2022 BMW X5

On July 8, 2026, the vehicle unexpectedly stalled while I was driving in the middle lane on the I-95 highway, creating a safety concern. There was complete loss of engine power and low power to steering. The vehicle had to be towed to BMW of Peabody, Massachusetts. The vehicle had 30850 miles during the incident. During the inspection at service centre, I was informed that the safety fuse box and 12V auxiliary battery had failed which stalled the vehicle.

I took my 2022 BMW X5 xDrive 45e for concerns of shuddering at low speeds and tight turns under warranty. No warning messages on dashboard. I asked specifically what was causing the shuddering. BMW of Raleigh would not respond. But they found that the Transfer Case was affected so they flushed the oil and put an oil mixture replacement in. According to the most recent BMW service bulletin, the technician is only to put in DTF oil. The technician not only put in DTF oil but also an over-the-counter non-approved chemical additive. Reading the service bulletin, the Transfer Case is supposed to have a lifetime warranty. We were charged over $500 for this "oil change", but it was under warranty. Transfer Case failures can result in accidents on highways and other roadways and complete mechanical failure of vehicle.. The oil change did not fix the Transfer Case issue but extended out the vehicle so that it now falls out of warranty. A TC replacement will cost $10,000 or more out of pocket. TC issues is a known BMW issue since 2018. Lawsuit has begun w/thousands of plaintiffs all over USA w/ 2019-2025 BMWs because they refuse to acknowledge that they are at fault even though they continue to put out bulletins for this exact issue. BMW has made sure that Transfer Case is not on any warranty they offer.

Electronic Shifter goes out when exposed to moisture.. We had the vehicle detailed and it will not move after apparently some moisture got into the shift know that is located next to cup holders.. BMW will not warranty the part and acknowledge it is an issue.. Luckily we have an extended warranty that is covering the 2500.00 part

I am writing to you as a loyal BMW owner to formally lodge a serious complaint regarding a technical safety failure in my BMW X5 and the subsequent dismissive treatment I received at an authorized service center in New York. The Incident Recently, while reversing, the Driving Assistance and Parking Assistant systems failed without warning. As a result, the vehicle collided with an object, causing damage to the rear bumper. This was not a result of driver negligence, but a direct failure of the safety technology that I trusted to protect my family. Service Center Negligence Upon visiting the service center to address this life-threatening defect, I was met with unacceptable indifference. The service advisor flatly refused to investigate the system failure, stating they would only perform a standard NYC Inspection. I was given a follow-up appointment for May 5th—forcing me to wait weeks to address a critical safety defect. Safety Concerns & Demand for Replacement As a father [XXX], I no longer feel safe operating this vehicle. The integrity of the safety modules has been compromised, and my confidence in this specific car is completely shattered. Repairing a bumper does not fix a failed safety system that could have caused a much more serious accident.And when I provide all of this evidence to BMW North America they Lay to me and asked me to take my vehicle without resolving the problem and the doesn’t care about my family safety INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The electric A/C compressor on my 2022 BMW X5 xDrive45e (VIN [XXX] ) failed internally at approximately 59,000 miles, causing metal debris to circulate throughout the refrigerant system. The failed compressor and contaminated components are at BMW of Sterling (Sterling, VA) and available for inspection. This is a safety concern because the A/C refrigerant circuit provides thermal management for the high-voltage hybrid battery. BMW of Sterling's service advisor confirmed in writing that the A/C system is "a critical component of your vehicle's HV system," that there is no independent backup cooling system, and that the failure "can cause potential high voltage battery failures." Without active cooling, the HV battery is at risk of overheating, which could result in a thermal event. The failure was diagnosed and confirmed by BMW of Sterling. They categorized the repair as "EHV: FULLY ELECTRIC OR HYBRID VEHICLE DRIVETRAIN DIAGNOSTICS" with the complaint "HIGH VOLTAGE SYSTEM ERROR." The repair estimate is $11,356.59 and requires replacement of the compressor, condenser, all expansion valves, and a double system flush. BMW Service Information Bulletin SI B64 09 21 documents this exact failure pattern for the G05 X5 xDrive45e, and BMW created a dedicated repair kit (part 64 50 5 A5B 590) for it. This is my second major HV component failure. A battery cell replacement was performed under warranty in 2025. Both failures were confirmed by the dealership to be component defects unrelated to owner use. Prior to complete failure, a fan noise was present in the front driver's area for a period of time before it stopped, consistent with the compressor degrading before failing entirely. A high voltage system error was displayed. BMW NA (case #XXX) has declined warranty coverage despite the vehicle being within the 8-year/80,000-mile HV battery warranty. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

I was driving my 2022 BMW X5 on the highway at approximately 78 mph when the vehicle suddenly and unexpectedly applied the brakes without any obstruction or vehicle in front of me. A warning appeared instructing me to release the brakes while driving. This created a dangerous situation and could have caused a rear-end collision. The vehicle has approximately 34,000 miles. This appears to be a malfunction of the automatic emergency braking system. This happened on 2 seperate occasions.

The front Continental PremiumContact 6 tires, size 275/35ZR22, DOT [XXX] , developed abnormal and premature tread/shoulder failure. The condition included splitting, tearing, separation along the shoulder area, and exposed internal cords. I first raised concerns about the tire condition at about 20,000 miles. An alignment was performed at 20,142 miles, but the condition later worsened. One of the front tires deteriorated while the vehicle was being driven, creating a serious safety risk. The condition was documented with photographs and dashcam evidence. The vehicle was not safely drivable on the affected tire. The full set was later replaced based on BMW’s recommendation, at a cost of $2,358.75. A warranty/defect claim was submitted through the BMW / Dealer Tire / Continental process, but I did not receive a clear manufacturer-level inspection explanation or meaningful response. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

While driving, the vehicle displayed a 'Drivetrain malfunction' warning on the dashboard and began jerking. I safely pulled over and turned off the vehicle. Immediately after stopping, there was a distinct, strong electrical burning smell coming from the engine compartment. The vehicle was inspected by an authorized BMW dealership. The dealer diagnosed a catastrophic failure of the starter motor. The vehicle's computer logged fault codes 21611A (excessive counter-torque), 21A511 (Start system: Timeout), and 216119 (Line disconnection). These codes confirm the starter motor suffered a severe electrical overload and thermal event. This premature failure and fire hazard identically matches the safety risks outlined in BMW's recent massive starter motor recalls (such as NHTSA Recalls 25V-636 and 26V-056), but my specific vehicle is currently excluded from those recall campaigns. The starter requires complete replacement due to this overheating damage

I am writing to formally express my concern regarding serious and repeated safety-related failures with my 2022 BMW X5 xDrive45e, VIN [XXX] . I purchased this vehicle in 2022 through a custom build, at a purchase price exceeding $80,000, with the expectation of reliability, safety, and premium quality consistent with the BMW brand. In October 2025, while my wife was driving with my son in the vehicle, the hybrid component safety box failed without warning, causing the vehicle to stall on the roadway. This created a dangerous situation for my family. The vehicle was towed to the dealership, repaired, and returned to me on November 4, 2025. Unfortunately, on February 3, 2026, a second serious incident occurred. After my wife picked up my son from school, the vehicle began jerking violently while driving, and a strong sulphur-like odor entered the cabin. Fearing for their safety, she immediately stopped driving. The vehicle was again towed to BMW of Jackson. I was informed today by the service advisor that the failure is due to another hybrid-related component, specifically the EME Hybrid Inverter, and that BMW North America is declining to cover this repair under warranty. These repeated hybrid system failures are deeply concerning, particularly given that both incidents involved my wife and children and posed clear safety risks. As a result, both of my children are now fearful of riding in the vehicle, and this situation has caused significant emotional distress to my family. Given the nature of these failures, the vehicle’s purchase price, and BMW’s emphasis on safety and engineering excellence, I find it unacceptable that a critical hybrid component failure would not be covered under warranty—especially following a prior hybrid system failure less than four months earlier. I am requesting that BMW North America review this matter promptly and provide a reasonable resolution, including warranty coverage for the EME Hybrid Inverter repair. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA