Engine. Review the 32 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Electrical System. Review the 20 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Fuel/propulsion System. Review the 14 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

1 crash reports11 fire reports0 injury reports

Service Brakes complaints

3 reports

Clear category filter

Mileage unknown · Jan 31, 2026

Service Brakes

Read full complaint

1. TICKING NOISE WHILE CORNERING WITHOUT THE BRAKES APPLIED: Ticking noise coming from front wheel while cornering without brakes applied, noticeable at low speeds. The vehicle must be moving. 2. CRACKING NOISES FROM THE FRONTAXLE AREA WHILE TURNING THE WHEELS, WHEN STATION: Cracking noises are heard from the front axle area while maneuvering at low speeds (e.g., parking lot maneuvers) or when turning the steering wheel while stationary. I am reporting safety issues that were never addressed by BMW North America, and for which I received no notification. Although I purchased my vehicle used, I registered it with BMW USA. The vehicle is out of warranty, but it is affected by the conditions described in SIB 34 05 17 and SIB 31 01 12. BMW USA is refusing to correct these defects, despite their clear safety implications. I was never informed of these issues by BMW USA.

NHTSA ODI #11714732

53,000 miles · Apr 21, 2017

Electrical SystemService BrakesSteering

Read full complaint

MY 2011 BMW 550I HAS THRICE HAD THIS WEIRD RESPONSE IN THE PAST 6 MONTHS. AFTER DRIVING FOR 30M-1H SUDDENLY GOT MULTIPLE DIFFERENT WARNING LIGHTS BEFORE I LOST CONTROL OF STEERING (STIFF LIKE A DEAD BODY) AND BRAKES FOLLOWING WHICH THE CAR STALLED. IT WAS TOWED TO THE DEALERSHIP WHO SAID THIS WAS A BAD BATTERY WHICH DID NOT MAKE SENSE BUT THE CAR WAS RUNNING THEREAFTER SO I TOOK IT HOME. THE SECOND TIME THE DEALERSHIP WAS CLOSED - I WAS ABLE TO START THE CAR A FEW MINUTES LATER AND TOOK THE RISK OF DRIVING HOME. THE DEALERSHIP SAID SINCE THE CAR WAS RUNNING THEY COULD NOT RUN ANY DIAGNOSIS. THEREAFTER THE CAR RAN FINE FOR 3 WEEKS AND THEN IT HAPPENED AGAIN. THIS TIME I COULD RESTART IT BUT THE CAR WOULD ONLY MOVE A FEW FEET BEFORE STALLING. AFTER TOWING IT TO THE DEALER THEY TELL ME THAT THE BATTERY AND ALTERNATOR BOTH ARE BAD. I CAN UNDERSTAND THAT BUT THERE SHOULD NEVER BE A TOTAL LOSS OF CONTROL ON STEERING AND BRAKES. THAT TO ME IS A SAFETY ISSUE AND BMW NEEDS TO FIX IT BUT THE DEALERSHIP DOES NOT SEEM TO KNOW WHAT TO DO. THEY JUST WANT TO FIX THE BATTERY AND ALTERNATOR AND CALL IT "PROBLEM RESOLVED" WITHOUT DIGGING FURTHER. I HAVE NOT SEEN ANY RECALLS EITHER. I AM NOW AFRAID TO DRIVE THE CAR BECAUSE IT COULD GET ME KILLED.

NHTSA ODI #10979764

7,000 miles · Sep 12, 2013

Service BrakesWheels

Read full complaint

THIS COMPLAINT IS CONCERNING MY 2011 BMW 550I. I HAVE BEEN HAVING PROBLEMS WITH MY BMW SINCE ABOUT 7000 MILES ON THE VEHICLE. THE BRAKES KEEP LOCKING, THE ROTORS KEEP GRINDING AND GROOVING, NOSE COMING FROM THE BRAKES WHILE DRIVING AND STOPPING, AND THE DEALER HAS CHANGED THEM MORE THAN 4 TIMES AND THE ISSUES CONTINUES TO HAPPEN. THEY ADVISED ME THAT THEY CANNOT FIX IT AND THERE IS NOTHING ELSE THEY CAN DO. PLEASE HELP ME WITH MY VEHICLE ISSUE. IT HAS BEEN PARKED FROM MORE THAN A YEAR AND A HALF AND I FEEL THAT IT IS A SAFETY ISSUE. I FEEL LIKE MY LIFE IS IN DANGER IF I DRIVE THIS VEHICLE. *TR

NHTSA ODI #10543299

Official recalls

18V248000 · Engine And Engine Cooling:engine; Engine And Engine Cooling:engine:gasoline:turbo/supercharger

Apr 18, 2018

BMW of North America, LLC (BMW) is recalling certain 2011-2012 BMW 550i, 550i xDrive, 550i Gran Turismo, 550i Gran Turismo xDrive, 750i, 750Li, 750i xDrive, 750Li xDrive, 760Li, X5 xDrive50i, X5 M, X6 xDrive50i, X6 M, ActiveHybrid7, MINI Cooper S Convertible, John Cooper Works (JCW) Convertible, Cooper S Countryman, Cooper S Countryman ALL4, Cooper S, JCW, Cooper S Clubman, JCW Clubman, Cooper S Roadster, JCW Roadster, Cooper S Coupe, JCW Coupe and Rolls-Royce Ghost, 2011 BMW X6 Hybrid and 2012 BMW 650i Coupe, 650i xDrive Coupe, 650i Convertible and 650i xDrive Convertible vehicles. The electric auxiliary water pump may fail and cause the circuit board to overheat.

Consequence & remedy

Consequence: If the circuit board were to overheat, it can increase the risk of a fire.

Remedy: BMW will notify owners, and dealers will replace the electric auxiliary water pump, free of charge. Depending on the model, there are currently limited parts available, however not all parts are available at this time. Owners will be notified of the recall beginning June 11, 2018, and will receive a second notification when remedy parts become available. Owners may contact BMW customer service at BMW 1-800-525-7417, MINI at 1-866-825-1525, or Rolls-Royce at 1-877-877-3735. Note: BMW recommends that owners park their vehicle outdoors until the recall remedy has been performed.

Additional source detail variants (2)

Engine And Engine Cooling:engine:gasoline:turbo/supercharger

Consequence: If the circuit board were to overheat, it can increase the risk of a fire.

Remedy: BMW will notify owners, and dealers will replace the electric auxiliary water pump, free of charge. Depending on the model, there are currently limited parts available, however not all parts are available at this time. Owners will be notified of the recall beginning June 11, 2018, and will receive a second notification when remedy parts become available. Owners may contact BMW customer service at BMW 1-800-525-7417, MINI at 1-866-825-1525, or Rolls-Royce at 1-877-877-3735. Note: BMW recommends that owners park their vehicle outdoors until the recall remedy has been performed.

Engine And Engine Cooling:engine

Consequence: If the circuit board were to overheat, it can increase the risk of a fire.

16V832000 · Air Bags:frontal:sensor/control MODULE-INACTIVE

Nov 17, 2016

BMW of North America, LLC (BMW) is recalling certain model year 2011 BMW 528i, 528xi, 535i, 535xi, 550i and 550xi vehicles manufactured March 1, 2010, through August 31, 2011. The affected vehicles may have received a replacement Sensor Cluster Unit (SCU) during a service visit. These SCUs have an acceleration sensor that may have been incorrectly programmed and, as a result, the SCU may not accurately determine if activation and deployment of the air bags, safety belt pre-tensioners and head restraints is necessary in the event of a crash.

Consequence & remedy

Consequence: Depending on the severity of the crash, inadequate activation of the driver and/or passenger air bags, safety belt pre-tensioners and active head restraints may increase the risk of injury.

Remedy: BMW will notify owners, and dealers will replace the SCU, free of charge. The recall began on December 16, 2016. Owners may contact BMW customer service at 1-800-525-7417.

16V746000 · Fuel System, Gasoline:delivery:fuel Pump

Oct 17, 2016

BMW of North America, LLC (BMW) is recalling certain model year 2007-2011 BMW X5 3.0si, X5 4.8i, X5 M, X5 xDrive30i, X5 xDrive35i, X5 xDrive48i and X5 xDrive50i, 2008-2011 X6 x Drive35i, X6 xDrive50i and X6 M, 2010-2011 X6 ActiveHybrid, 535i xDrive Gran Turismo, 535i Gran Turismo, 550i xDrive Gran Turismo and 550i Gran Turismo, 2011-2012 528i, 535i, 535i xDrive, 550i and 550i xDrive and 2012 535i ActiveHybrid, 640i Convertible, 650i Convertible, 650i xDrive Convertible, 650i Coupe and 650i Coupe xDrive vehicles. The affected vehicles have in-tank fuel pumps that may have insufficiently crimped wire contacts.

Consequence & remedy

Consequence: The loose wires may cause the connector to melt, resulting in a fuel leak. Additionally, the fuel pump may stop working, possibly causing an engine stall and increase the risk of a crash.

Remedy: BMW will notify owners, and dealers will replace the fuel pump module, free of charge. The recall began February 2017. Owners may contact BMW customer service at 1-800-525-7417.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

No exact-year investigations in this snapshot.