IllustrationFREQUENT ISSUES WITH DEF ACTIVE/PASSIVE TANKS AND SENSORS AND THE DEALER RUNS ABOUT $2500 UPWARD CHARGES FOR EACH OF THESE REPAIRS. THE COMPLETE X5 DIESEL IS FULL OFF ISSUES COMPARED TO THEIR 35I
2012 BMW X5
Owner reports · Recalls · Investigations
More warning signs than most X5 years
Owner complaints for the 2012 BMW X5 are substantially higher than the model-year median of 100.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all X5 years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
210–25K
2025–50K
4750–75K
3975–100K
27100–150K
3150K+
157 reports with mileage · 114 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Engine. Review the 92 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Air Bags. Review the 83 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 53 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
4 crash reports10 fire reports4 injury reports
Fuel/propulsion System complaints
24 reportsDIESEL ENGINE, SCR PASSIVE TANK/SENSOR NEEDS REPLACE. BMW DEALER SAID ITS NOT COVERED IN THE WARRANTY (EXTENDED WARRANTY OF 10Y/120K MILES, BUT SCR ACTIVE TANK/SENSOR IS COVERED. WHAT? MY MILEAGE 94K MILES). PASSIVE TANK STILL PART OF THE EMISSIONS SYSTEMS. COST IS $3K REPAIR. I DON'T UNDERSTAND (BMW) PUT THE SENSOR BUILT INTO…
Read full complaint
DIESEL ENGINE, SCR PASSIVE TANK/SENSOR NEEDS REPLACE. BMW DEALER SAID ITS NOT COVERED IN THE WARRANTY (EXTENDED WARRANTY OF 10Y/120K MILES, BUT SCR ACTIVE TANK/SENSOR IS COVERED. WHAT? MY MILEAGE 94K MILES). PASSIVE TANK STILL PART OF THE EMISSIONS SYSTEMS. COST IS $3K REPAIR. I DON'T UNDERSTAND (BMW) PUT THE SENSOR BUILT INTO THE TANK. I'M SURE A LOT OF BMW OWNERS WILL RUN INTO THIS ISSUE COSTING LOTS OF DOLLARS AND PROFIT FOR BMW. NEED TO GET BMW TO COVER THIS COST.
CHECK ENGINE LIGHT CAME ON AND BMW SERVICE CENTER TOLD ME THE SENSORS IN THE PASSIVE DIESEL EXHAUST FLUID TANK FAILED AND ENTIRE TANK NEEDS TO BE REPLACED. BMW EXTENDED THE WARRANTY ON THE ACTIVE TANK, BUT NOT PASSIVE. THINK ITS RIDICULOUS THAT ONLY ONE TANK IS COVERED WHILE THE PASSIVE IS NOT. THIS IS A WELL-DOCUMENTED ISSUE…
Read full complaint
CHECK ENGINE LIGHT CAME ON AND BMW SERVICE CENTER TOLD ME THE SENSORS IN THE PASSIVE DIESEL EXHAUST FLUID TANK FAILED AND ENTIRE TANK NEEDS TO BE REPLACED. BMW EXTENDED THE WARRANTY ON THE ACTIVE TANK, BUT NOT PASSIVE. THINK ITS RIDICULOUS THAT ONLY ONE TANK IS COVERED WHILE THE PASSIVE IS NOT. THIS IS A WELL-DOCUMENTED ISSUE ON BMW'S DIESEL.
THE DIESEL EXHAUST FLUID PASSIVE TANK IN MY BMW X5 HAS FAILED, WHICH FROM WHAT I'VE READ IN MANY FORUMS IS AN UNACCEPTABLY COMMON OCCURRENCE. WHILE TAKING THE CAR INTO THE DEALERSHIP TO HAVE THREE OTHER RECALLS ADDRESSED I ASKED ABOUT THE TANK BEING COVERED IN THE EXTENDED EMMISSIONS WARRANTY ON THE CAR. THEY INFORMED ME THAT TH…
Read full complaint
THE DIESEL EXHAUST FLUID PASSIVE TANK IN MY BMW X5 HAS FAILED, WHICH FROM WHAT I'VE READ IN MANY FORUMS IS AN UNACCEPTABLY COMMON OCCURRENCE. WHILE TAKING THE CAR INTO THE DEALERSHIP TO HAVE THREE OTHER RECALLS ADDRESSED I ASKED ABOUT THE TANK BEING COVERED IN THE EXTENDED EMMISSIONS WARRANTY ON THE CAR. THEY INFORMED ME THAT THE MAIN DIESEL EXHAUST FLUID TANK IS COVERED (WHICH THEY REPLACED BECAUSE IT HAD FAILED TOO), BUT THE RESERVE OR PASSIVE TANK WAS NOT COVERED UNDER THE WARRANTY. NOW THERE IS A COUNTDOWN ON THE DASH THAT IF I DRIVE OVER 900 MILES WITHOUT FIXING IT THE CAR WILL KNOW LONGER START. I HAVE HAD MY DIESEL EXHAUST FLUID FILLED MULTIPLE TIMES BUT THE MESSAGE RETURNS IMMEDIATELY. TO REPLACE THE DEFECTIVE TANK IS $2,500. I'M MAKING A COMPLAINT BECAUSE AS I SAID THIS IS A WIDESPREAD ISSUE WITH THIS PART AND IF BMW REALIZES THERE IS A DEFECT ON THE MAIN TANK, WHY WOULDN'T THEY ALSO REPLACE THE PASSIVE TANK UNDER EXTENDED WARRANTY?
I'M WRITING TO YOU REGARDING MY 2012 BMW X5M. ON OCTOBER 8, 2017 I WAS DRIVING MY CAR AND SUDDENLY THE CHECK ENGINE LIGHT CAME UP AND ALMOST IMMEDIATELY THE CAR LOST POWER AND A VERY LOUD BANGING NOISE START COMING UP FROM THE FRONT OF THE CAR. I WAS IN THE MIDDLE OF A BUSY INTERSECTION WHEN THIS HAPPENED AND THE CAR COULD BAREL…
Read full complaint
I'M WRITING TO YOU REGARDING MY 2012 BMW X5M. ON OCTOBER 8, 2017 I WAS DRIVING MY CAR AND SUDDENLY THE CHECK ENGINE LIGHT CAME UP AND ALMOST IMMEDIATELY THE CAR LOST POWER AND A VERY LOUD BANGING NOISE START COMING UP FROM THE FRONT OF THE CAR. I WAS IN THE MIDDLE OF A BUSY INTERSECTION WHEN THIS HAPPENED AND THE CAR COULD BARELY MOVE. I PULLED OVER AS SOON AS I WAS OUT OF THE INTERSECTION AND GOT THE CAR TOWED TO THE NEAREST BMW AUTHORIZE DEALER - BMW OF SILVER SPRING, MD (3211 AUTOMOBILE BLVD, SILVER SPRING, MD 20904). AFTER A FEW CONVERSATIONS WITH THE DEALER I WAS TOLD THAT I HAVE TO REPLACE THE ENTIRE ENGINE AND THAT THERE WILL BE NO EFFORT MADE TO DETERMINE THE REASON FOR THE ENGINE FAILURE. THE CAR IS A WELL MAINTAINED VEHICLE AND I HAVE RECORDS FOR ALL THE MAINTENANCE WORK DONE. THAT INCLUDES OIL CHANGES DONE EVERY 5,000- 7,000 MILES. I TOLD THE DEALER THAT I SUSPECT THE ISSUE COULD BE A FAULTY FUEL INJECTOR. THE SYMPTOMS I SHARED WITH THE BMW DEALER WERE ROUGH STARTS, ROUGH IDLE AND FUEL SMELL WERE PRESENT ESPECIALLY THE DAY WE TOWED THE CAR IN. THE DEALER REFUSED TO ACCEPT ANY OF THE SHARED INFORMATION AND DENIED MY REQUEST FOR THE FUEL INJECTORS TO BE CHECKED ALTHOUGH THEY ARE UNDER EXTENDED WARRANTY. AS A RESULT, I WAS GIVEN NO CHOICE BUT PAY THE COST OF THE ENTIRE ENGINE REPLACEMENT. THE DEALER REFUSED TO GIVE ME THE OLD ENGINE BACK BECAUSE I WANTED IT INSPECTED TO CHECK WHETHER A FAULTY INJECTOR WAS THE REASON FOR THE ENGINE FAILURE.
TL* THE CONTACT OWNS A 2012 BMW X5. WHILE DRIVING APPROXIMATELY 30 MPH, THE CHECK ENGINE WARNING AND LOW POWER MODE INDICATORS ILLUMINATED. THE VEHICLE WAS TAKEN TO WALSER BMW AUTO CAMPUS OF WICHITA (11000 E 13TH ST N, WICHITA, KS 67206, PHONE: (316) 221-3841) WHERE IT WAS DIAGNOSED THAT THE HIGH PRESSURE FUEL PUMP FAILED AND NE…
Read full complaint
TL* THE CONTACT OWNS A 2012 BMW X5. WHILE DRIVING APPROXIMATELY 30 MPH, THE CHECK ENGINE WARNING AND LOW POWER MODE INDICATORS ILLUMINATED. THE VEHICLE WAS TAKEN TO WALSER BMW AUTO CAMPUS OF WICHITA (11000 E 13TH ST N, WICHITA, KS 67206, PHONE: (316) 221-3841) WHERE IT WAS DIAGNOSED THAT THE HIGH PRESSURE FUEL PUMP FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. IN ADDITION, WHILE ATTEMPTING TO DRIVE THE VEHICLE, THE CHECK ENGINE AND LOW POWER MODE INDICATORS ILLUMINATED AGAIN. THE VEHICLE WAS TAKEN BACK TO WALSER BMW WHERE IT WAS DIAGNOSED THAT THE VANOS SOLENOID FAILED, THERE WERE METAL SHAVINGS IN THE OIL, AND THE ENGINE NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT CONTACTED. THE APPROXIMATE FAILURE MILEAGE WAS 75,140. *TT CONSUMER STATED BMW CUSTOMER CARE PACKAGE B001314 WAS COMPLETED BY BMW BEFORE CONSUMER PURCHASED THE VEHICLE. AT APPROX. 36,000 MILES. FROM CONSUMER'S FIRST BMW SERVICE, THE BMW SERVICE MANAGER TOLD THE CONSUMER HE WOULD HAVE CONTINUOUS PROBLEM AS THE N63 ENGINE WAS NOTORIOUS FOR TROUBLE. UPDATED 9/4/18*JB
HESITATION STARTING THE CAR, DIAGNOSIS BY DEALER WAS FUEL PUMP FAILING. MILEAGE WAS 65,000. COST TO REPAIR 1500.00. I SEE THERE WAS A RECALL FOR MODEL YEARS 2008-2011.
AN ENGINE LIGHT COMES ON WHEN HARD BREAKING. SOME TIME THE LIGHTS GO OFF AFTER NEXT REFUELING. WHEN CHECK IN, THE COMPUTER INDICATE SOME PROBLEM WITH SENSOR RELATED TO FUEL TANK.
ENGINE LOSE POWER AT HIGHWAY SPEED DUE TO FUEL PUMP!! IT HAPPENED MORE THAN ONCE ON THE HIGHWAY AND CAR WON'T GO TO THE POSTED SPEED LIMIT. TURN CAR OFF AND RESTART AGAIN EVERYTHING WORKS FINE FOR FEW DAYS.
BOUGHT IT USED 58K MILES , ON FIRST DAY THE BATTERY DIED, TOOK IT TO BMW DEALER, LABOR+PARTS+PROGRAMMING $475! ONLY AFTER 4YRS THE BATTERY FAILED ? AFTER 2 MONTHS ENGINE OVERHEATING, TOWED THE CAR TO THE DEALER, WATER BUMP +THERMOSTAT +FLUSHING COOLANT AND A FEW MORE FLUSHING ALL TRANS, ETC PLUS ALIMENT, $1800 FOR WATER BUM…
Read full complaint
BOUGHT IT USED 58K MILES , ON FIRST DAY THE BATTERY DIED, TOOK IT TO BMW DEALER, LABOR+PARTS+PROGRAMMING $475! ONLY AFTER 4YRS THE BATTERY FAILED ? AFTER 2 MONTHS ENGINE OVERHEATING, TOWED THE CAR TO THE DEALER, WATER BUMP +THERMOSTAT +FLUSHING COOLANT AND A FEW MORE FLUSHING ALL TRANS, ETC PLUS ALIMENT, $1800 FOR WATER BUMP AND THERMOSTAT+ THE OTHER THINGS ALL TOGETHER CAME UP TO $2500 AFTER$300 DISCOUNT, WE WENT TO PICKUP THE CAR ASKED FOR DISCOUNT AND GOT THE BILL DOWN TO $1978. VERY VERY DISAPPOINTED ABOUT THE QUALITY OF BMW AND ELECTRIC WATER PUMP THAT FAILS AND NEEDS TO BE REPLACED ON ALMOST EVERY BMW ONLY AFTER LIKE 30K AND UP? UNLIKE OTHER CARS WATER PUMP WILL FAIL AFTER 150K-200K MILES.
Official recalls
1020V016000 · Air Bags:frontal:passenger Side:inflator Module
Jan 15, 2020
BMW of North America, LLC (BMW) is recalling certain 2009-2012 X5 xDrive35d, 2008-2012 X6 xDrive35i, X6 xDrive50i and X6 M, 2007-2012 X5 30si, X5 xDrive30i, X5 xDrive35i, X5 48i, X5 xDrive48i, X5 xDrive50i and X5 M and 2010-2011 X6 ActiveHybrid vehicles equipped with non-desiccated, passenger frontal air bag inflators containing phase stabilized ammonium nitrate (PSPI-2) propellant that were used as interim remedy parts for previous Takata recalls. These inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Owners are advised not to drive their vehicles until this remedy is performed. BMW will notify owners, and dealers will replace the passenger front air bag, free of charge. The recall began March 11, 2020. Owners may contact BMW customer service at 1-800-525-7417.
20V017000 · Air Bags:frontal:driver Side:inflator Module
Jan 15, 2020
BMW of North America, LLC (BMW) is recalling certain 2008-2013 128i and 135i Convertibles, 128i, 135i, and M Coupes, 2007-2010 X3 30si and X3 xDrive30i, 2013-2015 X1 sDrive28i, X1 xDrive28i and X1 xDrive35i, 2007-2013 328i, 328i xDrive, 335i, 335is, 335i xDrive and M3 Coupes, 2006-2011 328i, 328xi, 328i xDrive, 325i, 325xi, 330i, 330xi, 335i, 335xi, 335i xDrive and M3, 2009-2011 335D, 2006-2012 325xi, 328i, 328xi and 328i xDrive, 2010-2011 X6 ActiveHybrid, 2007-2013 328i, 335i, 335is, M3 Coupes, X5 30si, X5 xDrive30i, X5 xDrive35i, X5 48i, X5 xDrive48i, X5 xDrive50i and X5 M, 2009-2013 X5 xDrive35d and 2008-2014 X6 xDrive35i, X6 xDrive50i and X6M vehicles equipped with non-desiccated driver frontal air bag inflators containing phase stabilized ammonium nitrate (PSAN) that were used as interim remedy parts for previous Takata recalls. These inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: BMW will notify owners, and dealers will replace the driver air bag. On X5 and X6 vehicles, only the inflator will be replaced. All repairs will be performed free of charge. The recall began March 11, 2020. Owners may contact BMW customer service at 1-800-525-7417.
19V017000 · Air Bags:frontal:passenger Side:inflator Module
Jan 14, 2019
BMW of North America, LLC (BMW) is recalling certain 2007-2013 X5 xDrive30i, X5 xDrive35i, X5 xDrive48i, X5 xDrive50i and X5 M vehicles, 2008-2014 X6 xDrive35i, X6 xDrive50i and X6 M vehicles, 2009-2013 X5 xDrive35d vehicles and 2010-2011 X6 ActiveHybrid vehicles. These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the passenger frontal air bag, these inflators may explode due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Owners are advised not to drive their vehicles until the remedy is performed. BMW will notify owners, and dealers will replace the passenger frontal air bag module, free of charge. The recall began March 14, 2019. Owners may contact BMW customer service at 1-800-525-7417.
18V336000 · Engine And Engine Cooling:engine
May 23, 2018
BMW of North America, LLC (BMW) is recalling certain 2009-2013 X5 xDrive 35d diesel vehicles. The engine idler pulley bolt may loosen over time and break.
Consequence & remedy
Consequence: If the idler pulley bolt breaks, the vehicle may unexpectedly lose power-assisted steering, increasing the risk of a crash.
Remedy: BMW will notify owners, and dealers will replace the idler pulley bolt with an improved part, free of charge. The recall began March 11, 2019. Owners may contact BMW customer service at 1-800-525-7417.
18V248000 · Engine And Engine Cooling:engine; Engine And Engine Cooling:engine:gasoline:turbo/supercharger
Apr 18, 2018
BMW of North America, LLC (BMW) is recalling certain 2011-2012 BMW 550i, 550i xDrive, 550i Gran Turismo, 550i Gran Turismo xDrive, 750i, 750Li, 750i xDrive, 750Li xDrive, 760Li, X5 xDrive50i, X5 M, X6 xDrive50i, X6 M, ActiveHybrid7, MINI Cooper S Convertible, John Cooper Works (JCW) Convertible, Cooper S Countryman, Cooper S Countryman ALL4, Cooper S, JCW, Cooper S Clubman, JCW Clubman, Cooper S Roadster, JCW Roadster, Cooper S Coupe, JCW Coupe and Rolls-Royce Ghost, 2011 BMW X6 Hybrid and 2012 BMW 650i Coupe, 650i xDrive Coupe, 650i Convertible and 650i xDrive Convertible vehicles. The electric auxiliary water pump may fail and cause the circuit board to overheat.
Consequence & remedy
Consequence: If the circuit board were to overheat, it can increase the risk of a fire.
Remedy: BMW will notify owners, and dealers will replace the electric auxiliary water pump, free of charge. Depending on the model, there are currently limited parts available, however not all parts are available at this time. Owners will be notified of the recall beginning June 11, 2018, and will receive a second notification when remedy parts become available. Owners may contact BMW customer service at BMW 1-800-525-7417, MINI at 1-866-825-1525, or Rolls-Royce at 1-877-877-3735. Note: BMW recommends that owners park their vehicle outdoors until the recall remedy has been performed.
Additional source detail variants (2)
Engine And Engine Cooling:engine:gasoline:turbo/supercharger
BMW of North America, LLC (BMW) is recalling certain 2011-2012 BMW 550i, 550i xDrive, 550i Gran Turismo, 550i Gran Turismo xDrive, 750i, 750Li, 750i xDrive, 750Li xDrive, 760Li, X5 xDrive50i, X5 M, X6 xDrive50i, X6 M, ActiveHybrid7, MINI Cooper S Convertible, John Cooper Works (JCW) Convertible, Cooper S Countryman, Cooper S Countryman ALL4, Cooper S, JCW, Cooper S Clubman, JCW Clubman, Cooper S Roadster, JCW Roadster, Cooper S Coupe, JCW Coupe and Rolls-Royce Ghost, 2011 BMW X6 Hybrid and 2012 BMW 650i Coupe, 650i xDrive Coupe, 650i Convertible and 650i xDrive Convertible vehicles. The electric auxiliary water pump may fail and cause the circuit board to overheat.
Consequence: If the circuit board were to overheat, it can increase the risk of a fire.
Remedy: BMW will notify owners, and dealers will replace the electric auxiliary water pump, free of charge. Depending on the model, there are currently limited parts available, however not all parts are available at this time. Owners will be notified of the recall beginning June 11, 2018, and will receive a second notification when remedy parts become available. Owners may contact BMW customer service at BMW 1-800-525-7417, MINI at 1-866-825-1525, or Rolls-Royce at 1-877-877-3735. Note: BMW recommends that owners park their vehicle outdoors until the recall remedy has been performed.
Engine And Engine Cooling:engine
BMW of North America, LLC (BMW) is recalling certain 2011-2012 BMW 550i, 550i xDrive, 550i Gran Turismo, 550i Gran Turismo xDrive, 750i, 750Li, 750i xDrive, 750Li xDrive, 760Li, X5 xDrive50i, X5 M, X6 xDrive50i, X6 M, ActiveHybrid7, MINI Cooper S Convertible, John Cooper Works (JCW) Convertible, Cooper S Countryman, Cooper S Countryman ALL4, Cooper S, JCW, Cooper S Clubman, JCW Clubman, Cooper S Roadster, JCW Roadster, Cooper S Coupe, JCW Coupe and Rolls-Royce Ghost, 2011 BMW X6 Hybrid and 2012 BMW 650i Coupe, 650i xDrive Coupe, 650i Convertible and 650i xDrive Convertible vehicles. The electric auxiliary water pump may fail and cause the circuit board to overheat.
Consequence: If the circuit board were to overheat, it can increase the risk of a fire.
Remedy: BMW will notify owners, and dealers will replace the electric auxiliary water pump, free of charge. Depending on the model, there are currently limited parts available, however not all parts are available at this time. Owners will be notified of the recall beginning June 11, 2018, and will receive a second notification when remedy parts become available. Owners may contact BMW customer service at BMW 1-800-525-7417, MINI at 1-866-825-1525, or Rolls-Royce at 1-877-877-3735. Note: BMW recommends that owners park their vehicle outdoors until the recall remedy has been performed.
18V030000 · Air Bags:frontal:passenger Side:inflator Module
Jan 9, 2018
BMW of North America, LLC (BMW) is recalling certain 2007-2013 X5 xDrive30i, X5 xDrive35i, X5 xDrive48i, X5 xDrive50i, X5 M, 2009-2010 X5 xDrive35d vehicles and 2009-2013 X6 xDrive35i, X6 xDrive50i, and X6 M vehicles ever registered in the states of Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands or "Zone A." BMW is also recalling certain 2007-2010 X5 xDrive30i, X5 xDrive35i, X5 xDrive48i, X5 xDrive50i, X5 M, X5 xDrive35d, X6 xDrive35i, X6 xDrive50i and X6M vehicles ever registered in the states of Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia or "Zone B." BMW is also recalling certain 2007-2009 X5 xDrive30i, X5 xdrive35i, X5 xDrive48i, X5 xDrive50i, X5 M, X5 xDrive35d, X6 xDrive35i, X6 xDrive50i and X6M vehicles ever registered in the states of AK, CO, CT, ID, IA, ME, MA, MI, MN, MT, NH, NY, ND, OR, RI, SD, UT, VT, WA, WI, and WY or "Zone C." These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the passenger frontal air bag, these inflators may explode due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Owners are advised not to drive their vehicles until the remedy is performed. BMW will notify owners, and dealers will replace the passenger front air bag module, free of charge. The recall is expected to begin March 2018. Owners may contact BMW customer service at 1-800-525-7417.
17V138000 · Power Train:driveline:driveshaft
Mar 2, 2017
BMW of North America, LLC, (BMW) is recalling certain 2011-2013 X5 xDrive35i, X5 xDrive50i, X5 M and X5 xDrive35d vehicles, 2011-2014 X6 xDrive35i, X6 xDrive50i and X6M vehicles, and 2011 x6 ActiveHybrid Vehicles. Water and debris may enter the front driveshaft's universal joint, causing excessive wear and possibly resulting in the joint's failure.
Consequence & remedy
Consequence: If the front universal joint fails, the front wheels would not be driven, affecting vehicle traction. Additionally, continued driving of the vehicle with a broken front universal joint may damage other components. Either condition may increase the risk of a crash.
Remedy: BMW will notify owners, and dealers will replace the front driveshaft, free of charge. The recall began on April 18, 2017. Owners may contact BMW customer service at 1-800-525-7417.
17V020000 · Air Bags:frontal:passenger Side:inflator Module
Jan 10, 2017
BMW of North America, LLC (BMW) is recalling certain 2012 X5 xDrive30i, X5 xDrive35i, X5 xDrive48i, X5 xDrive50i, X5 M, X6 xDrive35i, X6 xDrive50i, and X6 M vehicles originally sold, or ever registered, in Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands, or "Zone A." Additionally, unless included in "Zone A" above, BMW is recalling certain 2009 X5 xDrive30i, X5 xDrive35i, X5 xDrive48i, X5 xDrive50i, and X5 M vehicles, 2008-2009 X6 xDrive 35i, X6 xDrive50i, X6 M, and 2009 X5 xDrive35d vehicles originally sold, or ever registered, in Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia, or "Zone B." Additionally, unless included in "Zone A" or "Zone B" above, BMW is recalling certain 2007-2008 X5 xDrive30i, X5 xDrive35i, X5 xDrive48i, X5 xDrive50i and X5 M vehicles, and 2008 X6 xDrive35i, X6 xDrive50i, and X6 M vehicles originally sold, or ever registered in the states of Alaska, Colorado, Connecticut, Idaho, Iowa, Maine, Massachusetts, Michigan, Minnesota, Montana, New Hampshire, New York, North Dakota, Oregon, Rhode Island, South Dakota, Utah, Vermont, Washington, Wisconsin, and Wyoming. These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the front air bags, these inflators may rupture due to propellant degradation occurring after long-term exposure to high absolute humidity and temperature cycling.
Consequence & remedy
Consequence: An inflator rupture may result in metal fragments striking the vehicle occupants resulting in serious injury or death.
Remedy: Owners are advised not to drive their vehicles until the remedy is performed. BMW will notify owners, and dealers will replace the front passenger air bag inflator or air bag module, free of charge. Interim letters were mailed March 2017. Owners will receive a second notice when remedy parts become available. Owners may contact BMW customer service at 1-800-525-7417.
12V267000 · Steering
Jun 13, 2012
BMW IS RECALLING CERTAIN MODEL YEAR 2012 X5 VEHICLES EQUIPPED WITH A DIESEL ENGINE AND 2013 X5 AND X6 VEHICLES. DUE TO A MACHINING ERROR OF THE STEERING GEAR SURFACE, POWER STEERING FLUID MAY LEAK.
Consequence & remedy
Consequence: LEAKING POWER STEERING FLUID CAN SPRAY ONTO HOT EXHAUST PARTS, INCREASING THE RISK OF AN ENGINE COMPARTMENT FIRE.
Remedy: BMW WILL NOTIFY OWNERS, AND DEALERS WILL INSPECT, AND IF NECESSARY, REPLACE THE STEERING GEAR FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JULY 20, 2012. OWNERS MAY CONTACT BMW CUSTOMER RELATIONS AND SERVICES AT 1-800-525-7417.
12V019000 · Power Train:automatic Transmission
Jan 23, 2012
BMW IS RECALLING CERTAIN MODEL YEAR 2012 X5 XDRIVE 35I SPORTS ACTIVITY VEHICLES, MANUFACTURED FROM DECEMBER 19, 2011, THROUGH DECEMBER 21, 2011. DUE TO A MANUFACTURING ERROR, ENGAGEMENT OF THE TRANSMISSIONS PARKING LOCK MAY NOT OCCUR EVEN IF THE P POSITION HAS BEEN SELECTED AND IS DISPLAYED.
Consequence & remedy
Consequence: IF THE DRIVER BELIEVES THAT THE TRANSMISSION IS IN PARK AND DOES NOT USE THE PARKING BRAKE, THE VEHICLE COULD ROLL AWAY AFTER EXITING THE VEHICLE INCREASING THE RISK OF A CRASH OR INJURY.
Remedy: BMW WILL NOTIFY OWNERS, AND DEALERS WILL REPLACE THE AUTOMATIC TRANSMISSION FREE OF CHARGE. THE SAFETY RECALL BEGAN ON FEBRUARY 2, 2012. OWNERS MAY CONTACT BMW CUSTOMER RELATIONS AND SERVICES AT 1-800-525-7417.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1RQ18001 · Idler Pulley Bolt Failure
Opened Apr 18, 2018 · Closed Dec 1, 2018
Status: closed (inferred from source dates) · Steering; Steering:hydraulic Power Assist System; Steering:hydraulic Power Assist:hose, Piping, And Connections
In a May 23, 2018 letter, BMW of North America, LLC (BMW) notified the National Highway Traffic Safety Administration (NHTSA) of a safety defect that may result in the loss of power steering assist in certain model year (MY) 2009 through 2013 BMW X5 xDrive35d vehicles (Recall 18V-336). The recall, which affects approximately 33,214 vehicles built from March 12, 2008 through June 27, 2013, corrects the remedy and expands the scope of a prior BMW recall (12V-550) which addressed idle pulley bolt failure in approximately 29,800 MY 2009 through 2012 BMW X5 xDrive35d vehicles built from September 1, 2008 through November 15, 2012. BMW's analysis indicates that due to a number of contributing factors it is possible that the bolt's pre-stressing force could drop to an extent that it results in the bolt becoming loosened over time. A loosening of the bolt could cause additional bending stress on top of the bolt. As a result, the bolt could break. If this were to happen, then a sudden loss of power steering assist could occur.If there were a loss of power steering assist, manual steering capability would be retained, although the effort required to steer the vehicle would be greater, and therefore may increase the risk of crash.ODI's analysis of the complaints it has received from the public (VOQ's) and BMW complaint data submitted in response to the information request letter for RQ18-001 identified a total of 93 unique VIN reports alleging failure of the idler pulley bolt after recall 12V-550 was completed on the vehicle, including 31 VOQ's and 72 BMW consumer complaints (5 complaints received by NHTSA and BMW, 3 unique VIN's submitted multiple complaints to BMW, and 1 unique VIN submitted multiple complaints to NHTSA).BMW is developing a new idler pulley fastening system as the remedy for 18V-336.The remedy is planned to begin in February 2019.Based on BMW's safety recall, this recall query is closed.The 31 VOQ's referenced in this resume are: 10499780, 10559422, 10579534, 10655424, 10661614, 10702323, 10819617, 10903433, 10948014, 10984353, 11002447, 11010667, 11013643, 11041551, 11054759, 11054909, 11066063, 11083479, 11097562, 11098865, 11113332, 11128649, 11130277, 10552773, 10817406, 10937632, 10956710, 11032006, 11042259, 11063010, 11091513.
Additional source detail variants (3)
Steering
In a May 23, 2018 letter, BMW of North America, LLC (BMW) notified the National Highway Traffic Safety Administration (NHTSA) of a safety defect that may result in the loss of power steering assist in certain model year (MY) 2009 through 2013 BMW X5 xDrive35d vehicles (Recall 18V-336). The recall, which affects approximately 33,214 vehicles built from March 12, 2008 through June 27, 2013, corrects the remedy and expands the scope of a prior BMW recall (12V-550) which addressed idle pulley bolt failure in approximately 29,800 MY 2009 through 2012 BMW X5 xDrive35d vehicles built from September 1, 2008 through November 15, 2012. BMW's analysis indicates that due to a number of contributing factors it is possible that the bolt's pre-stressing force could drop to an extent that it results in the bolt becoming loosened over time. A loosening of the bolt could cause additional bending stress on top of the bolt. As a result, the bolt could break. If this were to happen, then a sudden loss of power steering assist could occur.If there were a loss of power steering assist, manual steering capability would be retained, although the effort required to steer the vehicle would be greater, and therefore may increase the risk of crash.ODI's analysis of the complaints it has received from the public (VOQ's) and BMW complaint data submitted in response to the information request letter for RQ18-001 identified a total of 93 unique VIN reports alleging failure of the idler pulley bolt after recall 12V-550 was completed on the vehicle, including 31 VOQ's and 72 BMW consumer complaints (5 complaints received by NHTSA and BMW, 3 unique VIN's submitted multiple complaints to BMW, and 1 unique VIN submitted multiple complaints to NHTSA).BMW is developing a new idler pulley fastening system as the remedy for 18V-336.The remedy is planned to begin in February 2019.Based on BMW's safety recall, this recall query is closed.The 31 VOQ's referenced in this resume are: 10499780, 10559422, 10579534, 10655424, 10661614, 10702323, 10819617, 10903433, 10948014, 10984353, 11002447, 11010667, 11013643, 11041551, 11054759, 11054909, 11066063, 11083479, 11097562, 11098865, 11113332, 11128649, 11130277, 10552773, 10817406, 10937632, 10956710, 11032006, 11042259, 11063010, 11091513.
Steering:hydraulic Power Assist:hose, Piping, And Connections
In a May 23, 2018 letter, BMW of North America, LLC (BMW) notified the National Highway Traffic Safety Administration (NHTSA) of a safety defect that may result in the loss of power steering assist in certain model year (MY) 2009 through 2013 BMW X5 xDrive35d vehicles (Recall 18V-336). The recall, which affects approximately 33,214 vehicles built from March 12, 2008 through June 27, 2013, corrects the remedy and expands the scope of a prior BMW recall (12V-550) which addressed idle pulley bolt failure in approximately 29,800 MY 2009 through 2012 BMW X5 xDrive35d vehicles built from September 1, 2008 through November 15, 2012. BMW's analysis indicates that due to a number of contributing factors it is possible that the bolt's pre-stressing force could drop to an extent that it results in the bolt becoming loosened over time. A loosening of the bolt could cause additional bending stress on top of the bolt. As a result, the bolt could break. If this were to happen, then a sudden loss of power steering assist could occur.If there were a loss of power steering assist, manual steering capability would be retained, although the effort required to steer the vehicle would be greater, and therefore may increase the risk of crash.ODI's analysis of the complaints it has received from the public (VOQ's) and BMW complaint data submitted in response to the information request letter for RQ18-001 identified a total of 93 unique VIN reports alleging failure of the idler pulley bolt after recall 12V-550 was completed on the vehicle, including 31 VOQ's and 72 BMW consumer complaints (5 complaints received by NHTSA and BMW, 3 unique VIN's submitted multiple complaints to BMW, and 1 unique VIN submitted multiple complaints to NHTSA).BMW is developing a new idler pulley fastening system as the remedy for 18V-336.The remedy is planned to begin in February 2019.Based on BMW's safety recall, this recall query is closed.The 31 VOQ's referenced in this resume are: 10499780, 10559422, 10579534, 10655424, 10661614, 10702323, 10819617, 10903433, 10948014, 10984353, 11002447, 11010667, 11013643, 11041551, 11054759, 11054909, 11066063, 11083479, 11097562, 11098865, 11113332, 11128649, 11130277, 10552773, 10817406, 10937632, 10956710, 11032006, 11042259, 11063010, 11091513.
Steering:hydraulic Power Assist System
In a May 23, 2018 letter, BMW of North America, LLC (BMW) notified the National Highway Traffic Safety Administration (NHTSA) of a safety defect that may result in the loss of power steering assist in certain model year (MY) 2009 through 2013 BMW X5 xDrive35d vehicles (Recall 18V-336). The recall, which affects approximately 33,214 vehicles built from March 12, 2008 through June 27, 2013, corrects the remedy and expands the scope of a prior BMW recall (12V-550) which addressed idle pulley bolt failure in approximately 29,800 MY 2009 through 2012 BMW X5 xDrive35d vehicles built from September 1, 2008 through November 15, 2012. BMW's analysis indicates that due to a number of contributing factors it is possible that the bolt's pre-stressing force could drop to an extent that it results in the bolt becoming loosened over time. A loosening of the bolt could cause additional bending stress on top of the bolt. As a result, the bolt could break. If this were to happen, then a sudden loss of power steering assist could occur.If there were a loss of power steering assist, manual steering capability would be retained, although the effort required to steer the vehicle would be greater, and therefore may increase the risk of crash.ODI's analysis of the complaints it has received from the public (VOQ's) and BMW complaint data submitted in response to the information request letter for RQ18-001 identified a total of 93 unique VIN reports alleging failure of the idler pulley bolt after recall 12V-550 was completed on the vehicle, including 31 VOQ's and 72 BMW consumer complaints (5 complaints received by NHTSA and BMW, 3 unique VIN's submitted multiple complaints to BMW, and 1 unique VIN submitted multiple complaints to NHTSA).BMW is developing a new idler pulley fastening system as the remedy for 18V-336.The remedy is planned to begin in February 2019.Based on BMW's safety recall, this recall query is closed.The 31 VOQ's referenced in this resume are: 10499780, 10559422, 10579534, 10655424, 10661614, 10702323, 10819617, 10903433, 10948014, 10984353, 11002447, 11010667, 11013643, 11041551, 11054759, 11054909, 11066063, 11083479, 11097562, 11098865, 11113332, 11128649, 11130277, 10552773, 10817406, 10937632, 10956710, 11032006, 11042259, 11063010, 11091513.