I AM 70 YEARS OLD, DRIVING IN A HIGH TRAFFIC AREA AND MY VEHICLE STOPPED! I BROUGHT IT INTO THE DEALERSHIP AND WAS TOLD IT WAS A TIMING CHAIN ISSUE AND IT NEEDS TO BE REPLACED. THE REPAIR COST IS VERY EXPENSIVE. THERE WAS A LAWSUIT SETTLED ABOUT FAULY TIMING CHAINS IN 2021. MY VEHICLE IS NOT COVERED BY IT, NOT DUE TO MILEAGE B…
Read full complaint
I AM 70 YEARS OLD, DRIVING IN A HIGH TRAFFIC AREA AND MY VEHICLE STOPPED! I BROUGHT IT INTO THE DEALERSHIP AND WAS TOLD IT WAS A TIMING CHAIN ISSUE AND IT NEEDS TO BE REPLACED. THE REPAIR COST IS VERY EXPENSIVE. THERE WAS A LAWSUIT SETTLED ABOUT FAULY TIMING CHAINS IN 2021. MY VEHICLE IS NOT COVERED BY IT, NOT DUE TO MILEAGE BUT AGE. IT IS DANGEROUS FOR A CAR TO SUDDENLY STOP IN THE MIDDLE OF HEAVY TRAFFIC. I HAD TO CALL THE POLICE TO STAY BEHIND MY CAR WITH LIGHTS FLASHING SO IT WAS NOT HIT. LOUISIANA WAS UNDER AN EXTREME HEAT WARNING AT THIS TIME. THE CAR COULD NOT BE STARTED AND I HAD TO WAIT FOR A WREAKER, IN EXTREME HEAT. BMW DID NOT RECALL THESE VEHICLES NAMED IN THIS SUIT. NO ENGINE LIGHT CAME ON PRIOR TO THIS INCIDENT. I TRAVEL LONG DISTANCES TO LARGER CITIES FOR HEALTHCARE. I AM THANKFUL THIS DID NOT HAPPEN ON AN INTERSTATE WITH SIX LANES. IN MY OPINION, RECALLS SHOULD HAVE BEEN SENT OUT TO OWNERS. IT PUTS DRIVERS AT RISK IN AREAS OF HIGH TRAFFIC.
NHTSA ODI #11530219
Mileage unknown · Oct 2, 2022
Power TrainService BrakesUnknown Or Other
Upon purchasing the vehicle it was not serviced as supposed I have been calling only to be played around with this has been a nightmare I haven't made my 3rd payment and currently carless
NHTSA ODI #11487466
Mileage unknown · Jul 19, 2022
EnginePower TrainSteering
Error Codes : 1. E11480 No Message (Alive Counter Safety 0xD7) Receiver Instrument Cluster Transmitter Airbag 2. E11482 Message (Alive Counter Safety 0xD7) Not Current Receiver Instrument Cluster Transmitter Airbag 3. B7F685 Under Voltage . 4. E114DB Instrument Panel: Demand Based Service Message, Message From CBS Subscriber (B…
Read full complaint
Error Codes : 1. E11480 No Message (Alive Counter Safety 0xD7) Receiver Instrument Cluster Transmitter Airbag 2. E11482 Message (Alive Counter Safety 0xD7) Not Current Receiver Instrument Cluster Transmitter Airbag 3. B7F685 Under Voltage . 4. E114DB Instrument Panel: Demand Based Service Message, Message From CBS Subscriber (BBV) Missing 5. E114DC Instrument Panel: Demand Based Service Message, Message From CBS Subscriber (BBH) Missing 6. E11421 Message Demand Based Service Message From CBS User Has Failed DRIVETRAIN MALFUCTION when drive sport mode The Trunk always Open for no Reason when unlock the car.
NHTSA ODI #11474654
Mileage unknown · Dec 1, 2021
Power Train
The timing belt broke with no warning and destroyed the engine.
NHTSA ODI #11442312
90,000 miles · Dec 14, 2020
EnginePower Train
I CURRENTLY HAVE A 2013 528I BMW WITH LESS 90K MILES AND LESS THAN 8 YEARS OLD. I WAS DRIVING THE VEHICLE AND ALL OF A SUDDEN I RECEIVED A DRIVETRAIN MALFUNCTION THAT ABRUPTLY STOPPED THE CAR. I GOT TO FIND OUT THAT THE ENGINE WAS COMPLETELY DONE. I CALLED BMW TO SEE IF THERE WAS ANY RECALL ON THAT ISSUE, I ALSO FOUND OUT THAT M…
Read full complaint
I CURRENTLY HAVE A 2013 528I BMW WITH LESS 90K MILES AND LESS THAN 8 YEARS OLD. I WAS DRIVING THE VEHICLE AND ALL OF A SUDDEN I RECEIVED A DRIVETRAIN MALFUNCTION THAT ABRUPTLY STOPPED THE CAR. I GOT TO FIND OUT THAT THE ENGINE WAS COMPLETELY DONE. I CALLED BMW TO SEE IF THERE WAS ANY RECALL ON THAT ISSUE, I ALSO FOUND OUT THAT MANY BMW OWNERS HAVE HAD THE SAME ISSUE AND HAD TO GET THE ENGINE REPLACED. IF I WAS ON THE FREEWAY THIS WOULD HAVE BEEN A MAJOR TRAFFIC INCIDENT ACCIDENT,
NHTSA ODI #11383392
91,000 miles · Sep 18, 2020
EnginePower Train
WHILE DRIVING A MESSAGE OF DRIVETRAIN MALFUNCTION POPS UP ON THE IDRIVE SYSTEM. SPARK PLUGS HAVE BEEN CHANGED ALONG WITH REGULAR OIL CHANGES. HAPPENS OCCASIONALY THEN I SHUT THE CAR OFF AND LOCK THEN UNLOCK AND RESTART. SOMETIMES THE MESSAGE WILL POP BACK UP AND SOMETIMES IT DOES NOT.
NHTSA ODI #11359896
Mileage unknown · Oct 14, 2019
EnginePower Train
PRE MATURE TIMING CHAIN AND VANOS FAILURE.
NHTSA ODI #11268233
110,000 miles · Jun 29, 2019
EnginePower Train
HAD 100,000M WARRANTY. AROUND 110K NOTICE "ENGINE OIL PRESSURE" LIGHT FOR FIRST TIME. ADDED A BIT OF OIL AND LIGHT WENT AWAY. CAME ON AGAIN, TOOK IT INTO DEALER. THEY REPLACED AN OIL GASKET AND ANOTHER GASKET. LIGHT CAME BACK ON WITHIN 5 BLOCKS OF DEALER. THEY KEPT MY CAR FOR 3 WEEKS, SAID ENGINEERS AT HEADQUARTERS SAID I NEED …
Read full complaint
HAD 100,000M WARRANTY. AROUND 110K NOTICE "ENGINE OIL PRESSURE" LIGHT FOR FIRST TIME. ADDED A BIT OF OIL AND LIGHT WENT AWAY. CAME ON AGAIN, TOOK IT INTO DEALER. THEY REPLACED AN OIL GASKET AND ANOTHER GASKET. LIGHT CAME BACK ON WITHIN 5 BLOCKS OF DEALER. THEY KEPT MY CAR FOR 3 WEEKS, SAID ENGINEERS AT HEADQUARTERS SAID I NEED A NEW ENGINE. NOW, I DRIVE CARS UNTIL 260K MILES AND THEN SOMEONE ELSE DRIVES THEM AFTER ME. NEEDING A NEW ENGINE AT 110K MILES IS AWFUL. THEY WANT TO PUT IN A NEW 'SHORT ENGINE", CAM SHAFT POSITION SENSOR, CAM FOLLOWER,AND TURBOCHARGER. I'VE HAD MY OIL CHANGED AS OFTEN AS I SHOULD, NOW TELL ME, HOW IS THIS NEEDING ALL OF THAT MY FAULT?? I STILL OWE 2.5 YEARS ON CAR. THIS IS A LANDFILL PROBLEM RIGHT HERE AND NEEDS TO BE CORRECTED BY BMW.
NHTSA ODI #11228409
102,000 miles · May 13, 2019
EnginePower Train
ENGINE IMMEDIATELY LOST POWER ON HIGHWAY AT APPROXIMATELY 70 MPH WITH NO WARNING. THE CAR WENT INTO NEUTRAL STATING TO GET TO A SAFE AREA, WHICH I WAS ABLE TO DRIFT TO. ONCE THE CAR STOPPED IT SWITCHED TO PARK. I TRIED TO RESTART THE ENGINE BUT IT WOULD NOT TURN. BECAUSE THE ENGINE WAS NOT RUNNING YOU CAN NOT PUT THE CAR INTO NE…
Read full complaint
ENGINE IMMEDIATELY LOST POWER ON HIGHWAY AT APPROXIMATELY 70 MPH WITH NO WARNING. THE CAR WENT INTO NEUTRAL STATING TO GET TO A SAFE AREA, WHICH I WAS ABLE TO DRIFT TO. ONCE THE CAR STOPPED IT SWITCHED TO PARK. I TRIED TO RESTART THE ENGINE BUT IT WOULD NOT TURN. BECAUSE THE ENGINE WAS NOT RUNNING YOU CAN NOT PUT THE CAR INTO NEUTRAL. THIS CAUSED DIFFICULTY IN GETTING THE CAR TOWED FROM THE HIGHWAY SHOULDER. THE BMW N20 ENGINE HAS A KNOWN FLAW WITH THE OIL AND TIMING CHAIN. THE VEHICLE WAS TOWED TO A BMW SERVICE CENTER WHERE IT WAS CONFIRMED THAT THE ENGINE IS DAMAGED FROM THE CHAIN AND THE ENGINE WILL NEED TO BE REPLACED AT A VALUE OF $18,000. THE VEHICLE HAS 102,000 MILES ON IT. BMW NA STATES THAT THE CAN NOT ASSIST IN COST SINCE IT IS OUTSIDE OF THE WARRANTY PERIOD, ALTHOUGH THEY HAVE ALREADY EXTENDED THE WARRANTY FOR THIS FAULT ONCE. ALL MAINTENANCE HAD BEEN COMPLETED BASED ON THE SERVICE INTERVALS. THE CHAIN SERVICE CHECK IS NOT UNTIL 150,000 MILES. IT IS HARD TO BELIEVE THAT A ONCE REPUTABLE CAR MANUFACTURER WOULD LET THEIR CUSTOMERS STRANDED ON THE ROAD AND THEN AGAIN IN THE SERVICE CENTER WITH A REPAIR BILL WORTH MORE THAN THE VEHICLE ITSELF. I LOOK FORWARD TO THE RESOLUTION OF THE CURRENT CLASS ACTION LAWSUIT IN THIS MATTER AS MY CAR SITS UNUSABLE.
NHTSA ODI #11207240
118,000 miles · Jul 12, 2018
EnginePower Train
118,000 MILES HAD TO REPLACE BOTH FRONT DRIVE AXLES AND TURBO CHARGER. NO RECOURSE TO BMW ? MY LAST 2000 BMW 528 WENT 450,000 MILES AND NEVER HAD THESE PROBLEMS.
BMW of North America, LLC. (BMW) is recalling certain 2012-2015 X1 sDrive28i, X1 xDrive28i, 2012-2016 Z4 sDrive28i, 528i, 528i xDrive, 328i, 328xi, 2016-2018 X5 xdrive 40e, 2014-2016 228i, 228xi, 428i, 428i xDrive, 328xi Gran Turismo, 2013-2017 X3 sDrive28i, X3 xDrive28i, 2015-2018 X4 xDrive28i, 2015-2016 428xi vehicles. An improperly sealed electrical connector on the water pump may be exposed to water and short circuit.
Consequence & remedy
Consequence: An electrical short increases the risk of a fire.
Remedy: Dealers will inspect and replace the water pump and plug connector as necessary, and install a protective shield, free of charge. Owner notification letters were mailed on March 28, 2025. Owners may contact BMW customer service at 1-800-525-7417.
BMW of North America, LLC. (BMW) is recalling certain 2012-2015 X1 sDrive28i, X1 xDrive28i, 2012-2016 Z4 sDrive28i, 528i, 528i xDrive, 328i, 328xi, 2016-2018 X5 xdrive 40e, 2014-2016 228i, 228xi, 428i, 428i xDrive, 328xi Gran Turismo, 2013-2017 X3 sDrive28i, X3 xDrive28i, 2015-2018 X4 xDrive28i, 2015-2016 428xi vehicles. An improperly sealed electrical connector on the water pump may be exposed to water and short circuit.
Consequence: An electrical short increases the risk of a fire.
Remedy: Dealers will inspect and replace the water pump and plug connector as necessary, and install a protective shield, free of charge. Owner notification letters were mailed on March 28, 2025. Owners may contact BMW customer service at 1-800-525-7417.
Engine And Engine Cooling:cooling System:pump
BMW of North America, LLC. (BMW) is recalling certain 2012-2015 X1 sDrive28i, X1 xDrive28i, 2012-2016 Z4 sDrive28i, 528i, 528i xDrive, 328i, 328xi, 2016-2018 X5 xdrive 40e, 2014-2016 228i, 228xi, 428i, 428i xDrive, 328xi Gran Turismo, 2013-2017 X3 sDrive28i, X3 xDrive28i, 2015-2018 X4 xDrive28i, 2015-2016 428xi vehicles. An improperly sealed electrical connector on the water pump may be exposed to water and short circuit.
Consequence: An electrical short increases the risk of a fire.
Remedy: Dealers will inspect and replace the water pump and plug connector as necessary, and install a protective shield, free of charge. Owner notification letters were mailed on March 28, 2025. Owners may contact BMW customer service at 1-800-525-7417.
BMW of North America, LLC (BMW) is recalling certain model year 2013 528i, 528i xDrive, 535i, 535i xDrive, 550i, 550i xDrive, and ActiveHybrid 5 vehicles. The rear reflex reflectors may not reflect enough light. As such, the vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, "Lamps, Reflective Devices, and Associated Equipment."
Consequence & remedy
Consequence: The vehicle may be less visible to other vehicles, increasing the risk of a crash.
Remedy: BMW will notify owners, and dealers will replace the rear reflex reflectors, free of charge. The recall began July 28, 2017. Owners may contact BMW customer service at 1-800-525-7417.
BMW of North America LLC (BMW) is recalling certain model year 2014 BMW 328i xDrive Sports Wagon, 2012-2014 BMW 320i Sedan, 328i Sedan, 320i xDrive Sedan, 328i xDrive Sedan, 2012-2013 BMW 528i Sedan, 528i xDrive Sedan, 2013-2014 BMW X1 sDrive28i, X1 xDrive28i Sports Activity Vehicle, 2013-2014 BMW X3 xDrive28i Sports Activity Vehicle, 2012-2014 BMW Z4 sDrive28i Roadster, and 2014 BMW 428i Coupe, and 428i xDrive Coupe. Due to insufficient lubrication, the vacuum pump that supplies brake power assistance may fail. Note: This recall is an expansion of recall 13V-454.
Consequence & remedy
Consequence: A failure of the brake vacuum pump results in a reduction in braking power that could increase the risk of a crash.
Remedy: BMW will notify owners, and dealers will install a locking ring in the camshaft to retain the camshaft seal disk in the proper location, free of charge. The recall began on December 2, 2014. Owners may contact BMW customer service at 1-800-525-7417.
Additional source detail variants (2)
Service Brakes, Hydraulic:power Assist:vacuum:hoses, Lines/piping, And Fittings
BMW of North America LLC (BMW) is recalling certain model year 2014 BMW 328i xDrive Sports Wagon, 2012-2014 BMW 320i Sedan, 328i Sedan, 320i xDrive Sedan, 328i xDrive Sedan, 2012-2013 BMW 528i Sedan, 528i xDrive Sedan, 2013-2014 BMW X1 sDrive28i, X1 xDrive28i Sports Activity Vehicle, 2013-2014 BMW X3 xDrive28i Sports Activity Vehicle, 2012-2014 BMW Z4 sDrive28i Roadster, and 2014 BMW 428i Coupe, and 428i xDrive Coupe. Due to insufficient lubrication, the vacuum pump that supplies brake power assistance may fail. Note: This recall is an expansion of recall 13V-454.
Consequence: A failure of the brake vacuum pump results in a reduction in braking power that could increase the risk of a crash.
Remedy: BMW will notify owners, and dealers will install a locking ring in the camshaft to retain the camshaft seal disk in the proper location, free of charge. The recall began on December 2, 2014. Owners may contact BMW customer service at 1-800-525-7417.
Service Brakes, Hydraulic:power Assist:vacuum
BMW of North America LLC (BMW) is recalling certain model year 2014 BMW 328i xDrive Sports Wagon, 2012-2014 BMW 320i Sedan, 328i Sedan, 320i xDrive Sedan, 328i xDrive Sedan, 2012-2013 BMW 528i Sedan, 528i xDrive Sedan, 2013-2014 BMW X1 sDrive28i, X1 xDrive28i Sports Activity Vehicle, 2013-2014 BMW X3 xDrive28i Sports Activity Vehicle, 2012-2014 BMW Z4 sDrive28i Roadster, and 2014 BMW 428i Coupe, and 428i xDrive Coupe. Due to insufficient lubrication, the vacuum pump that supplies brake power assistance may fail. Note: This recall is an expansion of recall 13V-454.
Consequence: A failure of the brake vacuum pump results in a reduction in braking power that could increase the risk of a crash.
Remedy: BMW will notify owners, and dealers will install a locking ring in the camshaft to retain the camshaft seal disk in the proper location, free of charge. The recall began on December 2, 2014. Owners may contact BMW customer service at 1-800-525-7417.
BMW of North America LLC (BMW) is recalling certain model year 2012-2014 320i, 328i, 320i xDrive, and 328i xDrive sedans; model year 2014 328i xDrive Sports Wagons; model year 2012-2013 528i and 528i xDrive sedans, model year 2013-2014 X1 sDrive28i and X1 xDrive28i vehicles and model year 2012-2014 Z4 sDrive28i roadsters. Due to insufficient lubrication, the vacuum pump that supplies brake power assistance may fail.
Consequence & remedy
Consequence: A failure of the brake vacuum pump results in a reduction in braking power that could increase the risk of a crash.
Remedy: BMW will notify owners, and dealers will modify the vehicles to prevent insufficient vacuum pump lubrication, free of charge. The safety recall began on January 31, 2014. Owners may contact BMW customer relations at 1-800-525-7417 or email BMW at CustomerRelations@bmwusa.com.
Additional source detail variants (2)
Service Brakes, Hydraulic:power Assist:vacuum:hoses, Lines/piping, And Fittings
BMW of North America LLC (BMW) is recalling certain model year 2012-2014 320i, 328i, 320i xDrive, and 328i xDrive sedans; model year 2014 328i xDrive Sports Wagons; model year 2012-2013 528i and 528i xDrive sedans, model year 2013-2014 X1 sDrive28i and X1 xDrive28i vehicles and model year 2012-2014 Z4 sDrive28i roadsters. Due to insufficient lubrication, the vacuum pump that supplies brake power assistance may fail.
Consequence: A failure of the brake vacuum pump results in a reduction in braking power that could increase the risk of a crash.
Remedy: BMW will notify owners, and dealers will modify the vehicles to prevent insufficient vacuum pump lubrication, free of charge. The safety recall began on January 31, 2014. Owners may contact BMW customer relations at 1-800-525-7417 or email BMW at CustomerRelations@bmwusa.com.
Service Brakes, Hydraulic:power Assist:vacuum
BMW of North America LLC (BMW) is recalling certain model year 2012-2014 320i, 328i, 320i xDrive, and 328i xDrive sedans; model year 2014 328i xDrive Sports Wagons; model year 2012-2013 528i and 528i xDrive sedans, model year 2013-2014 X1 sDrive28i and X1 xDrive28i vehicles and model year 2012-2014 Z4 sDrive28i roadsters. Due to insufficient lubrication, the vacuum pump that supplies brake power assistance may fail.
Consequence: A failure of the brake vacuum pump results in a reduction in braking power that could increase the risk of a crash.
Remedy: BMW will notify owners, and dealers will modify the vehicles to prevent insufficient vacuum pump lubrication, free of charge. The safety recall began on January 31, 2014. Owners may contact BMW customer relations at 1-800-525-7417 or email BMW at CustomerRelations@bmwusa.com.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
PE13030 · Loss Of Power Assist Braking
Opened Sep 6, 2013 · Closed Oct 25, 2013
Status: closed (inferred from source dates) · Service Brakes, Hydraulic:power Assist:vacuum
In a letter dated September 26, 2013, BMW Group submitted a safety recall notice to NHTSA identifying a defect condition in the vacuum pump oil supply that may result in loss of power assist braking in 76,191 model year (MY) 2012 through 2014 BMW 3-Series, 5-Series, X1 SAV, X3 SAV, and Z4 vehicles equipped with 4-cylinder engines (NHTSA Recall 13V-454).According to BMW, movement of the seal disk within the camshaft may result in blocking of the oil supply to the vacuum pump, resulting in improper pump operation and loss of power assist braking.On July 11, 2013, BMW initiated a change to the camshaft geometry that prevented the seal disk from blocking the oil port.BMW has not received any braking complaints related to loss of power assist after the design change was implemented in production.The owners of all affected vehicles will be contacted by mail and asked to take their vehicle to a BMW dealer who will install a locking ring into the camshaft to keep the seal disk in its proper location.BMW expects to begin dealer and owner notification in November 2013 and complete dealer and owner notification in December when the remedy is expected to be available.Based on the actions taken by BMW, this investigation is closed.
2013 BMW 528I Problems, Complaints & Recalls | Skip That Year
Illustration