NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
85 reports45,342 miles · Dec 3, 2010
Electrical SystemStructureVisibility
WHILE DRIVING IN HEAVY RAIN, THE VEHICLE'S ELECTRONIC CONTROL SYSTEM ISSUED A FRENZY OF ALERTS, AND INTERRUPTED FUNCTION OF SEVERAL SUBSYSTEMS INCLUDING THE WINDSHIELD WIPERS. THE SYSTEM ISSUED A MESSAGE "CONTINUED DRIVING NOT POSSIBLE" AND THEN FURTHER ALERTS. THE BMW CENTER EXAMINED THE CAR AND STATED THAT WATER HAD ENTERED TH…
Read full complaint
WHILE DRIVING IN HEAVY RAIN, THE VEHICLE'S ELECTRONIC CONTROL SYSTEM ISSUED A FRENZY OF ALERTS, AND INTERRUPTED FUNCTION OF SEVERAL SUBSYSTEMS INCLUDING THE WINDSHIELD WIPERS. THE SYSTEM ISSUED A MESSAGE "CONTINUED DRIVING NOT POSSIBLE" AND THEN FURTHER ALERTS. THE BMW CENTER EXAMINED THE CAR AND STATED THAT WATER HAD ENTERED THE CAR THROUGH THE SUNROOF DRAINAGE SYSTEM AND FLOODED THE COMPARTMENT HOUSING THE CONTROL SYSTEMS, CAUSING THE SUDDEN MALFUNCTION. DESPITE THE FACT THAT THERE IS NO MAINTENANCE PROTOCOL ESTABLISHED BY BMW FOR THE DRAINAGE SYSTEM, I HAD THE SUNROOF DRAINS CHECKED ON OCTOBER 2009 AND WAS ASSURED BY THE BMW CENTER THAT IT WAS WORKING TO SPECIFICATION AT THAT TIME. NEVERTHELESS, BMW'S CENTER ATTRIBUTED THE FAILURE TO THE DRAINAGE SYSTEM BEING PARTIALLY BLOCKED. (N.B. THE SYSTEM HAD NOT BEEN CHECKED FOR THE FIRST THREE YEARS OF USE, SO WHY WOULD IT FAIL 1 YEAR AND 1 MONTH AFTER INSPECTION?) THE DRAIN SYSTEM IS CONCEALED WITHIN THE ROOF AND IS NOT ACCESSIBLE TO CAR OWNER. THE COMBINATION OF THE DEFECTIVE DRAINAGE SYSTEM AND THE PLACEMENT OF THE ELECTRONIC CONTROL SYSTEMS AT THE POINT OF WATER COLLECTION PRESENTS A SAFETY HAZARD WHEN DRIVING IN INCLEMENT WEATHER. SEARCHING ON THE INTERNET TURNS UP SIMILAR COMPLAINTS ON OTHER BMW MODELS EQUIPPED WITH PANORAMIC SUNROOFS SUCH AS THE X3, X5, AND 535XI AND 325.
NHTSA ODI #10370017
33,800 miles · Nov 5, 2010
Power Train
BMW CAR CAN BE A DEATH TRAP! MY 2006 530I SMG GEARBOX WITH 34K MILES LOST POWER COMPLETELY WITHOUT WARNING ON THE ROAD. LUCKILY, I WAS APPROACHING A STOP LIGHT AND THE CAR BECAME UNDRIVABLE AND NEEDED TO BE TOLLED AWAY. I WAS 5 MINUTES FROM GETTING ON A HIGHWAY AND IF I WAS ON HIGHWAY, IT WOULD BE A DIFFERENT STORY. THE FAILURE…
Read full complaint
BMW CAR CAN BE A DEATH TRAP! MY 2006 530I SMG GEARBOX WITH 34K MILES LOST POWER COMPLETELY WITHOUT WARNING ON THE ROAD. LUCKILY, I WAS APPROACHING A STOP LIGHT AND THE CAR BECAME UNDRIVABLE AND NEEDED TO BE TOLLED AWAY. I WAS 5 MINUTES FROM GETTING ON A HIGHWAY AND IF I WAS ON HIGHWAY, IT WOULD BE A DIFFERENT STORY. THE FAILURE WAS DUE TO A LEAK IN THE HYDRAULIC COMPONENT OF THE TRANSMISSION. THIS IS A SEALED SYSTEM WITH NO USER SERVICEABLE/INSPECTION SUPPORT AND OBVIOUSLY THE CAR HAS NO MONITOR FACILITY FOR THIS COMPONENT SINCE THERE WAS NO WARNING. WITH THE HYDRAULIC FAILURE, THE TRANSMISSION DISENGAGED THE GEAR BACK TO NEUTRAL WHICH RESULTS IN COMPLETE POWER LOST AND I COULD NOT "RE-ENGAGE" IT BACK IN GEAR. THE TRANSMISSION IS UNDER COMPUTER CONTROL (AUTOMATIC). *TR
NHTSA ODI #10364132
39,000 miles · Oct 5, 2010
StructureVisibility
TL*THE CONTACT OWNS A 2006 BMW 530 XIT. THE CONTACT NOTICED THAT WHEN IT RAINED THE WATER PENETRATED THE VEHICLE SPARE TIRE AREA CAUSING DAMAGED TO THE VEHICLE MAIN ELECTRICAL SYSTEM CAUSING THE INSTRUMENTAL PANEL AND ALL ELECTRICAL FUNCTION TO FAIL. THE CONTACT STATED HE EXPERIENCED THE FAILURE SEVERAL TIMES. THE VEHICLE WAS TA…
Read full complaint
TL*THE CONTACT OWNS A 2006 BMW 530 XIT. THE CONTACT NOTICED THAT WHEN IT RAINED THE WATER PENETRATED THE VEHICLE SPARE TIRE AREA CAUSING DAMAGED TO THE VEHICLE MAIN ELECTRICAL SYSTEM CAUSING THE INSTRUMENTAL PANEL AND ALL ELECTRICAL FUNCTION TO FAIL. THE CONTACT STATED HE EXPERIENCED THE FAILURE SEVERAL TIMES. THE VEHICLE WAS TAKEN TO THE DEALER WILL CLEAN THE HOSES CLEAN THE UPHOLSTERY FABRIC, REPLACED THE DAMAGED WIRING SYSTEM. THE FAILURE AND THE CURRENT MILEAGE WERE 39,000. UPDATED 01/20/11 *BF THE CONSUMER STATED THE MOONROOF WAS NOT DESGINED CORRECTLY.
NHTSA ODI #10359336
45,000 miles · Sep 28, 2010
Power Train
2006 BMW 530I - WHEN STOPPING, CAR LURCHES FORWARD FORCEFULLY. ALMOST HIT CAR IN FRONT OF ME - FELT LIKE SOMEONE HIT ME. *TR
NHTSA ODI #10357973
48,800 miles · Jun 30, 2010
Service Brakes, Hydraulic
I NOTICED JUST SHORT OF 49,000 MILES ON MY 2006 BMW 530I THE BRAKES WERE VERY HARD TO PUSH AT SLOWER SPEEDS AND WHEN APPROACHING TRAFFIC STOPS. THROUGH TESTS OF MY OWN AND OF BMW SERVICE, THE CAUSE IS BRAKE BOOSTER FAILURE. I WAS TOLD BY THE DEALER THAT THEY HAVE SEEN A LOT OF THESE CARS WITH THIS PROBLEM AND THE HEAT IN THIS …
Read full complaint
I NOTICED JUST SHORT OF 49,000 MILES ON MY 2006 BMW 530I THE BRAKES WERE VERY HARD TO PUSH AT SLOWER SPEEDS AND WHEN APPROACHING TRAFFIC STOPS. THROUGH TESTS OF MY OWN AND OF BMW SERVICE, THE CAUSE IS BRAKE BOOSTER FAILURE. I WAS TOLD BY THE DEALER THAT THEY HAVE SEEN A LOT OF THESE CARS WITH THIS PROBLEM AND THE HEAT IN THIS AREA WAS PARTIALLY TO BLAME. I'VE OWNED A LOT OF CARS IN THIS AREA AND I'VE NEVER HEARD OF THIS HAPPENING. THE BRAKE BOOSTER NEEDS REPLACED, BUT AS OF THIS DATE HAS NOT BEEN DONE YET. *TR
NHTSA ODI #10340862
38,000 miles · Apr 15, 2010
Air Bags
I OWN A 2006 BMW 530XIT (VIN# [XXX] ) WITH A FAILED PASSENGER AIRBAG SENSOR MAT. BMW SAYS THAT MY VIN# IS NOT PART OF THE RECALL AND SO I MUST PAY OUT OF POCKET FOR THE REPLACEMENT. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
NHTSA ODI #10325888
56,000 miles · Jan 14, 2010
Suspension
TL*THE CONTACT OWNS A 2006 BMW 530XI. WHEN THE VEHICLE DROVE 20 MPH OVER A BUMP IN THE ROAD HE HEARD A LOUD NOISE UNDER THE FRONT OF THE VEHICLE. THE NOISE WAS LOUDER WHENEVER THE WEATHER WAS FRIGID. HE TOOK THE VEHICLE TO THE DEALER TWICE FOR THE FAILURE. THE DIAGNOSIS CONFIRMED THAT THE FAILURE WAS CAUSED BY THE FRONT CONTRO…
Read full complaint
TL*THE CONTACT OWNS A 2006 BMW 530XI. WHEN THE VEHICLE DROVE 20 MPH OVER A BUMP IN THE ROAD HE HEARD A LOUD NOISE UNDER THE FRONT OF THE VEHICLE. THE NOISE WAS LOUDER WHENEVER THE WEATHER WAS FRIGID. HE TOOK THE VEHICLE TO THE DEALER TWICE FOR THE FAILURE. THE DIAGNOSIS CONFIRMED THAT THE FAILURE WAS CAUSED BY THE FRONT CONTROL LOWER ARM BUSHING. THE ESTIMATED COST FOR REPAIR WAS $312.00. THE MANUFACTURER WAS NOTIFIED. THE MANUFACTURER STATED THAT HIS VIN WAS NOT INCLUDED IN RECALL NUMBER 06V187000 SUSPENSION, FRONT CONTROL ARMS;THEREFORE; THEY WOULD NOT ASSIST WITH THE REPAIR. THE VEHICLE WILL BE REPAIRED. THE FAILURE MILEAGE WAS 56,000. THE CURRENT MILEAGE WAS 72,000.
NHTSA ODI #10299766
39,050 miles · Jan 12, 2010
Tires
I PURCHASED A SET OF KUMHO ESCTA SPT, SIZE 245/35-19 TIRES FROM MY RETAILER ON JAN.12 2009. ON MARCH 28, 2009, I HAD 1 TIRE REPLACED DUE TO SEPARATION OF THE SIDEWALL. ON SEPT 19TH, 2009, I EXPERIENCED ANOTHER TIRE FAILURE WHILE AT FREEWAY SPEED. 2 ADDITIONAL TIRES WERE REPLACED AS WELL, AS THEY WERE SHOWING SIGNS OF FAILING. …
Read full complaint
I PURCHASED A SET OF KUMHO ESCTA SPT, SIZE 245/35-19 TIRES FROM MY RETAILER ON JAN.12 2009. ON MARCH 28, 2009, I HAD 1 TIRE REPLACED DUE TO SEPARATION OF THE SIDEWALL. ON SEPT 19TH, 2009, I EXPERIENCED ANOTHER TIRE FAILURE WHILE AT FREEWAY SPEED. 2 ADDITIONAL TIRES WERE REPLACED AS WELL, AS THEY WERE SHOWING SIGNS OF FAILING. JAN 07, 2010 I EXPERIENCED A 5TH TIRE FAILURE. ALL TIRE SHARE THE SAME TYPE OF FAILURE. INNER SIDEWALL SEPARATION OF THE CORDS (VISIBLE). I HAVE ASKED KUMHO TO REIMBURSE MY RETAILER, WHICH THEY HAVE DENIED. *TR
NHTSA ODI #10299509
40,000 miles · Dec 21, 2009
Electrical SystemFireInjury
TL* THE CONTACT OWNS A 2006 BMW M5. WHILE DRIVING BETWEEN 35-40 MPH THE VEHICLE CAUGHT ON FIRE. THE VEHICLE HAD A HISTORY OF ELECTRICAL PROBLEMS SINCE THE DAY OF PURCHASE. DURING THE FIRE, THE VEHICLE LOST THE ABILITY TO BRAKE. HE HAD TO USE THE EMERGENCY BRAKE TO STOP THE VEHICLE. THE FIRE DEPARTMENT EXTINGUISHED THE FLAMES…
Read full complaint
TL* THE CONTACT OWNS A 2006 BMW M5. WHILE DRIVING BETWEEN 35-40 MPH THE VEHICLE CAUGHT ON FIRE. THE VEHICLE HAD A HISTORY OF ELECTRICAL PROBLEMS SINCE THE DAY OF PURCHASE. DURING THE FIRE, THE VEHICLE LOST THE ABILITY TO BRAKE. HE HAD TO USE THE EMERGENCY BRAKE TO STOP THE VEHICLE. THE FIRE DEPARTMENT EXTINGUISHED THE FLAMES. THE VEHICLE WAS COMPLETELY DESTROYED. HE SUFFERED MINOR BURNS ON HIS HANDS. THE FAILURE MILEAGE WAS 40,000.
NHTSA ODI #10296583
46,000 miles · Aug 4, 2009
Wheels
TL*THE CONTACT OWNS A 2006 BMW 525I. WHILE DRIVING 35 MPH, THE CONTACT DROVE OVER A POTHOLE AND THE REAR PASSENGER SIDE RIM SPLIT IN HALF. THE TIRE WAS COMPLETELY SHREDDED INTO TWO PIECES. SHE PULLED OVER AND HAD THE VEHICLE TOWED TO THE DEALER. THE MECHANIC STATED THAT THE DRIVER WAS AT FAULT BECAUSE THEY WERE NOT WILLING T…
Read full complaint
TL*THE CONTACT OWNS A 2006 BMW 525I. WHILE DRIVING 35 MPH, THE CONTACT DROVE OVER A POTHOLE AND THE REAR PASSENGER SIDE RIM SPLIT IN HALF. THE TIRE WAS COMPLETELY SHREDDED INTO TWO PIECES. SHE PULLED OVER AND HAD THE VEHICLE TOWED TO THE DEALER. THE MECHANIC STATED THAT THE DRIVER WAS AT FAULT BECAUSE THEY WERE NOT WILLING TO ASSUME RESPONSIBILITY FOR THE REPAIRS. THROUGH RESEARCH, THE CONTACT DISCOVERED THAT THIS WAS A COMMON FAILURE FOR HER YEAR AND MODEL VEHICLE. THE VEHICLE IS CURRENTLY AT THE DEALER, BUT HAS NOT YET BEEN REPAIRED. THE VIN WAS UNKNOWN. THE CURRENT AND FAILURE MILEAGES WERE 46,000.
NHTSA ODI #10279328
Official recalls
7Mar 2, 2022
BMW of North America, LLC (BMW) is recalling certain 2008-2013 1 Series Coupe (128i); 2007-2013 3 Series Coupe (328i, 328xi, 328i xDrive); 2007-2010 X3 SAV (X3 3.0si, X3 xDrive30i); 2008-2013 1 Series Convertible (128i); 2006-2011 3 Series Sedan (325i, 325xi, 328i, 328xi, 328i xDrive, 330i, 330xi); 2006-2012 3 Series Wagon (328i, 328i xDrive); 2007-2013 3 Series Convertible (328i); 2006-2010 5 Series Sedan (525i, 525xi, 528i, 528xi, 530i, 530xi); 2006-2007 5 Series Wagon (530xi); 2007-2010 X5 SAV (X5 3.0si, X5 xDrive30i); 2006-2008 Z4 Coupe (Z4 3.0si); and 2006-2011 Z4 Roadster (Z4 3.0i, Z4 3.0si, Z4 sDrive30i) vehicles. The heater for the positive crankcase ventilation (PCV) valve may short circuit.
Consequence & remedy
Consequence: An electrical short can cause the PCV valve heater to overheat, increasing the risk of a fire while driving or, soon after driving when parked.
Remedy: This recall supersedes and expands previous NHTSA recalls 17V-683 and 19V-273. Dealers will install an electrical wiring harness with fuse protection for the PCV Valve heater in potentially affected vehicles, free of charge. This recall supersedes and expands previous NHTSA recalls 17V-683 and 19V-273. Vehicles previously repaired under the prior recalls will need to come back for the new recall remedy. The remedy is currently being developed. Interim owner notification letters informing owners of the safety risk were mailed on April 1, 2022. Owner notification letters were mailed on July 22, 2022. Owners may contact BMW customer service at 1-800-525-7417.
Mar 26, 2012
BMW IS RECALLING CERTAIN MODEL YEAR 2004-2010 5-SERIES, MODEL YEAR 2004-2010 6-SERIES, MODEL YEAR 2006-2010 M5, AND MODEL YEAR 2007-2010 M6 VEHICLES. THE INSULATED BULKHEAD CONNECTOR FOR THE POSITIVE BATTERY CABLE MAY HAVE BEEN INCORRECTLY ATTACHED TO THE TRUNK FLOOR PANEL, WHICH CAN LEAD TO A LOOSENING OF THE BOLT CONNECTION. AS IT LOOSENS, AN INCREASE IN ELECTRICAL RESISTANCE AT THIS CABLE CONNECTION IS POSSIBLE AND COULD CAUSE THE CABLE CONNECTION TO OVERHEAT.
Consequence & remedy
Consequence: OVERHEATING COULD LEAD TO A FIRE, EVEN WHILE THE VEHICLE IS NOT IN USE. AS A PRECAUTION, OWNERS ARE ADVISED TO PARK OUTSIDE UNTIL THE REMEDY HAS BEEN MADE.
Remedy: BMW WILL NOTIFY OWNERS, AND DEALERS WILL INSPECT AND SECURE THE BATTERY BOLT CABLE CONNECTION AS NECESSARY, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON APRIL 30, 2012. OWNERS MAY CONTACT BMW CUSTOMER RELATIONS AND SERVICES AT 1-800-525-7417.
Oct 1, 2010
BMW IS RECALLING CERTAIN MODEL YEAR 2004-2010 5-SERIES, 6-SERIES, AND MODEL YEAR 2002-2008 7-SERIES VEHICLES. A CHECK VALVE OF THE BRAKE VACUUM PUMP MAY LEAK A SMALL AMOUNT OF LUBRICATING OIL. OVER TIME THIS COULD RESULT IN CONTAMINATION OF THE BRAKE BOOSTER.
Consequence & remedy
Consequence: POWER ASSIST BRAKING PERFORMANCE COULD BE ADVERSELY AFFECTED. IN EXTREME CASES THERE COULD BE A COMPLETE LOSS OF POWER ASSIST BRAKING. AN UNEXPECTED REDUCTION OR LOSS IN POWER BRAKING ASSIST MAY INCREASE THE RISK OF A CRASH.
Remedy: BMW WILL NOTIFY OWNERS AND DEALERS WILL REPAIR THE VEHICLES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON NOVEMBER 24, 2010. OWNERS MAY CONTACT BMW AT 1-800-525-7417.
Aug 5, 2008
BMW IS RECALLING 200,000 MY 2006 3 SERIES SPORT SEAT, MY 2004-2006 5 SERIES STANDARD AND SPORT SEAT, AND MY 2004-2006 X3 PASSENGER VEHICLES. DEPENDING ON THE MANNER AND FREQUENCY OF THE FRONT PASSENGER'S ENTRY AND EXIT, SMALL CRACKS HAVE DEVELOPED IN THE MAT. IF THIS OCCURS, THE FRONT PASSENGER AIR BAGS, WITH THE EXCEPTION OF THE HEAD PROTECTION SYSTEM, WILL BE DEACTIVATED AND THE AIR BAG WARNING LAMP AS WELL AS THE PASSENGER AIR BAG "ON-OFF" LAMP WILL BE ILLUMINATED.
Consequence & remedy
Consequence: IN THIS SITUATION THE FRONT PASSENGER AIR BAGS WILL NOT DEPLOY EVEN IF A SUFFICIENTLY SEVERE ACCIDENT WOULD OCCUR AND OCCUPANT PROTECTION PROVIDED BY THE SYSTEM WOULD NOT BE POSSIBLE.
Remedy: DEALERS WILL REWORK THE FRONT PASSENGER SEAT SENSOR MAT SO THAT EXTERNAL FORCE APPLICATION TO THE SEAT DOES NOT CAUSE A CRACK TO THE MAT. THE RECALL BEGAN ON NOVEMBER 6, 2008. BMW WILL ALSO EXTEND THE WARRANTY ON THESE VEHICLES TO 10 YEARS FROM FIRST REGISTRATION WITHOUT ANY MILEAGE LIMIT. OWNERS MAY CONTACT BMW AT 1-800-525-7417.
Jul 26, 2006
ON CERTAIN PASSENGER VEHICLES, THE LOWER RUBBER MOUNT OF THE REAR SHOCK ABSORBERS MAY NOT HAVE BEEN MANUFACTURED TO SPECIFICATIONS AND MAY NOT ADHERE CORRECTLY TO ITS HOUSING WITHIN THE SHOCK ABSORBER.
Consequence & remedy
Consequence: THE BUSHING COULD LOOSEN AND OVER TIME COULD SEPARATE FROM ITS HOUSING. THE DRIVER WILL EXPERIENCE IMPAIRED VEHICLE HANDLING AND CONTROL INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE REAR SHOCK ABSORBER FREE OF CHARGE. THE RECALL BEGAN ON SEPTEMBER 13, 2006. OWNERS MAY CONTACT BMW AT 1-800-831-1117.
May 30, 2006
ON CERTAIN PASSENGER VEHICLES, THE NUTS WHICH SECURE THE FRONT AXLE CONTROL ARM AND TENSION STRUT TO THE FRONT WHEEL HUB MAY NOT HAVE BEEN TIGHTENED TO SPECIFICATION. OVER TIME THE NUTS COULD LOOSEN AND THE CONTROL ARM AND TENSION STRUT COULD BE DAMAGED.
Consequence & remedy
Consequence: VEHICLE HANDLING AND CONTROL COULD COMPROMISE INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL RETIGHTEN THE FRONT AXLE CONTROL ARM AND TENSION STRUT NUTS TO THE CORRECT SPECIFICATIONS FREE OF CHARGE. THE RECALL BEGAN ON JUNE 28, 2006. OWNERS MAY CONTACT BMW AT 1-800-831-1117.
Nov 1, 2005
CERTAIN PASSENGER VEHICLES MAY HAVE BEEN BUILT WITH AN INCORRECTLY MANUFACTURED AUTOMATIC TRANSMISSION PARKING PAWL GUIDE PLATE.
Consequence & remedy
Consequence: THIS COULD CAUSE THE PARKING LOCK SYSTEM NOT TO ENGAGE, AFTER THE TRANSMISSION IS PLACED IN THE PARK ("P") POSITION. IF THE VEHICLE WAS PARKED ON AN INCLINE, AND THE PARKING BRAKE WAS NOT ENGAGED, THIS COULD RESULT IN A VEHICLE ROLLAWAY CONDITION.
Remedy: DEALERS WILL REPAIR AND REPLACE THE AUTOMATIC TRANSMISSION GUIDE PLATE FREE OF CHARGE. THE RECALL BEGAN ON NOVEMBER 30, 2005. OWNERS MAY CONTACT BMW AT 1-800-332-4269.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA08001 · BMW Airbag Light Illumination
Opened Jan 4, 2008 · Closed Dec 31, 2008
Status: closed (inferred from source dates) · Air Bags; Air Bags:frontal; Air Bags:frontal:sensor/control MODULE-INACTIVE
BMW IS CONDUCTING A SAFETY RECALL CAMPAIGN ON APPROXIMATELY 200,000 MY04 THROUGH MY06 SUBJECT VEHICLES BUILT THROUGH 11/30/05 TO CORRECT THE FRONT PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT. THE SPECIFIC VEHICLES INCLUDED IN THE RECALL AREMY04- 06/ 5-SERIES WITH STANDARD AND SPORT SEATS, MY04-06/ X3-SERIES AND MY06/ 3-SERIES WITH SPORT SEATS. IN ADDITION, BMW WILL EXTEND THE WARRANTY COVERAGE OF THE PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT TO 10-YEAR/UNLIMITED MILEAGE ON APPROXIMATELY 120,000 REMAINING MY04-06 SUBJECT VEHICLES BUILT THROUGH 11/30/05. THE SPECIFIC VEHICLES INCLUDED IN THE EXTENDED WARRANTY ARE MY 06/ 6 SERIES, MY 06/ 3-SERIES WITH STANDARD SEATS, MY04-05/ Z4, MY04-06/ 7 SERIES, MY 06/ X5, AND MY04-06/ 5-SERIES WITH COMFORT SEATS.THE AVERAGE FREQUENCY OF FAILURES AMONG THE EXTENDED WARRANTY GROUPS WAS LESS THAN 1/7TH OF THE RECALL VEHICLE GROUPS.PLEASE SEE BMW'S 08V-384 RECALL NOTIFICATION FOR FURTHER DETAILSDEPENDING ON SEAT CONFIGURATION AND VEHICLE GEOMETRY, THE OCCUPANT DETECTION MAT CAN FATIGUE DURING USE DEPENDING ON THE MANNER AND FREQUENCY OF THE FRONT PASSENGER'S ENTRY AND EXIT.SPECIFICALLY, OVER TIME, MICRO-CRACKS COULD DEVELOP IN THE SIDE FLANKS OF THE MAT CAUSING A BROKEN CIRCUIT.A BROKENCIRCUIT CAN LEAD TO THE DEACTIVATION OF THE PASSENGER AIR BAG AND THE ILLUMINATION OF BOTH THE AIR BAG WARNING LIGHT AND THE PASSENGER AIR BAG LIGHT.
Additional source detail variants (3)
Air Bags
BMW IS CONDUCTING A SAFETY RECALL CAMPAIGN ON APPROXIMATELY 200,000 MY04 THROUGH MY06 SUBJECT VEHICLES BUILT THROUGH 11/30/05 TO CORRECT THE FRONT PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT. THE SPECIFIC VEHICLES INCLUDED IN THE RECALL AREMY04- 06/ 5-SERIES WITH STANDARD AND SPORT SEATS, MY04-06/ X3-SERIES AND MY06/ 3-SERIES WITH SPORT SEATS. IN ADDITION, BMW WILL EXTEND THE WARRANTY COVERAGE OF THE PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT TO 10-YEAR/UNLIMITED MILEAGE ON APPROXIMATELY 120,000 REMAINING MY04-06 SUBJECT VEHICLES BUILT THROUGH 11/30/05. THE SPECIFIC VEHICLES INCLUDED IN THE EXTENDED WARRANTY ARE MY 06/ 6 SERIES, MY 06/ 3-SERIES WITH STANDARD SEATS, MY04-05/ Z4, MY04-06/ 7 SERIES, MY 06/ X5, AND MY04-06/ 5-SERIES WITH COMFORT SEATS.THE AVERAGE FREQUENCY OF FAILURES AMONG THE EXTENDED WARRANTY GROUPS WAS LESS THAN 1/7TH OF THE RECALL VEHICLE GROUPS.PLEASE SEE BMW'S 08V-384 RECALL NOTIFICATION FOR FURTHER DETAILSDEPENDING ON SEAT CONFIGURATION AND VEHICLE GEOMETRY, THE OCCUPANT DETECTION MAT CAN FATIGUE DURING USE DEPENDING ON THE MANNER AND FREQUENCY OF THE FRONT PASSENGER'S ENTRY AND EXIT.SPECIFICALLY, OVER TIME, MICRO-CRACKS COULD DEVELOP IN THE SIDE FLANKS OF THE MAT CAUSING A BROKEN CIRCUIT.A BROKENCIRCUIT CAN LEAD TO THE DEACTIVATION OF THE PASSENGER AIR BAG AND THE ILLUMINATION OF BOTH THE AIR BAG WARNING LIGHT AND THE PASSENGER AIR BAG LIGHT.
Air Bags:frontal
BMW IS CONDUCTING A SAFETY RECALL CAMPAIGN ON APPROXIMATELY 200,000 MY04 THROUGH MY06 SUBJECT VEHICLES BUILT THROUGH 11/30/05 TO CORRECT THE FRONT PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT. THE SPECIFIC VEHICLES INCLUDED IN THE RECALL AREMY04- 06/ 5-SERIES WITH STANDARD AND SPORT SEATS, MY04-06/ X3-SERIES AND MY06/ 3-SERIES WITH SPORT SEATS. IN ADDITION, BMW WILL EXTEND THE WARRANTY COVERAGE OF THE PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT TO 10-YEAR/UNLIMITED MILEAGE ON APPROXIMATELY 120,000 REMAINING MY04-06 SUBJECT VEHICLES BUILT THROUGH 11/30/05. THE SPECIFIC VEHICLES INCLUDED IN THE EXTENDED WARRANTY ARE MY 06/ 6 SERIES, MY 06/ 3-SERIES WITH STANDARD SEATS, MY04-05/ Z4, MY04-06/ 7 SERIES, MY 06/ X5, AND MY04-06/ 5-SERIES WITH COMFORT SEATS.THE AVERAGE FREQUENCY OF FAILURES AMONG THE EXTENDED WARRANTY GROUPS WAS LESS THAN 1/7TH OF THE RECALL VEHICLE GROUPS.PLEASE SEE BMW'S 08V-384 RECALL NOTIFICATION FOR FURTHER DETAILSDEPENDING ON SEAT CONFIGURATION AND VEHICLE GEOMETRY, THE OCCUPANT DETECTION MAT CAN FATIGUE DURING USE DEPENDING ON THE MANNER AND FREQUENCY OF THE FRONT PASSENGER'S ENTRY AND EXIT.SPECIFICALLY, OVER TIME, MICRO-CRACKS COULD DEVELOP IN THE SIDE FLANKS OF THE MAT CAUSING A BROKEN CIRCUIT.A BROKENCIRCUIT CAN LEAD TO THE DEACTIVATION OF THE PASSENGER AIR BAG AND THE ILLUMINATION OF BOTH THE AIR BAG WARNING LIGHT AND THE PASSENGER AIR BAG LIGHT.
Air Bags:frontal:sensor/control MODULE-INACTIVE
BMW IS CONDUCTING A SAFETY RECALL CAMPAIGN ON APPROXIMATELY 200,000 MY04 THROUGH MY06 SUBJECT VEHICLES BUILT THROUGH 11/30/05 TO CORRECT THE FRONT PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT. THE SPECIFIC VEHICLES INCLUDED IN THE RECALL AREMY04- 06/ 5-SERIES WITH STANDARD AND SPORT SEATS, MY04-06/ X3-SERIES AND MY06/ 3-SERIES WITH SPORT SEATS. IN ADDITION, BMW WILL EXTEND THE WARRANTY COVERAGE OF THE PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT TO 10-YEAR/UNLIMITED MILEAGE ON APPROXIMATELY 120,000 REMAINING MY04-06 SUBJECT VEHICLES BUILT THROUGH 11/30/05. THE SPECIFIC VEHICLES INCLUDED IN THE EXTENDED WARRANTY ARE MY 06/ 6 SERIES, MY 06/ 3-SERIES WITH STANDARD SEATS, MY04-05/ Z4, MY04-06/ 7 SERIES, MY 06/ X5, AND MY04-06/ 5-SERIES WITH COMFORT SEATS.THE AVERAGE FREQUENCY OF FAILURES AMONG THE EXTENDED WARRANTY GROUPS WAS LESS THAN 1/7TH OF THE RECALL VEHICLE GROUPS.PLEASE SEE BMW'S 08V-384 RECALL NOTIFICATION FOR FURTHER DETAILSDEPENDING ON SEAT CONFIGURATION AND VEHICLE GEOMETRY, THE OCCUPANT DETECTION MAT CAN FATIGUE DURING USE DEPENDING ON THE MANNER AND FREQUENCY OF THE FRONT PASSENGER'S ENTRY AND EXIT.SPECIFICALLY, OVER TIME, MICRO-CRACKS COULD DEVELOP IN THE SIDE FLANKS OF THE MAT CAUSING A BROKEN CIRCUIT.A BROKENCIRCUIT CAN LEAD TO THE DEACTIVATION OF THE PASSENGER AIR BAG AND THE ILLUMINATION OF BOTH THE AIR BAG WARNING LIGHT AND THE PASSENGER AIR BAG LIGHT.
PE07045 · BMW Airbag Light Illumination
Opened Sep 4, 2007 · Closed Jan 4, 2008
Status: closed (inferred from source dates) · Air Bags; Air Bags:frontal; Air Bags:frontal:sensor/control MODULE-INACTIVE
IN CERTAIN MY 2005 THROUGH MY 2006 BMW VEHICLES, THE OCCUPANT CLASSIFICATION SYSTEM (OCS) FOR THE PASSENGER FRONTAL AIRBAG MAY MALFUNCTION AND RENDER THE PASSENGER AIRBAG INOPERATIVE.IN JUNE 2006, BMW ISSUED A TECHNICAL SERVICE BULLETIN (SI B 72 02 06) REGARDING THE ILLUMINATION OF THE AIRBAG WARNING LIGHT AND THE PASSENGER AIRBAG STATUS LAMP.ILLUMINATION OF THESE LIGHTS WARN THAT AN OPEN ELECTRICAL CIRCUIT MAY BE PRESENT WITHIN THE PASSENGER SEAT MAT SENSOR.WHEN BOTH OF THE LIGHTS ARE ILLUMINATED, THE PASSENGER FRONTAL AIR BAG WILL NOT DEPLOY IN A FRONTAL CRASH.CERTAIN BMW VEHICLES IN ADDITION TO THE SUBJECT VEHICLES CONTAIN THE SAME SEAT MAT SENSOR.THESE ARE THE MY 2004 5-SERIES, 7-SERIES AND X3, THE MY 2004 THROUGH 2006Z-4 SERIES AND MY 2006 3-SERIES, 6-SERIES AND X5 VEHICLES.AN IMPROVED SEAT MAT SENSOR WAS INTRODUCED IN DECEMBER 2005 FOR THE MID-MY 2006 PRODUCTION.IN RESPONSE TO ODI'S INFORMATION REQUEST LETTER, BMW PROVIDED 1,172 OWNER REPORTS AND 28,238 WARRANTY CLAIMS.INITIAL REVIEW OF THE DATA INDICATE THAT 280 NON-DUPLICATING OWNER REPORTS AND 13,051 NON-DUPLICATING WARRANTY CLAIMS MAY BE RELATED THE SUBJECT DEFECT ISSUE ON THE SUBJECT VEHICLESTHIS PRELIMINARY EVALUATION IS BEING UPGRADED TO AN ENGINEERING ANALYSIS (EA08-001).
Additional source detail variants (3)
Air Bags
IN CERTAIN MY 2005 THROUGH MY 2006 BMW VEHICLES, THE OCCUPANT CLASSIFICATION SYSTEM (OCS) FOR THE PASSENGER FRONTAL AIRBAG MAY MALFUNCTION AND RENDER THE PASSENGER AIRBAG INOPERATIVE.IN JUNE 2006, BMW ISSUED A TECHNICAL SERVICE BULLETIN (SI B 72 02 06) REGARDING THE ILLUMINATION OF THE AIRBAG WARNING LIGHT AND THE PASSENGER AIRBAG STATUS LAMP.ILLUMINATION OF THESE LIGHTS WARN THAT AN OPEN ELECTRICAL CIRCUIT MAY BE PRESENT WITHIN THE PASSENGER SEAT MAT SENSOR.WHEN BOTH OF THE LIGHTS ARE ILLUMINATED, THE PASSENGER FRONTAL AIR BAG WILL NOT DEPLOY IN A FRONTAL CRASH.CERTAIN BMW VEHICLES IN ADDITION TO THE SUBJECT VEHICLES CONTAIN THE SAME SEAT MAT SENSOR.THESE ARE THE MY 2004 5-SERIES, 7-SERIES AND X3, THE MY 2004 THROUGH 2006Z-4 SERIES AND MY 2006 3-SERIES, 6-SERIES AND X5 VEHICLES.AN IMPROVED SEAT MAT SENSOR WAS INTRODUCED IN DECEMBER 2005 FOR THE MID-MY 2006 PRODUCTION.IN RESPONSE TO ODI'S INFORMATION REQUEST LETTER, BMW PROVIDED 1,172 OWNER REPORTS AND 28,238 WARRANTY CLAIMS.INITIAL REVIEW OF THE DATA INDICATE THAT 280 NON-DUPLICATING OWNER REPORTS AND 13,051 NON-DUPLICATING WARRANTY CLAIMS MAY BE RELATED THE SUBJECT DEFECT ISSUE ON THE SUBJECT VEHICLESTHIS PRELIMINARY EVALUATION IS BEING UPGRADED TO AN ENGINEERING ANALYSIS (EA08-001).
Air Bags:frontal
IN CERTAIN MY 2005 THROUGH MY 2006 BMW VEHICLES, THE OCCUPANT CLASSIFICATION SYSTEM (OCS) FOR THE PASSENGER FRONTAL AIRBAG MAY MALFUNCTION AND RENDER THE PASSENGER AIRBAG INOPERATIVE.IN JUNE 2006, BMW ISSUED A TECHNICAL SERVICE BULLETIN (SI B 72 02 06) REGARDING THE ILLUMINATION OF THE AIRBAG WARNING LIGHT AND THE PASSENGER AIRBAG STATUS LAMP.ILLUMINATION OF THESE LIGHTS WARN THAT AN OPEN ELECTRICAL CIRCUIT MAY BE PRESENT WITHIN THE PASSENGER SEAT MAT SENSOR.WHEN BOTH OF THE LIGHTS ARE ILLUMINATED, THE PASSENGER FRONTAL AIR BAG WILL NOT DEPLOY IN A FRONTAL CRASH.CERTAIN BMW VEHICLES IN ADDITION TO THE SUBJECT VEHICLES CONTAIN THE SAME SEAT MAT SENSOR.THESE ARE THE MY 2004 5-SERIES, 7-SERIES AND X3, THE MY 2004 THROUGH 2006Z-4 SERIES AND MY 2006 3-SERIES, 6-SERIES AND X5 VEHICLES.AN IMPROVED SEAT MAT SENSOR WAS INTRODUCED IN DECEMBER 2005 FOR THE MID-MY 2006 PRODUCTION.IN RESPONSE TO ODI'S INFORMATION REQUEST LETTER, BMW PROVIDED 1,172 OWNER REPORTS AND 28,238 WARRANTY CLAIMS.INITIAL REVIEW OF THE DATA INDICATE THAT 280 NON-DUPLICATING OWNER REPORTS AND 13,051 NON-DUPLICATING WARRANTY CLAIMS MAY BE RELATED THE SUBJECT DEFECT ISSUE ON THE SUBJECT VEHICLESTHIS PRELIMINARY EVALUATION IS BEING UPGRADED TO AN ENGINEERING ANALYSIS (EA08-001).
Air Bags:frontal:sensor/control MODULE-INACTIVE
IN CERTAIN MY 2005 THROUGH MY 2006 BMW VEHICLES, THE OCCUPANT CLASSIFICATION SYSTEM (OCS) FOR THE PASSENGER FRONTAL AIRBAG MAY MALFUNCTION AND RENDER THE PASSENGER AIRBAG INOPERATIVE.IN JUNE 2006, BMW ISSUED A TECHNICAL SERVICE BULLETIN (SI B 72 02 06) REGARDING THE ILLUMINATION OF THE AIRBAG WARNING LIGHT AND THE PASSENGER AIRBAG STATUS LAMP.ILLUMINATION OF THESE LIGHTS WARN THAT AN OPEN ELECTRICAL CIRCUIT MAY BE PRESENT WITHIN THE PASSENGER SEAT MAT SENSOR.WHEN BOTH OF THE LIGHTS ARE ILLUMINATED, THE PASSENGER FRONTAL AIR BAG WILL NOT DEPLOY IN A FRONTAL CRASH.CERTAIN BMW VEHICLES IN ADDITION TO THE SUBJECT VEHICLES CONTAIN THE SAME SEAT MAT SENSOR.THESE ARE THE MY 2004 5-SERIES, 7-SERIES AND X3, THE MY 2004 THROUGH 2006Z-4 SERIES AND MY 2006 3-SERIES, 6-SERIES AND X5 VEHICLES.AN IMPROVED SEAT MAT SENSOR WAS INTRODUCED IN DECEMBER 2005 FOR THE MID-MY 2006 PRODUCTION.IN RESPONSE TO ODI'S INFORMATION REQUEST LETTER, BMW PROVIDED 1,172 OWNER REPORTS AND 28,238 WARRANTY CLAIMS.INITIAL REVIEW OF THE DATA INDICATE THAT 280 NON-DUPLICATING OWNER REPORTS AND 13,051 NON-DUPLICATING WARRANTY CLAIMS MAY BE RELATED THE SUBJECT DEFECT ISSUE ON THE SUBJECT VEHICLESTHIS PRELIMINARY EVALUATION IS BEING UPGRADED TO AN ENGINEERING ANALYSIS (EA08-001).
Illustration