IllustrationWHEN THE BATTERY WAS CHANGED IN THE CAR, THE PASSENGER RESTRAINT SYSTEM FAILURE LIGHT CAME ON. THE VEHICLE WAS NOT IN MOTION, NOR HAS IT BEEN IN ANY KIND OF WRECK. AN AIRBAG LIGHT AND PASSENGER RESTRAINT LIGHT IS NOW ON. BMW SAYS IT IS NOT UNDER RECALL.
2005 BMW 525I
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all 525I years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
30–25K
225–50K
350–75K
775–100K
13100–150K
2150K+
30 reports with mileage · 5 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Air Bags. Review the 22 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Seat Belts. Review the 7 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Seats. Review the 6 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
0 crash reports4 fire reports1 injury reports
What owners actually said
35 reportsWHILE DRIVING WITH A PASSENGER, THE PASSENGER WARNING SENSOR ILLUMINATED. AN INDEPENDENT MECHANIC VERIFIED THAT THE SENSOR IS BAD. I CALLED BMW NORTH AMERICA CONCERNING THE VOLUNTARY RECALL CAMPAIGN #08V384000, BUT THEY SAID MY SPECIFIC VIN WAS NOT INCLUDED IN THIS RECALL THAT COVERED MY MODEL, MANUFACTURE DATE AND THIS SPECIF…
Read full complaint
WHILE DRIVING WITH A PASSENGER, THE PASSENGER WARNING SENSOR ILLUMINATED. AN INDEPENDENT MECHANIC VERIFIED THAT THE SENSOR IS BAD. I CALLED BMW NORTH AMERICA CONCERNING THE VOLUNTARY RECALL CAMPAIGN #08V384000, BUT THEY SAID MY SPECIFIC VIN WAS NOT INCLUDED IN THIS RECALL THAT COVERED MY MODEL, MANUFACTURE DATE AND THIS SPECIFIC ISSUE. THE CAR HAS NOT BEEN FIXED. FAILURE MILEAGE WAS AT 94,400 MILES.
I OWN A 2005 BMW 525I. WHILE DRIVING AT AN UNKNOWN SPEED, THE PASSENGER SIDE AIR BAG AND PASSENGER SIDE SEAT BELT WARNING LIGHTS ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, WHO DIAGNOSED THAT THE PASSENGER SIDE OCCUPANCY SEAT SENSOR NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTI…
Read full complaint
I OWN A 2005 BMW 525I. WHILE DRIVING AT AN UNKNOWN SPEED, THE PASSENGER SIDE AIR BAG AND PASSENGER SIDE SEAT BELT WARNING LIGHTS ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, WHO DIAGNOSED THAT THE PASSENGER SIDE OCCUPANCY SEAT SENSOR NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE WHICH SAID IT WAS NOT COVERED UNDER A RECALL. THE FAILURE MILEAGE WAS APPROXIMATELY 140,000.
ON APRIL 11, 2015. I WAS TAKING MY VEHICLE TO MY MECHANIC TO GET IT SERVICED AFTER SITTING ALL WINTER. AS I WAS DRIVING I NOTICED SMOKE COMING FROM THE REAR OF THE VEHICLE. I PULLED OVER, COULD NOT LOCATE THE SOURCE. I CONTINUED TO MY MECHANIC. ONCE THERE WE OPENED THE TRUNK, WE NOTICED AND SMELLED SOMETHING BURNING. WE TOOK OUT…
Read full complaint
ON APRIL 11, 2015. I WAS TAKING MY VEHICLE TO MY MECHANIC TO GET IT SERVICED AFTER SITTING ALL WINTER. AS I WAS DRIVING I NOTICED SMOKE COMING FROM THE REAR OF THE VEHICLE. I PULLED OVER, COULD NOT LOCATE THE SOURCE. I CONTINUED TO MY MECHANIC. ONCE THERE WE OPENED THE TRUNK, WE NOTICED AND SMELLED SOMETHING BURNING. WE TOOK OUT THE TIRE AND NOTICED WATER IN THE WHEEL WELL, WHICH MADE AN ELECTRICAL COMPONENT SPARKING, SMOKING AND ON FIRE. I HAD THE VEHICLE TOWED TO BMW. THEY STATED THE WATER DAMAGED THE MICRO POWER MODULE. BMW PAID FOR THE REPAIRS, AND RELOCATED THE MODULE AWAY FROM THE WHEEL WELL. I FEEL WHERE IT WAS PLACED PREVIOUS WAS VERY DANGEROUS. IF I HAD ANY COMBUSTIBLE ITEM IN MY TRUNK MY BMW WOULD HAVE FULLY CAUGHT FIRE. BMW SHOULD RECALL ALL VEHICLE AND RELOCATION ANY ELECTRICAL COMPONENTS THAT CAN BE DAMAGED BY WATER, POSSIBLY CATCH FIRE. THIS IS VERY DANGEROUS
TL* THE CONTACT OWNS A 2005 BMW 525I. WHILE DRIVING AT AN UNKNOWN SPEED, THE PASSENGER SIDE AIR BAG AND PASSENGER SIDE SEAT BELT WARNING LIGHTS ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, WHO DIAGNOSED THAT THE PASSENGER SIDE OCCUPANCY SEAT SENSOR NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFA…
Read full complaint
TL* THE CONTACT OWNS A 2005 BMW 525I. WHILE DRIVING AT AN UNKNOWN SPEED, THE PASSENGER SIDE AIR BAG AND PASSENGER SIDE SEAT BELT WARNING LIGHTS ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, WHO DIAGNOSED THAT THE PASSENGER SIDE OCCUPANCY SEAT SENSOR NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 86,000.
THE FIRST DAY I GOT MY BRAND NEW 2005 BMW 525I WAS IN DECEMBER OF 2004 AND I WAS DRIVING IT AND A EMERGENCY WARNING LIGHT CAME ON TELLING ME THAT SOMETHING WAS WRONG WITH THE TRANSMISSION, TO PULL OVER AND HAVE IT TOWED TO THE NEAREST BMW DEALERSHIP. I HAD TO GET MY BRAND NEW CAR TOWED BACK TO THE DEALERSHIP WHERE THEY REPLACED…
Read full complaint
THE FIRST DAY I GOT MY BRAND NEW 2005 BMW 525I WAS IN DECEMBER OF 2004 AND I WAS DRIVING IT AND A EMERGENCY WARNING LIGHT CAME ON TELLING ME THAT SOMETHING WAS WRONG WITH THE TRANSMISSION, TO PULL OVER AND HAVE IT TOWED TO THE NEAREST BMW DEALERSHIP. I HAD TO GET MY BRAND NEW CAR TOWED BACK TO THE DEALERSHIP WHERE THEY REPLACED THE TRANSMISSION. THIS WAS ONLY THE BEGINNING OF A CYCLE OF EVENTS THAT NEVER HAPPENED WITH MY HONDA ACCORD, MERCEDES, ACURA, BLAZER OR SATURN. MY SCREEN LIGHTS UP LIKE A CHRISTMAS TREE ALL THE TIME WITH ALL KINDS OF STRANGE WARNINGS THAT UNLESS YOU ARE AN ENGINEER MIGHT AS WELL BE IN SWAHILI. I HAVE HAD A PROBLEM WITH THE PASSENGER RESTRAINT SYSTEM FAILURE LIGHT STAYING ON AND NO ONE CAN FIGURE THAT ONE OUT. I HAVE HAD A FLAT TIRE LIGHT COME ON (IT'S ON RIGHT NOW) WHEN THERE IS NO FLAT TIRE. THE WOOD PANELING ON THE PASSENGER'S SIDE ABOVE THE GLOVE COMPARTMENT HAS 3 HUGE CRACKS THAT GO ALL THE WAY THROUGH IT. MY GLOVE COMPARTMENT WON'T OPEN BECAUSE THE HANDLE BROKE OFF. MY SUNROOF COVER FLIES BACK INTO THE BACK OF THE TOP OF THE CAR AND GETS LOST BACK THERE AND THERE IS NO WAY TO REACH IT. THE LIGHTER (WHICH I NEED FOR A CHARGER FOR MY PHONE) MALFUNCTIONS AND THE WOODEN PANEL COVER DISAPPEARED INTO THE INTERIOR COMPONENT OF THE CAR AS I WATCHED HELPLESS LEAVING A BIG UGLY GAPING HOLE. I AM SO CAREFUL WITH MY CAR AND CAN'T BELIEVE THIS IS WHAT I GOT FOR $50,000. THESE ARE PROBLEMS THAT A 1972 VOLVO MIGHT DEAL WITH BUT MY 2005 BMW? THE REPAIRS AND SERVICE ARE OUTLANDISHLY EXPENSIVE AND TO HAVE THESE PROBLEMS IS SIMPLY UNACCEPTABLE. THE FRONT DRIVER FLOOR MAT GETS STUCK UNDER THE PEDALS ALMOST MAKING ME WRECK! I'M EMBARRASSED WITH HOW MY BRAND NEW BMW HAS TURNED INTO A "GHETTO" RIDE. *TR
ACTIVE STEERING FAULT. *TR
TL* THE CONTACT OWNS A 2005 BMW 525I. THE CONTACT STATED THAT THE AIR BAG AND SEAT BELT WARNING LIGHTS REMAINED ILLUMINATED. THE DEALER STATED THAT THE SEAT MAT SENSOR NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED, BUT THE FAILURE RECURRED. THE VEHICLE WAS RETURNED TO THE DEALER WHO STATED THAT THE SEAT MAT SENSOR NEEDED TO B…
Read full complaint
TL* THE CONTACT OWNS A 2005 BMW 525I. THE CONTACT STATED THAT THE AIR BAG AND SEAT BELT WARNING LIGHTS REMAINED ILLUMINATED. THE DEALER STATED THAT THE SEAT MAT SENSOR NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED, BUT THE FAILURE RECURRED. THE VEHICLE WAS RETURNED TO THE DEALER WHO STATED THAT THE SEAT MAT SENSOR NEEDED TO BE REPLACED AGAIN. THE VEHICLE WAS NOT REPAIRED AND THE MANUFACTURER WAS NOTIFIED. THE VIN WAS UNAVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 15,000.
WARNING LIGHT APPEARED ON DASHBOARD ABOUT A PASSENGER RESTRAINT MALFUNCTION. THE SEATBELT SIGNAL AND AIRBAG SIGNAL REMAINED ILLUMINATED ON THE DASHBOARD. RECORDS SHOW THAT THE PASSENGER SEAT OCCUPANCY SENSOR WAS REPLACED AUG 21, 2007 AT FIRST OWNERS EXPENSE. THE LIGHT CAME BACK ON AFTER WE PURCHASED THE VEHICLE AND WERE TOLD …
Read full complaint
WARNING LIGHT APPEARED ON DASHBOARD ABOUT A PASSENGER RESTRAINT MALFUNCTION. THE SEATBELT SIGNAL AND AIRBAG SIGNAL REMAINED ILLUMINATED ON THE DASHBOARD. RECORDS SHOW THAT THE PASSENGER SEAT OCCUPANCY SENSOR WAS REPLACED AUG 21, 2007 AT FIRST OWNERS EXPENSE. THE LIGHT CAME BACK ON AFTER WE PURCHASED THE VEHICLE AND WERE TOLD THAT THERE HAS BEEN NO RECALL FOR OUR VIN #. THIS VEHICLE WAS MANUFACTURED DURING THE TIME SPAN OF THE RECALL THAT BMW ISSUED IN 2008 (WHICH HAPPENS TO BE AFTER THE OCCUPANCY SENSOR HAD BEEN REPLACED AT OWNERS EXPENSE). WHY IS THIS VEHICLE NOT INCLUDED IN THE RECALL? WHY IS THE REPLACEMENT OCCUPANCY SENSOR FAILING FOR A 2ND TIME? *TR
THE AIRBAG LIGHT AND SEATBELT LIGHT CAME ON AND REMAIN ON. AUTO SHOP REFERRED ME TO BMW TO HAVE RECALL ON PASSENGER MAT SENSOR ERROR. BMW DEALERSHIP TELLS ME THE RECALL HAD BEEN PERFORMED ON 7/3/2009, SO IT IS NOT COVERED AND I NEED TO PAY REPAIR PRICES. FROM MY UNDERSTANDING, PASSENGER AIRBAG WILL NOT WORK NOW. *JS
Official recalls
0No recalls in this snapshot.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA08001 · BMW Airbag Light Illumination
Opened Jan 4, 2008 · Closed Dec 31, 2008
Status: closed (inferred from source dates) · Air Bags; Air Bags:frontal; Air Bags:frontal:sensor/control MODULE-INACTIVE
BMW IS CONDUCTING A SAFETY RECALL CAMPAIGN ON APPROXIMATELY 200,000 MY04 THROUGH MY06 SUBJECT VEHICLES BUILT THROUGH 11/30/05 TO CORRECT THE FRONT PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT. THE SPECIFIC VEHICLES INCLUDED IN THE RECALL AREMY04- 06/ 5-SERIES WITH STANDARD AND SPORT SEATS, MY04-06/ X3-SERIES AND MY06/ 3-SERIES WITH SPORT SEATS. IN ADDITION, BMW WILL EXTEND THE WARRANTY COVERAGE OF THE PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT TO 10-YEAR/UNLIMITED MILEAGE ON APPROXIMATELY 120,000 REMAINING MY04-06 SUBJECT VEHICLES BUILT THROUGH 11/30/05. THE SPECIFIC VEHICLES INCLUDED IN THE EXTENDED WARRANTY ARE MY 06/ 6 SERIES, MY 06/ 3-SERIES WITH STANDARD SEATS, MY04-05/ Z4, MY04-06/ 7 SERIES, MY 06/ X5, AND MY04-06/ 5-SERIES WITH COMFORT SEATS.THE AVERAGE FREQUENCY OF FAILURES AMONG THE EXTENDED WARRANTY GROUPS WAS LESS THAN 1/7TH OF THE RECALL VEHICLE GROUPS.PLEASE SEE BMW'S 08V-384 RECALL NOTIFICATION FOR FURTHER DETAILSDEPENDING ON SEAT CONFIGURATION AND VEHICLE GEOMETRY, THE OCCUPANT DETECTION MAT CAN FATIGUE DURING USE DEPENDING ON THE MANNER AND FREQUENCY OF THE FRONT PASSENGER'S ENTRY AND EXIT.SPECIFICALLY, OVER TIME, MICRO-CRACKS COULD DEVELOP IN THE SIDE FLANKS OF THE MAT CAUSING A BROKEN CIRCUIT.A BROKENCIRCUIT CAN LEAD TO THE DEACTIVATION OF THE PASSENGER AIR BAG AND THE ILLUMINATION OF BOTH THE AIR BAG WARNING LIGHT AND THE PASSENGER AIR BAG LIGHT.
Additional source detail variants (3)
Air Bags
BMW IS CONDUCTING A SAFETY RECALL CAMPAIGN ON APPROXIMATELY 200,000 MY04 THROUGH MY06 SUBJECT VEHICLES BUILT THROUGH 11/30/05 TO CORRECT THE FRONT PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT. THE SPECIFIC VEHICLES INCLUDED IN THE RECALL AREMY04- 06/ 5-SERIES WITH STANDARD AND SPORT SEATS, MY04-06/ X3-SERIES AND MY06/ 3-SERIES WITH SPORT SEATS. IN ADDITION, BMW WILL EXTEND THE WARRANTY COVERAGE OF THE PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT TO 10-YEAR/UNLIMITED MILEAGE ON APPROXIMATELY 120,000 REMAINING MY04-06 SUBJECT VEHICLES BUILT THROUGH 11/30/05. THE SPECIFIC VEHICLES INCLUDED IN THE EXTENDED WARRANTY ARE MY 06/ 6 SERIES, MY 06/ 3-SERIES WITH STANDARD SEATS, MY04-05/ Z4, MY04-06/ 7 SERIES, MY 06/ X5, AND MY04-06/ 5-SERIES WITH COMFORT SEATS.THE AVERAGE FREQUENCY OF FAILURES AMONG THE EXTENDED WARRANTY GROUPS WAS LESS THAN 1/7TH OF THE RECALL VEHICLE GROUPS.PLEASE SEE BMW'S 08V-384 RECALL NOTIFICATION FOR FURTHER DETAILSDEPENDING ON SEAT CONFIGURATION AND VEHICLE GEOMETRY, THE OCCUPANT DETECTION MAT CAN FATIGUE DURING USE DEPENDING ON THE MANNER AND FREQUENCY OF THE FRONT PASSENGER'S ENTRY AND EXIT.SPECIFICALLY, OVER TIME, MICRO-CRACKS COULD DEVELOP IN THE SIDE FLANKS OF THE MAT CAUSING A BROKEN CIRCUIT.A BROKENCIRCUIT CAN LEAD TO THE DEACTIVATION OF THE PASSENGER AIR BAG AND THE ILLUMINATION OF BOTH THE AIR BAG WARNING LIGHT AND THE PASSENGER AIR BAG LIGHT.
Air Bags:frontal
BMW IS CONDUCTING A SAFETY RECALL CAMPAIGN ON APPROXIMATELY 200,000 MY04 THROUGH MY06 SUBJECT VEHICLES BUILT THROUGH 11/30/05 TO CORRECT THE FRONT PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT. THE SPECIFIC VEHICLES INCLUDED IN THE RECALL AREMY04- 06/ 5-SERIES WITH STANDARD AND SPORT SEATS, MY04-06/ X3-SERIES AND MY06/ 3-SERIES WITH SPORT SEATS. IN ADDITION, BMW WILL EXTEND THE WARRANTY COVERAGE OF THE PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT TO 10-YEAR/UNLIMITED MILEAGE ON APPROXIMATELY 120,000 REMAINING MY04-06 SUBJECT VEHICLES BUILT THROUGH 11/30/05. THE SPECIFIC VEHICLES INCLUDED IN THE EXTENDED WARRANTY ARE MY 06/ 6 SERIES, MY 06/ 3-SERIES WITH STANDARD SEATS, MY04-05/ Z4, MY04-06/ 7 SERIES, MY 06/ X5, AND MY04-06/ 5-SERIES WITH COMFORT SEATS.THE AVERAGE FREQUENCY OF FAILURES AMONG THE EXTENDED WARRANTY GROUPS WAS LESS THAN 1/7TH OF THE RECALL VEHICLE GROUPS.PLEASE SEE BMW'S 08V-384 RECALL NOTIFICATION FOR FURTHER DETAILSDEPENDING ON SEAT CONFIGURATION AND VEHICLE GEOMETRY, THE OCCUPANT DETECTION MAT CAN FATIGUE DURING USE DEPENDING ON THE MANNER AND FREQUENCY OF THE FRONT PASSENGER'S ENTRY AND EXIT.SPECIFICALLY, OVER TIME, MICRO-CRACKS COULD DEVELOP IN THE SIDE FLANKS OF THE MAT CAUSING A BROKEN CIRCUIT.A BROKENCIRCUIT CAN LEAD TO THE DEACTIVATION OF THE PASSENGER AIR BAG AND THE ILLUMINATION OF BOTH THE AIR BAG WARNING LIGHT AND THE PASSENGER AIR BAG LIGHT.
Air Bags:frontal:sensor/control MODULE-INACTIVE
BMW IS CONDUCTING A SAFETY RECALL CAMPAIGN ON APPROXIMATELY 200,000 MY04 THROUGH MY06 SUBJECT VEHICLES BUILT THROUGH 11/30/05 TO CORRECT THE FRONT PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT. THE SPECIFIC VEHICLES INCLUDED IN THE RECALL AREMY04- 06/ 5-SERIES WITH STANDARD AND SPORT SEATS, MY04-06/ X3-SERIES AND MY06/ 3-SERIES WITH SPORT SEATS. IN ADDITION, BMW WILL EXTEND THE WARRANTY COVERAGE OF THE PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT TO 10-YEAR/UNLIMITED MILEAGE ON APPROXIMATELY 120,000 REMAINING MY04-06 SUBJECT VEHICLES BUILT THROUGH 11/30/05. THE SPECIFIC VEHICLES INCLUDED IN THE EXTENDED WARRANTY ARE MY 06/ 6 SERIES, MY 06/ 3-SERIES WITH STANDARD SEATS, MY04-05/ Z4, MY04-06/ 7 SERIES, MY 06/ X5, AND MY04-06/ 5-SERIES WITH COMFORT SEATS.THE AVERAGE FREQUENCY OF FAILURES AMONG THE EXTENDED WARRANTY GROUPS WAS LESS THAN 1/7TH OF THE RECALL VEHICLE GROUPS.PLEASE SEE BMW'S 08V-384 RECALL NOTIFICATION FOR FURTHER DETAILSDEPENDING ON SEAT CONFIGURATION AND VEHICLE GEOMETRY, THE OCCUPANT DETECTION MAT CAN FATIGUE DURING USE DEPENDING ON THE MANNER AND FREQUENCY OF THE FRONT PASSENGER'S ENTRY AND EXIT.SPECIFICALLY, OVER TIME, MICRO-CRACKS COULD DEVELOP IN THE SIDE FLANKS OF THE MAT CAUSING A BROKEN CIRCUIT.A BROKENCIRCUIT CAN LEAD TO THE DEACTIVATION OF THE PASSENGER AIR BAG AND THE ILLUMINATION OF BOTH THE AIR BAG WARNING LIGHT AND THE PASSENGER AIR BAG LIGHT.
PE07045 · BMW Airbag Light Illumination
Opened Sep 4, 2007 · Closed Jan 4, 2008
Status: closed (inferred from source dates) · Air Bags; Air Bags:frontal; Air Bags:frontal:sensor/control MODULE-INACTIVE
IN CERTAIN MY 2005 THROUGH MY 2006 BMW VEHICLES, THE OCCUPANT CLASSIFICATION SYSTEM (OCS) FOR THE PASSENGER FRONTAL AIRBAG MAY MALFUNCTION AND RENDER THE PASSENGER AIRBAG INOPERATIVE.IN JUNE 2006, BMW ISSUED A TECHNICAL SERVICE BULLETIN (SI B 72 02 06) REGARDING THE ILLUMINATION OF THE AIRBAG WARNING LIGHT AND THE PASSENGER AIRBAG STATUS LAMP.ILLUMINATION OF THESE LIGHTS WARN THAT AN OPEN ELECTRICAL CIRCUIT MAY BE PRESENT WITHIN THE PASSENGER SEAT MAT SENSOR.WHEN BOTH OF THE LIGHTS ARE ILLUMINATED, THE PASSENGER FRONTAL AIR BAG WILL NOT DEPLOY IN A FRONTAL CRASH.CERTAIN BMW VEHICLES IN ADDITION TO THE SUBJECT VEHICLES CONTAIN THE SAME SEAT MAT SENSOR.THESE ARE THE MY 2004 5-SERIES, 7-SERIES AND X3, THE MY 2004 THROUGH 2006Z-4 SERIES AND MY 2006 3-SERIES, 6-SERIES AND X5 VEHICLES.AN IMPROVED SEAT MAT SENSOR WAS INTRODUCED IN DECEMBER 2005 FOR THE MID-MY 2006 PRODUCTION.IN RESPONSE TO ODI'S INFORMATION REQUEST LETTER, BMW PROVIDED 1,172 OWNER REPORTS AND 28,238 WARRANTY CLAIMS.INITIAL REVIEW OF THE DATA INDICATE THAT 280 NON-DUPLICATING OWNER REPORTS AND 13,051 NON-DUPLICATING WARRANTY CLAIMS MAY BE RELATED THE SUBJECT DEFECT ISSUE ON THE SUBJECT VEHICLESTHIS PRELIMINARY EVALUATION IS BEING UPGRADED TO AN ENGINEERING ANALYSIS (EA08-001).
Additional source detail variants (3)
Air Bags
IN CERTAIN MY 2005 THROUGH MY 2006 BMW VEHICLES, THE OCCUPANT CLASSIFICATION SYSTEM (OCS) FOR THE PASSENGER FRONTAL AIRBAG MAY MALFUNCTION AND RENDER THE PASSENGER AIRBAG INOPERATIVE.IN JUNE 2006, BMW ISSUED A TECHNICAL SERVICE BULLETIN (SI B 72 02 06) REGARDING THE ILLUMINATION OF THE AIRBAG WARNING LIGHT AND THE PASSENGER AIRBAG STATUS LAMP.ILLUMINATION OF THESE LIGHTS WARN THAT AN OPEN ELECTRICAL CIRCUIT MAY BE PRESENT WITHIN THE PASSENGER SEAT MAT SENSOR.WHEN BOTH OF THE LIGHTS ARE ILLUMINATED, THE PASSENGER FRONTAL AIR BAG WILL NOT DEPLOY IN A FRONTAL CRASH.CERTAIN BMW VEHICLES IN ADDITION TO THE SUBJECT VEHICLES CONTAIN THE SAME SEAT MAT SENSOR.THESE ARE THE MY 2004 5-SERIES, 7-SERIES AND X3, THE MY 2004 THROUGH 2006Z-4 SERIES AND MY 2006 3-SERIES, 6-SERIES AND X5 VEHICLES.AN IMPROVED SEAT MAT SENSOR WAS INTRODUCED IN DECEMBER 2005 FOR THE MID-MY 2006 PRODUCTION.IN RESPONSE TO ODI'S INFORMATION REQUEST LETTER, BMW PROVIDED 1,172 OWNER REPORTS AND 28,238 WARRANTY CLAIMS.INITIAL REVIEW OF THE DATA INDICATE THAT 280 NON-DUPLICATING OWNER REPORTS AND 13,051 NON-DUPLICATING WARRANTY CLAIMS MAY BE RELATED THE SUBJECT DEFECT ISSUE ON THE SUBJECT VEHICLESTHIS PRELIMINARY EVALUATION IS BEING UPGRADED TO AN ENGINEERING ANALYSIS (EA08-001).
Air Bags:frontal
IN CERTAIN MY 2005 THROUGH MY 2006 BMW VEHICLES, THE OCCUPANT CLASSIFICATION SYSTEM (OCS) FOR THE PASSENGER FRONTAL AIRBAG MAY MALFUNCTION AND RENDER THE PASSENGER AIRBAG INOPERATIVE.IN JUNE 2006, BMW ISSUED A TECHNICAL SERVICE BULLETIN (SI B 72 02 06) REGARDING THE ILLUMINATION OF THE AIRBAG WARNING LIGHT AND THE PASSENGER AIRBAG STATUS LAMP.ILLUMINATION OF THESE LIGHTS WARN THAT AN OPEN ELECTRICAL CIRCUIT MAY BE PRESENT WITHIN THE PASSENGER SEAT MAT SENSOR.WHEN BOTH OF THE LIGHTS ARE ILLUMINATED, THE PASSENGER FRONTAL AIR BAG WILL NOT DEPLOY IN A FRONTAL CRASH.CERTAIN BMW VEHICLES IN ADDITION TO THE SUBJECT VEHICLES CONTAIN THE SAME SEAT MAT SENSOR.THESE ARE THE MY 2004 5-SERIES, 7-SERIES AND X3, THE MY 2004 THROUGH 2006Z-4 SERIES AND MY 2006 3-SERIES, 6-SERIES AND X5 VEHICLES.AN IMPROVED SEAT MAT SENSOR WAS INTRODUCED IN DECEMBER 2005 FOR THE MID-MY 2006 PRODUCTION.IN RESPONSE TO ODI'S INFORMATION REQUEST LETTER, BMW PROVIDED 1,172 OWNER REPORTS AND 28,238 WARRANTY CLAIMS.INITIAL REVIEW OF THE DATA INDICATE THAT 280 NON-DUPLICATING OWNER REPORTS AND 13,051 NON-DUPLICATING WARRANTY CLAIMS MAY BE RELATED THE SUBJECT DEFECT ISSUE ON THE SUBJECT VEHICLESTHIS PRELIMINARY EVALUATION IS BEING UPGRADED TO AN ENGINEERING ANALYSIS (EA08-001).
Air Bags:frontal:sensor/control MODULE-INACTIVE
IN CERTAIN MY 2005 THROUGH MY 2006 BMW VEHICLES, THE OCCUPANT CLASSIFICATION SYSTEM (OCS) FOR THE PASSENGER FRONTAL AIRBAG MAY MALFUNCTION AND RENDER THE PASSENGER AIRBAG INOPERATIVE.IN JUNE 2006, BMW ISSUED A TECHNICAL SERVICE BULLETIN (SI B 72 02 06) REGARDING THE ILLUMINATION OF THE AIRBAG WARNING LIGHT AND THE PASSENGER AIRBAG STATUS LAMP.ILLUMINATION OF THESE LIGHTS WARN THAT AN OPEN ELECTRICAL CIRCUIT MAY BE PRESENT WITHIN THE PASSENGER SEAT MAT SENSOR.WHEN BOTH OF THE LIGHTS ARE ILLUMINATED, THE PASSENGER FRONTAL AIR BAG WILL NOT DEPLOY IN A FRONTAL CRASH.CERTAIN BMW VEHICLES IN ADDITION TO THE SUBJECT VEHICLES CONTAIN THE SAME SEAT MAT SENSOR.THESE ARE THE MY 2004 5-SERIES, 7-SERIES AND X3, THE MY 2004 THROUGH 2006Z-4 SERIES AND MY 2006 3-SERIES, 6-SERIES AND X5 VEHICLES.AN IMPROVED SEAT MAT SENSOR WAS INTRODUCED IN DECEMBER 2005 FOR THE MID-MY 2006 PRODUCTION.IN RESPONSE TO ODI'S INFORMATION REQUEST LETTER, BMW PROVIDED 1,172 OWNER REPORTS AND 28,238 WARRANTY CLAIMS.INITIAL REVIEW OF THE DATA INDICATE THAT 280 NON-DUPLICATING OWNER REPORTS AND 13,051 NON-DUPLICATING WARRANTY CLAIMS MAY BE RELATED THE SUBJECT DEFECT ISSUE ON THE SUBJECT VEHICLESTHIS PRELIMINARY EVALUATION IS BEING UPGRADED TO AN ENGINEERING ANALYSIS (EA08-001).