IllustrationWHEN I TURNED ON THE DRIVER'S SIDE SEAT HEATER, THE SEAT HEATER BURNED THROUGH AND BURNED A HOLE THROUGH MY CLOTHES
2005 BMW X3
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2005 BMW X3 do not stand out strongly from the model-year median of 86.
About this comparison →How this year compares
Owner complaints by model year
Compare all X3 years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
70–25K
1325–50K
1650–75K
2275–100K
26100–150K
9150K+
93 reports with mileage · 10 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Seats. Review the 48 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Air Bags. Review the 30 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 18 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
4 crash reports18 fire reports17 injury reports
What owners actually said
103 reportsPASSENGER AIR SAYS OFF WHEN A PASSENGER IS IN SEAT ## VIN PASSED ## BMW X3 2005 ##
THE INTERNAL WIRING OF THE HID HEADLIGHTS HAS DETERIORATED TO THE POINT OF FALLING APART LEAVING BARE CONDUCTORS IN MULTIPLE LOCATIONS. THIS HAS CAUSED THE HEADLIGHTS, ADAPTIVE MOTOR DRIVES, AND DECORATIVE LIGHTING TO BE INTERMITTENT AND FAIL. WITH THE BARE CONDUCTORS, AN APPRECIABLE FIRE HAZARD EXISTS.
TL* THE CONTACT OWNS A 2005 BMW X3. WHILE DRIVING ON LOOSE GRAVEL AT APPROXIMATELY 50 MPH, THE CONTACT LOST CONTROL OF THE VEHICLE. THE VEHICLE ROLLED OVER AND THE DRIVER'S SIDE WINDOW SHATTERED. THE AIR BAGS DID NOT DEPLOY. THE CONTACT SUSTAINED INJURIES TO THE LEFT HAND, WHICH REQUIRED MEDICAL ATTENTION. A POLICE REPORT WAS FI…
Read full complaint
TL* THE CONTACT OWNS A 2005 BMW X3. WHILE DRIVING ON LOOSE GRAVEL AT APPROXIMATELY 50 MPH, THE CONTACT LOST CONTROL OF THE VEHICLE. THE VEHICLE ROLLED OVER AND THE DRIVER'S SIDE WINDOW SHATTERED. THE AIR BAGS DID NOT DEPLOY. THE CONTACT SUSTAINED INJURIES TO THE LEFT HAND, WHICH REQUIRED MEDICAL ATTENTION. A POLICE REPORT WAS FILED. THE VEHICLE WAS TOWED TO THE DEALER WHERE IT WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VIN AND FAILURE MILEAGE WERE UNAVAILABLE.
ACCORDING TO YOUR BULLETIN THERE ARE PROBLEMS WITH THE PASSENGER AIRBAG ( WHICH I AM HAVING) BUT THERE IS NO RECALL BY BMW. AIRBAG LIGHT GOES ON AND OFF.
TL* THE CONTACT OWNS A 2005 BMW X3. THE CONTACT STATED THAT THE AIR BAG WARNING LIGHT REMAINED ILLUMINATED FOR AN EXTENDED PERIOD OF TIME. THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 08V384000 (AIR BAGS). THE VIN WAS NOT AVAILABLE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VIN AND FAILURE MILEAGE WERE NOT AVAI…
Read full complaint
TL* THE CONTACT OWNS A 2005 BMW X3. THE CONTACT STATED THAT THE AIR BAG WARNING LIGHT REMAINED ILLUMINATED FOR AN EXTENDED PERIOD OF TIME. THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 08V384000 (AIR BAGS). THE VIN WAS NOT AVAILABLE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VIN AND FAILURE MILEAGE WERE NOT AVAILABLE. UPDATED 05/20/16*LJ UPDATED 11/21/2017*JS
BOTH SEATS. PURCHASED THIS VEHICLE WITH 183K MILES. WAS GETTING COLD OUT, TURNED ON THE HEATED SEAT FUNCTION AND NOTICED A BURNING SMELL UPON DRIVING DOWN THE COUNTRY ROADS FROM MY HOUSE. THE SIDE OF THE DRIVERS SEAT MELTED THROUGH. COULD SEE IT GLOWING INSIDE OF THE SEAT. SOMEONE HAD DONE A SEAT REPAIR PREVIOUSLY TO COVER THIS…
Read full complaint
BOTH SEATS. PURCHASED THIS VEHICLE WITH 183K MILES. WAS GETTING COLD OUT, TURNED ON THE HEATED SEAT FUNCTION AND NOTICED A BURNING SMELL UPON DRIVING DOWN THE COUNTRY ROADS FROM MY HOUSE. THE SIDE OF THE DRIVERS SEAT MELTED THROUGH. COULD SEE IT GLOWING INSIDE OF THE SEAT. SOMEONE HAD DONE A SEAT REPAIR PREVIOUSLY TO COVER THIS ISSUE. APPROX. 1 YEAR LATER I WAS DRIVING DOWN THE HIGHWAY WHEN MY PASSENGER HAD TURNED ON HIS HEATED SEAT. HE STARTED YELLING AND NOTICED THE SEAT HAD BURNED THROUGH THE LEATHER. LUCKILY NO ACCIDENTS WERE CAUSED.
I BOUGHT A BMW X3 IN 2005 AND NOTICED THAT WHEN THE MOTOR IS OFF THE HORN DOES NOT SOUND. MY HUSBAND BOUGHT A BMW 3 SERIES IN 2007, AND MY DAUGHTER/SON IN LAW BOUGHT AN X1 TWO MONTHS AGO. AND I HAVE ASKED FRIENDS WHO OWN BMW'S AND THEY SAY THE SAME THING - WHEN THE MOTOR IS OFF, THE HORN DOES NOT SOUND. THIS IS NOT NECESSARI…
Read full complaint
I BOUGHT A BMW X3 IN 2005 AND NOTICED THAT WHEN THE MOTOR IS OFF THE HORN DOES NOT SOUND. MY HUSBAND BOUGHT A BMW 3 SERIES IN 2007, AND MY DAUGHTER/SON IN LAW BOUGHT AN X1 TWO MONTHS AGO. AND I HAVE ASKED FRIENDS WHO OWN BMW'S AND THEY SAY THE SAME THING - WHEN THE MOTOR IS OFF, THE HORN DOES NOT SOUND. THIS IS NOT NECESSARILY A SAFETY ISSUE BUT IT CERTAINLY CAN BE. MY BROTHER DRIVES A FORD SUV IN THE CHICAGO AREA. LAST MONTH HIS CAR SLIPPED OFF A VERY ICY ROAD AND WAS COVERED BY SNOW ALMOST IMMEDIATELY! HE WAS REALLY STUCK AND TOLD ME THAT IF HE COULD NOT SOUND THE HORN WHEN A POLICE OFFICER WAS PASSING, HE WOULD HAVE REALLY BEEN IN TROUBLE (CELL PHONE WAS AT HOME - OF COURSE). AND THEN THERE IS MY NOT TOO BIG PROBLEM -- WAITING IN THE CAR FOR HUBBY TO COME OUT AND CAN NOT SOUND THE HORN. LAST WEEK I WAS PARKED IN A LINE WAITING FOR A TRAIN TO COME WHEN THE TRUCK IN FRONT OF ME BEGAN TO BACK UP. MY MOTOR WAS OFF (BEEN WAITING AWHILE) AND I HAD TO FIGURE OUT WHERE I HAD PUT THE KEYS, GET THE MOTOR ENGAGED AND THEN BEEP AT THE TRUCK -- JUST INCHES FROM HIM HITTING ME!
MY WIFE HAS A 2005 BMW X3 WITH AN AIRBAG WARNING INDICATOR LIGHT ILLUMINATED ON THE DASH. THE PROBLEM/SYMPTOM IS THAT THERE IS A LITTLE RED LIGHT IN THE INSTRUMENT CLUSTER THAT LOOKS LIKE AN AIRBAG IS DEPLOYED ALONG WITH A YELLOW LIGHT ABOVE YOUR HEAD THAT SAYS "PASSENGER AIRBAG OFF". SO IN THE EVENT OF AN ACCIDENT THE PASSENGER…
Read full complaint
MY WIFE HAS A 2005 BMW X3 WITH AN AIRBAG WARNING INDICATOR LIGHT ILLUMINATED ON THE DASH. THE PROBLEM/SYMPTOM IS THAT THERE IS A LITTLE RED LIGHT IN THE INSTRUMENT CLUSTER THAT LOOKS LIKE AN AIRBAG IS DEPLOYED ALONG WITH A YELLOW LIGHT ABOVE YOUR HEAD THAT SAYS "PASSENGER AIRBAG OFF". SO IN THE EVENT OF AN ACCIDENT THE PASSENGER AIRBAG WOULD NOT DEPLOY. THERE IS A SENSOR UNDER THE PASSENGER SEAT THAT IS BASICALLY THERE SO THAT IF A PERSON THAT DOES NOT WEIGH A CERTAIN AMOUNT, LIKE A CHILD FOR EXAMPLE, IS SITTING THERE THE BAG WILL NOT DEPLOY BECAUSE IT HAS BEEN KNOWN TO CAUSE PROBLEMS FOR SMALLER INDIVIDUALS. HOWEVER, SINCE THE SENSOR BECOMES DEFECTIVE, THE SYSTEM DEFAULTS TO AIRBAG OFF MODE AND THEREFORE YOU NEVER HAVE AN AIRBAG REGARDLESS OF WHO IS IN THE PASSENGER SEAT. THE DEALER TOLD ME THEY COULD DO NOTHING FOR US BECAUSE THE VIN NUMBER DID NOT MATCH THE RECALL, BUT BMWUSA IS THE ONE THAT INDICATED THAT THERE IS AN EXTENDED WARRANTY SPECIFICALLY FOR THIS PROBLEM WITH THE AIRBAG LIGHT AND THAT IT WOULD BE COVERED REGARDLESS OF THE VIN MATCHING THE RECALL. RIVERSIDE BMW HAS REFUSED TO HELP US WITH THIS MATTER BUT STATED THAT IF BMW OF NORTH AMERICA AUTHORIZED THE FIX, THEY WOULD REPAIR THE SEAT SENSOR MAT. CAN YOU PLEASE HELP US RESOLVE THIS ISSUE WITH BMW. THANK YOU, MARK SULLIVAN
BOUGHT USED WITH 105,378 MILES. HUSBAND DROVE 55 MILES A WEEK FOR 16 WEEKS. PARKED IN LOT FOR 5 MONTHS (20 WEEKS). I DROVE IT TO THE DEALERSHIP IT HAD 107 K ON IT. IN AN 8 HOUR PERIOD IT GAINED OVER 2500 MILES ON AN 8TH OF TANK OF GAS. WHEN I GOT IT BACK IT HAD 110K ON IT. DEALERSHIP BLAMED THE KEY. DIFFERENT MECHANIC CHECKE…
Read full complaint
BOUGHT USED WITH 105,378 MILES. HUSBAND DROVE 55 MILES A WEEK FOR 16 WEEKS. PARKED IN LOT FOR 5 MONTHS (20 WEEKS). I DROVE IT TO THE DEALERSHIP IT HAD 107 K ON IT. IN AN 8 HOUR PERIOD IT GAINED OVER 2500 MILES ON AN 8TH OF TANK OF GAS. WHEN I GOT IT BACK IT HAD 110K ON IT. DEALERSHIP BLAMED THE KEY. DIFFERENT MECHANIC CHECKED NOTHING WRONG WITH ODOMETER OR COMPUTER. THAT WAS JANUARY OF 2015. HE DROVE IT FROM JANUARY TO APRIL, THEN PARKED IT FOR THE REST OF THE YEAR. GOT IN IT IN DECEMBER, DROVE 11MILES ROUND TRIP AND ODOMETER JUMPED TO 115,187 FROM AN ESTIMATE OF 111K (WHEN IT WAS PARKED.) DEALERSHIP CAN'T EXPLAIN, MECHANICS CAN'T EXPLAIN AND BMWUSA CAN'T EXPLAIN HOW THIS VEHICLE HAS GAINED OVER 6K ON THE ODOMETER WHILE IT HAS BEEN PARKED.
Official recalls
108V384000 · Air Bags:frontal
Aug 5, 2008
BMW IS RECALLING 200,000 MY 2006 3 SERIES SPORT SEAT, MY 2004-2006 5 SERIES STANDARD AND SPORT SEAT, AND MY 2004-2006 X3 PASSENGER VEHICLES. DEPENDING ON THE MANNER AND FREQUENCY OF THE FRONT PASSENGER'S ENTRY AND EXIT, SMALL CRACKS HAVE DEVELOPED IN THE MAT. IF THIS OCCURS, THE FRONT PASSENGER AIR BAGS, WITH THE EXCEPTION OF THE HEAD PROTECTION SYSTEM, WILL BE DEACTIVATED AND THE AIR BAG WARNING LAMP AS WELL AS THE PASSENGER AIR BAG "ON-OFF" LAMP WILL BE ILLUMINATED.
Consequence & remedy
Consequence: IN THIS SITUATION THE FRONT PASSENGER AIR BAGS WILL NOT DEPLOY EVEN IF A SUFFICIENTLY SEVERE ACCIDENT WOULD OCCUR AND OCCUPANT PROTECTION PROVIDED BY THE SYSTEM WOULD NOT BE POSSIBLE.
Remedy: DEALERS WILL REWORK THE FRONT PASSENGER SEAT SENSOR MAT SO THAT EXTERNAL FORCE APPLICATION TO THE SEAT DOES NOT CAUSE A CRACK TO THE MAT. THE RECALL BEGAN ON NOVEMBER 6, 2008. BMW WILL ALSO EXTEND THE WARRANTY ON THESE VEHICLES TO 10 YEARS FROM FIRST REGISTRATION WITHOUT ANY MILEAGE LIMIT. OWNERS MAY CONTACT BMW AT 1-800-525-7417.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA08001 · BMW Airbag Light Illumination
Opened Jan 4, 2008 · Closed Dec 31, 2008
Status: closed (inferred from source dates) · Air Bags; Air Bags:frontal; Air Bags:frontal:sensor/control MODULE-INACTIVE
BMW IS CONDUCTING A SAFETY RECALL CAMPAIGN ON APPROXIMATELY 200,000 MY04 THROUGH MY06 SUBJECT VEHICLES BUILT THROUGH 11/30/05 TO CORRECT THE FRONT PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT. THE SPECIFIC VEHICLES INCLUDED IN THE RECALL AREMY04- 06/ 5-SERIES WITH STANDARD AND SPORT SEATS, MY04-06/ X3-SERIES AND MY06/ 3-SERIES WITH SPORT SEATS. IN ADDITION, BMW WILL EXTEND THE WARRANTY COVERAGE OF THE PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT TO 10-YEAR/UNLIMITED MILEAGE ON APPROXIMATELY 120,000 REMAINING MY04-06 SUBJECT VEHICLES BUILT THROUGH 11/30/05. THE SPECIFIC VEHICLES INCLUDED IN THE EXTENDED WARRANTY ARE MY 06/ 6 SERIES, MY 06/ 3-SERIES WITH STANDARD SEATS, MY04-05/ Z4, MY04-06/ 7 SERIES, MY 06/ X5, AND MY04-06/ 5-SERIES WITH COMFORT SEATS.THE AVERAGE FREQUENCY OF FAILURES AMONG THE EXTENDED WARRANTY GROUPS WAS LESS THAN 1/7TH OF THE RECALL VEHICLE GROUPS.PLEASE SEE BMW'S 08V-384 RECALL NOTIFICATION FOR FURTHER DETAILSDEPENDING ON SEAT CONFIGURATION AND VEHICLE GEOMETRY, THE OCCUPANT DETECTION MAT CAN FATIGUE DURING USE DEPENDING ON THE MANNER AND FREQUENCY OF THE FRONT PASSENGER'S ENTRY AND EXIT.SPECIFICALLY, OVER TIME, MICRO-CRACKS COULD DEVELOP IN THE SIDE FLANKS OF THE MAT CAUSING A BROKEN CIRCUIT.A BROKENCIRCUIT CAN LEAD TO THE DEACTIVATION OF THE PASSENGER AIR BAG AND THE ILLUMINATION OF BOTH THE AIR BAG WARNING LIGHT AND THE PASSENGER AIR BAG LIGHT.
Additional source detail variants (3)
Air Bags
BMW IS CONDUCTING A SAFETY RECALL CAMPAIGN ON APPROXIMATELY 200,000 MY04 THROUGH MY06 SUBJECT VEHICLES BUILT THROUGH 11/30/05 TO CORRECT THE FRONT PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT. THE SPECIFIC VEHICLES INCLUDED IN THE RECALL AREMY04- 06/ 5-SERIES WITH STANDARD AND SPORT SEATS, MY04-06/ X3-SERIES AND MY06/ 3-SERIES WITH SPORT SEATS. IN ADDITION, BMW WILL EXTEND THE WARRANTY COVERAGE OF THE PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT TO 10-YEAR/UNLIMITED MILEAGE ON APPROXIMATELY 120,000 REMAINING MY04-06 SUBJECT VEHICLES BUILT THROUGH 11/30/05. THE SPECIFIC VEHICLES INCLUDED IN THE EXTENDED WARRANTY ARE MY 06/ 6 SERIES, MY 06/ 3-SERIES WITH STANDARD SEATS, MY04-05/ Z4, MY04-06/ 7 SERIES, MY 06/ X5, AND MY04-06/ 5-SERIES WITH COMFORT SEATS.THE AVERAGE FREQUENCY OF FAILURES AMONG THE EXTENDED WARRANTY GROUPS WAS LESS THAN 1/7TH OF THE RECALL VEHICLE GROUPS.PLEASE SEE BMW'S 08V-384 RECALL NOTIFICATION FOR FURTHER DETAILSDEPENDING ON SEAT CONFIGURATION AND VEHICLE GEOMETRY, THE OCCUPANT DETECTION MAT CAN FATIGUE DURING USE DEPENDING ON THE MANNER AND FREQUENCY OF THE FRONT PASSENGER'S ENTRY AND EXIT.SPECIFICALLY, OVER TIME, MICRO-CRACKS COULD DEVELOP IN THE SIDE FLANKS OF THE MAT CAUSING A BROKEN CIRCUIT.A BROKENCIRCUIT CAN LEAD TO THE DEACTIVATION OF THE PASSENGER AIR BAG AND THE ILLUMINATION OF BOTH THE AIR BAG WARNING LIGHT AND THE PASSENGER AIR BAG LIGHT.
Air Bags:frontal
BMW IS CONDUCTING A SAFETY RECALL CAMPAIGN ON APPROXIMATELY 200,000 MY04 THROUGH MY06 SUBJECT VEHICLES BUILT THROUGH 11/30/05 TO CORRECT THE FRONT PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT. THE SPECIFIC VEHICLES INCLUDED IN THE RECALL AREMY04- 06/ 5-SERIES WITH STANDARD AND SPORT SEATS, MY04-06/ X3-SERIES AND MY06/ 3-SERIES WITH SPORT SEATS. IN ADDITION, BMW WILL EXTEND THE WARRANTY COVERAGE OF THE PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT TO 10-YEAR/UNLIMITED MILEAGE ON APPROXIMATELY 120,000 REMAINING MY04-06 SUBJECT VEHICLES BUILT THROUGH 11/30/05. THE SPECIFIC VEHICLES INCLUDED IN THE EXTENDED WARRANTY ARE MY 06/ 6 SERIES, MY 06/ 3-SERIES WITH STANDARD SEATS, MY04-05/ Z4, MY04-06/ 7 SERIES, MY 06/ X5, AND MY04-06/ 5-SERIES WITH COMFORT SEATS.THE AVERAGE FREQUENCY OF FAILURES AMONG THE EXTENDED WARRANTY GROUPS WAS LESS THAN 1/7TH OF THE RECALL VEHICLE GROUPS.PLEASE SEE BMW'S 08V-384 RECALL NOTIFICATION FOR FURTHER DETAILSDEPENDING ON SEAT CONFIGURATION AND VEHICLE GEOMETRY, THE OCCUPANT DETECTION MAT CAN FATIGUE DURING USE DEPENDING ON THE MANNER AND FREQUENCY OF THE FRONT PASSENGER'S ENTRY AND EXIT.SPECIFICALLY, OVER TIME, MICRO-CRACKS COULD DEVELOP IN THE SIDE FLANKS OF THE MAT CAUSING A BROKEN CIRCUIT.A BROKENCIRCUIT CAN LEAD TO THE DEACTIVATION OF THE PASSENGER AIR BAG AND THE ILLUMINATION OF BOTH THE AIR BAG WARNING LIGHT AND THE PASSENGER AIR BAG LIGHT.
Air Bags:frontal:sensor/control MODULE-INACTIVE
BMW IS CONDUCTING A SAFETY RECALL CAMPAIGN ON APPROXIMATELY 200,000 MY04 THROUGH MY06 SUBJECT VEHICLES BUILT THROUGH 11/30/05 TO CORRECT THE FRONT PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT. THE SPECIFIC VEHICLES INCLUDED IN THE RECALL AREMY04- 06/ 5-SERIES WITH STANDARD AND SPORT SEATS, MY04-06/ X3-SERIES AND MY06/ 3-SERIES WITH SPORT SEATS. IN ADDITION, BMW WILL EXTEND THE WARRANTY COVERAGE OF THE PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT TO 10-YEAR/UNLIMITED MILEAGE ON APPROXIMATELY 120,000 REMAINING MY04-06 SUBJECT VEHICLES BUILT THROUGH 11/30/05. THE SPECIFIC VEHICLES INCLUDED IN THE EXTENDED WARRANTY ARE MY 06/ 6 SERIES, MY 06/ 3-SERIES WITH STANDARD SEATS, MY04-05/ Z4, MY04-06/ 7 SERIES, MY 06/ X5, AND MY04-06/ 5-SERIES WITH COMFORT SEATS.THE AVERAGE FREQUENCY OF FAILURES AMONG THE EXTENDED WARRANTY GROUPS WAS LESS THAN 1/7TH OF THE RECALL VEHICLE GROUPS.PLEASE SEE BMW'S 08V-384 RECALL NOTIFICATION FOR FURTHER DETAILSDEPENDING ON SEAT CONFIGURATION AND VEHICLE GEOMETRY, THE OCCUPANT DETECTION MAT CAN FATIGUE DURING USE DEPENDING ON THE MANNER AND FREQUENCY OF THE FRONT PASSENGER'S ENTRY AND EXIT.SPECIFICALLY, OVER TIME, MICRO-CRACKS COULD DEVELOP IN THE SIDE FLANKS OF THE MAT CAUSING A BROKEN CIRCUIT.A BROKENCIRCUIT CAN LEAD TO THE DEACTIVATION OF THE PASSENGER AIR BAG AND THE ILLUMINATION OF BOTH THE AIR BAG WARNING LIGHT AND THE PASSENGER AIR BAG LIGHT.
PE07045 · BMW Airbag Light Illumination
Opened Sep 4, 2007 · Closed Jan 4, 2008
Status: closed (inferred from source dates) · Air Bags; Air Bags:frontal; Air Bags:frontal:sensor/control MODULE-INACTIVE
IN CERTAIN MY 2005 THROUGH MY 2006 BMW VEHICLES, THE OCCUPANT CLASSIFICATION SYSTEM (OCS) FOR THE PASSENGER FRONTAL AIRBAG MAY MALFUNCTION AND RENDER THE PASSENGER AIRBAG INOPERATIVE.IN JUNE 2006, BMW ISSUED A TECHNICAL SERVICE BULLETIN (SI B 72 02 06) REGARDING THE ILLUMINATION OF THE AIRBAG WARNING LIGHT AND THE PASSENGER AIRBAG STATUS LAMP.ILLUMINATION OF THESE LIGHTS WARN THAT AN OPEN ELECTRICAL CIRCUIT MAY BE PRESENT WITHIN THE PASSENGER SEAT MAT SENSOR.WHEN BOTH OF THE LIGHTS ARE ILLUMINATED, THE PASSENGER FRONTAL AIR BAG WILL NOT DEPLOY IN A FRONTAL CRASH.CERTAIN BMW VEHICLES IN ADDITION TO THE SUBJECT VEHICLES CONTAIN THE SAME SEAT MAT SENSOR.THESE ARE THE MY 2004 5-SERIES, 7-SERIES AND X3, THE MY 2004 THROUGH 2006Z-4 SERIES AND MY 2006 3-SERIES, 6-SERIES AND X5 VEHICLES.AN IMPROVED SEAT MAT SENSOR WAS INTRODUCED IN DECEMBER 2005 FOR THE MID-MY 2006 PRODUCTION.IN RESPONSE TO ODI'S INFORMATION REQUEST LETTER, BMW PROVIDED 1,172 OWNER REPORTS AND 28,238 WARRANTY CLAIMS.INITIAL REVIEW OF THE DATA INDICATE THAT 280 NON-DUPLICATING OWNER REPORTS AND 13,051 NON-DUPLICATING WARRANTY CLAIMS MAY BE RELATED THE SUBJECT DEFECT ISSUE ON THE SUBJECT VEHICLESTHIS PRELIMINARY EVALUATION IS BEING UPGRADED TO AN ENGINEERING ANALYSIS (EA08-001).
Additional source detail variants (3)
Air Bags
IN CERTAIN MY 2005 THROUGH MY 2006 BMW VEHICLES, THE OCCUPANT CLASSIFICATION SYSTEM (OCS) FOR THE PASSENGER FRONTAL AIRBAG MAY MALFUNCTION AND RENDER THE PASSENGER AIRBAG INOPERATIVE.IN JUNE 2006, BMW ISSUED A TECHNICAL SERVICE BULLETIN (SI B 72 02 06) REGARDING THE ILLUMINATION OF THE AIRBAG WARNING LIGHT AND THE PASSENGER AIRBAG STATUS LAMP.ILLUMINATION OF THESE LIGHTS WARN THAT AN OPEN ELECTRICAL CIRCUIT MAY BE PRESENT WITHIN THE PASSENGER SEAT MAT SENSOR.WHEN BOTH OF THE LIGHTS ARE ILLUMINATED, THE PASSENGER FRONTAL AIR BAG WILL NOT DEPLOY IN A FRONTAL CRASH.CERTAIN BMW VEHICLES IN ADDITION TO THE SUBJECT VEHICLES CONTAIN THE SAME SEAT MAT SENSOR.THESE ARE THE MY 2004 5-SERIES, 7-SERIES AND X3, THE MY 2004 THROUGH 2006Z-4 SERIES AND MY 2006 3-SERIES, 6-SERIES AND X5 VEHICLES.AN IMPROVED SEAT MAT SENSOR WAS INTRODUCED IN DECEMBER 2005 FOR THE MID-MY 2006 PRODUCTION.IN RESPONSE TO ODI'S INFORMATION REQUEST LETTER, BMW PROVIDED 1,172 OWNER REPORTS AND 28,238 WARRANTY CLAIMS.INITIAL REVIEW OF THE DATA INDICATE THAT 280 NON-DUPLICATING OWNER REPORTS AND 13,051 NON-DUPLICATING WARRANTY CLAIMS MAY BE RELATED THE SUBJECT DEFECT ISSUE ON THE SUBJECT VEHICLESTHIS PRELIMINARY EVALUATION IS BEING UPGRADED TO AN ENGINEERING ANALYSIS (EA08-001).
Air Bags:frontal
IN CERTAIN MY 2005 THROUGH MY 2006 BMW VEHICLES, THE OCCUPANT CLASSIFICATION SYSTEM (OCS) FOR THE PASSENGER FRONTAL AIRBAG MAY MALFUNCTION AND RENDER THE PASSENGER AIRBAG INOPERATIVE.IN JUNE 2006, BMW ISSUED A TECHNICAL SERVICE BULLETIN (SI B 72 02 06) REGARDING THE ILLUMINATION OF THE AIRBAG WARNING LIGHT AND THE PASSENGER AIRBAG STATUS LAMP.ILLUMINATION OF THESE LIGHTS WARN THAT AN OPEN ELECTRICAL CIRCUIT MAY BE PRESENT WITHIN THE PASSENGER SEAT MAT SENSOR.WHEN BOTH OF THE LIGHTS ARE ILLUMINATED, THE PASSENGER FRONTAL AIR BAG WILL NOT DEPLOY IN A FRONTAL CRASH.CERTAIN BMW VEHICLES IN ADDITION TO THE SUBJECT VEHICLES CONTAIN THE SAME SEAT MAT SENSOR.THESE ARE THE MY 2004 5-SERIES, 7-SERIES AND X3, THE MY 2004 THROUGH 2006Z-4 SERIES AND MY 2006 3-SERIES, 6-SERIES AND X5 VEHICLES.AN IMPROVED SEAT MAT SENSOR WAS INTRODUCED IN DECEMBER 2005 FOR THE MID-MY 2006 PRODUCTION.IN RESPONSE TO ODI'S INFORMATION REQUEST LETTER, BMW PROVIDED 1,172 OWNER REPORTS AND 28,238 WARRANTY CLAIMS.INITIAL REVIEW OF THE DATA INDICATE THAT 280 NON-DUPLICATING OWNER REPORTS AND 13,051 NON-DUPLICATING WARRANTY CLAIMS MAY BE RELATED THE SUBJECT DEFECT ISSUE ON THE SUBJECT VEHICLESTHIS PRELIMINARY EVALUATION IS BEING UPGRADED TO AN ENGINEERING ANALYSIS (EA08-001).
Air Bags:frontal:sensor/control MODULE-INACTIVE
IN CERTAIN MY 2005 THROUGH MY 2006 BMW VEHICLES, THE OCCUPANT CLASSIFICATION SYSTEM (OCS) FOR THE PASSENGER FRONTAL AIRBAG MAY MALFUNCTION AND RENDER THE PASSENGER AIRBAG INOPERATIVE.IN JUNE 2006, BMW ISSUED A TECHNICAL SERVICE BULLETIN (SI B 72 02 06) REGARDING THE ILLUMINATION OF THE AIRBAG WARNING LIGHT AND THE PASSENGER AIRBAG STATUS LAMP.ILLUMINATION OF THESE LIGHTS WARN THAT AN OPEN ELECTRICAL CIRCUIT MAY BE PRESENT WITHIN THE PASSENGER SEAT MAT SENSOR.WHEN BOTH OF THE LIGHTS ARE ILLUMINATED, THE PASSENGER FRONTAL AIR BAG WILL NOT DEPLOY IN A FRONTAL CRASH.CERTAIN BMW VEHICLES IN ADDITION TO THE SUBJECT VEHICLES CONTAIN THE SAME SEAT MAT SENSOR.THESE ARE THE MY 2004 5-SERIES, 7-SERIES AND X3, THE MY 2004 THROUGH 2006Z-4 SERIES AND MY 2006 3-SERIES, 6-SERIES AND X5 VEHICLES.AN IMPROVED SEAT MAT SENSOR WAS INTRODUCED IN DECEMBER 2005 FOR THE MID-MY 2006 PRODUCTION.IN RESPONSE TO ODI'S INFORMATION REQUEST LETTER, BMW PROVIDED 1,172 OWNER REPORTS AND 28,238 WARRANTY CLAIMS.INITIAL REVIEW OF THE DATA INDICATE THAT 280 NON-DUPLICATING OWNER REPORTS AND 13,051 NON-DUPLICATING WARRANTY CLAIMS MAY BE RELATED THE SUBJECT DEFECT ISSUE ON THE SUBJECT VEHICLESTHIS PRELIMINARY EVALUATION IS BEING UPGRADED TO AN ENGINEERING ANALYSIS (EA08-001).