IllustrationSTEERING BINDING WHEN MOVING STEERING TO LEFT OR RIGHT FROM THE CENTER POSITION
2004 BMW Z4
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all Z4 years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
680–25K
12925–50K
10550–75K
4275–100K
26100–150K
2150K+
372 reports with mileage · 39 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Steering. Review the 378 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Air Bags. Review the 18 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 14 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
1 crash reports2 fire reports0 injury reports
Steering complaints
378 reportsSTEERING HAS A "NOTCHED" OR "STICKY" FEEL TO IT WHEN TRAVELING ON HIGHWAYS AT SPEEDS AROUND 50MPH AND HIGHER. WHEN THE NEED TO TURN ARISES AND THE STEERING WHEEL "STICKS" IN THE 'NOTCH", IT REQUIRES EXTRA EFFORT TO GET THE WHEEL OUT OF THE NOTCH, CAUSING "OVER STEER" WITH DIFFICULT RECOVERY. I WON'T LET MY WIFE DRIVE THE Z-4 A…
Read full complaint
STEERING HAS A "NOTCHED" OR "STICKY" FEEL TO IT WHEN TRAVELING ON HIGHWAYS AT SPEEDS AROUND 50MPH AND HIGHER. WHEN THE NEED TO TURN ARISES AND THE STEERING WHEEL "STICKS" IN THE 'NOTCH", IT REQUIRES EXTRA EFFORT TO GET THE WHEEL OUT OF THE NOTCH, CAUSING "OVER STEER" WITH DIFFICULT RECOVERY. I WON'T LET MY WIFE DRIVE THE Z-4 AS I FEEL THIS IS A DANGEROUS CHARACTERISTIC THAT COULD RESULT IN AN ACCIDENT. MY DEALER WAS NOTIFIED OF THE SITUATION BUT WAS "UNABLE TO DUPLICATE" THE FAULT; (PRIOR TO MY WARRANTY RUNNING OUT). ON THE FOLLOWING SERVICE, WITH MY RENEWED COMPLAINT, THE DEALER WAS ABLE TO DUPLICATE AND IDENTIFY THE PROBLEM. MY BMW WARRANTY WAS EXPIRED, BUT I HAD PURCHASED AN "EXTENDED WARRANTY", HOWEVER THE "STEERING" PROBLEM WAS NOT COVERED UNDER THE NEW WARRANTY. THE COST FOR REPAIR WAS IN EXCESS OF $3000.00! I HAVE PARKED THE CAR EXCEPT FOR LOCAL SLOW SPEED, COOL DAY RIDES. I UNDERSTAND THAT THE NHTSA HAS LOOKED INTO THE PROBLEM. I HAVE NOT HEARD ANYTHING FROM MY BMW DEALER YET. ??? A COMPUTERIZED "BRAKE SENSOR" LIGHT HAS BEEN ON FOR MANY YEARS AND HAS BEEN UNABLE TO BE REMEDIED. THE DEALER CHECKED THE BRAKES AND THEY ARE FINE, JUST CAN'T GET THE "SENSOR LIGHT" TO STAY OUT. *TR
TL* THE CONTACT OWNS A 2004 BMW Z4. WHILE TRAVELING 65 MPH, THE CONTACT NOTICED THAT THE STEERING WHEEL WOULD CONTINUALLY OVER STEER AND WOULD BECOME STUCK IN POSITION. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE CONTACT WAS INFORMED THAT THE FAILURE COULD NOT BE DUPLICATED. THE VEHICLE WAS NOT REPAIRED. THE CURRENT MILEAGE WA…
Read full complaint
TL* THE CONTACT OWNS A 2004 BMW Z4. WHILE TRAVELING 65 MPH, THE CONTACT NOTICED THAT THE STEERING WHEEL WOULD CONTINUALLY OVER STEER AND WOULD BECOME STUCK IN POSITION. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE CONTACT WAS INFORMED THAT THE FAILURE COULD NOT BE DUPLICATED. THE VEHICLE WAS NOT REPAIRED. THE CURRENT MILEAGE WAS 94,000, AND THE FAILURE MILEAGE WAS 46,000.
THE Z4 HAS AN POWER STEERING PROBLEM THAT SEEMS TO HAVE ISSUES AT HIGHER SPEEDS AND TEMPERATURES WHERE THERE SEEMS TO BE A LOSS OF POWER STEERING WHERE THERE IS A SIGNIFICANTLY INCREASED EFFORT TO TURN THE STEERING WHEEL. I FEEL EXTREMELY UNSAFE DRIVING THE CAR AND DON'T FEEL LIKE I HAVE CONTROL OF THE STEERING AND HAVE A LOT O…
Read full complaint
THE Z4 HAS AN POWER STEERING PROBLEM THAT SEEMS TO HAVE ISSUES AT HIGHER SPEEDS AND TEMPERATURES WHERE THERE SEEMS TO BE A LOSS OF POWER STEERING WHERE THERE IS A SIGNIFICANTLY INCREASED EFFORT TO TURN THE STEERING WHEEL. I FEEL EXTREMELY UNSAFE DRIVING THE CAR AND DON'T FEEL LIKE I HAVE CONTROL OF THE STEERING AND HAVE A LOT OF TROUBLE KEEPING THE CAR IN THE LANE. SOMETIMES THE STEERING FEELS LIKE IT IS STUCK. I THINK THAT THE CAR IS VERY DANGEROUS TO DRIVE AND I AM NOW AFRAID TO DRIVE THE CAR SINCE I AM A WOMAN AND MAY NOT HAVE THE PROPER UPPER BODY STRENGTH TO CONTROL THE CAR! *TR
BROUGHT MY CAR OUT OF STORAGE FOR THE YEAR. WHILE DRIVING IT WOULD PULL BOTH TO THE RIGHT AND TO THE LEFT DEPENDING ON LANE CHOICE. STEERING WHEEL FEELS LIKE IT IS CLICKING FROM ONE POSITION TO ANOTHER. CONSTANT STEERING INPUT REQUIRED TO KEEP IT IN A STRAIGHT LINE. ALIGNMENT IS FINE, TIRES ARE PROPERLY INFLATED AND BALANCED…
Read full complaint
BROUGHT MY CAR OUT OF STORAGE FOR THE YEAR. WHILE DRIVING IT WOULD PULL BOTH TO THE RIGHT AND TO THE LEFT DEPENDING ON LANE CHOICE. STEERING WHEEL FEELS LIKE IT IS CLICKING FROM ONE POSITION TO ANOTHER. CONSTANT STEERING INPUT REQUIRED TO KEEP IT IN A STRAIGHT LINE. ALIGNMENT IS FINE, TIRES ARE PROPERLY INFLATED AND BALANCED. IT'S LIKE THE STEERING WHEEL IS SLIPPING FROM ONE POSITION TO ANOTHER WITHOUT MOVING IT. *TR
ON FIRST HOT DAY OF THE YEAR (85 DEGREES F), THE CAR WAS VERY DIFFICULT TO STEER AT HIGHWAY SPEEDS. IT FELT LIKE THE STEERING WHEEL WAS "STICKING". IT TOOK EXTRA EFFORT TO MOVE THE STEERING WHEEL, CAUSING THE CAR TO TURN MORE THAN DESIRED. I FEEL THIS IS VERY DANGEROUS. *KB
AFTER PURCHASING THE VEHICLE (A 2004 BMW Z4 WITH ONLY 34500 MILES) ON THE WAY HOME I NOTICED A "STICKING" IN THE STEERING WHEEL AT HIGHWAY SPEEDS (APPROXIMATELY 1ST WEEK OF FEBRUARY 2012). WHICH OF COURSE WAS VERY DISAPPOINTING BEING THAT I HAD ONLY OWNED THE CAR FOR ABOUT 30 MINUTES. BUT CONSIDERING THE MILEAGE AND AGE OF THE C…
Read full complaint
AFTER PURCHASING THE VEHICLE (A 2004 BMW Z4 WITH ONLY 34500 MILES) ON THE WAY HOME I NOTICED A "STICKING" IN THE STEERING WHEEL AT HIGHWAY SPEEDS (APPROXIMATELY 1ST WEEK OF FEBRUARY 2012). WHICH OF COURSE WAS VERY DISAPPOINTING BEING THAT I HAD ONLY OWNED THE CAR FOR ABOUT 30 MINUTES. BUT CONSIDERING THE MILEAGE AND AGE OF THE CAR I HOPED IT WAS BECAUSE THE CAR HAD BEEN SITTING FOR SOMETIME. I WAS WRONG IT IS BECOMING MORE AND MORE OF A PROBLEM. AFTER VERY LITTLE RESEARCH I'VE FOUND THAT THIS IS APPARENTLY A VERY COMMON PROBLEM WITH THESE CARS. APPARENTLY IT IS DUE TO EXPANSION OF A GEAR IN THE STEERING COLUMN DUE TO HEAT. I AM VERY DISAPPOINTED. I FELT I HAD FOUND A GOOD CAR CONSIDERING THE VERY LOW MILEAGE. I'VE FOUND THAT MANY PEOPLE HAVE HAD TO HAVE THEIR STEERING COLUMNS REPLACED AT A COST OF OVER 3000 DOLLARS! THIS IS UNBELIEVABLE ON A CAR WITH ONLY 35,000 MILES ON IT! THIS IS DEFINITELY DANGEROUS! FOR THE STEERING WHEEL TO "STICK" AND REQUIRE SIGNIFICANTLY INCREASED EFFORT TO TURN IS A SERIOUS DANGER! THE DANGER OF OVER CORRECTION IS UNDENIABLE. AFTER A RECENT SHORT TRIP DOWN THE HIGHWAY MY FOREARMS WERE VERY FATIGUED AFTER TRYING TO KEEP THIS CAR ON COURSE FOR JUST A FEW MILES.I JUST WONDER HOW MANY WRECKS HAVE BEEN CAUSED BY THIS DEFECT. I FIND IT VERY HARD TO BELIEVE THAT A COMPANY OF BMW'S STATURE WOULD NOT BE DOING EVERYTHING WITHIN ITS POWER TO CORRECT THIS DANGEROUS DEFECT IMMEDIATELY. I GUESS SOMEONE WILL HAVE TO GET HURT FIRST. INSTEAD OF BEING PROACTIVE AND PREVENTING SUCH A DISASTER. OR MAYBE THEY'RE JUST MAKING TOO MUCH MONEY SELLING NEW STEERING COLUMNS TO PEOPLE WHO ARE UNAWARE OF THE DEFECT. SOMETHING HAS TO BE DONE! *TR
I HAVE THE "Z4 STICKY STEERING" PROBLEM WHICH IS WIDELY DOCUMENTED ON THE INTERNET. STEERING IS OK WHEN COLD OR AT LOW SPEEDS AND OCCURS ONLY WHEN TEMPERATURE IS OVER 75 DEGREES F AND AT SPEEDS OVER 45 MPH. THE STEERING WHEEL FIRMLY RESISTS TURNING (STICKS) AND, WHEN ENOUGH FORCE IS APPLIED, FINALLY RELEASES AND TURNS UNTIL AN…
Read full complaint
I HAVE THE "Z4 STICKY STEERING" PROBLEM WHICH IS WIDELY DOCUMENTED ON THE INTERNET. STEERING IS OK WHEN COLD OR AT LOW SPEEDS AND OCCURS ONLY WHEN TEMPERATURE IS OVER 75 DEGREES F AND AT SPEEDS OVER 45 MPH. THE STEERING WHEEL FIRMLY RESISTS TURNING (STICKS) AND, WHEN ENOUGH FORCE IS APPLIED, FINALLY RELEASES AND TURNS UNTIL ANOTHER STICKY ZONE CREATES RESISTANCE. THIS MAKES SLIGHT STEERING CORRECTIONS IMPOSSIBLE AND RESULTS IN A ZIG ZAG RATHER THAT STRAIGHT LINE PATH DOWN THE ROAD. THIS IS A SERIOUS SAFETY ISSUE SINCE THE EFFORT LEVEL IS MUCH TOO HIGH FOR DRIVING AT HIGHWAY SPEED AND COMPROMISES THE ABILITY TO PREDICTABLY CONTROL THE VEHICLE. THE EFFORT LEVEL TO OVERCOME THE STICKINESS IN THE STEERING WHEEL ROTATION IS COMPARABLE TO THAT REQUIRED FOR PARALLEL PARKING OF AN OLD NON POWER STEERING VEHICLE. MY WIFE IS AFRAID TO DRIVE THE CAR ON THE HIGHWAY. I HAVE HAD OTHER CARS RECALLED FOR MUCH LESS SIGNIFICANT ISSUES THAN THIS. *TR
TL* THE CONTACT OWNS A 2004 BMW Z4. WHILE TRAVELING 65 MPH, THE CONTACT NOTICED THAT THE VEHICLE WOULD SWAY FROM RIGHT TO LEFT WHICH MADE IT DIFFICULT TO REMAIN DRIVING IN THE SAME LANE OR IN A STRAIGHT LINE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE CURRENT AND FAILURE MILEAGES WERE 84,000.
TL* THE CONTACT OWNS A 2004 BMW Z4. THE CONTACT WAS DRIVING 55 MPH WHEN THE STEERING WHEEL BECAME DIFFICULT TO STEER. THE VEHICLE WAS TAKEN TO THE DEALER BUT THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 15,000 AND THE CURRENT MILEAGE WAS 62,000.
Official recalls
104V182000 · Fuel System, Gasoline:delivery:fuel Pump
Apr 12, 2004
ON CERTAIN PASSENGER VEHICLES, UNDER CERTAIN ENVIRONMENTAL CONDITIONS, A VAPOR LOCK IN THE FUEL PUMP COULD OCCUR CAUSING THE ENGINE TO STALL. IF THIS WERE TO HAPPEN, THE ENGINE WOULD NOT BE ABLE TO BE RESTARTED FOR APPROXIMATELY 15 TO 20 MINUTES.
Consequence & remedy
Consequence: IF STALLING WERE TO OCCUR, THE DRIVER WOULD BE UNABLE TO MAINTAIN VEHICLE SPEED OR ACCELERATE, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSTALL A RESISTOR IN THE ELECTRICAL LINE POWERING THE FUEL PUMP IN ORDER TO PREVENT AN OCCURRENCE OF VAPOR LOCK. THE RECALL BEGAN MAY 11, 2004. OWNERS SHOULD CONTACT BMW AT 1-800-831-1117.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2PE10020 · Sticky Steering
Opened Jun 28, 2010 · Closed Jun 28, 2011
Status: closed (inferred from source dates) · Steering; Steering:column; Steering:electric Power Assist System
ODI has evaluated the sticky steering condition, which included reviews of complaints and warranty claims, interviews and surveys of owners of complaint vehicles, road tests of complaint vehicles, and a review of BMW's engineering and test data.ODI found the sticky steering condition does not result in a significant steering effort, thus the impact on the driver's ability to control the vehicle does not appear to be significant.A safety-related defect trend has not been identified at this time and further use of agency resources does not appear to be warranted.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that no safety-related defect exists.The agency will monitor the issue and reserves the right to take future action if warranted by the circumstances.See the attached report for additional information.In addition, during this investigation, ODI became aware of allegations of failure or loss of electric power-assisted steering on the subject vehicles.As a result, ODI is separately reviewing this issue to determine whether additional agency action is needed.
Additional source detail variants (3)
Steering
ODI has evaluated the sticky steering condition, which included reviews of complaints and warranty claims, interviews and surveys of owners of complaint vehicles, road tests of complaint vehicles, and a review of BMW's engineering and test data.ODI found the sticky steering condition does not result in a significant steering effort, thus the impact on the driver's ability to control the vehicle does not appear to be significant.A safety-related defect trend has not been identified at this time and further use of agency resources does not appear to be warranted.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that no safety-related defect exists.The agency will monitor the issue and reserves the right to take future action if warranted by the circumstances.See the attached report for additional information.In addition, during this investigation, ODI became aware of allegations of failure or loss of electric power-assisted steering on the subject vehicles.As a result, ODI is separately reviewing this issue to determine whether additional agency action is needed.
Steering:column
ODI has evaluated the sticky steering condition, which included reviews of complaints and warranty claims, interviews and surveys of owners of complaint vehicles, road tests of complaint vehicles, and a review of BMW's engineering and test data.ODI found the sticky steering condition does not result in a significant steering effort, thus the impact on the driver's ability to control the vehicle does not appear to be significant.A safety-related defect trend has not been identified at this time and further use of agency resources does not appear to be warranted.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that no safety-related defect exists.The agency will monitor the issue and reserves the right to take future action if warranted by the circumstances.See the attached report for additional information.In addition, during this investigation, ODI became aware of allegations of failure or loss of electric power-assisted steering on the subject vehicles.As a result, ODI is separately reviewing this issue to determine whether additional agency action is needed.
Steering:electric Power Assist System
ODI has evaluated the sticky steering condition, which included reviews of complaints and warranty claims, interviews and surveys of owners of complaint vehicles, road tests of complaint vehicles, and a review of BMW's engineering and test data.ODI found the sticky steering condition does not result in a significant steering effort, thus the impact on the driver's ability to control the vehicle does not appear to be significant.A safety-related defect trend has not been identified at this time and further use of agency resources does not appear to be warranted.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that no safety-related defect exists.The agency will monitor the issue and reserves the right to take future action if warranted by the circumstances.See the attached report for additional information.In addition, during this investigation, ODI became aware of allegations of failure or loss of electric power-assisted steering on the subject vehicles.As a result, ODI is separately reviewing this issue to determine whether additional agency action is needed.
EA08001 · BMW Airbag Light Illumination
Opened Jan 4, 2008 · Closed Dec 31, 2008
Status: closed (inferred from source dates) · Air Bags; Air Bags:frontal; Air Bags:frontal:sensor/control MODULE-INACTIVE
BMW IS CONDUCTING A SAFETY RECALL CAMPAIGN ON APPROXIMATELY 200,000 MY04 THROUGH MY06 SUBJECT VEHICLES BUILT THROUGH 11/30/05 TO CORRECT THE FRONT PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT. THE SPECIFIC VEHICLES INCLUDED IN THE RECALL AREMY04- 06/ 5-SERIES WITH STANDARD AND SPORT SEATS, MY04-06/ X3-SERIES AND MY06/ 3-SERIES WITH SPORT SEATS. IN ADDITION, BMW WILL EXTEND THE WARRANTY COVERAGE OF THE PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT TO 10-YEAR/UNLIMITED MILEAGE ON APPROXIMATELY 120,000 REMAINING MY04-06 SUBJECT VEHICLES BUILT THROUGH 11/30/05. THE SPECIFIC VEHICLES INCLUDED IN THE EXTENDED WARRANTY ARE MY 06/ 6 SERIES, MY 06/ 3-SERIES WITH STANDARD SEATS, MY04-05/ Z4, MY04-06/ 7 SERIES, MY 06/ X5, AND MY04-06/ 5-SERIES WITH COMFORT SEATS.THE AVERAGE FREQUENCY OF FAILURES AMONG THE EXTENDED WARRANTY GROUPS WAS LESS THAN 1/7TH OF THE RECALL VEHICLE GROUPS.PLEASE SEE BMW'S 08V-384 RECALL NOTIFICATION FOR FURTHER DETAILSDEPENDING ON SEAT CONFIGURATION AND VEHICLE GEOMETRY, THE OCCUPANT DETECTION MAT CAN FATIGUE DURING USE DEPENDING ON THE MANNER AND FREQUENCY OF THE FRONT PASSENGER'S ENTRY AND EXIT.SPECIFICALLY, OVER TIME, MICRO-CRACKS COULD DEVELOP IN THE SIDE FLANKS OF THE MAT CAUSING A BROKEN CIRCUIT.A BROKENCIRCUIT CAN LEAD TO THE DEACTIVATION OF THE PASSENGER AIR BAG AND THE ILLUMINATION OF BOTH THE AIR BAG WARNING LIGHT AND THE PASSENGER AIR BAG LIGHT.
Additional source detail variants (3)
Air Bags
BMW IS CONDUCTING A SAFETY RECALL CAMPAIGN ON APPROXIMATELY 200,000 MY04 THROUGH MY06 SUBJECT VEHICLES BUILT THROUGH 11/30/05 TO CORRECT THE FRONT PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT. THE SPECIFIC VEHICLES INCLUDED IN THE RECALL AREMY04- 06/ 5-SERIES WITH STANDARD AND SPORT SEATS, MY04-06/ X3-SERIES AND MY06/ 3-SERIES WITH SPORT SEATS. IN ADDITION, BMW WILL EXTEND THE WARRANTY COVERAGE OF THE PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT TO 10-YEAR/UNLIMITED MILEAGE ON APPROXIMATELY 120,000 REMAINING MY04-06 SUBJECT VEHICLES BUILT THROUGH 11/30/05. THE SPECIFIC VEHICLES INCLUDED IN THE EXTENDED WARRANTY ARE MY 06/ 6 SERIES, MY 06/ 3-SERIES WITH STANDARD SEATS, MY04-05/ Z4, MY04-06/ 7 SERIES, MY 06/ X5, AND MY04-06/ 5-SERIES WITH COMFORT SEATS.THE AVERAGE FREQUENCY OF FAILURES AMONG THE EXTENDED WARRANTY GROUPS WAS LESS THAN 1/7TH OF THE RECALL VEHICLE GROUPS.PLEASE SEE BMW'S 08V-384 RECALL NOTIFICATION FOR FURTHER DETAILSDEPENDING ON SEAT CONFIGURATION AND VEHICLE GEOMETRY, THE OCCUPANT DETECTION MAT CAN FATIGUE DURING USE DEPENDING ON THE MANNER AND FREQUENCY OF THE FRONT PASSENGER'S ENTRY AND EXIT.SPECIFICALLY, OVER TIME, MICRO-CRACKS COULD DEVELOP IN THE SIDE FLANKS OF THE MAT CAUSING A BROKEN CIRCUIT.A BROKENCIRCUIT CAN LEAD TO THE DEACTIVATION OF THE PASSENGER AIR BAG AND THE ILLUMINATION OF BOTH THE AIR BAG WARNING LIGHT AND THE PASSENGER AIR BAG LIGHT.
Air Bags:frontal
BMW IS CONDUCTING A SAFETY RECALL CAMPAIGN ON APPROXIMATELY 200,000 MY04 THROUGH MY06 SUBJECT VEHICLES BUILT THROUGH 11/30/05 TO CORRECT THE FRONT PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT. THE SPECIFIC VEHICLES INCLUDED IN THE RECALL AREMY04- 06/ 5-SERIES WITH STANDARD AND SPORT SEATS, MY04-06/ X3-SERIES AND MY06/ 3-SERIES WITH SPORT SEATS. IN ADDITION, BMW WILL EXTEND THE WARRANTY COVERAGE OF THE PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT TO 10-YEAR/UNLIMITED MILEAGE ON APPROXIMATELY 120,000 REMAINING MY04-06 SUBJECT VEHICLES BUILT THROUGH 11/30/05. THE SPECIFIC VEHICLES INCLUDED IN THE EXTENDED WARRANTY ARE MY 06/ 6 SERIES, MY 06/ 3-SERIES WITH STANDARD SEATS, MY04-05/ Z4, MY04-06/ 7 SERIES, MY 06/ X5, AND MY04-06/ 5-SERIES WITH COMFORT SEATS.THE AVERAGE FREQUENCY OF FAILURES AMONG THE EXTENDED WARRANTY GROUPS WAS LESS THAN 1/7TH OF THE RECALL VEHICLE GROUPS.PLEASE SEE BMW'S 08V-384 RECALL NOTIFICATION FOR FURTHER DETAILSDEPENDING ON SEAT CONFIGURATION AND VEHICLE GEOMETRY, THE OCCUPANT DETECTION MAT CAN FATIGUE DURING USE DEPENDING ON THE MANNER AND FREQUENCY OF THE FRONT PASSENGER'S ENTRY AND EXIT.SPECIFICALLY, OVER TIME, MICRO-CRACKS COULD DEVELOP IN THE SIDE FLANKS OF THE MAT CAUSING A BROKEN CIRCUIT.A BROKENCIRCUIT CAN LEAD TO THE DEACTIVATION OF THE PASSENGER AIR BAG AND THE ILLUMINATION OF BOTH THE AIR BAG WARNING LIGHT AND THE PASSENGER AIR BAG LIGHT.
Air Bags:frontal:sensor/control MODULE-INACTIVE
BMW IS CONDUCTING A SAFETY RECALL CAMPAIGN ON APPROXIMATELY 200,000 MY04 THROUGH MY06 SUBJECT VEHICLES BUILT THROUGH 11/30/05 TO CORRECT THE FRONT PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT. THE SPECIFIC VEHICLES INCLUDED IN THE RECALL AREMY04- 06/ 5-SERIES WITH STANDARD AND SPORT SEATS, MY04-06/ X3-SERIES AND MY06/ 3-SERIES WITH SPORT SEATS. IN ADDITION, BMW WILL EXTEND THE WARRANTY COVERAGE OF THE PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT TO 10-YEAR/UNLIMITED MILEAGE ON APPROXIMATELY 120,000 REMAINING MY04-06 SUBJECT VEHICLES BUILT THROUGH 11/30/05. THE SPECIFIC VEHICLES INCLUDED IN THE EXTENDED WARRANTY ARE MY 06/ 6 SERIES, MY 06/ 3-SERIES WITH STANDARD SEATS, MY04-05/ Z4, MY04-06/ 7 SERIES, MY 06/ X5, AND MY04-06/ 5-SERIES WITH COMFORT SEATS.THE AVERAGE FREQUENCY OF FAILURES AMONG THE EXTENDED WARRANTY GROUPS WAS LESS THAN 1/7TH OF THE RECALL VEHICLE GROUPS.PLEASE SEE BMW'S 08V-384 RECALL NOTIFICATION FOR FURTHER DETAILSDEPENDING ON SEAT CONFIGURATION AND VEHICLE GEOMETRY, THE OCCUPANT DETECTION MAT CAN FATIGUE DURING USE DEPENDING ON THE MANNER AND FREQUENCY OF THE FRONT PASSENGER'S ENTRY AND EXIT.SPECIFICALLY, OVER TIME, MICRO-CRACKS COULD DEVELOP IN THE SIDE FLANKS OF THE MAT CAUSING A BROKEN CIRCUIT.A BROKENCIRCUIT CAN LEAD TO THE DEACTIVATION OF THE PASSENGER AIR BAG AND THE ILLUMINATION OF BOTH THE AIR BAG WARNING LIGHT AND THE PASSENGER AIR BAG LIGHT.