Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
70–25K
1425–50K
2050–75K
2275–100K
23100–150K
11150K+
97 reports with mileage · 63 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Engine And Engine Cooling. Review the 31 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Electrical System. Review the 24 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Latches/locks/linkages. Review the 18 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
4 crash reports16 fire reports10 injury reports
What owners actually said
160 reports
Mileage unknown · Mar 27, 2002
Air Bags
DRIVING ON THE EXIT RAMP FROM FDR DRIVE TO THE 49TH STREET EXIT, WHEN SUDDENLY... ALL AIR BAGS ON THE DRIVER'S SIDE BEGAN TO POP. FRONT, REAR, 5 IN ALL. NO ACCIDENT. DID NOT HIT ANYTHING. NO APPARENT/OBVIOUS REASON. CAR GROUND TO A HALT; WILL NOT MOVE - RIGHT IN THE MIDDLE OF THE ROAD. CAR WAS PUSHED ASIDE TO ALLOW OTHERS TO PAS…
Read full complaint
DRIVING ON THE EXIT RAMP FROM FDR DRIVE TO THE 49TH STREET EXIT, WHEN SUDDENLY... ALL AIR BAGS ON THE DRIVER'S SIDE BEGAN TO POP. FRONT, REAR, 5 IN ALL. NO ACCIDENT. DID NOT HIT ANYTHING. NO APPARENT/OBVIOUS REASON. CAR GROUND TO A HALT; WILL NOT MOVE - RIGHT IN THE MIDDLE OF THE ROAD. CAR WAS PUSHED ASIDE TO ALLOW OTHERS TO PASS. CONTACTED BMW ROAD ASSISTANCE. CAR WAS TOWED TO BMW OF MANHATTAN. THEY ARE LOOKING IT OVER, AND WILL TELL ME THEIR FINDINGS. CURSORY INSPECTIONS SUGGESTS NOTHING COULD HAVE CAUSED IT. NO SCRATCHES, NO BUMPS, NO NICKS, NO NOTHING! ARRRRRGH! NLM
NHTSA ODI #759865
Mileage unknown · Jan 26, 2002
Visibility
THE RIGHT SIDE MIRROR IS SUPPOSED TO TILT DOWNWARD WHEN THE CAR IS PUT IN REVERSE, TO AID THE DRIVER IN BACKUP OF THE CAR. WHEN THE CAR IS PLACED IN FORWARD GEAR, THE MIRROR IS SUPPOSED TO MOVE IN THE FORWARD DRIVING DIRECTION. THE PROBLEM IS THAT EITHER THE RIGHT MIRROR DOES NOT MOVE BACK TO THE FRONT DRIVING POSITION AND/OR TH…
Read full complaint
THE RIGHT SIDE MIRROR IS SUPPOSED TO TILT DOWNWARD WHEN THE CAR IS PUT IN REVERSE, TO AID THE DRIVER IN BACKUP OF THE CAR. WHEN THE CAR IS PLACED IN FORWARD GEAR, THE MIRROR IS SUPPOSED TO MOVE IN THE FORWARD DRIVING DIRECTION. THE PROBLEM IS THAT EITHER THE RIGHT MIRROR DOES NOT MOVE BACK TO THE FRONT DRIVING POSITION AND/OR THE DRIVER SIDE MIRROR ALSO MOVES, WHEN IT IS NOT SUPPOSED TO AT ALL. THUS, YOU MUST THEN USE THE BUTTONS TO ADJUST EACH MIRROR WHEN YOU TRY TO DRIVE FORWARD. SOMETIMES YOU FORGET TO DO THIS AND DRIVE FORWARD AND REALIZE ONCE IN THE STREAM OF TRAFFIC, THE MIRROR(S) ARE IN A DANGEROUS POSITION BECAUSE THEY DON'T LET YOU SEE BEHIND YOU. THIS IS ESPECIALLY HARD IN PARALLEL PARKING IN TRAFFIC. BMW HAS KNOWN OF THIS PROBLEM IN ITS CARS FOR 18 MONTHS AS SHOWN IN THEIR PRINTOUT TO ME. THE DEALER SAID AT LEAST 10 OF THEIR CARS HAVE THIS PROBLEM AND BMW DOESN'T KNOW HOW TO FIX IT AFTER 18 MONTHS. BMW SAID THEY COULD TOTALLY DEACTIVATE THE MIRRORS, BUT THEN THEY COULD NOT BE ADJUSTED FOR A DRIVER OF DIFFERENT HEIGHT, ALSO LEADING TO A DANGEROUS SITUATION. I WROTE THE PRESIDENT OF BMW AND THEY SAID THEY ARE LOOKING INTO IT, BUT AFTER 18 MONTHS, THEY EITHER CAN'T FIX IT OR WON'T SPEND THE MONEY TO FIND OUT HOW TO FIX IT.*AK
NHTSA ODI #757359
Mileage unknown · Jan 7, 2002
Tires
THER VEHICLE CANNOT BE SAFE IN ICY CONDITION BECAUSE SNOW CHAINS CANNOT BE FITTED ON THE VEHICLE. THE DEALERSHIP IS AWARE OF THE PROBLEM.
NHTSA ODI #8001713
Mileage unknown · Jan 6, 2002
Electrical System
FAILS TO START AFTTER MULTIPLE STOPS AND HOT ENGINE ON SEVERAL OCCATIONS EVEN AFTER TWO REPAIR AT SEATTLE BMW DEALER. FAILURE LAST FROM 2 -40 MINUTES WITH MULTIPLE ATTEMPTS TO START. TAILGATE REMOTE LOCATED "ON KEY" OPENS TAILGATE AT TOUCH ATTEMPT TO START OR BUNP ON KEY. LETTER TO BMW DATED 1/6/02*AK
NHTSA ODI #756474
Mileage unknown · Oct 12, 2001
Engine And Engine Cooling
RECALL 01 V 206 003/ENGINE AUXILIARY COOLING FAN: UNABLE TO GET DEALER ; GLOBAL IMPORT; ATLANTA, GA; PHONE# 770/951-9382 TO HONOR RECALL, PARTS WERE UNAVAILBLE. FEEL FREE TO PROVIDE ANY FURTHER INFORMATION. *AK
NHTSA ODI #897652
Mileage unknown · Sep 26, 2001
Engine And Engine Cooling
CONSUMER HAD JUST GOTTEN OUT OF VEHICLE WHEN FRONT END WAS SMOKING/SPARKS FLYING, AND ASHES COMING FROM ENGINE. DEALER DIAGNOSED AUXILLARY FAN AS THE CAUSE. VEHICLE WAS PART OF RECALL 01V20600, BUT CONSUMER DID NOT RECEIVE A NOTICE. *AK
NHTSA ODI #896912
Mileage unknown · Aug 30, 2001
Suspension
TIRES WERE WEARING OUT PREMATURELY. DEALER NOTICED REAR SUSPENSION CONTROL ARM WAS BENT, CAUSING TIRES TO WEAR OUT PREMATURELY. DEALER REPLACED PART.*AK
NHTSA ODI #895525
Mileage unknown · Jul 20, 2001
Engine And Engine Cooling
MY AUX FAN IS NOT PART OF BMW'S CURRENT RECALL DUE TO FIRES HOWEVER, I DO HAVE THE "BAD" FAN AND IT IS SCHEDLUED TO BE REPLACED AS SOON AS THEY CAN GET A PART. MY CONCERN IS THAT BMW HAS NOT EXPANDED THE RECALL TO INCLUDE ALL VEHICLES WITH THE BAD FAN THAT STARTS FIRES UNDER THE HOOD.*AK
NHTSA ODI #748810
Mileage unknown · Jul 16, 2001
Fuel System, Gasoline
FUEL LEAKING FROM FUEL PUMP SEAL INTO PASSENGER'S COMPARTMENT AND OUTSIDE . PRIOR TO THE PROBLEM, DEALER REPLACED FUEL PUMP. SINCE THEN, DEALER HAS INSPECTED VEHICLE AND REPLACED FUEL TANK. PLEASE PROVIDE ADDITIONAL INFORMATION.*AK
NHTSA ODI #892815
Mileage unknown · Jul 13, 2001
Power Train
THE VEHICLE LOOSES ALL POWER TO TRANSMISSION AND GOES INTO A NEUTRAL STATE CAUSING SUDDEN STOP ON ACCELERATION, THIS POSES A THREAT WHILE PASSING VEHICLES OR TURNING OUT NOT THE HIGHWAY. NLM
BMW of North America, LLC (BMW) is recalling certain 2000-2001 X5 vehicles that may be equipped with a sport steering wheel containing a Takata PSDI-4 air bag inflator. The inflator may explode during deployment due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature, and temperature cycling.
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.
Remedy: Owners are advised not to drive their vehicles until the remedy is complete. Dealers will inspect and replace the driver's front air bag, as necessary, free of charge. Owner notification letters were mailed December 29, 2025. Owners may contact BMW customer service at 1-800-525-7417. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning December 23, 2025. This recall expands previous NHTSA recall number 19V015.
BMW of North America, LLC (BMW) is recalling certain 2000-2002 BMW 320i, 323i, 325i, 325xi, 330i, 330xi, 323Ci, 325Ci, 330Ci, M3, 323iT, 325iT and 325xiT vehicles, 2001-2002 525i, 530i, 540i, M5, 525iT and 540iT vehicles, and 2001-2003 X5 3.0i, X5 4.4i, and X5 4.6is vehicles. These vehicles may have had a driver-side air bag module installed as replacement equipment such as after a vehicle crash necessitating replacement of the original air bag, or as a remedy part for a prior recall. These replacement modules contain an air bag inflator that may rupture due to propellant degradation occurring after long-term exposure to lower absolute humidity, temperature and temperature cycling.
Consequence & remedy
Consequence: In the event of a crash necessitating deployment of the driver's frontal air bag, the inflator could rupture with metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Owners are advised not to drive their vehicles until the vehicle has been remedied. BMW will notify owners, and dealers will inspect the driver side air bag module, replacing it as necessary, free of charge. The recall began March 15, 2017. Owners may contact BMW customer service at 1-800-525-7417.
ON CERTAIN SPORT UTILITY VEHICLES, IT MAY BE POSSIBLE FOR THE FRONT BRAKE LINE TO SLIP OUT OF THE RETAINING BRACKET LOCATED AT THE FRONT STRUT. THE BRAKE HOSE THAT IS ATTACHED TO THE BRAKE LINE COULD COME IN CONTACT WITH THE TIRE AND BE SUBJECTED TO WEAR AND ABRASION.
Consequence & remedy
Consequence: THIS COULD INITIALLY CAUSE SOME BRAKE FLUID LEAKAGE, AND EVENTUALLY LEAD TO A SUBSTANTIAL LOSS OF BRAKE FLUID. THERE COULD BE A NOTICEABLE REDUCTION IN BRAKE PERFORMANCE IF A LOSS OF FRONT BRAKE PERFORMANCE OCCURS.
Remedy: DEALERS WILL INSTALL AN ADDITIONAL RETAINING CLIP TO FURTHER SECURE THE BRAKE LINE TO THE FRONT STRUT. ADDITIONALLY, IF INSPECTION OF ANY BRAKE HOSE INDICATES THAT IT HAS EXPERIENCED DAMAGE, THE HOSE WILL BE REPLACED. OWNER NOTIFICATION BEGAN FEBRUARY 14, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BMW AT 1-800-831-1117.
ON CERTAIN PASSENGER VEHICLES, DUE TO A MANUFACTURING PROBLEM, THE BRAKE PEDAL ARM PIVOT SHAFT COULD LOOSEN FROM ITS SUPPORT BRACKET.
Consequence & remedy
Consequence: EVENTUALLY, THE BRAKE PEDAL ARM COULD DETACH FROM THE BRACKET, RENDERING THE SERVICE BRAKING SYSTEM INEFFECTIVE, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL CHECK THE BRAKE PEDAL ARM PIVOT SHAFT FOR PROPER SEATING IN ITS SUPPORT BRACKET. IN ADDITION, A PIN WILL BE INSTALLED TO SECURE THE SHAFT TO THE BRACKET. OWNER NOTIFICATION BEGAN AUGUST 14, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BMW AT 1-800-332-4269.
ON CERTAIN PASSENGER VEHICLES, THE ENGINE AUXILIARY/COOLING FAN OPERATION, INCLUDING VARIABLE SPEED, IS ELECTRONICALLY CONTROLLED. FAILURE OF THE FAN MOTOR CAN CAUSE THE ELECTRICAL CIRCUITRY OF THE FAN CONTROL UNIT TO OVERLOAD AND FAIL, CAUSING THE FAN TO STOP OPERATING.
Consequence & remedy
Consequence: IF THIS WERE TO OCCUR, ENGINE OVERHEATING AND SUBSEQUENT ENGINE DAMAGE COULD RESULT. IN ADDITION, IT IS POSSIBLE FOR THE FAILURE OF THE ELECTRICAL CIRCUITRY TO CAUSE A FIRE IN THE FAN CONTROL UNIT LOCATED IN THE FRONT OF THE ENGINE COMPARTMENT.
Remedy: DEALERS WILL REPLACE THE FAN. OWNER NOTIFICATION BEGAN SEPTEMBER 28, 2001. THIS IS A SUPPLEMENT TO A RECALL THAT BEGAN DURING SEPTEMBER 2001 (SEE RECALL CAMPAIGN 01V206). OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BMW AT 1-800-831-1117.
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE ENGINE AUXILIARY/COOLING FAN OPERATION, INCLUDING VARIABLE SPEED, IS ELECTRONICALLY CONTROLLED. FAILURE OF THE FAN MOTOR CAN CAUSE THE ELECTRICAL CIRCUITRY OF THE FAN CONTROL UNIT TO OVERLOAD AND FAIL, CAUSING THE FAN TO STOP OPERATING.
Consequence & remedy
Consequence: IF THIS WERE TO OCCUR, ENGINE OVERHEATING AND SUBSEQUENT ENGINE DAMAGE COULD RESULT. IN ADDITION, IT IS POSSIBLE FOR THE FAILURE OF THE ELECTRICAL CIRCUITRY TO CAUSE A FIRE IN THE FAN CONTROL UNIT LOCATED IN THE FRONT OF THE ENGINE COMPARTMENT.
Remedy: DEALERS WILL REPLACE THE FAN. OWNER NOTIFICATION BEGAN SEPTEMBER 28, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BMW AT 1-800-831-1117.
VEHICLE DESCRIPTION: 4.4I SPORT UTILITY VEHICLES. OVER AN EXTENDED PERIOD OF TIME, ABRASION PARTICLES COULD DEPOSIT ON THE ELECTRICAL CONTACTS WITHIN THE SWITCH, CAUSING A DISRUPTION OF THE ELECTRIC CURRENT THROUGH THE CONTACTS. IF THE DISRUPTION OCCURS WHEN THE VEHICLE IS STATIONARY WITH THE TRANSMISSION IN THE NEUTRAL OR PARK POSITIONS, THE TRANSMISSION WILL SWITCH AUTOMATICALLY INTO THE EMERGENCY PROGRAM, WHICH IS DISPLAYED IN THE INSTRUMENT CLUSTER VIA A WARNING LAMP AND A MESSAGE, "TRANS. FAIL-SAFE PROG." IN THIS CASE, THE VEHICLE CAN BE DRIVEN IN LOWER GEARS ONLY WITH LIMITED ENGINE OUTPUT.
Consequence & remedy
Consequence: IF THIS PROBLEM OCCURS, THE ABILITY TO MAINTAIN SPEED IN TRAFFIC AND/OR ACCELERATE COULD BE GREATLY DIMINISHED, POSSIBLY LEADING TO A CRASH.
Remedy: DEALERS WILL REPLACE THE TRANSMISSION GEAR POSITION INDICATOR SWITCH. OWNER NOTIFICATION BEGAN AUGUST 14, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BMW AT 1-800-831-1117.
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. DUE TO AN ASSEMBLY ERROR, ONE OR BOTH SELF-LOCKING NUTS THAT SECURE THE PEDAL ASSEMBLY TO THE BOOSTER MAY HAVE BEEN CROSS-THREADED ON THE BOOSTER STUDS THAT PROTRUDE THROUGH THE FIREWALL. IN SUCH A CASE, THE NUT(S) WOULD NOT BE FULLY SEATED ON THE STUD(S).
Consequence & remedy
Consequence: IF THIS OCCURRED, THE EFFECTIVE BRAKE PEDAL TRAVEL COULD BE REDUCED DUE TO RELATIVE MOVEMENT BETWEEN THE PEDAL AND BOOSTER. BRAKING PERFORMANCE WHILE DRIVING COULD BE ADVERSELY AFFECTED. IN ADDITION, IT IS POSSIBLE THAT THE BOOSTER COULD DEVELOP A LEAK AFTER AN EXTENDED PERIOD OF TIME RESULTING IN A REDUCTION IN BRAKE POWER ASSIST.
Remedy: DEALERS WILL INSPECT THE TWO LOCK NUTS TO DETERMINE IF THEY ARE PROPERLY SEATED. IF THE NUTS ARE NOT PROPERLY SEATED OR ARE CROSS-THREADED, THE BRAKE BOOSTER WILL BE REPLACED. OWNER NOTIFICATION BEGAN AUGUST 17, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BMW AT 1-800-831-1117.
VEHICLE DESCRIPTION: PASSENGER VEHICLES. DUE TO AN ASSEMBLY ERROR DURING VEHICLE PRODUCTION, ANY OF THE THREE BOLTS THAT SECURE THE PULLEY TO THE PUMP MAY HAVE BEEN INADEQUATELY TIGHTENED.
Consequence & remedy
Consequence: IN SUCH A CASE, THE BOLTS COULD ULTIMATELY LOOSEN CAUSING THE PULLEY TO THROW OFF THE DRIVE BELT. THIS WOULD RESULT IN THE LOSS OF CERTAIN ENGINE AUXILIARY FUNCTIONS, I.E., POWER STEERING ASSIST, WATER PUMP, OR ALTERNATOR. STEERING EFFORT WOULD THEN BE INCREASED.
Remedy: DEALERS WILL INSPECT THE POWER STEERING PUMP PULLEY TO SEE IF IT IS LOOSE. IF THE PULLEY IS NOT LOOSE ON THE PUMP, THE RETAINING BOLTS WILL BE TORQUED TO SPECIFICATION. IF THE PULLEY IS LOOSE, THE PUMP, PULLEY, ATTACHING BOLTS, AND DRIVE BELT WILL BE REPLACED. OWNER NOTIFICATION BEGAN AUGUST 17, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BMW AT 1-800-831-1117.
VEHICLE DESCRIPTION: PASSENGER VEHICLES. DURING ASSEMBLY OF THESE VEHICLES, THE LOWER END OF THE SPINDLE MAY NOT HAVE BEEN INSERTED COMPLETELY INTO THE COUPLING. IN SUCH A CASE, THE FASTENING BOLT USED TO SECURE THE CONNECTION MAY NOT COMPLETELY ENGAGE THE SPINDLE WITHIN THE COUPLING. DURING DRIVING, IT WOULD BE POSSIBLE FOR THE SPINDLE TO DISCONNECT.
Consequence & remedy
Consequence: THIS COULD RESULT IN A LOSS OF STEERING CAPABILITY AND INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT THE SPINDLE TO ENSURE PROPER INSERTION IN THE COUPLING, AND, IF NECESSARY, THE SPINDLE WILL BE FULLY INSERTED AND THE FASTENING BOLT REPLACED. OWNER NOTIFICATION BEGAN FEBRUARY 6, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BMW AT 1-800-831-1117.
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. THE NUT THAT SECURES THE AXIAL JOINT OF THE LEFT STEERING TIE ROD TO THE STEERING GEAR BOX MAY HAVE NOT HAVE BEEN TIGHTENED SECURELY. THIS COULD LEAD TO LOOSENING OF THE NUT AND, INITIALLY TO STEERING WHEEL PLAY AND/OR MISALIGNMENT, AS WELL AS NOISE FROM THE STEERING LINKAGE. IF VEHICLE OPERATION CONTINUES, THE TIE ROD COULD DISCONNECT FROM THE STEERING GEAR BOX.
Consequence & remedy
Consequence: IF THIS WERE TO OCCUR, LOSS OF STEERING CONTROL COULD RESULT.
Remedy: DEALERS WILL INSPECT AND RE-TORQUE THE NUT SECURING THE AXIAL JOINT OF THE LEFT STEERING TIE ROD. IF THE TORQUE OF THE NUT IS FOUND TO BE LOOSE, THE RIGHT NUT WILL ALSO BE CHECKED AND CORRECTED IF NECESSARY, AND A FRONT WHEEL ALIGNMENT WILL BE PERFORMED.
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. THE SAFETY BELT LOWER OUTBOARD ANCHORAGE BOLT ON THE DRIVER'S AND FRONT PASSENGER'S SEATS MAY NOT HAVE BEEN SECURED PROPERLY.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, THE SAFETY BELT SYSTEM MIGHT NOT BE ABLE TO PROVIDE ITS MAXIMUM RESTRAINT FUNCTION.
Remedy: DEALERS WILL INSPECT THE BOLTS AND CORRECT THE TORQUE IF NECESSARY.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
2001 BMW X5 Problems, Complaints & Recalls | Skip That Year
Illustration