2021 BMW X7

I am writing to report a critical safety concern regarding BMW vehicles equipped with the B58 Technical Update (B58TU) engine, specifically including my 2021 BMW X7. While my vehicle has not yet experienced a failure, I am filing this report due to the severe safety hazard and widespread nature of the variable-displacement engine oil pump defect. This pump contains an internal thermoplastic adjusting component that is prone to sudden fracture, resulting in an erratic or complete loss of engine oil pressure. According to widespread field reports, when this component fails—often during cold starts in low ambient temperatures—drivers receive little to no actionable warning before engine damage or complete vehicle disablement occurs. This sudden loss of lubrication can cause the vehicle to stall in active traffic or leave occupants stranded in freezing conditions, creating a serious and potentially life-threatening safety risk. Out of deep concern for my family's safety, I recently inquired with my local BMW dealership about preemptively replacing this pump and was quoted a staggering $21,000. It is unacceptable to place this massive financial and safety burden on consumers, especially since BMW has actively removed the plastic part number from dealer networks, making it impossible for owners to verify whether their vehicle contains the defective plastic component or the updated metal design. Given the sudden nature of these failures and the extreme safety risks involved, I strongly urge the NHTSA to open an investigation into this defect and compel BMW to issue a formal recall. Thank you for your prompt attention to this urgent safety matter.

Dear NHTSA Vehicle Safety Hotline Team, I am writing to formally report a serious safety concern regarding my 2021 BMW X7. My vehicle is exhibiting a dangerous condition where it fails to start on the initial attempt, displays a "Repeat Start Attempt" warning message on the dashboard, and then heavily strains to turn over on the second attempt.While I am aware that BMW issued a safety recall (NHTSA Campaign Number 24V-576) regarding starter motor overheating and engine fire risks for certain 2019–2021 models, I believe the current remediation or scope may not fully protect consumers from the immediate hazards of this failure.When the vehicle demands a second start attempt, it forces a high electrical draw that risks severely overheating the starter mechanism. This creates an immediate risk of electrical thermal overload and potential engine compartment fires while trying to get the vehicle moving.Below are the specific details of my vehicle and the safety incident:Vehicle Make and Model: 2021 BMW X7 Vehicle Identification Number: [XXX] Current Mileage: 57226 Incident Description: The vehicle consistently fails its initial ignition sequence. It prompts a "Repeat Start Attempt" notification, forcing a high-stress second startup sequence that poses an immediate electrical fire hazard.I request that the NHTSA review this ongoing issue, ensure that BMW's remedy effectively eliminates the fire risk during these secondary start cycles, and hold the manufacturer accountable for immediate component replacement.Thank you for your prompt attention to this safety matter. I look forward to your investigation. Sincerely, INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

A failed front differential on my 2021 BMW X7 M50i, which currently has approximately 59,000 miles. BMW of Wesley Chapel has diagnosed the front differential as failed and provided an estimated repair cost of approximately $11,500. The Service Manager Stevon Budhu has also submitted a goodwill request on our behalf to BMW I have two young daughters whom I transport daily, and safety is a key reason we selected the BMW X7 as our family vehicle. This type of drivetrain failure at this mileage is unexpected for a premium BMW SUV and is understandably concerning.

The left-side 3rd-row seat on my 2021 BMW X7 is stuck upright and won't fold down to open up cargo space. You can hear the motor trying to work, but the physical latch inside the seat gets completely stuck and won't release. The seat mechanism is available for inspection. This is a major safety hazard because the seat latch is failing. If the seat cannot lock or unlock properly, the structural integrity is compromised. In a crash or under hard braking, the seat back could collapse forward and injure passengers in the back rows. The problem started out as an intermittent glitch a few months ago where it would eventually work after a few tries, but now it is permanently stuck. There were never any warning lights or messages on the dashboard. I called my local BMW dealership about this known, well-documented manufacturing issue, but they refused to offer any warranty coverage or assistance since the standard 4-year factory warranty just expired. It has not been inspected by police or insurance.

While driving my 2021 BMW X7 at approximately 32,000 miles, the vehicle suddenly displayed a drivetrain malfunction warning along with a low engine oil pressure warning. At the same time, I noticed excessive heat and a strong burning smell coming from the vehicle. I also heard abnormal mechanical noises coming from the engine, which sounded like knocking or grinding. The engine failure occurred unexpectedly at relatively low mileage and required extensive repairs, with estimated costs of approximately $15,000. A sudden loss of oil pressure and abnormal engine noises while driving creates a serious safety risk because it can lead to engine damage, loss of power, or the vehicle becoming disabled in traffic without warning. Based on the diagnosis and information from the repair facility, the failure may be related to an internal engine or oil pump issue affecting lubrication. I am reporting this incident because similar failures have been reported by other BMW owners, and I believe this condition warrants investigation as a potential safety-related defect.

very known issue of catastrophic failure to the oil pump, made in Italy with plastic component, used in my vehicle. The part has been updated to metal components on bmw side without any knowledge to the customers with same part number. Faulty xdrive tranfer case, wheel jerks on low speed turning. Currently in class action lawsuit.

Front differential complete fail. 56k miles. Replaced with new part, not an improved one but the same as factory at BMW dealership. My vehicle is 2021 x7 m50i. Reading other forums this is common if not standard on same models of this year. Very upset to have had to come out of pocket $9k to replace. Just outside of warranty. Was told will likely happen again in 50k miles. I wanted to keep this car like I have my other cars well into 170k miles. Looking to sell. Don’t understand how BMW doesn’t recall this.

The contact owns a 2021 BMW X7. The contact stated that while driving at 20 MPH and depressing the accelerator pedal, the vehicle went into LIMP Mode. The message "Pull Over and Turn Off Your Car - You Have Lost All the Water In the Radiator" was displayed. The contact was able to pull over to the side of the road. The vehicle was able to restart, but was towed to Hawkeye Motorsports LLC, where it was diagnosed that the water pump pulley had shattered. The mechanic replaced the coolant pump, coolant lines, and belts. Additionally, the coolant lines were tested. The vehicle was repaired. The manufacturer was contacted and informed that reimbursement assistance could only be provided if the VIN was included in a related recall. The manufacturer referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 79,000.

Front differential needing completely replaced at 44,000 miles. Might need a transfer case replacement as well. Original quote of $8,300 and if the transfer case is needing replaced, another $8,000-$10,000 job. I have done research online that a lot of other people with X7's are having this issue. Autobahn BMW in Fort Worth, Texas confirmed the issue and that it needs complete replacement done. There were no warnings, no lights on the dash, and nothing that would indicate there was an issue until leaking starting and I could smell the oil burning.