2011
Status: closed (inferred from source dates) · Steering; Steering:column; Steering:electric Power Assist System
ODI has evaluated the sticky steering condition, which included reviews of complaints and warranty claims, interviews and surveys of owners of complaint vehicles, road tests of complaint vehicles, and a review of BMW's engineering and test data.ODI found the sticky steering condition does not result in a significant steering effort, thus the impact on the driver's ability to control the vehicle does not appear to be significant.A safety-related defect trend has not been identified at this time and further use of agency resources does not appear to be warranted.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that no safety-related defect exists.The agency will monitor the issue and reserves the right to take future action if warranted by the circumstances.See the attached report for additional information.In addition, during this investigation, ODI became aware of allegations of failure or loss of electric power-assisted steering on the subject vehicles.As a result, ODI is separately reviewing this issue to determine whether additional agency action is needed.
Additional source detail variants (3)
Steering
ODI has evaluated the sticky steering condition, which included reviews of complaints and warranty claims, interviews and surveys of owners of complaint vehicles, road tests of complaint vehicles, and a review of BMW's engineering and test data.ODI found the sticky steering condition does not result in a significant steering effort, thus the impact on the driver's ability to control the vehicle does not appear to be significant.A safety-related defect trend has not been identified at this time and further use of agency resources does not appear to be warranted.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that no safety-related defect exists.The agency will monitor the issue and reserves the right to take future action if warranted by the circumstances.See the attached report for additional information.In addition, during this investigation, ODI became aware of allegations of failure or loss of electric power-assisted steering on the subject vehicles.As a result, ODI is separately reviewing this issue to determine whether additional agency action is needed.
Steering:column
ODI has evaluated the sticky steering condition, which included reviews of complaints and warranty claims, interviews and surveys of owners of complaint vehicles, road tests of complaint vehicles, and a review of BMW's engineering and test data.ODI found the sticky steering condition does not result in a significant steering effort, thus the impact on the driver's ability to control the vehicle does not appear to be significant.A safety-related defect trend has not been identified at this time and further use of agency resources does not appear to be warranted.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that no safety-related defect exists.The agency will monitor the issue and reserves the right to take future action if warranted by the circumstances.See the attached report for additional information.In addition, during this investigation, ODI became aware of allegations of failure or loss of electric power-assisted steering on the subject vehicles.As a result, ODI is separately reviewing this issue to determine whether additional agency action is needed.
Steering:electric Power Assist System
ODI has evaluated the sticky steering condition, which included reviews of complaints and warranty claims, interviews and surveys of owners of complaint vehicles, road tests of complaint vehicles, and a review of BMW's engineering and test data.ODI found the sticky steering condition does not result in a significant steering effort, thus the impact on the driver's ability to control the vehicle does not appear to be significant.A safety-related defect trend has not been identified at this time and further use of agency resources does not appear to be warranted.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that no safety-related defect exists.The agency will monitor the issue and reserves the right to take future action if warranted by the circumstances.See the attached report for additional information.In addition, during this investigation, ODI became aware of allegations of failure or loss of electric power-assisted steering on the subject vehicles.As a result, ODI is separately reviewing this issue to determine whether additional agency action is needed.
EA08001 · BMW Airbag Light Illumination
Opened Jan 4, 2008 · Closed Dec 31, 2008
Status: closed (inferred from source dates) · Air Bags; Air Bags:frontal; Air Bags:frontal:sensor/control MODULE-INACTIVE
BMW IS CONDUCTING A SAFETY RECALL CAMPAIGN ON APPROXIMATELY 200,000 MY04 THROUGH MY06 SUBJECT VEHICLES BUILT THROUGH 11/30/05 TO CORRECT THE FRONT PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT. THE SPECIFIC VEHICLES INCLUDED IN THE RECALL AREMY04- 06/ 5-SERIES WITH STANDARD AND SPORT SEATS, MY04-06/ X3-SERIES AND MY06/ 3-SERIES WITH SPORT SEATS. IN ADDITION, BMW WILL EXTEND THE WARRANTY COVERAGE OF THE PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT TO 10-YEAR/UNLIMITED MILEAGE ON APPROXIMATELY 120,000 REMAINING MY04-06 SUBJECT VEHICLES BUILT THROUGH 11/30/05. THE SPECIFIC VEHICLES INCLUDED IN THE EXTENDED WARRANTY ARE MY 06/ 6 SERIES, MY 06/ 3-SERIES WITH STANDARD SEATS, MY04-05/ Z4, MY04-06/ 7 SERIES, MY 06/ X5, AND MY04-06/ 5-SERIES WITH COMFORT SEATS.THE AVERAGE FREQUENCY OF FAILURES AMONG THE EXTENDED WARRANTY GROUPS WAS LESS THAN 1/7TH OF THE RECALL VEHICLE GROUPS.PLEASE SEE BMW'S 08V-384 RECALL NOTIFICATION FOR FURTHER DETAILSDEPENDING ON SEAT CONFIGURATION AND VEHICLE GEOMETRY, THE OCCUPANT DETECTION MAT CAN FATIGUE DURING USE DEPENDING ON THE MANNER AND FREQUENCY OF THE FRONT PASSENGER'S ENTRY AND EXIT.SPECIFICALLY, OVER TIME, MICRO-CRACKS COULD DEVELOP IN THE SIDE FLANKS OF THE MAT CAUSING A BROKEN CIRCUIT.A BROKENCIRCUIT CAN LEAD TO THE DEACTIVATION OF THE PASSENGER AIR BAG AND THE ILLUMINATION OF BOTH THE AIR BAG WARNING LIGHT AND THE PASSENGER AIR BAG LIGHT.
Additional source detail variants (3)
Air Bags
BMW IS CONDUCTING A SAFETY RECALL CAMPAIGN ON APPROXIMATELY 200,000 MY04 THROUGH MY06 SUBJECT VEHICLES BUILT THROUGH 11/30/05 TO CORRECT THE FRONT PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT. THE SPECIFIC VEHICLES INCLUDED IN THE RECALL AREMY04- 06/ 5-SERIES WITH STANDARD AND SPORT SEATS, MY04-06/ X3-SERIES AND MY06/ 3-SERIES WITH SPORT SEATS. IN ADDITION, BMW WILL EXTEND THE WARRANTY COVERAGE OF THE PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT TO 10-YEAR/UNLIMITED MILEAGE ON APPROXIMATELY 120,000 REMAINING MY04-06 SUBJECT VEHICLES BUILT THROUGH 11/30/05. THE SPECIFIC VEHICLES INCLUDED IN THE EXTENDED WARRANTY ARE MY 06/ 6 SERIES, MY 06/ 3-SERIES WITH STANDARD SEATS, MY04-05/ Z4, MY04-06/ 7 SERIES, MY 06/ X5, AND MY04-06/ 5-SERIES WITH COMFORT SEATS.THE AVERAGE FREQUENCY OF FAILURES AMONG THE EXTENDED WARRANTY GROUPS WAS LESS THAN 1/7TH OF THE RECALL VEHICLE GROUPS.PLEASE SEE BMW'S 08V-384 RECALL NOTIFICATION FOR FURTHER DETAILSDEPENDING ON SEAT CONFIGURATION AND VEHICLE GEOMETRY, THE OCCUPANT DETECTION MAT CAN FATIGUE DURING USE DEPENDING ON THE MANNER AND FREQUENCY OF THE FRONT PASSENGER'S ENTRY AND EXIT.SPECIFICALLY, OVER TIME, MICRO-CRACKS COULD DEVELOP IN THE SIDE FLANKS OF THE MAT CAUSING A BROKEN CIRCUIT.A BROKENCIRCUIT CAN LEAD TO THE DEACTIVATION OF THE PASSENGER AIR BAG AND THE ILLUMINATION OF BOTH THE AIR BAG WARNING LIGHT AND THE PASSENGER AIR BAG LIGHT.
Air Bags:frontal
BMW IS CONDUCTING A SAFETY RECALL CAMPAIGN ON APPROXIMATELY 200,000 MY04 THROUGH MY06 SUBJECT VEHICLES BUILT THROUGH 11/30/05 TO CORRECT THE FRONT PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT. THE SPECIFIC VEHICLES INCLUDED IN THE RECALL AREMY04- 06/ 5-SERIES WITH STANDARD AND SPORT SEATS, MY04-06/ X3-SERIES AND MY06/ 3-SERIES WITH SPORT SEATS. IN ADDITION, BMW WILL EXTEND THE WARRANTY COVERAGE OF THE PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT TO 10-YEAR/UNLIMITED MILEAGE ON APPROXIMATELY 120,000 REMAINING MY04-06 SUBJECT VEHICLES BUILT THROUGH 11/30/05. THE SPECIFIC VEHICLES INCLUDED IN THE EXTENDED WARRANTY ARE MY 06/ 6 SERIES, MY 06/ 3-SERIES WITH STANDARD SEATS, MY04-05/ Z4, MY04-06/ 7 SERIES, MY 06/ X5, AND MY04-06/ 5-SERIES WITH COMFORT SEATS.THE AVERAGE FREQUENCY OF FAILURES AMONG THE EXTENDED WARRANTY GROUPS WAS LESS THAN 1/7TH OF THE RECALL VEHICLE GROUPS.PLEASE SEE BMW'S 08V-384 RECALL NOTIFICATION FOR FURTHER DETAILSDEPENDING ON SEAT CONFIGURATION AND VEHICLE GEOMETRY, THE OCCUPANT DETECTION MAT CAN FATIGUE DURING USE DEPENDING ON THE MANNER AND FREQUENCY OF THE FRONT PASSENGER'S ENTRY AND EXIT.SPECIFICALLY, OVER TIME, MICRO-CRACKS COULD DEVELOP IN THE SIDE FLANKS OF THE MAT CAUSING A BROKEN CIRCUIT.A BROKENCIRCUIT CAN LEAD TO THE DEACTIVATION OF THE PASSENGER AIR BAG AND THE ILLUMINATION OF BOTH THE AIR BAG WARNING LIGHT AND THE PASSENGER AIR BAG LIGHT.
Air Bags:frontal:sensor/control MODULE-INACTIVE
BMW IS CONDUCTING A SAFETY RECALL CAMPAIGN ON APPROXIMATELY 200,000 MY04 THROUGH MY06 SUBJECT VEHICLES BUILT THROUGH 11/30/05 TO CORRECT THE FRONT PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT. THE SPECIFIC VEHICLES INCLUDED IN THE RECALL AREMY04- 06/ 5-SERIES WITH STANDARD AND SPORT SEATS, MY04-06/ X3-SERIES AND MY06/ 3-SERIES WITH SPORT SEATS. IN ADDITION, BMW WILL EXTEND THE WARRANTY COVERAGE OF THE PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT TO 10-YEAR/UNLIMITED MILEAGE ON APPROXIMATELY 120,000 REMAINING MY04-06 SUBJECT VEHICLES BUILT THROUGH 11/30/05. THE SPECIFIC VEHICLES INCLUDED IN THE EXTENDED WARRANTY ARE MY 06/ 6 SERIES, MY 06/ 3-SERIES WITH STANDARD SEATS, MY04-05/ Z4, MY04-06/ 7 SERIES, MY 06/ X5, AND MY04-06/ 5-SERIES WITH COMFORT SEATS.THE AVERAGE FREQUENCY OF FAILURES AMONG THE EXTENDED WARRANTY GROUPS WAS LESS THAN 1/7TH OF THE RECALL VEHICLE GROUPS.PLEASE SEE BMW'S 08V-384 RECALL NOTIFICATION FOR FURTHER DETAILSDEPENDING ON SEAT CONFIGURATION AND VEHICLE GEOMETRY, THE OCCUPANT DETECTION MAT CAN FATIGUE DURING USE DEPENDING ON THE MANNER AND FREQUENCY OF THE FRONT PASSENGER'S ENTRY AND EXIT.SPECIFICALLY, OVER TIME, MICRO-CRACKS COULD DEVELOP IN THE SIDE FLANKS OF THE MAT CAUSING A BROKEN CIRCUIT.A BROKENCIRCUIT CAN LEAD TO THE DEACTIVATION OF THE PASSENGER AIR BAG AND THE ILLUMINATION OF BOTH THE AIR BAG WARNING LIGHT AND THE PASSENGER AIR BAG LIGHT.
2004 BMW Z4 Problems, Complaints & Recalls | Skip That Year
Illustration