EXCESSIVE FORCE IS NEEDED TO TURN WHEEL SAFELY AT HIGH RATE OF SPEED. WITH POOR ROAD CONDITIONS, THIS EFFECT IS SEVERELY EXAGGERATED!!! STEERING BINDS UP WHEN ATTEMPTING TO MAKE SMALL CORRECTIONS RESULTING IN OVERCORRECTIONS IN EITHER DIRECTION CAUSING A SAFETY HAZARD TO BOTH ME AND OTHER VEHICLES IF I WERE TO CROSS LANES DUE…
Read full complaint
EXCESSIVE FORCE IS NEEDED TO TURN WHEEL SAFELY AT HIGH RATE OF SPEED. WITH POOR ROAD CONDITIONS, THIS EFFECT IS SEVERELY EXAGGERATED!!! STEERING BINDS UP WHEN ATTEMPTING TO MAKE SMALL CORRECTIONS RESULTING IN OVERCORRECTIONS IN EITHER DIRECTION CAUSING A SAFETY HAZARD TO BOTH ME AND OTHER VEHICLES IF I WERE TO CROSS LANES DUE TO OVERCORRECTION SITUATION. *TR
NHTSA ODI #10449654
51,000 miles · Feb 21, 2012
Steering
TL* THE CONTACT OWNS A 2004 BMW Z4. THE CONTACT STATED THAT WHILE DRIVING, THE STEERING WHEEL BECOME STIFF. THE STEERING WHEEL WOULD PULL TO THE RIGHT AND THE VEHICLE WOULD VEER TOWARD THE RIGHT AS WELL. THE DEALER WAS NOTIFIED OF THE FAILURE BUT PROVIDED NO ASSISTANCE. THE MANUFACTURED WAS CONTACTED VIA POSTAL MAIL BUT THE …
Read full complaint
TL* THE CONTACT OWNS A 2004 BMW Z4. THE CONTACT STATED THAT WHILE DRIVING, THE STEERING WHEEL BECOME STIFF. THE STEERING WHEEL WOULD PULL TO THE RIGHT AND THE VEHICLE WOULD VEER TOWARD THE RIGHT AS WELL. THE DEALER WAS NOTIFIED OF THE FAILURE BUT PROVIDED NO ASSISTANCE. THE MANUFACTURED WAS CONTACTED VIA POSTAL MAIL BUT THE CONTACT HAD NOT RECEIVED A CONFIRMATION NOTICE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 51,000 AND THE CURRENT MILEAGE WAS 53,000.
NHTSA ODI #10448642
42,000 miles · Feb 2, 2012
Steering
VEHICLE BOUGHT JULY 2011 WITH 40000 MILES. IN DECEMBER, 2011 ON THE RETURN TRIP (200 MILES EACH WAY), AFTER A 5 HR LAYOVER, THE STEERING ON THE CAR STARTED TO STICK IN THE STRAIGHT AHEAD POSITION. WHEN THE CAR DRIFTED TO THE LEFT AND STEERING NEEDED TO BE CORRECTED TO THE RIGHT, THE STEERING WHEEL WOULD NOT MOVE UNTIL A LOT OF …
Read full complaint
VEHICLE BOUGHT JULY 2011 WITH 40000 MILES. IN DECEMBER, 2011 ON THE RETURN TRIP (200 MILES EACH WAY), AFTER A 5 HR LAYOVER, THE STEERING ON THE CAR STARTED TO STICK IN THE STRAIGHT AHEAD POSITION. WHEN THE CAR DRIFTED TO THE LEFT AND STEERING NEEDED TO BE CORRECTED TO THE RIGHT, THE STEERING WHEEL WOULD NOT MOVE UNTIL A LOT OF FORCE WAS APPLIED AND THEN THE CAR WOULD OVER CORRECT TO THE RIGHT, SOME TIMES GOING ON THE SHOULDER OF THE ROAD. IT DID NOT SEEM TO BE AS PREVALENT WHEN CORRECTIONS TO THE LEFT WERE NEEDED. SINCE THEN IT HAS OCCURRED ON AT LEAST TWO OTHER OCCASIONS, ALWAYS ON EXPRESSWAYS AND AT SPEEDS IN EXCESS OF 50 MPH. AND WHEN THE TEMPERATURE IS ABOVE 70 DEGREES F. *KB
NHTSA ODI #10446267
32,000 miles · Jan 13, 2012
Electrical SystemSteering
THE STEERING BINDS AT ALMOST ANY SPEED. I NOTICED IT WHEN DRIVING STRAIGHT FORWARD. WHEN A CORRECTION IN DIRECTION IS MADE THE WHEEL BINDS UNTIL GREATER PRESSURE IS APPLIED. IT SEEMS THE PROBLEM IS REQUIRING EVEN MORE PRESSURE FOR THE CORRECTION. I CALLED BMWNA AND THEY TOLD ME THEY HAVE HEARD NOTHING ABOUT THIS PROBLEM. I A…
Read full complaint
THE STEERING BINDS AT ALMOST ANY SPEED. I NOTICED IT WHEN DRIVING STRAIGHT FORWARD. WHEN A CORRECTION IN DIRECTION IS MADE THE WHEEL BINDS UNTIL GREATER PRESSURE IS APPLIED. IT SEEMS THE PROBLEM IS REQUIRING EVEN MORE PRESSURE FOR THE CORRECTION. I CALLED BMWNA AND THEY TOLD ME THEY HAVE HEARD NOTHING ABOUT THIS PROBLEM. I AM IN FEAR FOR MY SAFETY AS WELL AS OTHERS AROUND BMW'S Z-4 2004. *TR
NHTSA ODI #10443737
32,750 miles · Jan 10, 2012
Steering
THE STEERING BECOMES STUCK. UNDER HIGHWAY DRIVING CONDITIONS MAY CAUSE ERRATIC CONTROL AND ULTIMATELY AN ACCIDENT. THE STEERING SEEMS TO BIND AND NEEDS GREATER PRESSURE TO FREE THE STEERING ITSELF. *TR
NHTSA ODI #10443266
55,300 miles · Dec 13, 2011
Steering
I JUST RECENTLY PURCHASED A 2004 BMW Z4. I NOTICED THAT WHILE DRIVING ON THE HIGHWAY THAT THE STEERING IS MALFUNCTIONING. WHILE TRAVELING IN A STRAIGHT PATH, THE STEERING GETS "STUCK" AND YOU NEED TO JERK THE STEERING WHEEL TO MAKE A TURN TO THE RIGHT OR LEFT, OR EVEN TO CHANGE LANES. THIS IS A VERY DANGEROUS ACTION AND COULD…
Read full complaint
I JUST RECENTLY PURCHASED A 2004 BMW Z4. I NOTICED THAT WHILE DRIVING ON THE HIGHWAY THAT THE STEERING IS MALFUNCTIONING. WHILE TRAVELING IN A STRAIGHT PATH, THE STEERING GETS "STUCK" AND YOU NEED TO JERK THE STEERING WHEEL TO MAKE A TURN TO THE RIGHT OR LEFT, OR EVEN TO CHANGE LANES. THIS IS A VERY DANGEROUS ACTION AND COULD CAUSE A SERIOUS ACCIDENT. I HAVE NOTIFIED BMW NORTH AMERICA AND INDY WHOLESALE DIRECT, THE DEALER THAT I PURCHASED THIS CAR FROM. NEITHER ONE SEEMS TO WANT TO HELP IN THIS SITUATION AND BOTH HAVE IGNORED MY COMPLAINTS. THIS IS THE SECOND COMPLAINT I HAVE FILED WITH THE NHTSA. I DID NOT GET A RESPONSE FROM MY ORIGINAL COMPLAINT A COUPLE OF WEEKS AGO. *TR
NHTSA ODI #10439816
55,300 miles · Nov 25, 2011
Steering
DRIVING ON A 70 DEGREE FALL DAY ON INTERSTATE 70, NEAR ST. LOUIS, THE STEERING BECAME LOCKED IN A CENTER POSITION. I WAS TRAVELING AROUND 65 TO 70 MPH WHEN THIS OCCURRED. I HAD TO JERK THE STEERING WHEEL TO GET IT OFF CENTER TO MAKE A TURN. THIS HAPPENED A FEW TIMES BEFORE I GOT TO MY DESTINATION. JERKING A STEERING WHEEL A…
Read full complaint
DRIVING ON A 70 DEGREE FALL DAY ON INTERSTATE 70, NEAR ST. LOUIS, THE STEERING BECAME LOCKED IN A CENTER POSITION. I WAS TRAVELING AROUND 65 TO 70 MPH WHEN THIS OCCURRED. I HAD TO JERK THE STEERING WHEEL TO GET IT OFF CENTER TO MAKE A TURN. THIS HAPPENED A FEW TIMES BEFORE I GOT TO MY DESTINATION. JERKING A STEERING WHEEL AT A HIGH RATE OF SPEED ON A CROWDED HIGHWAY IS A HARROWING EXPERIENCE AND, TO SAY THE LEAST, VERY UNSAFE AND DANGEROUS. I JUST PURCHASED THIS CAR AND I AM TRULY NERVOUS ABOUT DRIVING THIS VEHICLE OR LETTING MY WIFE DRIVE THIS VEHICLE. I HAVE CONTACTED THE DEALER AND AM WAITING TO HEAR BACK. *TR
NHTSA ODI #10437284
19,400 miles · Oct 13, 2011
Steering
POWER STEERING STICKS ON HOT DAYS TYPICALLY ABOVE 80 DEGREES. PROBLEM USUALLY OCCURS ON THE HIGHWAY AT SPEEDS ABOVE 50 MPH BUT HAS HAPPENED AT LOWER SPEEDS AS WELL. IT TAKES EXCESSIVE FORCE TO RELEASE THE STICKING WHICH RESULTS IN OVERCORRECTION. THIS HAS CREATED A DANGEROUS SITUATION ON SEVERAL OCCASIONS. AFTER MUCH RESEARCH IT…
Read full complaint
POWER STEERING STICKS ON HOT DAYS TYPICALLY ABOVE 80 DEGREES. PROBLEM USUALLY OCCURS ON THE HIGHWAY AT SPEEDS ABOVE 50 MPH BUT HAS HAPPENED AT LOWER SPEEDS AS WELL. IT TAKES EXCESSIVE FORCE TO RELEASE THE STICKING WHICH RESULTS IN OVERCORRECTION. THIS HAS CREATED A DANGEROUS SITUATION ON SEVERAL OCCASIONS. AFTER MUCH RESEARCH IT APPEARS THAT THIS IS A SIGNIFICANT ISSUE IN 2004 Z4'S. I DON'T UNDERSTAND WHY BMW HASN'T VOLUNTARILY HAD A RECALL OR WHY NHTSA HASN'T DEMANDED ONE. THIS IS A DANGEROUS SITUATION IDENTIFIED BY MANY Z4 OWNERS. *TR
NHTSA ODI #10430004
91,500 miles · Sep 19, 2011
Air BagsSteering
WHEN I WAS DRIVING HOME FROM WORK TODAY MY CAR EXPERIENCED A POWER STEERING ISSUE WHERE THE STEERING WHEEL WOULD "FREEZE" OR "STICK" IN ONE PLACE. I HAD TO EXERT A LOT OF FORCE ON THE WHEEL TO GET THE STEERING WHEEL TO MOVE BUT WHEN IT "BROKE FREE" IT TURNED A LOT WITH THE HELP OF THE POWER STEERING PUMP BECAUSE I WAS PUTTING S…
Read full complaint
WHEN I WAS DRIVING HOME FROM WORK TODAY MY CAR EXPERIENCED A POWER STEERING ISSUE WHERE THE STEERING WHEEL WOULD "FREEZE" OR "STICK" IN ONE PLACE. I HAD TO EXERT A LOT OF FORCE ON THE WHEEL TO GET THE STEERING WHEEL TO MOVE BUT WHEN IT "BROKE FREE" IT TURNED A LOT WITH THE HELP OF THE POWER STEERING PUMP BECAUSE I WAS PUTTING SO MUCH FORCE ON THE WHEEL TO GET IT TO MOVE. I HAD A HARD TIME KEEPING THE CAR IN MY LANE. THE POWER STEERING WAS DOING THIS THE ENTIRE DRIVE HOME OF 20 MILES. THE CAR WAS VERY UNSAFE TO DRIVE AND THIS ISSUE NEEDS TO BE FIXED SINCE IT IS A HAZARD. IF THE POWER STEERING WAS JUST NOT WORKING AT ALL, IT WOULD BE OKAY BECAUSE THEN AT LEAST THE STEERING WHEEL WOULD BE HARD TO MOVE ALL OF THE TIME SO I COULD CONTROL HOW MUCH I TURNED THE STEERING WHEEL ACCURATELY. SINCE THE POWER STEERING WORKS "INTERMITTENTLY" BUT ONLY AFTER I APPLY A LOT OF FORCE ON THE WHEEL TO GET THE WHEEL TO BREAK FREE, THE CAR VEERS VIOLENTLY WHEN THE POWER STEERING ACTUALLY DOES WORK. THIS PROBLEM IS VERY COMMON PER THE WEBSITE AND SHOULD BE RECALLED. THIS FAILURE IS REPORTED TO THE NHTSA ON CARS RANGING FROM 15,000 MILES UP TO OVER 100,000 MILES. THE PROBLEM FROM WHAT I WAS READING, IS MORE EVIDENT IN COLD OR HOT TEMPERATURES. IT WAS 102F OUTSIDE TODAY IN PHOENIX ON MY DRIVE HOME. THE PASSENGER AIR BAG SEAT SENSOR WAS FLASHING ON AND OFF WHEN THERE WAS A PASSENGER. THE AIR BAG MALFUNCTION LIGHT TURNED ON AFTER THIS. I DO NOT KNOW IF THE AIRBAG WILL INFLATE IF THERE IS A PASSENGER IN THE CAR OR NOT. BMW STATES MY CAR IS NOT COVERED UNDER THE RECALL ACCORDING TO THE VIN BUT THE CAR FITS THE MODEL, MAKE, AND YEAR OF THE PRESENT RECALL. HOW CAN MY CAR HAVE THE SAME PROBLEMS AS THE RECALL DESCRIBES, BE THE SAME MAKE/MODEL/YEAR, BUT NOT BE COVERED UNDER THE RECALL? THANKS FOR YOUR TIME! [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6) *KB
NHTSA ODI #10426364
Mileage unknown · Sep 12, 2011
Steering
ON HOT DAYS THE STEERING WILL CATCH AND REQUIRE UNUSUALLY HIGHER FORCE TO STEER RIGHT OR LEFT. LATER AT NIGHT WHEN THE CAR IS COOLER THE STEERING WILL BE NORMAL. *TR
ON CERTAIN PASSENGER VEHICLES, UNDER CERTAIN ENVIRONMENTAL CONDITIONS, A VAPOR LOCK IN THE FUEL PUMP COULD OCCUR CAUSING THE ENGINE TO STALL. IF THIS WERE TO HAPPEN, THE ENGINE WOULD NOT BE ABLE TO BE RESTARTED FOR APPROXIMATELY 15 TO 20 MINUTES.
Consequence & remedy
Consequence: IF STALLING WERE TO OCCUR, THE DRIVER WOULD BE UNABLE TO MAINTAIN VEHICLE SPEED OR ACCELERATE, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSTALL A RESISTOR IN THE ELECTRICAL LINE POWERING THE FUEL PUMP IN ORDER TO PREVENT AN OCCURRENCE OF VAPOR LOCK. THE RECALL BEGAN MAY 11, 2004. OWNERS SHOULD CONTACT BMW AT 1-800-831-1117.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2
PE10020 · Sticky Steering
Opened Jun 28, 2010 · Closed Jun 28, 2011
Status: closed (inferred from source dates) · Steering; Steering:column; Steering:electric Power Assist System
ODI has evaluated the sticky steering condition, which included reviews of complaints and warranty claims, interviews and surveys of owners of complaint vehicles, road tests of complaint vehicles, and a review of BMW's engineering and test data.ODI found the sticky steering condition does not result in a significant steering effort, thus the impact on the driver's ability to control the vehicle does not appear to be significant.A safety-related defect trend has not been identified at this time and further use of agency resources does not appear to be warranted.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that no safety-related defect exists.The agency will monitor the issue and reserves the right to take future action if warranted by the circumstances.See the attached report for additional information.In addition, during this investigation, ODI became aware of allegations of failure or loss of electric power-assisted steering on the subject vehicles.As a result, ODI is separately reviewing this issue to determine whether additional agency action is needed.
Additional source detail variants (3)
Steering
ODI has evaluated the sticky steering condition, which included reviews of complaints and warranty claims, interviews and surveys of owners of complaint vehicles, road tests of complaint vehicles, and a review of BMW's engineering and test data.ODI found the sticky steering condition does not result in a significant steering effort, thus the impact on the driver's ability to control the vehicle does not appear to be significant.A safety-related defect trend has not been identified at this time and further use of agency resources does not appear to be warranted.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that no safety-related defect exists.The agency will monitor the issue and reserves the right to take future action if warranted by the circumstances.See the attached report for additional information.In addition, during this investigation, ODI became aware of allegations of failure or loss of electric power-assisted steering on the subject vehicles.As a result, ODI is separately reviewing this issue to determine whether additional agency action is needed.
Steering:column
ODI has evaluated the sticky steering condition, which included reviews of complaints and warranty claims, interviews and surveys of owners of complaint vehicles, road tests of complaint vehicles, and a review of BMW's engineering and test data.ODI found the sticky steering condition does not result in a significant steering effort, thus the impact on the driver's ability to control the vehicle does not appear to be significant.A safety-related defect trend has not been identified at this time and further use of agency resources does not appear to be warranted.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that no safety-related defect exists.The agency will monitor the issue and reserves the right to take future action if warranted by the circumstances.See the attached report for additional information.In addition, during this investigation, ODI became aware of allegations of failure or loss of electric power-assisted steering on the subject vehicles.As a result, ODI is separately reviewing this issue to determine whether additional agency action is needed.
Steering:electric Power Assist System
ODI has evaluated the sticky steering condition, which included reviews of complaints and warranty claims, interviews and surveys of owners of complaint vehicles, road tests of complaint vehicles, and a review of BMW's engineering and test data.ODI found the sticky steering condition does not result in a significant steering effort, thus the impact on the driver's ability to control the vehicle does not appear to be significant.A safety-related defect trend has not been identified at this time and further use of agency resources does not appear to be warranted.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that no safety-related defect exists.The agency will monitor the issue and reserves the right to take future action if warranted by the circumstances.See the attached report for additional information.In addition, during this investigation, ODI became aware of allegations of failure or loss of electric power-assisted steering on the subject vehicles.As a result, ODI is separately reviewing this issue to determine whether additional agency action is needed.
EA08001 · BMW Airbag Light Illumination
Opened Jan 4, 2008 · Closed Dec 31, 2008
Status: closed (inferred from source dates) · Air Bags; Air Bags:frontal; Air Bags:frontal:sensor/control MODULE-INACTIVE
BMW IS CONDUCTING A SAFETY RECALL CAMPAIGN ON APPROXIMATELY 200,000 MY04 THROUGH MY06 SUBJECT VEHICLES BUILT THROUGH 11/30/05 TO CORRECT THE FRONT PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT. THE SPECIFIC VEHICLES INCLUDED IN THE RECALL AREMY04- 06/ 5-SERIES WITH STANDARD AND SPORT SEATS, MY04-06/ X3-SERIES AND MY06/ 3-SERIES WITH SPORT SEATS. IN ADDITION, BMW WILL EXTEND THE WARRANTY COVERAGE OF THE PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT TO 10-YEAR/UNLIMITED MILEAGE ON APPROXIMATELY 120,000 REMAINING MY04-06 SUBJECT VEHICLES BUILT THROUGH 11/30/05. THE SPECIFIC VEHICLES INCLUDED IN THE EXTENDED WARRANTY ARE MY 06/ 6 SERIES, MY 06/ 3-SERIES WITH STANDARD SEATS, MY04-05/ Z4, MY04-06/ 7 SERIES, MY 06/ X5, AND MY04-06/ 5-SERIES WITH COMFORT SEATS.THE AVERAGE FREQUENCY OF FAILURES AMONG THE EXTENDED WARRANTY GROUPS WAS LESS THAN 1/7TH OF THE RECALL VEHICLE GROUPS.PLEASE SEE BMW'S 08V-384 RECALL NOTIFICATION FOR FURTHER DETAILSDEPENDING ON SEAT CONFIGURATION AND VEHICLE GEOMETRY, THE OCCUPANT DETECTION MAT CAN FATIGUE DURING USE DEPENDING ON THE MANNER AND FREQUENCY OF THE FRONT PASSENGER'S ENTRY AND EXIT.SPECIFICALLY, OVER TIME, MICRO-CRACKS COULD DEVELOP IN THE SIDE FLANKS OF THE MAT CAUSING A BROKEN CIRCUIT.A BROKENCIRCUIT CAN LEAD TO THE DEACTIVATION OF THE PASSENGER AIR BAG AND THE ILLUMINATION OF BOTH THE AIR BAG WARNING LIGHT AND THE PASSENGER AIR BAG LIGHT.
Additional source detail variants (3)
Air Bags
BMW IS CONDUCTING A SAFETY RECALL CAMPAIGN ON APPROXIMATELY 200,000 MY04 THROUGH MY06 SUBJECT VEHICLES BUILT THROUGH 11/30/05 TO CORRECT THE FRONT PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT. THE SPECIFIC VEHICLES INCLUDED IN THE RECALL AREMY04- 06/ 5-SERIES WITH STANDARD AND SPORT SEATS, MY04-06/ X3-SERIES AND MY06/ 3-SERIES WITH SPORT SEATS. IN ADDITION, BMW WILL EXTEND THE WARRANTY COVERAGE OF THE PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT TO 10-YEAR/UNLIMITED MILEAGE ON APPROXIMATELY 120,000 REMAINING MY04-06 SUBJECT VEHICLES BUILT THROUGH 11/30/05. THE SPECIFIC VEHICLES INCLUDED IN THE EXTENDED WARRANTY ARE MY 06/ 6 SERIES, MY 06/ 3-SERIES WITH STANDARD SEATS, MY04-05/ Z4, MY04-06/ 7 SERIES, MY 06/ X5, AND MY04-06/ 5-SERIES WITH COMFORT SEATS.THE AVERAGE FREQUENCY OF FAILURES AMONG THE EXTENDED WARRANTY GROUPS WAS LESS THAN 1/7TH OF THE RECALL VEHICLE GROUPS.PLEASE SEE BMW'S 08V-384 RECALL NOTIFICATION FOR FURTHER DETAILSDEPENDING ON SEAT CONFIGURATION AND VEHICLE GEOMETRY, THE OCCUPANT DETECTION MAT CAN FATIGUE DURING USE DEPENDING ON THE MANNER AND FREQUENCY OF THE FRONT PASSENGER'S ENTRY AND EXIT.SPECIFICALLY, OVER TIME, MICRO-CRACKS COULD DEVELOP IN THE SIDE FLANKS OF THE MAT CAUSING A BROKEN CIRCUIT.A BROKENCIRCUIT CAN LEAD TO THE DEACTIVATION OF THE PASSENGER AIR BAG AND THE ILLUMINATION OF BOTH THE AIR BAG WARNING LIGHT AND THE PASSENGER AIR BAG LIGHT.
Air Bags:frontal
BMW IS CONDUCTING A SAFETY RECALL CAMPAIGN ON APPROXIMATELY 200,000 MY04 THROUGH MY06 SUBJECT VEHICLES BUILT THROUGH 11/30/05 TO CORRECT THE FRONT PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT. THE SPECIFIC VEHICLES INCLUDED IN THE RECALL AREMY04- 06/ 5-SERIES WITH STANDARD AND SPORT SEATS, MY04-06/ X3-SERIES AND MY06/ 3-SERIES WITH SPORT SEATS. IN ADDITION, BMW WILL EXTEND THE WARRANTY COVERAGE OF THE PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT TO 10-YEAR/UNLIMITED MILEAGE ON APPROXIMATELY 120,000 REMAINING MY04-06 SUBJECT VEHICLES BUILT THROUGH 11/30/05. THE SPECIFIC VEHICLES INCLUDED IN THE EXTENDED WARRANTY ARE MY 06/ 6 SERIES, MY 06/ 3-SERIES WITH STANDARD SEATS, MY04-05/ Z4, MY04-06/ 7 SERIES, MY 06/ X5, AND MY04-06/ 5-SERIES WITH COMFORT SEATS.THE AVERAGE FREQUENCY OF FAILURES AMONG THE EXTENDED WARRANTY GROUPS WAS LESS THAN 1/7TH OF THE RECALL VEHICLE GROUPS.PLEASE SEE BMW'S 08V-384 RECALL NOTIFICATION FOR FURTHER DETAILSDEPENDING ON SEAT CONFIGURATION AND VEHICLE GEOMETRY, THE OCCUPANT DETECTION MAT CAN FATIGUE DURING USE DEPENDING ON THE MANNER AND FREQUENCY OF THE FRONT PASSENGER'S ENTRY AND EXIT.SPECIFICALLY, OVER TIME, MICRO-CRACKS COULD DEVELOP IN THE SIDE FLANKS OF THE MAT CAUSING A BROKEN CIRCUIT.A BROKENCIRCUIT CAN LEAD TO THE DEACTIVATION OF THE PASSENGER AIR BAG AND THE ILLUMINATION OF BOTH THE AIR BAG WARNING LIGHT AND THE PASSENGER AIR BAG LIGHT.
Air Bags:frontal:sensor/control MODULE-INACTIVE
BMW IS CONDUCTING A SAFETY RECALL CAMPAIGN ON APPROXIMATELY 200,000 MY04 THROUGH MY06 SUBJECT VEHICLES BUILT THROUGH 11/30/05 TO CORRECT THE FRONT PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT. THE SPECIFIC VEHICLES INCLUDED IN THE RECALL AREMY04- 06/ 5-SERIES WITH STANDARD AND SPORT SEATS, MY04-06/ X3-SERIES AND MY06/ 3-SERIES WITH SPORT SEATS. IN ADDITION, BMW WILL EXTEND THE WARRANTY COVERAGE OF THE PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT TO 10-YEAR/UNLIMITED MILEAGE ON APPROXIMATELY 120,000 REMAINING MY04-06 SUBJECT VEHICLES BUILT THROUGH 11/30/05. THE SPECIFIC VEHICLES INCLUDED IN THE EXTENDED WARRANTY ARE MY 06/ 6 SERIES, MY 06/ 3-SERIES WITH STANDARD SEATS, MY04-05/ Z4, MY04-06/ 7 SERIES, MY 06/ X5, AND MY04-06/ 5-SERIES WITH COMFORT SEATS.THE AVERAGE FREQUENCY OF FAILURES AMONG THE EXTENDED WARRANTY GROUPS WAS LESS THAN 1/7TH OF THE RECALL VEHICLE GROUPS.PLEASE SEE BMW'S 08V-384 RECALL NOTIFICATION FOR FURTHER DETAILSDEPENDING ON SEAT CONFIGURATION AND VEHICLE GEOMETRY, THE OCCUPANT DETECTION MAT CAN FATIGUE DURING USE DEPENDING ON THE MANNER AND FREQUENCY OF THE FRONT PASSENGER'S ENTRY AND EXIT.SPECIFICALLY, OVER TIME, MICRO-CRACKS COULD DEVELOP IN THE SIDE FLANKS OF THE MAT CAUSING A BROKEN CIRCUIT.A BROKENCIRCUIT CAN LEAD TO THE DEACTIVATION OF THE PASSENGER AIR BAG AND THE ILLUMINATION OF BOTH THE AIR BAG WARNING LIGHT AND THE PASSENGER AIR BAG LIGHT.
2004 BMW Z4 Problems, Complaints & Recalls | Skip That Year
Illustration