NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
143 reports85,000 miles · Nov 11, 2012
SeatsInjury
THE HEATED SEAT DEVICE IN THE PASSENGER SEAT BECOMES HOT ENOUGH TO BURN YOUR LEG, PRIMARILY ON THE LEFT SIDE. A BURNING SENSATION AND INTENSE HEAT IS FELT WHEN THE HEATED SEAT IS TURNED ON, MAKING IT IMPOSSIBLE TO USE, FOR FEAR OF BURNS OR FIRE. APPEARS TO BE A COMMON ISSUE WITH THESE SEAT ELEMENTS, AND COULD CAUSE SERIOUS BURN…
Read full complaint
THE HEATED SEAT DEVICE IN THE PASSENGER SEAT BECOMES HOT ENOUGH TO BURN YOUR LEG, PRIMARILY ON THE LEFT SIDE. A BURNING SENSATION AND INTENSE HEAT IS FELT WHEN THE HEATED SEAT IS TURNED ON, MAKING IT IMPOSSIBLE TO USE, FOR FEAR OF BURNS OR FIRE. APPEARS TO BE A COMMON ISSUE WITH THESE SEAT ELEMENTS, AND COULD CAUSE SERIOUS BURNS OR FIRE. WHY IS THERE NOT A RECALL ON A SERIOUS BODILY INJURY, SAFETY AND FIRE ISSUE? *TR
NHTSA ODI #10483966
55,000 miles · Aug 30, 2012
SeatsInjury
FRONT SEAT HEATERS BECOME TOO HOT ON OUTSIDE BOLSTER ( LEFT SIDE ON DRIVER'S SEAT, RIGHT SIDE ON PASSENGER SEAT), BURNING HOLE IN SEAT COVER AND BURNING PERSON SITTING IN SEAT. *TR
NHTSA ODI #10473001
61,000 miles · Aug 21, 2012
Air Bags
TL* THE CONTACT OWNS A 2006 BMW X3. THE VEHICLE WAS INCLUDED IN THE RECALL UNDER NHTSA CAMPAIGN ID NUMBER: 08V384000 (AIR BAGS:FRONTAL) AND TAKEN IN FOR REPAIR BY THE PRIOR OWNER. THE CONTACT STATED THAT THE AIR BAG AND SEAT BELT WARNING LIGHTS ILLUMINATED ON THE INSTRUMENT PANEL. THE SEAT BELT WARNING CHIME WOULD SOUND. THE VEH…
Read full complaint
TL* THE CONTACT OWNS A 2006 BMW X3. THE VEHICLE WAS INCLUDED IN THE RECALL UNDER NHTSA CAMPAIGN ID NUMBER: 08V384000 (AIR BAGS:FRONTAL) AND TAKEN IN FOR REPAIR BY THE PRIOR OWNER. THE CONTACT STATED THAT THE AIR BAG AND SEAT BELT WARNING LIGHTS ILLUMINATED ON THE INSTRUMENT PANEL. THE SEAT BELT WARNING CHIME WOULD SOUND. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTICS WHERE THE CONTACT WAS ADVISED THAT THE FRONT PASSENGER SEAT MAT SENSOR WOULD HAVE TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 61,000.
NHTSA ODI #10471680
55,000 miles · Aug 2, 2012
Air Bags
TL* THE CONTACT OWNS A 2006 BMW X3. THE CONTACT STATED THAT THE PASSENGER AIR BAG LIGHT ILLUMINATED WHILE A PASSENGER WAS SEATED IN THE FRONT PASSENGER SEAT. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER AND THE CONTACT WAS INFORMED THAT THE VEHICLE WAS NOT INCLUDED IN THE RECALL ASSOCIATED WITH NHTSA CAMPAIGN ID NUMBER 08V38400…
Read full complaint
TL* THE CONTACT OWNS A 2006 BMW X3. THE CONTACT STATED THAT THE PASSENGER AIR BAG LIGHT ILLUMINATED WHILE A PASSENGER WAS SEATED IN THE FRONT PASSENGER SEAT. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER AND THE CONTACT WAS INFORMED THAT THE VEHICLE WAS NOT INCLUDED IN THE RECALL ASSOCIATED WITH NHTSA CAMPAIGN ID NUMBER 08V384000 (AIR BAGS:FRONTAL). THE CONTACT WAS ALSO INFORMED THAT THE ENTIRE FRONT PASSENGER SEAT WOULD NEED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 55,000.
NHTSA ODI #10469019
60,250 miles · Jul 23, 2012
Air Bags
TL* THE CONTACT OWNS A 2006 BMW X5. THE CONTACT STATED THAT THE FRONT PASSENGER SEAT OCCUPANT SENSOR FOR AIR BAG WAS DEFECTIVE. THE AIR BAG WARNING LIGHT WAS ILLUMINATED. THE VEHICLE WAS TAKEN TO DEALER WHO STATED THERE WAS A DEFECT HOWEVER THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE HOWEVER NO FUR…
Read full complaint
TL* THE CONTACT OWNS A 2006 BMW X5. THE CONTACT STATED THAT THE FRONT PASSENGER SEAT OCCUPANT SENSOR FOR AIR BAG WAS DEFECTIVE. THE AIR BAG WARNING LIGHT WAS ILLUMINATED. THE VEHICLE WAS TAKEN TO DEALER WHO STATED THERE WAS A DEFECT HOWEVER THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE HOWEVER NO FURTHER ASSISTANCE WAS OFFERED. THE APPROXIMATE CURRENT MILEAGE WAS 60,260. THE FAILURE MILEAGE WAS 60,250.
NHTSA ODI #10467004
60,500 miles · Jul 2, 2012
Visibility
AFTER EACH RAINFALL, FRONT AND/OR REAR PASSENGER FOOTWELLS FLOOD, DEPENDING ON THE ANGLE THAT THE VEHICLE IS PARKED. DEALERSHIP REPLACED VAPOR BARRIERS BUT A WATER TEST REVEALED THAT THE SUNROOF GLASS IS TOO LOW, CAUSING THE LEAK. *JS
NHTSA ODI #10463969
65,000 miles · Apr 20, 2012
Electrical SystemSeats
HEATING ELEMENT FOR FRONT DRIVER SEAT SHORTED, CAUSING IT TO BURN THROUGH THE LEATHER. FORTUNATELY, I CAUGHT IT IN TIME BEFORE FIRE OR INJURY. SEARCHING THE INTERNET REVEALS THAT THIS HAS OCCURRED FOR MANY OTHERS AS WELL, SOMETIMES WITH MORE DAMAGING RESULTS. *JS
NHTSA ODI #10455878
50,850 miles · Jan 30, 2012
Electrical SystemSeatsFireInjury
DRIVER SEAT CAUGHT FIRE WHEN SEAT WARMER WAS ENGAGED. LEATHER SEAT HAS VISIBLE BURN MARK. FIRE BURNED DRIVER. WHEN SEAT WARMER WAS DISENGAGED, SMOKE BEGAN BILLOWING FROM SEAT, FILLING THE VEHICLE WITH SMOKE. SEAT WARMER WAS ENGAGED UPON VEHICLE START IN OWNER'S GARAGE. VEHICLE WAS MOVING APPROXIMATELY 10 MPS (1-2 MINS LATER) WH…
Read full complaint
DRIVER SEAT CAUGHT FIRE WHEN SEAT WARMER WAS ENGAGED. LEATHER SEAT HAS VISIBLE BURN MARK. FIRE BURNED DRIVER. WHEN SEAT WARMER WAS DISENGAGED, SMOKE BEGAN BILLOWING FROM SEAT, FILLING THE VEHICLE WITH SMOKE. SEAT WARMER WAS ENGAGED UPON VEHICLE START IN OWNER'S GARAGE. VEHICLE WAS MOVING APPROXIMATELY 10 MPS (1-2 MINS LATER) WHEN FIRE BEGAN. *TT
NHTSA ODI #10445930
33,000 miles · Jan 13, 2012
Seats
AFTER MY 2006 BMW X3 HAD BEEN RUNNING FOR ABOUT 10 MINUTES, WITH THE HEATED SEAT ON, I BEGAN TO FEEL A BURN IN MY BOTTOM AS WELL AS SMELL SMOKE. I PULLED OVER, GOT OUT, AND NOTICED THAT THE LEFT CUSHION OF MY DRIVERS SEAT WAS SMOKING AND HAD MELTED ABOUT A QUARTER SIZE HOLE IN THE LEATHER UPHOLSTERY. THIS IS A COMMON AND KNOW …
Read full complaint
AFTER MY 2006 BMW X3 HAD BEEN RUNNING FOR ABOUT 10 MINUTES, WITH THE HEATED SEAT ON, I BEGAN TO FEEL A BURN IN MY BOTTOM AS WELL AS SMELL SMOKE. I PULLED OVER, GOT OUT, AND NOTICED THAT THE LEFT CUSHION OF MY DRIVERS SEAT WAS SMOKING AND HAD MELTED ABOUT A QUARTER SIZE HOLE IN THE LEATHER UPHOLSTERY. THIS IS A COMMON AND KNOW ISSUE TO BMW. HOWEVER, THEY HAVE NOT ISSUED A RECALL. VERY DANGEROUS!!! *TR
NHTSA ODI #10443671
67,000 miles · Dec 6, 2011
Engine And Engine CoolingFuel System, Gasoline
THE INTAKE BOOT BETWEEN THE MASS AIR SENSOR AND THE THROTTLE BODY CRACKS OVER TIME. THIS CAUSES THE CHECK ENGINE LIGHT TO COME ON. EVEN THOUGH THIS IS A KNOWN FAILURE ITEM, AND THE CAR IS WITHIN THE CPO WARRANTY PERIOD, BMW DOES NOT COVER ANY HOSES OR TUBES, AS THEY BELIEVE THEY ARE "WEAR" ITEMS. SINCE IT IS NOT COVERED ITS A $…
Read full complaint
THE INTAKE BOOT BETWEEN THE MASS AIR SENSOR AND THE THROTTLE BODY CRACKS OVER TIME. THIS CAUSES THE CHECK ENGINE LIGHT TO COME ON. EVEN THOUGH THIS IS A KNOWN FAILURE ITEM, AND THE CAR IS WITHIN THE CPO WARRANTY PERIOD, BMW DOES NOT COVER ANY HOSES OR TUBES, AS THEY BELIEVE THEY ARE "WEAR" ITEMS. SINCE IT IS NOT COVERED ITS A $175 DOLLAR DIAGNOSTIC FEE AND $38.54 FOR THE PART VS $50 DEDUCTIBLE. YOU DO NOT KNOW IF YOUR REPAIR IS COVERED UNTIL THE DIAGNOSTIC, SO SHORT OF HAVING TO TAKE IT TO ANOTHER MECHANIC TO HAVE IT CHECKED YOU COULD BE PENALIZED $125 FOR WANTING YOU CAR REPAIRED UNDER THE EXTENDED WARRANTY WHICH YOU PAID EXTRA FOR. *TR
NHTSA ODI #10438764
Official recalls
2Sep 28, 2017
BMW of North America, LLC (BMW) is recalling certain 2006-2010 BMW X3 2.5i, X3 3.0i and X3 xDrive30i Sports Activity Vehicles. The front passenger seat occupant detection mat that determines if, and how, the passenger frontal air bag should deploy in a crash may fatigue and develop cracks which could lead to a system failure.
Consequence & remedy
Consequence: Should the system fail, in the event of a crash, the front passenger air bag would be deactivated, increasing the risk of personal injury.
Remedy: BMW will notify owners, and dealers will replace the front passenger seat occupant detection mat, free of charge. Interim owner notification letters were mailed on November 27, 2017. A second notification letter will be sent when parts are available. Owners may contact BMW customer service at 1-800-525-7417.
Aug 5, 2008
BMW IS RECALLING 200,000 MY 2006 3 SERIES SPORT SEAT, MY 2004-2006 5 SERIES STANDARD AND SPORT SEAT, AND MY 2004-2006 X3 PASSENGER VEHICLES. DEPENDING ON THE MANNER AND FREQUENCY OF THE FRONT PASSENGER'S ENTRY AND EXIT, SMALL CRACKS HAVE DEVELOPED IN THE MAT. IF THIS OCCURS, THE FRONT PASSENGER AIR BAGS, WITH THE EXCEPTION OF THE HEAD PROTECTION SYSTEM, WILL BE DEACTIVATED AND THE AIR BAG WARNING LAMP AS WELL AS THE PASSENGER AIR BAG "ON-OFF" LAMP WILL BE ILLUMINATED.
Consequence & remedy
Consequence: IN THIS SITUATION THE FRONT PASSENGER AIR BAGS WILL NOT DEPLOY EVEN IF A SUFFICIENTLY SEVERE ACCIDENT WOULD OCCUR AND OCCUPANT PROTECTION PROVIDED BY THE SYSTEM WOULD NOT BE POSSIBLE.
Remedy: DEALERS WILL REWORK THE FRONT PASSENGER SEAT SENSOR MAT SO THAT EXTERNAL FORCE APPLICATION TO THE SEAT DOES NOT CAUSE A CRACK TO THE MAT. THE RECALL BEGAN ON NOVEMBER 6, 2008. BMW WILL ALSO EXTEND THE WARRANTY ON THESE VEHICLES TO 10 YEARS FROM FIRST REGISTRATION WITHOUT ANY MILEAGE LIMIT. OWNERS MAY CONTACT BMW AT 1-800-525-7417.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA08001 · BMW Airbag Light Illumination
Opened Jan 4, 2008 · Closed Dec 31, 2008
Status: closed (inferred from source dates) · Air Bags; Air Bags:frontal; Air Bags:frontal:sensor/control MODULE-INACTIVE
BMW IS CONDUCTING A SAFETY RECALL CAMPAIGN ON APPROXIMATELY 200,000 MY04 THROUGH MY06 SUBJECT VEHICLES BUILT THROUGH 11/30/05 TO CORRECT THE FRONT PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT. THE SPECIFIC VEHICLES INCLUDED IN THE RECALL AREMY04- 06/ 5-SERIES WITH STANDARD AND SPORT SEATS, MY04-06/ X3-SERIES AND MY06/ 3-SERIES WITH SPORT SEATS. IN ADDITION, BMW WILL EXTEND THE WARRANTY COVERAGE OF THE PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT TO 10-YEAR/UNLIMITED MILEAGE ON APPROXIMATELY 120,000 REMAINING MY04-06 SUBJECT VEHICLES BUILT THROUGH 11/30/05. THE SPECIFIC VEHICLES INCLUDED IN THE EXTENDED WARRANTY ARE MY 06/ 6 SERIES, MY 06/ 3-SERIES WITH STANDARD SEATS, MY04-05/ Z4, MY04-06/ 7 SERIES, MY 06/ X5, AND MY04-06/ 5-SERIES WITH COMFORT SEATS.THE AVERAGE FREQUENCY OF FAILURES AMONG THE EXTENDED WARRANTY GROUPS WAS LESS THAN 1/7TH OF THE RECALL VEHICLE GROUPS.PLEASE SEE BMW'S 08V-384 RECALL NOTIFICATION FOR FURTHER DETAILSDEPENDING ON SEAT CONFIGURATION AND VEHICLE GEOMETRY, THE OCCUPANT DETECTION MAT CAN FATIGUE DURING USE DEPENDING ON THE MANNER AND FREQUENCY OF THE FRONT PASSENGER'S ENTRY AND EXIT.SPECIFICALLY, OVER TIME, MICRO-CRACKS COULD DEVELOP IN THE SIDE FLANKS OF THE MAT CAUSING A BROKEN CIRCUIT.A BROKENCIRCUIT CAN LEAD TO THE DEACTIVATION OF THE PASSENGER AIR BAG AND THE ILLUMINATION OF BOTH THE AIR BAG WARNING LIGHT AND THE PASSENGER AIR BAG LIGHT.
Additional source detail variants (3)
Air Bags
BMW IS CONDUCTING A SAFETY RECALL CAMPAIGN ON APPROXIMATELY 200,000 MY04 THROUGH MY06 SUBJECT VEHICLES BUILT THROUGH 11/30/05 TO CORRECT THE FRONT PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT. THE SPECIFIC VEHICLES INCLUDED IN THE RECALL AREMY04- 06/ 5-SERIES WITH STANDARD AND SPORT SEATS, MY04-06/ X3-SERIES AND MY06/ 3-SERIES WITH SPORT SEATS. IN ADDITION, BMW WILL EXTEND THE WARRANTY COVERAGE OF THE PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT TO 10-YEAR/UNLIMITED MILEAGE ON APPROXIMATELY 120,000 REMAINING MY04-06 SUBJECT VEHICLES BUILT THROUGH 11/30/05. THE SPECIFIC VEHICLES INCLUDED IN THE EXTENDED WARRANTY ARE MY 06/ 6 SERIES, MY 06/ 3-SERIES WITH STANDARD SEATS, MY04-05/ Z4, MY04-06/ 7 SERIES, MY 06/ X5, AND MY04-06/ 5-SERIES WITH COMFORT SEATS.THE AVERAGE FREQUENCY OF FAILURES AMONG THE EXTENDED WARRANTY GROUPS WAS LESS THAN 1/7TH OF THE RECALL VEHICLE GROUPS.PLEASE SEE BMW'S 08V-384 RECALL NOTIFICATION FOR FURTHER DETAILSDEPENDING ON SEAT CONFIGURATION AND VEHICLE GEOMETRY, THE OCCUPANT DETECTION MAT CAN FATIGUE DURING USE DEPENDING ON THE MANNER AND FREQUENCY OF THE FRONT PASSENGER'S ENTRY AND EXIT.SPECIFICALLY, OVER TIME, MICRO-CRACKS COULD DEVELOP IN THE SIDE FLANKS OF THE MAT CAUSING A BROKEN CIRCUIT.A BROKENCIRCUIT CAN LEAD TO THE DEACTIVATION OF THE PASSENGER AIR BAG AND THE ILLUMINATION OF BOTH THE AIR BAG WARNING LIGHT AND THE PASSENGER AIR BAG LIGHT.
Air Bags:frontal
BMW IS CONDUCTING A SAFETY RECALL CAMPAIGN ON APPROXIMATELY 200,000 MY04 THROUGH MY06 SUBJECT VEHICLES BUILT THROUGH 11/30/05 TO CORRECT THE FRONT PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT. THE SPECIFIC VEHICLES INCLUDED IN THE RECALL AREMY04- 06/ 5-SERIES WITH STANDARD AND SPORT SEATS, MY04-06/ X3-SERIES AND MY06/ 3-SERIES WITH SPORT SEATS. IN ADDITION, BMW WILL EXTEND THE WARRANTY COVERAGE OF THE PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT TO 10-YEAR/UNLIMITED MILEAGE ON APPROXIMATELY 120,000 REMAINING MY04-06 SUBJECT VEHICLES BUILT THROUGH 11/30/05. THE SPECIFIC VEHICLES INCLUDED IN THE EXTENDED WARRANTY ARE MY 06/ 6 SERIES, MY 06/ 3-SERIES WITH STANDARD SEATS, MY04-05/ Z4, MY04-06/ 7 SERIES, MY 06/ X5, AND MY04-06/ 5-SERIES WITH COMFORT SEATS.THE AVERAGE FREQUENCY OF FAILURES AMONG THE EXTENDED WARRANTY GROUPS WAS LESS THAN 1/7TH OF THE RECALL VEHICLE GROUPS.PLEASE SEE BMW'S 08V-384 RECALL NOTIFICATION FOR FURTHER DETAILSDEPENDING ON SEAT CONFIGURATION AND VEHICLE GEOMETRY, THE OCCUPANT DETECTION MAT CAN FATIGUE DURING USE DEPENDING ON THE MANNER AND FREQUENCY OF THE FRONT PASSENGER'S ENTRY AND EXIT.SPECIFICALLY, OVER TIME, MICRO-CRACKS COULD DEVELOP IN THE SIDE FLANKS OF THE MAT CAUSING A BROKEN CIRCUIT.A BROKENCIRCUIT CAN LEAD TO THE DEACTIVATION OF THE PASSENGER AIR BAG AND THE ILLUMINATION OF BOTH THE AIR BAG WARNING LIGHT AND THE PASSENGER AIR BAG LIGHT.
Air Bags:frontal:sensor/control MODULE-INACTIVE
BMW IS CONDUCTING A SAFETY RECALL CAMPAIGN ON APPROXIMATELY 200,000 MY04 THROUGH MY06 SUBJECT VEHICLES BUILT THROUGH 11/30/05 TO CORRECT THE FRONT PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT. THE SPECIFIC VEHICLES INCLUDED IN THE RECALL AREMY04- 06/ 5-SERIES WITH STANDARD AND SPORT SEATS, MY04-06/ X3-SERIES AND MY06/ 3-SERIES WITH SPORT SEATS. IN ADDITION, BMW WILL EXTEND THE WARRANTY COVERAGE OF THE PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT TO 10-YEAR/UNLIMITED MILEAGE ON APPROXIMATELY 120,000 REMAINING MY04-06 SUBJECT VEHICLES BUILT THROUGH 11/30/05. THE SPECIFIC VEHICLES INCLUDED IN THE EXTENDED WARRANTY ARE MY 06/ 6 SERIES, MY 06/ 3-SERIES WITH STANDARD SEATS, MY04-05/ Z4, MY04-06/ 7 SERIES, MY 06/ X5, AND MY04-06/ 5-SERIES WITH COMFORT SEATS.THE AVERAGE FREQUENCY OF FAILURES AMONG THE EXTENDED WARRANTY GROUPS WAS LESS THAN 1/7TH OF THE RECALL VEHICLE GROUPS.PLEASE SEE BMW'S 08V-384 RECALL NOTIFICATION FOR FURTHER DETAILSDEPENDING ON SEAT CONFIGURATION AND VEHICLE GEOMETRY, THE OCCUPANT DETECTION MAT CAN FATIGUE DURING USE DEPENDING ON THE MANNER AND FREQUENCY OF THE FRONT PASSENGER'S ENTRY AND EXIT.SPECIFICALLY, OVER TIME, MICRO-CRACKS COULD DEVELOP IN THE SIDE FLANKS OF THE MAT CAUSING A BROKEN CIRCUIT.A BROKENCIRCUIT CAN LEAD TO THE DEACTIVATION OF THE PASSENGER AIR BAG AND THE ILLUMINATION OF BOTH THE AIR BAG WARNING LIGHT AND THE PASSENGER AIR BAG LIGHT.
PE07045 · BMW Airbag Light Illumination
Opened Sep 4, 2007 · Closed Jan 4, 2008
Status: closed (inferred from source dates) · Air Bags; Air Bags:frontal; Air Bags:frontal:sensor/control MODULE-INACTIVE
IN CERTAIN MY 2005 THROUGH MY 2006 BMW VEHICLES, THE OCCUPANT CLASSIFICATION SYSTEM (OCS) FOR THE PASSENGER FRONTAL AIRBAG MAY MALFUNCTION AND RENDER THE PASSENGER AIRBAG INOPERATIVE.IN JUNE 2006, BMW ISSUED A TECHNICAL SERVICE BULLETIN (SI B 72 02 06) REGARDING THE ILLUMINATION OF THE AIRBAG WARNING LIGHT AND THE PASSENGER AIRBAG STATUS LAMP.ILLUMINATION OF THESE LIGHTS WARN THAT AN OPEN ELECTRICAL CIRCUIT MAY BE PRESENT WITHIN THE PASSENGER SEAT MAT SENSOR.WHEN BOTH OF THE LIGHTS ARE ILLUMINATED, THE PASSENGER FRONTAL AIR BAG WILL NOT DEPLOY IN A FRONTAL CRASH.CERTAIN BMW VEHICLES IN ADDITION TO THE SUBJECT VEHICLES CONTAIN THE SAME SEAT MAT SENSOR.THESE ARE THE MY 2004 5-SERIES, 7-SERIES AND X3, THE MY 2004 THROUGH 2006Z-4 SERIES AND MY 2006 3-SERIES, 6-SERIES AND X5 VEHICLES.AN IMPROVED SEAT MAT SENSOR WAS INTRODUCED IN DECEMBER 2005 FOR THE MID-MY 2006 PRODUCTION.IN RESPONSE TO ODI'S INFORMATION REQUEST LETTER, BMW PROVIDED 1,172 OWNER REPORTS AND 28,238 WARRANTY CLAIMS.INITIAL REVIEW OF THE DATA INDICATE THAT 280 NON-DUPLICATING OWNER REPORTS AND 13,051 NON-DUPLICATING WARRANTY CLAIMS MAY BE RELATED THE SUBJECT DEFECT ISSUE ON THE SUBJECT VEHICLESTHIS PRELIMINARY EVALUATION IS BEING UPGRADED TO AN ENGINEERING ANALYSIS (EA08-001).
Additional source detail variants (3)
Air Bags
IN CERTAIN MY 2005 THROUGH MY 2006 BMW VEHICLES, THE OCCUPANT CLASSIFICATION SYSTEM (OCS) FOR THE PASSENGER FRONTAL AIRBAG MAY MALFUNCTION AND RENDER THE PASSENGER AIRBAG INOPERATIVE.IN JUNE 2006, BMW ISSUED A TECHNICAL SERVICE BULLETIN (SI B 72 02 06) REGARDING THE ILLUMINATION OF THE AIRBAG WARNING LIGHT AND THE PASSENGER AIRBAG STATUS LAMP.ILLUMINATION OF THESE LIGHTS WARN THAT AN OPEN ELECTRICAL CIRCUIT MAY BE PRESENT WITHIN THE PASSENGER SEAT MAT SENSOR.WHEN BOTH OF THE LIGHTS ARE ILLUMINATED, THE PASSENGER FRONTAL AIR BAG WILL NOT DEPLOY IN A FRONTAL CRASH.CERTAIN BMW VEHICLES IN ADDITION TO THE SUBJECT VEHICLES CONTAIN THE SAME SEAT MAT SENSOR.THESE ARE THE MY 2004 5-SERIES, 7-SERIES AND X3, THE MY 2004 THROUGH 2006Z-4 SERIES AND MY 2006 3-SERIES, 6-SERIES AND X5 VEHICLES.AN IMPROVED SEAT MAT SENSOR WAS INTRODUCED IN DECEMBER 2005 FOR THE MID-MY 2006 PRODUCTION.IN RESPONSE TO ODI'S INFORMATION REQUEST LETTER, BMW PROVIDED 1,172 OWNER REPORTS AND 28,238 WARRANTY CLAIMS.INITIAL REVIEW OF THE DATA INDICATE THAT 280 NON-DUPLICATING OWNER REPORTS AND 13,051 NON-DUPLICATING WARRANTY CLAIMS MAY BE RELATED THE SUBJECT DEFECT ISSUE ON THE SUBJECT VEHICLESTHIS PRELIMINARY EVALUATION IS BEING UPGRADED TO AN ENGINEERING ANALYSIS (EA08-001).
Air Bags:frontal
IN CERTAIN MY 2005 THROUGH MY 2006 BMW VEHICLES, THE OCCUPANT CLASSIFICATION SYSTEM (OCS) FOR THE PASSENGER FRONTAL AIRBAG MAY MALFUNCTION AND RENDER THE PASSENGER AIRBAG INOPERATIVE.IN JUNE 2006, BMW ISSUED A TECHNICAL SERVICE BULLETIN (SI B 72 02 06) REGARDING THE ILLUMINATION OF THE AIRBAG WARNING LIGHT AND THE PASSENGER AIRBAG STATUS LAMP.ILLUMINATION OF THESE LIGHTS WARN THAT AN OPEN ELECTRICAL CIRCUIT MAY BE PRESENT WITHIN THE PASSENGER SEAT MAT SENSOR.WHEN BOTH OF THE LIGHTS ARE ILLUMINATED, THE PASSENGER FRONTAL AIR BAG WILL NOT DEPLOY IN A FRONTAL CRASH.CERTAIN BMW VEHICLES IN ADDITION TO THE SUBJECT VEHICLES CONTAIN THE SAME SEAT MAT SENSOR.THESE ARE THE MY 2004 5-SERIES, 7-SERIES AND X3, THE MY 2004 THROUGH 2006Z-4 SERIES AND MY 2006 3-SERIES, 6-SERIES AND X5 VEHICLES.AN IMPROVED SEAT MAT SENSOR WAS INTRODUCED IN DECEMBER 2005 FOR THE MID-MY 2006 PRODUCTION.IN RESPONSE TO ODI'S INFORMATION REQUEST LETTER, BMW PROVIDED 1,172 OWNER REPORTS AND 28,238 WARRANTY CLAIMS.INITIAL REVIEW OF THE DATA INDICATE THAT 280 NON-DUPLICATING OWNER REPORTS AND 13,051 NON-DUPLICATING WARRANTY CLAIMS MAY BE RELATED THE SUBJECT DEFECT ISSUE ON THE SUBJECT VEHICLESTHIS PRELIMINARY EVALUATION IS BEING UPGRADED TO AN ENGINEERING ANALYSIS (EA08-001).
Air Bags:frontal:sensor/control MODULE-INACTIVE
IN CERTAIN MY 2005 THROUGH MY 2006 BMW VEHICLES, THE OCCUPANT CLASSIFICATION SYSTEM (OCS) FOR THE PASSENGER FRONTAL AIRBAG MAY MALFUNCTION AND RENDER THE PASSENGER AIRBAG INOPERATIVE.IN JUNE 2006, BMW ISSUED A TECHNICAL SERVICE BULLETIN (SI B 72 02 06) REGARDING THE ILLUMINATION OF THE AIRBAG WARNING LIGHT AND THE PASSENGER AIRBAG STATUS LAMP.ILLUMINATION OF THESE LIGHTS WARN THAT AN OPEN ELECTRICAL CIRCUIT MAY BE PRESENT WITHIN THE PASSENGER SEAT MAT SENSOR.WHEN BOTH OF THE LIGHTS ARE ILLUMINATED, THE PASSENGER FRONTAL AIR BAG WILL NOT DEPLOY IN A FRONTAL CRASH.CERTAIN BMW VEHICLES IN ADDITION TO THE SUBJECT VEHICLES CONTAIN THE SAME SEAT MAT SENSOR.THESE ARE THE MY 2004 5-SERIES, 7-SERIES AND X3, THE MY 2004 THROUGH 2006Z-4 SERIES AND MY 2006 3-SERIES, 6-SERIES AND X5 VEHICLES.AN IMPROVED SEAT MAT SENSOR WAS INTRODUCED IN DECEMBER 2005 FOR THE MID-MY 2006 PRODUCTION.IN RESPONSE TO ODI'S INFORMATION REQUEST LETTER, BMW PROVIDED 1,172 OWNER REPORTS AND 28,238 WARRANTY CLAIMS.INITIAL REVIEW OF THE DATA INDICATE THAT 280 NON-DUPLICATING OWNER REPORTS AND 13,051 NON-DUPLICATING WARRANTY CLAIMS MAY BE RELATED THE SUBJECT DEFECT ISSUE ON THE SUBJECT VEHICLESTHIS PRELIMINARY EVALUATION IS BEING UPGRADED TO AN ENGINEERING ANALYSIS (EA08-001).
Illustration