NHTSA owner reports · September 18, 2026 snapshot.
Fuel/propulsion System complaints
24 reportsClear category filterMileage unknown · Jun 8, 2025
Fuel/propulsion System
Dear Sir/Madam, I am writing to you today to report a potential issue with my 2012 BMW X5 3.5i, VIN [XXX] . My vehicle appears to be experiencing fuel wire problems , along with the smell of gas, consistent with those described in recall number 16V-746000. I would appreciate it if you would investigate this matter further and …
Read full complaint
Dear Sir/Madam, I am writing to you today to report a potential issue with my 2012 BMW X5 3.5i, VIN [XXX] . My vehicle appears to be experiencing fuel wire problems , along with the smell of gas, consistent with those described in recall number 16V-746000. I would appreciate it if you would investigate this matter further and advise on the appropriate course of action to address this concern. I have spent too much money on having the car towed around town.. Thank you for your time and attention to this matter. Sincerely, [XXX] [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA ODI #11665570
Mileage unknown · Jun 28, 2023
Fuel/propulsion SystemService Brakes
Despite replacing brake sensors, brake pads and rotors break wear light illumination on dashboard dealer unable to fix issues At 70000 miles defective exhaust back pressure sensor
NHTSA ODI #11529492
91,000 miles · Oct 28, 2020
Fuel/propulsion SystemPower Train
ENGINE MALFUNCTION LIGHT AND CAR OVERHEATING CAUSED BY WATER PUMP, THERE'S NO RECALL FOR MY VIN BUT IT SEEMS THIS IS AN ONGOING ISSUE WITH BMW X5 MODELS... THE BMW DID A RECALL ON MY X5 AND AFTER THEY FINISHED THE RECALL THE TRANSFER CASE STOPPED WORKING PROPERLY, HOWEVER, THE TRANSFER CASE WAS WORKING PERFECTLY BEFORE THE RECAL…
Read full complaint
ENGINE MALFUNCTION LIGHT AND CAR OVERHEATING CAUSED BY WATER PUMP, THERE'S NO RECALL FOR MY VIN BUT IT SEEMS THIS IS AN ONGOING ISSUE WITH BMW X5 MODELS... THE BMW DID A RECALL ON MY X5 AND AFTER THEY FINISHED THE RECALL THE TRANSFER CASE STOPPED WORKING PROPERLY, HOWEVER, THE TRANSFER CASE WAS WORKING PERFECTLY BEFORE THE RECALLED. THE BMW POWER TRAIN RECALL DAMAGE THE TRANSFER CASE
NHTSA ODI #11366858
120,895 miles · Nov 24, 2019
Fuel/propulsion System
WHILE DRIVING HOME ON THE MOST DANGEROUS HIGHWAY IN COLORADO, MY VEHICLE SUDDENLY WENT FROM DOING 75MPH TO 50MPH DURING TRAFFIC HOUR, ALMOST CAUSING MY VEHICLE TO GET INTO AN ACCIDENT, WITH MY FAMILY IN THE CAR. SO VERY DANGEROUS. THE ENGINE LIGHT AND THE ENGINE MALFUNCTION MESSAGE CAME ON. I WAS ABLE TO MERGE OFF THE HIGHWA…
Read full complaint
WHILE DRIVING HOME ON THE MOST DANGEROUS HIGHWAY IN COLORADO, MY VEHICLE SUDDENLY WENT FROM DOING 75MPH TO 50MPH DURING TRAFFIC HOUR, ALMOST CAUSING MY VEHICLE TO GET INTO AN ACCIDENT, WITH MY FAMILY IN THE CAR. SO VERY DANGEROUS. THE ENGINE LIGHT AND THE ENGINE MALFUNCTION MESSAGE CAME ON. I WAS ABLE TO MERGE OFF THE HIGHWAY AND HAVE MY CAR AND HAVE A MECHANIC TAKE A LOOK AT IT. THE ERROR CODE IS P15DF (HIGH PRESSURE FUEL PUMP). I DID SOME RESEARCH ON THIS AND FOUND THAT BMW HAD BEEN TAKEN TO COURT ON THIS SAFETY ISSUE. BMW HAD RECALLED 1000'S OF BMW'S FOR THIS EXACT SAME ISSUE. I WROTE TO BMW CUSTOMER RELATIONS AND THEIR RESPONSE BASICALLY IS THAT MY CAR'S VIN DOES TO QUALIFY FOR THIS RECALL. I STATED TO THEM THAT IT SHOULD BE RECALLED BECAUSE IT HAS THE EXACT SAME PROBLEM AS THE 1000'S THAT WERE RECALLED. IN REALITY THEY DO NOT WANT TO PAY FOR IT. I FEEL THAT MY VEHICLE SHOULD BE RECALLED TO INCLUDE 1000'S OF OTHER X5'S, BEFORE SOMEONE IS KILLED.
NHTSA ODI #11282094
Mileage unknown · Sep 5, 2019
EngineFuel/propulsion System
EGR VALVE IS FAULTY CAUSING EMISSIONS ISSUES AND CAN LEAD TO OVERHEATING. RECALLS HAVE BEEN PERFORMED ON 2009 - 2011 MODELS AND 2013 MODELS AND NEWER BUT NOT ON THE 2012 WITH THE SAME ISSUE.
NHTSA ODI #11253368
97,000 miles · Aug 10, 2019
Electrical SystemFuel/propulsion System
MY CAR HAS PCV HEATER CHECK ENGINE LIGHT CODE COMING ON AND OFF. BMW IS FORCED BY NHTSA TO DO RECALL ON BMW CAR FIRE BUT ONLY COVER UP TO PRODUCTION MODEL THRU DECEMBER 2011. MY CAR HAS JUNE 2012 PRODUCTION, THE PCV HEATER VALVE CHECK ENGINE LIGHT HAS BEEN ON AND OFF FROM LAST YEAR, I HAD REPLACED HVAC HEATER VALVE (WRONG DIAGNO…
Read full complaint
MY CAR HAS PCV HEATER CHECK ENGINE LIGHT CODE COMING ON AND OFF. BMW IS FORCED BY NHTSA TO DO RECALL ON BMW CAR FIRE BUT ONLY COVER UP TO PRODUCTION MODEL THRU DECEMBER 2011. MY CAR HAS JUNE 2012 PRODUCTION, THE PCV HEATER VALVE CHECK ENGINE LIGHT HAS BEEN ON AND OFF FROM LAST YEAR, I HAD REPLACED HVAC HEATER VALVE (WRONG DIAGNOSE FOR PART SPECIFIC FROM MY MECHANIC) BUT NOW I FIND OUT THERE IS A RECALL FOR IT, BUT NOT COVERING MY YEAR. PLEASE ADVISE ME IF NHTSA CAN MAKE BMW EXTEND THE RECALL YEAR COVERAGE? THANK YOU.
NHTSA ODI #11243024
75,000 miles · Mar 26, 2019
Fuel/propulsion System
TL* THE CONTACT OWNS A 2012 BMW X5. WHILE DRIVING 35 MPH, THE VEHICLE SUDDENLY SHUT OFF WITHOUT WARNING. THE VEHICLE WAS TOWED TO MOMENTUM BMW (10002 SOUTHWEST FWY, HOUSTON, TX 77074) WHERE IT WAS DIAGNOSED THAT THE HIGH PRESSURE FUEL PUMP FAILED. THE MANUFACTURER WAS ALSO CONTACTED AND DID NOT ASSIST. THE VEHICLE WAS NOT REPAIR…
Read full complaint
TL* THE CONTACT OWNS A 2012 BMW X5. WHILE DRIVING 35 MPH, THE VEHICLE SUDDENLY SHUT OFF WITHOUT WARNING. THE VEHICLE WAS TOWED TO MOMENTUM BMW (10002 SOUTHWEST FWY, HOUSTON, TX 77074) WHERE IT WAS DIAGNOSED THAT THE HIGH PRESSURE FUEL PUMP FAILED. THE MANUFACTURER WAS ALSO CONTACTED AND DID NOT ASSIST. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 75,000.
NHTSA ODI #11191578
74,000 miles · Mar 13, 2019
Fuel/propulsion System
I WAS DRIVING MY CAR AT 35 MILES PER HOUR SUDDENLY THE CAR LOST POWER STEERING WHEEL LOCKED SO IT WAS HARD TO KEEP CONTROL OF THE VEHICLE. I TRIED RESTARTING THE CAR BUT WITH NO RESULTS. A POLICEMAN HAD TO STAY BEHIND ME ALL THE TIME FOR OVER AN HOUR UNTIL A TOWING TRUCK CAME TO TOW THE CAR. BMW DIAGNOSTE THE CAR BEFORE WITH A F…
Read full complaint
I WAS DRIVING MY CAR AT 35 MILES PER HOUR SUDDENLY THE CAR LOST POWER STEERING WHEEL LOCKED SO IT WAS HARD TO KEEP CONTROL OF THE VEHICLE. I TRIED RESTARTING THE CAR BUT WITH NO RESULTS. A POLICEMAN HAD TO STAY BEHIND ME ALL THE TIME FOR OVER AN HOUR UNTIL A TOWING TRUCK CAME TO TOW THE CAR. BMW DIAGNOSTE THE CAR BEFORE WITH A FUEL RAIL REGULATOR. SO I WENT AND REPLACED THAT COMPONENT STILL THE CAR DID NOT WANT TO START!?. SO I TOWED IT TO BMW AFTER 4 DAYS OF DIAGNOSTICS THAT THEY SAID THE DIAGNOSTICS ITSELF IS $1900! THEY CAME TO A CONCLUSION THAT THE FUEL HIGH PRESSURE PUMP FAILED AND CONTAMINATED THE FUEL SYSTEM AND BROKE THE INJECTORS AND MESSED UP THE WHOLE FUEL SYSTEM. THEIR ESTIMATE TO REPLACE THE WHOLE IS OVER $11000! AND TO JUST REPLACE THE FAILED AND CLEAN UP THE FUEL SYSTEM IT WILL COST ME OVER $4000. THE CAR IS ONLY $75000 HOW WOULD A MAJOR FAILURE HAPPEN TO THAT COMPONENT. THERE WAS NO MISFUELING, THEY CHECKED THE DIESEL AND THEY SAID IT IS NOT GAS AND IT DOES NOT HAVE WATER EITHER. I HAVE READ WHERE OTHER PEOPLE COMPLAINING FROM THE SAME ISSUE FUEL HIGH PRESSURE PUMP FAILURE. IF I WERE ON A HIGHWAY AND SINCE THE CAR DID NOT GIVE ANY NOTICE OR MESSAGE I THINK I WOULD HAVE BEEN IN AN ACCIDENT SINCE THE CAR JUST SHUT DOWN WITH NO WARNING OR SIGN.
NHTSA ODI #11186360
74,000 miles · Feb 27, 2019
Fuel/propulsion System
EMISSION LIGHT CAME ON WHILE DRIVING ON A HIGHWAY. BMW DIAGNOSED IT WAS A FAULTY DMTL PUMP (LEAK DIAGNOSIS PUMP). DEALER (BMW) DECLINED COVER UNDER EMISSION WARRANTY.
NHTSA ODI #11182887
131,000 miles · Jan 2, 2019
EngineFuel/propulsion SystemPower Train
ON AUGUST 7, 2018, I WAS TRAVELING ON INTERSTATE 95 IN MARYLAND (NORTH OF BALTIMORE) IN ROUTE TO NEW YORK STATE. DURING THE HIGHWAY DRIVE, MY BMW DRASTICALLY REDUCED SPEED TO 10 MILES PER HOUR AND THE CHECK ENGINE LIGHT CAME ON AND STAYED ON. I HAD TO MOVE MY CAR TO A SAFE PLACE TO AVOID BEING HIT BY THE OTHER VEHICLES ON T…
Read full complaint
ON AUGUST 7, 2018, I WAS TRAVELING ON INTERSTATE 95 IN MARYLAND (NORTH OF BALTIMORE) IN ROUTE TO NEW YORK STATE. DURING THE HIGHWAY DRIVE, MY BMW DRASTICALLY REDUCED SPEED TO 10 MILES PER HOUR AND THE CHECK ENGINE LIGHT CAME ON AND STAYED ON. I HAD TO MOVE MY CAR TO A SAFE PLACE TO AVOID BEING HIT BY THE OTHER VEHICLES ON THE HIGHWAY. I COULD NOT CONTINUE TO DRIVE MY CAR. AND, I WAS WORRIED ABOUT MY SAFETY AND WAS AT RISK DUE TO THE BMW CAR ISSUE. I CALLED AAA AND MY CAR WAS TOWED TO PASSPORT BMW IN SUITLAND, MARYLAND FOR REPAIR. ON AUGUST 8TH, PASSPORT EVALUATED MY CAR AND DIAGNOSED THE PROBLEM. I WAS INFORMED BY PASSPORT BMW THAT MY CAR ENGINE PROBLEM WAS DUE TO A FAULTY FUEL IGNITION SYSTEM WHICH HAD TO BE REPLACED. I APPROVED THIS OVER $570 REPAIR TO MY CAR. HOWEVER, WHEN I PICKED UP THE CAR, THE ENGINE LIGHT WAS STILL ON. AGAIN, I WAS CONCERNED SINCE MY CAR WAS REPAIRED BY BMW YET THE PROBLEM HAD NOT BEEN FIXED SINCE THE ENGINE LIGHT WAS STILL ON. I CONTACTED THE SERVICE ADVISOR TO INFORM HIM OF THE PROBLEM. HE APOLOGIZED AND REQUESTED THAT I BRING THE CAR BACK IN TO PASSPORT BMW ON THE NEXT DAY. THE NEXT DAY, I BROUGHT THE CAR IN TO PASSPORT BMW, I WAS INFORMED THAT THE CATALYTIC CONVERTER, AN ESTIMATED $3388 REPAIR, NEEDED TO BE REPLACED. MY CAR HAS BEEN IN FOR BMW SERVICE MAINTENANCE AND RECALL REPAIRS SEVERAL TIME. MY CAR WAS IN FOR MAINTENANCE SEVERAL TIMES AND WAS NOT ACCURATELY DIAGNOSED OR REPAIRED. THERE IS NO INDICATION THAT THE REPAIR DIAGNOSED ON AUGUST 8TH FIXED THE PROBLEM THAT CAUSED MY CAR TO STOP RUNNING ON THE HIGHWAY ON AUGUST 7TH. I PAID FOR THAT REPAIR IN AUGUST AND IT DID NOT FIX THE CHECK ENGINE PROBLEM AND WANT TO BE REIMBURSED FOR THIS EXPENSE. I AM CONCERNED ABOUT THE NUMEROUS REPAIRS TO MY BMW DESPITE THE FACT THAT MY CAR HAS BEEN SERVICED BY THE PASSPORT BMW SERVICE DEPARTMENT.
NHTSA ODI #11164436
Official recalls
10Jan 15, 2020
BMW of North America, LLC (BMW) is recalling certain 2009-2012 X5 xDrive35d, 2008-2012 X6 xDrive35i, X6 xDrive50i and X6 M, 2007-2012 X5 30si, X5 xDrive30i, X5 xDrive35i, X5 48i, X5 xDrive48i, X5 xDrive50i and X5 M and 2010-2011 X6 ActiveHybrid vehicles equipped with non-desiccated, passenger frontal air bag inflators containing phase stabilized ammonium nitrate (PSPI-2) propellant that were used as interim remedy parts for previous Takata recalls. These inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Owners are advised not to drive their vehicles until this remedy is performed. BMW will notify owners, and dealers will replace the passenger front air bag, free of charge. The recall began March 11, 2020. Owners may contact BMW customer service at 1-800-525-7417.
Jan 15, 2020
BMW of North America, LLC (BMW) is recalling certain 2008-2013 128i and 135i Convertibles, 128i, 135i, and M Coupes, 2007-2010 X3 30si and X3 xDrive30i, 2013-2015 X1 sDrive28i, X1 xDrive28i and X1 xDrive35i, 2007-2013 328i, 328i xDrive, 335i, 335is, 335i xDrive and M3 Coupes, 2006-2011 328i, 328xi, 328i xDrive, 325i, 325xi, 330i, 330xi, 335i, 335xi, 335i xDrive and M3, 2009-2011 335D, 2006-2012 325xi, 328i, 328xi and 328i xDrive, 2010-2011 X6 ActiveHybrid, 2007-2013 328i, 335i, 335is, M3 Coupes, X5 30si, X5 xDrive30i, X5 xDrive35i, X5 48i, X5 xDrive48i, X5 xDrive50i and X5 M, 2009-2013 X5 xDrive35d and 2008-2014 X6 xDrive35i, X6 xDrive50i and X6M vehicles equipped with non-desiccated driver frontal air bag inflators containing phase stabilized ammonium nitrate (PSAN) that were used as interim remedy parts for previous Takata recalls. These inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: BMW will notify owners, and dealers will replace the driver air bag. On X5 and X6 vehicles, only the inflator will be replaced. All repairs will be performed free of charge. The recall began March 11, 2020. Owners may contact BMW customer service at 1-800-525-7417.
Jan 14, 2019
BMW of North America, LLC (BMW) is recalling certain 2007-2013 X5 xDrive30i, X5 xDrive35i, X5 xDrive48i, X5 xDrive50i and X5 M vehicles, 2008-2014 X6 xDrive35i, X6 xDrive50i and X6 M vehicles, 2009-2013 X5 xDrive35d vehicles and 2010-2011 X6 ActiveHybrid vehicles. These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the passenger frontal air bag, these inflators may explode due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Owners are advised not to drive their vehicles until the remedy is performed. BMW will notify owners, and dealers will replace the passenger frontal air bag module, free of charge. The recall began March 14, 2019. Owners may contact BMW customer service at 1-800-525-7417.
May 23, 2018
BMW of North America, LLC (BMW) is recalling certain 2009-2013 X5 xDrive 35d diesel vehicles. The engine idler pulley bolt may loosen over time and break.
Consequence & remedy
Consequence: If the idler pulley bolt breaks, the vehicle may unexpectedly lose power-assisted steering, increasing the risk of a crash.
Remedy: BMW will notify owners, and dealers will replace the idler pulley bolt with an improved part, free of charge. The recall began March 11, 2019. Owners may contact BMW customer service at 1-800-525-7417.
Apr 18, 2018
BMW of North America, LLC (BMW) is recalling certain 2011-2012 BMW 550i, 550i xDrive, 550i Gran Turismo, 550i Gran Turismo xDrive, 750i, 750Li, 750i xDrive, 750Li xDrive, 760Li, X5 xDrive50i, X5 M, X6 xDrive50i, X6 M, ActiveHybrid7, MINI Cooper S Convertible, John Cooper Works (JCW) Convertible, Cooper S Countryman, Cooper S Countryman ALL4, Cooper S, JCW, Cooper S Clubman, JCW Clubman, Cooper S Roadster, JCW Roadster, Cooper S Coupe, JCW Coupe and Rolls-Royce Ghost, 2011 BMW X6 Hybrid and 2012 BMW 650i Coupe, 650i xDrive Coupe, 650i Convertible and 650i xDrive Convertible vehicles. The electric auxiliary water pump may fail and cause the circuit board to overheat.
Consequence & remedy
Consequence: If the circuit board were to overheat, it can increase the risk of a fire.
Remedy: BMW will notify owners, and dealers will replace the electric auxiliary water pump, free of charge. Depending on the model, there are currently limited parts available, however not all parts are available at this time. Owners will be notified of the recall beginning June 11, 2018, and will receive a second notification when remedy parts become available. Owners may contact BMW customer service at BMW 1-800-525-7417, MINI at 1-866-825-1525, or Rolls-Royce at 1-877-877-3735. Note: BMW recommends that owners park their vehicle outdoors until the recall remedy has been performed.
Additional source detail variants (2)
Engine And Engine Cooling:engine:gasoline:turbo/supercharger
BMW of North America, LLC (BMW) is recalling certain 2011-2012 BMW 550i, 550i xDrive, 550i Gran Turismo, 550i Gran Turismo xDrive, 750i, 750Li, 750i xDrive, 750Li xDrive, 760Li, X5 xDrive50i, X5 M, X6 xDrive50i, X6 M, ActiveHybrid7, MINI Cooper S Convertible, John Cooper Works (JCW) Convertible, Cooper S Countryman, Cooper S Countryman ALL4, Cooper S, JCW, Cooper S Clubman, JCW Clubman, Cooper S Roadster, JCW Roadster, Cooper S Coupe, JCW Coupe and Rolls-Royce Ghost, 2011 BMW X6 Hybrid and 2012 BMW 650i Coupe, 650i xDrive Coupe, 650i Convertible and 650i xDrive Convertible vehicles. The electric auxiliary water pump may fail and cause the circuit board to overheat.
Consequence: If the circuit board were to overheat, it can increase the risk of a fire.
Remedy: BMW will notify owners, and dealers will replace the electric auxiliary water pump, free of charge. Depending on the model, there are currently limited parts available, however not all parts are available at this time. Owners will be notified of the recall beginning June 11, 2018, and will receive a second notification when remedy parts become available. Owners may contact BMW customer service at BMW 1-800-525-7417, MINI at 1-866-825-1525, or Rolls-Royce at 1-877-877-3735. Note: BMW recommends that owners park their vehicle outdoors until the recall remedy has been performed.
Engine And Engine Cooling:engine
BMW of North America, LLC (BMW) is recalling certain 2011-2012 BMW 550i, 550i xDrive, 550i Gran Turismo, 550i Gran Turismo xDrive, 750i, 750Li, 750i xDrive, 750Li xDrive, 760Li, X5 xDrive50i, X5 M, X6 xDrive50i, X6 M, ActiveHybrid7, MINI Cooper S Convertible, John Cooper Works (JCW) Convertible, Cooper S Countryman, Cooper S Countryman ALL4, Cooper S, JCW, Cooper S Clubman, JCW Clubman, Cooper S Roadster, JCW Roadster, Cooper S Coupe, JCW Coupe and Rolls-Royce Ghost, 2011 BMW X6 Hybrid and 2012 BMW 650i Coupe, 650i xDrive Coupe, 650i Convertible and 650i xDrive Convertible vehicles. The electric auxiliary water pump may fail and cause the circuit board to overheat.
Consequence: If the circuit board were to overheat, it can increase the risk of a fire.
Remedy: BMW will notify owners, and dealers will replace the electric auxiliary water pump, free of charge. Depending on the model, there are currently limited parts available, however not all parts are available at this time. Owners will be notified of the recall beginning June 11, 2018, and will receive a second notification when remedy parts become available. Owners may contact BMW customer service at BMW 1-800-525-7417, MINI at 1-866-825-1525, or Rolls-Royce at 1-877-877-3735. Note: BMW recommends that owners park their vehicle outdoors until the recall remedy has been performed.
Jan 9, 2018
BMW of North America, LLC (BMW) is recalling certain 2007-2013 X5 xDrive30i, X5 xDrive35i, X5 xDrive48i, X5 xDrive50i, X5 M, 2009-2010 X5 xDrive35d vehicles and 2009-2013 X6 xDrive35i, X6 xDrive50i, and X6 M vehicles ever registered in the states of Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands or "Zone A." BMW is also recalling certain 2007-2010 X5 xDrive30i, X5 xDrive35i, X5 xDrive48i, X5 xDrive50i, X5 M, X5 xDrive35d, X6 xDrive35i, X6 xDrive50i and X6M vehicles ever registered in the states of Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia or "Zone B." BMW is also recalling certain 2007-2009 X5 xDrive30i, X5 xdrive35i, X5 xDrive48i, X5 xDrive50i, X5 M, X5 xDrive35d, X6 xDrive35i, X6 xDrive50i and X6M vehicles ever registered in the states of AK, CO, CT, ID, IA, ME, MA, MI, MN, MT, NH, NY, ND, OR, RI, SD, UT, VT, WA, WI, and WY or "Zone C." These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the passenger frontal air bag, these inflators may explode due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Owners are advised not to drive their vehicles until the remedy is performed. BMW will notify owners, and dealers will replace the passenger front air bag module, free of charge. The recall is expected to begin March 2018. Owners may contact BMW customer service at 1-800-525-7417.
Mar 2, 2017
BMW of North America, LLC, (BMW) is recalling certain 2011-2013 X5 xDrive35i, X5 xDrive50i, X5 M and X5 xDrive35d vehicles, 2011-2014 X6 xDrive35i, X6 xDrive50i and X6M vehicles, and 2011 x6 ActiveHybrid Vehicles. Water and debris may enter the front driveshaft's universal joint, causing excessive wear and possibly resulting in the joint's failure.
Consequence & remedy
Consequence: If the front universal joint fails, the front wheels would not be driven, affecting vehicle traction. Additionally, continued driving of the vehicle with a broken front universal joint may damage other components. Either condition may increase the risk of a crash.
Remedy: BMW will notify owners, and dealers will replace the front driveshaft, free of charge. The recall began on April 18, 2017. Owners may contact BMW customer service at 1-800-525-7417.
Jan 10, 2017
BMW of North America, LLC (BMW) is recalling certain 2012 X5 xDrive30i, X5 xDrive35i, X5 xDrive48i, X5 xDrive50i, X5 M, X6 xDrive35i, X6 xDrive50i, and X6 M vehicles originally sold, or ever registered, in Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands, or "Zone A." Additionally, unless included in "Zone A" above, BMW is recalling certain 2009 X5 xDrive30i, X5 xDrive35i, X5 xDrive48i, X5 xDrive50i, and X5 M vehicles, 2008-2009 X6 xDrive 35i, X6 xDrive50i, X6 M, and 2009 X5 xDrive35d vehicles originally sold, or ever registered, in Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia, or "Zone B." Additionally, unless included in "Zone A" or "Zone B" above, BMW is recalling certain 2007-2008 X5 xDrive30i, X5 xDrive35i, X5 xDrive48i, X5 xDrive50i and X5 M vehicles, and 2008 X6 xDrive35i, X6 xDrive50i, and X6 M vehicles originally sold, or ever registered in the states of Alaska, Colorado, Connecticut, Idaho, Iowa, Maine, Massachusetts, Michigan, Minnesota, Montana, New Hampshire, New York, North Dakota, Oregon, Rhode Island, South Dakota, Utah, Vermont, Washington, Wisconsin, and Wyoming. These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the front air bags, these inflators may rupture due to propellant degradation occurring after long-term exposure to high absolute humidity and temperature cycling.
Consequence & remedy
Consequence: An inflator rupture may result in metal fragments striking the vehicle occupants resulting in serious injury or death.
Remedy: Owners are advised not to drive their vehicles until the remedy is performed. BMW will notify owners, and dealers will replace the front passenger air bag inflator or air bag module, free of charge. Interim letters were mailed March 2017. Owners will receive a second notice when remedy parts become available. Owners may contact BMW customer service at 1-800-525-7417.
Jun 13, 2012
BMW IS RECALLING CERTAIN MODEL YEAR 2012 X5 VEHICLES EQUIPPED WITH A DIESEL ENGINE AND 2013 X5 AND X6 VEHICLES. DUE TO A MACHINING ERROR OF THE STEERING GEAR SURFACE, POWER STEERING FLUID MAY LEAK.
Consequence & remedy
Consequence: LEAKING POWER STEERING FLUID CAN SPRAY ONTO HOT EXHAUST PARTS, INCREASING THE RISK OF AN ENGINE COMPARTMENT FIRE.
Remedy: BMW WILL NOTIFY OWNERS, AND DEALERS WILL INSPECT, AND IF NECESSARY, REPLACE THE STEERING GEAR FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JULY 20, 2012. OWNERS MAY CONTACT BMW CUSTOMER RELATIONS AND SERVICES AT 1-800-525-7417.
Jan 23, 2012
BMW IS RECALLING CERTAIN MODEL YEAR 2012 X5 XDRIVE 35I SPORTS ACTIVITY VEHICLES, MANUFACTURED FROM DECEMBER 19, 2011, THROUGH DECEMBER 21, 2011. DUE TO A MANUFACTURING ERROR, ENGAGEMENT OF THE TRANSMISSIONS PARKING LOCK MAY NOT OCCUR EVEN IF THE P POSITION HAS BEEN SELECTED AND IS DISPLAYED.
Consequence & remedy
Consequence: IF THE DRIVER BELIEVES THAT THE TRANSMISSION IS IN PARK AND DOES NOT USE THE PARKING BRAKE, THE VEHICLE COULD ROLL AWAY AFTER EXITING THE VEHICLE INCREASING THE RISK OF A CRASH OR INJURY.
Remedy: BMW WILL NOTIFY OWNERS, AND DEALERS WILL REPLACE THE AUTOMATIC TRANSMISSION FREE OF CHARGE. THE SAFETY RECALL BEGAN ON FEBRUARY 2, 2012. OWNERS MAY CONTACT BMW CUSTOMER RELATIONS AND SERVICES AT 1-800-525-7417.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1RQ18001 · Idler Pulley Bolt Failure
Opened Apr 18, 2018 · Closed Dec 1, 2018
Status: closed (inferred from source dates) · Steering; Steering:hydraulic Power Assist System; Steering:hydraulic Power Assist:hose, Piping, And Connections
In a May 23, 2018 letter, BMW of North America, LLC (BMW) notified the National Highway Traffic Safety Administration (NHTSA) of a safety defect that may result in the loss of power steering assist in certain model year (MY) 2009 through 2013 BMW X5 xDrive35d vehicles (Recall 18V-336). The recall, which affects approximately 33,214 vehicles built from March 12, 2008 through June 27, 2013, corrects the remedy and expands the scope of a prior BMW recall (12V-550) which addressed idle pulley bolt failure in approximately 29,800 MY 2009 through 2012 BMW X5 xDrive35d vehicles built from September 1, 2008 through November 15, 2012. BMW's analysis indicates that due to a number of contributing factors it is possible that the bolt's pre-stressing force could drop to an extent that it results in the bolt becoming loosened over time. A loosening of the bolt could cause additional bending stress on top of the bolt. As a result, the bolt could break. If this were to happen, then a sudden loss of power steering assist could occur.If there were a loss of power steering assist, manual steering capability would be retained, although the effort required to steer the vehicle would be greater, and therefore may increase the risk of crash.ODI's analysis of the complaints it has received from the public (VOQ's) and BMW complaint data submitted in response to the information request letter for RQ18-001 identified a total of 93 unique VIN reports alleging failure of the idler pulley bolt after recall 12V-550 was completed on the vehicle, including 31 VOQ's and 72 BMW consumer complaints (5 complaints received by NHTSA and BMW, 3 unique VIN's submitted multiple complaints to BMW, and 1 unique VIN submitted multiple complaints to NHTSA).BMW is developing a new idler pulley fastening system as the remedy for 18V-336.The remedy is planned to begin in February 2019.Based on BMW's safety recall, this recall query is closed.The 31 VOQ's referenced in this resume are: 10499780, 10559422, 10579534, 10655424, 10661614, 10702323, 10819617, 10903433, 10948014, 10984353, 11002447, 11010667, 11013643, 11041551, 11054759, 11054909, 11066063, 11083479, 11097562, 11098865, 11113332, 11128649, 11130277, 10552773, 10817406, 10937632, 10956710, 11032006, 11042259, 11063010, 11091513.
Additional source detail variants (3)
Steering
In a May 23, 2018 letter, BMW of North America, LLC (BMW) notified the National Highway Traffic Safety Administration (NHTSA) of a safety defect that may result in the loss of power steering assist in certain model year (MY) 2009 through 2013 BMW X5 xDrive35d vehicles (Recall 18V-336). The recall, which affects approximately 33,214 vehicles built from March 12, 2008 through June 27, 2013, corrects the remedy and expands the scope of a prior BMW recall (12V-550) which addressed idle pulley bolt failure in approximately 29,800 MY 2009 through 2012 BMW X5 xDrive35d vehicles built from September 1, 2008 through November 15, 2012. BMW's analysis indicates that due to a number of contributing factors it is possible that the bolt's pre-stressing force could drop to an extent that it results in the bolt becoming loosened over time. A loosening of the bolt could cause additional bending stress on top of the bolt. As a result, the bolt could break. If this were to happen, then a sudden loss of power steering assist could occur.If there were a loss of power steering assist, manual steering capability would be retained, although the effort required to steer the vehicle would be greater, and therefore may increase the risk of crash.ODI's analysis of the complaints it has received from the public (VOQ's) and BMW complaint data submitted in response to the information request letter for RQ18-001 identified a total of 93 unique VIN reports alleging failure of the idler pulley bolt after recall 12V-550 was completed on the vehicle, including 31 VOQ's and 72 BMW consumer complaints (5 complaints received by NHTSA and BMW, 3 unique VIN's submitted multiple complaints to BMW, and 1 unique VIN submitted multiple complaints to NHTSA).BMW is developing a new idler pulley fastening system as the remedy for 18V-336.The remedy is planned to begin in February 2019.Based on BMW's safety recall, this recall query is closed.The 31 VOQ's referenced in this resume are: 10499780, 10559422, 10579534, 10655424, 10661614, 10702323, 10819617, 10903433, 10948014, 10984353, 11002447, 11010667, 11013643, 11041551, 11054759, 11054909, 11066063, 11083479, 11097562, 11098865, 11113332, 11128649, 11130277, 10552773, 10817406, 10937632, 10956710, 11032006, 11042259, 11063010, 11091513.
Steering:hydraulic Power Assist:hose, Piping, And Connections
In a May 23, 2018 letter, BMW of North America, LLC (BMW) notified the National Highway Traffic Safety Administration (NHTSA) of a safety defect that may result in the loss of power steering assist in certain model year (MY) 2009 through 2013 BMW X5 xDrive35d vehicles (Recall 18V-336). The recall, which affects approximately 33,214 vehicles built from March 12, 2008 through June 27, 2013, corrects the remedy and expands the scope of a prior BMW recall (12V-550) which addressed idle pulley bolt failure in approximately 29,800 MY 2009 through 2012 BMW X5 xDrive35d vehicles built from September 1, 2008 through November 15, 2012. BMW's analysis indicates that due to a number of contributing factors it is possible that the bolt's pre-stressing force could drop to an extent that it results in the bolt becoming loosened over time. A loosening of the bolt could cause additional bending stress on top of the bolt. As a result, the bolt could break. If this were to happen, then a sudden loss of power steering assist could occur.If there were a loss of power steering assist, manual steering capability would be retained, although the effort required to steer the vehicle would be greater, and therefore may increase the risk of crash.ODI's analysis of the complaints it has received from the public (VOQ's) and BMW complaint data submitted in response to the information request letter for RQ18-001 identified a total of 93 unique VIN reports alleging failure of the idler pulley bolt after recall 12V-550 was completed on the vehicle, including 31 VOQ's and 72 BMW consumer complaints (5 complaints received by NHTSA and BMW, 3 unique VIN's submitted multiple complaints to BMW, and 1 unique VIN submitted multiple complaints to NHTSA).BMW is developing a new idler pulley fastening system as the remedy for 18V-336.The remedy is planned to begin in February 2019.Based on BMW's safety recall, this recall query is closed.The 31 VOQ's referenced in this resume are: 10499780, 10559422, 10579534, 10655424, 10661614, 10702323, 10819617, 10903433, 10948014, 10984353, 11002447, 11010667, 11013643, 11041551, 11054759, 11054909, 11066063, 11083479, 11097562, 11098865, 11113332, 11128649, 11130277, 10552773, 10817406, 10937632, 10956710, 11032006, 11042259, 11063010, 11091513.
Steering:hydraulic Power Assist System
In a May 23, 2018 letter, BMW of North America, LLC (BMW) notified the National Highway Traffic Safety Administration (NHTSA) of a safety defect that may result in the loss of power steering assist in certain model year (MY) 2009 through 2013 BMW X5 xDrive35d vehicles (Recall 18V-336). The recall, which affects approximately 33,214 vehicles built from March 12, 2008 through June 27, 2013, corrects the remedy and expands the scope of a prior BMW recall (12V-550) which addressed idle pulley bolt failure in approximately 29,800 MY 2009 through 2012 BMW X5 xDrive35d vehicles built from September 1, 2008 through November 15, 2012. BMW's analysis indicates that due to a number of contributing factors it is possible that the bolt's pre-stressing force could drop to an extent that it results in the bolt becoming loosened over time. A loosening of the bolt could cause additional bending stress on top of the bolt. As a result, the bolt could break. If this were to happen, then a sudden loss of power steering assist could occur.If there were a loss of power steering assist, manual steering capability would be retained, although the effort required to steer the vehicle would be greater, and therefore may increase the risk of crash.ODI's analysis of the complaints it has received from the public (VOQ's) and BMW complaint data submitted in response to the information request letter for RQ18-001 identified a total of 93 unique VIN reports alleging failure of the idler pulley bolt after recall 12V-550 was completed on the vehicle, including 31 VOQ's and 72 BMW consumer complaints (5 complaints received by NHTSA and BMW, 3 unique VIN's submitted multiple complaints to BMW, and 1 unique VIN submitted multiple complaints to NHTSA).BMW is developing a new idler pulley fastening system as the remedy for 18V-336.The remedy is planned to begin in February 2019.Based on BMW's safety recall, this recall query is closed.The 31 VOQ's referenced in this resume are: 10499780, 10559422, 10579534, 10655424, 10661614, 10702323, 10819617, 10903433, 10948014, 10984353, 11002447, 11010667, 11013643, 11041551, 11054759, 11054909, 11066063, 11083479, 11097562, 11098865, 11113332, 11128649, 11130277, 10552773, 10817406, 10937632, 10956710, 11032006, 11042259, 11063010, 11091513.
Illustration