IllustrationTL* THE CONTACT OWNS A 2004 BMW Z4. WHILE DRIVING AT VARIOUS SPEEDS, THE STEERING WHEEL SEIZED AND BECAME VERY DIFFICULT TO TURN. THE FAILURE OCCURRED INTERMITTENTLY. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 85,000.
2004 BMW Z4
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all Z4 years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
680–25K
12925–50K
10550–75K
4275–100K
26100–150K
2150K+
372 reports with mileage · 39 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Steering. Review the 378 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Air Bags. Review the 18 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 14 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
1 crash reports2 fire reports0 injury reports
What owners actually said
411 reportsCAR HAS BEEN HAVING STICKY STEERING PROBLEMS FOR AWHILE NOW. IT HAS GOTTEN WORSE THIS SUMMER . WHEN THE WEATHER IS ABOVE 70 OR THE LONGER I DRIVE THE WORSE IT GETS. PROBLEM HAS GOTTEN SO BAD THAT IT IS NOT SAFE TO DRIVE ANY LONGER. STEERING WHEEL SEEMS TO HAVE A FLAT SPOT IN THE MIDDLE AND CAUSES YOU TO OVER STEER WHEN THIS HAPP…
Read full complaint
CAR HAS BEEN HAVING STICKY STEERING PROBLEMS FOR AWHILE NOW. IT HAS GOTTEN WORSE THIS SUMMER . WHEN THE WEATHER IS ABOVE 70 OR THE LONGER I DRIVE THE WORSE IT GETS. PROBLEM HAS GOTTEN SO BAD THAT IT IS NOT SAFE TO DRIVE ANY LONGER. STEERING WHEEL SEEMS TO HAVE A FLAT SPOT IN THE MIDDLE AND CAUSES YOU TO OVER STEER WHEN THIS HAPPENS. VERY DANGEROUS. WAS TOLD IT WOULD BE AROUND 3000 DOLLARS TO FIX?? IT IS A GREAT CAR BESIDES THAT!! TO BAD IT CANNOT BE DRIVEN AT THIS TIME. JUST SITTING IN GARAGE. WOULD LOVE TO HAVE ANOTHER ONE BUT NOT AT THE EXPENSE OF A NEW STEERING COLUMN.
THE STEERING COLUMN FREEZES IN POSITION AND HOLDING THE STEERING IT WHEEL FEELS LIKE IT'S BEING HELD BY A MAGNET MUCH LIKE A DC MOTOR FEELS IF YOU TRY TO ROTATE IT. FOR EXAMPLE AFTER ROUNDING THE BEND OR TAKING THE CORNER THE STEERING WHEEL WOULD STAY IN POSITION AND YOU HAVE TO PHYSICALLY TURN THE STEERING WHEEL BACK TO CENTER…
Read full complaint
THE STEERING COLUMN FREEZES IN POSITION AND HOLDING THE STEERING IT WHEEL FEELS LIKE IT'S BEING HELD BY A MAGNET MUCH LIKE A DC MOTOR FEELS IF YOU TRY TO ROTATE IT. FOR EXAMPLE AFTER ROUNDING THE BEND OR TAKING THE CORNER THE STEERING WHEEL WOULD STAY IN POSITION AND YOU HAVE TO PHYSICALLY TURN THE STEERING WHEEL BACK TO CENTER IT'S LIKE IT'S STUCK THERE BY MAGNETIC FORCE. I CALLED MY BMW DEALERSHIP AND ASKED THE SERVICE ADVISOR ABOUT THIS PROBLEM. HE HAD NO IDEA WHAT I WAS TALKING ABOUT THEN HE ASKED THE SERVICE FORMAN AND WAS TOLD IT'S A WELL KNOWN PROBLEM AND THE ONLY FIX IS TO REPLACE THE STEERING COLUMN AT $3600-4000. IF THIS IS A WELL KNOWN PROBLEM THEN WHY ISN'T THERE A RECALL. AND WHY ISN'T BMW TAKING RESPONSIBILITY FOR A DESIGN FLAW.
THE DAY I PURCHASED MY USED 2004 BMW Z4, I NOTICED A PROBLEM WITH THE STEERING WHEEL "STICKING". I CALLED THE DEALER AND WAS TOLD IT WAS NORMAL WITH THAT PARTICULAR CAR. OVER THE YEARS, THERE ARE DAYS THAT IT DRIVES NORMALLY WITH NO STEERING PROBLEMS, BUT FOR THE MOST PART, THE STEERING WHEEL STARTS REALLY STICKING WHEN THE CAR …
Read full complaint
THE DAY I PURCHASED MY USED 2004 BMW Z4, I NOTICED A PROBLEM WITH THE STEERING WHEEL "STICKING". I CALLED THE DEALER AND WAS TOLD IT WAS NORMAL WITH THAT PARTICULAR CAR. OVER THE YEARS, THERE ARE DAYS THAT IT DRIVES NORMALLY WITH NO STEERING PROBLEMS, BUT FOR THE MOST PART, THE STEERING WHEEL STARTS REALLY STICKING WHEN THE CAR IS GOING OVER 20 MPH OR I SHOULD SAY, IT'S HARDER TO CONTROL THE STEERING WHEEL AT A SPEED IN EXCESS OF 20-25 MPH. THE BMW DEALER WHERE I LIVE NOW TOLD ME THAT IT WAS HAPPENING BECAUSE I DON'T DRIVE THE CAR OFTEN ENOUGH. AND IT'S TRUE THAT I DON'T DRIVE VERY OFTEN - I JUST ROLLED OVER 50,000 MILES AND THE CAR IS 14 YEARS OLD. I HAVE MANY TIMES HAD TO PULL OFF OF THE HIGHWAY OR DRIVE WITH MY HAZARD LIGHTS ON BECAUSE I WASN'T ABLE TO STAY WITHIN MY LANE DUE TO THE STEERING PROBLEM. I GET FRIGHTENED TO DRIVE ANYWHERE EXCEPT THE CITY STREETS NEAR MY HOME WHERE THE SPEED LIMIT IS UNDER 40 MPH. I AM GOING TO CONTACT THE DEALER HERE IN OK AGAIN AND SEE WHAT THEY CAN DO TO FIX THIS ISSUE ONCE AND FOR ALL BECAUSE MY CAR HAS BECOME UNSAFE TO DRIVE IN A NORMAL FASHION.
I HAVE NOTICED ON WARM DAYS THE STEERING BECOMES STICKY AS IF THE POWER STEERING IS COMING ON AND OFF. THIS CAUSES A OVER CONTROLLING OF THE CAR AND MAKES IT DIFFICULT TO DRIVE. I FELT VERY UNSAFE. I TOOK THE CAR TO BMW ROADSHOW AT MEMPHIS AND WAS TOLD THE PROBLEM WAS THE ELECTRIC STEERING UNIT AND WILL COST $4000 TO REPAIR. I…
Read full complaint
I HAVE NOTICED ON WARM DAYS THE STEERING BECOMES STICKY AS IF THE POWER STEERING IS COMING ON AND OFF. THIS CAUSES A OVER CONTROLLING OF THE CAR AND MAKES IT DIFFICULT TO DRIVE. I FELT VERY UNSAFE. I TOOK THE CAR TO BMW ROADSHOW AT MEMPHIS AND WAS TOLD THE PROBLEM WAS THE ELECTRIC STEERING UNIT AND WILL COST $4000 TO REPAIR. I RESEARCHED THE INTERNET AND WAS SHOCKED AT THE NUMBER OF COMPLAINTS GOING BACK AS FAR AS 2009. I CALLED BMW CUSTOMER SERVICE AND WAS TOLD THAT IT WAS NOT THEIR PROBLEM. SOMEONE IS GOING TO GET HURT IF IT HAS NOT ALREADY HAPPENED. BMW KNOWS OF THIS PROBLEM AND HAS CORRECT IT IN LATER MODELS AND THEY KNOW HOW IT FIX THE ISSUE. IT APPEARS THIS IS AN AGE RELATE ISSUE, NOT MILEAGE, AND THESE CARS,2003-2005 ARE OUT OF WARRANTY. IN MY RESEARCH I SEE THAT NHTSA IS AWARE OF THIS PROBLEM BUT HAS CLOSED THE ISSUE. THIS IS A SAFETY ISSUE AND THIS INVESTIGATION NEEDS TO BE REOPENED.
THIS HAS BEEN A CONTINUOUS PROBLEM. I JUST HAD THE FRONT STRUTS AND OTHER FRONT END WORK DONE FIGURING IT WOULD FIX THE PROBLEM, IT DIDN'T. IN RESEARCHING THE PROBLEM AND TALKING WITH OTHER BMW Z4 OWNERS, THIS HAPPENS ON ALL 2003-2005 BMW Z4. THERE IS A PROBLEM IN THE STEERING COLUMN. IT WILL CAUSE AN ACCIDENT, ESPECIALLY WHE…
Read full complaint
THIS HAS BEEN A CONTINUOUS PROBLEM. I JUST HAD THE FRONT STRUTS AND OTHER FRONT END WORK DONE FIGURING IT WOULD FIX THE PROBLEM, IT DIDN'T. IN RESEARCHING THE PROBLEM AND TALKING WITH OTHER BMW Z4 OWNERS, THIS HAPPENS ON ALL 2003-2005 BMW Z4. THERE IS A PROBLEM IN THE STEERING COLUMN. IT WILL CAUSE AN ACCIDENT, ESPECIALLY WHEN IT HAPPENS A HIGH SPEED. WHEN THE CAR HAS BEEN RUNNING AWHILE (LONGER THAN 1 HOUR, MOST LIKELY HEAT RELATED), THE STEERING BECOMES VERY, VERY STIFF AND FEELS LIKE THE STEERING WHEEL IS LOCKED, AND TO MOVE THE STEERING WHEEL YOU MUST EXERT AN EXTRAORDINARY FORCE TO MAKE IT MOVE. THE PROBLEM CONTINUES TO HAPPENS AT ALL SPEEDS UNTIL THE CAR SITS AWHILE (COOLS OFF). AT HIGH SPEEDS THIS CAN MAKE YOU OVER CORRECT AND FORCE YOU OUT OF YOUR LANE. IF I EVER COME UP AND AN OBJECT IN MY LANE (I.E. TIRE FRAGMENT FROM A TRUCK) AND I HAVE TO MOVE OUT THE WAY AND THERE IS ANOTHER VEHICLE IN THE NEXT LANE, IT IS VERY POSSIBLE I COULD SIDESWIPE THAT VEHICLE AND CAUSE AN ACCIDENT. THE DEFECT HAS BEEN CORRECTED IN OTHER VEHICLES BY INSTALLING A NEW STEERING COLUMN FROM EARLIER YEAR BMW Z4 (2008 OR EARLIER), SO IT SEEMS THAT BMW KNOWS OF THE PROBLEM AND HAS CORRECTED THE DEFECT. BMW JUST NEEDS TO MAKE IT RIGHT WITH ALL THE VEHICLES EFFECTED. I KNOW FROM RESEARCH THAT THIS HAS BEEN LOOKED AT BEFORE (2010 OR 2011) BY THE NHTSA, BUT NO RECALL WAS ISSUED. THIS NEEDS TO BE REOPENED AND A RECALL IMPLEMENTED. THESE ARE LOW MILEAGE AND WELL MAINTAINED CARS, AND WILL STILL BE ON THE ROAD FOR A NUMBER OF YEARS. IF THIS WAS ON ANY OTHER MASSED PRODUCED CAR (GM, FAULTY IGNITION), THERE WOULD HAVE DEFINITELY BEEN A RECALL BY NOW. I DON'T KNOW HOW TO TELL YOU HOW SERIOUS THIS DEFECT IS, BUT IT IS DANGEROUS! I WILL NOT ALLOW ANYONE ELSE DRIVE THIS VEHICLE. THANK YOU!
STEERING WAS NOTICED TO BE "NOTCHY" WHILE DRIVING AT HIGHWAY SPEEDS. SEEMS LIKE STEERING IS CAUGHT ON SOMETHING THEN BREAKS FREE. INITIALLY THOUGHT IS WAS LOW POWER STEERING FLUID, BUT DISCOVERED THIS VEHICLE HAS ELECTRICAL POWER STEERING. FURTHER TESTING SHOWED IT HAPPENS AT ALL SPEEDS. THE STEERING CAN BECOME DIFFICULT TO M…
Read full complaint
STEERING WAS NOTICED TO BE "NOTCHY" WHILE DRIVING AT HIGHWAY SPEEDS. SEEMS LIKE STEERING IS CAUGHT ON SOMETHING THEN BREAKS FREE. INITIALLY THOUGHT IS WAS LOW POWER STEERING FLUID, BUT DISCOVERED THIS VEHICLE HAS ELECTRICAL POWER STEERING. FURTHER TESTING SHOWED IT HAPPENS AT ALL SPEEDS. THE STEERING CAN BECOME DIFFICULT TO MOVE AND OVER-CORRECTIONS OCCUR WHEN IT BREAKS FREE. FORTUNATELY NO ACCIDENTS OCCURRED, ALTHOUGH IT IS VERY POSSIBLE THAT IT COULD EASILY HAPPEN.
TL* THE CONTACT OWNS A 2004 BMW Z4. WHILE DRIVING APPROXIMATELY 45 MPH IN WARM WEATHER, THE STEERING WHEEL BECAME STICKY AND DIFFICULT TO TURN INTERMITTENTLY. THE FAILURE RECURRED ON SEVERAL OCCASIONS. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 30,…
Read full complaint
TL* THE CONTACT OWNS A 2004 BMW Z4. WHILE DRIVING APPROXIMATELY 45 MPH IN WARM WEATHER, THE STEERING WHEEL BECAME STICKY AND DIFFICULT TO TURN INTERMITTENTLY. THE FAILURE RECURRED ON SEVERAL OCCASIONS. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 30,000. THE VIN WAS UNAVAILABLE. UPDATED 09/14/15*LJ UPDATED 10/26/2017*CN
TL* THE CONTACT OWNS A 2004 BMW Z4. WHILE DRIVING 60 MPH, THE STEERING WHEEL SEIZED. THE VEHICLE WAS UNABLE TO BE DRIVEN WHEN THE INCIDENT OCCURRED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE ISSUE. THE VIN WAS UNAVAILABLE. THE FAILURE MILEAGE WAS 94,000.
TL* THE CONTACT OWNS A 2004 BMW Z4. THE CONTACT STATED THAT THE POWER STEERING WARNING LIGHT ILLUMINATED AND THE STEERING WHEEL SEIZED. THE VEHICLE WAS UNABLE TO BE DRIVEN. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 140,352. UPDATED 09/01/15*LJ THE CONSUMER STATED THE ENTIRE S…
Read full complaint
TL* THE CONTACT OWNS A 2004 BMW Z4. THE CONTACT STATED THAT THE POWER STEERING WARNING LIGHT ILLUMINATED AND THE STEERING WHEEL SEIZED. THE VEHICLE WAS UNABLE TO BE DRIVEN. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 140,352. UPDATED 09/01/15*LJ THE CONSUMER STATED THE ENTIRE STEERING COLUMN NEEDED TO BE REPLACED. UPDATED 10/27/2015*JS
Official recalls
104V182000 · Fuel System, Gasoline:delivery:fuel Pump
Apr 12, 2004
ON CERTAIN PASSENGER VEHICLES, UNDER CERTAIN ENVIRONMENTAL CONDITIONS, A VAPOR LOCK IN THE FUEL PUMP COULD OCCUR CAUSING THE ENGINE TO STALL. IF THIS WERE TO HAPPEN, THE ENGINE WOULD NOT BE ABLE TO BE RESTARTED FOR APPROXIMATELY 15 TO 20 MINUTES.
Consequence & remedy
Consequence: IF STALLING WERE TO OCCUR, THE DRIVER WOULD BE UNABLE TO MAINTAIN VEHICLE SPEED OR ACCELERATE, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSTALL A RESISTOR IN THE ELECTRICAL LINE POWERING THE FUEL PUMP IN ORDER TO PREVENT AN OCCURRENCE OF VAPOR LOCK. THE RECALL BEGAN MAY 11, 2004. OWNERS SHOULD CONTACT BMW AT 1-800-831-1117.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2PE10020 · Sticky Steering
Opened Jun 28, 2010 · Closed Jun 28, 2011
Status: closed (inferred from source dates) · Steering; Steering:column; Steering:electric Power Assist System
ODI has evaluated the sticky steering condition, which included reviews of complaints and warranty claims, interviews and surveys of owners of complaint vehicles, road tests of complaint vehicles, and a review of BMW's engineering and test data.ODI found the sticky steering condition does not result in a significant steering effort, thus the impact on the driver's ability to control the vehicle does not appear to be significant.A safety-related defect trend has not been identified at this time and further use of agency resources does not appear to be warranted.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that no safety-related defect exists.The agency will monitor the issue and reserves the right to take future action if warranted by the circumstances.See the attached report for additional information.In addition, during this investigation, ODI became aware of allegations of failure or loss of electric power-assisted steering on the subject vehicles.As a result, ODI is separately reviewing this issue to determine whether additional agency action is needed.
Additional source detail variants (3)
Steering
ODI has evaluated the sticky steering condition, which included reviews of complaints and warranty claims, interviews and surveys of owners of complaint vehicles, road tests of complaint vehicles, and a review of BMW's engineering and test data.ODI found the sticky steering condition does not result in a significant steering effort, thus the impact on the driver's ability to control the vehicle does not appear to be significant.A safety-related defect trend has not been identified at this time and further use of agency resources does not appear to be warranted.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that no safety-related defect exists.The agency will monitor the issue and reserves the right to take future action if warranted by the circumstances.See the attached report for additional information.In addition, during this investigation, ODI became aware of allegations of failure or loss of electric power-assisted steering on the subject vehicles.As a result, ODI is separately reviewing this issue to determine whether additional agency action is needed.
Steering:column
ODI has evaluated the sticky steering condition, which included reviews of complaints and warranty claims, interviews and surveys of owners of complaint vehicles, road tests of complaint vehicles, and a review of BMW's engineering and test data.ODI found the sticky steering condition does not result in a significant steering effort, thus the impact on the driver's ability to control the vehicle does not appear to be significant.A safety-related defect trend has not been identified at this time and further use of agency resources does not appear to be warranted.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that no safety-related defect exists.The agency will monitor the issue and reserves the right to take future action if warranted by the circumstances.See the attached report for additional information.In addition, during this investigation, ODI became aware of allegations of failure or loss of electric power-assisted steering on the subject vehicles.As a result, ODI is separately reviewing this issue to determine whether additional agency action is needed.
Steering:electric Power Assist System
ODI has evaluated the sticky steering condition, which included reviews of complaints and warranty claims, interviews and surveys of owners of complaint vehicles, road tests of complaint vehicles, and a review of BMW's engineering and test data.ODI found the sticky steering condition does not result in a significant steering effort, thus the impact on the driver's ability to control the vehicle does not appear to be significant.A safety-related defect trend has not been identified at this time and further use of agency resources does not appear to be warranted.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that no safety-related defect exists.The agency will monitor the issue and reserves the right to take future action if warranted by the circumstances.See the attached report for additional information.In addition, during this investigation, ODI became aware of allegations of failure or loss of electric power-assisted steering on the subject vehicles.As a result, ODI is separately reviewing this issue to determine whether additional agency action is needed.
EA08001 · BMW Airbag Light Illumination
Opened Jan 4, 2008 · Closed Dec 31, 2008
Status: closed (inferred from source dates) · Air Bags; Air Bags:frontal; Air Bags:frontal:sensor/control MODULE-INACTIVE
BMW IS CONDUCTING A SAFETY RECALL CAMPAIGN ON APPROXIMATELY 200,000 MY04 THROUGH MY06 SUBJECT VEHICLES BUILT THROUGH 11/30/05 TO CORRECT THE FRONT PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT. THE SPECIFIC VEHICLES INCLUDED IN THE RECALL AREMY04- 06/ 5-SERIES WITH STANDARD AND SPORT SEATS, MY04-06/ X3-SERIES AND MY06/ 3-SERIES WITH SPORT SEATS. IN ADDITION, BMW WILL EXTEND THE WARRANTY COVERAGE OF THE PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT TO 10-YEAR/UNLIMITED MILEAGE ON APPROXIMATELY 120,000 REMAINING MY04-06 SUBJECT VEHICLES BUILT THROUGH 11/30/05. THE SPECIFIC VEHICLES INCLUDED IN THE EXTENDED WARRANTY ARE MY 06/ 6 SERIES, MY 06/ 3-SERIES WITH STANDARD SEATS, MY04-05/ Z4, MY04-06/ 7 SERIES, MY 06/ X5, AND MY04-06/ 5-SERIES WITH COMFORT SEATS.THE AVERAGE FREQUENCY OF FAILURES AMONG THE EXTENDED WARRANTY GROUPS WAS LESS THAN 1/7TH OF THE RECALL VEHICLE GROUPS.PLEASE SEE BMW'S 08V-384 RECALL NOTIFICATION FOR FURTHER DETAILSDEPENDING ON SEAT CONFIGURATION AND VEHICLE GEOMETRY, THE OCCUPANT DETECTION MAT CAN FATIGUE DURING USE DEPENDING ON THE MANNER AND FREQUENCY OF THE FRONT PASSENGER'S ENTRY AND EXIT.SPECIFICALLY, OVER TIME, MICRO-CRACKS COULD DEVELOP IN THE SIDE FLANKS OF THE MAT CAUSING A BROKEN CIRCUIT.A BROKENCIRCUIT CAN LEAD TO THE DEACTIVATION OF THE PASSENGER AIR BAG AND THE ILLUMINATION OF BOTH THE AIR BAG WARNING LIGHT AND THE PASSENGER AIR BAG LIGHT.
Additional source detail variants (3)
Air Bags
BMW IS CONDUCTING A SAFETY RECALL CAMPAIGN ON APPROXIMATELY 200,000 MY04 THROUGH MY06 SUBJECT VEHICLES BUILT THROUGH 11/30/05 TO CORRECT THE FRONT PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT. THE SPECIFIC VEHICLES INCLUDED IN THE RECALL AREMY04- 06/ 5-SERIES WITH STANDARD AND SPORT SEATS, MY04-06/ X3-SERIES AND MY06/ 3-SERIES WITH SPORT SEATS. IN ADDITION, BMW WILL EXTEND THE WARRANTY COVERAGE OF THE PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT TO 10-YEAR/UNLIMITED MILEAGE ON APPROXIMATELY 120,000 REMAINING MY04-06 SUBJECT VEHICLES BUILT THROUGH 11/30/05. THE SPECIFIC VEHICLES INCLUDED IN THE EXTENDED WARRANTY ARE MY 06/ 6 SERIES, MY 06/ 3-SERIES WITH STANDARD SEATS, MY04-05/ Z4, MY04-06/ 7 SERIES, MY 06/ X5, AND MY04-06/ 5-SERIES WITH COMFORT SEATS.THE AVERAGE FREQUENCY OF FAILURES AMONG THE EXTENDED WARRANTY GROUPS WAS LESS THAN 1/7TH OF THE RECALL VEHICLE GROUPS.PLEASE SEE BMW'S 08V-384 RECALL NOTIFICATION FOR FURTHER DETAILSDEPENDING ON SEAT CONFIGURATION AND VEHICLE GEOMETRY, THE OCCUPANT DETECTION MAT CAN FATIGUE DURING USE DEPENDING ON THE MANNER AND FREQUENCY OF THE FRONT PASSENGER'S ENTRY AND EXIT.SPECIFICALLY, OVER TIME, MICRO-CRACKS COULD DEVELOP IN THE SIDE FLANKS OF THE MAT CAUSING A BROKEN CIRCUIT.A BROKENCIRCUIT CAN LEAD TO THE DEACTIVATION OF THE PASSENGER AIR BAG AND THE ILLUMINATION OF BOTH THE AIR BAG WARNING LIGHT AND THE PASSENGER AIR BAG LIGHT.
Air Bags:frontal
BMW IS CONDUCTING A SAFETY RECALL CAMPAIGN ON APPROXIMATELY 200,000 MY04 THROUGH MY06 SUBJECT VEHICLES BUILT THROUGH 11/30/05 TO CORRECT THE FRONT PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT. THE SPECIFIC VEHICLES INCLUDED IN THE RECALL AREMY04- 06/ 5-SERIES WITH STANDARD AND SPORT SEATS, MY04-06/ X3-SERIES AND MY06/ 3-SERIES WITH SPORT SEATS. IN ADDITION, BMW WILL EXTEND THE WARRANTY COVERAGE OF THE PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT TO 10-YEAR/UNLIMITED MILEAGE ON APPROXIMATELY 120,000 REMAINING MY04-06 SUBJECT VEHICLES BUILT THROUGH 11/30/05. THE SPECIFIC VEHICLES INCLUDED IN THE EXTENDED WARRANTY ARE MY 06/ 6 SERIES, MY 06/ 3-SERIES WITH STANDARD SEATS, MY04-05/ Z4, MY04-06/ 7 SERIES, MY 06/ X5, AND MY04-06/ 5-SERIES WITH COMFORT SEATS.THE AVERAGE FREQUENCY OF FAILURES AMONG THE EXTENDED WARRANTY GROUPS WAS LESS THAN 1/7TH OF THE RECALL VEHICLE GROUPS.PLEASE SEE BMW'S 08V-384 RECALL NOTIFICATION FOR FURTHER DETAILSDEPENDING ON SEAT CONFIGURATION AND VEHICLE GEOMETRY, THE OCCUPANT DETECTION MAT CAN FATIGUE DURING USE DEPENDING ON THE MANNER AND FREQUENCY OF THE FRONT PASSENGER'S ENTRY AND EXIT.SPECIFICALLY, OVER TIME, MICRO-CRACKS COULD DEVELOP IN THE SIDE FLANKS OF THE MAT CAUSING A BROKEN CIRCUIT.A BROKENCIRCUIT CAN LEAD TO THE DEACTIVATION OF THE PASSENGER AIR BAG AND THE ILLUMINATION OF BOTH THE AIR BAG WARNING LIGHT AND THE PASSENGER AIR BAG LIGHT.
Air Bags:frontal:sensor/control MODULE-INACTIVE
BMW IS CONDUCTING A SAFETY RECALL CAMPAIGN ON APPROXIMATELY 200,000 MY04 THROUGH MY06 SUBJECT VEHICLES BUILT THROUGH 11/30/05 TO CORRECT THE FRONT PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT. THE SPECIFIC VEHICLES INCLUDED IN THE RECALL AREMY04- 06/ 5-SERIES WITH STANDARD AND SPORT SEATS, MY04-06/ X3-SERIES AND MY06/ 3-SERIES WITH SPORT SEATS. IN ADDITION, BMW WILL EXTEND THE WARRANTY COVERAGE OF THE PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT TO 10-YEAR/UNLIMITED MILEAGE ON APPROXIMATELY 120,000 REMAINING MY04-06 SUBJECT VEHICLES BUILT THROUGH 11/30/05. THE SPECIFIC VEHICLES INCLUDED IN THE EXTENDED WARRANTY ARE MY 06/ 6 SERIES, MY 06/ 3-SERIES WITH STANDARD SEATS, MY04-05/ Z4, MY04-06/ 7 SERIES, MY 06/ X5, AND MY04-06/ 5-SERIES WITH COMFORT SEATS.THE AVERAGE FREQUENCY OF FAILURES AMONG THE EXTENDED WARRANTY GROUPS WAS LESS THAN 1/7TH OF THE RECALL VEHICLE GROUPS.PLEASE SEE BMW'S 08V-384 RECALL NOTIFICATION FOR FURTHER DETAILSDEPENDING ON SEAT CONFIGURATION AND VEHICLE GEOMETRY, THE OCCUPANT DETECTION MAT CAN FATIGUE DURING USE DEPENDING ON THE MANNER AND FREQUENCY OF THE FRONT PASSENGER'S ENTRY AND EXIT.SPECIFICALLY, OVER TIME, MICRO-CRACKS COULD DEVELOP IN THE SIDE FLANKS OF THE MAT CAUSING A BROKEN CIRCUIT.A BROKENCIRCUIT CAN LEAD TO THE DEACTIVATION OF THE PASSENGER AIR BAG AND THE ILLUMINATION OF BOTH THE AIR BAG WARNING LIGHT AND THE PASSENGER AIR BAG LIGHT.