Electrical System. Review the 17 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Air Bags. Review the 13 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Engine. Review the 12 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

1 crash reports8 fire reports1 injury reports

Fuel System, Gasoline complaints

4 reports

Clear category filter

37,610 miles · Feb 6, 2011

Fuel System, Gasoline

FUEL LEAKS IN GARAGE AFTER FILLUP OF EMPTY TANK. OCCURRED AFTER TEMPERATURES BELOW 20 DEG F. *TR

NHTSA ODI #10380919

34,300 miles · Feb 6, 2011

Fuel System, Gasoline

GAS ODOR IN GARAGE; SEALS LEAKING ON THE FUEL TANK; SEALS REPLACED. *TR

NHTSA ODI #10380917

49,000 miles · Feb 2, 2011

Fuel System, Gasoline

Read full complaint

WHEN REFEULING ON LOW FUEL IN TEMPERATURES BELOW 15 DEG F THE TANK SEALS FAIL AND LEAK OR EMIT FUEL VAPORS AFTER FILLING TANK BETWEEN HALF WAY AND FULL. THIS HAS OCCURRED AND BEEN IN FOR SERVICE 5 TIMES ON THE SAME MODE OF FAILURE ALTHOUGH 1 WAS IN WARMER TEMPERATURES. THE ENTIRE TANK WAS REPLACED THE FIRST TIME, 2ND TIME THE FUEL PUMP, 3RD TIME NO ISSUE FOUND (HIGHER TEMP), 4TH TIME 2 SEALS REPLACED, 5TH TIME ONE SEAL REPLACED. GIVEN THE MODE OF FAILURE STRONGLY SUSPECT A PRESSURE EQUALIZATION PROBLEM IS OCCURING WITH WARMER 40-50 DEG F FUEL ENTERING THE COLDER TANK CAUSING SUBSEQUENT SEAL FAILURES. *TR

NHTSA ODI #10380032

2,501 miles · Sep 5, 2007

Fuel System, Gasoline

2008 BMW 535XI DIAGNOSED WITH DEFECTIVE FUEL PUMP. ENGINE MALFUNCTIONED AND POWER REDUCED TO HALF DURING OPERATION. ** PLEASE NOTE: ACTUAL VEHICLE IS A 2008 535XI SPORTS WAGON THE VEHICLE SECTION DOES NOT HAVE ACTUAL SELECTION AVAILABLE. *TR

NHTSA ODI #10201988

Official recalls

13V564000 · Air Bags:sensor:occupant Classification

Nov 12, 2013

BMW of North America LLC (BMW) is recalling certain model year 2006 325i, 325xi, 330i, 330xi sedans and 325xi sports wagons, model year 2007 328i, 328xi, 335i, 335xi sedans and 328i and 328xi sports wagons, model year 2006-2007 525i, 525xi, 530i, 530xi, 550i sedans and 530xi sports wagons, model year 2006 760i sedans, model year 2006-2007 750i, 750Li, and 760Li sedans, and model year 2006 X5 sports activity vehicles, equipped with certain seat types. The front passenger seat occupant detection mat that determines if and how the passenger frontal air bag should deploy in a crash may fatigue and develop cracks which could lead to a system failure.

Consequence & remedy

Consequence: Should the system fail, in the event of a crash, the front passenger air bag would be deactivated, increasing the risk of personal injury.

Remedy: BMW will notify owners with an interim notification letter in January 2014 since parts are not currently available. When parts are available, BMW sent a second letter in August and dealers will repair the occupant detection mat to eliminate the possibility that it may crack, free of charge. Additionally, owners of model year 2006-2007 3 Series with standard seats, 5 Series with comfort seats, and Z4 models, will receive an extended warranty on their front passenger seat occupant detection mat. Owners may contact BMW customer relations at 1-800-525-7417 or email BMW at CustomerRelations@bmwusa.com.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

No exact-year investigations in this snapshot.