NHTSA owner reports · September 18, 2026 snapshot.
Engine And Engine Cooling complaints
31 reportsClear category filter88,000 miles · Jan 3, 2008
Engine And Engine CoolingLatches/locks/linkages
MY 2001 BMW X5 HAS SERIOS ISSUES WITH ITS DESIGN THAT BMW CORP REFUSES TO ACKNOWLEDGE OR FIX. 1ST THERE IS A FAULTY DESIGN ON THE PVC CAUSING THE VALVE TO FREEZE AND DRAIN THE OIL INTO THE ENGINE. THIS ALMOST CAUSED A FIRE IN MY CAR. AND COST ME ABOUT $1200 TO FIX. 2ND THERE IS A DESIGN FLAW WITH THE FRONT DOORS WHEREBY THE EI…
Read full complaint
MY 2001 BMW X5 HAS SERIOS ISSUES WITH ITS DESIGN THAT BMW CORP REFUSES TO ACKNOWLEDGE OR FIX. 1ST THERE IS A FAULTY DESIGN ON THE PVC CAUSING THE VALVE TO FREEZE AND DRAIN THE OIL INTO THE ENGINE. THIS ALMOST CAUSED A FIRE IN MY CAR. AND COST ME ABOUT $1200 TO FIX. 2ND THERE IS A DESIGN FLAW WITH THE FRONT DOORS WHEREBY THE EITHER FREEZE SHUT OR REFUSE TO LOCK IN TEMPERATURES BELOW 17F. THIS IS A HAZARD WAITING TO HAPPEN. PLEASE HELP US ( CONSUMERS) SINCE BMW APPARENTLY HAS NO INTEREST IN ADRESSING THESE ISSUES.*CN
NHTSA ODI #10213628
63,000 miles · Aug 26, 2007
Engine And Engine Cooling
BMW X5 3.0L 2001 1) CAR LOST POWER ON THE FREEWAY REQUIRING AN EMERGENCY STOP. VERY DANGEROUS SITUATION BUT NO ONE WAS INJURED. 2) A HOLE IN THE PLASTIC COOLING SYSTEM CAUSED THE COOLANT TO EJECT. THE ENGINE OVERHEATED CAUSING TOTAL LOSS OF ENGINE. THERE WERE NO AUDIBLE OR VISIBLE WARNINGS. APPARENTLY THIS VEHICLE DOES NOT…
Read full complaint
BMW X5 3.0L 2001 1) CAR LOST POWER ON THE FREEWAY REQUIRING AN EMERGENCY STOP. VERY DANGEROUS SITUATION BUT NO ONE WAS INJURED. 2) A HOLE IN THE PLASTIC COOLING SYSTEM CAUSED THE COOLANT TO EJECT. THE ENGINE OVERHEATED CAUSING TOTAL LOSS OF ENGINE. THERE WERE NO AUDIBLE OR VISIBLE WARNINGS. APPARENTLY THIS VEHICLE DOES NOT HAVE A COOLANT SENSOR AND THE ENGINE TEMPERATURE GAUGE CAN MALFUNCTION IF THE COOLANT HAS ALL LEAKED OUT. 3) ENTIRE ENGINE REPLACEMENT AT 63,000 MILES (OUT OF WARRANTY). CAR HAS HAD ALL BMW RECOMMENDED MAINTENANCE SERVICE. *TR
NHTSA ODI #10200828
Mileage unknown · Sep 28, 2005
Engine And Engine Cooling
THE COOLING FAN BEGAN TURNING ON AND BLOW AT MAXIMUM POWER BY ITSELF. THIS HAPPENED SEVERAL TIMES. I WAS NOT UNTIL WE TALKED WITH A ANOTHER PERSON WHO ALSO EXPERIENCED THE SAME PROBLEM, THAT WE FOUND IT THERE WAS A RECALL BY BMW. WE TOOK OUR VEHICLE TO THE DEALER (IN BUENA PARK,CA) AND WAS TOLD THAT WE HAD TO PAY FOR REPAIR…
Read full complaint
THE COOLING FAN BEGAN TURNING ON AND BLOW AT MAXIMUM POWER BY ITSELF. THIS HAPPENED SEVERAL TIMES. I WAS NOT UNTIL WE TALKED WITH A ANOTHER PERSON WHO ALSO EXPERIENCED THE SAME PROBLEM, THAT WE FOUND IT THERE WAS A RECALL BY BMW. WE TOOK OUR VEHICLE TO THE DEALER (IN BUENA PARK,CA) AND WAS TOLD THAT WE HAD TO PAY FOR REPAIRS BECAUSE WE WAITED TO LONG TO BRING THE VEHICLE IN! REMEMBER - NEITHER SAVAGE BMW NOR BMW NORTH AMERICA NOTIFIED US ABOUT THE DEFECT! SO WE HAD TO PAY FOR THE REPAIRS OUT OF POCKET AND THE DEALER REFUSED TO REIMBURSE US. *NM
NHTSA ODI #10138029
113,744 miles · Apr 1, 2005
Engine And Engine CoolingFuel System, GasolineSteering
I PURCHASED MY 2001 BMW X5, NEW IN SEPT OF 2000. I BEGAN HAVING PROBLEMS WITH IT PRETTY QUICKLY. THE MOST PLAUGING PROBLEM WAS THE GAS GAUGE. IT TOOK BMW 5 TIMES TO FINALLY FIX IT. 2/26/01 14461 MILAGE, 3/9/01 14512 MILAGE, 5/16/01 18566 MILES, 8/29/01 24493 MILES, AND FINALLY 2/26/02 37268 MILES. THERE WERE A NUMBER OF OTH…
Read full complaint
I PURCHASED MY 2001 BMW X5, NEW IN SEPT OF 2000. I BEGAN HAVING PROBLEMS WITH IT PRETTY QUICKLY. THE MOST PLAUGING PROBLEM WAS THE GAS GAUGE. IT TOOK BMW 5 TIMES TO FINALLY FIX IT. 2/26/01 14461 MILAGE, 3/9/01 14512 MILAGE, 5/16/01 18566 MILES, 8/29/01 24493 MILES, AND FINALLY 2/26/02 37268 MILES. THERE WERE A NUMBER OF OTHER ISSUES WITH THE CAR, WATER PUMP, LOWER CONTRO ARM (TWICE), AND VARIOUS OTHER NON-ESSENTIAL ITEMS. I TRIED TO ENACT THE LEMON LAW, BUT SINCE THE 3RD TIME ON THE FUEL GAUGE WAS AT 18500 MILES, I WAS TOLD IT DIDN'T APPLY. NOW AFTER 4 AND A HALF YEARS, I HAVE 114,000 MILES ON THE CAR AND I WAS JUST TOLD THAT THE MOTOR IS SHOT AND WILL HAVE TO BE REPLACED AT A COST OF $11,500. I CAN'T SINK THAT KIND OF MONEY INTO A CAR WITH THAT MANY MILES BUT I CAN'T SELL IT WITH A BAD MOTOR AND I CAN'T MAKE PAYMENTS ON TWO CARS. THIS CAR HAS BEEN ONE PROBLEM AFTER ANOTHER AND BMW HAS REFUESED HELP ME. THE ONLY OFFER THEY MADE WAS TO GIVE ME $5000.00 OFF ON A NEW CAR WHEN I HIRED A LAWYER TO TRY TO ENACT THE LEMON LAW, BUT WITH THE MILAGE I HAD ON THE CAR ALREADY I STILL WOULD HAVE OWED THEM MONEY ON THE TRADE-IN. THERE HASN'T BEEN ONE INCIDENT. IT'S JUST BEEN ONE THING AFTER ANOTHER SINCE I BOUGHT THE CAR. I HAVE PAID BMW OVER $3600.00 FOR SERVICE AND REPAIRS NOT COVERED BY WARRANTY SINCE I BOUGHT THE VEHICLE. NOW IT'S GOING TO COST ME OVER $11,000 MORE TO GET THE CAR RUNNING AGAIN. I HAVE ALL THE SERVICE RECORDS AND HAVE ALWAYS PAMPERED THE CAR. I ONLY USED THE BEST GAS, NEVER MISSED ANY SCHEDULED SERVICES. I CAN'T BELIEVE BMW IS NOT STANDING BEHIND THEIR PRODUCTS BETTER THAN THIS.*AK
NHTSA ODI #10116227
Mileage unknown · Feb 3, 2005
Engine And Engine Cooling
THE CONSUMER EXPERIENCED SUDDEN STALLING AT VARIOUS SPEEDS WHILE ON THE ROAD. THE VEHICLE WAS TAKEN TO THE SHOP, HOWEVER THE CAUSE WAS UNDETERMINED. *JB
NHTSA ODI #10109711
26,780 miles · Dec 19, 2004
Engine And Engine CoolingVisibility
BMW X-5 COOLANT SYSTEM FAILURE WITH ONLY 26,800 MILES. THE COOLANT RESERVOIR AND TUBES TO THE RADIATOR BURNED OUT. ALSO 3 POWER WINDOW REGULATORS MALFUNCTIONED. AT THIS MOMENT FIXED BUT UNACCEPTABLE FOR THE COST AND ENGINEERING OF THE CAR. ALL PARTS WERE REPLACED AND SUPPOSEDLY NEW. DID NOT SEE NEW OR OLD PARTS. *JB
NHTSA ODI #10104079
38,600 miles · Nov 21, 2004
Engine And Engine Cooling
NORMAL DRIVING, RADIATOR RESERVOIR CRACKED DURING NORMAL DRIVING, LEAKING VERY HOT RADIATOR FLUID, CAUSING SMOKING, STOPPED VEHICLE, AND HAD IT TOWED. *AK
NHTSA ODI #10100290
57,000 miles · Sep 29, 2004
Engine And Engine Cooling
FUEL TANK LEAKING. TOOK TO DEALERSHIP. NEEDED FUEL TANK AND LINES REPLACED. OVER $4,000 IN REPAIRS FOR A 2001? ASKED ABOUT RECALL ON FUEL TANKS TSB 165200.. SAID DOES NOT PERTAIN TO MY VEHICLE. WHATEVER?*AK
NHTSA ODI #10093311
Mileage unknown · May 10, 2004
Engine And Engine Cooling
WHILE DRIVING 10 MPH, THE VEHICLE STALLED. THE DRIVER TRIED TO RESTART BUT WAS UNABLE TO START. THE DRIVER NOTICED THAT THE CHECK ENGINE LIGHT FLASHED ON THEN OFF. THE DRIVER HAD THE VEHICLE TOWED TO THE DEALER FOR INSPECTION. THE MECHANIC INFORMED THE DRIVER THAT THE ENGINE NEEDED REPLACING DUE TO HEAD GASKET FAILURE. PLEA…
Read full complaint
WHILE DRIVING 10 MPH, THE VEHICLE STALLED. THE DRIVER TRIED TO RESTART BUT WAS UNABLE TO START. THE DRIVER NOTICED THAT THE CHECK ENGINE LIGHT FLASHED ON THEN OFF. THE DRIVER HAD THE VEHICLE TOWED TO THE DEALER FOR INSPECTION. THE MECHANIC INFORMED THE DRIVER THAT THE ENGINE NEEDED REPLACING DUE TO HEAD GASKET FAILURE. PLEASE PROVIDE FURTHER DETAILS. *JB
NHTSA ODI #10073429
Mileage unknown · Feb 11, 2004
Engine And Engine Cooling
VEHICLE WAS PARKED, CONSUMER STARTED UP THE VEHICLE, AND IT DID NOT NOT MOVE. CONSUMER HAD VEHICLE TOWED TO THE DEALER FOR INSPECTION, AND MECHANIC PLACED THE VEHICLE ON THE DIAGNOSTIC MACHINE. MECHANIC COULD NOT RESOLVE THE PROBLEM. *AK
NHTSA ODI #10057974
Official recalls
12Oct 31, 2025
BMW of North America, LLC (BMW) is recalling certain 2000-2001 X5 vehicles that may be equipped with a sport steering wheel containing a Takata PSDI-4 air bag inflator. The inflator may explode during deployment due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature, and temperature cycling.
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.
Remedy: Owners are advised not to drive their vehicles until the remedy is complete. Dealers will inspect and replace the driver's front air bag, as necessary, free of charge. Owner notification letters were mailed December 29, 2025. Owners may contact BMW customer service at 1-800-525-7417. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning December 23, 2025. This recall expands previous NHTSA recall number 19V015.
Jan 20, 2017
BMW of North America, LLC (BMW) is recalling certain 2000-2002 BMW 320i, 323i, 325i, 325xi, 330i, 330xi, 323Ci, 325Ci, 330Ci, M3, 323iT, 325iT and 325xiT vehicles, 2001-2002 525i, 530i, 540i, M5, 525iT and 540iT vehicles, and 2001-2003 X5 3.0i, X5 4.4i, and X5 4.6is vehicles. These vehicles may have had a driver-side air bag module installed as replacement equipment such as after a vehicle crash necessitating replacement of the original air bag, or as a remedy part for a prior recall. These replacement modules contain an air bag inflator that may rupture due to propellant degradation occurring after long-term exposure to lower absolute humidity, temperature and temperature cycling.
Consequence & remedy
Consequence: In the event of a crash necessitating deployment of the driver's frontal air bag, the inflator could rupture with metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Owners are advised not to drive their vehicles until the vehicle has been remedied. BMW will notify owners, and dealers will inspect the driver side air bag module, replacing it as necessary, free of charge. The recall began March 15, 2017. Owners may contact BMW customer service at 1-800-525-7417.
Jan 9, 2003
ON CERTAIN SPORT UTILITY VEHICLES, IT MAY BE POSSIBLE FOR THE FRONT BRAKE LINE TO SLIP OUT OF THE RETAINING BRACKET LOCATED AT THE FRONT STRUT. THE BRAKE HOSE THAT IS ATTACHED TO THE BRAKE LINE COULD COME IN CONTACT WITH THE TIRE AND BE SUBJECTED TO WEAR AND ABRASION.
Consequence & remedy
Consequence: THIS COULD INITIALLY CAUSE SOME BRAKE FLUID LEAKAGE, AND EVENTUALLY LEAD TO A SUBSTANTIAL LOSS OF BRAKE FLUID. THERE COULD BE A NOTICEABLE REDUCTION IN BRAKE PERFORMANCE IF A LOSS OF FRONT BRAKE PERFORMANCE OCCURS.
Remedy: DEALERS WILL INSTALL AN ADDITIONAL RETAINING CLIP TO FURTHER SECURE THE BRAKE LINE TO THE FRONT STRUT. ADDITIONALLY, IF INSPECTION OF ANY BRAKE HOSE INDICATES THAT IT HAS EXPERIENCED DAMAGE, THE HOSE WILL BE REPLACED. OWNER NOTIFICATION BEGAN FEBRUARY 14, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BMW AT 1-800-831-1117.
Jul 24, 2002
ON CERTAIN PASSENGER VEHICLES, DUE TO A MANUFACTURING PROBLEM, THE BRAKE PEDAL ARM PIVOT SHAFT COULD LOOSEN FROM ITS SUPPORT BRACKET.
Consequence & remedy
Consequence: EVENTUALLY, THE BRAKE PEDAL ARM COULD DETACH FROM THE BRACKET, RENDERING THE SERVICE BRAKING SYSTEM INEFFECTIVE, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL CHECK THE BRAKE PEDAL ARM PIVOT SHAFT FOR PROPER SEATING IN ITS SUPPORT BRACKET. IN ADDITION, A PIN WILL BE INSTALLED TO SECURE THE SHAFT TO THE BRACKET. OWNER NOTIFICATION BEGAN AUGUST 14, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BMW AT 1-800-332-4269.
May 16, 2002
ON CERTAIN PASSENGER VEHICLES, THE ENGINE AUXILIARY/COOLING FAN OPERATION, INCLUDING VARIABLE SPEED, IS ELECTRONICALLY CONTROLLED. FAILURE OF THE FAN MOTOR CAN CAUSE THE ELECTRICAL CIRCUITRY OF THE FAN CONTROL UNIT TO OVERLOAD AND FAIL, CAUSING THE FAN TO STOP OPERATING.
Consequence & remedy
Consequence: IF THIS WERE TO OCCUR, ENGINE OVERHEATING AND SUBSEQUENT ENGINE DAMAGE COULD RESULT. IN ADDITION, IT IS POSSIBLE FOR THE FAILURE OF THE ELECTRICAL CIRCUITRY TO CAUSE A FIRE IN THE FAN CONTROL UNIT LOCATED IN THE FRONT OF THE ENGINE COMPARTMENT.
Remedy: DEALERS WILL REPLACE THE FAN. OWNER NOTIFICATION BEGAN SEPTEMBER 28, 2001. THIS IS A SUPPLEMENT TO A RECALL THAT BEGAN DURING SEPTEMBER 2001 (SEE RECALL CAMPAIGN 01V206). OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BMW AT 1-800-831-1117.
Jun 21, 2001
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE ENGINE AUXILIARY/COOLING FAN OPERATION, INCLUDING VARIABLE SPEED, IS ELECTRONICALLY CONTROLLED. FAILURE OF THE FAN MOTOR CAN CAUSE THE ELECTRICAL CIRCUITRY OF THE FAN CONTROL UNIT TO OVERLOAD AND FAIL, CAUSING THE FAN TO STOP OPERATING.
Consequence & remedy
Consequence: IF THIS WERE TO OCCUR, ENGINE OVERHEATING AND SUBSEQUENT ENGINE DAMAGE COULD RESULT. IN ADDITION, IT IS POSSIBLE FOR THE FAILURE OF THE ELECTRICAL CIRCUITRY TO CAUSE A FIRE IN THE FAN CONTROL UNIT LOCATED IN THE FRONT OF THE ENGINE COMPARTMENT.
Remedy: DEALERS WILL REPLACE THE FAN. OWNER NOTIFICATION BEGAN SEPTEMBER 28, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BMW AT 1-800-831-1117.
Jun 14, 2001
VEHICLE DESCRIPTION: 4.4I SPORT UTILITY VEHICLES. OVER AN EXTENDED PERIOD OF TIME, ABRASION PARTICLES COULD DEPOSIT ON THE ELECTRICAL CONTACTS WITHIN THE SWITCH, CAUSING A DISRUPTION OF THE ELECTRIC CURRENT THROUGH THE CONTACTS. IF THE DISRUPTION OCCURS WHEN THE VEHICLE IS STATIONARY WITH THE TRANSMISSION IN THE NEUTRAL OR PARK POSITIONS, THE TRANSMISSION WILL SWITCH AUTOMATICALLY INTO THE EMERGENCY PROGRAM, WHICH IS DISPLAYED IN THE INSTRUMENT CLUSTER VIA A WARNING LAMP AND A MESSAGE, "TRANS. FAIL-SAFE PROG." IN THIS CASE, THE VEHICLE CAN BE DRIVEN IN LOWER GEARS ONLY WITH LIMITED ENGINE OUTPUT.
Consequence & remedy
Consequence: IF THIS PROBLEM OCCURS, THE ABILITY TO MAINTAIN SPEED IN TRAFFIC AND/OR ACCELERATE COULD BE GREATLY DIMINISHED, POSSIBLY LEADING TO A CRASH.
Remedy: DEALERS WILL REPLACE THE TRANSMISSION GEAR POSITION INDICATOR SWITCH. OWNER NOTIFICATION BEGAN AUGUST 14, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BMW AT 1-800-831-1117.
Jun 14, 2001
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. DUE TO AN ASSEMBLY ERROR, ONE OR BOTH SELF-LOCKING NUTS THAT SECURE THE PEDAL ASSEMBLY TO THE BOOSTER MAY HAVE BEEN CROSS-THREADED ON THE BOOSTER STUDS THAT PROTRUDE THROUGH THE FIREWALL. IN SUCH A CASE, THE NUT(S) WOULD NOT BE FULLY SEATED ON THE STUD(S).
Consequence & remedy
Consequence: IF THIS OCCURRED, THE EFFECTIVE BRAKE PEDAL TRAVEL COULD BE REDUCED DUE TO RELATIVE MOVEMENT BETWEEN THE PEDAL AND BOOSTER. BRAKING PERFORMANCE WHILE DRIVING COULD BE ADVERSELY AFFECTED. IN ADDITION, IT IS POSSIBLE THAT THE BOOSTER COULD DEVELOP A LEAK AFTER AN EXTENDED PERIOD OF TIME RESULTING IN A REDUCTION IN BRAKE POWER ASSIST.
Remedy: DEALERS WILL INSPECT THE TWO LOCK NUTS TO DETERMINE IF THEY ARE PROPERLY SEATED. IF THE NUTS ARE NOT PROPERLY SEATED OR ARE CROSS-THREADED, THE BRAKE BOOSTER WILL BE REPLACED. OWNER NOTIFICATION BEGAN AUGUST 17, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BMW AT 1-800-831-1117.
May 24, 2001
VEHICLE DESCRIPTION: PASSENGER VEHICLES. DUE TO AN ASSEMBLY ERROR DURING VEHICLE PRODUCTION, ANY OF THE THREE BOLTS THAT SECURE THE PULLEY TO THE PUMP MAY HAVE BEEN INADEQUATELY TIGHTENED.
Consequence & remedy
Consequence: IN SUCH A CASE, THE BOLTS COULD ULTIMATELY LOOSEN CAUSING THE PULLEY TO THROW OFF THE DRIVE BELT. THIS WOULD RESULT IN THE LOSS OF CERTAIN ENGINE AUXILIARY FUNCTIONS, I.E., POWER STEERING ASSIST, WATER PUMP, OR ALTERNATOR. STEERING EFFORT WOULD THEN BE INCREASED.
Remedy: DEALERS WILL INSPECT THE POWER STEERING PUMP PULLEY TO SEE IF IT IS LOOSE. IF THE PULLEY IS NOT LOOSE ON THE PUMP, THE RETAINING BOLTS WILL BE TORQUED TO SPECIFICATION. IF THE PULLEY IS LOOSE, THE PUMP, PULLEY, ATTACHING BOLTS, AND DRIVE BELT WILL BE REPLACED. OWNER NOTIFICATION BEGAN AUGUST 17, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BMW AT 1-800-831-1117.
Feb 6, 2001
VEHICLE DESCRIPTION: PASSENGER VEHICLES. DURING ASSEMBLY OF THESE VEHICLES, THE LOWER END OF THE SPINDLE MAY NOT HAVE BEEN INSERTED COMPLETELY INTO THE COUPLING. IN SUCH A CASE, THE FASTENING BOLT USED TO SECURE THE CONNECTION MAY NOT COMPLETELY ENGAGE THE SPINDLE WITHIN THE COUPLING. DURING DRIVING, IT WOULD BE POSSIBLE FOR THE SPINDLE TO DISCONNECT.
Consequence & remedy
Consequence: THIS COULD RESULT IN A LOSS OF STEERING CAPABILITY AND INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT THE SPINDLE TO ENSURE PROPER INSERTION IN THE COUPLING, AND, IF NECESSARY, THE SPINDLE WILL BE FULLY INSERTED AND THE FASTENING BOLT REPLACED. OWNER NOTIFICATION BEGAN FEBRUARY 6, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BMW AT 1-800-831-1117.
Oct 24, 2000
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. THE NUT THAT SECURES THE AXIAL JOINT OF THE LEFT STEERING TIE ROD TO THE STEERING GEAR BOX MAY HAVE NOT HAVE BEEN TIGHTENED SECURELY. THIS COULD LEAD TO LOOSENING OF THE NUT AND, INITIALLY TO STEERING WHEEL PLAY AND/OR MISALIGNMENT, AS WELL AS NOISE FROM THE STEERING LINKAGE. IF VEHICLE OPERATION CONTINUES, THE TIE ROD COULD DISCONNECT FROM THE STEERING GEAR BOX.
Consequence & remedy
Consequence: IF THIS WERE TO OCCUR, LOSS OF STEERING CONTROL COULD RESULT.
Remedy: DEALERS WILL INSPECT AND RE-TORQUE THE NUT SECURING THE AXIAL JOINT OF THE LEFT STEERING TIE ROD. IF THE TORQUE OF THE NUT IS FOUND TO BE LOOSE, THE RIGHT NUT WILL ALSO BE CHECKED AND CORRECTED IF NECESSARY, AND A FRONT WHEEL ALIGNMENT WILL BE PERFORMED.
Sep 11, 2000
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. THE SAFETY BELT LOWER OUTBOARD ANCHORAGE BOLT ON THE DRIVER'S AND FRONT PASSENGER'S SEATS MAY NOT HAVE BEEN SECURED PROPERLY.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, THE SAFETY BELT SYSTEM MIGHT NOT BE ABLE TO PROVIDE ITS MAXIMUM RESTRAINT FUNCTION.
Remedy: DEALERS WILL INSPECT THE BOLTS AND CORRECT THE TORQUE IF NECESSARY.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Illustration