IllustrationThe car was off and caught fire due too electrical malfunctioning. The a/c unit was staying on even after cutting the car off . Along with my steering wheel randomly adjusting at start of the car . The fire started inside out .
2002 BMW 525I
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all 525I years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 18 of 28 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Air Bags. Review the 8 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 5 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Seats. Review the 5 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
0 crash reports2 fire reports1 injury reports
Electrical System complaints
5 reportsI AND NUMEROUS OTHERS HAVE HAD PROBLEMS WITH THE INSTRUMENT CLUSTER PIXEL ON THE BMW 525I VEHICLES, WHICH MAKES IT EXTREMELY DIFFICULT TO READ WHETHER YOU HAVE A ENGINE CONCERNS OR WORSE IF THE ENGINE IS OVERHEATING, ETC. THIS COULD BE POTENTIALLY HAZARDOUS AND THE MANUFACTURER IS WELL AWARE OF THE PROBLEM, AND THEY HAVE EVEN…
Read full complaint
I AND NUMEROUS OTHERS HAVE HAD PROBLEMS WITH THE INSTRUMENT CLUSTER PIXEL ON THE BMW 525I VEHICLES, WHICH MAKES IT EXTREMELY DIFFICULT TO READ WHETHER YOU HAVE A ENGINE CONCERNS OR WORSE IF THE ENGINE IS OVERHEATING, ETC. THIS COULD BE POTENTIALLY HAZARDOUS AND THE MANUFACTURER IS WELL AWARE OF THE PROBLEM, AND THEY HAVE EVEN REPAIRED A FEW BMWS AT NO CHARGE. HOWEVER, WHEN I NOTIFIED THE COMPANY OF MY COMPLAINT, THEY ADVISED ME THAT THEY WOULD COVER 25% OF THE PARTS AND LABOR, AND LEAVE ME TO PAY THE REMAINING $452.00. AS I MENTIONED EARLIER, THIS IS A HUGE PROBLEM AND THE VEHICLES SHOULD BE RECALLED. TO SEE ADDITIONAL COMPLAINTS FROM OTHER BMW OWNERS, PLEASE GO TO HTTP://FORUMS.BIMMERFORUMS.COM/FORUM/SHOWTHREAD.PHP?T=419695. *KB
THE BATTERY WARNING LIGHT FAILS TO ILLUMINATE WHEN THE CAR'S ALTERNATOR FAILS. AT IDLE A VOLTMETER READ 11.5V. WITH THE CAR OFF THE READING WAS 12.2V. EVEN IF MY METER IS INACCURATE A RUNNING CAR SHOULD PRODUCE A HIGHER READING THAN A BATTERY IN A NON-RUNNING CAR IF THE ALTERNATOR IS WORKING. I REMOVED THE BATTERY FROM THE C…
Read full complaint
THE BATTERY WARNING LIGHT FAILS TO ILLUMINATE WHEN THE CAR'S ALTERNATOR FAILS. AT IDLE A VOLTMETER READ 11.5V. WITH THE CAR OFF THE READING WAS 12.2V. EVEN IF MY METER IS INACCURATE A RUNNING CAR SHOULD PRODUCE A HIGHER READING THAN A BATTERY IN A NON-RUNNING CAR IF THE ALTERNATOR IS WORKING. I REMOVED THE BATTERY FROM THE CAR AND ATTACHED IT TO A "SMART" CHARGER. THE CHARGER STARTED OUT READING "LO." MY CHARGER READS "LO" WHEN THE CHARGE IS LESS THAN 50% OR SO, AND ABOVE THAT REPORTS ESTIMATED CHARGE IN INCREMENTS OF 10%. *TR
TL*THE CONTACT OWNS A 2002 BMW 525I. THE DRIVER'S SEAT CONTROLS MAKE A SQUEAKING NOISE WHEN MOVING THE SEAT. THE VEHICLE WAS TAKEN TO THE DEALER, BUT THE FAILURE WAS NOT REPAIRED. THE DEALER STATED THAT THERE WAS SOMETHING IN THE SEAT TRACK, WHICH CAUSED THE NOISE. WHEN THE CONTACT LOCKS THE VEHICLE, THE ALARM SOUNDS, BUT TH…
Read full complaint
TL*THE CONTACT OWNS A 2002 BMW 525I. THE DRIVER'S SEAT CONTROLS MAKE A SQUEAKING NOISE WHEN MOVING THE SEAT. THE VEHICLE WAS TAKEN TO THE DEALER, BUT THE FAILURE WAS NOT REPAIRED. THE DEALER STATED THAT THERE WAS SOMETHING IN THE SEAT TRACK, WHICH CAUSED THE NOISE. WHEN THE CONTACT LOCKS THE VEHICLE, THE ALARM SOUNDS, BUT THE HORN WOULD NOT. THE FAILURE CAUSED THE BATTERY TO FAIL WHEN THIS OCCURRED OVERNIGHT. THE VEHICLE WAS TAKEN TO THE DEALER AND THEY REPLACED THE SENSOR; HOWEVER, THE FAILURE PERSISTED. IN ADDITION, THE KEYS DO NOT LOCK OR UNLOCK THE DRIVER'S SIDE DOOR. THE CONTACT WAS INFORMED THAT HE NEEDED A NEW MODULE, WHICH HAS NOT YET ARRIVED. THE FAILURE MILEAGE WAS 48,000.
WHILE DRIVING AND WITHOUT WARNING THE CONSUMER HAD TO DRIVE A CERTAIN SPEED IN ORDER FOR THE AJAR INDICATOR LIGHT OR THE ALARM SOUND TO COME ON, TO LET THE CONSUMER KNOW THE DOOR OR TRUNK WAS OPEN. THERE WAS ALSO NO WARNING CHIME TO LET THE DRIVER KNOW THAT OCCUPANTS IN THE VEHICLE RELEASED THE SEAT BELTS. *AK AFTER THE VEHICL…
Read full complaint
WHILE DRIVING AND WITHOUT WARNING THE CONSUMER HAD TO DRIVE A CERTAIN SPEED IN ORDER FOR THE AJAR INDICATOR LIGHT OR THE ALARM SOUND TO COME ON, TO LET THE CONSUMER KNOW THE DOOR OR TRUNK WAS OPEN. THERE WAS ALSO NO WARNING CHIME TO LET THE DRIVER KNOW THAT OCCUPANTS IN THE VEHICLE RELEASED THE SEAT BELTS. *AK AFTER THE VEHICLE WAS PLACED IN DRIVE, IT WOULD TAKE ABOUT TWO VEHICLE LENGTHS BEFORE THE GONG SOUNDS, THE FUEL SENDING UNIT WAS INOPERATIVE AND CAUSED THE VEHICLE TO STALL, AT THE TIME THE VEHICLE SHOWED A HALF A TANK, THERE WAS A LOUD POPPING THAT HAD COME FROM THE CENTER OF THE VEHICLE, THE VEHICLE JUMPED BETWEEN GEAR(1ST TO 2ND GEAR AND WOULD JERK), THE REMOTE KEY WOULDN'T WORK, THE LEFT REAR SEAT BELT WOULD NOT EXTEND, THE VEHICLE WOULD CRANK BUT WOULDN'T START, THE VEHICLE ALARM WAS TOO SENSITIVE, AND THE RIGHT REAR DOOR'S FULL SHADE DID NOT RETRACT. *SCC THE FUSE IN THE GLOVE BOX WAS LOOSE. *JB
Official recalls
419V015000 · Air Bags:frontal:driver Side:inflator Module
Jan 14, 2019
BMW of North America, LLC (BMW) is recalling certain model year 2000-2003 525i Sedan, 530i Sedan, 540i Sedan, 2001-2003 525i Sports Wagon and 540i Sports Wagon vehicles, and 2000-2004 X5 SAV 3.0i, X5 SAV 4.4i, and X5 SAV 4.6is vehicles. This recall affects certain vehicles where the original steering wheel has been replaced with the optional sports steering wheel. The sports steering wheel has a frontal air bag inflator that may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Owners are advised not to drive their vehicles until the vehicle has been remedied. BMW will notify owners, and dealers will inspect the vehicle for an optional sports steering wheel with an affected inflator. Dealers will replace the air bag module as necessary, free of charge. The recall began March 14, 2019. Owners may contact BMW customer service at 1-800-525-7417.
15V318000 · Air Bags:frontal:driver Side:inflator Module
May 28, 2015
BMW of North America, LLC (BMW) is recalling certain model year 2002-2005 325i, 325xi, 330i, and 330xi Sedans, and 325xi and 325i Sportswagons, 2002-2006 330Ci, 325Ci, and M3 Convertibles and 325i, 330i, and M3 Coupes, 2002-2003 M5, 540i, 525i Sedan, and 530i Sedans, and 540i and 525i Sportswagons, and 2003 X5 3.0i and 4.4i Sports Activity Vehicles. Please note that the 5-series and X5 vehicles are only included if they are equipped with the optional sports steering wheel. The affected vehicles are equipped with a dual-stage driver frontal air bag that may be susceptible to moisture intrusion which, over time, could cause the inflator to rupture.
Consequence & remedy
Consequence: In the event of a crash necessitating deployment of the driver's frontal air bag, the inflator could rupture with metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Owners are advised not to drive their vehicles until the vehicle has been remedied. BMW will notify owners, and dealers will replace the front driver air bag module, free of charge. The recall began Aug 2016. Owners may contact BMW customer service at 1-800-525-7417. Note: This recall supersedes recall 14V-348 in its entirety. Additionally, vehicles that have had their driver side frontal air bag replaced previously as part of a recall remedy need to have their air bag replaced under this recall as well. Note: On December 17, 2015 BMW removed the model year 2004 X5 3.0i and 4.4i Sports Activity vehicle from this recall. Those vehicles were mistakenly identified as including the air bags that are subject to this recall.
02V057000 · Suspension
Feb 19, 2002
ON CERTAIN PASSENGER VEHICLES, DURING THE STRUT MOUNT MANUFACTURING PROCESS, THE THRUST BEARING WAS NOT PROPERLY POSITIONS AND SECURED. IF THE SUSPENSION IS FULLY UNLOADED, THE FRONT STRUT COULD SEPARATE FROM THE UPPER MOUNT.
Consequence & remedy
Consequence: THIS COULD AFFECT VEHICLE HANDLING AND CONTROL, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE BOTH FRONT SPRING STRUT UPPER MOUNTS. OWNER NOTIFICATION BEGAN MARCH 15, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BMW AT 1-800-831-1117.
01V352000 · Tires:sidewall
Nov 26, 2001
VEHICLE DESCRIPTION: DURING THE TIRE MOUNTING PROCESS ON CERTAIN PASSENGER VEHICLES BUILT WITH STANDARD (NON-SPORT) SUSPENSION AND EQUIPPED WITH CONTINENTAL CONTITOURINGCONTACT CH95 ECOPLUS TIRES, SIZE 225/65R16 95H, HAVING DOT CODES 4001, 4101, OR 4201, THE OUTER SIDEWALL SURFACE OF THE TIRES MAY HAVE BEEN CUT BY A SHARP EDGE. OPERATION OF THE VEHICLE OVER A LONG PERIOD OF TIME COULD LEAD TO A REDUCTION OF INFLATION PRESSURE.
Consequence & remedy
Consequence: CONTINUED DRIVING WITH LOW INFLATION PRESSURE IN THE TIRE COULD ULTIMATELY RESULT IN DAMAGE TO THE TIRE, AFFECT VEHICLE HANDLING AND CONTROL, AND COULD IN SOME CASES RESULT IN A VEHICLE CRASH.
Remedy: DEALERS WILL INSPECT ALL FIVE TIRES FOR A POSSIBLE CUT IN THE SIDEWALL, AND IF A CUT IS FOUND, THE TIRE WILL BE REPLACED. OWNER NOTIFICATION BEGAN DECEMBER 10, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BMW AT 1-800-831-1117.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0No exact-year investigations in this snapshot.