NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
85 reports13,859 miles · Aug 16, 2007
Electrical System
TL*THE CONTACT OWNS A 2006 BMW 525XI. WHILE DRIVING 60 MPH, THE LIGHTS ON THE DASHBOARD ILLUMINATED AND THE VEHICLE DECELERATED TO 10 MPH. THE VEHICLE WAS UNABLE TO DRIVE OVER 10 MPH. THE DEALER STATED THAT THERE WAS WATER ON THE PASSENGER FLOOR OF THE VEHICLE, WHICH DAMAGED ALL OF THE WIRING AND SENSORS. THE DEALER WAS UNAB…
Read full complaint
TL*THE CONTACT OWNS A 2006 BMW 525XI. WHILE DRIVING 60 MPH, THE LIGHTS ON THE DASHBOARD ILLUMINATED AND THE VEHICLE DECELERATED TO 10 MPH. THE VEHICLE WAS UNABLE TO DRIVE OVER 10 MPH. THE DEALER STATED THAT THERE WAS WATER ON THE PASSENGER FLOOR OF THE VEHICLE, WHICH DAMAGED ALL OF THE WIRING AND SENSORS. THE DEALER WAS UNABLE TO DETERMINE WHERE THE WATER ORIGINATED, BUT SUGGESTED THAT IT MAY HAVE ENTERED THROUGH AN OPEN WINDOW WHILE IT WAS RAINING. THE CURRENT AND FAILURE MILEAGES WERE 13,859.
NHTSA ODI #10199844
3,500 miles · Jan 27, 2007
Engine And Engine Cooling
SINCE PURCHASING THE VEHICLE (10/12/2005) THE VEHICLE ALERTS US THAT THE OIL LEVEL IS LOW - DO NOT CONTINUE TO OPERATE VEHICLE. THE CAR WAS SERVICED EACH TIME THE PROBLEM OCCURRED BY SOUTH BAY BMW. REPROGRAMMING, SENSORS AND OIL CONSUMPTION TESTS HAVE BEEN DONE; HOWEVER, WHATEVER REPAIRS ARE DONE, THE PROBLEM RECURS. *JB
NHTSA ODI #10180889
14,700 miles · Dec 14, 2006
Air BagsCrash
DT*: THE CONTACT STATED THE VEHICLE WAS INVOLVED IN A 2 MPH COLLISION, AND THE DRIVER AIR BAG DEPLOYED WITH VERY LOW PRESSURE, AS IF OOZING OUT. THERE WAS NO POLICE REPORT TAKEN AT THE SCENE. THE VEHICLE WAS TAKEN TO A PRIVATE REPAIR SHOP, WHERE THE MECHANIC WAS UNABLE TO DETERMINE THE CAUSE OF THE PROBLEM. THE MANUFACTURER W…
Read full complaint
DT*: THE CONTACT STATED THE VEHICLE WAS INVOLVED IN A 2 MPH COLLISION, AND THE DRIVER AIR BAG DEPLOYED WITH VERY LOW PRESSURE, AS IF OOZING OUT. THERE WAS NO POLICE REPORT TAKEN AT THE SCENE. THE VEHICLE WAS TAKEN TO A PRIVATE REPAIR SHOP, WHERE THE MECHANIC WAS UNABLE TO DETERMINE THE CAUSE OF THE PROBLEM. THE MANUFACTURER WAS ALSO NOTIFIED.
NHTSA ODI #10176161
25,000 miles · Dec 9, 2006
Air Bags
THE FRONT PASSENGER SIDE SEAT HAS A SENSOR THAT DISABLES THE AIR BAG IF AN ADULT IS NOT SITTING IN THE SEAT (BASED ON WEIGHT) SINCE IT HAS BEEN DETERMINED THAT AIRBAGS ARE DANGEROUS FOR CHILDREN. THE SENSOR IN MY CAR IS MALFUNCTIONING AND ALWAYS KEEPS THE AIR BAG DISABLED, EVEN IF AN ADULT IS IN THE SEAT. DEALER HAS ORDERED A …
Read full complaint
THE FRONT PASSENGER SIDE SEAT HAS A SENSOR THAT DISABLES THE AIR BAG IF AN ADULT IS NOT SITTING IN THE SEAT (BASED ON WEIGHT) SINCE IT HAS BEEN DETERMINED THAT AIRBAGS ARE DANGEROUS FOR CHILDREN. THE SENSOR IN MY CAR IS MALFUNCTIONING AND ALWAYS KEEPS THE AIR BAG DISABLED, EVEN IF AN ADULT IS IN THE SEAT. DEALER HAS ORDERED A REPLACEMENT PART. I'M DRIVING AROUND WITHOUT AIR BAG PROTECTION FOR THE PASSENGER SIDE SEAT. *NM
NHTSA ODI #10175644
4,000 miles · Nov 24, 2006
EquipmentInjury
DUE TO A CERTAIN DEFECT IN THE AIRCONDITIONING AIR DUCT, THE HUMIDITY BUILDS UP TO A HIGH LEVEL CAUSING EVENTUAL MOLD FORMATION IN THE AIR DUCT. AS A RESULT OF THAT A BAD SMELL WILL PROGRESSIVELY INCREASE UNTILL IT CAN BE EASILY NOTICABLE ESPECIALLY DURING THE FIRST MINUTE OF STARTING THE AIR CONDITIONNER. MOLDS ARE KNOWN TO BE …
Read full complaint
DUE TO A CERTAIN DEFECT IN THE AIRCONDITIONING AIR DUCT, THE HUMIDITY BUILDS UP TO A HIGH LEVEL CAUSING EVENTUAL MOLD FORMATION IN THE AIR DUCT. AS A RESULT OF THAT A BAD SMELL WILL PROGRESSIVELY INCREASE UNTILL IT CAN BE EASILY NOTICABLE ESPECIALLY DURING THE FIRST MINUTE OF STARTING THE AIR CONDITIONNER. MOLDS ARE KNOWN TO BE STRONG ALLERGENS AND CAN RESULT IN WORSENING NASAL ALLERGY SYMPTOMS, COUGH, NASAL CONGESTION, AND SNEEZING. I BELLEIVE IT IS A HEALTH HAZARD TO PEOPLE WITH MOLD ALLERGIES LIKE MY SON WHO HAD NOTICABLE WOSENING OF HIS NASAL CONGESTION AND EVENTUALLY HIS OBSTRUCTIVE SLEEP APNEA SYMPTOMS AS A RESULT OF THAT. UP ON CANTACTING THE LOCAL DEALER IN TEH AREA AND LATER THE BMW CUSTOMER SERVICE DEPARTMENT, THEY ACKNOWLEDGED THE PROBLEM SINCE I WAS NOT THE ONLY ONE WITH THE SAME COMPLAINT, BUT THEY ONLY OFFERED TO CLEAN THE DUCTS ONCE A YEAR, WHICH IS A SHORT TERM REMEDY AND DOES NOT PREVENT THE RECURRENCE OF THE PROBLEM. I BELEIVE IT IS A HAELTH RISK AND CUSTOMERS NEED TO BE INFORMED UPFRONT ABOUT THIS PROBLEM BEFORE THEY MAKE A SELECTION TO BUY THAT VEHICLE. *NM
NHTSA ODI #10174207
8,000 miles · Nov 17, 2006
Power TrainVehicle Speed Control
DT*: THE CONTACT STATED THE ENGINE HESITATED WHEN ACCELERATING FROM A STOP. THE HESITATION OF THE ENGINE LASTED BETWEEN 5 TO 10 SECONDS. THE VEHICLE WAS TAKEN TO THE SERVICE DEALER AND MANUFACTURER, WHO DID NOT FIND ANY PROBLEM WITH THE ENGINE. THE VEHICLE WAS NOT INVOLVED IN ANY ACCIDENTS.*AK WHEN PULLING OUT INTO TRAFFIC, …
Read full complaint
DT*: THE CONTACT STATED THE ENGINE HESITATED WHEN ACCELERATING FROM A STOP. THE HESITATION OF THE ENGINE LASTED BETWEEN 5 TO 10 SECONDS. THE VEHICLE WAS TAKEN TO THE SERVICE DEALER AND MANUFACTURER, WHO DID NOT FIND ANY PROBLEM WITH THE ENGINE. THE VEHICLE WAS NOT INVOLVED IN ANY ACCIDENTS.*AK WHEN PULLING OUT INTO TRAFFIC, THE VEHICLE HESITATED. THE CONSUEMER WAS TOLD THE VEHICLE IS UNDERPOWERED FOR ITS WEIGHT. UPDATED 12/18/06. *JB
NHTSA ODI #10173733
17,000 miles · Nov 13, 2006
Air BagsEquipmentSeat Belts
CAR STARTED BEEPING UNCONTROLLABLY THAN SERVICE LIGHT REPORTED A MALFUNCTION IN THE AIR PAGES AND SEAT BELT RESTRAINTS ON THE PASSENGER SIDE SEATS. DEALER DIAGNOSED PROBLEM AS DEFECTED SENSORS. HAD TO WAIT FOR PART THEN RETURN FOR ANOTHER SERVICE TRIP AND WAIT FOR COMPLIMENTARY CAR. ITS AMAZING WHEN YOUR IN A CAR SERVICE IS AN E…
Read full complaint
CAR STARTED BEEPING UNCONTROLLABLY THAN SERVICE LIGHT REPORTED A MALFUNCTION IN THE AIR PAGES AND SEAT BELT RESTRAINTS ON THE PASSENGER SIDE SEATS. DEALER DIAGNOSED PROBLEM AS DEFECTED SENSORS. HAD TO WAIT FOR PART THEN RETURN FOR ANOTHER SERVICE TRIP AND WAIT FOR COMPLIMENTARY CAR. ITS AMAZING WHEN YOUR IN A CAR SERVICE IS AN EMERGENCY THEY NEVER HAVE LOANER AVAILABLE. I DEPEND ON MY CAR, SO IT IS VERY DIFFICULT TO WAIT FOR SERVICE. AGAIN WITH NO EXPLANATION THEY ALSO HAD TO UPDATE COMPUTER NOW MANY NEW FUNCTION THAT WERE NOT WORKING ARE NOW FUNCTIONING LIKE THE BLUE TOOTH. SIDE LIGHTS THAT I DIDN'T EVEN KNOW WHERE THERE. *JB
NHTSA ODI #10173310
15,000 miles · Nov 13, 2006
Electrical SystemTires
AFTER NUMEROUS SERVICES FOR ELECTRONICALLY DEFECTIVE PROBLEMS, MY CARS COMPUTER SHUT DOWN. JUST SHUT DOWN. SINCE THE COMPUTER CONTROLS ALL FUNCTION I WAS LEFT WITH NO CONTROL OVER MY CAR. I WAS LEFT WITH NO GPS, NO CLIMATE CONTROL, NO ENTERTAINMENT CONTROL, AND IN ORDER IN HAVE THE CAR SERVICES WITH A COMPLIMENTARY VEHICLE IT HA…
Read full complaint
AFTER NUMEROUS SERVICES FOR ELECTRONICALLY DEFECTIVE PROBLEMS, MY CARS COMPUTER SHUT DOWN. JUST SHUT DOWN. SINCE THE COMPUTER CONTROLS ALL FUNCTION I WAS LEFT WITH NO CONTROL OVER MY CAR. I WAS LEFT WITH NO GPS, NO CLIMATE CONTROL, NO ENTERTAINMENT CONTROL, AND IN ORDER IN HAVE THE CAR SERVICES WITH A COMPLIMENTARY VEHICLE IT HAD TO MAKE WEEKS TO BE SERVICED. EVEN THOUGH I WAS SOLD ON THE FACT THAT THE COMPANY WILL BE PICK UP THE CAR, HOW YOU DO WAIT. THE CAR HAD TO BE SERVICED TWO TIMES AND BECAME A HUGE IN CONVINCE. *JB
NHTSA ODI #10173309
3,000 miles · Nov 13, 2006
Electrical System
I PURCHASED CAR IN MAY 2005 AND WITHIN 4 WEEKS MY CAR LIGHTS AND SIGNAL WOULD JUST FLASH OUT OF CONTROL. THE CAR WOULD THEN BEEP ALL THE TIME. THE DEALER SAID THEY DON'T KNOW WHY. THEN THE COMPUTER LOCKED MY CAR. AFTER WAITED ALMOST 2 HOURS FOR ROADSIDE THE DEALER CAME TO BRING ME TO A RENTAL CAR DEALERSHIP. THE CAR WAS TOWED AN…
Read full complaint
I PURCHASED CAR IN MAY 2005 AND WITHIN 4 WEEKS MY CAR LIGHTS AND SIGNAL WOULD JUST FLASH OUT OF CONTROL. THE CAR WOULD THEN BEEP ALL THE TIME. THE DEALER SAID THEY DON'T KNOW WHY. THEN THE COMPUTER LOCKED MY CAR. AFTER WAITED ALMOST 2 HOURS FOR ROADSIDE THE DEALER CAME TO BRING ME TO A RENTAL CAR DEALERSHIP. THE CAR WAS TOWED AND THEN THE CAR WAS RE KEYED. THE COMPUTER WAS UPDATED AND ALL ELECTRONICALLY DEFECTS WORKED BETTER THEN DELIVERY. *JB
NHTSA ODI #10173308
Mileage unknown · Oct 18, 2006
Exterior Lighting
THE TAILLIGHTS OF BMWS (MADE IN ABOUT THE LAST THREE YEARS), SOME LEXUS (STARTING ABOUT TWO YEARS AGO) AND SOME CADILLACS (STARTING ABOUT A YEAR AGO) USE LEDS THAT ARE MODULATED ON AND OFF. THESE CAN BECOME A DISTRACTION AT NIGHT WHEN MOVING ONE'S EYES QUICKLY FROM SIDE TO SIDE. IT CAN GIVE THE ILLUSION THAT THERE ARE MORE CA…
Read full complaint
THE TAILLIGHTS OF BMWS (MADE IN ABOUT THE LAST THREE YEARS), SOME LEXUS (STARTING ABOUT TWO YEARS AGO) AND SOME CADILLACS (STARTING ABOUT A YEAR AGO) USE LEDS THAT ARE MODULATED ON AND OFF. THESE CAN BECOME A DISTRACTION AT NIGHT WHEN MOVING ONE'S EYES QUICKLY FROM SIDE TO SIDE. IT CAN GIVE THE ILLUSION THAT THERE ARE MORE CARS ON THE HIGHWAY THAN THERE ARE.
NHTSA ODI #10171166
Official recalls
7Mar 2, 2022
BMW of North America, LLC (BMW) is recalling certain 2008-2013 1 Series Coupe (128i); 2007-2013 3 Series Coupe (328i, 328xi, 328i xDrive); 2007-2010 X3 SAV (X3 3.0si, X3 xDrive30i); 2008-2013 1 Series Convertible (128i); 2006-2011 3 Series Sedan (325i, 325xi, 328i, 328xi, 328i xDrive, 330i, 330xi); 2006-2012 3 Series Wagon (328i, 328i xDrive); 2007-2013 3 Series Convertible (328i); 2006-2010 5 Series Sedan (525i, 525xi, 528i, 528xi, 530i, 530xi); 2006-2007 5 Series Wagon (530xi); 2007-2010 X5 SAV (X5 3.0si, X5 xDrive30i); 2006-2008 Z4 Coupe (Z4 3.0si); and 2006-2011 Z4 Roadster (Z4 3.0i, Z4 3.0si, Z4 sDrive30i) vehicles. The heater for the positive crankcase ventilation (PCV) valve may short circuit.
Consequence & remedy
Consequence: An electrical short can cause the PCV valve heater to overheat, increasing the risk of a fire while driving or, soon after driving when parked.
Remedy: This recall supersedes and expands previous NHTSA recalls 17V-683 and 19V-273. Dealers will install an electrical wiring harness with fuse protection for the PCV Valve heater in potentially affected vehicles, free of charge. This recall supersedes and expands previous NHTSA recalls 17V-683 and 19V-273. Vehicles previously repaired under the prior recalls will need to come back for the new recall remedy. The remedy is currently being developed. Interim owner notification letters informing owners of the safety risk were mailed on April 1, 2022. Owner notification letters were mailed on July 22, 2022. Owners may contact BMW customer service at 1-800-525-7417.
Mar 26, 2012
BMW IS RECALLING CERTAIN MODEL YEAR 2004-2010 5-SERIES, MODEL YEAR 2004-2010 6-SERIES, MODEL YEAR 2006-2010 M5, AND MODEL YEAR 2007-2010 M6 VEHICLES. THE INSULATED BULKHEAD CONNECTOR FOR THE POSITIVE BATTERY CABLE MAY HAVE BEEN INCORRECTLY ATTACHED TO THE TRUNK FLOOR PANEL, WHICH CAN LEAD TO A LOOSENING OF THE BOLT CONNECTION. AS IT LOOSENS, AN INCREASE IN ELECTRICAL RESISTANCE AT THIS CABLE CONNECTION IS POSSIBLE AND COULD CAUSE THE CABLE CONNECTION TO OVERHEAT.
Consequence & remedy
Consequence: OVERHEATING COULD LEAD TO A FIRE, EVEN WHILE THE VEHICLE IS NOT IN USE. AS A PRECAUTION, OWNERS ARE ADVISED TO PARK OUTSIDE UNTIL THE REMEDY HAS BEEN MADE.
Remedy: BMW WILL NOTIFY OWNERS, AND DEALERS WILL INSPECT AND SECURE THE BATTERY BOLT CABLE CONNECTION AS NECESSARY, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON APRIL 30, 2012. OWNERS MAY CONTACT BMW CUSTOMER RELATIONS AND SERVICES AT 1-800-525-7417.
Oct 1, 2010
BMW IS RECALLING CERTAIN MODEL YEAR 2004-2010 5-SERIES, 6-SERIES, AND MODEL YEAR 2002-2008 7-SERIES VEHICLES. A CHECK VALVE OF THE BRAKE VACUUM PUMP MAY LEAK A SMALL AMOUNT OF LUBRICATING OIL. OVER TIME THIS COULD RESULT IN CONTAMINATION OF THE BRAKE BOOSTER.
Consequence & remedy
Consequence: POWER ASSIST BRAKING PERFORMANCE COULD BE ADVERSELY AFFECTED. IN EXTREME CASES THERE COULD BE A COMPLETE LOSS OF POWER ASSIST BRAKING. AN UNEXPECTED REDUCTION OR LOSS IN POWER BRAKING ASSIST MAY INCREASE THE RISK OF A CRASH.
Remedy: BMW WILL NOTIFY OWNERS AND DEALERS WILL REPAIR THE VEHICLES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON NOVEMBER 24, 2010. OWNERS MAY CONTACT BMW AT 1-800-525-7417.
Aug 5, 2008
BMW IS RECALLING 200,000 MY 2006 3 SERIES SPORT SEAT, MY 2004-2006 5 SERIES STANDARD AND SPORT SEAT, AND MY 2004-2006 X3 PASSENGER VEHICLES. DEPENDING ON THE MANNER AND FREQUENCY OF THE FRONT PASSENGER'S ENTRY AND EXIT, SMALL CRACKS HAVE DEVELOPED IN THE MAT. IF THIS OCCURS, THE FRONT PASSENGER AIR BAGS, WITH THE EXCEPTION OF THE HEAD PROTECTION SYSTEM, WILL BE DEACTIVATED AND THE AIR BAG WARNING LAMP AS WELL AS THE PASSENGER AIR BAG "ON-OFF" LAMP WILL BE ILLUMINATED.
Consequence & remedy
Consequence: IN THIS SITUATION THE FRONT PASSENGER AIR BAGS WILL NOT DEPLOY EVEN IF A SUFFICIENTLY SEVERE ACCIDENT WOULD OCCUR AND OCCUPANT PROTECTION PROVIDED BY THE SYSTEM WOULD NOT BE POSSIBLE.
Remedy: DEALERS WILL REWORK THE FRONT PASSENGER SEAT SENSOR MAT SO THAT EXTERNAL FORCE APPLICATION TO THE SEAT DOES NOT CAUSE A CRACK TO THE MAT. THE RECALL BEGAN ON NOVEMBER 6, 2008. BMW WILL ALSO EXTEND THE WARRANTY ON THESE VEHICLES TO 10 YEARS FROM FIRST REGISTRATION WITHOUT ANY MILEAGE LIMIT. OWNERS MAY CONTACT BMW AT 1-800-525-7417.
Jul 26, 2006
ON CERTAIN PASSENGER VEHICLES, THE LOWER RUBBER MOUNT OF THE REAR SHOCK ABSORBERS MAY NOT HAVE BEEN MANUFACTURED TO SPECIFICATIONS AND MAY NOT ADHERE CORRECTLY TO ITS HOUSING WITHIN THE SHOCK ABSORBER.
Consequence & remedy
Consequence: THE BUSHING COULD LOOSEN AND OVER TIME COULD SEPARATE FROM ITS HOUSING. THE DRIVER WILL EXPERIENCE IMPAIRED VEHICLE HANDLING AND CONTROL INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE REAR SHOCK ABSORBER FREE OF CHARGE. THE RECALL BEGAN ON SEPTEMBER 13, 2006. OWNERS MAY CONTACT BMW AT 1-800-831-1117.
May 30, 2006
ON CERTAIN PASSENGER VEHICLES, THE NUTS WHICH SECURE THE FRONT AXLE CONTROL ARM AND TENSION STRUT TO THE FRONT WHEEL HUB MAY NOT HAVE BEEN TIGHTENED TO SPECIFICATION. OVER TIME THE NUTS COULD LOOSEN AND THE CONTROL ARM AND TENSION STRUT COULD BE DAMAGED.
Consequence & remedy
Consequence: VEHICLE HANDLING AND CONTROL COULD COMPROMISE INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL RETIGHTEN THE FRONT AXLE CONTROL ARM AND TENSION STRUT NUTS TO THE CORRECT SPECIFICATIONS FREE OF CHARGE. THE RECALL BEGAN ON JUNE 28, 2006. OWNERS MAY CONTACT BMW AT 1-800-831-1117.
Nov 1, 2005
CERTAIN PASSENGER VEHICLES MAY HAVE BEEN BUILT WITH AN INCORRECTLY MANUFACTURED AUTOMATIC TRANSMISSION PARKING PAWL GUIDE PLATE.
Consequence & remedy
Consequence: THIS COULD CAUSE THE PARKING LOCK SYSTEM NOT TO ENGAGE, AFTER THE TRANSMISSION IS PLACED IN THE PARK ("P") POSITION. IF THE VEHICLE WAS PARKED ON AN INCLINE, AND THE PARKING BRAKE WAS NOT ENGAGED, THIS COULD RESULT IN A VEHICLE ROLLAWAY CONDITION.
Remedy: DEALERS WILL REPAIR AND REPLACE THE AUTOMATIC TRANSMISSION GUIDE PLATE FREE OF CHARGE. THE RECALL BEGAN ON NOVEMBER 30, 2005. OWNERS MAY CONTACT BMW AT 1-800-332-4269.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA08001 · BMW Airbag Light Illumination
Opened Jan 4, 2008 · Closed Dec 31, 2008
Status: closed (inferred from source dates) · Air Bags; Air Bags:frontal; Air Bags:frontal:sensor/control MODULE-INACTIVE
BMW IS CONDUCTING A SAFETY RECALL CAMPAIGN ON APPROXIMATELY 200,000 MY04 THROUGH MY06 SUBJECT VEHICLES BUILT THROUGH 11/30/05 TO CORRECT THE FRONT PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT. THE SPECIFIC VEHICLES INCLUDED IN THE RECALL AREMY04- 06/ 5-SERIES WITH STANDARD AND SPORT SEATS, MY04-06/ X3-SERIES AND MY06/ 3-SERIES WITH SPORT SEATS. IN ADDITION, BMW WILL EXTEND THE WARRANTY COVERAGE OF THE PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT TO 10-YEAR/UNLIMITED MILEAGE ON APPROXIMATELY 120,000 REMAINING MY04-06 SUBJECT VEHICLES BUILT THROUGH 11/30/05. THE SPECIFIC VEHICLES INCLUDED IN THE EXTENDED WARRANTY ARE MY 06/ 6 SERIES, MY 06/ 3-SERIES WITH STANDARD SEATS, MY04-05/ Z4, MY04-06/ 7 SERIES, MY 06/ X5, AND MY04-06/ 5-SERIES WITH COMFORT SEATS.THE AVERAGE FREQUENCY OF FAILURES AMONG THE EXTENDED WARRANTY GROUPS WAS LESS THAN 1/7TH OF THE RECALL VEHICLE GROUPS.PLEASE SEE BMW'S 08V-384 RECALL NOTIFICATION FOR FURTHER DETAILSDEPENDING ON SEAT CONFIGURATION AND VEHICLE GEOMETRY, THE OCCUPANT DETECTION MAT CAN FATIGUE DURING USE DEPENDING ON THE MANNER AND FREQUENCY OF THE FRONT PASSENGER'S ENTRY AND EXIT.SPECIFICALLY, OVER TIME, MICRO-CRACKS COULD DEVELOP IN THE SIDE FLANKS OF THE MAT CAUSING A BROKEN CIRCUIT.A BROKENCIRCUIT CAN LEAD TO THE DEACTIVATION OF THE PASSENGER AIR BAG AND THE ILLUMINATION OF BOTH THE AIR BAG WARNING LIGHT AND THE PASSENGER AIR BAG LIGHT.
Additional source detail variants (3)
Air Bags
BMW IS CONDUCTING A SAFETY RECALL CAMPAIGN ON APPROXIMATELY 200,000 MY04 THROUGH MY06 SUBJECT VEHICLES BUILT THROUGH 11/30/05 TO CORRECT THE FRONT PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT. THE SPECIFIC VEHICLES INCLUDED IN THE RECALL AREMY04- 06/ 5-SERIES WITH STANDARD AND SPORT SEATS, MY04-06/ X3-SERIES AND MY06/ 3-SERIES WITH SPORT SEATS. IN ADDITION, BMW WILL EXTEND THE WARRANTY COVERAGE OF THE PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT TO 10-YEAR/UNLIMITED MILEAGE ON APPROXIMATELY 120,000 REMAINING MY04-06 SUBJECT VEHICLES BUILT THROUGH 11/30/05. THE SPECIFIC VEHICLES INCLUDED IN THE EXTENDED WARRANTY ARE MY 06/ 6 SERIES, MY 06/ 3-SERIES WITH STANDARD SEATS, MY04-05/ Z4, MY04-06/ 7 SERIES, MY 06/ X5, AND MY04-06/ 5-SERIES WITH COMFORT SEATS.THE AVERAGE FREQUENCY OF FAILURES AMONG THE EXTENDED WARRANTY GROUPS WAS LESS THAN 1/7TH OF THE RECALL VEHICLE GROUPS.PLEASE SEE BMW'S 08V-384 RECALL NOTIFICATION FOR FURTHER DETAILSDEPENDING ON SEAT CONFIGURATION AND VEHICLE GEOMETRY, THE OCCUPANT DETECTION MAT CAN FATIGUE DURING USE DEPENDING ON THE MANNER AND FREQUENCY OF THE FRONT PASSENGER'S ENTRY AND EXIT.SPECIFICALLY, OVER TIME, MICRO-CRACKS COULD DEVELOP IN THE SIDE FLANKS OF THE MAT CAUSING A BROKEN CIRCUIT.A BROKENCIRCUIT CAN LEAD TO THE DEACTIVATION OF THE PASSENGER AIR BAG AND THE ILLUMINATION OF BOTH THE AIR BAG WARNING LIGHT AND THE PASSENGER AIR BAG LIGHT.
Air Bags:frontal
BMW IS CONDUCTING A SAFETY RECALL CAMPAIGN ON APPROXIMATELY 200,000 MY04 THROUGH MY06 SUBJECT VEHICLES BUILT THROUGH 11/30/05 TO CORRECT THE FRONT PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT. THE SPECIFIC VEHICLES INCLUDED IN THE RECALL AREMY04- 06/ 5-SERIES WITH STANDARD AND SPORT SEATS, MY04-06/ X3-SERIES AND MY06/ 3-SERIES WITH SPORT SEATS. IN ADDITION, BMW WILL EXTEND THE WARRANTY COVERAGE OF THE PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT TO 10-YEAR/UNLIMITED MILEAGE ON APPROXIMATELY 120,000 REMAINING MY04-06 SUBJECT VEHICLES BUILT THROUGH 11/30/05. THE SPECIFIC VEHICLES INCLUDED IN THE EXTENDED WARRANTY ARE MY 06/ 6 SERIES, MY 06/ 3-SERIES WITH STANDARD SEATS, MY04-05/ Z4, MY04-06/ 7 SERIES, MY 06/ X5, AND MY04-06/ 5-SERIES WITH COMFORT SEATS.THE AVERAGE FREQUENCY OF FAILURES AMONG THE EXTENDED WARRANTY GROUPS WAS LESS THAN 1/7TH OF THE RECALL VEHICLE GROUPS.PLEASE SEE BMW'S 08V-384 RECALL NOTIFICATION FOR FURTHER DETAILSDEPENDING ON SEAT CONFIGURATION AND VEHICLE GEOMETRY, THE OCCUPANT DETECTION MAT CAN FATIGUE DURING USE DEPENDING ON THE MANNER AND FREQUENCY OF THE FRONT PASSENGER'S ENTRY AND EXIT.SPECIFICALLY, OVER TIME, MICRO-CRACKS COULD DEVELOP IN THE SIDE FLANKS OF THE MAT CAUSING A BROKEN CIRCUIT.A BROKENCIRCUIT CAN LEAD TO THE DEACTIVATION OF THE PASSENGER AIR BAG AND THE ILLUMINATION OF BOTH THE AIR BAG WARNING LIGHT AND THE PASSENGER AIR BAG LIGHT.
Air Bags:frontal:sensor/control MODULE-INACTIVE
BMW IS CONDUCTING A SAFETY RECALL CAMPAIGN ON APPROXIMATELY 200,000 MY04 THROUGH MY06 SUBJECT VEHICLES BUILT THROUGH 11/30/05 TO CORRECT THE FRONT PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT. THE SPECIFIC VEHICLES INCLUDED IN THE RECALL AREMY04- 06/ 5-SERIES WITH STANDARD AND SPORT SEATS, MY04-06/ X3-SERIES AND MY06/ 3-SERIES WITH SPORT SEATS. IN ADDITION, BMW WILL EXTEND THE WARRANTY COVERAGE OF THE PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT TO 10-YEAR/UNLIMITED MILEAGE ON APPROXIMATELY 120,000 REMAINING MY04-06 SUBJECT VEHICLES BUILT THROUGH 11/30/05. THE SPECIFIC VEHICLES INCLUDED IN THE EXTENDED WARRANTY ARE MY 06/ 6 SERIES, MY 06/ 3-SERIES WITH STANDARD SEATS, MY04-05/ Z4, MY04-06/ 7 SERIES, MY 06/ X5, AND MY04-06/ 5-SERIES WITH COMFORT SEATS.THE AVERAGE FREQUENCY OF FAILURES AMONG THE EXTENDED WARRANTY GROUPS WAS LESS THAN 1/7TH OF THE RECALL VEHICLE GROUPS.PLEASE SEE BMW'S 08V-384 RECALL NOTIFICATION FOR FURTHER DETAILSDEPENDING ON SEAT CONFIGURATION AND VEHICLE GEOMETRY, THE OCCUPANT DETECTION MAT CAN FATIGUE DURING USE DEPENDING ON THE MANNER AND FREQUENCY OF THE FRONT PASSENGER'S ENTRY AND EXIT.SPECIFICALLY, OVER TIME, MICRO-CRACKS COULD DEVELOP IN THE SIDE FLANKS OF THE MAT CAUSING A BROKEN CIRCUIT.A BROKENCIRCUIT CAN LEAD TO THE DEACTIVATION OF THE PASSENGER AIR BAG AND THE ILLUMINATION OF BOTH THE AIR BAG WARNING LIGHT AND THE PASSENGER AIR BAG LIGHT.
PE07045 · BMW Airbag Light Illumination
Opened Sep 4, 2007 · Closed Jan 4, 2008
Status: closed (inferred from source dates) · Air Bags; Air Bags:frontal; Air Bags:frontal:sensor/control MODULE-INACTIVE
IN CERTAIN MY 2005 THROUGH MY 2006 BMW VEHICLES, THE OCCUPANT CLASSIFICATION SYSTEM (OCS) FOR THE PASSENGER FRONTAL AIRBAG MAY MALFUNCTION AND RENDER THE PASSENGER AIRBAG INOPERATIVE.IN JUNE 2006, BMW ISSUED A TECHNICAL SERVICE BULLETIN (SI B 72 02 06) REGARDING THE ILLUMINATION OF THE AIRBAG WARNING LIGHT AND THE PASSENGER AIRBAG STATUS LAMP.ILLUMINATION OF THESE LIGHTS WARN THAT AN OPEN ELECTRICAL CIRCUIT MAY BE PRESENT WITHIN THE PASSENGER SEAT MAT SENSOR.WHEN BOTH OF THE LIGHTS ARE ILLUMINATED, THE PASSENGER FRONTAL AIR BAG WILL NOT DEPLOY IN A FRONTAL CRASH.CERTAIN BMW VEHICLES IN ADDITION TO THE SUBJECT VEHICLES CONTAIN THE SAME SEAT MAT SENSOR.THESE ARE THE MY 2004 5-SERIES, 7-SERIES AND X3, THE MY 2004 THROUGH 2006Z-4 SERIES AND MY 2006 3-SERIES, 6-SERIES AND X5 VEHICLES.AN IMPROVED SEAT MAT SENSOR WAS INTRODUCED IN DECEMBER 2005 FOR THE MID-MY 2006 PRODUCTION.IN RESPONSE TO ODI'S INFORMATION REQUEST LETTER, BMW PROVIDED 1,172 OWNER REPORTS AND 28,238 WARRANTY CLAIMS.INITIAL REVIEW OF THE DATA INDICATE THAT 280 NON-DUPLICATING OWNER REPORTS AND 13,051 NON-DUPLICATING WARRANTY CLAIMS MAY BE RELATED THE SUBJECT DEFECT ISSUE ON THE SUBJECT VEHICLESTHIS PRELIMINARY EVALUATION IS BEING UPGRADED TO AN ENGINEERING ANALYSIS (EA08-001).
Additional source detail variants (3)
Air Bags
IN CERTAIN MY 2005 THROUGH MY 2006 BMW VEHICLES, THE OCCUPANT CLASSIFICATION SYSTEM (OCS) FOR THE PASSENGER FRONTAL AIRBAG MAY MALFUNCTION AND RENDER THE PASSENGER AIRBAG INOPERATIVE.IN JUNE 2006, BMW ISSUED A TECHNICAL SERVICE BULLETIN (SI B 72 02 06) REGARDING THE ILLUMINATION OF THE AIRBAG WARNING LIGHT AND THE PASSENGER AIRBAG STATUS LAMP.ILLUMINATION OF THESE LIGHTS WARN THAT AN OPEN ELECTRICAL CIRCUIT MAY BE PRESENT WITHIN THE PASSENGER SEAT MAT SENSOR.WHEN BOTH OF THE LIGHTS ARE ILLUMINATED, THE PASSENGER FRONTAL AIR BAG WILL NOT DEPLOY IN A FRONTAL CRASH.CERTAIN BMW VEHICLES IN ADDITION TO THE SUBJECT VEHICLES CONTAIN THE SAME SEAT MAT SENSOR.THESE ARE THE MY 2004 5-SERIES, 7-SERIES AND X3, THE MY 2004 THROUGH 2006Z-4 SERIES AND MY 2006 3-SERIES, 6-SERIES AND X5 VEHICLES.AN IMPROVED SEAT MAT SENSOR WAS INTRODUCED IN DECEMBER 2005 FOR THE MID-MY 2006 PRODUCTION.IN RESPONSE TO ODI'S INFORMATION REQUEST LETTER, BMW PROVIDED 1,172 OWNER REPORTS AND 28,238 WARRANTY CLAIMS.INITIAL REVIEW OF THE DATA INDICATE THAT 280 NON-DUPLICATING OWNER REPORTS AND 13,051 NON-DUPLICATING WARRANTY CLAIMS MAY BE RELATED THE SUBJECT DEFECT ISSUE ON THE SUBJECT VEHICLESTHIS PRELIMINARY EVALUATION IS BEING UPGRADED TO AN ENGINEERING ANALYSIS (EA08-001).
Air Bags:frontal
IN CERTAIN MY 2005 THROUGH MY 2006 BMW VEHICLES, THE OCCUPANT CLASSIFICATION SYSTEM (OCS) FOR THE PASSENGER FRONTAL AIRBAG MAY MALFUNCTION AND RENDER THE PASSENGER AIRBAG INOPERATIVE.IN JUNE 2006, BMW ISSUED A TECHNICAL SERVICE BULLETIN (SI B 72 02 06) REGARDING THE ILLUMINATION OF THE AIRBAG WARNING LIGHT AND THE PASSENGER AIRBAG STATUS LAMP.ILLUMINATION OF THESE LIGHTS WARN THAT AN OPEN ELECTRICAL CIRCUIT MAY BE PRESENT WITHIN THE PASSENGER SEAT MAT SENSOR.WHEN BOTH OF THE LIGHTS ARE ILLUMINATED, THE PASSENGER FRONTAL AIR BAG WILL NOT DEPLOY IN A FRONTAL CRASH.CERTAIN BMW VEHICLES IN ADDITION TO THE SUBJECT VEHICLES CONTAIN THE SAME SEAT MAT SENSOR.THESE ARE THE MY 2004 5-SERIES, 7-SERIES AND X3, THE MY 2004 THROUGH 2006Z-4 SERIES AND MY 2006 3-SERIES, 6-SERIES AND X5 VEHICLES.AN IMPROVED SEAT MAT SENSOR WAS INTRODUCED IN DECEMBER 2005 FOR THE MID-MY 2006 PRODUCTION.IN RESPONSE TO ODI'S INFORMATION REQUEST LETTER, BMW PROVIDED 1,172 OWNER REPORTS AND 28,238 WARRANTY CLAIMS.INITIAL REVIEW OF THE DATA INDICATE THAT 280 NON-DUPLICATING OWNER REPORTS AND 13,051 NON-DUPLICATING WARRANTY CLAIMS MAY BE RELATED THE SUBJECT DEFECT ISSUE ON THE SUBJECT VEHICLESTHIS PRELIMINARY EVALUATION IS BEING UPGRADED TO AN ENGINEERING ANALYSIS (EA08-001).
Air Bags:frontal:sensor/control MODULE-INACTIVE
IN CERTAIN MY 2005 THROUGH MY 2006 BMW VEHICLES, THE OCCUPANT CLASSIFICATION SYSTEM (OCS) FOR THE PASSENGER FRONTAL AIRBAG MAY MALFUNCTION AND RENDER THE PASSENGER AIRBAG INOPERATIVE.IN JUNE 2006, BMW ISSUED A TECHNICAL SERVICE BULLETIN (SI B 72 02 06) REGARDING THE ILLUMINATION OF THE AIRBAG WARNING LIGHT AND THE PASSENGER AIRBAG STATUS LAMP.ILLUMINATION OF THESE LIGHTS WARN THAT AN OPEN ELECTRICAL CIRCUIT MAY BE PRESENT WITHIN THE PASSENGER SEAT MAT SENSOR.WHEN BOTH OF THE LIGHTS ARE ILLUMINATED, THE PASSENGER FRONTAL AIR BAG WILL NOT DEPLOY IN A FRONTAL CRASH.CERTAIN BMW VEHICLES IN ADDITION TO THE SUBJECT VEHICLES CONTAIN THE SAME SEAT MAT SENSOR.THESE ARE THE MY 2004 5-SERIES, 7-SERIES AND X3, THE MY 2004 THROUGH 2006Z-4 SERIES AND MY 2006 3-SERIES, 6-SERIES AND X5 VEHICLES.AN IMPROVED SEAT MAT SENSOR WAS INTRODUCED IN DECEMBER 2005 FOR THE MID-MY 2006 PRODUCTION.IN RESPONSE TO ODI'S INFORMATION REQUEST LETTER, BMW PROVIDED 1,172 OWNER REPORTS AND 28,238 WARRANTY CLAIMS.INITIAL REVIEW OF THE DATA INDICATE THAT 280 NON-DUPLICATING OWNER REPORTS AND 13,051 NON-DUPLICATING WARRANTY CLAIMS MAY BE RELATED THE SUBJECT DEFECT ISSUE ON THE SUBJECT VEHICLESTHIS PRELIMINARY EVALUATION IS BEING UPGRADED TO AN ENGINEERING ANALYSIS (EA08-001).
Illustration